310503_Application_20240220

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non-Discharge General Permit
On September 30, 2024, the North Carolina State Non-Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non-Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. 'Therefore,all applications
must be received by the Division of Water Resources by no later than April 3,2024.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Certificate Of Coverage Number: AWS310503
2. Facility Name: Butch Norman Farm
3. Permittee's Name(same as on the Waste Management Plan): Butch W Nonnan
4. Permittee's Mailing Address: PO Box 38
City: Rose Hill State: NC Zip: 28458-0038
Telephone Number: 910-289-2054 Ext. E-mail: normanann i4mail.com
5. Facility's Physical Address: 1155 Pasture Branch Rd
City: Rose Hill State: NC Zip: 28458
6. County where Facility is located: Duplin
7. Farm Manager's Name(if different from Landowner):
8, Farm Manager's telephone number(include area code):
9. Integrator's Name(if there is not an Integrator,write "None"): Murphy-Brown LLC
10. Operator Name(OIC): Butch W.Norman Phone No.: 910-289-8809 OIC#: 17257
11. Lessee's Name(if there is not a Lessee,write"None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Swine-Feeder to Finish 4,896
Operation Types:
Swine Cattle Dry Poultry Other Tvnes
Wean to Finish Dairy Calf Non Laying Chickens Horses-Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses-Other
Farrow to Finish Milk Cow Pullets Sheep-Sheep
Feeder to Finish Dry Cow Turkeys Sheep-Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultn,
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment Lagoons,Digesters and Waste Storage Ponds(WSP): (Fill/Verify the following information.
Make all necessary corrections and provide missing data.)
Structure Type Estimated Liner Type Estimated Design Freeboard
Structure (Lagoon/Digester/ Date (Clay,Synthetic, Capacity Surface Area "Redline"
Name WSP) Built Unknown) (Cubic Feet) (Square Feet) (inches)
1 Lagoon 8/1/1997 Full,clay 1,135,062.00 130,680.00 19.50
Submit one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed
application as required by NC General Statutes 143-215.1OC(d), either by mailing to the address below or sending it via
email to the email address below.
The CAWMP must include the following components:
I. The most recent Waste Utilization Plan(WUP),signed by the owner and a certified technical specialist,containing:
a. The method by which waste is applied to the disposal fields(e.g.irrigation,injection,etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation(RYE)for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2, A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted-Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation(design,calculations,etc.) Please be sure the above table is
accurate and complete. Also provide any site evaluations,wetland determinations,or hazard classifications that may be
applicable to your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g.composting,digesters,solids separators,sludge drying system,waste transfers,etc.)
I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included,this application package will be returned to me as incomplete.

Note: In accordance with NC General Statutes 143-215.6A and 143-215.613, any person who knowingly makes any false
statement, representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18
U.S.C.Section 1001 provides a punishment by a fine of not more than$10,000 or imprisonment of not more than 5 years,or both
for a similar offense.)
Print the Name of the Perm ittee/Lan downer/Signing Official and Sign below. (If multiple Landowners exist,all landowners
should sign. If Landownnterr,is a�corporation, signature should be by a principal executive
�4—
officer of the corporation):
Name(Print): ,Q���`' 'C i'�'b'� Title: LV WVVI `
Signature: �� , V�1 u t t `r N�rrf/1�Q _ Date: Zl f C 4 q
Name(Print): Title:
Signature: Date:
Name(Print): Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
E-mail: [e-mail]
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699-1636

ROY COOPERx��'
Governor
y
ELIZABETH S.BISER
Secretary
RICHARD E.ROGERS,JR. NORTH CAROLINA
Director Environmental Quality
February 12,2024
Butch W Norman
Butch Norman Farm
PO Box 38
Rose Hill,NC 28458-0038
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non-Discharge General Permits,
which expire on September 30, 2024. In order to ensure your continued coverage under the State Non-Discharge General
Permits,you must submit an application for permit coverage to the Division of Water Resources (DWR)by April 3,2024.
Enclosed you will find a "Request for Certificate of Coverage for Facility Currently Covered by an Expiring State
Non-Discharge General Permit."The application form must be completed,signed by the Permittee,and returned to the DWR by
Anril 3.2024.
Mailing Address: NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699 1636
Email:animal.oi)[e-mail]
phone:[phone]
Please note that You must include one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with the
completed and slatted application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NC G.S. § 143-215.1
and could result in assessments of civil penalties of up to$25,000 per day.
Copies of the animal waste operation State Non-Discharge Generai Permits are available at
www.deg.nc.p-ov/animalpermits2024.General permits can be requested by writing to the address above.
If you have any questions about the State Non-Discharge General Permits,the enclosed application,or any related matter please
feel free to contact the Animal Feeding Operations Branch staff at 919-707-9129.
Sincerely,
Michael Pjetraj, Deputy Director
Division of Water Resources
Enclosures: Request for Certificate of Coverage for Facility Currently Covered by an Expiring State Non-Discharge
General Permit
North CarolinaDtpartmentofEnrironmtutalQuaVtr Division ofWattrRtsources
3 $12 North Salisbury Strml 1636111all Strrict Ctuttr Raltiah,North Carolina 21699.1636
919.1079129

50
31— �) Version—November 26,2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should beat least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
a A composting system approved and permitted by the NC Department of Agriculture&Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off-farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm-specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Signature of Farm Owner/Manager Date
N� 3 -16i
Signature of Technical Specialist Date

INSECT CONTROL CHECKLIST FOR ANIMAL OPERATIONS
Source Cause BMP's to Minimize Odor Site Specific Practices i
(Liquid Systems)
Flush Gutters Accumulation of solids ( Flush system is designed and operated
sufficiently to remove accumulated
solids from gutters as designed.
(K) Remove bridging of accumulated solids at
discharge
Lagoons and Pits Crusted Solids i t.Maintain lagoons,settling basins and
pits where pest breeding is apparent to
minimize the crusting of solids to a depth
of no more than 6-8 inches over more than
30%of surface.
Excessive Decaying vegetation(✓)Maintain vegetative control along banks of
Vegetative Growth lagoons and other impoundment's to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
(Dry Systems)
Feeders Feed Spillage () Design,operate and maintain feed systems(e.g..
bunkers and troughs)to minimize the accumulation i
of decaying wastage.
{) Clean up spillage on a routine basis(e.g.7-10 day
interval during summer;15-30 day interval during winter).
Feed Storage Accumulation of feed {} Reduce moisture accumulation within and around
residues immediate perimeter of feed storage areas by
insuring drainage away from site and/or providing
adequate containment(e.g.,covered bin for
brewer's grain and similar high moisture grain
products).
(} Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed.
Animal Holding Accumulation of animal () Eliminate low area that trap moisture along fences
Areas wastes and feed wastage and other locations where waste accumulates and
disturbance by animals is minimal.
() Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e.inspect for and remove or break up accumulated
solids as needed).
MIC--November 11,1996
10

