WQ0006083_Final Permit_19921009

State of North Carolina
Department of Environment, Health and Natural Resources
Division of Environmental Management
512 North Salisbury Street • Raleigh, North Carolina 27611
James G. Martin, Governor
William W. Cobey, Jr., Secretary
Mr. John M. Jordan, Jr.,
Jordan Properties
P.O. Box 128
Saxapahaw, NC 27340
Dear Mr. Jordan:
Vice -President
A. Preston Howard, Jr., P.E.
Acting Director
October 9, 1992
Subject: Permit No. WQ0006083
Jordan Properties
Phillips Place Subdivision
Lot No. 1
Wastewater Spray Irrigation
Orange County
In accordance with your application received January 17, 1992, we are forwarding herewith Permit
No. WQ0006083, dated October 9, 1992, to Jordan Properties for the construction and operation of a
single family residence spray irrigation system.
This permit shall be effective from the date of issuance until September 30, 1997, and shall be
subject to the conditions and limitations as specified therein. Please pay particular attention to the
monitoring requirements in this permit. Failure to establish an adequate system for collecting and
maintaining the required operational information will result in future compliance problems.
If any parts, requirements, or limitations contained in this permit are unacceptable to you, you have
the right to request an adjudicatory hearing upon written request within 30 days following receipt of this
permit. This request roust be in the form of a written petition, conforming to Chapter 150B of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, P.O. Drawer 27447,
Raleigh, NC 27611-7447. Unless such demands are made this permit shall be final and binding.
Regional Offices
Asheville Fayetteville Mooresville Raleigh Washington Wilmington Winston-Salem
704/251-6208 9191486-1541 704/663-1699 919/5714700 919/946-6481 919/395-3900 9191896-7007
Pollution Prevention Pays
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

One set of approved plans and specifications is being forwarded to you. If you need additional
information concerning this matter, please contact Mr. John Seymour at 9191733-5083.
cc: Orange County Health Department
Raleigh Regional Office, Water Quality
Raleigh Regional Office, Groundwater
Groundwater Section, Jack Floyd
Training and Certification Unit (Single Family Residence)
Facilities Assessment Unit

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT, HEALTH AND NATURAL RESOURCES
RALEIGH
SPRAY IRRIGATION SYSTEM PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina
as amended, and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
Jordan Properties
Orange County
FOR THE
construction and operation of a 360 GPD single family residence spray irrigation system consisting of a
1000 gallon septic tank, a 360 square foot sand filter, tablet chiorinator,two 1,500 gallon storage/pump
tanks connected in series with a 28.3 GPM pump and 16,800 square feet of woodland irrigation area to
serve Phillips Place Subdivision Lot #1 with no discharge of wastes to the surface waters, pursuant to the
application received January 17, 1992, and in conformity with the project plan, specifications, and other
supporting data subsequently filed and approved by the Department of Environment, Health and Natural
Resources and considered a part of this permit.
This permit shall be effective from the date of issuance until September 30, 1997, and shall be
subject to the following specified conditions and limitations:
1. Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a professional engineer certifying that the permitted
facility has been installed in accordance with this permit, the approved plans and
specifications. Mail the Certification to the Permits and Engineering Unit, P.O. Box
29535, Raleigh, NC 27626-0535.
2. The Raleigh Regional Office, phone no. 919/571-4700 shall be notified at least forty-eight
(48) hours in advance of operation of the installed facilities so that an in-place inspection
can be made. Such notification to the regional supervisor shall be made during the normal
office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State
Holidays.
3. The spray irrigation facilities shall be effectively maintained and operated at all times so that
there is no discharge to the surface waters, nor any contamination of ground waters which
will render them unsatisfactory for normal use. In the event that the facilities fail to
perform satisfactorily, including the creation of nuisance conditions or failure of the
irrigation area to adequately absorb the wastewater, the Penrnittee shall take such immediate
corrective action to correct the problem, including actions as may be required by the
Division of Environmental Management.

