NCGNE0525_COMPLETE FILE - HISTORICAL_20090313

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO. IV L& N L VS3S
DOC TYPE CS'HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE ❑ aD0030
YYYYMMDD

A,i';A'r
NC®ENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
February 27, 2009
RECEIVEp
N.C,D60t.of ENR
Ms. Teresa Frutuozo MAR 33 2009
Leggett& Platt, Inc. ylineton 5afem
1430 Sherman Court Regional office
High Point, NC 27260
Subject: No-Exposure Certification NCGNE0525
Leggett & Platt, Inc.
1430 Sherman Ct., High Point, NC 27260
Guilford County
Dear Ms, Frutuozo:
The Division has reviewed your submittal of the No-Exposure Certification for Exclusion from NPDES Stormwater
Permitting form. Based on your submittal and signed certification of no exposure at the above referenced facility, the
Division is granting your conditional exclusion from permitting as provided for under 40 CFR 126.22(g), which is
incorporated by reference in North Carolina regulations. We are also hereby rescinding your current permit number
NCG030022-
Please note that by our acceptance of your no-exposure certification, you are obligated to maintain no-exposure
conditions at your facility. If conditions change such that your facility can no longer qualify for a no-exposure
exclusion, you are obligated to immediately obtain NPDES permit coverage for your stormwater discharge.
Otherwise, the discharge becomes subject to enforcement as an un-permitted discharge. Your conditional no-
exposure exclusion expires in five years (February 26, 2014). At that time you must re-certify with the Division, or .
obtain NPDES permit coverage for any stormwater discharges from your facility.
Your conditional exclusion from permitting does not affect your facility's legal requirements to obtain environmental
permits that may be required under other federal, state, or local regulations or ordinances.
- If you have any questions or need further information, please contact Robert Patterson at [phone], or at
[e-mail],
Sincerely,
for Coleen H. Sullins
cc: Winston-Salem Regional Office-Corey Basinger Stormwater Permitting File NCG030022
Stormwater Permitting Unit No- Exposure Files Fran McPherson-Budget Office
Wetlands and Stormwater Branch One
1617 Mail Service Center,Raleigh,North Carolina 27699-1617 NorthCarol inn
Location:512 N.Salisbury St.Raleigh,North Carolina 27604
Phone:[phone] FAX:91M07-64941 Customer Service:1-877-623-6748 )Vatura"l,/
Internet:www.ncwaterquality.org
An Equal Opportunity 1 Affirmative Action Employer

1�s, 'AY'
1:0R AGENCY USE:ONLY
Date� Received Division of Water Quality/Surface Water Protection Year Month nay
NCDENRNational Pollutant Discharge Elimination System Certificate ofCCooverage
mc­C­DE--»r NO EXPOSURE CERTII=ICATION for Exclusion
[w Aloxwi —N.VURu REY CC!
NCGNE0000
NO EXPOSURE CERTIFICATION
National Pollutant Discharge Elimination System application for exclusion from a Stormwater Per it
g Y P
based on NO EXPOSURE:
Submission of this No Exposure Certification constitutes notice that your facility does not require it
authorization for its stormwater discharges associated with industrial activity in the State of North
Carolina because it qualifies for a no exposure exclusion. A condition of no exposure at an industriah9 Jri,
facility means all industrial materials and activities are protected by a storm resistant shelter(with some.�l�d
exceptions)to prevent exposure to rain, snow, snowmelt, and/or runoff. eyC�
Industrial materials or activities include, but are not limited to: material handling equipment or activities,
industrial machinery, raw materials, intermediate products, by-products, final products, or waste
products. Material handling activities include the storage, loading and unloading, transportation, or
conveyance of any raw material, intermediate product, final product or waste product. A storm resistant
shelter is not required for the following industrial materials and activities:drums, barrels, tanks,and
similar containers that are tightly sealed, provided those containers are not deteriorated and do not leak.
"Sealed"means banded or otherwise secured and with locked or non-operational taps or valves;
adequately maintained vehicles used in material handling;and final products, other than products that
would be mobilized in stormwater discharges(e.g., rock salt).
A No Exposure-Certification must be provided for each facility qualifying for the no exposure exclusion.
In addition, the exclusion from NPDES permitting is available on a facility-wide basis only—not for
individual outfalls. If any industrial activities or materials are, or will be, exposed to precipitation, the
facility is not eligible for the no exposure exclusion. By signing and submitting this No Exposure
Certification form,you certify that a condition of no exposure exists at this facility or site and are
obligated to comply with the terms and conditions of 40 CFR 122.26(g).
You are required to reapply for the No Exposure Exclusion once every five (5) years.
For questions,please contact the DWO Regional Office for your area. (Seepage 5)
(Please print or type)
1) Mailing address of owner/operator address to which all certification correspondence will be mailed):
Name
Street Address
City State,Jt1+?--ZIP Code
Telephone No. .3-13IJ 12 bod Fax: 5
2) Location of facility prod ucingd ischarge:
Facility Name i r r r>? 6,9061 Ene 7
Facility Contact je C"�`'
Street Address f . () ur
City fluk State -ZIP Code
County Ua _
Telephone No. 3iI r Iwo Fax:
Page 1 of 5
SWU-NE-110607 Last revised 11/06/0Aa