Dry Manure Handling Accumulations of animal (}Remove spillage on a routine basis(e.g.7-10 day
Systems wastes interval during summer;15-30 days interval during
winter)where manure is loaded for land application I
or disposal.
()Provide for adequate drainage around manure stockpiles
(}Inspect for and remove or break up accumulated wastes
in filter strips around stockpiles and manure handling
areas as needed.
The issues checked ( } pertain to this operation. The landowner 1 integrator agrees to
use sound judgment in applying insect control measures as practical.
I certify the aforementioned insect control Best Management Practices have been j
reviewed with me.
(Landowner Signature)
For more information contact the Cooperative Extension Service, Department of Entomology, Box
7613, North Carolina State University, Raleigh, NC 27695-7613.
AMIC -- November 11, 1996
11

Grower: Butc lorman [phone] Designed By: JWR
Address: P.O. Box 38 Checked By: JES
Rose Hill, NC 28458 Date: 08/01/97
County: Du fin Sheet 1 of 7
ANAEROBIC WASTE LAGOON DESIGN
FARM INFORMATION
Farm Population:
Nursery: —_—___----__---____
0
Finishing: —.—__w__._.-------___— 4896 Hd.
Farrow to weanling: ---------_---_----____ 0
Farrow to feeder: --.---___—____--_—__ 0
Farrow to finish: —------------ __—__—__ 0
Boars: _��.__-_...__ 0
Storage Period: ———————————— —————— 180 Days
25Yr. / 24 Hr Storm Event ----_—_—__—---______ 7.5 In.
"Heavy Rain" Factor Not Applicable
Rainfall in Excess of Evaporation --—--________________ 7.0 In.
Additional Water Usage: --._—__.�____—___—___ 0
Additional Drainage Area: -----__—__—___.-_____ 0
LAGOON INFORMATION
Is Lagoon Designed as an Irregular Shape? (Y/N) -- -------Y
Does Operator Want Emergency Spillway? (Y/N) ——______——N
Is This Design for an Existing Farm? (Y/N) ------——--——_——Y
Is Drain Tile Req'd to Lower SHWT? (Y/N) —______—_—N
Seasonal High Water Table Eiev: _____________ 48.00 Ft.
Freeboard: __-------- ———————— 1.0 Ft.
Emergency Spillway Flow Depth: Not Applicable 0
Top of Storm /Spillway Buffer: Not Applicable 0
Side Slopes: --________________--- 3 :1 (H:V)
Press ALT—C to Download
contour areas see sheet 2 of 7...
Top of Dike Elevation: ----__---_--.-__-----_ 54.80 Ft.
Finished Bottom Elevation: _----_- --_-_____.-__.- 41.80 Ft.
Start Pump Elevation: -- ------_-__--_-____- _ 53.00 Ft.
Stop Pump Elevation: ----------- --_-___..--_ 49.50 Ft.
LAGOON VOLUME REQUIREDVOL. DESIGN VOLUMES % REQ'D.
Storm Stor = 77262 (Cu.Ft.) 94,321 (Cu.Ft.) 122.08%
Temporary= 339558 (Cu.Ft.) 378,520 (Cu.Ft.) 111.47%
Permanent = 660960 (Cu.Ft.) 662,221 Cu.Ft. 100.19%
Total Volume = 1,077,780 (Cu.Ft.) 1,135,062 (Cu.Ft.) 105.31%
Min. Required Liner Thickness ----_________________ **
Lagoon Surface Area: (insideTOD) ------------------------ 123,619S.F.
"Liner shall be equal to the 40 Mil GSE HDPE Liner as manufactured by GSE Lining
Technolo lnc. Houston' Texas.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

lGrowev: Buts' Norman [phone] Designed By: JWR
Address: P.O. pox 38 Checked By: JES
Rose Hill, NC 28458 Date:
Count : Du lin 08/01/97
Sheet 2 of 7
ACTUAL DESIGN VOLUME CALCULATIONS
LAGOON STAGE-AREA VOLUMES_
Contour
Elevation (FTJ Area SF
41.8071,540 lncr. Vol. Cu. FT Cumul. Vol. Cu. FT
42.00 72,254 14,379 9
,37
43.00 75,865 74,060 14 14,379
44.00 79,543 77,704 166,143
45.00 83,290 81,417 247,559
46.00 87,106 85,198 332,757
47.00 90,989 89,048 421,805
48.00 94,940
49.00 98 960 92'965 514,769
,
96,950 611,719
50.00 103,048 101,004 712,723
51.00 107,204 105,126 817,849
52.00 111,429 109,317 927,166
53.00 115,721 113,575 1,040,741
54.00 120,082 117,902 1,040
54.80 123,619 97,480 1,158, 42
, 42
23
These volumes were calculated usin�c the vcrtic<:�f aver _e end area method.
y�70TAL HEC D VOLUME-11,077,780 CF CUM II !kTIVE VOL. ZONE VOL 105.31%
END PUMP = = = _ > 49.50 FT 662,221 CF TR'MT 662,221 i00.19%
START PUMP = ; _ > 53A0 FT 1,040,741 CF TEMP 378,520 111.47%
MAX STORAGE - _ > 53.80 FT 1j135,062 CF STORM 94 321 122.08%
Murphy Family Farms Engineering �p p j Box 759, Rose HX NC 28458
[phone]

