310394_Application_20240328

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non-Discharge General Permit
On September 30, 2024, the North Carolina State Non-Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non-Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore,all applications
must be received by the Division of Water Resources by no later than April 3,2024.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Certificate Of Coverage Number: AWS310394
2. Facility Name: Ken Barfield Farm Inc
3. Permittee's Name(same as on the Waste Management Plan): Kenneth W Barfield
4. Permittee's Mailing Address: 2368 Summerlin Crossroad Rd
City: Mount Olive State: NC Zip: 28365
Telephone Number: 919-738-4199 Ext. E-mail: picsrus2298na bellsouth.net
5. Facility's Physical Address: 2368 Summerlin Crossroads Rd
City: Mount Olive State: NC Zip: 28365
6. County where Facility is located: DDuplin
7. Farm Manager's Name(if different from Landowner):
8. Farm Manager's telephone number(include area code):
9. Integrator's Name(if there is not an Integrator,write"None"):
s
10. Operator Name(OIC): Kenneth W.Barfield Phone No.: 919-658-6465 OIC#: 17161
11. Lessee's Name(if there is not a Lessee,write"None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Swine-Farrow to Wean 1,350
Operation Types:
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses-Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses-Other
Farrow to Finish Milk Cow Pullets Sheep-Sheep
Feeder to Finish Dry Cow Turkeys Sheep-Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment Lagoons,Digesters and Waste Storage Ponds(WSP):(Fill/Verify the following information.
Make all necessary corrections and provide missing data.)
Structure Type Estimated Liner Type Estimated Design Freeboard
Structure (Lagoon/Digester/ Date (Clay,Synthetic, Capacity Surface Area "Redline"
Name WSP) Built Unknown) (Cubic Feet) (Square Feet) (Inches)
1 Lagoon 1/1/1988 Full,clay 446,051.00 55,504.00 20.00
2 Lagoon 6/28/1996 Full,clay 541,323.00 81,750.00 22.00
Submit one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed
application as required by NC General Statutes 143-215.1OC(d), either by mailing to the address below or sending it via
email to the email address below.
The CAWMP must include the following components: _ _
1. The most recent Waste Utilization Plan(WUP),signed by the owner and a certified technical specialist,containing:
a. The method by which waste is applied to the disposal fields(e.g.irrigation,injection,etc.)
b. A map of every field used for land application(for example:irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation(RYE)for every crop shown in the WUP
£ The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2.A site map/schematic
3.Emergency Action Plan
4.Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6.Mortality Control Checklist with selected method noted-Use the enclosed updated Mortality Control Checklist
7.Lagoon/storage pond capacity documentation(design,calculations,etc.) Please be sure the above table is
accurate and complete. Also provide any site evaluations,wetland determinations,or hazard classifications that may be
applicable to your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list,please include the additional components with your submittal.
(e.g.composting,digesters,solids separators,sludge drying system,waste transfers,etc.)
I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included,this application package will be returned to me as incomplete.

Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false
statement, representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18
U.S.C. Section 1001 provides a punishment by a fine of not more than$10,000 or imprisonment of not more than 5 years,or both
for a similar offense.)
Print the Name of the Permittee/Landowner/Signing Official and Sign below.(If multiple Landowners exist,all landowners
should sign. If Landowner is a corporation, signature should Pe by incipal executive officerof the corporation):
Name(Print): XPAAP4k , A Title: w
Signature: Date: �—
Name(Print): Title:
Signature: Date:
Name(Print): Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
E-mail: [e-mail]
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699-1636

Murphy-Brown, LLC 10/23/2012 P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s): Ken Barfield Farm Inc.
Farm Name: Ken Barfield Farm 31-394
County. Duplin
Farm Capacity:
Farrow to Wean 1350
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Wean to Finish
Feeder to Finish
Storage Structure: Anaerobic Lagoon
Storage Period: >180 days
Application Method: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities,and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tans per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution,the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
i of 8

