WQ0005577_Final Permit_19911119

State of North Carolina
Department of Environment, Health and Natural Resources
Division of Environmental Management
512 North Salisbury Street • Raleigh, North Carolina 27611
James G. Martin, Governor George T. Everett, Ph.D
William W. Cobey, Jr., Secretary Director
November 19, 1991
Mr. Thomas Branson Wood, Owner
Wood Creek Flume
Route #1, Box 265 Willis Cove Road
Canton, North Carolina 28716
Subject: Permit No. WQ0005577
Thomas Branson Wood
Wood Creek Flume
Recycle System
Haywood County
Dear Mr. Wood:
In accordance with your application received September 10, 1991, we are forwarding herewith
Permit No. WQ0005577, dated November 19, 1991, to Mr. Thomas Branson Wood for the operation of
the subject recycle system.
This permit shall be effective from the date of issuance until October 31, 1996, and shall be subject
to the conditions and limitations as specified therein. Please pay particular attention to the monitoring
requirements in this permit. Failure to establish an adequate system for collecting and maintaining the
required operational information will result in future compliance problems.
If any parts, requirements, or limitations contained in this permit are unacceptable to you, you have
the right to request an adjudicatory hearing upon written request within 30 days following receipt of this
permit. This request must be in the form of a written petition, conforming to Chapter 150B of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, P.O. Drawer 27447,
Raleigh, NC 27611-7447. Unless such demands are made this permit shall be final and binding.
Regional Offices
Asheville Fayetteville Mooresville Raleigh Washington Wilmington Winston-Salem
704/251-6208 919/486-1541 704/663-1699 9191733-2314 919/946-6481 919/395-3900 919/896-7007
Pollution Prevention Pays
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

One set of approved plans and specifications is being forwarded to you. If you need additional
information concerning this matter, please contact Ms. e a . Griffin at 919/ 733-5083.
Y,
George T.
cc: Haywood County Health Department
Asheville Regional Office "
Michael K. Ford, P. E.
Groundwater Section

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT, HEALTH AND NATURAL RESOURCES
RALEIGH
RECYCLE SYSTEM PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina
as amended, and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
Mr. Thomas Branson Wood
Haywood County
FOR THE
operation of a 250 GPD gem mine flume operation which consists of a 16 -inch by 5.5 -inch by 6 foot long
flume a 113 hp sump pump and all associated appurtenances to serve the Wood Creek Flume operation
with no discharge of wastes to the surface waters, pursuant to the application received September 10, 1991
and in conformity with the project plan, specifications, and other supporting data subsequently filed and
approved by the Department of Environment, Health and Natural Resources and considered a part of this
permit.
This permit shall be effective from the date of issuance until October 31, 1996, and shall be subject
to the following specified conditions and limitations:
1. This permit shall become voidable unless the facilities are constructed in accordance with
the conditions of this permit, the approved plans, specifications, and other supporting data.
2. This permit is effective only with respect to the nature and volume of wastes described in
the application and other supporting data.
3. The facilities shall be properly maintained and operated at all times.
4. This permit is not transferable. In the event there is a desire for the facilities to change
ownership, or there is a name change of the Permittee, a formal permit request must be
submitted to the Division of Environmental Management accompanied by an application
fee, documentation from the parties involved, and other supporting materials as may be
appropriate. The approval of the request will be considered on its merits and may or may
not be approved.
5. Prior to continued operation of this permitted facility, a certification must be received from
a professional engineer certifying that the permitted facility has been installed in accordance
with this permit, the approved plans and specifications. Mail the Certification to the
Permits and Engineering Unit, P.O. Box 29535, Raleigh, NC 27626-0535.
3