F
Butcl Norman (910) 289-�2365 DesignedBy P.O. t)ox 38 Checked By: JNT
Rose Hill, NC 28458 ®ate: 08/01/97
Du linSheet 3 of 7
MINIMUM REQUIRED VOLUME CALCULA.TIOINS
nt Stora e:
red Treatment Volume:
Animal Tvpe Capacity�* ALW * cu.ft. Ib Total
Nurse 0 30 1.04 0
Finishing 4,896 135 1.00 660,960
Farrow to wean ling 0 433 1.00 0
!°arrow to feeder _— 0 522
Farrow to finish 0 1,417 1 00 0
Boars 0 400 1.0p 0
Total Required Treatment Volume (cu. ft.)= 660,960
Sludge Storage Volume:
Animal Moe 7iqci * ALW * cu.ft. ib = Total
Nursery_` p 30 0.00 0
Finishin 96 135 0.00 p
Farrow to weanIin 0 433 0.00 p
Farrow to feeder 0 522 0.00 p
Farrow to finish 0 _ 1,417 0 00 0
Boars 0 400 0,0001 0
Total Required Sludge Storage Volume (cu. ft.)= 0
Temporary Storage Volume:
Manure Production:
[Animal e a aci to. eno * a s a = ota
ursery 0 180 0.30 0
Fin ish i n 4,896 180 1.37 1,207.354
Farrow to wean lin 0 180 4.39 0
Farrow to feeder ----0 180 9.30 0
Farrow to finish 0 180 14.38 0
Boars 0 180 4 p6 0
Total Manure Production (gals.)= 1 207 354
Total Manure Production (cu.ft.)= 161,411
Excess Fresh Water:
Animal T e Capacity * Sto. Period * als Hd. da = Total
Nurser
y 0 180 0.20 0
Finishin 4,896 180 0.90 793,152
Farrow to wean Iing 0 180 2.90 0
Farrow to feeder _ 0 180 3.50
w 0
Farro to finish ----
Boars 0 180
2 70
Total Fresh Water Excess als = 0
-
31152
Total Fresh Water Excess (cu.ft.)= - 106,036
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

Grower But& 'Norman (910) 289--2365 Designed By: JWR
Address: P.O. pox 38 Checked By: JES
Rose Hill, NC 28458 Date: 08/01/97
County: Du lin Sheet 4 of 7
Te p_ ra torage Volume: Cont.)
Rainfall in Excess of Evaporation;
Vol,=(Lagoon Surface Area + Additional Drainage Area) * Rainfall / 12in./ft
Vol,= (123619 sq.ft, + 0 sq.ft,) * 7 in. /12 in./ft.
Total Required Volume for Rainfall in Excess of Evap. (cu.ft.)= 72,111
Storm Storage:
Vol,—(Lagoon Surf. Area + Addt'I Drainage Area) * 25Yr./24Hr. Storm(in) / 12in./ft.
Vol.= (123619 sq.ft + 0 sq.ft.) * 7.5 in. /12 in./ft.
Total Required Volume for 25Yr.-24Hr. Storm Event (cu.ft)= 77,262
"Heavy Bain" Storage:
Vol,=(Lagoon Surf. Area + Addt'I Drainage Area) * "Heavy Rain" Factor (in) / 12in./ft.
Vol.= (123619 sq.ft + 0 sq.ft.) * 0.0 in. /12 in./ft.
Total Required Volume for "Heavy Rain& (cu.ft.) = 0
(for Extended Periods of Chronic Rainfall)
Additional Water Storage:
No Additional Water Storage is Required
Total Required Storm Storage
(25 Yr. / 24 Hr. Storm + "Heavy Rain") = 77,262 (CU.FT)
Total Required Temporary Storage
(Manure Prod, + Excess Fr. Water + Rainfall Excess) = 339,558 (CU.FT)
Total Required Permanent Storage
(Treatment + Sludge) = 660,960 (CU.FT)
TOTAL REQUIREDVOLUME= 1077780 (CU.FT.)
p Y Y Engineering e NiUNC.28458.," [phone]
Mur h Famil Farms gn ineenn :.�.y P.Q.:Box-759;�Rose

Grower: Butc' orman [phone] Designed By: JWR
Address: P.O. Lox 38 Checked By: JES
Rose Hill, NC 28458 Date: 08/01/97
Count : Du iin Sheet 5 of 7
LAGOON DESIGN SUMMARY
Top of Dike Elevation ------------------- 54.80 FT.
Emergency Spillway Crest Elevation---------._____--___- Not Applicable
Top of 25 yr/24 hr Storm Storage ----- --.-..-_._..___-- _ - 53.80 Fr.
Top of "Heavy Rain" Storage ---- ________________ Not Applicable
Start Pump Elevation ------------____----- 53.00 FT.
End Pump Elevation ------------------- 49.50 FT.
Top of Sludge Storage ___________________ Not Applicable
Seasonal High Watertable Elev. --- - ___..-_-----_---- 48.00 Applicable
Finished Bottom Elevation .------------------- 41.80 FT.
Inside Top Length -------------__--__-.- Not Applicable
Inside Top Width ------------------- Not Applicable
Side Slopes ___________________ 3:1 H:V
Lagoon Surface Area ___________________ 123,619 SF
Min. Liner Thickness (if required) ------_-__.---__-_---_ **
Freeboard Depth - ------------ -_
Temporary Storage Period ----------__--__ 1'00 FT'
___-_-_ 180 Days
TOTAL DESIGN VOLUME = 1135062 (CU.FT.)
"Liner shall be equal to the 40 Mil GSE HDPE Liner as manufactured by GSE Lining
Technology, Inc., Houston, Texas.
Zone De ths:
Treatment/ Sludge Storage Zone Depth --------___- 7.7 FT.
Temporary Storage Zone Depth -------_____._ 3.5 FT.
Freeboard / Storm Storage Zone Depth ----------_ 1.8 FT
Total Lagoon Depth -----------_ 13.0 FT.
Murphy Family Farms Engineering '" P.0. Box 759, Rose Hill NC 28458
[phone]