This plan is based on the waste application method shown above. if you choose to change
methods in the future,you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made,which could
allow additional waste to be applied. Provisions shall be made for the area receiving;,waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan,if carried out,meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons,W,tons,etc.):
Capacity Type Waste Produced per Animal Total
1350 Farrow to Wean 3212 gal/yr 4,336,200 gal/yr
Farrow to Feeder 4015 gal/yr gal/yr
Farrow to Finish 10585 gal/yr gal/yr
Wean to Feeder 223 gal/yr gal/yr
Wean to Finish 838 gal/yr gal/yr
Feeder to Finish 986 gal/yr gal/yr
Total 4,339,200 gal/yr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Nitrogen Produced per Animal Total
1350 Farrow to Wean 3.85lbs/yr 5,198 lbs/yr
Farrow to Feeder 7.23 Ibs/yr lbs/yr
Farrow to Finish 19.05 lbs/yr lbs/yr
Wean to Feeder 0.4 Ibs/yr Ibs/yr
Wean to Finish 1.5 lbs/yr lbs/yr
Feeder to Finish 1.77 lbs/yr Ibs/yr
Total 5,198 Ibs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen'produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 25.4
Total N Required 1 st Year: 6403.975
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 6,403.98
Total Nitrogen Produced by Farm: 5,197.50
Nitrogen Balance for Crops: (1,206.48)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics,and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

Z a W mein W mwmc2mn b
am�uRi3m�Tr R
R V W 7 W
cQ W cO<6 O CONOOM a
ao uc0'd"°)cur?n 10 tp
4 to mno 0001g2 Wdo
p {p N N"N N N N N N N
'Q N N N N N N N N(NJ N
J
Z
O
a N 03 0) p 2 N
m O co W W cm r
fA [7�W N W W
O�
r
Z p
0 0 0 0 0 0 0 0 0 0
aQ �mmm�+mm�mmm�mmm�mn
J
Q R
�Za
C ED
Q d
J Q
pp fi
U=� o 0 o c c o 0 0 0 0
'0 sn m en+rs u7 in en rn mn
w
N la
G
O�
U y _
N
d— 4<Cti<tQQ4¢iw
4
F m a> a) m ar � m m 0
ffJ Cfl co[q(JJ f)CO
Q
va
p Y Y Y Y Y Y Y Y Y Y
a�y
N
W m t{)W C7 m C2
Z a u-, mn r mn as
im ,
N W R R to W
N N O)W co CD co W W W R S'D
R Ri
F 7 co m W N'D mn�^W tn
W
O
V N N N N N N N N N N N
j a N N N N N N N N N N co
a�
a
V} fa
J M
ICL=
Oy u RJ R A R R m In
co co co o c i
y m m m m m m m m mm
oa
� tf3 47 ii'3 t!'y 4'J A!i ctl L,to tf)
r e19 i[)4�ll'I to!tS[n t£3 LLT 47
N
63 O N D iU C1S N(IJ N 9 tJ @
m O U. (dl CF3 W CfJ tfi -
C 61
(} 00 fl]21 Cfl C6 C�tII ffl mtO ffl
tq U
N tD ID 5Ti tZi CQ(Si fD[D LPl
< < <<<<C�4¢
c
O
U Ren W rn--carrN ui
n. Omd 7 G7�R C*)OR cp CO.- N
4 i Q
a
=.6 R co 0]�
Q LL
`„'
6
r+ �
i+
a> r ar p
0[ ~

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields(i.e.small grain, etc, interseeded in bermuda),forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain,etc,is to be removed for hay or silage,care
should be exercised not to let small grain reach maturity,especially late in the season(i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of Bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation,you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall
The ideal time to interplant small grain, etc, is late September or early October. 'Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a Height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop Lbs N utilized/unit yield
A Barley 1.6 lbs N/bushel
B Hybrid Bermudagrass-Grazed 50 lbs N/ton
C Hybrid Bermudagrass-Hay 50 lbs N/ton
D Corn-Grain 1.25 lbs N/bushel
F Corn-Silage 12 lbs N/ton
F Cotton 0.12 lbs N/lbs lint
G Fescue-Grazed 50 lbs N/ton
H Fescue-Hay 50 lbs N/ton
i Oats 1.3 lbs N!bushel
J Rye 2.4 lbs N/bushel
K Small Grain-Grazed 50 lbs N/acre
L Small Grain-Hay 50 lbs N/acre
M Grain Sorghum 2.5 lbs N!cwt
N Wheat 2.4 lbs N I bushel
O Soybean 4.0 lbs N/bushel
P Pine Trees 40 lbs N/acre/yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers,filter strips along ditches,odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

