WQ0002564_Final Permit_20070304

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E., Director
Division of Water Quality
April 4, 2007
MR. NORMAN R. HIERS, PLANT MANAGER
GEORGIA-PACIFIC WOOD PRODUCTS LLC
WHITEVILLE PLYWOOD PLANT
1980 GEORGIA PACIFIC ROAD
WHITEVILLE, NORTH CAROLINA 28472
Subject: Permit No. WQ0002564
Name Change from Georgia-Pacific
Corporation to Georgia-Pacific
Wood Products LLC
Whiteville Plywood Plant
Wastewater Recycle System
Columbus County
Dear Mr. Hiers:
In accordance with your request to change the name on the subject permit from Georgia-Pacific
Corporation to Georgia-Pacific Wood Products LLC received on December 5, 2006, we are forwarding
herewith a renewed Permit No. WQ0002564, dated April 4, 2007, to Georgia-Pacific Wood Products
LLC for the continued operation of the subject wastewater recycle system.
This permit shall be efective from the date of issuance unfit September 30, 2009; shall void
Permit No. WQ0002564, issued on October 1, 2004; and shall be subject to the conditions and limitations
as specified therein. Make note of this permit's expiration date and the fact that a permit renewal
application is due to the Division of Water Quality (Division) no later than six months prior to that date
(i.e., see Condition 21), as the Division does not send reminders to apply for permit renewal.
This permit approves the continued operation of the wastewater recycle program for another five-
year cycle. As always, remember to take the time to review this permit thoroughly, as some of the
conditions contained therein may have been added, changed, or deleted since the last issuance. Pay
particular attention to the monitoring requirements in this permit. Failure to establish an adequate system
for collecting and maintaining the required operational information will result in future compliance
problems.
If any parts, requirements, and/or limitations contained in this permit are unacceptable, you have
the right to request an adjudicatory hearing upon written request within 30 days following receipt of this
permit. This request shall be in the from of a written petition, conforming to Chapter 150B of the North
Carolina General Statutes and filed with the Office of Administrative Hearings at 6714 Mail Service
Center, Raleigh, North Carolina 27699-6714. Unless such demands are made, this permit shall be final
and binding.
Nna
pr Carolina
Ntumily
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636 Phone [phone] Customer Service
Internet: http:1Wo.enr.state.ne.us 2729 Capital Boulevard Raleigh, NC 27604 Fax [phone]
Fax (919)7I5-6048
An Equal QpportunitylAffirmative Acton Employer— 50% Recycled110% Post Consumer Paper

Mr. Norman R. Hiers
Page 2
April 4, 2007
If you need any additional information concerning this matter, please contact Mr. David Goodrich by
telephone at [phone], or via e-mail at [e-mail].
Sincerely,
or Alan W. Klimek, P.E.
cc: Columbus County Health Department
Wilmington Regional Office -Aquifer Protection Section
Technical Assistance and Certification Unit
Aquifer Protection Section Central Files

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
RECYCLE SYSTEM PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina as
amended, and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
Georgia-Pacific Wood Products LLC
Columbus County
FOR THE
continued operation of a 3,000 GPD mobile equipment wash wastewater recycle system consisting of a
curbed 40 feet by 30 feet concrete wash station collection slab with slab drain, wastewater grit trench,
primary sump, oil separator, secondary sump with a 100 GPM pump, and approximately 850 linear feet of
3-inch force main which goes to the flyash scrubber system; a 100,000 GPD Log Vat wastewater treatment
and recycle system consisting of one debris screen, a 270,000 gallon anaerobic treatment/storage basin, a
clarifier and sodium hydroxide feed; a 3,000 GPD veneer dryer system consisting of a bar screen, a 20,000
gallon storage tank; also a 1.44 MGD Flyash Scrubber water recycle system consisting of two 118 feet by
25 feet by 10.5 feet (L x W x D) concrete sedimentation basins, discharge of scrubber water into the
settling basins, and a clear water sump with dual 1,000 GPM pumps, and all associated valves, piping, and
appurtenances to serve the Whiteville Plywood Plant, with no discharge of wastes to the surface waters,
with no discharge of wastes to surface waters, pursuant to the request for change of ownership name
received on December 5, 2006 and in conformity with the project plan, specifications, and other supporting
data subsequently filed and approved by the Department of Environment and Natural Resources and
considered a part of this permit.
This permit shall be effective from the date of issuance until September 30, 2009; shall void
Permit No. WQ0002564, issued on October 1, 2004; and shall be subject to the following specified
conditions and limitations:
1. This permit shall become voidable unless the facilities are constructed in accordance with the
conditions of this permit, the approved plans and specifications, and other supporting data.
2. This permit is effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. The facilities shall be properly maintained and operated at all times.

