NCG210335 DMR SW

r na n s ilia V as l `N
WV-14MuIdilllVS1S
3804 Comanche Road
Archdale, NC 27263
Phone: [phone]
Fax: [phone]
Email dlowe@ornamental com
November 13, 2015 ReCE,
N.C. Division of Energy, Mineral and Land Resources = '
2015
Attention: Storm Water Permitting Program (Laura Alexander) j% r
1612 Mail Service CenterP00ft-,' !l�71!l t�
Raleigh, NC 27699-1612
Re: October 27, 2015 Follow Up Stormwater Sampling Event Summary
Ornamental Products, LLC Plant 2, High Point, North Carolina
NPDES Industrial Stormwater Permit#NCG210335
Ms. Alexander:
Per our conversation on 11/12/2015 regarding the most recent Stormwater Sampling at the above
named location, please find enclosed a copy of those final results conducted by Phoenix Environmental.
The attached report references respectively:
Table 1(Stormwater Analytical Results)
Appendix A (Stormwater Sample Analytical Test Report)
Report of Analysis (by Research & Analytical Laboratories, Inc. for Phoenix Environmental)
Chain of Custody Record (by Research & Analytical Laboratories, Inc)
Appendix B (Stormwater Discharge Outfall (SDO) Qualitative Monitoring Report - 2 Pages)
Please contact my office at [phone] Monday — Friday between 8:OOam — S:OOpm with any related
questions.
Best regards,
Dennis B. Lowe, Human Resources Manager
Ornamental Mouldings, LLC/Ornamental Products, LLC

Phoenix Environmental, Inc.
300 New Hope Road
Thomasville, North Carolina 27360
Phone [phone]
Fax [phone]
November 6 2015
Mr. Dennis Lowe
Human Resources Manager
Ornamental Products LLC
2214 Shore Street
High Point, North Carolina 27264
Reference: October 27, 2015 Stormwater Sampling Event Summary, Ornamental Products,
LLC Plant 2, High Point, North Carolina.
Dear Mr. Lowe:
Ornamental Products, LLC (Ornamental) requested Phoenix Environmental, Inc. sample
stormwater at the above referenced location in accordance with NC General Permit #210000.
This report summarizes results of the sampling event.
On October 27, 2015 a storm system moved through the area and produced sufficient rain to
qualify as an event (—.l" + estimated at the OPI site by 9 am). The rain started intermittently at
—4 am and at approximately 8 am heavier rainfall moved into the area and stormwater from
outfall 004 was sampled. The total event produced +.64" of rain at the KNCARCHD2 gauging
station (Archdale, NC). The recovered samples were immediately placed on ice and shipped to
R&A Laboratories, Inc. in Kernersville, NC for analysis (BOD & TSS). The sample analytical
results are shown in Table 1 (see Appendix A). The Stormwater Discharge Outfall (SDO)
Qualitative Monitoring Report is contained in Appendix B. As seen in Table 1, the laboratory
results are well within Benchmark Values published for NC General Permit #210000.
Table 1
Stormwater Analytical Results
Sampling Date Outfall Location pH TSS (mg/1) COD (mg/1)
10-27-15 004 7.0 <5 24
NC Benchmark Values 1 6.0-9.0 100 120
Outfalls 001 — 004 were inspected as part of the SDO monitoring. It is noted there is continuing
erosion at outfall 003. A joint of the concrete pipe has eroded out of the bank and lies in the
creek. On the sampling date, erosion around the discharging end of the RCP at outfall 003 (in the
bank of the drainage system) did not appear to be of concern. This is expected to change through
time as water discharging from the pipe slowly erodes soil below the pipe until the pipe joint
falls off.

Appendix A
October 27, 2015
Stormwater Sample
Analytical Test Report

RESEARChi NAIyTiCA[ Report of Analysis
LA ORATORIES© INC. 1115/2015
NA = not analyzed
P.O. Box 473 146 Short Street Kernersville, North Carolina 27284 Tei' 336-996-2841 Fax. [phone] www.randalabs.com Page 1
ral coa basic Od
�istaE:�r:�+t
For: Phoenix Environmental
300 New Hope Road
�a`t,.•'� �-�hlg.,
Thomasville, NC 27360
r �?
.. �� NC#34 �� • ,.
Attn: Bruce Braswell
NC #337701 = Z
r
A+orais��sz���
Client Sample ID: OPI Stormwater Outfall 004
Lab Sample ID: 10835-01
Site: Phoenix Environmental
Collection Date: 10/27/2015 8:58
Parameter Method
Result Units Aepsumli Analyst Analysis Date/Time
COD EPA 410.4
24 mg/L 5 KN 10/29/2015
Total Suspended Solids (TSS) SM 2540 D-1997
a5.0 mg/L 5 JB 10/29/2015
NA = not analyzed
P.O. Box 473 146 Short Street Kernersville, North Carolina 27284 Tei' 336-996-2841 Fax. [phone] www.randalabs.com Page 1
ral coa basic Od

ESEARCh &. A NA1yTiCA1
lAboRATO&S f INC.
Analytical / Process Consultations
Phone [336) 996-2841
CHAIN OF CUSTODY RECORD
I %.Mvmn nerncTcurnree a --A
11 kNY
�'"-.
JOB- NO.
�,
¢
U
o
=C
2.
�Q 1• �Ot J�Q O , qac � �
}, U, N• , a
2� a �a `O O� 'No UU
0 S Q Qr C9 C` C� Q,
vOtiof o�
REQUESTED ANALYSIS
STREET ADDRESS� %!
T PROJE
V�-L
CITY, STATE, ZIPe,
% i
/V S E^ V�
SAMPLER NAME (PLEASE PRINT)
�I2 tiCC ^'L%
CQNTACT PHONE
� c9 ^� l
v jilsLCt- ri <) 1NC•� J � �s7�1: �Ol fd
S R SIGNATURE
`" � 6r �
SAMPLE NUMBER
(U6USE ONLY)
DATE
TIME
d
EPRES
(z)
caowve
REMOVED
(M)
snor
MATRIX
i
LOCATION
i
!
I
RELINQUISHED BY
DATEITIME
RECEIVED BY
REMARKS:
SAMPLE TEMPERATURE AT RECEIPT- °C
RELINQUISHED BY
DATEITIME
REEI ED Y

Appendix B
Stormwater Discharge Outfall (SDO)
Qualitative Monitoring Report