310382_Application_20240320

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non-Discharge General Perrnit
On September 30,2024,the North Carolina State Non-Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non-Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore,all applications
must be received by the Division of Water Resources by no later than April 3,2024.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
I. Certificate Of Coverage Number: AWS310382
2. Facility Name: Pack Farm 1-3
3. Permittee's Name(same as on the Waste Management Plan): Bobby Quinn Howard
4. Permittee's Mailing Address: 145 Buck Branch Dr
City: Warsaw State: NC Zip: 28398
Telephone Number: 910-289-7716 Ext. E-mail:
5. Facility's Physical Address: 259 Dark Branch Rd
City: Kenansville State: NC Zip: 28349
6. County where Facility is located: DDuplin
7. Farm Manager's Name(if different from Landowner):
g_ Farm Manager's telephone number(include area code):
9. Integrator's Name(if there is not an Integrator,write"None"): Prestage Farms Inc
10. Operator Name(OIC): Bobby Quinn Howard Phone No.: 910-289-7716 OIC#: 989078
11. Lessee's Name(if there is not a Lessee,write"None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Swine-Feeder to Finish 2,205
Operation Types:
Swine Cattle Dry Poultry Other Tvpes
Wean to Finish Dairy Calf Non Laying Chickens Horses-Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses-Other
Farrow to Finish Milk Cow Pullets Sheep-Sheep
Feeder to Finish Dry Cow Turkeys Sheep-Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Vt'et Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment Lagoons,Digesters and Waste Storage Ponds(WSP):(Fill/Verify the following information.
Make all necessary corrections and provide missing data.)
Structure Type Estimated Liner Type Estimated Design Freeboard
Structure (Lagoon/Digester/ Date (Clay,Synthetic, Capacity Surface Area "Redline"
Name WSP) Built Unknown) (Cubic Feet) (Square Feet) (inches)
14-16 Lagoon 6/24/1992 Full,clay 439,198.00 54,950.00 19.50
Submit one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed
application as required by NC General Statutes 143-215.10C(d),either by mailing to the address below or sending it via
email to the email address below.
The CAWMP must include the following components:
�71.The most recent Waste Utilization Plan(WUP),signed by the owner and a certified technical specialist,containing:
a. The method by which waste is applied to the disposal fields(e.g.irrigation,injection,etc.)
b. A map of every field used for land application(for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation(RYE)for every crop shown in the WUP
£ The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
✓2. A site map/schematic
V3.Emergency Action Plan
✓4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted-Use the enclosed updated Mortality Control Checklist
7_ Lagoon/storage pond capacity documentation(design,calculations,etc.) Please be sure the above table is
accurate and complete. Also provide any site evaluations,wetland determinations,or hazard classifications that may be
L applicable to your facility.
J�.Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list,please include the additional components with your submittal.
(e.g.composting,digesters,solids separators,sludge drying system,waste transfers,etc.)
I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included,this application package will be returned to me as incomplete.

Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false
statement, representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18
U.S.C.Section 1001 provides a punishment by a line of not more than$10,000 or imprisonment of not more than 5 years,or both
for a similar offense.)
Print the Name of the Pennittee/LandownerlSigning Official and Sign below.(If multiple Landowners exist,all landowners
should sign. If Landowneris a corporation,signature should be by a principal executive officer of the corporation):
Name(Print): Ltd i.lAIA O NO Ki 10 e*d Title:
Signature: L l 1 n 14 0 t, Date: �— e
Name(Print): Title:
Signature: Date:
Name(Print): Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
E-mail: [e-mail] gov
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699-1636

