NC0083925_Permit Issuance_20090312

A�
CCDENR
North Carolina Department of Environment and Natural Resources
Beverly Eaves Perdue
Govemor
Thomas Roberts, President
Aqua North Carolina, Inc.
202 Mackenan Court
Cary, North Carolina 27511
Dear Mr. Roberts:
Division of Water Quality
Coleen H. Sullins
Director
March 12, 2009
Subject: Issuance of NPDES
Permit NCO083925
Salem Glen Subdivision WWTP
Davidson County
Dee Freeman
Secretary
Division personnel have reviewed and approved your application for renewal of the subject permit. Accordingly, we are
forwarding the attached NPDES discharge permit. This permit is issued pursuant to the requirements of North Carolina
General Statute 143-215.1 and the Memorandum of Agreement between North Carolina and the U.S. Environmental
Protection Agency dated October 15, 2007 (or as subsequently amended).
Please be advised that Permit Condition A. (2.) requires compliance withing thirty (30) days after issuance of this
final permit.
If any parts, measurement frequencies or sampling requirements contained in this permit are unacceptable to you, you
have the right to an adjudicatory hearing upon written request within thirty (30) days following receipt of this letter. This
request must be in the form of a written petition, conforming to Chapter 150B of the North Carolina General Statutes, and
filed with the Office of Administrative Hearings (6714 Mail Service Center, Raleigh, North Carolina 27699-6714). Unless
such demand is made, this decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may require modification
or revocation and reissuance of the permit. This permit does not affect the legal requirements to obtain other permits
which may be required by the Division of Water Quality or permits required by the Division of Land Resources, the
Coastal Area Management Act or any other Federal or Local governmental permit that may be required. If you have any
questions concerning this permit, please contact Bob Guerra at telephone number [phone].
Sincerely,
t) Coleen H. Sullins
Enclosure: NPDES Perm CC0083952
cc: Winston-Salem Regional Office / Surface Water Protection
NPDES Unit
Central Files
1617 Mail Service Center, Ralegh, North Carolina 27699-1617
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604
Phone: [phone] FAX: [phone] Customer Service: 1-877-623-6748
Internet w .ncwateiquality.org
An Equal Opportunity \ Alfirrnallve Action Employer
One
NorthCarolina
;Ukrally

Permit NCO083925
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND' NATURAL RESOURCES
DIVISION OF WATER QUALITY
PRPMTT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Aqua North Carolina, Inc.
is hereby authorized to discharge wastewater from a facility located at the
Salem Glen Subdivision WWTP
Dock Davis Road
Clemmons
Davidson County
to receiving waters designated as the Yadkin River in the Yadkin -Pee Dee River
in accordance with effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective April 1, 2009.
This permit and authorization to discharge shall expire at midnight on December
31, 2013.
Signed this day March 12, 2009.
PTen H. Sullins, Director
sion of Water Quality
By Authority of the Environmental Management Commission

Permit NC0083925
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are
hereby revoked. As of this permit issuance, any previously issued permit bearing this
number is no longer effective. Therefore, the exclusive authority to operate and discharge
from this facility arises under the permit conditions, requirements, terms, and provisions
included herein.
Aqua North Carolina, Inc. is hereby authorized to:
1. Continue to operate an existing 0.10 MGD extended -aeration package
wastewater treatment system with a discharge of treated domestic wastewater
consisting of:
a. an effluent flow control chamber with bar screen.
b. a flow equalization tank,
c. two (2) 50,000 gallon aeration basins with coarse air bubblers,
d. two (2) rectangular clarifiers with air sludge wasting and return,
e. UV disinfection with backup tablet chlorination/dechlorination,
f. Effluent clear well,
g. Effluent pump station and
h. Flow measuring device.
2. The facility is at the Salem Glen WWTP located on Dock Davis Road near
Clemmons in Davidson County.
3. After receiving Authorization to Construct from the Division of Water Quality,
expand the facility to a 0.20 MGD WWTP.
4. Discharge from said treatment works at the location specified on the attached
map into the Yadkin River, classified as WS-IV waters in the Yadkin -Pee Dee
River Basin.

