NC0045993_Permit (Issuance)_20240826

Permit NCO045993
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER RESOURCES
PFRMTT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
ATI Specialty Materials, LLC
is hereby authorized to discharge wastewater from a facility located at
2020 Ashcraft Avenue
Monroe
Union County
to receiving waters designated as Richardson Creek in the Yadkin -Pee Dee River Basin
in accordance with effluent limitations, monitoring requirements, and other conditions
set forth in Parts I, II, III, and IV hereof.
The permit shall become effective October 1, 2024
This permit and the authorization to discharge shall expire at midnight on September 30, 2029
Signed this day August 27, 2024
Douglas Dowden
Environmental Program Supervisor II
Division of Water Resources
By Authority of the Environmental Management Commission
Page 1 of 8

Permit NC0045993
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are hereby
revoked, and as of this issuance, any previously issued permit bearing this number is no longer
effective. Therefore, the exclusive authority to operate and discharge from this facility arises
under the permit conditions, requirements, terms, and provisions included herein.
ATI Specialty Materials, LLC
is hereby authorized to:
1. Continue to operate two cooling ponds with an oil skimming baffle located at the Monroe
Facility at 2020 Ashcraft Avenue, Monroe, in Union County; and
2. Discharge from said treatment works at the location specified on the attached map into
Richardson Creek, which is classified C waters in the Yadkin -Pee Dee River Basin.
Page 2 of 8

Permit NCO045993
PART I
A. (1). EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
[15A NCAC 02B .0400 et seq., 02B .0500 et seq.]
During the period beginning on the effective date of this permit and lasting until expiration, the Permittee
is authorized to discharge from outfall 001. Such discharges shall be limited and monitored' by the
Permittee as specified below:
EFFLUENT
CHARACTERISTICS
EFFLUENT
LIMITATIONS
MONITORING
REQUIREMENTS
Monthly
Average
Daily
Maximum
Measurement
Frequency
Sample
Type
Sample
Location2
Flow, MGD
No limit
Continuous
Recording
Effluent
Total Chromium
0.04 lb/day
0.09 lb/day
2/Month
Composite
Effluent
Total Fluoride
43.34 lb/day
98.77 lb/day
2/Month
Composite
Effluent
Total Cyanide3
0.171 lb/day
0.414 lb/day
2/Month
Grab
Effluent
Total Nickel
0.09 lb/day
0.13 lb/day
2/Month
Composite
Effluent
Total Lead
0.29 lb/day
0.6 lb/day
2/Month
Composite
Effluent
Total Zinc
0.87 lb/day
2.09 lb/day
2/Month
Composite
Effluent
Total Copper
15.38 µg/L
18.96 µg/L
2/Month
Composite
Effluent
Total Cadmium, µg/L
Quarterly
Composite
Effluent
NH3 as N
(April 1 -October 31)
2.0 mg/L
10.0 mg/L
2/Month
Composite
Effluent
NH3 as N
(November 1-March 31)
4.0 mg/L
20.0 mg/L
2/Month
Composite
Effluent
Total Suspended Solids
30.0 mg/L
45.0 mg/L
2/Month
Composite
Effluent
Oil and Grease
10.0 mg/L
15.0 mg/L
2/Month
Grab
Effluent
Temperature, oC4
Weekly
Grab
Effluent,
Upstream,
Downstream
Conductivity, µmho/cm
2/Month
Grab
Effluent,
Upstream,
Downstream
pH
6.0 < pH < 9.0
Monthly
Grab
Effluent
Chronic Toxicitys
I
I Quarterly
Composite
Effluent
Notes:
1. See Special Condition A (3).
2. Sample locations: Upstream: 50 feet above discharge point; Downstream: at a point 100 feet
downstream of the discharge point.
3. The Division shall consider all cyanide values reported below 10 µg/L to be "zero' for compliance
purposes. However, Discharge Monitoring Reports (DMRs) shall record all values reported by a North
Carolina -certified laboratory (even if these values fall below 10 µg/L).
4. The temperature of the effluent will be regulated so that the temperature of the receiving stream does
not increase more than 2.8°C (5.05°F) above the natural water temperature (between upstream and
downstream monitoring locations) and does not exceed a maximum of 32°C (89.6°F). [15 A NCAC
02B .0211 (18)].
Page 3 of 8