`rc STATE"'`
ROY COOPER
Governor
ELIZABETH S.BISERY..-
Secretary
RICHARD E.ROGERS,JR. NORTH CAROLINA
Director Environmental Quality
February 12,2024
Bobby Guinn Howard
Pack Farm 1-3
145 Buck Branch Dr
Warsaw,NC 28398
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non-Discharge General Permits,
which expire on September 30, 2024_ In order to ensure your continued coverage under the State Non-Discharge General
Permits you must submit an application for permit coverage to the Division of Water Resources(DWR)by April 3,2024.
Enclosed you will find a "Request for Certificate of Coverage for Facility Currently Covered by an Expiring State
Non-Discharge General Permit."The implication form must be completed signed by the Pennittee,and returned to the DWR by
April 3,2024.
Mailing Address: NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699 1636
Email:animal.gperations@)deq.nc.gov
phone:[phone]
Please note that you must include one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with the
completed and signed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage tinder a valid general permit would constitute a violation of NC G_S. § 143-215.1
and could result in assessments of civil penalties of up to$25,000 per day.
Copies of the animal waste operation State Non-Discharge General Permits are available at
www.deq.nc.gov/animalperinits2O24.General permits can be requested by writing to the address above.
If you have any questions about the State Non-Discharge General Permits,the enclosed application,or any related matter please
feel free to contact the Animal Feeding Operations Branch staff at 919-707-9129.
Sincerely,
Michael Pjetraj,Deputy Director
Division of Water Resources
Enclosures: Request for Certificate of Coverage for Facility Currently Covered b an n Expiring State Non-Discharge
General Pemlit
�srthCar�liaaY9�srteteat3fEarirramaatati�aakt.; 1}iri�i�aafll,'eterl�esQarrxs
12-North 5s7ishurr5tret 163d1fsi15mireC[ntFr Field_=hti�TtLfarolino'Z'4491636
919 767-9129

Version—November 26,2018
®rtality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should beat least one foot above the seasonal
high water table.Attach burial location map and plan.
a Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B ,0200,
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture &Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off-farm,
additional requirements must be met and a permit is required from NC DEQ.
a In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture& Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinion of the State Veterinarian,would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm-specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS.Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
-31
Signature of Farm Owner/Ma ager Date
�- Q&eel -k-_ 1 1t g
Signature of Technical Ypecialist Date

Insect Control Checklist for Animal Operations
Source CaIISe fill•II's to Control Insects Site— -- ,l.
Specific 1 aclices
Liquid Systems
l lush (iuticns nccumulalion ofsulids
O Flush sys(cnl IS dC5lblled and opaalcd
sufficiently to remove accumulated solids f onl
gutters as designed.
O Remove bridging of accuntulated solids at
discharge
l,aguuns and Pi
ls • Crusted Solids s Maintain lagoons, settling basllls and Ails where
pest breeding is app,u'enl to nlininlizc Ilse
crusting of solids to a depth of no more than G -
3 inches over more than 30%of surlace.
I:xccssivc Vegetative • llccaying vegetation
Uo%%th ® Maintain vcgclativc control along banks of
la-Roons and other impotutdnien(s to prevent
acctnntilalivn of decaying vegetative matter
along Svatct's edge on ilnhotmdmcnl's perimeter.
Dry Systems
I ceders I�ccd Spillage
O Ucsign, operate and maintain feed systems (e.g.,
blinkers and troughs) to minimize tlnc
accumulation of decaying wastage.
O Clean ill spillage on a rouline basis(e.g., 7 - 10
day intccval during summer; 15-30 day inlcrval
during winlcr).
I•ccd Stungc • /lccunnnlations ul feed residues
O itcduce ntoisturc accuniulalion within and
around innnlediate perimeter of feed storage
areas by insuring drainage away trout site
and/or providing adequate containment (e.g.,
covered bin for brewer's grain and similar(nigh
nloislwc grain products).
O luspect for and remove or break up accuntulaled
solids in filler strips around feed storage as
needed.
MI IC- November 1 1, 1996, 11;tge I

