NC0077615_Permit Issuance_20090310

North Carolina
Beverly Eaves Perdue
Governor
-4.
NCDENR
Department of Environment and
Division of Water Quality
Coleen H. Sullins
Director
March 10, 2009
Mr. Homer Prevette
Homer's Truck Stop of Statesville, LLC
306 Stamey Farm Road
Statesville, NC 28677
Subject: Issuance of NPDES Permit NCO077615
Homer's Truck Stop WWTP
Iredell County
Dear Mr. Prevette:
Natural Resources
Dee Freeman
Secretary
Division personnel have reviewed and approved your application for renewal of the subject permit. Accordingly,
we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to the requirements of
North Carolina General Statute 143-215.1 and the Memorandum of Agreement between North Carolina and the
U.S. Environmental Protection Agency dated May 9, 1994 (or as subsequently amended).
This final permit includes no changes from the draft permit sent to you on January 14, 2009.
If any parts, measurement frequencies or sampling requirements contained in this permit are unacceptable to you,
you have the right to an adjudicatory hearing upon written request within thirty (30) days following receipt of this
letter. This request must be in the form of a written petition, conforming to Chapter 150B of the North Carolina
General Statutes, and filed with the Office of Administrative Hearings (6714 Mail Service Center, Raleigh, North
Carolina 27699-6714). Unless such demand is made, this decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may require
modification or revocation and reissuance of the permit. This permit does not affect the legal requirements to
obtain other permits which may be required by the Division of Water Quality or permits required by the Division
of Land Resources, the Coastal Area Management Act or any other Federal or Local governmental permit that
may be required.
If you have any questions concerning this permit, please contact Bob Sledge at telephone number (919) 807-
6398.
cc: Central Files
Sincerely, 4
T t
en H. Sullins
Mooresville Regional Office/Surface Water Protection Section
NPDES Unit
1617 Mail Service Center, Raleigh, North Carolina 27699.1617 VoCarolinaOne
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604
Phone:[phone]\FAX:[phone]\CustomerService:1-877-623-6748 �Internet www.ncwaterqualiry.orgL
An Equal Opporlurdty l AlPomativeAction Employer

Permit NCO077615
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIlVI NATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by the North Carolina Environmental Management
Commission, and the Federal Water Pollution Control Act, as amended,
Mr. Homer Prevette
is hereby authorized to discharge wastewater from, a facility located at
Homer's Truck Stop of Statesville, LLC
Off Gilbert Road
Statesville
Iredell County
to receiving waters designated as Third Creek in the Yadkin -Pee Dee River Basin in accordance with
effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III and IV
hereof.
This permit shall become effective April 1, 2009.
This permit and authorization to discharge shall expire at midnight on March 31, 2014.
Signed this day March 10, 2009.
Coleen H. Sullins, Director
Division of Water Quality
By Authority of the Environmental Management Commission

Permit NCO077615
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are hereby
revoked. As of this permit issuance, any previously issued permit bearing this number is no longer
effective. Therefore, the exclusive authority to operate and discharge from this facility arises under the
permit conditions, requirements, terms, and provisions included herein.
Mr. Homer Prevette
is hereby authorized to:
1. Continue operation of an existing 0.025 MGD wastewater treatment facility that includes the
following components:
➢ Grease trap
➢ Grinder pump tank
➢ Flow equalization tank with bar screen
➢ Aeration basin
➢ Clarifier with sludge return
➢ Aerated sludge holding tank
➢ Chlorine contact basin with tablet chlorination
➢ Dechlorination
This facility is located at Homer's Truck Stop of Statesville, LLC, north of Gilbert Road, near
Statesville in Iredell County.
2. Discharge from said treatment works at the location specified on the attached map into Third
Creek, currently a class C water in the Yadkin -Pee Dee River Basin.

