WQ0004329_Final Permit_19901217

State of North Carolina
Department of Environment, Health and Natural Resources
Division of Environmental Management
512 North Salisbury Street • Raleigh, North Carolina 27611
James G. Martin, Governor
William W. Cobey, Jr., Secretary
George T. Everett, Ph.D.
Director
December 17, 1990
Mr. Jerry A. Walters
Town Administrator
Town of Wake Forest
401 Elm Street
Wake Forest, North Carolina 27587
Subject: Permit No. WQ0004329
Town of Wake Forest
Water Treatment Plant Improvements
Sludge Decant Recycle System
Wake County
Dear Mr. Walters:
In accordance with your application received August 30, 1990, we are forwarding
herewith Permit No. WQ0004329, dated December 17, 1990, to the Town of Wake Forest for the
construction and operation of the subject wastewater recycle system.
This permit shall be effective from the date of issuance until December 31, 1995, and shall
be subject to the conditions and limitations as specified therein. Portions of the system herein
permitted are also permitted under WQ0004091, issued this date, and the Authorization to
Construct issued this date in accordance with NPDES Permit No. NC0007528.
If any parts, requirements, or limitations contained in this permit are unacceptable to you,
you have the right to request an adjudicatory hearing upon written request within 30 days
following receipt of this permit. This request must be in the form of a written petition, conforming
to Chapter 150B of North Carolina General Statutes, and filed with the Office of Administrative
Hearings, P.O. Box 11666, Raleigh, NC 27604. Unless such demands are made this permit shall
be final and binding.
One set of approved plans and specifications is being forwarded to you. If you need
additional information concerning this matter, please contact Mr. Dana Bolden at 9191733-5083.
cc: Wake County Health Department
Raleigh Regional Office
Raymond A. Cordon, Piedmont
Pollution Prevention Pays
P.O. Box 27687, Raleigh, North Carolina 27611-7687 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT, HEALTH AND NATURAL RESOURCES
RALEIGH
+ RECYCLE SYSTEM PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
Town of Wake Forest
Wake County
FOR THE
construction and operation of a 225 GPM filter backwash recycle pump station with duplex
pumps and high water alarms, approximately 125 linear feet of two inch force main (from recycle
pump station to raw water intake line), an approximate 790,300 gallon sludge holding lagoon,
approximately 270 linear feet of 12 inch sludge removal and drain piping, and approximately 165
linear feet of 18 inch sludge removal and drain piping, to serve the Town of Wake Forest Water
Treatment Plant with no discharge of wastes to the surface waters, pursuant to the application
received August 30, 1990 and inc;,.LAAAG, .: the project plan, specifications, and other
supporting data subsequently filed and approved by the Department of Environment, Health and
Natural Resources and considered a part of this permit.
This permit shall be effective from the date of issuance until December 31, 1995, and shall
be subject to the following specified conditions and limitations:
This permit shall become voidable unless the facilities are constructed in accordance with
the conditions of this permit, the approved plans, specifications, and other supporting
data.
2. This permit is effective only with respect to the nature and volume of wastes described in
the application and other supporting data.
3. The facilities shall be properly maintained and operated at all times.
4. This permit is not transferable. In the event there is a desire for the facilities to change
ownership, or there is a name change of the Permittee, a formal permit request must be
submitted to the Division of Environmental Management accompanied by an application
fee, documentation from the parties involved, and other supporting materials as may be
appropriate. The approval of the request will be considered on its merits and may or may
not be approved.
5. Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a professional engineer certifying that the permitted
facility has been installed in accordance with this permit, the approved plans and
specifications. Mail the Certification to the Permits and Engineering Unit, P_O. Box
27687, Raleigh, NC 27611.