4. The issuance of this permit shall not relieve the Permittee of the responsibility for damages
to surface or groundwaters resulting from the operation of this facility.
5. The sand media of the subsurface sand filter must comply with the Division's
specifications. The engineer's certification will serve as proof of compliance with this
condition.
6. A leakage test shall be performed on the septic tank and dosing tank to insure that any
exfiltration occurs at a rate which does not exceed twenty (20) gallons per twenty-four (24)
hour per 1,000 gallons of tank capacity. The engineer's certification will serve as proof of
compliance with this condition.
7. If excavation into bedrock for the septic tank or sand filter installation is required, the pit
shall be lined with a 10 mil synthetic liner.
8. The sludge generated from these treatment facilities must be disposed of in accordance with
General Statute 143-215.1 and in a manner approved by the North Carolina Division of
Environmental Management.
9. Diversion or bypassing of the untreated wastewater from the treatment facilities is
prohibited.
10. The following buffers shall be maintained:
a) 400 feet between wetted area and any residence or places of public assembly under
separate ownership,
b) 150 feet between wetted area and property lines,
C) 100 feet between wetted area and wells,
d) 100 feet between wetted area and drainageways or surface water bodies,
e) 50 feet between wetted area and public right of ways,
f) 100 feet between treatment/storage units and any wells,
g) 50 feet between treatment units and property lines.
1. The facilities shall be properly maintained and operated at all times.
2. A suitable vegetative cover of woodland shall be maintained in the spray irrigation area.
3. Irrigation shall not be performed during inclement weather or when the ground is in a
condition that will cause runoff.
4. Adequate measures shall be taken to prevent wastewater runoff from the spray field.
5. The facilities shall be effectively maintained and operated as a non -discharge system to
prevent the discharge of any wastewater resulting from the operation of this facility.
6. The average annual weekly application rate shall not exceed 0.25 inches at an instantaneous
application rate not to exceed 0.16 inches per hour.
7. No type of wastewater other than that from Phillips Place Subdivision Lot #1 shall be
sprayed onto the irrigation area.
8. No traffic or equipment shall be allowed on the disposal area except while installation
occurs or while normal maintenance is being performed.
2

9. In the event that the sprinkler heads fail to achieve the design diameter of 85 feet due to
obstructions, the obstructions shall be removed or the sprinkler heads shall be raised and
supported to such height that the design diameter is achieved.
10. No traffic or equipment shall be allowed on the disposal area except while installation
occurs or while normal maintenance is being performed.
11. The Permittee is responsible for the operation and maintenance of the entire treatment and
disposal system including, but not limited to, the following items:
a. The septic tank shall be checked annually and pumped out as needed.
b. The tablet chlorinator shall be checked every week. Tablets shall be added so as to
provide proper chlorination.
C. The storage, pump, and alarm systems shall be inspected weekly. The scum layer
shall be removed at the same interval as the septic tank is cleaned out.
d. The spray system shall be inspected weekly to make certain of the sprayers proper
operation, that the vegetative growth allows proper spray pattern, that the soil is
absorbing the disposed treated wastewater with no surface runoff, and that no
objectionable odors are being generated.
1. Any monitoring deemed necessary by the Division of Environmental Management to insure
surface and ground water protection will be established and an acceptable sampling
reporting schedule shall be followed.
2. The Permittee shall maintain records of all maintenance performed on the system and
irrigation area as required in Condition 11.11 for a minimum of five years. This
information shall be provided to the Division of Environmental Management upon request.
3. Noncompliance Notification:
The Permittee shall report by telephone to the Raleigh Regional Office, telephone no. 919/
571-4700 as soon as possible, but in no case more than 24 hours or on the next working
day following the occurrence or fust knowledge of the occurrence of any of the following:
a. Any process unit failure, due to known or unknown reasons, that render the facility
incapable of adequate wastewater treatment such as mechanical or electrical failures of
pumps, spray heads, etc.
b. Any failure of a pumping station or treatment facility resulting in a by-pass directly to
receiving waters without treatment of all or any portion of the influent to such station or
facility.
Persons reporting such occurrences by telephone shall also file a written report in letter
form within 15 days following first knowledge of the occurrence. This report must outline
the actions taken or proposed to be taken to ensure that the problem does not recur.
tj

01 to 43 D111
1. Any groundwater quality monitoring, as deemed necessary by the Division, shall be
provided.
1. Adequate inspection, maintenance, and cleaning shall be provided by the Permittee to
insure proper operation of the subject facilities.
2. The Permittee or his designee shall inspect the wastewater treatment and disposal facilities
to prevent malfunctions and deterioration, operator errors and discharges which may cause
or lead to the release of wastes to the environment, a threat to human health, or a nuisance.
The Permittee shall keep an inspection log or summary including at least the date and time
of inspection, observations made, and any maintenance, repairs, or corrective actions
taken by the Permittee. This log of inspections shall be maintained by the Permittee for a
period of three years from the date of the inspection and shall be made available upon
request to the Division of Environmental Management or other permitting authority.
3. Any duly authorized officer, employee, or representative of the Division of Environmental
Management may, upon presentation of credentials, enter and inspect any property,
premises or place on or related to the disposal site and facility at any reasonable time for the
purpose of determining compliance with this permit; may inspect or copy any records that
must be kept under the terms and conditions of this permit; or may obtain samples of
groundwater, surface water, or leachate.
1. This permit shall become voidable unless the facilities are constructed in accordance with
the conditions of this permit, the approved plans, specifications, and other supporting data.
2. This permit is effective only with respect to the nature and volume of wastes described in
the application and other supporting data.
3. This permit is not transferable. In the event there is a desire for the facilities to change
ownership, or there is a name change of the Permittee, a formal permit request must be
submitted to the Division of Environmental Management accompanied by an application
fee, documentation from the parties involved, and other supporting materials as may be
appropriate. The approval of this request will be considered on its merits and may or may
not be approved.
4. Failure to abide by the conditions and limitations contained in this permit may subject the
Permittee to an enforcement action by the Division of Environmental Management in
accordance with North Carolina General Statute 143-215.6A to 143-215.6C.
5. The issuance of this permit does not preclude the Permittee from complying with any and
all statutes, rules, regulations, or ordinances which may be imposed by other government
agencies (local, state, and federal) which have jurisdiction.
6. The spray irrigation field shall be fenced with at least a two strand wire fence.
4

