WQ0002868_Final Permit_19990301

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B, Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
March 1, 1999
Robert R. Winchester
Martin Marietta Materials, Inc. -Salisbury Shop
P. O. Box 30013
Raleigh. North Carolina 27622-0013
r4iJW
•
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Permit No. WQ0002868
Martin Marietta Materials, Inc. -Salisbury Shop
Ultrasorb System -Pressure and Steam Cleaning
Operation
Wastewater Recycle System
Rowan County
Dear Mr. Winchester:
In accordance with your application received November 9, 1998, we are forwarding herewith Permit No.
WQ0002868, dated March 1, 1999, to Martin Marietta Materials, Inc. for the continued operation of the subject
wastewater recycle system.
This permit shall be effective from the date of issuance until January 31, 2004, shall void Permit No.
WQ0002868 issued August 16, 1994, and shall be subject to the conditions and limitations as specified therein.
Please pay particular attention to the monitoring requirements in this permit. Failure to establish an adequate
system for collecting and maintaining the required operational information will result in future compliance
problems.
If any parts, requirements, or limitations contained in'this permit are unacceptable, you have the right to
request an adjudicatory hearing upon written request within thirty (30) days following receipt of this permit. This
request must be in the form of a written petition, conforming to Chapter 150B of North Carolina General Statutes,
and filed with the Office of Administrative Hearings, P.O. Drawer 27447, Raleigh, NC 27611-7447. Unless such
demands are made this permit shall be final and binding.
PO Sox 29535, Raleigh, Borth Carolina 27626-0535 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

One set of approved plans and specifications is being forwarded to you. If you need additional information
concerning this matter. please contacts t [phone] exten ' n 533.
Sincere
A. Preston Howard. Jr., P.E.
cc: Rowan County Health Department
Mooresville Regional Office, Water Quality Section
Technical Assistance and Certification Unit
Non -Discharge Compliance/Enforcement Unit

iall _wr.:.[oM40111a I.n
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
RECYCLE SYSTEM PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina as amended, and
other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
Martin Marietta Materials, Inc. - Salisbury Shop
Rowan County
FOR THE
continued operation of a 200 GPD wastewater recycle system consisting of a wastewater catch basin, an
"Ultrasorb" brand package wastewater treatment unit, a 6,700 cubic foot stormwater containment pond/holding
lagoon with synthetic liner, and all associated piping, values, controls and appurtenances to serve Martin Marietta
Materials, Inc. -Salisbury Shop's vehicle washing area, with no discharge of wastes to the surface waters, pursuant
to the application received November 9, 1998, and in conformity with the project plan, specifications, and other
supporting data subsequently filed and approved by the Department of Environment and Natural Resources and
considered a part of this permit.
This permit shall be effective from the date of issuance until January 31, 2004, shall void Permit No.
WQ0002868 issued August 16, 1994, and shall be subject to the following specified conditions and limitations:
This permit shall become voidable unless the facilities are constructed in accordance with the conditions of
this permit, the approved plans and specifications, and other supporting data.
2. This permit is effective only with respect to the nature and volume of wastes described in the application and
other supporting data.
The facilities shall be properly maintained and operated at all times.
4. This permit is not transferable. In the event there is a desire for the facilities to change ownership, or there is
a name change of the Permittee, a formal permit request must be submitted to the Division of Water Quality
(Division) accompanied by an application fee, documentation from the parties involved, and other supporting
materials as may be appropriate. The approval of the request will be considered on its merits and may or may
not be approved.
Upon completion of construction and prior to operation of this permitted facility, a certification must be
received from a professional engineer certifying that the permitted facility has been installed in accordance
with this permit, the approved plans and specifications, and other supporting materials. If this project is to be
completed in phases and partialiy certified, you shall retain the responsibility to track further construction
approved under the same permit, and shall provide a final certificate of completion once the entire project has