6. In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as
may be required by this Division, such as the construction of additional or replacement
wastewater treatment or disposal facilities.
7. The Raleigh Regional Office, phone no. [phone], shall be notified at Ieast
forty-eight (48) hours in advance of operation of the installed facilities so that an in-place
inspection can be made. Such notification to the regional supervisor shall be made during
the normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday,
excluding State Holidays.
8. The sludge generated from these treatment facilities must be disposed of in accordance with
General Statute 143-215.1 and in a manner approved by the North Carolina Division of
Environmental Management.
9. The issuance of this permit shall not relieve the Permittee of the responsibility for damages
to surface or groundwaters resulting from the operation of this facility.
10. The facilities shall be effectively maintained and operated as a non -discharge system to
prevent the discharge of any wastewater resulting from the operation of this facility.
11. Diversion or bypassing of untreated wastewater from the treatment facilities is prohibited.
12. Freeboard in the sludge holding lagoon shall not be less than two feet at any time.
13. Any monitoring deemed necessary by the Division of Environmental Management to insure
surface and ground water protection will be established and an acceptable sampling
reporting schedule shall be followed.
14. Adequate inspection, maintenance, and cleaning shall be provided by the Permittee to
insure proper operation of the subject facilities.
15. The Permittee or his designee shall inspect the wastewater recycle facilities to prevent
malfunctions and deterioration, operator errors and discharges which may cause or lead to
the release of wastes to the environment, a threat to human health, or a nuisance. The
Permittee shall keep an inspection log or summary including at least the date and time of
inspection, observations made, and any maintenance, repairs, or corrective actions taken
by the Permittee. This log of inspections shall be maintained by the Permittee for a period
of three years from the date of the inspection and shall be made available upon request to
the Division of Environmental Management or other permitting authority.
16. Any duly authorized officer, employee, or representative of the Division of Environmental
Management may, upon presentation of credentials, enter and inspect any property,
premises or place on or related to the recycle system at any reasonable time for the
purpose of determining compliance with this permit; may inspect or copy any records that
must be kept under the terms and conditions of this permit; or may obtain samples of
groundwater, surface water, or leachate.
17. The annual administering and compliance fee must be paid by the Permittee within thirty
(30) days after being billed by the Division. Failure to pay the fee accordingly may cause
the Division to initiate action to revoke this permit as specified by 15 NCAC 2H .0205
(c)(4)•
IS. Failure to abide by the conditions and limitations contained in this permit may subject the
Permittee to an enforcement action by the Division of Environmental Management in
accordance with North Carolina General Statute 143-215.6.
19. The issuance of this permit does not preclude the Permittee from complying with any and
all statutes, rules, regulations, or ordinances which may be imposed by other government
agencies (local, state, and federal) which have jurisdiction.

20. A set of approved plans and specifications for the subject project must be retained by the
Permittee for the life of this project.
21. Noncompliance Notification:
The Permittee shall report by telephone to the Raleigh Regional Office, telephone no.
[phone], as soon as possible, but in no case more than 24 hours or on the next
working day following the occurrence or first knowledge of the occurrence of any of the
following:
a. Any occurrence at the wastewater treatment facility which results in the treatment of
significant amounts of wastes which are abnormal in quantity or characteristic, such
as the dumping of the contents of a basin or tank; the known passage of a slug of
hazardous substance through the facility; or any other unusual circumstances.
b. Any process unit failure, due to known or unknown reasons, that render the facility
incapable of adequate wastewater treatment such as mechanical or electrical failures
of pumps, aerators, compressors, etc.
c. Any failure of a pumping station, sewer line, or treatment facility resulting in a
by-pass directly to receiving waters without treatment of all or any portion of the
influent to such station or facility.
d. Any time that self-monitoring information indicates that the facility is not in
compliance with its permit limitations.
Persons reporting such occurrences by telephone shall also file a written report in letter
form within 15 days following first knowledge of the occurrence. This report must outline
the actions taken or proposed to be taken to ensure that the problem does not recur.
22. The lagoon shall have a liner of natural material at least one 111 foot in thickness at all
locations with a hydraulic conductivity of no greater than 1 x 10-6 centimeters per second
when compacted.
23. The Permittee, at least six (6) months prior to the expiration of this permit, shall request its
extension. Upon receipt of the request, the Commission will review the adequacy of the
facilities described therein, and if warranted, will extend the permit for such period of time
and under such conditions and limitations as it may deem appropriate.
Permit issued this the 17th day of December, 1990
a
CAROLINA E AL MANAGEMENT COMMISSION
George T. Evere hector
Division of Env' ental age ent
By Authority of the onmen Management Commission

Permit No. WQ0004329
December 17, 1990
Engineer's Certification
I, , as a duly registered Professional Engineer in the State of North
Carolina, having been authorized to observe (periodically, weekly, full time) the construction of the
project,
Project Name
Location
for the
Permittee hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to be built within substantial
compliance and intent of the approved plans and specifications.
Signature
Date
Registration No.

CO
ToO" -
F
WAKE
Lh, FOREST
u
U.
VICINITY MAP
i
EXISTING
PLANT
101