Permit NCO083925
A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
During the period beginning on the effective date of this permit and lasting until expiration or expansion above
0.10 MGD, the Permittee is authorized to discharge treated domestic wastewater from outfall 001. Such
discharges shall be limited and monitored by the Permittee as specified below:
:EFFLUE
t`3z )
CfIARAC7ERITICS
L� 7 nyL11VI1T$ » G, r µ4'}y k
t,..- 'i4' SN -;#' , v
_���'�?��•. i��M H:a� _ 2 .<. �` * ..� T `•,.�x,•; pin...
' �NIO 11+1G REQUIRE ' N.
.�'t: e.n - .Crx
.
�. Daffy,
I A ars eni R = K Sample` �d ; p' e:
,kY;uverage
Flow
0.10 MGD
Continuous
Recording
Influent or
Effluent
BODS, 5-day, 200
30.Omg/L
45.0 mg/L
Weekly
Composite
Effluent
Total Suspended
30.0 mg/L
45.0 mg/L
Weekly
Composite
Effluent
Solids
NH3 as N
2/Month
Composite
Effluent
Temperature
Weekly
Grab
Effluent
pH
(6.0 — 9.0 s.u.)
Weekly
Grab
Effluent
Total Residual
Chlorine12
28 ug/L
2/Month
Grab
Effluent
Total Nitrogen
Monthly
Composite
Effluent
NO + NO3 + TKN
Total Phosphorus
Monthly
Composite
Effluent
Footnotes:
1. Total residual Chlorine (TRC) monitoring requirements and limits are applicable if chlorine compounds
are used for disinfection.
2. The Division shall consider all effluent TRC values reported below 50 ug/I to be in compliance with the
permit. However, the Permittee shall continue to record and submit all values reported by a North
Carolina certified laboratory (including field certified), even if these values fall below 50 ug/l.
All samples collected should be from a representative discharge event.
There shall be no discharge of floating solids or visible foam in other than trace amounts.

Permit NCO083925
A. (2.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
Beginning upon authorized expansion above 0.10 MGD and lasting until expiration, the Permittee is authorized to
discharge treated domestic wastewater from outfall 001. Such discharges shall be limited and monitored by the
Permittee as specified below:
EFFLUENT ,
LIMITS
` MONITGRING REQUIREMENTS " r.�
s F x r - : : �a �r .> rvr ,r
Y�'.
CHARACTERISTICS
Monthly
Daily}rr}'lUleasurenerit'`
Sample �Sam
syle
p
era a
Avximum
Ma
1V, % 6?� ice.. ;._C 1
Fre uenc
.i
T
= e>. ,Location
•`
, .
Flow
0.20 MGD
Continuous
RecordingInfluent
or
Effluent
BOD5i 5-day, 200
30.Omg/L
45.0 mg/L
Weekly
Composite
Effluent
Total Suspended
30.0 mg/L
45.0 mg/L
Weekly
Composite
Effluent
Solids
NH3 as N
2/Month
Composite
Effluent
Temperature
Weekly
Grab
Effluent
pH
(6.0 — 9.0 s.u.)
Weekly
Grab
Effluent
Total Residual
28 ug/L
2/Month
Grab
Effluent
Chlorine1.2
Total Nitrogen
Monthly
Composite
Effluent
NO2 + NO3 + TKN
Total Phosphorus
Monthly
Composite
Effluent
Footnotes:
1. Total residual Chlorine (TRC) monitoring requirements and limits are applicable if chlorine compounds
are used for disinfection.
2. The Division shall consider all effluent TRC values reported below 50 ug/I to be in compliance with the
permit. However, the Permittee shall continue to record and submit all values reported by a North
Carolina certified laboratory (including field certified), even if these values fall below 50 ug/l.
All samples collected should be from a representative discharge event.
There shall be no discharge of floating solids or visible foam in other than trace amounts.