i
j
SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/ r/aniimai Farm Total/yr
1350 Farrow to Wean 0.84 1134
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
Wean to Finish 0.306
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 1134 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years,you will have approximately 5670 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre,you will need 18 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre,you will need 45.36 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type,crop,and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content,soil
structure,soil texture,water droplet size,and organiclisolids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,it is the responsibility of the
producer and irrigation designer to ensure that an irritation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make tf�s plan invalid.
*This is the maximum application amount,, Ilowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations,the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for>180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. ;1n no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil Application Rate Application Amount
Tract Hydrant Type Crop in/hr *inches
1 AuB B 0.6 1
2 AuB B 0.6 1
3 AuB B 0.6 1
4 AuB B 0.6 1
5 AuB B 0.6 1
6 AuB B 0.6 1
7 AuB B 0.6 1'
8 AuB B 0.6 1
9 AuB B 0.6 1
10 AuB B 0.6
6of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm. Ken Barfield Farm 31-394
Owner: Ken Barfield Farm Inc.
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities,will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Itwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Ken Barfield,Inc
Signature:
4ate
Name of Manager(if different from owner):
Signature:
Date
Name of Technical Specialist: Toni W. King
Affiliation: Murphy-Brown,LLC.
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw,NC 28398
Telephone: [phone]
;t
}
Signature:
Date
8of8

Additional Comments:
The acreage used in this NUP is based on the"wetted"acres determination
completed in 2002. This plan is for bermuda with a small grain overseed which
will be grazed. R.Y.E's are from the NC State Nutrient Management database.
The only change in this plan from the previous plan is the reduction in the
application rate to small grain overseed from 75 Ibs N per acre during split
windows to the more commonly used 50 Ibs N per acre with the standard
windows of Sept-April. This also extends the producers Bermuda application
windows from Aug 31 through the end of September..
7of8

ISE
� -
zfM -NIP
500
UR
114
s
�• F
�. -%`•-tic
t �+
-� '� v-� � ��--�-�--�� ,��•� .� �`'..'�'zurs+` ter'` �.� ,�''*- -�a - - �� � - - a
v
gm
SEEM� u r
- r
f -
- �
R�
-���-•-� �� �_ �.,� -
G�
�
�4
r =
g
F
' f n
�- - -

EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ) 910 395`� qco
EMERGENCY MANAGEMNET SERVICES (EMS) Ste »b-,jif„a
SOIL AND WATER CONSERVATION DISTRICT (SWCO) 410
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) 910 544,•-- zi.t3a
COOPERATIVE EXTERSION SERVICE (CES) j10 - ►tY3
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters
or leave you property to consider that you have a problem. You should make every
effort-to ensure that this does not happen. This plan should be posted in an accessible
location for all'employees at the facility. The following are some action items you should
take.
1'. Stop the release of wastes. Depending on the situation, this may ore may not be
possible. Suggested responses to some possible problems are listed betwo.
A. Lagoon overflow-possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
S. Runoff from waste application field-actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that cause the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers-action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c_ Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators-action include:
a. Stop recycle pump.
b. Stop irrigation pump.
C. Make sure siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
E. Leakage from base or sidewail of lagoon. Often this is seepage as opposed
to flowing leaks-possible action:
a. Dig a small sump or ditch from the embankmentto catch all
seepage, put in a submersible pump, and pump hack to lagoon.
b. if holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls-and lagoon
bottom as soon as passible_

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste.reach any surface waters?
b. Approximately how much was released and for what duration?
C. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWCL regional office; Phone - -. After
hours, emergency number: 919-733-3942. Your phone call should incfude: your
name, facility number, telephone number, the details of the incident from item 2
above, the enact location of the facility, the location or direction of movement of
the spill, weather and wind conditions. The corrective measures that-have been
under taken, and the seriousness of the sitution.
b. If spill leaves property or enters surface waters, call local EMS phone number.
c.• Instruct EMS to contact local Nelath Department.
d. Contact CEs, phone number - , local SWCD office phone number - -, and local
MRCS office for advice/technical assistance phone number - -.
4. If none of the above works call 911 or the Sheriffs Department and explain you
problem to them and ask the person to contact the proper agencies for you.
5. -. Contact the contractor of your choice to begin repair or problem to minimize. off-
site damage.
a. Contractors Name: �l ,r,�.5,
b. Contractors Address: A4I r
c. Contractors Phone: 19 �y3 t ram. i� 3b
5. Contact the technical specialist who certified the lagoon (MRCS, Consulting
Engineer, etc.)
a. Name: I
b. Phone: st4-�i�34 £xf. 7r'7
7. Implement procedures as advised by DW(1 and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste managment plan to
keep problems with release of wastes from happening again.
2.