GROWER: Buts Norman [phone] DESIGNED BY: JWR
ADDRESS: P.O. jox 38 CHECKED BY: JES
Rose Hill, NC 28458 DATE: 08/01/97
COUNTY: Du lin SHEET 1 OF 2
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) and 180 days of
temporary storage. The time required for the planned fluid level (permanent and
temporary storage) to be reached may vary due to site conditions, weather, flushing
operations, and the amount of fresh water added to the system.
The designed temporary storage consists of 180 days of temporary storage for:
(1) manure production of animals, (2) excess fresh water storage, (3) rainfall in
excess of evaporation, (4) storage for the 25 year/24 hour storm for the location,
(5) and, if applicable, an additional "heavy rain" storage volume for chronic rainfall
events. Allocation for any additional fresh water usage is also included in the
temporary storage. The volume of waste generated from a given number of animals
will be fairly constant throughout the year, but excess rainfall will vary from year to year.
The 25 year rainfall will not be a factor to consider in an annual pumping cycle, but
this storage volume must always be available.
A staff gauge must be installed in the lagoon that indicates the start pumping and stop
pumping levels. The start pumping level is the maxium liquid level under normal operating
conditions. The stop pumping level is the minimum liquid level under normal
operation to maintain required treatment volume and depth. Pumping can be started
and stopped anywhere between these two elevations for operating convenience as site
conditions permit, such as weather, soils, crop, and equipment in order to apply waste
without runoff or leaching. However, it is recommended that the lagoon be kept
pumped down as much as possible.
Land application of wastewater is recognized as an acceptable method of disposal.
Methods of application include solid set, center pivot, guns, and traveling guns. Care
should be taken when applying waste to prevent damage to crops or runoff to surface
waters.
The following items are to be carried out:
1. It is required that the treatment lagoon be precharged to one—half the treatent volume
or as otherwise specified on the lagoon design drawings before wastes are introduced.
The purpose is to prevent excessive odors during start-up. Precharging reduces the
concentration of the initial waste entering the lagoon thereby reducing odors. Solids should
be covered with effluent at all times. When precharging is complete, flush buildings with
recycled lagoon liquid. Fresh water should not be used for flushing after initial filling.
2. The attached Waste Utilization Plan shall be followed. The plan recommends
sampling and testing of waste before land application.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28453 [phone]

GROWER: Buts-' Norman [phone] DESIGNED BY: JWR
ADDRESS: P.O. oox 38 CHECKED BY: JES
Rose Hill, NC 28458 DATE: 08/01/97
COUNTY: Duplin SHEET 2 OF 2
3. Begin temporary storage pump—out of the lagoon when the fluid level reaches the
elevation 53.00 as marked by the staff gauge. Stop pump--out when the fluid level
reaches elevation 49.50. This temporary storage, less 25 year /24 hour storm,
contains 378520 cubic feet or 2831326 gallons.
4. The recommended maximum amount to apply per irrigation is one (1) inch and the
recommended maximum application rate is 0.3 inches per hour. Refer to the waste
utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the lagoon mowed
annually. Vegetation should be fertilized as needed to maintain a vigorous stand.
6. Repair any eroded or damaged areas and establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around waste utilization
fields adjacent to perennial streams. Waste will not be applied in open ditches.
Do not pump within 200 feet of a residence or within 100 feet of a well. Waste shall
be applied in a manner such that waste will not reach other property or public
rights—of—way.
9. The Clean Water Act of 1977 prohibits the discharge of pollutants into waters
of the United States. Waste shall not be discharged into surface waters, drainageways,
or wetlands by either discharge or by over—spraying. The Department of Environment,
Health, and Natural Resources, Division of Water Quality, has the responsibility
for enforcing this law.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

`k .-��r .��{} T+.;.t�y♦s ,,'♦ {` .. ,�'#: f t- i,f; rr„�d .►�1 � t.,.
`,r„ �"��� ��`r t: LSJ .� � .Y A�a'J � .r • � r `a: . M f. f„p '
;1. a�• �f� ��['�.�t'� "a 'r ♦i_'t. a .lr �; � �:r f - � ' J,'
��#
x�wl -Air I
{. i• �' S�♦4 �.'T'1 t''t i- i ry �- '1
.'A :.VA it •2 tit.t :`�./a., r :,Y .•:'Ja!• /{a i'ir • J4 1.1 s r • .•
*" •l r SyaW, �, 4 ., ,,,,,�s ;' � �- - ,{ f ,•j t r r./ .' r � � ': Pc
1 v�� -s �♦� ,a a a •t � •,t f' r (,. - ..•..<d .err �.
fT ♦\S vJ,ii�'4" 'FYI �!�„t�.. !''!. 'ti"'�r�'yJar -7'�Lt. a r 1 i�a `I !l t ] 1 i. '�'il' .._\ .:
�, r't. _ \,Js J'• 77
1�c- {�''�Q :QV [' J - ♦ f a f r-.{S .
\� r- ! ! 1 1 r a J jt •/ C/1ft ..
�� t r ?'v 'a•urt W�l ' rr i �.:� /.•� r a a .f t' f f l ', _irYl' ai!
f ..f a t tf" ti - i�♦ a�' j�! (r]1 �t+,��r r r � :A
{�i•,S /.S( � a �� + .K, t ryr,t. fie.
ol
41
'i�i ♦ r
x'�Y1
t a"�s+ � i ids r.•'' f�;{t,.� �,4.. 5 - r
7t{�1,•• 3` _ rr \� jhw
,
t�
y; ��, , j 1 � \r,T •]k,s ,
t 't
� y
t °�A ��n a��J•,'�.Tr ♦a `« y'� M `'f.��r c}���t�,!_a+� '3a"1�3.`�,i1,* iF' "yr���.�1;
ik",
':tat f V ,�!•' .r `a t-y.. r���uRJ�,�. +�� ., �'.�
-Ti: F':,. -� •+ +�' Y �� fit.. 1,}`�1 - tf �i6�rA "�'��fr.f„'
Y. '•��t'y �,�.�+• - '�y '\ t 1 �1�, t'`•��,�r• � �'��tj1��,•53^ CIF [
•� P. � 1 a tr v - � +i�� rYK t' `S�• t� Y� � ,lC� ���'aa7ci�li
I,)! 4• ',.,r1 .\ \k.. ��' C }�i '.w,'T,n•t � � �: ,fir, ty7 �' a y �
� yyl(j { `£., '`,:;;yy: �,-J - '� ,.`•t,f �]�,-,+t4 n'ti>>. �. i ,,,6 ����l��A i5'i,

EMERGENCY ACT�OH PLAN
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ)
EMERGENCY MANAGEMENT SERVICES (EMS)
SOIL AND WATER CONSERVATION DISTRICT (SWCD)
NATURAL RESOURCES CONSERVATION SERVICE (MRCS) 117 �o 3
COOPERATIVE EXTENSION SERVICE (CES)
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem. You should make every effort
to ensure that this does not happen. This plan should be posted in an accessible
location for all employees at the facility. The following are some action items you should
take.
1. Stop the release of wastes. Depending on the situation,this may or may not be possible. Suggested
responses to some possible problems are listed below.
A. Lagoon overflow- possible solutions are:
a) Add soil to berm to increase elevation of dam.
b) Pump wastes to fields at an acceptable rate.
c) Stop all flow to the lagoon immediately.
d) Call a pumping contractor.
e) Make sure no surface water is entering lagoon.
B. Runoff from waste application field-actions include:
a) immediately stop waste application.
b) Create a temporary diversion to contain waste.
c) Incorporate waste to reduce runoff.
d) Evaluate and eliminate the reason(s)that cause the runoff.
e) Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers-action include:
a) Stop recycle pump.
b) Stop irrigation pump.
c) Close valves to eliminate further discharge.
d) Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators-action include:
a) Stop recycle pump.
b) Stop irrigation pump.
c) Make sure siphon occurs.
d) Stop all flow in the house, flush systems, or solid separators.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing leaks -
possible action:
a) Dig a small sump or ditch from the embankment to catch all seepage, put in a submersible
pump, and pump back to lagoon.
b) If holes are caused by burrowing animals,trap or remove animals and fill holes and
compact with a clay type soil.
8