Permit NCO083925
A. (3.) PROCESS SCHEMATIC FLOW DIAGRAM
The Permittee shall submit a Process schematic flow diagram within 30 days from issuance
of permit. This submittal shall include:
Components utilized in treatment process and
• Size of process components in treatment process

Beverly Eaves Perdue, Governor
Dee Freeman, Secretary
North Carolina Department of Environment and Natural Resources
rol
January 14, 2009
MEMORANDUM
To: Lee Spencer
NCDENR / DEH / Regional Engineer
Winston-Salem Regional Office
From: Robert Guerra
NPDES Unit
Subject: Review of Draft NPDES Permit NCO083925
Salem Glen Subdivision WIX/TP
Davidson County
Coleco H. Sullins, Director
Division of Water Quality
JAN 29 2005
Please indicate below your agency's position or viewpoint on the draft permit and return this form by February 15,
2009. If you have any questions on the draft permit, please contact me at [phone] or e-mail
[e-mail].
T
NS � heck one)
Concur with the issuance of this permit provided the facility is operated and maintained properly, the stated
effluent limits are met prior to discharge, and the discharge does not contravene the designated water quality
standards.
❑ Concurs with issuance of the above permit, provided the following conditions are met:
❑ Opposes the issuance of the above permit, based on reasons stated below, or attached:
F
N�os�`lrCaro ina
�vatura27
North Carrohna Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Internet: www.ncwatercluaiity.org Location: 512 N. Salisbury St. Raleigh, NC 27604 Fax [phone]
An Equal OpportunWAffirmative Adion Employer —50% Recyded/10% Post Consumer Paper

Winston-Salem Journal
Advertising Affidavit
Winston-Salem Journal
P.O Box 3159
Winston-Salem, NC 27102
NCDENR/DWQ/POINT SOURCE BRANCH
ATTN: DINA SPRINKLE
1617 MAIL SERVICE CENTER
RALEIGH, NC 27699-1617
Account Number
3376309
Date
January 16, 2009
Date Category Description Ad Size Total Cost
01/16/2009 Legal Notices PUBLIC NOTICE STATE OF NORTH CAROLINA EN 2 x 167 L 1,108.59
PUBLIC NOTICE
STATE OF NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT
COMMISSION/NPOES UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NC 27699-1617
NOTIFICATION OF INTENT TO ISSUE
A NPDES WASTEWATER PERMIT
On the basis of thorough staff review and appllea-
tion of NC General Statute 143.215.1 and 15A NCAC
02H.0309 and other lawful standards and regula-
tions, the North Carolina Environmental Manage-
ment Commission proposes to issue a National
Pollutant Discharge Elimination System (NPDES)
wastewater dischargge permit to the person(s) list-
ed below effective 45 days from the publish delta of
this notice.
Written comments regarding the proposedp ermit
will be accepted until 30 days after the publish date
of this notice. All comments received prior to that
date are considered in the final determinations
regarding the proposed permit. The Director of the
NC Division of Water Quality may decide to hold a
Public meeting for the proposed permit, should
the Division receive a significant degree of public
Interest.
of the draft permit and
Ion on file used to deter
in the draft permit are
and payment of the costs
en no pours or o:uu a.m. ana
5:00 p.m. to review information onfile.
Media General Operations, Inc.
Publisher of the
Winston-Salem Journal
Forsyth County
Before the undersigned, a Notary Public of Forsyth County, North Carolina, duly
commissioned, qualified, and authorized by law to administer oaths, personally appeared
D.H. Stanfield, who by being duly sworn deposes and says: that he is Controller of the
Winston-Salem Journal, engaged in the publishing of a newspaper known as Winston-Salem
Journal, published, issued and entered as second class mail in the City of Winston-Salem, in
said County and State: that he is authorized to make this affidavit and sworn statement: that
the notice or other legal advertisement, a true copy of which is attached hereto, was
published in the Winston-Salem Journal on the following dates:
01/16/2009
and that the said newspaper in which such notice, paper document, or legal advertisement
was published was, at the time of each and every such publication, a newspaper meeting all
the requirements and qualifications of Section 1-597 of the General Statutes of North
CBTefina and was a qualified newspaper—w—RUG the meaning of Section 1-597 of the General
Statutes of North Carolina.
orth North
hCarinIn&(wnLa ML Ala. Carolina,
forrenewal of
Permit NCO089536 for the Bannertown Hills Subdivl- ThIS 16th day Of January, 2009
sion - Well #21n Surry County. This permitted facili-
W discharges 1600 gallons per day of greensand
liter backwash water to an unnamed tributary to
Faulker Creek within the Yadkin -Pee Dee River Ba.
sin. Total Suspended Solids (TSS) and total residual
chlorine are currently water quality limited. This
discharge may affect future allocations in this por.
lion of the Faulkner Creek.
Aqua North Carolina, Ina. (Lois Lane, ML Airy, North
Carolina) has applied for renewal of NPDES Permit
NCO089625 for the Hollows Subdivision - Well #1
in Sorry County. This permitted facility discharges
2000 gallons per day of greensand filter backwash
water to an unnamed tributary to Stewarts Creek
within the Yadkin -Pee Dee River Basin. Total Sus-
pended Solids (TSS) and total residual chlorine are
currently water Panty limited. This discharge may
affect future allocations In this portion of the
Stewarts Creek.
Aqua North Carolina, Inc (4163 Sinclair Street Den-
ver. NC, 28037) has applied for renewal of NPDES
Permit NCO088552 for the Colonial Woods Subdivi.
sion Well #2 in Surry County. This permitted faclllty
will discharge treated filter backwash to UT to Bull -
Creek in the Yadkin -Pee Dee River Basin. Currently
total suspended solids and total residual chlorine
are water quality limited. This discharge may affect
future allocations In this portion of the Yadkin -Pee
.Dee River Basin.
(signature ojperson making a rdavit)
Sworn to and subscribed before me, this 16th day of January,
My Commission expires &Ali•aLY I
THIS IS NOT A BILL. PLEASE PAY FROM INVOICE. THANK YOU

