WQ0007169_Final Permit_20010820

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
Gergory J. Thorpe, Ph.D., Acting
Michael L. Triplette
Caldwell Ready -Mix Inc.
PO Box 461
Granite Falls, NC 28630
Dear Mr. Michael L. Triplette:
2"_0
An
NCDENR
Director NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
August 20, 2001
Subject: Permit No. WQ0007169
Caldwell Ready -Mix Inc.
Wastewater Recycle System
Caldwell County
In accordance with your application received November 6, 2000, we are forwarding herewith Permit No.
WQ0007169, dated August 20, 2001, to Caldwell Ready -Mix Inc. for the operation of the subject wastewater
recycle system.
This permit shall be effective from the date of issuance until July 31, 2006, shall void Permit No.
WQ0007169 issued December 8, 1993, and shall be subject to the conditions and limitations as specified therein.
Please pay particular attention to the monitoring requirements in this permit. Failure to establish an adequate
system for collecting and maintaining the required operational information will result in future compliance
problems.
Please note that this facility has been constructed prior to permit issuance in accordance with NC General
Statute 143-215.1(d)(1)_ This system may not discharge any wastewater from the recycle system and stormwater
may only be discharged in accordance with a permit issued by the Division of Water Quality. The reviewer has
concerns that this system was not designed to contain all wastewater during intense precipitation events. The
Permittee should ensure that all water can be contained as required by this permit.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the right to
request an adjudicatory hearing upon written request within thirty (30) days following receipt of this permit. This
request must be in the form of a written petition, conforming to Chapter 150B of North Carolina General Statutes,
and filed with the Office of Administrative Hearings, 6714 Mail Service Center, Raleigh, NC 27699-67I4. Unless
such demands are made this permit shall be final and binding.
If you need additional information concerninZmatter, ase contact Sue Homewood at (919) 733-
5083 extension 502.
s
/ Gregory J. Thorpe, Ph.D.
cc: Caldwell County Health Department
Asheville Regional Office, Water Quality Section
Technical Assistance and Certification Unit
Non -Discharge Compliance/Enforcement Unit
1617 Mail Service Center, Raleigh, North Carolina 276 99-1 61 7 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
RECYCLE SYSTEM PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina as amended, and
other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
Caldwell Ready -Mix Inc.
Caldwell County
FOR THE
operation of an 8,880 GPD wastewater recycle system consisting of a truckwash area for external washing, a
interior truck washout area, a model 24-25250 Enviro-Port ready mix reclamation system consisting of a 2,250
gallon slurry tank with a 7.5 hp pump, a 5,500 gallon agitator tank, a 27 inch by 27 inch screw conveyor, an 8 feet
by 14 feet creen deck, and two 12 feet square sand and gravel bins. and an 14,600 gallon concrete wastewater
recycle basin to serve Caldwell Ready -Mix Inc. with no discharge of wastes to the surface waters, pursuant to the
application received November 6, 2000, and in conformity with the project plan, specifications, and other
supporting data subsequently filed and approved by the Department of Environment and Natural Resources and
considered a part of this permit.
This permit shall be effective from the date of issuance until July 31, 2006, shall void Permit No.
WQ0007169 issued December 8, 1993, and shall be subject to the following specified conditions and limitations:
This permit shall become voidable unless the facilities are constructed in accordance with the conditions of
this permit, the approved plans and specifications, and other supporting data.
2. This permit is effective only with respect to the nature and volume of wastes described in the application and
other supporting data_
3. The facilities shall be properly maintained and operated at all times.
4. This permit is not transferable. In the event there is a desire for the facilities to change ownership, or there is
a name change of the Permittee, a formal permit request must be submitted to the Division of Water Quality
(Division) accompanied by an application fee, documentation from the parties involved, and other supporting
materials as may be appropriate. The approval of the request will be considered on its merits and may or may
not be approved.