Homer's Truck Stop of Statesville, LLC
Quad Name: Statesville West
Receiving Stream: Third Creek
Latitude: 350 47' 08"
Stream Class: C
Longitude: 80' 57' 25"
Subbasin: Yadkin -Pee Dee 030706
Facility
Location"
North NPDES Permit NCO077615

Permit NCO077615
A. (L) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
During the period beginning on the effective date of this permit and lasting until expiration, the
Permittee is authorized to discharge from outfall 001. Such discharges shall be limited and
monitored by the Permittee as specified below:
+,..j£BL.-c
jiL'I; A41
. �L.a
_r 3' �L�G..� L S.
WI S x
., i`3'3_''Su,C� t /r 2 T•Srii'. r;... .�Y. 1S �....:,,"x" a_'-Y.LtY .y+i``h�+ti"
LION O G,
Cll,CTISTCS2
. T *
.. ��
©ai[y'f,le
,!
sure t` �
z
r. V"
Flow
0.025 MGD
Weekly
Instantaneous
Influent or
Effluent
BOD, 5-Day, 20 C
30.0 mg/L
45.0 mg/L
Weekly
Grab
Effluent
Total Suspended Solids
30.0 mg/L
45.0 mg/L
Weekly
Grab
Effluent
Oil and Grease
30.0 mg/L
60.0 mg/L
2/Month
Grab
Effluent
NH3-N
2/Month
Grab
Effluent
Fecal Coliform
200/100 ml
400/100 ml
Weekly
Grab
Effluent
(geometric mean
Total Residual Chlorines
28 ug/L
2/Week
Grab
Effluent
Temperature
Weekly
Grab
Effluent
Total Nitrogen
Quarterly
Grab
Effluent
NO2+NO3+TKN
Total Phosphorus
Quarterly
Grab
Effluent
MBAS
Monthly
Grab
Effluent
pH
> 6.0 and < 9.0 standard
Weekly
Grab
Effluent
units
NOTES:
1. The Division shall consider all effluent TRC values reported below 50 µg/L to be in
compliance with the permit. However, the Permittee shall continue to record and submit all
values reported by a North Carolina certified laboratory (including field certified), even if
these values fall below 50 µg/L. _
THERE SHALL BE NO DISCHARGE OF FLOATING SOLIDS OR VISIBLE FOAM IN OTHER THAN TRACE
AMOUNTS.