4 '
INSECT CONTROL CHECKLIST FOR ANIMAL OPERATIONS
Source Cause BmP,s to Minimize Odor Site Specific Practices
(Liquid Systems)
Flush Gutters' Accumulation murlation of sdids lush system is designed and operated
sufficiently to remove accumulated
from gutters as designed.
Remove bridging of accumulated solids at
discharge
Lagoons and Pits Crusted Solids Maintain lagoons,settling(basins and
pits where pest breeding is apparent to
minimize the crusting of solids to a depth
of no more than 6 8 incites over more than
3 %of surface.
Excessive Vegetative Decaying vegetation d-fMaintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
(Dry Systems)
Feeders reed Spillage ()Design, operate and maintain feed systems(a.g..
hunkers and troughs)to minimize the accumulation
of decaying wastage.
() Clean up spillage on a routine basis(e.g.7-10 day
interval during summer; 1 S-30 day interval during winter).
Feed Storage Accumulations of feed residues (}Reduce moisture accumulation within and around
immediate perimeter of feed storage areas by
insuring drainage away from site and/or providing
adequate containment(e.g.,covered bin for
brewer's grain and similar high Moisture grain
products)-
(}Inspect for and remove or break un accumulated
solids in filter strips around feed storage as needed-
Animal Holding Areas Accumulations of animal wastes {}Eliminate low area that trap moisture along fences
and feed wastage and other locations where waste accumulates and
and disturbance by animals is minimal.
d] Maintain fence rows and filter strips around ar+imai
holding areas to minimize accumulations of wastes
G.e.inspect for and remove or break up accumulated
solids as needed).
WIC--(November 11. 1236

Dry Manure Handling AccunvA aeons of animei wastes [] Remove spillage on a routine basis(e.g.7-10 day
Systems interval during-summer. 1530 days interval during
winter) where menace is loaded for land app6eation
or diaposaL
t Provide for adequate drainage around manure stockoies.
[}Inspee r for and remove or break up accun wilted waatas
in-alter snipes around stockpiles and nunure head&V
areas as needed.
The issues checked [ ) permin to this operation. The landownerfirrtegrattlr agrees to use sound judgment in.applying
insect control measures as practical.
I certify the aforementioned insect control Best Management Practices have been reviewed with me_
(Landowner nature)
For mare information cont at-the Cooperative Extension Service.pepertrnent of Entornology.Box 7613,.North Carolina State University.Raleigh, NC
27 6 9 5-761 3.
AMIC—November 11. 1996

{
SWINE FARM WASTE MANAGEMENT ODOR CONTROL CHECKLIST
Source Cause BMP's to Minimize Odor Site Specific Practices
Farmstead Swine production }/egetative or wooded buffer:
7Ro'cammended beat management
vices;
tad judgment and common sense
Animal body surfaces Dirty marture-covered animals Dry floors
Floor Surfaces Wet manure-covered floors (!,Witted floors:
{ Waterers located over slotted floors;
(} Ijeeders at high and of solid floors:
Scrape manure buildup from floors;
{) Underfloor ventilation for drying
Manure collection pits Urine (} Frequent manure removal by flush,pit
recharge.orscrape
Parital mieorbial decomposition () Underfloor ventilation
Ventilation exhaust.fans Volatile gases-. {)Fen maintenance;
Dust {}:!!ant air movement
Indoor surfaces Oust t-fWasndown between groups of animals
{} Feed additives;
{} Feeder covers;
{) Feed delivery downspout extenders to
feeder covers
Rush tanks Agitation of recycled lagoon {) Flush tank covers
liquid whiles tanks are filling (} Extend fill lines to near bottom of
tanks with anti--siphon vents
Flush alleys Agitation during wastewater (-Underfloor flush with underfloor
conveyanance ventilation
Pit recharge points Agitation of recycled lagoon {}Extend ter-hard fines to near bottom of
liquid while pits are filling pits with anti- phon vents
Lift s moans Agiwvon during sump tame filling p 7 Sump'Lank covers
and drawdown
Outside drawn collection Agitation during wastewater {) Box covers
or junction boxes eon"Venee -
End of drainpipes at lagoon Agitation during wastewater ()Extend discharge point of pipes
undemeath lagoon liquid level
Lagoon surfaces Volatile gas emissions WProPer lagoon liquid capacity
Biological rniAng nett lagoon startup procedures
Agitation { Minimum surface area-to-volume ratio
(}tAnirnum agitation wnen pumping
{) Mecnanical aeration
(} Proven biological additives
rrigation sprinkler nozzles High pressure agitation 1 gate on dry days with little or no wind
Wind draft 7toZrnurn recommended operation pressure
(VPurmp intake near lagoon liquid surface
(!Pump from second-stage,lagoon
BMOC—November 11. 1996