7. The issuance of this permit does not preclude the Permittee from complying with any and
all statutes, rules, regulations, or ordinances which may be imposed by other government
agencies (local, state, and federal) which have jurisdiction.
S. This permit may be revoked if the Permittee fails to abide by the conditions of the operation
and maintenance agreement previously signed by the Permittee.
9. A set of approved plans and specifications for the subject project must be retained by the
Permittee for the life of the project.
10. The Permittee, at least six (6) months prior to the expiration of this permit, shall request its
extension. Upon receipt of the request, the Commission will review the adequacy of the
facilities described therein, and if warranted, will extend the permit for such period of time
and under such conditions and limitations as it may deem appropriate.
Permit issued this the 9th day of October, 1992
CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
A. Preston ward', Jr.,,.E, Acting Director
Division of En ' en anagement
By Authority of the Enviro mental Management Commission
Permit Number WQ0006083
5

Permit No. WQ0006083
October 9, 1992
A . -M ,..1
I, , as a duly registered Professional Engineer in the State of North
Carolina, having been authorized to observe (periodically, weekly, full time) the construction of the
project,
Project Name
Location
for the
Permittee hereby state that, to the best of my abilities, due care and diligence was used in the observation
of the construction such that the construction was observed to be built within substantial compliance and
intent of the approved plans and specifications.
Signature
Date
rol
Registration No.

l . _. -- t` 5 ~ �• , i byo�/,�� . • � "s� 6esf �--�, r ! / �l l 1 `,�6�// 'd � 41
CammunitYC
t 73
67P wjll
685, rj` T'
°
3990
LL] 2'30'
sin
•� t a / / 1, [ I` ✓ �Biickhorni • r� .��,/�
_7� �J1 �� i?�1 } +moi - � �� � � ,'� .•--�'
Qz-
1700 -
J' 630 ��� it s' , j ��'r , J
} \
� � 54 `� \` b D \ �� f 1, !� ?, `�� �• �1�
I PA
� . • �. �� u a° x ros n
u •4�o nit '}. t �:' �/`� �/' � �\
o r- Lois
F e 11 o
Ji f Ct� l +cs-may
l0 186
820
FETAIM
CIA
36'00. 662 458 1930000 FEET 659 %0 X51 12'30" X62
7 5 9.1
Mapped, edited, and published by the Geological Survey `� 0006'O
i
rntrni by 111;G5 and USC&GS ,Ir

JUN -25--1991 08:47 FROM DEM WATER [QUALITY SECTION TO 89194936548 P.01/01
OPERATION AND MAINTENANCE AGREEMENT FOR THE
DIVISION OF ENVIRONMENTAL MANAGEMENT
jq-Y1. , 1892
DATE
l rGi a,n r Yd Tt7 Ezr es II
��i1/r0.S �IQC�i S��d1Y►StDV�
L 01 #
Single Family Residence
Wastewater Treatment System
Final Disposal by Spray Irrigation
orange . _ County
I agree to operate and maintain the wastewater treatment system as follows:
1. The Permittee is responsible for the operation and maintenance of the entire trearment and
disposal system including, but not limited to, the follgwing items:
a. The septic tank shall be checked every six (6) months and pumped out as required.
b. The tablet chlorinator shall be checked every week until the actual usage rate is
established and thence on a monthly basis. Tablets shall be added so as to provide
proper chlorination.
c. The storage system, pump system, and alarin system shall be inspected monthly.
The scum layer shall be removed at the same interval as the septic
tank is cleaned out.
d_ The spray system shall be inspected monthly to make certain of the sprayers proper
operation, that the veget=wastewater
owtb allows proper spray patterns, that the soil is
absorbing the disposed with no surface runoff, and that no
objectionable odors are being generated.
2. Failure of the Permittee to properly operate this system is subject to a penalty up to $10,000
per day.
3. Failure to meet permit conditions or violation of the State's surface or groundwater
regulations will require cessation of occupancy of the residence.
I understand that failure to comply with these conditions along with the pennit conditions may
result in voiding the permit.
�i
Sign .ure of App ' ant
Notary Seal and Signature
MY Commission Expires �Z- � b
T(ITP! P. 01