WQ0003950_Final Permit_19900921

State of North Carolina
Department of Environment, Health and Natural Resources
Division of Environmental Management
512 North Salisbury Street - Raleigh, North Carolina 27611
James G. Martin, Governor
William W. Cobey, Jr., Secretary
George T. Everett,Ph.D.
Director
September 21, 1990
Mr. John T. Curlee, Plant Engineer
Richardson - Vicks, U. S. A.
Post Office Box 18647
Greensboro, NC 27419 - 8647
Subject: Permit No. WQ0003950
Richards - Vicks, U. S. A.
Septic Tank /Nitrification Field
Subsurface Disposal System
Guilford County
Dear Mr. Curlee:
In accordance with your application received August 3, 1990, we are forwarding herewith
Permit No. WQ0003950, dated September 21, 1990, to Richardson - Vicks, U. S. A. for the
continued operation of a 250 GPD industrial subsurface wastewater disposal system. Issuance of
this permit voids Permit No. 12993, issued April 9, 1986.
This permit shall be effective from the date of issuance until August 31, 1995, and shall be
subject to the conditions and limitations as specified therein. Please pay particular attention to the
monitoring requirements in this permit. Failure to establish an adequate system for collecting and
maintaining the required operational information will result in future compliance problems.
If any parts, requirements, or limitations contained in this permit are unacceptable to you,
you have the right to request an adjudicatory hearing upon written request within 30 days
following receipt of this permit. This request must be in the form of a written petition,
conforming to Chapter 150B of North Carolina General Statutes, and filed with the Office of
Administrative Hearings, P.O. Box 11666, Raleigh, NC 27604. Unless such demands are made
this permit shall be final and binding.
if you need additional information concern this matter, please contact Mr. Lindsay L.
Mize at 919/ 733-5083.
Ni
ly,
T. Ever t
cc: Guilford County Health Departmen
Winston-Salem Regional Office
Hall Well & Septic Tanks, Inc.
Groundwater Section
Pollution Prevention Pays
P.O. Box 27687, Raleigh. North Carolina 27611-7687 Telephone [phone]
An Equal Opportunity Afl-umative Action Employer

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT, HEALTH AND NATURAL RESOURCES
RALEIGH
SUBSURFACE DISPOSAL SYSTEM PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
Richardson - Vicks, U. S. A.
Guilford County
FOR THE
continued operation of a 250 GPD subsurface wastewater disposal system consisting of a 1,000
gallon septic tank, a 1,000 gallon pump tank, a 10 GPM pump and high water level alarms, 340
linear feet of 1.25 inch force main, two flow distribution boxes, and 600 linear feet of nitrification
lines spaced at 10 feet on centers to serve Richards - Vicks, U. S. A.'s syrup tank rinse water
with no discharge of wastes to the surface waters, pursuant to the application received August 3,
1440 and in conformity with the project plan, specifications, and other supporting data
subsequently filed and approved by the Department of Environment, Health and Natural
Resources and considered a part of this permit.
This permit shall be effective from the date of issuance until August 31, 1445, and shall be
subject to the following specified conditions and limitations:
1. In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required by this Division, such as construction of additional or
replacement wastewater treatment or disposal facilities.
2. The issuance of this permit shall not relieve the Permittee of the responsibility for
damages to surface or groundwaters resulting from the operation of this facility.
3. This permit shall become voidable if the soils fail to adequately absorb the wastes
and may be rescinded unless the facilities are installed, maintained, and operated in
a manner which will protect the assigned water quality standards of the surface
waters and ground waters.
4. Adequate measures shall be taken to divert stormwater from the disposal area and
prevent wastewater runoff from the subsurface disposal field.
5'. The sludge generated from these treatment facilities must be disposed of in
accordance with General Statute 143-215.1 and in a manner approved by the North
Carolina Division of Environmental Management.

6. A usable reserve area shall be maintained for wastewater disposal. The reserve area
shall have the capability of accommodating the average daily flow of the facility
being served without exceeding the loading rates of the reserve area while meeting
all required buffer requirements.
7. Diversion or bypassing of the untreated wastewater from the treatment facilities is
prohibited.
8. The following buffers shall be maintained (facilities existing prior to issuance of
this renewal may be exempt):
a) 100 feet between disposal area and any public or private water supply including
wells
b) 100 feet between disposal area and "SA and SB" classified surface waters
c) 50 feet between disposal area and any stream, lake, river or natural drainageway
d) 50 feet between disposal area and property lines
e) 10 feet between disposal area and surface water interceptor drains or diversions
(upslope)
f) 25 feet between disposal area and surface water interceptor drains or diversions
(downslope) and groundwater drainage systems.
U1211"I ;: I► :►1 u:1► ►;► 4 U111 'R NORDIN
1. The facilities shall be properly maintained and operated at all times.
2. The Permittee shall employ a certified wastewater treatment plant operator to be in
responsible charge of the wastewater treatment facilities. The operator must hold a
certificate of the grade at least equivalent to the classification assigned to the
wastewater treatment facilities by the Certification Commission. Within thirty days
after the wastewater treatment facilities are 50% complete, the Permittee must
submit a letter to the Certification Commission which designates the operator in
responsible charge.
3. The application rates to the disposal field shall not exceed 0.15 gal.lft2lday.
4. The facilities shall be effectively maintained and operated as a non -discharge system
to prevent the discharge of any wastewater resulting from the operation of this
facility.
5. No traffic or equipment shall be allowed on the disposal area except while
installation occurs or while normal maintenance is being performed.
6. A suitable cover shall be maintained on the field(s) shall be kept mowed. The
clippings shall be removed to prevent the build up of thatch.
ui► �: ► :►,� C 'I: ►[M."1011111 I ta Dial►
1. Any monitoring deemed necessary by the Division of Environmental Management
to insure surface and ground water protection will be established and an acceptable
sampling reporting schedule shall be followed.