NCGNE0000 No Exposure Certification
3) Physical location information:
Please provide a narrative description of how to get to the facility (use street names, state road numbers, and
distance and direction from a roadway intersection).
(A copy of a map with the facility clearly located on it should be included with the certification application.)
4) Is the facility located on Native American Lands? ❑ Yes N4o
5) Is this a Federal facility? ❑ Yes Mi No
6) Latitude J5. q. � Longitude c). & . (deg, min, sec)
7) This NPDES Permit Application applies to which of the following:
❑ New or Proposed Facility Date operation is to begin
Existing Date operation began /
8) Was this facility or site ever covered under an NPDES Stormwater Permit?V- Yes ❑ No
If yes, what is the NPDES Permit Number? �
9) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility
SIC Code:;
10) Providej brief d scrfption of thetypes of industrial activities and products produced at this facility:
11) Does this facility have any Non-Discharge permits (ex: recycle permits)?
WIN o
❑ Yes
It yes, list the permit numbers for all current Non-Discharge permits for this facility:
Exposure Checklists(12. - 14.)
12) Are any of the following materials or activities exposed to precipitation, now or in the foreseeable
future? (Please check either "Yes" or "No.") If you answer "Yes"to any of these items, you are not
eligible for the no exposure exclusion.
a. Using, storing, or cleaning industrial machinery or equipment, and areas where ❑ Yes TING
residuals from using, storing or cleaning industrial machinery or equipment remain
and are exposed to stormwater
b. Materials or residuals on the ground or in stormwater inlets from spills/leaks ❑ Yes E(No
c. Materials or products from past industrial activity ❑ Yes /No
d. Material handling equipment (except adequately maintained vehicles) ❑ Yes "o
e. Materials or products during load inglunloading or transporting activities ❑ Yes l/fo
f. Materials or products stored outdoors (except final products intended for outside ❑ Yes VNo
use [e.g., new cars]where exposure to stormwater does not result in the discharge
of pollutants)
Page 2 of 5
SWU-NE-110607 Last revised 11/06107

NCGNE0000 No Exposure Certification
g. Materials contained in open, deteriorated or leaking storage drums, barrels, tanks, ❑ Yes R<0
and similar containers
h. Materials or products handled/scored on roads or railways owned or maintained by ❑ Yes U40
the discharger
i. Waste material (except waste in covered, non-leaking containers [e.g., dumpsters]) ❑ Yes "0
j. Application or disposal of process wastewater(unless otherwise permitted) ❑ Yes "o
k. Particulate matter or visible deposits of residuals from roof stacks and/or vents not ❑ Yes Pro
otherwise regulated (i.e., under an air quality control permit) and evident in the
stormwater outflow
1. Empty containers that previously contained materials that are not properly stored ❑ Yes Zo
(i.e., not closed and stored upside down to prevent precipitation accumulation)
m. For any exterior ASTs, as well as drums, barrels, tanks, and similar containers ❑ Yes V<o
stored outside, has the facility had any releases in the past three (3) years?
13) Above Ground Storage Tanks(ASTs): If you answer "No" to any of the following items, you are not
eligible for the no exposure exclusion.
a. Are exterior ASTs or piping free of rust, damaged or weathered coating, pits, or ❑ Yes ❑ No
deterioration, or evidence of leaks? ^Oe
b. Is secondary containment provided for all exterior ASTs? If so, is it free of any ❑ Yes ❑ No
cracks, holes, or evidence of leaks, and are drain valves maintained locked shut?
14) Secondary Containment: If you answer "No" to any of the following items, you are not eligible for the
no exposure exclusion.
a. Is secondary containment provided for single above ground storage containers ❑ Yes ❑ No
(including drums, barrels, etc.) with a capacity of more than 660-gallons?
b. Is secondary containment provided for above ground storage containers stored ❑ Yes ❑ No
in close proximity to each other with a combined capacity of more than 1,320-
gallons? �y�l
c. Is secondary containment provided for any amount of Title III Section 313 ❑ Yes 13 No
Superfund Amendments and Reauthorization Act (SARA) water priority
chemicals?
d. Is secondary containment provided for any amount of hazardous substances? ❑ Yes ❑ No
e. Are release valves on all secondary containment structures locked? ❑ Yes ❑ No
Page 3 of 5
SWU-NE-110607 Last revised 11/06/07