4. The following buffers shall be maintained:
a) 100 feet between treatment/storage units and any wells,
b) 50 feet between treatment/storage units and surface waters, and
c) 50 feet between treatment/storage units and property lines.
Some of the buffers specified above may not have been included in previous permits for this waste
treatment and disposal system. These buffers are not intended to prohibit or prevent modifications,
which are required by the Division, to improve performance of the existing treatment facility. These
buffers do, however, apply to modifications of the treatment and disposal facilities that are for the
purpose of increasing the flow that is tributary to the facility. These buffers do apply to any
expansion or modification of the irrigation areas and apply in instances in which the sale of property
would cause any of the buffers now complied with, for the treatment and disposal facilities, to be
violated. The applicant is advised that any modifications to the existing facilities will require a
permit modification.
This permit is not transferable. In the event there is a desire for the facilities to change ownership, or
there is a name change of the Permittee, a formal permit request must be submitted to the Division of
Water Quality (Division) accompanied by an application fee, documentation from the parties
involved, and other supporting materials as may be appropriate. The approval of the request will be
considered on its merits and may or may not be approved.
b. In the event that the facilities fail to perform satisfactorily, including the creation of nuisance
conditions, the Permittee shall take immediate corrective action, including those actions that may be
required by this Division, such as the construction of additional or replacement treatment or disposal
facilities.
7. The residuals generated from these treatment facilities must be disposed in accordance with General
Statute 143-215.1 and in a manner approved by the Division.
The issuance of this permit shall not relieve the Permittee of the responsibility for damages to
surface or groundwaters resulting from the operation of this facility.
The facilities shall be effectively maintained and operated as a non -discharge system to prevent the
discharge of any wastewater resulting from the operation of this facility.
10. Diversion or bypassing of untreated wastewater from the treatment facilities is prohibited.
11. Freeboard in the log vat shall not be less than two feet at any time.
12. Any monitoring deemed necessary by the Division to insure surface and ground water protection
will be established and an acceptable sampling reporting schedule shall be followed.
13. Adequate inspection, maintenance, and cleaning shall be provided by the Permittee to insure proper
operation of the subject facilities.
2