Upon completion of construction and prior to operation of this permitted facility, a certification must be
received from a professional engineer certifying that the permitted facility has been installed in accordance
with this permit, the approved plans and specifications, and other supporting materials. If this project is to be
completed in phases and partially certified, you shall retain the responsibility to track further construction
approved under the same en -nit, and shall provide a final certificate of completion once the entire project has
been completed. Mail the Certification to the Non -Discharge Permitting Unit, 1617 Mail Service Center,
Raleigh, NC 27699-1617.
6. In the event that the facilities fail to perform satisfactorily, including the creation of nuisance conditions, the
Permittee shall take immediate corrective action, including those actions that may be required by this
Division, such as the construction of additional or replacement treatment or disposal facilities.
7. The Asheville Regional Office, telephone number [phone], shall be notified at least forty-eight (48)
hours in advance of operation of the installed facilities so that an in-place inspection can be made. Such
notification to the regional supervisor shall be made during the normal office hours from 8:00 a.m. until 5:00
p.m. on Monday through Friday, excluding State Holidays.
8. The residuals generated from these treatment facilities must be disposed in accordance with General Statute
143-215.1 and in a manner approved by the Division.
9. The issuance of this permit shall not relieve the Permittee of the responsibility for damages to surface or
groundwaters resulting from the operation of this facility.
10. The facilities shall be effectively maintained and operated as a non -discharge system to prevent the discharge
of any wastewater resulting from the operation of this facility.
11. Diversion or bypassing of untreated wastewater from the treatment facilities is prohibited.
12. Freeboard in the concrete basin shall not be less than one (1) foot at any time.
13. Any monitoring deemed necessary by the Division to insure surface and ground water protection will be
established and an acceptable sampling reporting schedule shall be followed.
14. Adequate inspection, maintenance, and cleaning shall be provided by the Permittee to insure proper operation
of the subject facilities.
15. The Permittee or his designee shall inspect the wastewater recycle facilities to prevent malfunctions and
deterioration, operator errors and discharges which may cause or lead to the release of wastes to the
environment, a threat to human health, or a nuisance. The Permittee shall maintain an inspection log or
summary including at least the date and time of inspection, observations made, and any maintenance, repairs,
or corrective actions taken by the Permittee. This log of inspections shall be maintained by thePermittee for
a period of three years from the date of the inspection and shall be made available to the Division or other
permitting authority, upon request.
16. Any duly authorized officer, employee, or representative of the Division may, upon presentation of
credentials, enter and inspect any property, premises or place on or related to the recycle system at any
reasonable time for the purpose of determining compliance with this permit, may inspect or copy any records
that must be maintained under the terms and conditions of this permit, and may obtain samples of
groundwater, surface water, or leachate.
17. The annual administering and compliance fee must be paid by the Permittee within thirty (30) days after
being billed by the Division. Failure to pay the fee accordingly may cause the Division to initiate action to
revoke this permit as specified by 15A NCAC 2H.0205 (c)(4).

I& Failure to abide by the conditions and limitations contained in this permit may subject thePermittee to an
enforcement action by the Division in accordance with North Carolina General Statute 143-215.6A to 143-
215.6C. 1
s
19. The issuance of this permit does not preclude the Permittee from complying with any and all statutes, rules,
regulations, or ordinances which may be imposed by other government agencies (local, state, and federal)
which have jurisdiction_
20. A set of approved plans and specifications for the subject project must be retained by the Permittee for the
life of this project.
21. Noncompliance Notification:
The Permittee shall report by telephone to the Asheville Regional Office, telephone number [phone],
as soon as possible, but in no case more than 24 hours or on the next working day following the occurrence or
first knowledge of the occurrence of any of the following:
a. Any occurrence at the wastewater treatment facility which results in the treatment of significant amounts
of wastes which are abnormal in quantity or characteristic, such as the dumping of the contents of a basin
or tank, the known passage of a slug of hazardous substance through the facility, or any other unusual
circumstances;
b. Any process unit failure, due to known or unknown reasons, that renders the facility incapable of
adequate wastewater treatment, such as mechanical or electrical failures of pumps, aerators, compressors,
etc.;
c. Any failure of a pumping station, sewer line, or treatment facility resulting in a by-pass directly to
receiving waters without treatment of all or any portion of the influent to such station or facility; or
d. Any time that self-monitoring information indicates that the facility is not in compliance with its permit
limitations.
Persons reporting such occurrences by telephone shall also file a written report in letter form within five (5)
days following first knowledge of the occurrence. This report must outline the actions taken orproposed to
be taken to ensure that the problem does not recur.
22. Upon classification of the facility by the Water Pollution Control Systems Operators Certification
Commission (WPCSOCC), the Permittee shall employ a certified wastewater treatment plant operator to be
in responsible charge (ORC) of the wastewater treatment facilities. The operator must hold a certificate of
the type and grade at least equivalent to or greater than the classification assigned to the wastewater treatment
facilities by the WPCSOCC. The Permittee must also employ a certified back-up operator of the appropriate
type and grade to comply with the conditions of 15A NCAC 8G .0202. The ORC of the facility must visit
each Class I facility at least weekly and each Class II, III, and IV facility at least daily, excluding weekends
and holidays, and must properly manage and document daily operation and maintenance of the facility and
must comply with all other conditions of 15A NCAC 8G.0202.

23. The Permittee, at least six (6) months prior to the expiration of this permit, shall request its extension. Upon
receipt of the request, the Commission will review the adequacy of the facilities described therein, and if
warranted, will extend the permit for such period of time and under such conditions and limitations as it may
deem appropriate.
Permit issued this the 20'" of August, 2001
NOR77ROLINA V -0N ENTAL MANAGEMENT COMMISSION
f`
GregoryJ. Thorpe, Ph.D., Acting Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0007169
4

Permit No. WQ0007169
August 20, 2001
ENGINEER'S CERTIFICATION
Partial Final
1, , as a duly registered Professional Engineer in the State of North
Carolina, having been authorized to observe (periodically, weekly, full tune) the construction of the project,
Project Name
Location and County
for the Permittee hereby state that, to the best of my abilities, due care and diligence was used in the observation of
the construction such that the construction was observed to be built within substantial compliance and intent of this
permit, the approved plans and specifications, and other supporting materials.
Signature
Date
Registration No.