2. A record shall be maintained of all sludge removed from this facility. This record
shall include the name of the hauler, permit authorizing the disposal or a letter from
a municipality agreeing to accept the sludge, date the sludge was hauled, and
volume of sludge removed.
3. Noncompliance Notification:
The Permittee shall report by telephone to the Winston-Salem Regional Office,
telephone no. 919/761-2351, as soon as possible, but in no case more than 24
hours or on the next working day following the occurrence or first knowledge of
the occurrence of any of the following:
a. Any occurrence at the wastewater treatment facility which results in the
treatment of significant amounts of wastes which are abnormal in quantity
or characteristic, such as the dumping of the contents of a basin or tank; the
known passage of a slug of hazardous substance through the facility; or any
other unusual circumstances.
b. Any process unit failure, due to known or unknown reasons, that render the
facility incapable of adequate wastewater treatment such as mechanical or
electrical failures of pumps, aerators, compressors, etc.
c. Any failure of a pumping station, sewer line, or treatment facility resulting
in a by-pass directly to receiving waters without treatment of all or any
portion of the influent to such station or facility.
d. Any time that self-monitoring information indicates that the facility has gone
out of compliance with its permit limitations.
Persons reporting such occurrences by telephone shall also file a written report in
letter form within 15 days following first knowledge of the occurrence. This report
must outline the actions taken or proposed to be taken to ensure that the problem
does not reoccur.
1. Any groundwater quality monitoring as deemed necessary by the Division of
Environmental Management shall be provided.
1. Adequate inspection, maintenance, and cleaning shall be provided by the Permittee
to insure proper operation of the subject facilities.
2. The Permittee or his designee shall inspect the wastewater treatment and disposal
facilities to prevent malfunctions and deterioration, operator errors and discharges
which may cause or lead to the release of wastes to the environment, a threat to
human health, or a nuisance. The Permittee shall keep an inspection log or
summary including at least the date and time of inspection, observations made, and
any maintenance, repairs, or corrective actions taken by the Permittee. This log of
inspections shall be maintained by the Permittee for a period of three years from the
date of the inspection and shall be made available upon request to the Division of
Environmental Management or other permitting authority.
3

3. Any duly authorized officer, employee, or representative of the Division of
Environmental Management may, upon presentation of credentials, enter and
inspect any property, premises or place on or related to the disposal site and facility
at any reasonable time for the purpose of determining compliance with this permit;
may inspect or copy any records that must be kept under the terms and conditions
of this permit; or may obtain samples of groundwater, surface water, or leachate.
1. This permit shall become voidable unless the facilities are constructed in accordance
with the conditions of this permit, the approved plans, specifications and other
supporting data.
2. This permit is effective only with respect to the nature and volume of wastes
described in the application and other supporting data.
3. This permit is not transferable. In the event there is desire for the facilities to
change ownership, or there is a name change of the Permittee, a formal permit
request must be submitted to the Division of Environmental Management
accompanied by an application fee, documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request will
be considered on its merits and may or may not be approved.
4. Prior to any transfer of this land, a notice shall be given to the new owner that gives
full details of the materials applied or incorporated at this site.
5. A set of approved plans and specifications for the subject project must be retained
by the applicant for the life of the project.
6. The annual administering and compliance fee must be paid by the Permittee within
thirty (30) days after being billed by the Division. Failure to pay the fee
accordingly may cause the Division to initiate action to revoke this permit as
specified by 15 NCAC 2H .0205 (c)(4).
7. Failure to abide by the conditions and limitations contained in this permit may
subject the Permittee to an enforcement action by the Division of Environmental
Management in accordance with North Carolina General Statute 143-215.6,
8. The issuance of this permit does not preclude the Permittee from complying with
any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.
9. The Permittee, at least six (6) months prior to the expiration of this permit, shall
request its extension. Upon receipt of the request, the Commission will review the
adequacy of the facilities described therein, and if warranted, will extend the permit
for such period of time and under such conditions and limitations as it may deem
appropriate.
10. Issuance of this permit voids Permit No. 12993 issued April 9, 1986.
2

Permit issued this the 21st day of September, 1990
NOR CAROLINA E
George T. Everett,
Division of Environmen
By Authority of the Env
PERMIT NUMBER WQ0003950
AL MANAGEMENT COM VIISSION
Management Commission