Statesville Record & Landmark
Advertising Affidavit
NC DENR/DWO
BUDGET OFFICE
1617 MAIL SERVICE CENTER
RALEIGH, NC 27699
PUBLIC NOTICE
STATE OF NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT
COMMISSIOWNPDES UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NC 27699-1617
NOTIFICATION OF INTENT TO ISSUE A NPOES
WASTEWATeR PERMIT
On the basis of thorough staff review and applica-
tion of NC General Statute 143.215.1 and ESA NCAC
02H.0109 and other lawful standards and regula-
tions, the North Carolina Environmental Manage-
ment Commission proposes to issue a National
Pollutant Discharge Elimination System (NPDES)
wastewater discharge permit to the person(s) list-
ed below effective 45 days from the publish date
of this notice.
Written comments regarding the proposed permit
will be accepted until 30 days after the publish
date of this notice. All comments received prior to
that date are considered In the final determina-
tions regarding the proposed permit. The Director
of the NC Division of Water Quality may decide to
hold a public meeting for the proposed permit,.
should the Division receive a significant degree o
public interest.
Copies of the draft permit and other supporting in-
formation on file- used to determine conditions
present in the draft permit are available upon re-
quest and payment of the costs of reproduction.
Mail comments and/or requests for Information to
the NC Division of Water Quality at the above ad-
dress or call Dina Sprinkle [phone] at the
Point Source Branch. Please Include the NPDES
permit number (below) in any communication. In-
terested persons may also visit the Division of Wa-
ter Quality at S12 N. Salisbury Street, Raleigh, NC
27604-1148 between the hours of 8:00 a.m. and
5:00 p.m. to review Information on file.
The NC Department of Transportation (P.O. Box
250, North Wilkesboro, NC 28659) has applied for
renewal of NPDES permit NC0028606 for the 1-77
Rest Area in Iredell County. This permitted facility
discharges treated wastewater to the Camel
Branch in the Yadkin -Pee Dee River Basin. Cur-
rently fecal collform, ammonia nitrogen and total
residual chlorine are water quality limited. This
discharge may affect future allocations In this
portion of the Yadkin -Pee Dee River Basin.
David L Millsaps has applied for renewal of NPOES
permit NCO023191 for the Seven Cedars Mobile
Home Park WWTP in Iredell County. This permit-
ted facility discharges .010 MGD of treated waste-
water to Third Creek In the Yadkin -Pee Dee River
Basin. Currently, total residual chlorine is water
quality limited. This discharge may affect future
allocations in this portion of the Yadkin -Pee Dee
River Basin.
Hill Haven Residential Care. Inc. (114 Hill Haven
Road, Statesville, NC 28677) has applied for re-
newal of NPDES permit NCO045012 for the Hill Ha-
ven Residential Care WWTP In Iredell County. This
permitted facility discharges treated wastewater
to an unnamed tributary to Third Creek in the
Yadkin -Pee Dee River Basin. Currently fecal
collform, ammonia nitrogen and total residual
chlorine are water quality limited. This discharge
may affect future allocations in this portion of the
Yadkin -Pee Dee River Basin.
The Barium Springs Home for Children [P.O. Box i
Barium Springs, NC 28010] has applied for renewal
of NPDES permit NC0045471 for its WWTP In
Iredell County. This permitted facility discharges
treated wastewater into an unnamed tributary, to
Duck Creek in the Yadkin -Pee Dee River Basin.
Currently SOD, ammonia nitrogen, dissolved oxy-
gen, ter quallityi limited and total
ldischargge may affect
future allocations In this portion of the watershed.
Mr. Homer Prevette has applied for renewal of per-
mit NCO077615 for the Homer's Truck Stop WWTP
In Iredell County. This permitted facility discharg-
es treated wastewater to Third Creek In the
Yadkin -Pee Dee River Basin. Currently, fecal
coliform and total residual chlorine are water
North Carolina Community Newspapers
PO Box 968
Hickory, NC 28603
Account Number
3142720
Date
January 23, 2009
Description Ad Number Ad Size
PUBLIC NOTICE STATE OF NORTH CAROLINA EN 0001248091 2 x 144 L
Media General Operations, Inc.
Publisher of
Statesville Record & Landmark
Iredell County
Before the undersigned, a Notary Public of Catawba County, North
Carolina, duly commissioned, qualified, and authorized by law to
administer oaths, in said County and State; that he/she is authorized to
make this affidavit and sworn statement; that the notice or other legal
advertisement, a copy of which is attached hereto, was published in the
Statesville Record & Landmark on the following dates:
01 /23/2009
and that the said newspaper in which such notice, or legal advertisement
was published, was a newspaper meeting all the requirements and
qualifications of Section 1-597 of the General Statutes of North Carolina.
Bookkeepe
Newspaper reference: 0001248091
Sworn to and subscribed before me, thisj't�day of I t '2009
P ,
�o
ota Public • O Y
r
r
Pi •
My Commission expires:
THIS IS NOT A BILL. PLEASE PAY FROM INVOICE. THAN6.YVU,'�
pq 5 e (/ " ��
quality limited. This discharge may affect future
allocations In this portion of Third Creek.