been completed. Mail the Certification to the Non -Discharge Permitting Unit, P.O. Box 29535,Raleigh, NC
27626-0535.
6. In the event that the facilities fail to perform satisfactorily, including the creation of nuisance conditions, the
Permittee shall take immediate corrective action, including those actions that may be required by this
Division, such as the construction of additional or replacement treatment or disposal facilities.
7. The Mooresville Regional Office, telephone number [phone], shall be notified at least forty-eight (48)
hours in advance of operation of the installed facilities so that an in -place inspection can be made. Such
notification to the regional supervisor shall be made during the normal office hours from 8:00 a.m. until 5:00
p.m. on Monday through Friday, excluding State Holidays.
The residuals generated from these treatment facilities must be disposed in accordance with General Statute
143-215.1 and in a manner approved by the Division.
9, The issuance of this permit shall not relieve the Permittee of the responsibility for damages to surface or
groundwaters resulting from the operation of this facility.
10. The facilities shall be effectively maintained and operated as a non -discharge system to prevent the discharge
of any wastewater resulting from the operation of this facility.
I l . Diversion or bypassing of untreated wastewater from the treatment facilities is prohibited.
12. Freeboard in the containment pond/holding lagoon shall not be less than two feet at any time.
13. Any monitoring deemed necessary by the Division to insure surface and ground water protection will be
established and an acceptable sampling reporting schedule shall be followed.
14, Adequate inspection, maintenance, and cleaning shall be provided by the Permittee to insure proper operation
of the subject facilities.
15. The Permittee or his designee shall inspect the wastewater recycle facilities to prevent malfunctions and
deterioration, operator errors and discharges which may cause or lead to the release of wastes to the
environment, a threat to human health, or a nuisance. The Permittee shall maintain an inspection log or
summary including at least the date and time of inspection, observations made, and any maintenance, repairs,
or corrective actions taken by the Permittee. This log of inspections shall be maintained by the Permittee for
a period of three years from the date of the inspection and shall be made available to the Division or other
permitting authority, upon request.
16. Any duly authorized officer, employee, or representative of the Division may, upon presentation of
credentials, enter and inspect any property, premises or place on or related to the recycle system at any
reasonable time for the purpose of determining compliance with this permit, may inspect or copy any records
that must be maintained under the terms and conditions of this permit, and may obtain samples of
groundwater, surface water, or leachate.
17. The annual administering and compliance fee must be paid by the Permittee within thirty (30) days after
being billed by the Division. Failure to pay the fee accordingly may cause the Division to initiate action to
revoke this permit as specified by 15A NCAC 2H .0205 (c)(4).
18. Failure to abide by the conditions and limitations contained in this permit may subject the Permittee to an
enforcement action by the Division in accordance with North Carolina General Statute 143-215.6A to 143--
215.6C.
2

19. The issuance of this permit does not preclude the Permittee from complying with any and all statutes, rules,
regulations. or ordinances which may be imposed by other government agencies (local, state, and federal)
which ha,e jurisdiction.
20. A set of approved plans and specifications for the subject project must be retained by the Perm ittee for the
life of this project.
21. Groundwater Compliance:
Any groundwater quality monitoring, as deemed necessary by the Division, shall be provided.
The COMPLIANCE BOUNDARY for the disposal system is specified by regulations in 15A NCAC 2L,
Groundwater classifications and Standards. The Compliance Boundary for the disposal system individually
permitted after December 31, 1983 is established at either (1) 250 feet from the waste disposal area, or (2)
within 50 feet of the property boundary, whichever is closest to the waste disposal area. An exceedance of
the Groundwater Quality Standards at or beyond the Compliance Boundary is subject to immediate
redemption action in addition to the penalty provisions applicable under General Statute 143-215.6A(a)(1).
In accordance with 15ANCAC 2L, a REVIEW BOUNDARY is established around the disposal system
midway between the Compliance Boundary and the perimeter of the waste disposal area. Any exceedance of
standards at the Review Boundary shall require remediation action on the part of the permittee.
22. Noncompliance Notification:
The Permittee shall report by telephone to the Mooreville Regional Office, telephone number (704) 663-
1699. as soon as possible, but in no case more than 24 hours or on the next working day following the
occurrence or first knowledge of the occun-ence of any of the following:
a. Any occurrence at the wastewater treatment facility which results in the treatmentof significant amounts
of wastes which are abnormal in quantity or characteristic, such as the dumping of the contents of a basin
or tank, the known passage of a slug of hazardous substance through the facility, or any other unusual
circumstances;
b. Any process unit failure, due to known or unknown reasons, that renders the facility incapable of
adequate wastewater treatment, such as mechanical or electrical failures of pumps, aerators, compressors,
etc.;
c. Any failure of a pumping station, sewer line, or treatment facility resulting in a by-pass directly to
receiving waters without treatment of all or any portion of the influent to such station or facility; or
d. Any time that self -monitoring information indicates that the facility is not in compliance with its permit
limitations.
Persons reporting such occurrences by telephone shall also file a written report in letter form within five (5)
days following first knowledge of the occurrence. This report must outline the actions taken orproposed to
be taken to ensure that the problem does not recur.
23. A leakage test shall be performed on the septic tank and dosing tank to insure that any exfltration occurs at a
rate which does not exceed twenty (20) gallons per twenty-four (24) hours per 1,000 gallons of tank capacity.
The engineer's certification will serve as proof of compliance with this condition.
24. The lagoon shall have a liner of natural material at least one (1) foot in thickness, compacted to 95% proctor
standard dry density and installed and compacted in layers no thicker than six inches, with a hydraulic
conductivity no greater than 1 x 10-6 centimeters per second. Following installation and inspection of the
lagoon liner. and prior to waste disposal operations, verification of the liner's compliance with hydraulic