s
The application of sludge will increase the amount of odor at the waste application site.
Extra precaution should be used to observe the wind direction and other conditions
which could increase the concern of neighbors.
Possible Causes of Lagoon Failure
i
Lagoon failures result in the unplanned discharge of wastewater from the structure.
Types of failures include leakage through the bottom or sides, overtopping, and breach
of the dam. Assuming proper design and construction, the owner has the responsibility
for ensuring structure safety. Items which may lead to lagoon failures include:
o Modification of the lagoon structure -- an example is the placement of a pipe in the
dam without proper design and construction. (Consult an expert in lagoon design
before placing any pipes in dams.)
© Lagoon liquid levels -- high levels are a safety risk.
• Failure to inspect and maintain the dam.
• Excess surface water flowing into the lagoon.
• Liner integrity -- protect from inlet pipe scouring, damage during sludge removal, or
rupture from lowering lagoon liquid level below groundwater table.
NOTE: If lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the dam. Once this damage starts, it can quickly cause a large
discharge of wastewater and possible dam failure.

i
c) Have a professional evaluate the condition of the side walls and the lagoon bottom as soon
as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger(either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone #, After hours,
emergency number: [phone]. Your phone call should include: your name, facility
number, telephone number, the details of the incident from item 2 above, the exact
location of the facility, the location or direction of the movement of the spill, weather and
wind conditions. The corrective measures that have been under taken, and the
seriousness of the situation.
b. If the spill leaves property or enters surface waters, call local EMS phone number.
C. Instruct EMS to contact local Health Department.
d. Contact CE's phone number, local SWCD office phone number and the local NRCS
office for advice /technical assistance phone number.
4. If none of the above works call 911 or the Sheriff's Department and explain your problem to
them and ask the person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair or problem to minimize offsite damage.
a. Contractors Name: T>6LO G( y fiV�SV�t
b. Contractors Address:
c . Contractors Phone:
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting Engineer, etc.)
a. Name:
b. Phone:
7. Implement procedures as advised by DWQ and technical assistance agencies to rectify
the damage, repair the system, and reassess the waste management plan to keep
problems with release of wastes from happening again.
9

Swine Farm Waste Management Odor
Control Checklist Permit No.: A v/S31C0
Date: RC)3y
INSTRUCTIONS FOR USE Owner Signature:
♦ Odor Control Checklist is required by General Statute 143-215.10C(e)(1)
♦ Check any/all the BMPs you will implement on this facility. Items checked/selected become a requirement of the CAWMP.
♦ Items in bold or pre-selected are required.
♦ Add any site-specific details related to the selected BMPs
♦ Include any other odor control measures not listed
♦ NOTE: Not all BMPs may be cost-effective for every facility. Evaluate each BMP prior to selecting for your facility.
Cause/Source BMP Option to Minimize Odor Comments Site Specific Practices
FARMSTEAD
♦ Swine Production aintain vegetative or wooded buffers at or •Traps dust and gases, provides dilution
near property boundary and visual screening
• May require third party input/approval
♦ Improper drainage Grade and landscape so water drains away • Reduce odors and vectors that occur
om facilities and prevent ponding with stagnant conditions
Maintain farm access roads and prevent traffic • Prevents spillage during transport and
in waste application area tracking of waste onto public roads
❑ Other BMPs—please describe
MORTALITY MANAGEMENT
♦ Carcass ® Dispose of mortality using method approved • Required by statute and permit
Decomposition by NCDA&CS State Veterinarian. Manage • May require third party input/approval
Acc ding to CAWMP(Mortality Management
ecklist)and permit(s).
Put carcasses in refrigerated (or freezer)dead
boxes within 24 hours for short-term mortality
storage.
♦ Incomplete Incineration ❑ Use incinerators with secondary burners for • Reduce odors by complete incineration
complete combustion.
❑ Other BMPs—please describe
Swine AMOC Page 1 of 6 APPROVED—7/25/2019

Swine Farm Waste Management—Odor Control Checklist Permit No.:
Cause/Source BMP Option to Minimize Odor Comments Site Specific Practices
HOUSE/BARN—WASTE HANDLING
♦ Flush tanks ❑ Install flush tank covers • Pit-flush systems
♦ Odorous Gases ❑ Flush pits at least 4 times per day • Pit-flush systems
♦ Partial microbial ❑ Empty pits at least once every 7 days • Pit-recharge or"pull-plug" systems
decomposition ❑ Underfloor flush with pit ventilation
♦ Agitation of wastes ❑ Install/extend fill lines to near bottom of
tanks with anti-siphon vents
❑ Install covers on outside waste collection or
junction box
❑ Install sump tank covers for lift stations
♦ Ammonia ❑ Flush/recharge with treated effluent
❑ Treat waste in pits with proven biological or • Monitor for any solids accumulation in pit
chemical additive
❑ Other BMPs—please describe
HOUSE/BARN—FLOOR AND INDOOR SURFACES
♦ Manure covered floors ❑ S rape manure from alleys into pens daily •Will move with other manure via pits
r4all
all fully slotted floor system
waterers over slotted floor area
feeders at high end of solid floors • Where applicable
♦ Odorous Gases crape manure buildup from floors and walls •Aids in animal cleanliness
Keep floors dry •Aids in animal cleanliness
❑ Install underfloor ventilation for drying
❑ Replace bedding/scrape at frequency to •Solid floor/bedding systems
keep bedding dry
❑ Other BMPs—please describe
Swine AMOC Page 2 of 6 APPROVED—7/25/2019