SOC PRIORITY PROJECT: No
To: Western NPDES Unit
Water Quality Section
Attention: Robert "Eugene" Sledge
Date: October 23, 2008
NPDES STAFF REPORT AND RECOMMENDATION
County: Iredell
Permit No. NCO077615
PART I - GENERAL INFORMATION
1. Facility and address: Homers Truck Stop
306 Stamey Farm Road
Statesville, N.C. 28625
2. Report prepared by: Michael Parker, Environmental Engineer II
4. Persons contacted and telephone number: Mr. Jerry Rogers, ORC; Tel# [phone]
5. Directions to site: From Mooresville travel I-77 north to the intersection of I-40.
Proceed west approximately 6 miles on I-40 to exit 146 (Stamey Farm Road S.R. 1512).
The restaurant is located in the southeast quadrant of this intersection. To reach the
WWTP proceed on Stamey Farm Road approximately 0.4 mile to the intersection with
Gilbert Road (S.R 1513). Turn left on Gilbert Road and travel approximately 0.25 mile
to a dirt road located on the left behind a church. The WWTP is located at the end of
this dirt Road.
6. Discharge point(s). List for all discharge points:
Latitude: 35° 47' 08" Longitude: 80° 57' 25" U.S.G.S. Quad No.: D 15 SW
7. Receiving stream or affected surface waters: Third Creek.
a. Classification: C
b. River Basin and Subbasin No.: Yadkin; 03-07-06
C. Describe receiving stream features and pertinent downstream uses: The
receiving stream contained good flow at the time of inspection. There are four
known discharges above this discharge point. Pertinent downstream uses are
those typical for Class C water (secondary recreation, agriculture, etc.)
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
a. WWTP design capacity: 0.025 MGD
b. Current permitted capacity of the wastewater treatment facility? 0.025 MGD

Page Two
d. Date(s) and construction activities allowed by previous Authorizations to
Construct issued in the previous two years: There have been no ATCs issued to
this facility on the past two years.
e. Please provide a description of existing or substantially constructed wastewater
treatment facilities: The existing treatment consists of a grease trap, grinder
pump tank, flow equalization tank with a bar screen, aeration basin, clarifier with
sludge return, aerated sludge holding tank, a chlorine contact basin with tablet
chlorination, and sulfur dioxide dechlorination.
f. Proposed wastewater treatment facilities: There are no proposed W WT facilities
at this time.
g. Possible toxic impacts to surface waters: Chlorine is added to the waste stream;
however, dechlorination is provided.
2. Treatment plant classification: Class II (no change from previous rating)
PART III - OTHER PERTINENT INFORMATION
Special monitoring or limitations (including toxicity) requests: None at this time.
2. Important SOC or Compliance Schedule dates: This facility is neither under an SOC nor
is one being considered at this time.
4. Alternative Analysis Evaluation: There are no known alternatives to a discharge.
PART IV - EVALUATION AND RECOMMENDATIONS
The permittee, Homers Truck Stop, has requested renewal of the subject permit. There
has been one change at the WWTP since the permit was last renewed (dechlorination addition).
There have been no changes to the permit since the last renewal.
Historically, this facility has operated in a severely under loaded manner. This W WTP
was originally built to treat the wastewater from a Truck Stop and a motel, however, the motel
was never built, which resulted in the W WTP being severely under loaded. With influent flows
significantly lower than expected, plant operation was difficult and compliance problems
persisted. Fortunately, modifications to the W WTP allowed additional operator flexibility and
helped maintain relatively consistent compliance.
It is recommended that the subject perrpit be
as
of Report Preparer
q
Date
23
hAdsAdsr08Nhomers.doc Water Quality Regional Supervisor Date

