HomeMy WebLinkAboutNC0060534_Authorization to Construct_20180507 ROY COOPER
uY Governor
MICHAEL S. REGAN
Secretary
LINDA CULPEPPER
Water Resources Interim Director
ENVIRONMENTAL QUALITY
June 7,2018
Mr. Emory Owen
Operator in Responsible Charge
City of Brevard
95 W. Main St.
Brevard,North Carolina 28712
SUBJECT: Authorization to Construct
A to C No. 060534A04
City of Brevard
Brevard WWTF
NPDES Permit No. NC0060534
Dear Mr. Owen:
A Permit Application package for an Authorization to Construct (ATC) Permit was
received June 7, 2018,by the Division of Water Resources (Division).
This Authorization to Construct Permit is issued based solely upon the North
Carolina Licensed Professional Engineer's certification and the Applicant's certification of
• the ATC Permit Application package. The Division has waived the technical review of the
plans, specifications, calculations and other supporting documentation included in the
subject ATC Permit Application package. Note that the ATC Permit Application package
may be subject to a Division audit.
This ATC results in no increase in design or permitted capacity of the existing 2.5 MGD
Brevard Wastewater Treatment Facility and is hereby issued for the construction of the following
specific modifications:
Replacement of existing sewage pumps in the supernatant pump station with two (2) new
475 GPM 10 HP submersible pumps with piping and controls; in conformity with the
project plans, specifications, and other supporting documentation comprising the ATC
Permit Application package submitted to the Department of Environmental Quality.
This ATC is issued in accordance with Part III, Paragraph A of NPDES Permit No.
NC0060534 issued effective May 1,2017,and shall be subject to revocation unless the wastewater
treatment facilities are constructed in accordance with the conditions and limitations specified in
Permit No. NC0060534.
It is the Owner's responsibility to ensure that the as-constructed project meets the
requirements of all applicable regulations and statutes, the ATC Permit Application package, and
State of North Carolina I Environmental Quality I Water Resources
•512 N.Salisbury Street 11617 Mail service Center I Raleigh,North Carolina 27699-1612
Phone:919 807 6464
Mr.Emory Owen
June 7, 2018
Page 2 of 3
all of the requirements contained herein. Failure to comply may result in penalties in accordance
with North Carolina General Statute §143-215.6A through §143-215.6C.
The sludge generated from these treatment facilities must be disposed of in accordance
with G.S. 143-215.1 and in a manner approved by the Division.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as may
be required by the Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
The Asheville Regional Office, telephone number 828-296-4500, shall be notified at least
forty-eight(48)hours in advance of operation of the installed facilities so that an on site inspection
can be made. Such notification to the regional supervisor shall be made during the normal office
hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State Holidays.
Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a Professional Engineer certifying that the permitted facility
has been installed in accordance with the NPDES Permit and the ATC Permit Application package.
Mail the Certification to: Division of Water Resources, WQ Permitting — NPDES, 1617 Mail
Service Center, Raleigh,NC 27699-1617.
Upon classification of the facility by the Certification Commission, the Permittee shall
employ a certified wastewater treatment plant operator to be in responsible charge (ORC) of the
wastewater treatment facilities. The operator must hold a certificate of the type and grade at least
equivalent to or greater than the classification assigned to the wastewater treatment facilities by
the Certification Commission.
The Permittee must also employ a certified back-up operator of the appropriate type and
grade to comply with the conditions of T15A:8G.0202. The ORC of the facility must visit each
Class I facility at least weekly and each Class II, III and IV facility at least daily, excluding
weekends and holidays, must properly manage the facility, must document daily operation and
maintenance of the facility, and must comply with all other conditions of TI 5A:8G.0202.
A copy of the project plans and specifications shall be maintained on file by the
Permittee for the life of the facility.
During the construction of the proposed additions/modifications, the Permittee shall
continue to properly maintain and operate the'existing wastewater treatment facilities at all times,
and in such a manner, as necessary to comply with the effluent limits specified in the NPDES
Permit.
You are reminded that it is mandatory for the project to be constructed in accordance with
the North Carolina Sedimentation Pollution Control Act, and when applicable,the North Carolina
Mr. Emory Owen
June 7, 2018
Page 3 of 3
Dam Safety Act. In addition, the specifications must clearly state what the contractor's
responsibilities shall be in complying with these Acts.
Prior to entering into any contract(s) for construction, the recipient must have obtained all
applicable permits from the State.
The issuance of this ATC does not preclude the Permittee from complying with any and
all statutes,rules,regulations, or ordinances which may be imposed by other government agencies
(local, state, and federal)which have jurisdiction.
If you have any questions or need additional information, please contact Bing Bai at
telephone number(919) 807-6389.
Sincerely,
piny' Linda Culpepper
Interim Director, Division of Water Resources
With Engineer's Certificate attached:
cc: DWR Asheville Regional Office, Water Quality Programs
Central Files
ecopy: Randall Hintz,P.E.
WithersRavenel
Email: rhintz@withersravenel.com
NPDES File
Without Engineer's Certificate attached:
cc: Transylvania County Health Department