Swine Farm Waste Management — Odor Control Checklist Permit No.:
Cause/Source BMP Option to Minimize Odor Comments Site Specific Practices
HOUSE/BARN—VENTILATION
♦ Dust an fans regularly—specify frequency
♦ Volatile/odorous gases fficient air movement
Install temperature and humidity sensors to
control ventilation
❑ Treat barn exhaust • Examples: biofilters,wet scrubbing,windbreaks
• May reduce ventilation rate depending on method
❑ Other BM Ps—please describe
HOUSE/BARN—FEED
♦ Dust ❑ Install feed covers
♦ Adsorbed Gases ® Ke p outdoor feed storage covered except •Required by rule iSA NCAC 02D.1802
hen necessary to add/remove feed
Minimize free-fall height of dry feed
❑ Install feed delivery downspout extenders
to the feed covers
DXemove spoiled/unusable feed on regular basis
d Feed pellets instead of dry meal • May require third party input/approval
❑ Use feed additives • May require third party input/approval
♦ Ammonia ❑ Use feed-reduced crude protein diet • May require third party input/approval
❑ Other BM Ps—please describe
HOUSE/BARN—GENERAL
♦ Dust Install temperature and humidity sensors • Maintain relative humidity at 40 to 65%
♦ Odorous Gases to control ventilation
❑ Use ultraviolet light to treat indoor air
❑ Use indoor or outdoor electrostatic space • Can be used to treat exhaust air
charge system
❑ Other BMPs—please describe
Swine AMOC Page 3 of 6 APPROVED—7/25/2019

Swine Farm Waste Management—Odor Control Checklist Permit No.:
Cause/Source BMP Option to Minimize Odor Comments Site Specific Practices
LAGOON/WASTE STORAGE STRUCTURE
♦ Volatile Gases ® Maintain proper lagoon volume •Sufficient liquid volume/depth is required
for proper anaerobic treatment
❑ Minimize free-fall height of waste from
discharge pipe to lagoon surface
imuise
tend discharge point of pipe to below lagoon • Use caution not to scour or damage lagoon liner
quid level
aintain proper surface area-to-volume ratio
correct lagoon start-up procedures
❑ Aerate for odor control
® Manage sludge levels based on annual sludge
survey as required by permit
❑ Keep spilled feed or foreign debris out of lagoon
to prevent excess sludge accumulation
❑ Install/use solids separation system
❑ Use proven biological or chemical additives • Monitor for any increase in rate of solids accumulation
❑ Use permeable lagoon covers (not a digester)
❑ Use impermeable lagoon cover or • Methane can be flared if not utilized
anaerobic digester
❑ Other BM Ps—please describe
LAND APPLICATION
♦ Odorous gases ® Perform land application in accordance with
C WMP
♦ Wind drift ® P mp intake near lagoon surface • Required by rule 15A NCAC 02D.1802
❑ ump from second stage lagoon
Follow good neighbor policy .Avoid application on known weekends,
special days,or holidays/eves if possible
❑ Operate at minimum recommended pressure
❑ Increase setbacks beyond those required by
statute, rule,or permit
Swine AMOC Page 4 of 6 APPROVED—7/25/2019

Swine Farm Waste Management — Odor Control Checklist Permit No.:
Cause/Source BMP Option to Minimize Odor Comments Site Specific Practices
LAND APPLICATION (CONTINUED
Apply during favorable wind conditions, • Recommend checking predicted average hourly
(es (cially for traveling guns or impact wind speed within 24 hours prior to
rinklers) anticipated start
Whe ractical, apply waste on sunny days •Allows for vertical dissipation of odor
rixber than cool,overcast days
hen possible,apply waste mid-morning to •Allows for better vertical dissipation of odor
late-afternoon
❑ For traveling guns, use taper-ring or taper-bore • Less odor and drift than ring nozzles
nozzles
❑ For traveling guns, use largest-available nozzle
that provides acceptable application uniformity
❑ Replace impact sprinklers with low-drift nozzles
on center pivots and linear move systems.
❑ Use hose-drag system
❑ Use injection method for waste application
❑ Other BMPs—please describe
SLUDGE DISPOSAL
♦ Odorous gases ❑ Transport sludge in covered vehicles or tankers
❑ Apply in thin, uniform layers •Speeds drying and prevents ponding
❑ Incorporate land-applied sludge as soon as • Required within 48 hours or prior to next rain event,
practical after application,and in accordance whichever is first,for conventionally tilled
with permit. bare soils
❑ Use injection method for sludge application
❑ Dewater sludge prior to application
❑ Use alternatives to land application,such as
compost,gasification,energy generation,etc.
❑ Other BMPs—please describe
Swine AMOC Page 5 of 6 APPROVED—7/25/2019

ADDITIONAL INFORMATION AVAILABLE FROM:
Air Management Practices Assessment Tool (AMPAT) www.extension.iastate.edu/ampat/
AHG-538-A Certification Training for Animal Waste Management Systems:Type A NC Division of Water Resources
EBAE 103-83—Lagoon Design and Management for Livestock Manure Treatment and Storage www.bae.ncsu.edu
EBAE 128-88—Swine Production Facility Manure Management: Pit Recharge-Lagoon Treatment www.bae.ncsu.edu
EBAE 129-88—Swine Production Facility Manure Management: Underfloor Flush-Lagoon Treatment www.bae.ncsu.edu
EBAE Fact Sheet—Calibration of Manure and Wastewater Application Equipment www.bae,ncsu.edu
EBAE Fact Sheet—Swine Production Farm Potential Odor Sources and Remedies www.bae.ncsu.edu
NC NRCS Standard 359—Waste Treatment Lagoon www.nres.udsa.gov
NC NRCS Standard 380—Windbreak/Shelterbelt Establishment www.nres.udsa.gov
NC NRCS,Standard 422—Hedgerow Planting www.nres.udsa.gov
NC NRCS Standard 442—Sprinkler System www.nres.udsa.gov
Nuisance Concerns in Anima] Manure Management:Odors and Flies; PRO107 1995 Conference Proceedings Florida Cooperative Extension Service
Options for Managing Odor:A Report from the Swine Odor Task Force NC State University
Swine AMOC Page 6 of 6 APPROVED—7/25/2019