5 �+
NCieo7'76)S�
.57
�09i1��/y—C7e--Vi
OCT 6 2008 I i
i
�k'�---�-�-

NPDES APPLICATION - FORM D
For privately owned treatment systems treating 100% domestic wastewaters <1.0 MGD
Mail the complete application to:
N. C. Department of Environment and Natural Resources
Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
NPDES Permit 0000776IL5
If you are completing this form in computer use the TAB key or the up - down arrows to move from one
field to the next. To check the boxes, dick your mouse on top of the box. Otherwise, please print or type.
1. Contact Information:
Owner Name Homer Prevette
Facility Name Homer's Truck Stop of Statesville LLC
Mailing Address 306 Stamey Fram Rd
City
Statesville, NC 28677
State / Zip Code
28677
Telephone Number
[phone] �
Fax Number
[phone]
e-mail Address
2. Location of facility producing discharge:
Check here if same address as above ❑
Street Address or State Road Gilbert Rd
City
State / Zip Code
County
Statesville
NC 26877
Iredell
3. Operator Information:
Name of the firm, public organization or other entity that operates the facility. (Note that this is not
referring to the Operator in Responsible Charge or ORC)
Name Jerry Rogers
Mailing Address
City
State / Zip Code
Telephone Number
Fax Number
PO Box 228
Statesville
NC 28687
[phone]
(704-)878-2787
1 of 4 Form-D 1/06

NPDFS APPLICATION - FORM D
For privately owned treatment systems treating 100% domestic wastewaters <1.0 MGD
4. Description of wastewater:
Facility Generating Wastewater(check all that apply
Industrial
❑
Number of Employees
Commercial
❑
Number of Employees
Residential
❑
Number of Homes
School
❑
Number of Students/ Staff
Other
®
Explain: truck
Describe the source(s) of wastewater (example: subdivision, mobile home park, shopping centers,
restaurants, etc.):
Truck Stop and store with restaurant
� ':....:.�;. 3..,:�..,�-"..h.cam--•
Population served: / `y' "-
5. Type of collection system
® Separate (sanitary sewer only) ❑ Combined (storm sewer and sanitary sewer)
6. Outfall Information:
Number of separate discharge points 1
Outfall Identification number(s) 001
Is the outfall equipped with a diffuser? ❑ Yes ® No
7. Name of receiving stream(s) (Provide a map showing the exact location of each outfall):
- Third Creek
8. Frequency of Discharge: ® Continuous ❑ Intermittent
If intermittent:
Days per week discharge occurs: 7 Duration: 24 hrs.
9. Describe the treatment system
List all installed components, including capacity, provide design removal for BOD, TSS, nitrogen and
phosphorus. If the space provided is not sufficient, attach the description of the treatment system in a
separate sheet of paper.
Grease Trap, duplex submersible pump station and force main to WWTP.
WWTP:
Influnet bar screen, weir inlet flow splitter box, equalizaion tank with pimps, aeration
basin, clarifier with sludge return, aerated sludge holding tank, chlorine contact with
tablet chlorination and dechlorination fume with tablet dechlorination.
2 of 4 Form-D 1106

NPDES APPLICATION - FORM D
For privately owned treatment systems treating 1000/6 domestic wastewaters <1.0 MGD
10. Flow Information:
Treatment Plant Design flow 0.025 MGD
Annual Average daily flow 0.0016 MGD (for the previous 3 years)
Maximum daily flow 0.002 MGD (for the previous 3 years)
11. Is this facility located on Indian country?
❑ Yes ® No
12. Effluent Data
Provide data for the parameters listed. Fecal Coliform, Temperature and pH shall be grab samples, for all other
parameters 24-hour composite sampling shall be used. Effluent testing data must be based on at least three samples
and must be no more than four and one half years old.
Parameter
Daily
Maximum
Monthly
Average
Units of
Measurement
Number of
Samples
Biochemical Oxygen Demand
(SODS)
8.8
2.3
mg/1
52
Fecal Coliform
18
2
cfu/ 100ml
52
Total Suspended Solids
19.2
10.2
mg/1
52
Temperature (Summer)
25.2
22.2
C
32
Temperature (Winter)
10.3
9.2
C
20
pH
7.7
7.4
su
52
13. List all permits, construction approvals and/or applications:
Type Permit Number Type Permit Number
Hazardous Waste (RCRA)
UIC (SDWA)
NPDES
PSD (CAA)
Non -attainment program (CAA)
NESHAPS (CAA)
Ocean Dumping (MPRSA)
Dredge or fill.(Slction,404 or CWA)
Special Order of Cexsent,(SOCJ_________
Other
OCT 6
14. APPLICANT CERTIFICATION
i
I certify that I am familiar with the information contained in the .applicaticn and that to the
best of my knowledge and belief such information is true, complete, and accurate.
C t'
X
Printedd n-,calme of Person Signing
3 of 4 V '�� v ✓v t'--
jl
Forth-D 1106