Swine Farm Waste Management Odor Control Checklist
Source Cause •,BMPs to Minimize Odor
Farmstead • S Nine production Site Specific Practices
® Vegetative or wooded buffers;
® Recommended,best management practices;
Good judgment and common sense
Animal body surfaces • Dirty manure-covered animals 0 Dry.'floors
Floor surfaces • Wctrnanure-covered floors Slotted floors;
Waterers located over slotted floors;
® Feeders at high end of solid floors;
0 Scrape manure buildup from floors;
# Underfloor ventilation for drying
Manure collection pits Urine; ® Frequent manure removal by flush,pit recharge,
• Partial microbial decomposition or scrape;
Ventllatlon exhaust fans • Volatile gases; ® Underfloor ventilation
® Fan maintenance;
Dust M Efficient air movement
Indoor surfaces • Dust ® Washdown between groups of animals;
19 Feed additives;
O Feeder covers;
Feed delivery downspout extenders to feeder
covers -
Flush tanks • Agitation of recycled lagoon !7 Flush tank covers;
liquid while tanks are filling 13 Extend fill lines to near bottom of tanks wily
Flush alle s anti-siphon vents
Y Agitation during wastewater ® Underfloor flush with underfloor ventilation
conveyance
Pit recharge points Agitation of recycled lagoon ®y Extend recharge lines to near bottom of pits
liquid while pits are filling ' with anti-siphon vents
Lift stations • Agitation during sump tank C] Sump tank covers
filling and drawdown
Outside drain collection • Agitation during wastewater O Box covers
orJunetion boxes conveyance
AMOC®November 11, 1996, Page 3

Source Cause BMPs to Minimize.Odor Site Specific Practices
Standing water around ® Improper drainage; ® Grade and landscape such that water drains
facilities 8 Microbial decomposition of away from facilities
organic matter
Mmuro trucked onto ® Poorly maintained access roads 0 Farm access road maintenance
public roads from farm
access
Additional Information : Available From
Swine Manure Management ; 0200 RuleBMP Packet NCSU, County Extension Center
Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact.Shcet NCSU - BAE
Swine Production Facility Manure Management: Pit Recharge- Lagoon Treatment ; EBAE 128-88 NCSU - BAE
Swine Production Facility Manure Management: Underfloor Flush- Lagoon Treatment; EBAE 129-88 NCSU - BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage ; EBAE 103-83 NCSU - BAE
Calibration of Manure and Wastewater Application Equipment ; EBAE Fact Sheet NCSU - BAE
Controlling Odors from Swine Buildings; PIH-33 NCSU - Swine Extension
Environmental Assurance Program ; NPPC Manual NC Pork Producers Assoc
Options for Managing Odor; a report from the Swine Odor Task Force NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies ; PRO107, 1995 Conference Proceedings Florida Cooperative Extension
AMOC-November 11, 1996, Page 5

DUPLIN COUNTY
EMERGENCY ACTION PLAN
DIVISION OF WATER RESOURCES (DWR) 910-796-7215
EMERGENCY MANAGEMENT SERVICES (EMS) 910-296-2160
SOIL&WATER CONSERVATION DISTRICT (SWCD) 910-296-2120
NATURAL RESOURCES CONSERVATION SERVICE(NRCS) 910-296-2120
COOPERATIVE EXTENSION SERVICE (CES) 910-296-2143
This plan will be implemented in the event that waste from your operation are leaking,
overflowing, or running off the site. You should NOT wait until wastes reach surface
waters or leave your property to consider that you have a problem. You should make
every effort to ensure that this does not happen. This plan should be posted in an
accessible location for all employees at the facility. The following are some action items
you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested response to problems are listed below:
A. Lagoon overflow-possible solutions are:
a. Add soil to berm to increase elevation of dam, any permanent alteration of the
dam should be approved by a qualified technical specialist.
b. Pump wastes to field at an acceptable rate.
c. Stop all additional flow to the lagoon, hold wastes in the house if possible.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from wastes application field-action include:
a. Immediately stop wastes application.
b. Create a temporary diversion or berm to contain the waste.
c. Incorporate waste to reduce further runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinkler-action includes:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Close values to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush system, houses, solids separators-action includes:
a. Stop recycle(flushing system) pump.
b. Stop irrigation pump.
c. Make sure no siphon effect has been created.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks-possible action:

a. Dig a small sump or ditch to catch all seepage, put in a submersible pump, and
pump back into lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes
and compact with a clay type soil.
c. Have a professional evaluate the condition of the sidewalls and the lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger(either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, call your DWR (Division of Water Resources)
regional office, at 910-796-7215, after hours, emergency number: 1-800-858-
0368. Your phone call should include: YOUR NAME , FACILITY
NUMBER,TELEPHONE NUMBER,THE DETAILS OF TE INCIDENT
FROM ITEM#2 ABOVE, THE EXACT LOCATION OF THE FACILITY,
AND THE LOCATION OR DIRECTION OF MOVEMENT OF THE
SPILL, WEATHER AND WIND CONDITIONS,THE CORRECTIVE
MEASURES THAT HAVE BEEN UNDER TAKEN, AND THE
SERIOUSNESS OF THE SITUATION.
b. If the spill leaves the property or enters surface waters, call local (EMS)
Emergency Management Services at 910-296-2160.
c. Instruct EMS to contact local Health Department.
d. Contact local Soil and Water Conservation District, Natural Resources
Conservation Service office at 910-296-2120 and Cooperative Extension
Service at 910-296-2143 for advice/technical assistance.
4. If none of the above works call 911 or the sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair of the roblem to minimize off-
site damage. I / t
a. Contractors Name: V 0 ✓�^ of �i G�
b. Contractors Address:
c. Contractors Phone: g/n _ �S
Page 2

6. Contact the technical specialist who certified the lagoon.
a. Name: 664E-1va Cc.i�9o,J
b. Phone: 9l D- 69L—57"tq
7. Implement procedures as advised by DWR and technical assistance agencies to
rectify the damage,repair the system, and,reassess the waste management plan to
keep problems with release of wastes from happening again.
8. If you are a contract swine grower associated with a swine company integrator,
contact the company representative at 910-592-5771.
Page 3

OPERATION & MAINTENANCE PLAN
Proper lagoon management should be a year-round priority. It is especially important to manage
levels so that you do not have problems during extended rainy and wet periods.
Maximum storage capacity should be available in the lagoon for periods when the receiving crap is
dormant (such as wintertime for bermudagrass) or when there are extended rainy spells such as a
thunderstorm season in the summertime. This means that at the first sign of plant growth in the
later winter 1 early spring, irrigation according to a farm waste management plan, should be done
whenever the land in dry enough to receive lagoon liquid_ This will make storage space available
in the lagoon for future wet periods. In the late summer 1 early `all the lagoon should be pumped
down to the low marker (see Figure 2-1)to allovv for winter storage. Every effort should be made
to mainfair. the lagoon close to the minimum liquid level as long as the weather and waste
utilization plan will allow it.
Waiting until the lagoon has reached its maximum storage capacity before starting to irrigated does
not leave room for storing excess water during extended wet periods. Overflow from the lagoon for
any reason except a 25-year, 24-hour storm is a violation of state law and subject to penalty
action.
The routine maintenance of a lagoon involves the following:
• Maintenance of a vegetative cover for the dam. Fescue or common bermudagrass
are the most common vegetative covers. The vegetation should be fertilized each
year, if needed, to maintain a vigorous stand. The amount of fertilized applied
should be based on a soils test, but in the event that it is not practical to obtain a
soils test each year, the lagoon embankment and surrounding areas should be
fertilized with 800 pounds per acre of 10-10-10, or equivalent.
• Brush and trees on the embankment must be controlled. This may be done by
mowing, spraying, grazing, chopping, or a combination of these practices. This
should be done at least once a year and possibly twice in years that weather
conditions are favorable for heavy vegetative growth.
NOTE: if vegetation is controlled by spraying, the herbicide must not be allowed to enter the
lagoon water. Such chemicals could harm the bacteria in the lagoon that are treating the waste.
Maintenance inspections of the entire lagoon should be made during the initial filling of the lagoon
and at least monthly and after major rainfall and storm events. Items to be checked should
include, as a minimum, the following:
Waste Inlet Pipes, Recycling Pipes, and Overflow Pipes --look for:
1. separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes
2