Murphy-Brown, LLC 3/25/2009 2822 Hwy 24 West
P.O. Box 856
NQRMAKI FARMWarsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s): Butch Norman
Farm Name: Butch Norman Farm 31-503
County: Du lin
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 4896
Storage Structure: Anaerobic Lagoon
Storage Period: >180 days
Application Method: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems,
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same,
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made,which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean 3212 gal/yr gal/yr
Farrow to Feeder 4015 gal/yr gallyr
Farrow to Finish 10585 gallyr gallyr
Wean to Feeder 223 gal/yr gallyr
4896 Feeder to Finish 986 gal/yr 4,827,456 gallyr
Total 4,827,456 gal/yr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean 5.4 Ibslyr Ibs/yr
Farrow to Feeder 6.5 Ibslyr Ibslyr
Farrow to Finish 26 lbs/yr Ibs/yr
Wean to Feeder 0.48 Ibslyr Ibslyr
4896 Feeder to Finish 2.3 Ibslyr 11,261 Ibs/yr
Total 11,261 lbs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 53.518
Total N Required 1st Year: 14732.885
Total N Required 2nd Year: 11885.249
Average Annual Nitrogen Requirement of Crops: 13,309.07
Total Nitrogen Produced by Farm: 11,260.80
Nitrogen Balance for Crops: (2,048.27)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

�zJ? 1 7,2 3 7
Reception Area Specifications
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs NlAc Lbs N Total lbs N 2nd Crop Time to 2nd Crop 2nd Crop Lbs NIAc Lbs N Total Ibs N Total ITotallbsN
Acreage Type Code Apply Yield lbs NlUnit Residual !Ac Utilized Code Apply Yield Ibs NlUnit Residual !Ac Utilized Lbs N1Ac Utilized
T7070 F1 1 5.73 WO D March-Ju 100.0 1.25 15 110 630.3rK
N Se t-A rl 40 2.4 96 550.08 206 180.38
T7070 F1 2 7.2 Wo D March-Jul 100.0 1.25 15 110 792N Se t-A riI 40 2.4 96 6912 206 1483.2
T7103 F1 3 3.2 NcA D March-Jul 110.0 1.25 15 122.5 392N Sept-April 60 2.4 144 460.8 266.5 852.8
T7103 F1 4 1.98 NoA D March-July110.0 1.25 15 122.5 242.55N Sept-April 60 2.4 144 2.85.12 266.5 527.67
T7103 F2A 5 7.46 FoA BC March-Se 5.3 50 262.5 1958.25K Sept-Apo 1 50 SO 373 312.5 2331.25
T7103 F2B 6A 5.74 FoA D March-Ju 120.0 1.25 15 135 774.9N Se t-A ril 50 2.4 2 688.8 255 1463.7
F7103 F2A 66 0.688 FoA BC March-Se 5.3 50 262.5 180.6 Se t-A ril 1 50 0 34 4 312.5 215
F7103 F2A 7 5.33 FoA BC March-Sept5.3 50 262.5 1399.125 K Sept-Apfill 1 50 50 266.5 312.5 1665.625
T7103 F2A 8A 0.802 FoA D March-Ju 120.0 1.25 15 135 108.27 N Sept lil 50 2.4 120 96.24 255 204.51
F7103 F2A 8B 0.688 FoA BC March-Se 5.3 50 262.5 180.6 K Se t- ril 1 50 50 34.4 312.5 215
F7103 F2A 9 3.31 FoA BC March-Sept5.3 5o 262.5 868.875 K Sept-April 1 50 50 165.5 312.5 1034.375
F7103 F2A 10 2.75 FoA BC March-Se 5.3 50 262.5 72L 75 K Sept-April 1 50 50 137.5 312.5 859.375
F7103 172A 11 6.3 FoA BC March-Sept5.3 50 262.5 1653.75 K Se t- nl 1 50 50 315 312.5 1968.75
F7103 F2A 12 2.34 FoA BC March-Se 5.3 50 262.5 614.25 K Se t- ril 1 50 50 117 312.5 731.7.5
Totals: 53.518 10517.35 4215,54 14732.89
3(a)of 8

Reception Area Specifications
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs N/Ac Las N Total Ibs N 2nd Crop Time to 2nd Crop 2nd Crop Lbs NlAC Lbs N Total Ibs N Total Total Ibs N
Acreage Type Code Apply Yield lbs NlUnit Residual lAc Utilized Code Apply Yield Ibs NlUnit Residual !Ac Utilized Lbs NIAc Utilized
77070 F1 1 5.73 Wo O June-Set 28.0 4 112 641.76 0 0 112 641.76
T7070 F1 2 7.2 WO O June-Set 28.0 4 112 806.4 0 0 112 806A
T7103 F1 3 32 NoA O June-Set 33.0 4 132 422.4 0 0 132 422.4
T7103 F1 4 1.98 NoA O June Set 33.0 4 132 261.36 0 0 132 261.36
T7103 F2A 5 7.46 FoA BC arch-Se 5.3 50 262.5 1958.25 K Sept-April 1 50 50 373 312.5 2331.25
T7103 F2B 6A 5.74 FoA O June-Set 28.0 4 112 642.88 1 0 112 642.88
F7103 F2A 6B 0.688 FoA BC darch-Se 5.3 50 262.5 1 B0.6 K Sept-April 1 50 50 34.4 312.5 215
F7103 F2A 7 5.33 FoA BC Vlarch-Se 5.3 50 262.5 1399.125 K Se t-A HI 1 50 50 266.5 312.5 1 1665.625
T7103 F2A 8A 0.802 FoA O June-Sept 28.0 4 112 89.824 0 0 112 89.824
F7103 F2A 8B 0.688 FoA BC Jarch-Sep 5.3 50 262.5 180.E K Sept-April 1 50 50 34.4 312.5 215
F7103 F2A 9 3.31 FoA BC Oarch-Sep 5.3 50 262.5 868.875 K Sept-Apfil 1 50 50 165.5 312.5 1034.375
F7103 F2A 10 2.75 FoA BC arch-Se 5.3 50 262.5 721.875 K Se t-A r l 1 54 50 137.5 312.5 859.375
15 312.5
F7103 F2A 11 6.3 FoA BC arch-Se 731.25
5.3 50 262.5 1653.75 K Sept-April ril 1 50 50 3 5
F7103 F2A 12 2.34 FoA BC arch-Se 5.3 50 262.5 614.25 K Sept-April 1 50 50 117 312.5 31.2
Totals: 53.518 10441.95 1443.3 11885.25
3(b)of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season(i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop Lbs N utilized/unit yield
A Barley 1.6 lbs N /bushel
B Hybrid Bermudagrass - Grazed 50 lbs N/ton
C Hybrid Bermudagrass - Hay 50 lbs N/ton
D Corn - Grain 1.25 lbs N/bushel
E Corn- Silage 12 lbs N/ton
F Cotton 0.12 lbs N/lbs lint
G Fescue - Grazed 50 lbs N/ton
H Fescue- Hay 50 lbs N/ton
I Oats 1.3 lbs N /bushel
J Rye 2.4 lbs N/bushel
K Small Grain -Grazed 50 lbs N/acre
L Small Grain - Hay 50 lbs N /acre
M Grain Sorghum 2.5 lbs N/cwt
N Wheat 2.4 lbs N/bushel
0 Soybean 4.0 lbs N / bushel
P Pine Trees 40 lbs N/acre/yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