conductivity and thickness specifications must be provided by the project engineer to the Groundwater
Section. N.C. Diti ision of Water Quality, P.O. Box 29578, Raleigh, N.C. 27626-0578.
25. The interior surfaces of the lagoon shall be completely lined with a 30-mil thick liner. Following the
installation and inspection of the lagoon liner, and prior to waste disposal operations, certification of the
liners compliance with the approved construction specifications and the liner's integrity must be provided by
the project engineer to the Groundwater Section, N.C. Division of Water Quality, P.O. Box 29578, Raleigh,
N.C. 27626-0578.
26, Upon classification of the facility by the Water Pollution Control Systems Operators Certification
Commission (WPCSOCC), the Permittee shall employ a certified wastewater treatment plant operator to be
in responsible charge (ORC) of the wastewater treatment facilities. The operator must hold a certificate of
the type and grade at least equivalent to or greater than the classification assigned to the wastewater treatment
facilities by the WPCSOCC. The Permittee must also employ a certified back-up operator of the appropriate
type and grade to comply with the conditions of 15A NCAC 8A .0202. The ORC of the facility must visit
each Class I facility at least weekly and each Class II, ill, and IV facility at least daily, excluding weekends
and holidays. and must properly manage and document daily operation and maintenance of the facility and
must comply with all other conditions of 15A NCAC 8A .0202.
27. The Permittee, at least six (6) months prior to the expiration of this permit, shall request its extension. Upon
receipt of the request, the Commission will review the adequacy of the facilities described therein, and if
warranted, will extend the permit for such period of time and under such conditions and limitations as it may
deem appropriate.
Permit issued this the fir,-Yday of March, 1999
NORTH CAWkINA ENVIROC11}+IEVAL MANAGEMENT COMMISSION
-WPreston Hoard, Jr., P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0002868
4

Permit No. WQ0002868
March 1, 1999
ENGINEER'S CERTIFICATION
Partial Final
1, , as a duly registered Professional Engineer in the State of North
Carolina, having been authorized to observe (periodically, weekly, full time) the construction of the project,
Project Name
Location and County
for the Permittee hereby state that, to the best of my abilities, due care and diligence was used in the observation of
the construction such that the construction was observed to be built within substantial compliance and intent of this
permit, the approved plans and specifications, and other supporting materials.
Signature
Date
Registration No.

State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Environmental Management
blames B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
August 3, 1994
Donald A. Lineberry, Vice President
Nello L. Teer Company
Post Office Box 13983
Research Triangle Park, North Carolina 27709
Dear Mr. Lineberry:
IT
4••
NUWA
2J
�A1
�T
L7 E F=1
Subject: Permit No. WQ0002870
Permit No. WQ0006709
Nello L. Teer Company
North Durham Quarry
Rescission of Permit
Recycle Facility
Durham County
It has been brought to the Division's attention that Permit No. WQ0002870, issued March 9,
1990, and Permit No. WQ0006709, issued September 25, 1992, are no longer necessary because General
Permit No. NCG020235, issued April 29, 1994, has been approved to cover the subject recycle facilities.
herefore, Permit No. WQ0002870 and Permit No. WQ0006709 are hereby voided effective immediately.
If you have any questions or comments on this matter, please contact Mr. Michael D. Allen at
[phone]-
Sincerely,
I �Qj�
A. Prest Howard, Jr., P.E.
cc: Raleigh Regional Office, Water Quality
Permit File WQ0002870
Permit File WQ0006709
General Permit File NCGO20235
Kent Wiggins, Facilities Assessment Unit
Fran McPherson, Budget Office
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper