820034_Waste Utilization Plan_20241001

Murphy-Brown, LLC 10/1/2024 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s): Murphy Brown, LLC
Farm Name: Sholar Farm;AWS820034
County: Sampson
Permit Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Wean to Finish
Feeder to Finish 0
Gilts
Boars
Storage Structure: Anaerobic Lagoon
Storage Period: >180 days
Application Method: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils,when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWR regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 11

This plan is based on the waste application method shown above. If you choose to change
methods in the future,you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made,which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons,ft3,tons,etc.):
Capacity Type Waste Produced perAnimal Total
Farrow to Wean 3203 gal/yr gal/yr
Farrow to Feeder 3861 gal/yr gal/yr
Farrow to Finish 10478 gal/yr gal/yr
Wean to Feeder 191 gal/yr gal/yr
Wean to Finish 776 gal/yr gal/yr
Feeder to Finish 927 gal/yr gal/yr
Gilts 1015 gal/yr gal/yr
Boars 2959 gal/yr gal/yr
Total - gal/yr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean 3.84 Ibs/yr Ibs/yr
Farrow to Feeder 6.95 Ibs/yr Ibs/yr
Farrow to Finish 18.86 Ibs/yr Ibs/yr
Wean to Feeder 0.34 Ibs/yr Ibs/yr
Wean to Finish 1.4 Ibs/yr Ibs/yr
Feeder to Finish 1.67 Ibs/yr Ibs/yr
Gilts 1.83 Ibs/yr Ibs/yr
Boars 5.33 Ibs/yr Ibs/yr
Total - Ibs/yr
76.9 Ibs/yr *See Nan
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 31.59
Total N Required 1st Year: 8871.28
Total N Required 2nd Year: 0.00
Average Annual Nitrogen Requirement of Crops: 8,871.28
Total Nitrogen Produced by Farm: 76.90
Nitrogen Balance for Crops: (8,794.38)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics,and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of11

9 N r0 r co�` cOMNM V e-
MO I`cM0 aO0<O O M ti O O Zo co
C� m V N�MD)c00 V O co
H
V
Q 0 0 0 0 0 0 0 0 0 0
16 Z N N[0 to N N N N N N
H a N N N N N N N N N N
J
z O
.,2 N O D O�1O0 1O0 LOO U p O
m ti O N N N M �O O 47
F-
z u o CDg o 0 0 0 0 0 0
sa oO00000OOO
J u]m 0 l0 m l0 0 0 0 UO
Q R
3
z v
� ayi
J�
p c
0OO0000OOO
az 40000�n0voLnLOv>
O y
N
a
o.D
U y
C}
N
.O.
E
f Q Vl to Ul to (A N (4 N N N
a
V J J J J J J J J J J
cV
N
zy N LnrOn�NMM MtO MVI� cOVo m V
Oh O O c0 f�cD 4 O
NM 0a <7N0
AON
O<
^ @
Z NN(O0(OO NNNN N N
O _
S Q cq <
J` N N N N N N N N N N
Q M
7
`za
y N
N
J 0'
D C
O;! O CD CD CD CDO O O O CD
O O O O O O O O O O
UZ CD mm NNODN wc0
N y V V V V R C V R V
r L
Q
'O 0 0 0 0 0 0 0 0 0 0
U y vv,vvv,v,v,v,vv
} vvUr w-Itvvcvv
Vi
N N N N N N N N N N
M (n(n co co w co(n(n(n(0
Q i i i4. i i L
(6 cc M m m@ M M (6 M
O.
O C7
(j 0 U U U U U U U U U U
H V
d
y fnF m ccoM mm m m m m
m mmmmm� m G
O
cm
R a m h
V M OO<D 10 n M Ne0
y vEqUDgC:n�nOeor
V u M r 1 D E O M M N N<N
M i Q
in
O! Q m N M V l0 co N O
LL
C
O
C (W
Ll N N N N N N f6 l0 t6 l0 Ip
G1 F (A In(A(A V1(q co(A(A(n

z 6 O
L N
H�
u
aZ
F N
s
J
za O
N a
a N
07
F
Z V
J¢
za
N �
O.C
O=
U Z
a N
N
a
o.o
U y
c}
N
O
G
E¢
a
o „
U C
aU
C
N
z O
,.a
a N
F= I
0
a
NQ ro
J
¢ R
7
Z
N N
d
J�
GC
7
U Z
N�
Q
O a
U m
w�
O
m-
E¢
F
a
o a
U p
NU
m
O
y to F
C
O
�a
a =¢
N
da
a LL
O
QCD
u
d �

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields(i.e.small grain,etc, interseeded in bermuda),forage must be removed
through grazing, hay,and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage,care
should be exercised not to let small grain reach maturity,especially late in the season(i.e.
April or May). Shading may result if small grain gets too high and this will definitely interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation,you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season,depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop Description-Harvested As
A Barley Grain Crop
B Grazed Hybrid Bermudagrass Pasture/Grazed
C Hybrid Bermudagrass Hay Hay
B/C Comb. Hybrid Bermudagrass Graze/Hay Combination
D Corn-Grain Grain Crop
E Corn-Silage Silage
F Cotton Cotton Lint
G Grazed Fescue Pasture/Grazed
H Fescue Hay Hay
I Oats Grain Crop
J Rye Grain Crop
K Grazed Overseed Pasture/Grazed(Seeded in Bermudagrass)
L Overseed Hay Hay(Seeded in Bermudagrass)
M Grain Sorghum Grain Crop
N Wheat Grain Crop
O Soybean Grain Crop
P Pine Trees Pine Trees
S Small Grain Grain Crop/Hay(After Grain Crop)
CC Cover Crop Not Harvested; Burned/Disked In
SWG Swithgrass Biomass Crop
CG Crabgrass/Bermuda Mix Hay
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers,filter strips along ditches,odd areas unable to be irrigated,and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 11

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/yr/animal Farm Total/ r
Farrow to Wean 0.8
Farrow to Feeder 0.96
Farrow to Finish 3.9
Wean to Feeder 0.07
Wean to Finish 0.27
0 Feeder to Finish 0.34 0
Gilts 0.39
Boars 0.55
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 0 pounds of plant available nitrogen per year and will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years,you will have approximately 0 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre,you will need 0 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre,you will need 0 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type,crop,and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content,soil
structure,soil texture,water droplet size,and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations,the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for>180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 11

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil Application Rate Application Amount
Tract Hydrant Type Crop in/hr * inches
Shofar 1A BoB C 0.75 1
Shofar 1 B BoB C 0.75 1
Sholar 2 WaB C 0.6 1
Sholar 3 WaB C 0.6 1
Sholar 4 BoB C 0.75 1
Sholar 5 BoB C 0.75 1
Sholar 6 BoB C 0.75 1
Sholar 7 BoB C 0.75 1
Sholar 8 BoB C 0.75 1
Sholar 9 BoB C 0.75 1
6of11

Additional Comments:
8/31/2018-This plan revised to show a crop change for pulls 1A, 1B, 8 & 9
due to these pulls/fields being sprigged with coastal bermuda this summer.
This plan is written based on "On Farm records"for PAN production and the
application rates are based on the current rates as listed on the NCSU
Nutrient Management website. (Copy of calculations attached)
10/01/2024 This facility was depopulated Jan 16, 2019. Rainfall in Excess
of Evaporation:
115,846 cubic feet* 7.48 gal/cubic ft. =866,528 gal/year
866,528 gal/year * .08875 avg Ibs PAN/1000 gal = 76.90 Ibs PAN/yr.
Avg Ibs PAN/1000: from Sept 13,2023-08/28/2024
0.14
0.03
0.03
0.04
0.04
0.03
0.06
0.34
.71/8 = .08875
7of11

