NCGNE0711_COMPLETE FILE - HISTORICAL_20110126

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO. Iv U& N LV I I
DOC TYPE 12` HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE o
YYYYM M D D

NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director secretary
January 26, 2011
Danthem Filtration, Inc.
Attn: Ms. Kathy Lovette
P.O. Box 429
Thomasville, NC 27361
Subject: No-Exposure Certifications NCGNE0711 & NCGNE0712
at 102 & 150 Transit Avenue in Thomasville, NC
h�elogies man-W�.�rrr �tt,rct,t;�,-,
Davidson County
Dear Ms. Lovette:
The Division has reviewed your submittal of the No-Exposure Certification for Exclusion from NPDES
Stormwater Permitting applications. Based on your submittal of signed certifications of no. exposure at the
above referenced facilities, and on an inspection by Jenifer Carter of the Winston-Salem Regional office, the
Division is granting your conditional exclusion from permitting as provided for under 40 CFR 122.26(g),
which is incorporated by reference in North Carolina regulations.
Please note that by our acceptance of your no-exposure certifications, you are obligated to maintain no-
exposure conditions at your facilities. If conditions change such that your facilities no longer qualify for no-
exposure exclusion, you are obligated to immediately obtain NPDES permit coverage for your stormwater
discharges. Otherwise, the discharges becomes subject to enforcement as un-permitted discharges. You
must self re-certify annually using the included form, or obtain NPDES permit coverage for any stormwater
discharges from your facilities. The annual self re-certification does not need to be submitted to DWQ,
unless requested.
Your conditional exclusion from permitting does not affect your facilities' legal requirements to obtain
environmental permits that may be required under other federal, state, or local regulations or ordinances.
If you have any questions or need further information, please contact Jenifer Carter at [phone], or at
[e-mail]
Sincerely,
W. Corey Basinger
Interim Regional Supervisor
Winston-Salem Regional Office
Division of Water Quality
cc: W. .SRO,:files
Stormwater Permitting Unit: No- Exposure File
Forth Carolina Division of Water Quality,Vdknston-Salem Regional Office One
586 Waughtown Si.Winston-SBIem,North Carolina 27107 Nol 111Carolina
Fhone:336-771-5000I FAX:[phone],Customer Se.vice:1-877-623-67.8
Internet:wA,%y nctvaterquality.ory ;Vatumllry
An pquA Qponunify'.FSiirn afiwe ACiio�Ern ?Oyer

'A
FOR XGFNCY USE ONLY
Division of Water Quality/Surface Water Protection year Date ReceivedMomh Da
1
NCDENR National Pollutant Discharge Elimination System Certificate OfCovemge
NICIGINIE101iiIIIII
M„ t;«...�,.� NO EXPOSURE CERTIFICATION for-Exclu i�o`n.iv�o
I.��O��F:.T.,r,N � x.s NCGNE0000 N.G. Deot,ofENR
AU61 6_2010_.
NO EXPOSURE CERTIFICATION Please check here if this is a renewal. © RENEWAL
Regional Office
National Pollutant Discharge Elimination System application for exclusion from-a-Stormwater Permit based
on NO EXPOSURE:
Submission of this No Exposure Certification constitutes notification that your facility does not require a
permit for stormwater discharges associated with industrial activity in the State of North Carolina because
it qualifies for a no exposure exclusion. A condition of no exposure at an industrial facility means all
industrial materials and activities are protected by a storm resistant shelter(with some exceptions) to
prevent exposure to rain, snow, snowmelt, and/or runoff.
For permitted facilities In North Carolina, DWO must approve your application for No
Exposure Certification before this exclusion is effective. Until you are issued a No
Exposure Certification and your NPDES permit Is rescinded, your facility must continue
to abide by the terms and conditions of the current permit.
Industrial materials or activities include, but are not limited to: material handling equipment or activities,
industrial machinery, raw materials, intermediate products, by-products, final products, or waste products.
Material handling activities Include the storage, loading and unloading, transportation, or conveyance of
any raw material, intermediate product, final product or waste product. A storm resistant shelter is not
required for the following Industrial materials and activities: drums, barrels, tanks,and similar containers
that are tightly sealed,provided those containers are not deteriorated and do not leak. "Sealed"means
banded or otherwise secured and with locked or non-operational taps or valves;adequately maintained
vehicles used in material handling;and final products, other than products that would be mobilized in
stormwater discharges(e.g., rock salt).
A No Exposure Certification must be provided for each facility qualifying for the no exposure exclusion. In
addition, the exclusion from NPDES permitting Is available on a facility-wide basis only—not for individual
outfalls. if any industrial activities or materials are, or will be,exposed to precipitation, the facility Is not
eligible for the no exposure exclusion. By signing and submitting this No Exposure Certification form, you
certify that a condition of no exposure exists at this,facility or site and are obligated to comply with the
terms and conditions of 40 CFR 122.26(g).
You are required to reapply for the No Exposure Exclusion once everV five 5 ears.
For questions,please contact the DWO Regional Office for your area. (See page 6)
(Please print or type)
1} Mailing address of owner/operator(address to which all certification comes ondence will be m d :
Name fi F � a�'an � C.. r�
PEW
Contact a Love
Street Address 2
City I State n)C ZIP Code D t (a I
Telephone No. (cA_ _ Fax: 44 10 ('
o
o
Page 1 of 7
SWU-NE-021309 Last revised 2/13/2009