' I
SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
I
Farm Specifications PAN/yr/animal Farm Total/yr
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
4896 Feeder to Finish 0.36 1762.56
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements, Your production facility will produce
approximately 1762.56 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 8812.8 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre,you will need 29 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre,you will need 70,5024 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or pending occurs. This rate is limited by initial soil moisture content,soil
structure, soil texture,water droplet size,and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations,the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for>180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
I
The following is provided as a guide for establishing application rates and amounts.
Soil Application Rate Application Amount
Tract Hydrant Type Crop inlhr " inches j
T7070 F1 1 Wo D 0.4 1
T7070 171 2 Wo D 0.4 1
T7103 F1 3 NoA D 0.5 1
T7103 F1 4 NoA D 0.5 1
T7103 F2A 5 FoA BC 0.5 1
T7103 F2B 6A FoA D 0.5 1
F7103 F2A 6B FoA BC 0.5 1
F7103 F2A 7 FoA BC 0.5 1
T7103 F2A 8A FoA D 0.5 1
F7103 F2A 8B FoA BC 0.5 1
F7103 F2A 9 FoA BC 0.5 1
F7103 172A 10 FoA BC 0.5 1
F7103 F2A 11 FoA BC 0.5 1
F7103 F2A 12 FoA BC 0.5 1
6 of 8

Additional Comments:
This plan is based on the irrigation design and former NUP by Kraig
Westerbeek. Pulls 1,2,3,4,6,8 are in a two year crop rotation. Grower may
plant any combination of the row crops listed as long as the two year rotation
is followed. The bermuda rate shown is based on grower removing one half
of the yeild as hay, Residual nitrogen has been deducted from the corn rate.
7 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Butch Norman Farm 31-503
Owner: Butch Norman
Manager:
Owner/Manager Agreement:
/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities,will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Butch Norman
Signature: .
Date
Name of Manager(if different from owner):
Signature:
Date
Name of Technical Specialist: Toni W. King
Affiliation: Murphy-Brown, LLC,
Address: 2822 Hwy 24 West, PO Drawer 856 _
Warsaw, NC 28398
Telephone: [phone]
Signature: ��
Date
8 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1 Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. if the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
i
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over-spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre-plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate-determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

GROWER: Butch Norman [phone] DESIGNED BY: JWR
ADDRESS: P.O. Box 38 CHECKED BY: JES
Rose Hill, NC 28458 DATE: 08/01/97
COUNTY: Du lin SHEET 1 OF 2
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) and 180 days of
temporary storage. The time required for the planned fluid level (permanent and
temporary storage) to be reached may vary due to site conditions, weather, flushing
operations, and the amount of fresh water added to the system.
The designed temporary storage consists of 180 days of temporary storage for:
(1) manure production of animals, (2) excess fresh water storage, (3) rainfall in
excess of evaporation, (4) storage for the 25 year / 24 hour storm for the location,
(5) and, if applicable, an additional "heavy rain" storage volume for chronic rainfall
events. Allocation for any additional fresh water usage is also included in the
temporary storage. The volume of waste generated from a given number of animals
will be fairly constant throughout the year, but excess rainfall will vary from year to year.
The 25 year rainfall will not be a factor to consider in an annual pumping cycle, but
this storage volume must always be available.
A staff gauge must be installed in the lagoon that indicates the start pumping and stop
pumping levels. The start pumping level is the maxium liquid level under normal operating
conditions. The stop pumping level is the minimum liquid level under normal
operation to maintain required treatment volume and depth. Pumping can be started
and stopped anywhere between these two elevations for operating convenience as site
conditions permit, such as weather, soils, crop, and equipment in order to apply waste
without runoff or leaching. However, it is recommended that the lagoon be kept
pumped down as much as possible.
Land application of wastewater is recognized as an acceptable method of disposal.
Methods of application include solid set, center pivot, guns, and traveling guns. Care
should be taken when applying waste to prevent damage to crops or runoff to surface
waters,
The following items are to be carried out:
I. It is required that the treatment lagoon be precharged to one—half the treatent volume
or as otherwise specified on the lagoon design drawings before wastes are introduced.
The purpose is to prevent excessive odors during start--up. Precharging reduces the
concentration of the initial waste entering the lagoon thereby reducing odors. Solids should
be covered with effluent at all times. When precharging is complete, flush buildings with
recycled lagoon liquid. Fresh water should not be used for flushing after initial filling.
2. The attached Waste Utilization Plan shall be followed. The plan recommends
sampling and testing of waste before land application.
Murphy Family Farms Engineering P.D. Box 759, Rose Hill NC 28458 [phone]

GROWER: Butch Norman [phone] DESIGNED BY: JWR
ADDRESS: P.O. Box 38 CHECKED BY: JES
Rose Hill, NC 28458 DATE: 08/01/97
COUNTY: Du lin SHEET 2 OF 2
3. Begin temporary storage pump—out of the lagoon when the fluid level reaches the
elevation 53.00 as marked by the staff gauge, Stop pump—out when the fluid level
reaches elevation 49.50. This temporary storage, less 25 year /24 hour storm,
contains 378520 cubic feet or 2831326 gallons.
4. The recommended maximum amount to apply per irrigation is one (1) inch and the
recommended maximum application rate is 0.3 inches per hour, Refer to the waste
utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the lagoon mowed
annually. Vegetation should be fertilized as needed to maintain a vigorous stand.
6. Repair any eroded or damaged areas and establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around waste utilization
fields adjacent to perennial streams. Waste will not be applied in open ditches.
Do not pump within 200 feet of a residence or within 100 feet of a well. Waste shall
be applied in a manner such that waste will not reach other property or public
rights—of—way.
9. The Clean Water Act of 1977 prohibits the discharge of pollutants into waters
of the United States. Waste shall not be discharged into surface waters, drainageways,
or wetlands by either discharge or by over—spraying. The Department of Environment,
Health, and Natural Resources, Division of Water Quality, has the responsibility
for enforcing this law.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458
(910) 289—2111