NCGNE0000 No Exposure Certification
15) Hazardous Waste:
a. Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility? ❑ Yes VrNo
b. Is this facility a Small Quantity Generator(less than 1000 kg. of hazardous waste Ej Yes 1(No
generated per month) of hazardous waste?
c. Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste ❑ Yes ifo
generated per month) of hazardous waste?
If you answered yes to questions b. or c., please provide the following information:
Type(s) of waste:
How is material stored:
Where is material stored:
How many disposal shipments per year:
Name of transport/disposal vendor:
Vendor address:
16) Certification:
certify under penalty of law that I have read and understand the eligibility requirements for claiming a condition of"no
exposure"and obtaining an exclusion from NPDES stormwater permitting.
certify under penalty of law that there are no discharges of stormwater contaminated by exposure to industrial activities
or materials from the industrial facility or site identified in this document(except as allowed under 40 CFR 122.26(g)(2)),
understand that I am obligated to submit a no exposure certification form once every five (5) years to the North Carolina
Division of Water Quality and,if requested, to the operator of the local municipal separate storm sewer system (MS4) into
which the facility discharges (where applicable). I understand that I must allow the North Carolina Division of Water
Quality, or MS4 operator where the discharge is into the local MS4, to perform inspections to confirm the condition of no
exposure and to make such inspection reports publicly available upon request.
In the event that the site no longer qualifies for a No Exposure Exclusion, I understand that I must obtain coverage under
an NPDES permit prior to any point source discharge of stormwater from the facility.Additionally, I certify under penalty
of law that this document and all attachments were prepared under my direction or supervision in accordance with a
system designed to assure that qualified personnel property gathered and evaluated the information submitted. Based
on my inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the
information,the information submitted is to the best of my knowledge and belief true, accurate and complete. I am aware
that there are significant penalties for submitting false information, including the possibility of fine and imprisonment for
knowing violations.
I certify that I am familiar with the information contained in this application and that to the best of my knowledge and
belief such information is true, complete, and accurate.
Printed Narw Qf Person Signin
Title:
bf'S-D8'
Signature of Applicant) (Date Signed)
Page 4 of 5
SW U-NE-110607 Last revised 1 1106107

NCGNE0000 No Exposure Certification
Please note: This application for the No Exposure Exclusion is subject to approval by the
NCDENR Regional Office prior to issuance. The Regional Office may inspect your facility for
compliance with no exposure conditions prior to that approval. The Regional Office may also
inspect your facility at any time in the future for compliance with the No Exposure Exclusion.
North Carolina General Statute 143-215.6 B(i) provides that:
Any person who knowingly makes any false statement,representation,or certification in any application,record,report,plan,or other
document filed or required to be maintained under this Article or a rule implementing this Article;or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article;or who falsifies,tampers with,or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management]Commiss'on implementing this Article shall be guilty of a Class 2 misdemeanor which may include a line
not to exceed ten thousand dollars($)0,000).
There is currently no tee for a No Exposure Exclusion.
Final Checklist
This application should include the following items:
r4 This completed application and all supporting documentation.
l6 A map with the location of the facility clearly marked.
-Mail the entire package to:
Stormwater Permitting Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Note
The submission of this document does not guarantee the issuance of a No Exposure Exclusion.
For questions,please contact the DINO Regional Office for your area.
DWQ Regional Office Contact Information:
n::-y Win ton-Snlcnt FH
Asheville Office ...... [phone] �i. , F g
.,
Fayetteville Office ... [phone]
Mooresville Office '
-4200
Raleigh Office ........ (919) 791
U �L�PR � s 71e Moor s�illc I t "' r.2}
Washington office ...[phone] s
Wilmington Office ... [phone]
Winston-Salem ...... [phone]
Central Office .........[phone] _- -.�-•-�►
'f7wington
Page 5 o1 5
SWU-NE-110607 Last revised 11/06/07

Map of 1430 Sherman Ct High Point NC by MapQuest Page 1 of 1
Pr,:Q, .rU EE-"S 7
PAR
L L E D
ORIGINAL H.P INKS DONT
They're 99% ..
A: 1430 Sherman Ct, High Paint, NC 27260-8200
i�MgPQLI�ST V ' r_ 6w ri
F�T
.Y�z , -
e.. s �. a "ry t*'a' * T �
tics Pd rixr
��� , it A � t� Ate. ts� .1 � .,n �� �.{3�p1 �• �� _� /.�/;-{
Q '
}
c r
1 Ltl
t�
al. als: „xS ` vj " . 5adk�Q ' SWRfh s
i F'tSy s` n F y v:}La r r eII AIRf1Ur5E Ave
ok
r '� - 34. 6. S(# a C r `•a`y+ 2
phi - * ` f•011St AYC a- .=
M�H'1' S (]r/!1 .� 2 67,� _• V
f , 6677
>_Fr ';a.% y A4e;: Yti.f
r�
� raw
'"� +, , na'{�• '� S'C.b`t fiY��yA � �a,t' v �t,} i t fj t,+c ,
2wa trio. ? � � x? 't .�� t � �_ _ .'i :Dptd •.Z000�E1gVjZEQ For'TtIEA11aS�
. ..s..0
Directions and maps are informational only.We make no warranties on the accuracy of their content,road conditions or
route usability or expeditiousness.You assume all risk of use.MapQuest and its suppliers shall not be liable to you for
any loss or delay resulting from your use of MapQuest.Your use of MapQuest means you agree to our Terms of Use
http://www.mapquest.com/maps/1430+Sherman+Ct+High+paint+NC+27260-8200/ 5/5/2008