Permit NCO045993
5. Whole Effluent Toxicity shall be measured by the chronic toxicity P/F test (Ceriodaphnia) at 51%;
testing shall be performed in February, May, August, and November. See Condition A. (2.) for details.
Toxicity monitoring shall coincide with metals monitoring.
THERE SHALL BE NO DISCHARGE OF FLOATING SOLIDS OR VISIBLE OIL IN OTHER THAN TRACE AMOUNTS.
A. (2). CHRONIC TOXICITY PERMIT LIMIT (QRTRLY)
[15A NCAC 02B .0200 et seq.]
The effluent discharge shall at no time exhibit observable inhibition of reproduction or significant
mortality to Ceriodaphnia dubia at an effluent concentration of 51.0%.
The permit holder shall perform at a minimum, puarterlu monitoring using test procedures outlined in
the "North Carolina Ceriodaphnia Chronic Effluent Bioassay Procedure," Revised February 1998, or
subsequent versions or "North Carolina Phase II Chronic Whole Effluent Toxicity Test Procedure"
(Revised -February 1998) or subsequent versions. The tests will be performed during the months of
February, May, August, and November. Effluent sampling for this testing shall be performed at the
NPDES permitted final effluent discharge below all treatment processes.
If the quarterly test procedure results in a failure or ChV below the permit limit, then multiple -
concentration testing shall be performed at a minimum, in each of the two following months as
described in "North Carolina Phase II Chronic Whole Effluent Toxicity Test Procedure" (Revised -
December 2010) or subsequent versions.
All toxicity testing results required as part of this permit condition will be entered on the Effluent
Discharge Monitoring Form (MR-1) for the months in which tests were performed, using the parameter
code TGP313 for the pass/fail results and THP3B for the Chronic Value. Additionally, DWR Form AT-3
(original) is to be sent to the following address:
Attention: North Carolina Division of Water Resources
Water Sciences Section/Aquatic Toxicology Branch
1621 Mail Service Center
Raleigh, North Carolina 27699-1621
Or, results can be sent to the email, [e-mail].
Completed Aquatic Toxicity Test Forms shall be filed with the Water Sciences Section no later than 30
days after the end of the reporting period for which the report is made.
Test data shall be complete, accurate, include all supporting chemical/physical measurements and all
concentration/response data, and be certified by laboratory supervisor and ORC or approved designate
signature. Total residual chlorine of the effluent toxicity sample must be measured and reported if
chlorine is employed for disinfection of the waste stream.
Should there be no discharge of flow from the facility during a month in which toxicity monitoring is
required, the permittee will complete the information located at the top of the aquatic toxicity (AT) test
form indicating the facility name, permit number, pipe number, county, and the month/year of the
report with the notation of "No Flow" in the comment area of the form. The report shall be submitted to
the Water Sciences Section at the address cited above.
Should the permittee fail to monitor during a month in which toxicity monitoring is required, monitoring
will be required during the following month. Assessment of toxicity compliance is based on the toxicity
testing month.
Page 4 of 8

Permit NCO045993
Should any test data from this monitoring requirement or tests performed by the North Carolina Division
of Water Resources indicate potential impacts to the receiving stream, this permit may be re -opened and
modified to include alternate monitoring requirements or limits.
NOTE: Failure to achieve test conditions as specified in the cited document, such as minimum control
organism survival, minimum control organism reproduction, and appropriate environmental controls,
shall constitute an invalid test and will require immediate follow-up testing to be completed no later
than the last day of the month following the month of the initial monitoring.
A. (3). ELECTRONIC REPORTING OF DISCHARGE MONITORING REPORTS
[G. S. 143-215.1(b)]
Federal regulations require electronic submittal of all discharge monitoring reports (DMRs) and program
reports. The final NPDES Electronic Reporting Rule was adopted and became effective on December 21,
2015.
NOTE: This special condition supplements or supersedes the following sections within Part II of this
permit (Standard Conditions for NPDES Permits):
• Section B. (11.) Signatory Requirements
• Section D. (2.)
• Section D. (6.)
• Section E. (5.)
Reporting
Records Retention
Monitoring Reports
1. Reporting Requirements [Supersedes Section D. (2.) and Section E. (5.) (a)]
The permittee shall report discharge monitoring data electronically using the NC DWR's Electronic
Discharge Monitoring Report (eDMR) internet application.
Monitoring results obtained during the previous month(s) shall be summarized for each month and
submitted electronically using eDMR. The eDMR system allows permitted facilities to enter
monitoring data and submit DMRs electronically using the internet. Until such time that the state's
eDMR application is compliant with EPA's Cross -Media Electronic Reporting Regulation (CROMERR),
permittees will be required to submit all discharge monitoring data to the state electronically using
eDMR and will be required to complete the eDMR submission by printing, signing, and submitting
one signed original and a copy of the computer printed eDMR to the following address:
NC DEQ / Division of Water Resources / Water Quality Permitting Section
ATTENTION: Central Files
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
If a permittee is unable to use the eDMR system due to a demonstrated hardship or due to the
facility being physically located in an area where less than 10 percent of the households have
broadband access, then a temporary waiver from the NPDES electronic reporting requirements may
be granted and discharge monitoring data may be submitted on paper DMR forms (MR 1, 1. 1, 2, 3)
or alternative forms approved by the Director. Duplicate signed copies shall be submitted to the
mailing address above. See "How to Request a Waiver from Electronic Reporting" section below.
Regardless of the submission method, the first DMR is due on the last day of the month following the
issuance of the permit or in the case of a new facility, on the last day of the month following the
commencement of discharge.
Starting on December 21, 2025, the permittee must electronically report the following compliance
monitoring data and reports, when applicable:
Page 5 of 8