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Sholar Farm; AWS820034
Owner: Murphy Brown, LLC
Manager-
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWR before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWR upon request.
Name of Facility Owner: Murphy Brown, LLC
Signature: Li
Date
Name of Manager(if different from owner):
Signature:
Date
Name of Technical Specialist: Toni King
Affiliation: Smithfield Hog Production Division
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
r
Signature:
Date
8of11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1 Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based upon soil type, available moisture, historical data, climatic conditions,
and level of management, unless there are regulations that restrict the rate of applications
for other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field
(See USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and
flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is not
covered with waste to a depth that would inhibit growth. The potential for salt damage from
animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste/nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of the crop or forages breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following: The
outer perimeter of the land area onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential property boundary and canal. Animal
waste, other than swine waste from facilities sited on or after October 1, 1995, shall not be
applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by
the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by discharge
or by over-spraying. Animal waste may be applied to prior converted cropland provided the fields
have been approved as a land application site by a "technical specialist". Animal waste shall not
be applied on grassed waterways that discharge directly into water courses, and on other grassed
waterways, waste shall be applied at agronomic rates in a manner that causes no runoff or drift
from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be
discharged into the animal waste management system.
10 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
17 A protective cover of appropriate vegetation will be established on all disturbed areas (lagoon
embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to protect the
vegetation. Vegetation such as trees, shrubs, and other woody species, etc., are limited to areas
where considered appropriate. Lagoon areas should be kept mowed and accessible. Berms and
structures should be inspected regularly for evidence of erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated,the owner is responsible for
obtaining and implementing a "closure plan" which will eliminate the possibility of an illegal
discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to
prevent breakdowns, leaks and spills. A regular maintenance checklist should be kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct human
consumption. However, if animal waste is used on crops for direct human consumption, it should
only be applied pre-plant with no further applications of animal waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the temporary
storage (pumping volume) of all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will be required to mark the maximum
storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually at crop
sites where waste products are applied. Nitrogen shall be the rate-determining nutrient, unless
other restrictions require waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the soil shall be monitored
and alternative crop sites shall be used when these metals approach excessive levels. pH shall be
adjusted and maintained for optimum crop production. Soil and waste analysis records shall be
kept for a minimum of five years. Poultry dry waste application records shall be maintained for a
minimum of three years. Waste application records for all other waste shall be maintained for a
minimum of five years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
11 of 11

Mf Are A44 Ncs
'44 ° hls+ 14b' .50 31 f.44
vlo' �
Soon € 3l dA
.4L 2.Q3 �twQl t+a�
WA k5a
a
1
VIM.
AID
&x/S
fD
q ✓ '.s 1�c
• rdN '! 1 , �S)f
' 4
&RENT H. WHITFIELD & ASSOC, u,�:�� 21. 1997
P.O. "OX 21" 409 N. NORWOAp ST. (—V052AlnlOWM SUBVtY FOA-
VAUJACE N.C. 2NO6 �"
OWME (9ro) .?85_,f222 SNDLAR fARV
sc r•.

AWS820034
Ak— ' ,f, W E
tt i Wo s
� i1 Ly WaB
Mac
1
B
WaB Free
C`sat¢�M1 W!//geek MaC
8
aB
MaC 6
y Fo
CaB
B0
Au
To .emu
Property Line NRCS Soils Sholar Farm 0 370 740 1,480 Feet
NHD Flovdine NHD,Waterbody
Connector Playa 532 Moon Johnson Rd
Dftch Ice Mass 1 in= 0.13 miles 1:8.050
Pipeline Lake/Pond Rose Hill,NC 28458
Stream Reservoir
Artificial Path Swampmarsh Longitude: -78.25018 This Map Was Created By Garrett Metvin on 4/2woi5
Latitude: 34.767297 Using Data From USDA.USGS,NC OneMap,Sampson County GIS,
Coastline Estuary NC-DENR,and The Murphy-Brown LLC Engineering Dept.