NPDES APPLICATION - FORM D
For privately owned treatment systems treating 100°/u domestic wastewaters <1.0 MGD
North Carolina General Statute 143-215.6 (b)(2) states: Any person who knowingly makes any false statement
representation, or certification in any application, record, report, plan, or other document files or required to be
maintained under Article 21 or regulations of the Environmental Management Commission implementing that Article, or
who falsifies, tampers with, or knowly renders inaccurate any recording or monitoring device or method required to be
operated or maintained under Article 21 or regulations of the Environmental Management Commission implementing
that Article, shall be guilty of a misdemeanor punishable by a fine not to exceed $25,000, or by imprisonment not to
exceed six months, or by both. (18 U.S.C. Section 1001 provides a punishment by a fine of not more than $25,000 or
imprisonment not more than 5 years, or both, for a similar offense.)
/! li
OCT 6
4 of 4 Form-01/06

HOMERS TRUCK STOP
306 STAMEY FARM ROAD
STATESVILLE, NC 28677
(704) 8718008
�! OCT 1 7 2003
OCTOBER 13, 2008 -
NCDENR:
REFERENCE: NPDES PERMIT NCO077615-SLUDGE MANAGEMENT PLAN
DEAR MS SPRINKLE:
WE HAVE A SEPTIC TANK SERVICE TO PUMP OUT SLUDGE AND TAKE IT AWAY. ONE OF
THE ONES WE USE IS POWELL SEPTIC TANK SERVICE IN TAYLORSVI LLE, NC.
SORRY, WE DIDN'T INCLUDE THIS IN OTHER REPORT.
SINCERELY,
HOMER PREVETTE

FACT SHEET FOR EXPEDITED PERMIT RENEWALS
Basic Information to determine potential for expedited permit renewal
Reviewer/Date
V&-W -Z1,t12vde
Permit Number
AIC00 �461 /.S
Facility Name
A"ne s )5 u S{v 10 T�
Basin Name/Sub-basin number
V 4P ,E, I P �Db-r-
Receivin Stream
7A, �-W
Stream Classification in Permit
Does permit need NH3 limits?
40
Does permit need TRC limits?
Alo
Does permit have toxicity testing?
/I%
Does permit have Special Conditions?
A10
Does permit have instream monitoring?
Afo
Is the stream impaired on 303 d list)?
I -es
Any obvious compliance concerns?
Any permit mods since lastpermit?
Existing expiration date
,3 3 / p
New expiration date
3 3 I /
New permit effective date
—
Miscellaneous Comments
YES_ This is a SIMPLE EXPEDITED permit renewal (administrative
renewal with no changes, or only minor changes such as TRC, NH3,
name/ownership changes). Include conventional WTPs in this group.
YES ,/ This is a MORE COMPLEX EXPEDITED permit renewal (includes
Special Conditions (such as EAA, Wastewater Management Plan), 03(d
listed, toxicity testing, instream monitoring, compliance concerns, p ased
limits). Basin Coordinator to make case -by -case decision.
YES_ This permit CANNOT BE EXPEDITED for one of the following reasons:
• Major Facility (municipal/industrial)
• Minor Municipals with pretreatment program
• Minor Industrials subject to Fed Effluent Guidelines (lb/day limits for BOD, TSS,
etc)
• Limits based on reasonable potential analysis (metals, GW remediation organics)
• Permitted flow > 0.5 MGD (requires full Fact Sheet)
• Permits determined by Basin Coordinator to be outside expedited process
TB Version 8/18/2006 (NPDES Server/Current Versions/Expedited Fact Sheet)