r
NCGNE0000 No Exposure Certification
2) Location of facility p ooducing discharge: t
Facility Name -\ f i' C.
Facility Contact a lkl L ON Q
Street Address _AO2Ayk
City o , + State Aj -ZIP Code 2 0
County fN
Telephone No. <0 21- Fax: 3,�(o^ 1410 • D
3) Physical location information:
Please provide a narrative description of how to get to the facility(use street narVes, state rod numbers, and
distance and di(ection from a roadway intersection). _lA)QC2�IQUSQ Oi�_tjo(1 __ �n2 ►qn iw�,
Aornns\ 1e, Nc. (ASQ C1VeY1c�uC� enart�an�2
(A copy of a map with the facility clearly located on it should be included with the certification application.)
4) Is the facility located on Native American Lands? ❑ Yes &(No
5) Is this a Federal facility? ❑ Yes 9 No
6) Latitude 350,5'S' 02" Longitude - 0a�3' tq (deg., min., seconds)
7) This NPDES No Exposure Exclusion application applies to which of the following:
❑ New or Proposed Facility Date operation is to begin
14 Existing Date operation began 19
❑ Renewal of existing No Exposure Certification Certification No.: NCGNE
S) Was this facility or site ever covered under an NPDES Stormwater Permit? ❑ Yes No
If yes,what is the NPDES Permit Number?
9) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code)that describes the primary industrial
activity at this facility
SIC Code:2- -.5--ALL 39 y y
10) Provide a brief description of the types of industrial activities and products produced at this facility:
S 1 � NPi i �o, , Q, C4i� Q. ~ /1�
Q sz al 1
11) Does this facility have any Non-Discharge permits(ex: recycle permits)?
�No
Yes
If yes, list the permit numbers for all current Non-Discharge permits for this facility:
Page 2 of 7
SWU-NE-021309 Last revised 2/13/2009

NCGNE0000 No Exposure Certification
Exposure Checklists(12. - 14.)
12) Are any of the following materials or activities exposed to precipitation, now or In the foreseeable
future? (Please check either"Yes" or"No.") If you answer "Yes" to any of these items, you are not
eligible for the no exposure exclusion.
a. Using, storing, or cleaning industrial machinery or equipment, and areas where ❑ Yes `0 No ❑ N/A
residuals from using, storing or cleaning industrial machinery or equipment remain
and are exposed to stormwater
b. Materials or residuals on the ground or in stormwater inlets from spills/leaks ❑ Yes I�,No ❑ N/A
c. Materials or products from past industrial activity ❑ Yes *No ❑ N/A
d. Material handling equipment (except adequately maintained vehicles) ❑ Yes 1ANo ❑ N/A
e. Materials or products during loading/unloading or transporting activities ❑ Yes 1154 No ❑ N/A
f. Materials or products stored outdoors (except final products intended for outside ❑ Yes %No ❑ N/A
use [e.g., new cars]where exposure to stormwater does not result in the discharge
of pollutants)
g. Materials contained in open, deteriorated or leaking storage drums, barrels, tanks, ❑ Yes f(No ❑ N/A
and similar containers
h. Materials or products handled/stored on roads or railways owned or maintained by ❑ Yes R No ❑ N/A
the discharger
i. Waste material (except waste in covered, non-leaking containers[e.g., dumpsters]) ❑ Yes IgNo ❑ NIA
j. Application or disposal of process wastewater (unless otherwise permitted) ❑ Yes KNo ❑ N/A
k. Particulate matter or visible deposits of residuals from roof stacks and/or vents not ❑ Yes V No ❑ N/A
otherwise regulated (i.e., under an air quality control permit) and evident in the
stormwater outflow
I. Empty containers that previously contained materials that are not properly stored ❑ Yes $zNo ❑ NIA
(i.e., not closed and stored upside down to prevent precipitation accumulation)
m. For any exterior ASTs, as well as drums, barrels, tanks, and similar containers ❑ Yes 151�No ❑ N/A
stored outside, has the facility had any releases in the past three (3) years?
13) Above Ground Storage Tanks (ASTs): If you answer "No"to any of the following items,you are not
eligible for the no exposure exclusion.
a. Are exterior ASTs or piping free of rust, damaged or weathered coating, pits, or ❑ Yes ❑ No *N/A
deterioration, or evidence of leaks?
b. Is secondary containment provided for all exterior ASTs? If so, is it free of any ❑ Yes ❑ No tq N/A
cracks, holes, or evidence of leaks, and are drain valves maintained locked shut?
Page 3 of 7
SWU-NE-021309 Last revised 2/13/2009