Lagoon surface --look for:
1. undesirable vegetative growth
2. floating or lodged debris
Embankment--hook for:
1. settlement, cracking, or"jug" holes
2. side slope stability — slumps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack or vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon
dam. A good stand of vegetation will reduce the potential damage caused by wave
action. If wave action causes serious damage to a lagoon sidewall, baffles in the lagoon,
may be used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dam. If your lagoon
has any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a
threat of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps --check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, or a large amount of vibration, may indicate that the pump is in need of repair or
replacement.
NOTE: Pumping systems should be inspected and operated frequently enough so that
you are not completely "surprised" by equipment failure. You should perform your
pumping system maintenance at a time when your lagoon is at its low level. This will
allow some safety time should major repairs be required. Having a nearly full lagoon is
not the time to think about switching, repairing, or borrowing pumps. Probably, if your
lagoon, is full, your neighbor's lagoon is full also. You should consider maintaining an
inventory of spare parts or pumps.
Surface water diversion features are designed to carry all surface drainage
waters (such as rainfall runoff, roof drainage, gutter outlets, and parking lot
runoff) away from your lagoon and other waste treatment or storage
structures. The only water that should be coming from your lagoon is that
which comes from your flushing (washing) system pipes and the rainfall that
hits the lagoon directly. You should inspect your diversion system for the
following:
1. adequate vegetation
2. diversion capacity
3. ridge berm height
3

Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an overflow problem from a surface water diversion or there may be seepage into
the lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before waste
loading begins, taking care not to erode lining or bank slopes.
3. Drainpipes into the lagoon should have a flexible pipe extender on the end of the
pipe to discharge near the bottom of the lagoon during initial filling or another
means of slowing the incoming water to avoid erosion of the lining.
4. When possible, begin loading new lagoons in the spring to maximize bacterial
establishment (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon liquid
volume. This seeding should occur at (east two weeks prior to the addition of
wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below 7.0, add
agricultural lime at the rate of 1 pound per 1000 cubic feet of lagoon liquid volume
until the pH rises above 7.0. Optimum lagoon liquid pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate biological
activity. Consultation with a technical specialist is recommended if these
conditions occur for prolonged periods, especially during the warm season.
Loading:
The more frequently and regularly that wastewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several limes daily
are optimum for treatment. Pit recharge systems. in which one or more buildings are
drained and recharged each day, also work well.
4

• Practice water conservation — minimize building water usage and spillage from
leaking waterers, broken pipes and washdown through proper maintenance and
water conservation.
• Minimize feed wastage and spillage by keeping feeders adjusted. This will reduce
the amount of solids entering the lagoon.
Management:
• Maintain lagoon liquid level between the permanent storage level and the full
temporary storage level.
• Place visible markers or stakes on the lagoon bank to show the minimum liquid level
and the maximum liquid level. (Figure 2-1).
• Start irrigating at the earliest possible date in the spring based on nutrient
requirements and soil moisture so that temporary storage will be maximized for the
summer thunderstorm season. Similarly, irrigate in the late summer / early fall to
provide maximum lagoon storage for the winter.
• The lagoon liquid level should never be closer than 1 foot to the lowest point of the
dam or embankment.
• Don not pump the lagoon liquid level lower than the permanent storage level unless
you are removing sludge_
• Locate float pump intakes approximately 18 inches underneath the liquid surface and
as far away from the drainpipe inlets as possible.
• Prevent additions of bedding materials, long-stemmed forage or vegetation, molded
feed, plastic syringes, or other foreign materials into the lagoon.
• Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed.
• Maintain strict vegetation, rodent, and varmint control near lagoon edges.
• Do not allow trees or large bushes to grow on lagoon dam or embankment.
• Remove sludge from the lagoon either when the sludge storage capacity is full or
before it fills 50 percent of the permanent storage volume.
• If animal production is to be terminated, the owner is responsible for obtaining and
implementing a closure plan to eliminate the possibility of a pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:
5

