NC0087106_Authorization to Construct_20020315

.N
William G. Lapsley & Associates, P.A.
Consulting Engineers and Land Planners
1635 Asheville Highway
Post Office Box 546
Hendersonville, North Carolina 28793
828-697-7334 - FAX [phone]
March 15, 2002
Ms. Jacquelyn M. Nowell
NPDES Permit Unit
NC Division of Water Quality T
1617 Mail Service Center D
Raleigh, NC 27699-1617 i
�u
Re: Champion Hills WWTP MAR 19 2002
Permit N00087106.
A/C #0087106 DENR - WATER QUALITY
SOURCE BRAN^N
Henderson County POINT SO
Dear Ms. Nowell:
Enclosed for your records please find the Engineer's Certification for the above
referenced project.
William G. Lapsley, P.E.
William R. Buie, P.E.
G. Thomas Jones III, P.E.
Wm. James Jones, P.E.
Please note that it was not necessary to upgrade the -existing effluent pumps included in
the approved plans. During a test run of the existing pumps the system worked find therefore,
new pumps are not required.
If you have any questions or concerns please feel free to contact our office.
WGL/ds
cc: Lee Weber, Champion Hills
0-
Printed on Recycled Paper

gut No. NC0087106
"ithorization to Construct
WWTP
.:hampion Hills
January 25, 2002
a Page 3
Engineer's Certification
I,
WA%b^ G. La duly registered Professional Engineer in the State of
North Carolina, having been nut horiz d to observe (periodically, e) the construction of
the project, 5� w �m Wt VMC60KWS NAM for the
o�
Projeck Name Location
Permittee hereby state that, to the best of my abilities, due care and diligence was used in the observation
of the following installations:
• the installation of a tee(s) in the existing effluent force main with two (2) control valves,
• the installation of 4" � effluent force main to the receiving stream, an unnamed tributary of
South Fork Big Willow Creek
• the upgrading of the dual pumps of the effluent discharge lift station from 5 HP to 7 %Z HP
for the above referenced project such that the construction was observed to be built within substantial
compliance and intent of the approved plans and specifications:
The permittee must comply, even during the construction phase, with all limits required by the NPDES
permit. Once construction under this ATC has been completed and an Engineer's Certificate has been
submitted, the permittee is authorized to operate the new treatment units.
Sign
Date
In addition, please check one of the following:
-4- F •. C,
• SEAL
' 669
!�w••• r A� r `l� • ` �4ti �+`
. Vlea� •'
��yy
-'•....••'S�
,I,��ivvw��,'
E G Tad` `i`
ire:
. ►a,a`a�
•
There are still some major components that require completion. Another Engineer's
Certificate will be submitted once all substantial construction has been completed.
All substantial construction has been completed.
The Division of Water Quality hereby
receipt and acceptance of
Bn t� on

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
Gregory J. Thorpe, Ph.D., Acting Director
January 25, 2002
Mr. Lee J. Weber
Champion Hills POA, Inc.
1 Hagen Drive
Hendersonville, North Carolina 28739-8964
Dear Mr. Weber:
L19.9�VA
NCD NR
Subject: Permit No. NCO087106
ATC Number 087106AO I
Champion Hills WWTP
Henderson County
The Division received a letter of request for Authorization to Construct on October 16, 2001. Final plans and
specifications for the subject project have been reviewed and found to be satisfactory. Authorization is hereby granted for
the installation of an effluent discharge line. Specifically, this ATC allows:
the installation of a tee(s) in the existing effluent force main with two (2) control valves,
the installation of 4" 0 effluent force main to the receiving stream, an unnamed tributary of
South Fork Big Willow Creek
the upgrading of the dual pumps of the effluent discharge lift station from 5 HP to 7 %Z HP
This Authorization to Construct is issued in accordance with Part III, Paragraph C of NPDES Permit No.
NCO087106 issued September 25, 2001 and shall be subject to revocation unless the wastewater treatment facilities are
constructed in accordance with the conditions and limitations specified in Permit No. NC0087106. Failure to abide by the
requirements contained in this Authorization to Construct may subject the Permittee to an enforcement action by the Division
of Water Quality in accordance with North Carolina General Statute 143-215.6A to 143-215.6C. The issuance of this
Authorization to Construct does not preclude the Permittee from complying with any and all statutes, rules, regulations, or
ordinances which may be imposed by other government agencies (local, state, and federal) which have jurisdiction.
In the event that the facility fails to perform satisfactorily, including the creation of nuisance conditions, the
Permittee shall take immediate corrective action, including those as may be required by this Division, such as the
construction of additional or replacement wastewater treatment or disposal facilities.
The Asheville Regional Office, telephone number [phone], shall be notified at least forty-eight (48) hours in
advance of operation of the installed facilities so that an on -site inspection can be made. Such notification to the regional
supervisor shall be made during the normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday,
excluding State Holidays.
Upon completion of construction and prior to operation of this permitted facility, a certification must be received
from a professional engineer certifying that the permitted facility has been installed in accordance with the NPDES Permit,
this Authorization to Construct, and the approved plans and specifications. Mail the completed certification to: North
Carolina DENR-DWQ, NPDES Unit, 1617 Mail Service Center, Raleigh, NC 27699-1617.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Permit No. NCO087106
Authorization to Construct
Champion Hills WWTP
January 25, 2002
Page 2
One (1) set of approved plans and specifications is being forwarded to you. A copy of the approved plans and
specifications shall be maintained on site by the Permittee for the life of the facility. If you have any questions or need
additional information, please contact Jacquelyn M. Nowell, telephone number [phone], extension 512.
Sincerer
Gregory J. Thorpe, Ph.D.
cc: Central Files
NPDES Unit
Asheville Regional Office, DWQ
Technical Assistance and Certification