NCGNE0000 No Exposure Certification
14) Secondary Containment: If you answer "No"to any of the following items,you are not eligible for the
no exposure exclusion.
a. Is secondary containment provided for single above ground storage containers ❑ Yes ❑ No %N/A
(including drums, barrels, etc.) with a capacity of more than 660-gallons?
b. is secondary containment provided for above ground storage containers stored ❑ Yes ❑ No N/A
in close proximity to each other with a combined capacity of more than 1,320-
gallons?
c. Is secondary containment provided for Title III Section 313 Superfund ❑ Yes ❑ No N/A
Amendments and Reauthorization Act(SARA) water priority chemicals`?
d. Is secondary containment provided for hazardous substances" designated in 40 ❑ Yes ❑ No �(N/A
CFR §116?
e. Are release valves on all secondary containment structures locked? ❑ Yes ❑ No E�N/A
15) Hazardous Waste:
a. Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility? ❑ Yes No ❑ N/A
b. Is this facility a Small Quantity Generator(less than 1000 kg. of hazardous waste ❑ Yes No ❑ N/A
generated per month) of hazardous waste?
c. Is this facility a Large Quantity Generator (1000 kg.or more of hazardous waste ❑ Yes No ❑ N/A
generated per month) of hazardous waste?
If you answered yes to questions b. or c., please provide the following information:
Type(s) of waste:
How is material stored:
Where is material stored:
How many disposal shipments per year:
Name of transport/disposal vendor:
Vendor address:
Footnotes to Questions 14) c. & d.
'Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for de minimis amounts of certain substances,
and/or other qualifiers, as described in the exemptions from reporting requirements of Title III SARA 313 in 40 CFR
§372.38.
`*Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for amounts less than the Reportable Quantities
of the hazardous substances listed in 40 CFR §117.3.
Page 4 of 7
SWU-NE-021309 Last revised 2/13/2009

NCGNE0000 No Exposure Certification
16) Other information: if you answer "Yes" to any of the following items,you might not be eligible for the
no exposure exclusion. A more in-depth evaluation of the site circumstances may be required.
a. Does your facility store used, recycled, or otherwise reclaimed pallets outside? 3KYes ❑ No ❑ NIA
b. Does your facility have coal piles on site? ❑ Yes 6d No ❑ NIA
c. Does your facility store other fuel sources outside in piles, such as wood chips, ❑ Yes pL No ❑ NIA
sawdust, etc.?
d. Does your facility have air emissions associated with its industrial activity(e.g., "M Yes ❑ No ❑ NIA
degreasing operations, plating, painting and metal finishing)? if so, describe the
industrial activity: W &NCXuyv,2s
e. If you answered yes to d., are those emissions mitted by an Air Quality Permit? ❑ Yes IV No ID N/A
Please specify: dn����iar�S_at`e W41 er,)owJ:hre.sh lc re
f. Please list any other environmental program permits (federal, state, etc.) not
specified earlier in this application (such as Hazardous Waste Permits, etc.):
Permit: W , Program:
Permit: Program:
Permit: _ Program:
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
L • s�
Page 5 of 7
SWU-NE-021309 Last remised 2/13/2009