• proper lagoon sizing,
• mechanical solids separation of flushed waste,
• gravity settling of flushed waste solids in an appropriately designed basin, or
• minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long term will:
• have more nutrients,
• have more odor, and
• require more land to properly use the nutrients.
Removal techniques:
• Hire a custom applicator.
• Mix the sludge and lagoon liquid with a chopper- agitator impeller pump through large
-bore sprinkler irrigation system onto nearby cropland; and soil incorporate.
• Dewater the upper part of lagoon by irrigation onto nearby cropland or forageland; mix
remaining sludge; pump into liquid sludge applicator; haul and spread onto cropland or
forageland; and soil incorporate.
• Dewater the upper part, of lagoon by irrigation onto nearby cropland or forageland;
dredge sludge from lagoon with dragline or sludge barge; berm an area beside lagoon
to receive the sludge so that liquids can drain back into lagoon; allow sludge to
dewater, haul and spread with manure spreader onto cropland or forageland; and soil
incorporate.
Regardless of the method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that field and
crop requirement. Waste application rates will be discussed in detail in. Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage.
Close attention by the pumper or drag-line operator will ensure that the lagoon liner
remains intact. If you see soil material or the synthetic liner material being disturbed, you
should stop the activity immediately and not resume until you are sure that the sludge
can be removed without liner injury. If the liner is damaged it must be repaired as soon
as possible.
Sludge removed from the lagoon has a much higher phosphorus and heavy metal
content than liquid. Because of this it should probably be applied to land with low
phosphorus and metal levels, as indicated by a soil test, and incorporated to reduce the
chance of erosion. Note that if the sludge is applied to fields with very high soil-test
phosphors, it should be applied only at rates equal to the crop removal of phosphorus.
As with other wastes, always have your lagoon sludge analyzed for its nutrient value.
6

The application of sludge will increase the amount of odor at the waste application site.
Extra precaution should be used to observe the wind direction and other conditions
which could increase the concern of neighbors.
Possible Causes of Lagoor: EaRure
Lagoon failures result in the unplanned discharge of wastewater from the structure.
Types of failures include leakage through the boom or sides, overtopping, and breach
of the dam. Assuming proper design and construction, the owner has the responsibility
for ensuring structure safety. Items which may lead to lagoon failures include:
• Modification of the lagoon structure -- an example is the placement of a pipe in the
dam without proper design and construction. (Consult an expert in lagoon design
before placing any pipes in dams.)
• Lagoon liquid levels --high levels are a safety risk.
• Failure to inspect and maintain the dam.
• Excess surface water flowing into the lagoon.
Liner integrity -- protect from inlet pipe scouring, damage during sludge removal, or
rupture from lowering lagoon liquid level below groundwater table.
NOTE: If lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the dam. Once this damage starts, it can quickly cause a large
discharge of wastewater and possible dam failure-
7