Permit NCO045993
Sewer Overflow/Bypass Event Reports;
Pretreatment Program Annual Reports; and
Clean Water Act (CWA) Section 316(b) Annual Reports.
The permittee may seek an electronic reporting waiver from the Division (see "How to Request a
Waiver from Electronic Reporting" section below).
2. Electronic Submissions
In accordance with 40 CFR 122.41(1)(9), the permittee must identify the initial recipient at the time of
each electronic submission. The permittee should use the EPA's website resources to identify the
initial recipient for the electronic submission.
Initial recipient of electronic NPDES information from NPDES-regulated facilities means the entity
(EPA or the state authorized by EPA to implement the NPDES program) that is the designated entity
for receiving electronic NPDES data [see 40 CFR 127.2(b)].
EPA plans to establish a website that will also link to the appropriate electronic reporting tool for
each type of electronic submission and for each state. Instructions on how to access and use the
appropriate electronic reporting tool will be available as well. Information on EPA's NPDES
Electronic Reporting Rule is found at:
https: / /www.federalregister. gov/ documents / 2015 / 10 / 22 / 2015-249 54 / national-pollutant-
dis charge-elimination-system-npdes-electronic-reporting-rule
Electronic submissions must start by the dates listed in the "Reporting Requirements" section above.
3. How to Request a Waiver from Electronic Reporting
The permittee may seek a temporary electronic reporting waiver from the Division. To obtain an
electronic reporting waiver, a permittee must first submit an electronic reporting waiver request to
the Division. Requests for temporary electronic reporting waivers must be submitted in writing to
the Division for written approval at least sixty (60) days prior to the date the facility would be
required under this permit to begin submitting monitoring data and reports. The duration of a
temporary waiver shall not exceed 5 years and shall thereupon expire. At such time, monitoring
data and reports shall be submitted electronically to the Division unless the permittee re -applies for
and is granted a new temporary electronic reporting waiver by the Division. Approved electronic
reporting waivers are not transferrable. Only permittees with an approved reporting waiver request
may submit monitoring data and reports on paper to the Division for the period that the approved
reporting waiver request is effective.
Information on eDMR and the application for a temporary electronic reporting waiver are found on
the following web page:
http://deg.nc.gov/about/divisions/water-resources/edmr
4. Signatory Requirements [Supplements Section B. (11.) (b) and Supersedes Section B. (11.) (d)l
All eDMRs submitted to the permit issuing authority shall be signed by a person described in Part II,
Section B. (11.)(a) or by a duly authorized representative of that person as described in Part II,
Section B. (11.)(b). A person, and not a position, must be delegated signatory authority for eDMR
reporting purposes.
For eDMR submissions, the person signing and submitting the DMR must obtain an eDMR user
account and login credentials to access the eDMR system. For more information on North Carolina's
Page 6 of 8

Permit NCO045993
eDMR system, registering for eDMR and obtaining an eDMR user account, please visit the following
web page:
http://deg.nc.gov/about/divisions/water-resources/edmr
Certification. Any person submitting an electronic DMR using the state's eDMR system shall make
the following certification [40 CFR 122.22]. NO OTHER STATEMENTS OF CERTIFICATION WILL BE
ACCEPTED:
'7 certify, under penalty of law, that this document and all attachments were prepared under my
direction or supervision in accordance with a system designed to assure that qualified personnel
properly gather and evaluate the information submitted. Based on my inquiry of the person or persons
who manage the system, or those persons directly responsible for gathering the information, the
information submitted is, to the best of my knowledge and belief, true, accurate, and complete. I am
aware that there are significant penalties for submitting false information, including the possibility of
fines and imprisonment for knowing violations. "
5. Records Retention [Supplements Section D. 16.)]
The permittee shall retain records of all Discharge Monitoring Reports, including eDMR submissions.
These records or copies shall be maintained for a period of at least 3 years from the date of the
report. This period may be extended by request of the Director at any time [40 CFR 122.41].
Page 7 of 8

Permit NCO045993
Page 8 of 8