14. The Permittee or his designee shall inspect the wastewater recycle facilities to prevent malfunctions
and deterioration, operator errors and discharges which may cause or lead to the release of wastes to
the environment, a threat to human health, or a nuisance. The Permittee shall maintain an inspection
log or summary including at least the date and time of inspection, observations made, and any
maintenance, repairs, or corrective actions taken by the Permittee. This log of inspections shall be
maintained by the Permittee for a period of three years from the date of the inspection and shall be
made available to the Division or other permitting authority, upon request.
15. Any duly authorized officer, employee, or representative of the Division may, upon presentation of
credentials, enter and inspect any property, premises or place on or related to the recycle system at
any reasonable time for the purpose of determining compliance with this permit, may inspect or
copy any records that must be maintained under the terms and conditions of this permit, and may
obtain samples of groundwater, surface water, or leachate.
16. The annual administering and compliance fee must be paid by the Permittee within thirty (30) days
after being billed by the Division. Failure to pay the fee accordingly may cause the Division to
initiate action to revoke this permit as specified by 15A NCAC 2H .0205 (c)(4).
IT Failure to abide by the conditions and limitations contained in this permit may subject the Permittee
to an enforcement action by the Division in accordance with North Carolina General Statute 143-
215.6A to 143-215.6C.
18. The issuance of this permit does not exempt the Permittee from complying with any and all statutes,
rules, regulations, or ordinances which may be imposed by other government agencies (local, state,
and federal) which have jurisdiction, including but not limited to applicable river buffer rules in 15A
NCAC 2B.0200, erosion and sedimentation control requirements in 15A NCAC Chapter 4 and under
the Division's General Permit NCG010000, and any requirements pertaining to wetlands under 15A
NCAC 2B .0200 and 2H .0500.20.
19. Noncompliance Notification.:
The Permittee shall report by telephone to the Wilmington Regional Office, telephone number (910)
796-7215, as soon as possible, but in no case more than 24 hours or on the next working day
following the occurrence or first knowledge of the occurrence of any of the following:
a. Any occurrence at the wastewater treatment facility which results in the treatment of significant
amounts of wastes which are abnormal in quantity or characteristic, such as the dumping of the
contents of a basin or tank, the known passage of a slug of hazardous substance through the
facility, or any other unusual circumstances;
b. Any process unit failure, due to known or unknown reasons, that renders the facility incapable of
adequate wastewater treatment, such as mechanical or electrical failures of pumps, aerators,
compressors, etc.;
Any failure of a pumping station, sewer line, or treatment facility resulting in a by-pass directly
to receiving waters without treatment of all or any portion of the influent to such station or
facility; or
d. Any time that self -monitoring information indicates that the facility is not in compliance with its
permit limitations.
C]

Occurrences outside normal business hours may also be reported to the Division's Emergency
Management personnel at telephone number [phone], or [phone]. Persons reporting
such occurrences by telephone shall also file a written report in letter form within five (5) days
following first knowledge of the occurrence. This report must outline the actions taken or proposed
to be taken to ensure that the problem does not recur.
20. Upon classification of the wastewater treatment and spray irrigation facilities by the Water Pollution
Control System Operators Certification Commission (WPCSOCC), the Permittee shall designate and
employ a certified operator to be in responsible charge (ORC) and one or more certified operator(s)
to be back-up ORC(s) of the facilities in accordance with 15A NCAC 8G .0201. The ORC shall
visit the facilities in accordance with 15A NCAC 8G .0204 or as specified in this permit and shall
comply with all other conditions specified in these rules.
21. The Permittee, at least six (6) months prior to the expiration of this permit, shall request its
extension. Upon receipt of the request, the Commission will review the adequacy of the facilities
described therein, and if warranted, will extend the permit for such period of time and under such
conditions and limitations as it may deem appropriate.
22. Wastewater may be hauled from the evaporative pit at the contiguous Whiteville CNS facility
(WQ0008087) and introduced into the log vat as long as the freeboard specified in Condition 11 is
maintained.
Permit issued this the 4th day of April 2007
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0002564
n
W

(• ./ • f�, � % '•��` nit , k4 .' - - - f"
ds
Lo
Cho 1 ^�
IQ
in 7.--?
j' ..._._ \. / - �'' -gym �h ' • ` ._
GZ`*
Strip P. _ o�
100 i - r 76' �- �—•�
sping Hill
� • i • );,`�, /•' �' / �! _ 'Southeastern-� , s r 1.
roErnunhv Callege—
tPORT
�oeo�
rivo inri - F r///� 'L .��l l 1 l J toy•/, �S Y .- .._i ,' v.,._..
_�CCCGG Peat- - _ J �j
�
iq
�y
°• ; `�� J �� �i r'' • :7�to Po ds �oryof 1 v'+`` '•-- ` .••�
7 swag /��� rl'�•`. �%% ,: I f1f % '.� � j P't� j... �,
=93, �1 Ch lu
1
_l "Jfxroe
Mlle Vi w ;r . -�_ _ sti $ _
� n
.E
SITE LOCATION MAP
VVvv �' GEORGIA-PACIFIC WOOD PRODUCTS LLC
{ SCALE IN FEET WASTEWATER RECYCLE SYSTEM
J 0 2,000 4,000 _'-- WHITEVILLE PLYWOOD PLANT
' -f _ = COLUMBUS COUNTY
z - WQ0002564
f\