Aqua North Carolina, Inc (4163 Sinclair Street, Den-
ver, NC, 28D37) has applied for renewal of NPDES
,emit NCO088528 for the Hlllcrest Subdivision Well
#3 in Surry County. This permitted facility will dis-
charge treated filter backwash to UT to Champ
Creek in the Yadkin -Pee Dee River Basin. Currently
total suspended solids and total residual chlorine
are water quality limited. This discharge mayy affect
future allocations in this portion of theYadkin-Pee
Dee River Basin.
280371 hasl applied for Sinclair
newalt of NPDES Denver,
mt
NCO088617 for the Snow Hill Subdivision Well #1 In
Sorry County. This permitted facility discharges
0.0026 MGD of treated wastewater to an unnamed
tributary to Cody Creek in the Yadkin -Pee Dee River
Basin. Currently total residual chlorine is water
quality limited. This discharge may affect future
allocations in this portion of the Yadkin -Pee Dee
River Basin.
Central Care, Inc (139 Apex Lane, Mount Airy, NC,
270307 has applied for renewal of permit NCO
for for its WWTP in Surry County. This permitted facili-
ty discharges treated domestic wastewater to an
unnamed tributary to Stewarts Creek in the Yadkin
Pee Dee River Basin. Currently ammonia nitrogen.
fecal colifom and total residual chlorine are water
quality et uture
llotl s in his portion of Stwam Creek.
Aqua North Capella Inc has appplietl for renewal of
NPDES permit, number NC0088633, for the Reeves
Woods Subdivision Well #2 WTP near Mount Airy
in Surry County. The facility dischargges filter back-
wash water into an unnamed tributarryy in the
Yadkin River Basin. The new permit sets TSS, Total
Residual Chlorine, and pH as water quality limited
parameters. This discharrgge may effect future allo-
cations in this portion of the Yadkin River Basin.
Aqua North-C mRnq Irle has -applied for renewal of
its discharge perm it NCO083925 for Salem Glen
Subdivision WWTP. This facility discharges treated
wastewater to the Yadkin River in the Yadkin -
Pee Dee River Basin. Currently SODS, Ammonia as
Nitroggen, Total Residual Chlorine, Total Nihogen
and TPlat Phosphorous are water quality lotted.
This discharge may impact future allocation of this
resource.
Aqua North Carolina, hats. (Stonington Way Court,
Kemersvdle, North Carolina) has applied for renew-
al of NPDES Permit NCOOM501 for the Stonington
Subdivision - Well #1 in Forsyth County. This per-
mitted facillyt discharges 2100 gallons per day of
greensand 1 ter backwash water to an unnamed
Mbutary to Abbotts Creek within the Yadkin -Pee
Dee River Basin. Total Suspended Solids (TSS) and
total residual chlorine are currently water quality
limited. This discharge may affect future alloca-
tions in this portion of the Abbots Creek
The Roaring Gap club, has (P.O. Box 129, Roartn
GlwN NC00389)97 or thei RoamgfeGapw Club WWTP
Pn Wilkes County. This permitted facility discharges
treated domestic wastewater to the unnamed Crib.
utary to the Mitchell River in the Yadkin -Pee Dee
River Basin. Currently SOD.total suspended solids.
fecal colifom and total residual chlorine are water
qualitylimited. This discharge may affect future
allocations in this portion o the Yadkin -Pee Dee
River Basin.
The Town of North Wilkesboro. P.O. BOX 218. North
Wilkesboro North Carolina, 28659, has applied
for renewal of its permit, North Wilkesboro - Thur-
man St. Wastewater Treatment Plant - NPDES No.
NC0020761, discharging treated municipal waste-
water to the Yadkin River in the Yadkin River Basin.
Ammonia, fecal coliform, and residual chlorine are
water duality limited. This discharge may affect
future discharges in this portion of the basin.
WSJ: January le. 2009