6. In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as
may be required by this Division, such as the construction of additional or replacement
wastewater treatment or disposal facilities.
7. The sludge generated from these treatment facilities must be disposed of in accordance with
General Statute 143-215.1 and in a manner approved by the North Carolina Division of
Environmental Management.
8. The issuance of this permit shall not relieve the Permittee of the responsibility for damages
to surface or groundwaters resulting from the operation of this facility.
9. The facilities shall be effectively maintained and operated as a non -discharge system to
prevent the discharge of any wastewater resulting from the operation of this facility.
10. Diversion or bypassing of untreated wastewater from the treatment facilities is prohibited.
11. Any monitoring deemed necessary by the Division of Environmental Management to insure
surface and ground water protection will be established and an acceptable sampling
reporting schedule shall be followed.
12. Adequate inspection, maintenance, and cleaning shall be provided by the Permittee to
insure proper operation of the subject facilities including daily operation records ( date/time
makeup water added or sediment basin cleaned and by whom).
13. The Permittee or his designee shall inspect the wastewater recycle facilities to prevent
malfunctions and deterioration, operator errors and discharges which may cause or lead to
the release of wastes to the environment, a threat to human health, or a nuisance. The
Permittee shall keep an inspection log or summary including at least the date and time of
inspection, observations made, and any maintenance, repairs, or corrective actions taken
by the Permittee. This log of inspections shall be maintained by the Permittee for a period
of three years from the date of the inspection and shall be made available upon request to
the Division of Environmental Management or other permitting authority.
14. Any duly authorized officer, employee, or representative of the Division of Environmental
Management may, upon presentation of credentials, enter and inspect any property,
premises or place on or related to the recycle system at any reasonable time for the purpose
of determining compliance with this permit; may inspect or copy any records that must be
kept under the terms and conditions of this permit; or may obtain samples of groundwater,
surface water, or leachate.
15. The annual administering and compliance fee must be paid by the Permittee within thirty
(30) days after being billed by the Division. Failure to pay the fee accordingly may cause
the Division to initiate action to revoke this permit as specified by 15 NCAC 2H .0205
(c)(4).
16. Failure to abide by the conditions and limitations contained in this permit may subject the
Permittee to an enforcement action by the Division of Environmental Management in
accordance with North Carolina General Statute 143-215.6A to 143-215.6C.
17. The issuance of this permit does not preclude the Permittee from complying with any and
all statutes, rules, regulations, or ordinances which may be imposed by other government
agencies (Iocal, state, and federal) which have jurisdiction.
18. A set of approved plans and specifications for the subject project must be retained by the
Permittee for the life of this project.
►.I

19. Noncompliance Notification:
The Permittee shall report by telephone to the Asheville Regional Office, telephone no.
(704) 251-620$, as soon as possible, but in no case more than 24 hours or on the next
working day following the occurrence or first knowledge of the occurrence of any of the
following:
a. Any occurrence at the wastewater treatment facility which results in the treatment of
significant amounts of wastes which are abnormal in quantity or characteristic, such
as the dumping of the contents of a basin or tank; the known passage of a slug of
hazardous substance through the facility; or any other unusual circumstances.
b. Any process unit failure, due to known or unknown reasons, that render the facility
incapable of adequate wastewater treatment such as mechanical or electrical failures
of pumps, aerators, compressors, etc.
c. Any failure of a pumping station, sewer line, or treatment facility resulting in a by-
pass directly to receiving waters without treatment of all or any portion of the
influent to such station or facility.
d. Any time that self-monitoring information indicates that the facility is not in
compliance with its permit limitations.
Persons reporting such occurrences by telephone shall also file a written report in letter
form within 15 days following first knowledge of the occurrence. This report must outline
the actions taken or proposed to be taken to ensure that the problem does not recur.
20. A leakage test shall be performed on the septic tank and dosing tank to insure that any
exfiltration occurs at a rate which does not exceed twenty (20) gallons per twenty-four (24)
hour per 1,000 gallons of tank capacity. The engineer's certification will serve as proof of
compliance with this condition.
21. The Permittee, at least six (6) months prior to the expiration of this permit, shall request its
extension. Upon receipt of the request, the Commission will review the adequacy of the
facilities described therein, and if warranted, will extend the permit for such period of time
and under such conditions and limitations as it may deem appropriate.
Permit issue this the 19th day of November, 1991
ZFe-orge
AROLINA EN
1( aEvt,-r1et
ire c
Division of En
By Authority oEnvirc
Permit No. WQ0005577
AL MANAGEMENT COMMISSION
Commission
5

Permit No. WQ0005577
November 19, 1991
Engineer's Certification
1, 'as a duly registered Professional Engineer in the State of North
Carolina, having been authorized to observe (periodically, weekly, full time) the construction of the
project, for the
Location Project Name
Permittee hereby state that, to the best of my abilities, due care and diligence was used in the observation
of the construction such that the construction was observed to be built within substantial compliance and
intent of the approved plans and specifications.
Signature
Date
Z
Registration N

`-J (�� Saa � CtA . J a _ ' _ ��$i �1 ll., `� l I ,_• , • �� 'ri/n. ..L
71.
ftql
ren \V\•��� �% \�
\\� �� w I
M