NCGNE0000 No Exposure Certification
17) Certification:
certify under penalty of law that I have read and understand the eligibility requirements for claiming a condition of "no
exposure"and obtaining an exclusion from NPDES stormwater permitting.
I certify under penalty of law that there are no discharges of stormwater contaminated by exposure to industrial activities
or materials from the industrial facility or site identified in this document(except as allowed under 40 CFR 122.26(g)(2)).
I understand that I am obligated to submit a no exposure certification form once every five (5)years to the North Carolina
Division of Water Quality and, if requested, to the operator of the local municipal separate storm sewer system (MS4) into
which the facility discharges (where applicable). I understand that I must allow the North Carolina Division of Water
Quality, or MS4 operator where the discharge is into the local MS4,to perform inspections to confirm the condition of no
exposure and to make such inspection reports publicly available upon request.
In the event that the site no longer qualifies for a No Exposure Exclusion, I understand that I must obtain coverage under
an NPDES permit prior to any point source discharge of stormwater from the facility. Additionally, I certify under penalty of
law that this document and all attachments were prepared under my direction or supervision in accordance with a system
designed to assure that qualified personnel property gathered and evaluated the information submitted. Based on my
inquiry of the person or persons who manage the system,or those persons directly responsible for gathering the
information, the information submitted is to the best of my knowledge and belief true, accurate and complete. I am aware
that there are significant penalties for submitting false information, including the possibility of fine and imprisonment for
knowing violations.
I certify that I am familiar with the information contained in this application and that to the best of my knowledge and belief
such information is true,complete,and accurate.
Printed Name of Person Signing: gad 4 9 Lov vA
Title: -:�O YY-AnfG m r-
,,- 2o1 U
(Signature of piicent) (Date Signed)
Please note: This application for the No Exposure Exclusion is subject to approval by the
NCDENR Regional Office prior to issuance. The Regional Office may inspect your facility for
compliance with no exposure conditions prior to that approval. The Regional Office may also
Inspect your facility at any time in the future for compliance with the No Exposure Exclusion.
North Carolina General Statute 143-215.6 B(i) provides that:
Any person who knowingly makes any false statement,representation,or certification in any application,record,report,plan,or other
document filed or required to be maintained under this Article or a rule implementing this Article;or who knowingly makes a false
statement of a material fact in a nrlemaking proceeding or contested case under this Article;or who falsifies,tampers with,or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
(Environmental Management]Commission implementing this Article shalt be guilty of a Class 2 misdemeanor which may include a fine
not to exceed ten thousand dollars($10,000).
There is currently no fee for a No Exposure Exclusion.
Page 6 of 7
SWU-NE-021309 Last revised 2/13/2009

RANDOLPH
yQsrr s k{{; t
rEmily ct c�o�t ArY I I
Transit Ave
VoR [69as I
T`
I. +
r
o ,
n li i
Q
z 4 .•'
68 '
�� 'J♦
gsa-�
BUS
IN
4� � Qf c
n f.- r- ♦ r �
3Q1 aus �,,, Src �`
Glenda Or
rr-
a� n•
X: 3 r o
CQ- i s CA 65Q

NCGNE0000 No Exposure Certification
Final Checklist
This application should include the following items:
9H-/ This completed application and all supporting documentation.
CST A map with the location of the facility clearly marked.
❑N)R If this is a renewal, indicated current NCGNE number in Question 7.
E 301NIf the site currently has an NPDES Stormwater Permit, be sure to indicate the permit number in Question 8.
Mail the entire package to:
Stormwater Permitting Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Note
The submission of this document does not guarantee the issuance of a No Exposure Exclusion.
For questions,please contact the DWQ Regional Office for your area.
DWO Regional Office Contact Information:
Win tnnlSotern
Asheville Office ...... [phone]
Fayetteville Office ... [phone]
Mooresville Office ... [phone]
Raleigh Office ........ [phone] f e,;Ile 'oo le�
Washington Office ...[phone]
Wilmington Office ... [phone]
Winston-Salem ...... [phone] F e v!!le r
Central Office .........[phone]
Wil ngton
Page 7 of 7
SWU-NE-021309 Last revised 2/13/2009