AQUA
North Carolina..
Mrs. Dina Sprinkle
NC DNER/DWQ/Point Source Branch
1617 Mail Service Center
Raleigh, NC 27699-1677
SUBJECT: NPDES Renewal Application
Salem Glen Subdivision
Aqua North Carolina, Inc.
4163 Sinclair Street
Denver, NC 28037
June 2, 2008
NPDES Permit No. NC0083925
Davidson County, NC
Dear Mrs. Sprinkle:
T: 704.489.9401
F: 704.489.9409
www.aquanorthcarol ina.com
RECEIVED
JUN - 6 2008
DENR - WATER QUALITY
POINT SOURCE BRANCH
Transmitted herewith are the completed/signed originals and two copies each of the subject
NPDES permit application and sludge management plan. Also attached are two copies of this
cover letter.
There have been no major modifications to the wastewater treatment facility since issuance of
the last permit. However, Aqua NC still anticipates expansion of this facility and therefore
requests that the renewed permit contain the same language regarding this matter as is in the
current NPDES permit. The current permit provides for expansion to 0.2 MGD (upon approval
of an authorization to construct) and sets forth effluent limitations for the expanded facility. It is
my understanding that no filing fee is required for this renewal.
If you have questions regarding this application, please do not hesitate to contact me.
Si I
jcL '
Thomas R,Pferts
An Aqua America Company

A '006'
UUA.
North Carolina
SLUDGE MANAGEMENT PLAN
for
Aqua North Carolina, Inc. (Western Region -High Point)
No sludge will be treated on any wastewater treatment plant site operated by
Aqua North Carolina, Inc.
Where practical, sludge removal from Aqua North Carolina West facilities will be
transported via a contract hauler to another Aqua North Carolina West facility for
the purpose of "seeding" a new or under -loaded plant when there is a need for
such.
Unusable (or "dead") sludge will be removed by a permitted/licensed contract
hauler and properly disposed of in accordance with NCGS 143-215.1. Contract
haulers used by Aqua North Carolina West will be required to report, via a
sludge -hauler .manifest, the quantity of sludge transported and identify the
location of the proposed disposal site if the sludge is not taken to an existing
plant operated by Aqua North Carolina West. Aqua North Carolina West has not
entered into any agreement to accept sludge into its facilities from plants not
owned by them and have no intentions of doing so.
Aqua North Carolina West will keep records on the quantity of sludge removed
from each facility, the name of the contract hauler, and the destination of the
sludge (whether used in another plant or disposed of). The information will be
kept on file and will be made available to any regulatory agency having
jurisdiction over sludge treatment or disposal.
Aqua North Carolina West includes all of the facilities under the jurisdiction of the
Winston-Salem Regional Office.