Storage tank or basin Partial microbial decompesition {}Bottom or midlevel loading
surface Miring while filling f)Tank covers
Agitation when emptying () Basin surface mats of solids
()Proven biological additives or oxidants
Settling basin surface Partial micobial decomposition () Extend drainpipe outlets underneath liquid
Muting while{rll'ing level
Agitation when emptying ( Remove settled solids regularly
Manure, slung or sludge Agitation when spreading f}Soil injection of slurry/sludges
spreader outlets Volatile gas amissions ()Wash residual manure from spreader after use
()Proven biological additives or oxidants
Uncovered manure,slurry Volatile gas emissions while drying ()Sod infection of shrrry/sludges
or sludge on field surfaces {)god incorporation within 48 hours
()Spread in ttin uniforrn layers for rapid drying
{}Proven biological additives or oxidants
bead animals carcass decomposition WPraper disposition of carcasses
Dead animal disposal Carcass decomposition {)Complete covering of carcasses in burial pits
pits {)Proper locationiconstrucuon of disposal pits
Incinerators Incomplete combustion f} Se�eonclary stack burners
Standing water around Improper drainage WGrada,and landscape such that water drains
facilities Microbial decomposition of away from facilities
organic matter
Manure tracked onto public Pocriy maintained access roads (-)"Farm:access road maintenance
roads from farm access
Additional information: Available From.
Swine Manure Management:0200 RW*MMP Packet NCSU-County Extension Center
Swine Production Farm Potential Odor Sources and Remedies,EBAE Fact Sheet Nt SU-BAE
Swine Production Facility Manure Management:Pit Recharge--Lagoon Treatment;E13AE 128-88 NCSUL"E
Swine Production Facility Manure Management:Underfloor Ruse—(.agoon Treatment EBAE 129-SS NCSU-BAE
L.apoon Desio and Management for iivestack Manure Traeunent and storages;ESA 7o3_83 J%l=L;-QAt
'al-tbration of Manure and Wastewater Application&{tdpmem EBAE Fact Sheet NfSU-8AE
:;onuaffing Odors from Swine Bumps;PIH-33 NCSU-Swing Extension
°nvironnsenW Assurem Program:NPPC Manual NC Pork Produces Assoc
amions for Managing Odor,a reoM from the Swine Odor Task Force N SU Agri Communications
duisance Concerns in Animal Manure Managamenr.Odors and Flies:PRO107, I995 Conference Proceedings Florida Caeperative Extension
-he issues checked { ) pertain to this operation. The landownerintegrator agrees to use Sound judgment in applying
)dor control measures as practical.
certify the aforementioned Odor control Best Managment Practice have been reviewed with me.
6 a/,/W, -
(Landow r Signature)
'ACC—November 7 I, 1996

Operator:_______________ __________________> Qoriefu
Count -- - - � � ���
Dist . to nearest residence (other than owner) : ft .
sows (farrow to finish) :____________________>
s I (farrow to feeder) : ____________________> 550
head (finishing only) :______________________>
sows (farrow to wean) :______________________> 0
head (wean to feeder) : ______________________> >1
Ave. Live Weight for other operations (lbs. ) : >
Storage volume for sludge accum. (cu. ft . ) : =>
Treatment Volume (min. 1 cu. ft ./lb. ) : ==_-__> 1 . 0
25 Year - 24 Hour Rainfall (in. ) :==_________> 7. 5
Rainfall in excess of evaporation (in. ) ===__> 7 . 0
Drainage area of buildings & lots (sq. ft . ) : >
Volume of wash water (gallons/day) ====______>
Temporary storage period (days) :===_________> 180
Freeboard (ft . } :____________________________> 1
Side slopes (inside lagoon) :________________> 2 . 5 1
Inside top length (ft . ) :____________________> 265
Inside top width (ft . } :_____________________> 209.45
Top of dike elevation {ft _ ) :________________> S6 . 5
Bottom of lagoon elevation (ft. ) :==_________> 44 . 8
Seasonal high water table (SHWT) elev. (ft . ) :_>
Total required volume :_____________> 424279 cu. ft .
Actual design volume:====------====>446051.39 cu. ft .
Stop pumping el . (> or = to 0 . 0 ft SHWT> 52 . 6 ft .
(> or = to 50 . 8 ft Min)
Required minimum treatment volume: 287100 cu. ft .
Volume at stop pumping elevation: 301458 cu. ft .
Start pumping elev. ;________________________> ; 54 . 8 ft .
Volume at start pumping elevation: 409408 cu. ft .
Ac,,tual volume less 25yr-24hr rain: 411361 cu. ft .
N Verify that temp. storage is adequate:
Req. volume to be pumped:====> 102489 cu. ft .
Actual volume to be pumped:==> 107950 cu. ft .

r
-
a =bvV
€= rr"vm to —e_- _ —
�Moraae Vol -or Pat--
8 lun is
i e"sv x491 t ?#.`3,-xx a '.2 ai_
24
--' i ? s z' 1`7 Duli rfizs3 i }
3 Ei
_.-L'tF_..F-.zG -E3=.��.���=�<-_ _ •-
vT. i 3}f•-..t'R_..=js'T az&k.A a��{', t_
I
171
lnaG'ld,c--Imp
cip AN
zi z3a 'it'd flit. i' t ar.u�` djv-lb qui
i Cu
n a
s# -t - a
'_• :F rr r "ai [ :.tT" jaflt {fig.;
r.;
- fillF a-aftStop
8.:��.ft.
. €s ma .3#_..< ,.. 0.
NO
a� x
f �i z # _
sx
n ram-;ptnm#..sue '�..e..: I .J"s..p -

Phis lagoon is designed for waste treatment ipe-rroan'eiit sto-rage) and
160 days of tempara-ry sto'rage. The time required for the planned
fluid level (permanent and tempo-r.ry storage) tbe reached ma v� ry
due to sit e cQ?nd a.ti€]na., tclE'eat�i{?'r, 7'�.la5t'{A iig ��--rc.'� iorl, 'Eund the aniOltiit
of f-r sh water addi=d t= the
The dear.;igiied to ipore`cry t:orage C_onsi.ste of 1_1*0 day_ Storaye fo.v:
(1'l waste from a-i-limial't'"a acid (2) excess 'rztlin'C 11 after eva po-ratioil. (-";1so
included is storage for the 25 year -- 24 hom sto-rm for the location.
� ht� vo lume ofwaste generated from a given ]nui-ii3e-r Of animals will br:
fairly constant throughout the year acid f-rom year t-Ct -e—ar, but exceu•t.-
rainfall will vary from year to year. The ;"5 yea-f� will riot
be a factor' to consider I"n an aa]1rjuaS, ptt;{]ping Cycle, but this stowage
,_3Iume must: a.lwa G be
A ffl,;"r 1.n]E_ M eleVatiOAI is dote-rMined in each design to begs-i
punip1]ifg and this is r.t=Eivally the outlet inve- o f p�i��,� �s! �`roly.
building {s) . if the csutl et tripe is -not i.nstalied at the elevation to
begin pumping, a permanent marker must be installed at this tlevatic-,
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment d+_pth-
Pur„pi]ntg cyan be started O'f stopped at any time between ;these two
el.evat:o-os for operating convenie ica -as site conditions permit, Sach 4+'--
weathe'r, sails, crop, and eq-.tipment i.rl carder to appl; waste without �
-;-unof Or leachi'+']rn..
Land caPplif`_ltion Of +{a5te 4:ate-i- i5 as +:a?n acceptable,
method of disposal- Nethods of applicat'ir_!n itnc:lukde solid set,
center pivot, f{l:'rls, c;1nCI tret':eiing guy-, iY'ri gjg Lt:iC}ii.. care >I.-Iould be
taken when applying waste to prevent damage to crops..
The following iteais a-re to be ca-r-ried out: +
'3.'i• j.... t'r 01I C�1. _ ♦;lY,_,_t iiF.r..• '.{.� tIn L
,:". -... z i - ,L: -.`.�. .r.. �i. W1:�.=-_:af: .i:-rea�.r:]ent ._:3Q,G(37i i:!e P3 cam-.. t ,.
cha-rged •tb '1/2 its ceapac.` tv tI;, excessive odors du-r]g •�S_- _ �
- `J
start-up. Pre-cha:rgi]ng -reduces' the concentration of tine initial
Waste ente-ritig the, lagoon thereby 'reduci-nq odo-r's_ Solids should be
covered with effluent at all" tines. Winer] p-recha-i-grog is comply tc,
-- -flush buildings with recy cl.ed lagoon n liquid. Fresh water should not
he used for -flushiv , =.f-�.e'r initial f:�_llin►}_
2. The attached waste utilization plat, shall be followed_ This
plain 'recommends sampling and testing of waste (see attachntetnt)
befo-re laid application.
3. Begin ter{]pora-ry; 'storage pump--cut of the lagoon when fluid level
'reaches the elevation 109_5 as marked by perrncsnert marker. Stop pomp_
out when the fluid level 'reaches elevation 107. 3 . This temporary
storage, less 25 y'r- 24 hr sto-i ni, contains 126994 cubic -feet; or
949913 ' gallO]ns_

• Ti4- i'r�wwliili 'iii�L�il lii r�.lii�Liiitiiiiii"1; 't(7 a{3p1;+" .{=1•w�it
e S�.) ].c:h and -hE-: -f•'r'cofftiiic-:,nde d v.a X1MUrf, a p p i7.Cit'1 ic.i-s 'rate i S 0 3
l ii=i"s ��r�.,'r :iC•!t'i"_ 1 {-'tE-r 'l,ri lflie_ a7tt lit_ Util1ZatiGtl Pla-11 for Ct3'i-the—r dr_''1,.ail .
4L::'get.c'!'�:-7.Di1 G'il c_1'iC r?1iibaiit'iuertt and areas ad jaccn-it to the
V,211. `_'l -i.i•_ ; should be 'Yevtiiize: as
t_.
t••- ftia.ii"it.a-:i1, is e%:lC{=7-!•utrts:, _>tctk:;.{.
E. 'Repair li—eas or a-fQas d_i(iia'ggi-i] b -�tade3i'1_-:
establ'is:_h in
7_ All sUrf RCt- -i-UTIO f'f is to be diverted from the l_goo l to stable
- 1'ee-P a ti77.1-1iF11LL i Qf 25 fE'et of 9 raSS— v e9etct(;Cd L,uf f­_'r a-rolund
tt'1 ilizati.r:-n -Fields: i_xjJa i_�1i"Y t -1-'O-ffen iial s��-i��iii�. Wr_'_'te will
riot be applied i-I-I open ditches. Do nOt pli:1{.7 Within 2200 feet of a
�drilCs' t '� 0 s=- �.7 aiir=��
{- a:p
ma'.1ne'r not to r£}aj:!t, Cttt e—i -of-ways.
cl� 3� � a �i�
-3_ The Cleaii Wat-f- AC.- r of 1977 p-rohibits 'she discharge L:,f
pollutants into w�i-te'rs of the United Sota'te�_ T:-it: Depa'L-'cme-i-st of
Err, ironnicllc, kiealtll, all- 1{=stLl^al -esoa_.rces, Division of Eilviroi`t-
Csiental MctnagCsfll?nt, the 're5ponslbilit; for tFj_s law.
r
t

3/-37
Version—November 26,2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table.Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G,S. 106-16$.7.
Complete incineration according to 02 NCAC 52C .0102.
(� ( A composting system approved and permitted by the NC Department of Agriculture&Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off-farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture&Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm-specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Signa ure of Farm Owne /Manager Date
Signature of Technical Specialist Date