Qv I U W. gowr•Rtj I - 3
Operator:0. County: Duplin Date: 06/24/92
Distance to nearest residence (other than owner) : 850. 0 feet
1. STEADY STATE LIVE WEIGHT
0 sows (farrow to finish) x 1417 lbs. = 0 lbs
0 sows (farrow to feeder) x 522 lbs. = 0 lbs
2205 head (finishing only) x 135 lbs. = 297675 lbs
0 sows (farrow to wean) x 433 lbs. = 0 lbs
0 head (wean to feeder) x 30 lbs. = 0 lbs
TOTAL STEADY STATE LIVE WEIGHT (SSLW) = 297675 lbs
2 . MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 297675 lbs. SSLW x Treatment Volume(CF) /lb. SSLW
Treatment Volume(CF) /lb. SSLW= 1 CF/lb. SSLW
Volume = 297675 cubic feet
3 . STORAGE VOLUME FOR SLUDGE ACCUMULATION
N c o p•�r��i r�r t Mr�i7a�� �;�, R�w,tzsr'.
Volume = 0. 0 cubic feet S1aDc_c 7--D r3C- kM otr
4 . TOTAL DESIGN VOLUME
Inside top length 0 feet ; Inside top width feet
Top of dike at elevation 49. 0 feet
Freeboard 1. 0 feet ; Side slopes 2 . 5 : 1 (Inside lagoon)
Total design lagoon liquid level at elevation 48. 0 feet
Bottom of lagoon elevation 37 . 0 feet
Seasonal high water table elevation 0. 0 feet
Total design volume using prismoidal formula
SS/E 1 SS/END2 SS/SI El SS/SIDE2 LENGTH WIDTH DEPTH
2. 2 . 5 . 5 2 . 5 125. 0 130. 0 11. 0
AREA OF TOP
LENGTH * WI H =
127. 5 13 0 16575. 0 (AREA OF TOP)
AREA OF BOTTOM
LENGTH * WIDTH
100. 0 75 . 7500. 0 (AREA OF BOTTOM)
AREA OF MIDSEC ON
LENGTH * WI H * 4
113 . 8 2 . 5 46637 . 5 (AREA OF MIDSECTION * 4)
CU. FT. = REA TOP + (4*AR MIDSECTION) + AREA BOTTOM] * DEPTH/6
6575 . 0 4 637 . 5 7500. 0 1.8
VOLUME OF LAGOON AT TOTAL DESIG LIQUID LEVEL = 129 640 CU. FT.

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
130 .0 135. 0 17550. 0 square feet
Buildings (roof and lot water)
Length * Width =
220.0 170. 0 37400. 0 square feet
TOTAL DA 54950. 0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0. 00136
Volume = 297675 Lbs. SSLW * CF of Waste/Lb. /Day * 180 days
Volume = 72694 cubic feet
r-8. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0. 0 gallons/day * 180 days storage/7 . 48 gallons
per CF
Volume = 0. 0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7 . 0 inches
Volume = 7 . 0 in * DA / 12 inches per foot
Volume = 32054 .2 cubic feet

5D. Volume of 25 year - 24 hour storm
Volume = 7 . 5 inches / 12 inches per foot * DA
Volume = 34343 . 8 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 72694 cubic feet
5B. 0 cubic feet
5C. 32054 cubic feet
5D. 34344 cubic feet
TOTAL 139092 cubic feet
6. SUMMARY
Total required volume 436767 cubic feet
Total design volume avail. 439198 cubic feet
Min. req. treatment volume plus sludge accumulation 297675 cubic fe
At elev. 45. 0 feet ; Volume is cubic feet (end pumping)
Total design volume less 25yr-24hr storm is 404854 cubic feet
At elev. 47. 3 feet ; Volume is cubic feet (start pumping)
Seasonal high water table elevation 41. 0 feet
7. DESIGNED BY: APPROVED BY:�
Ste.
DATE: �Za`I�? DATE: Jo
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN

ti.
1�
t
•
�,. ou
i
•

OPERATION AND MAINTENANCE PLAN
------------------------------
This lagoon is designed for waste treatment with minimum odor
control. The time required for the planned fluid level to be
reached may vary due to soil conditions,flushing operations, and
the amount of fresh water added to the system.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent runoff from the field or damage
to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre-
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre-charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times.
2 . The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see Attachment B)
before land application.
3 . Begin pump-out of the lagoon when fluid level reaches eleva-
tion 47.3 as marked by permanent markers. Stop pump-out when
the fluid level reaches elevation 45. 0 or before fluid depth is
less than 6 feet deep (this prevents the loss of favorable
bacteria) .
4 . The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0 . 4
inch per hour.
5 . Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7 . All surface runoff is to be diverted from the lagoon to stable
outlets.
8 . The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

q
• : ! � ,cf t I I i_ !P�.1 , , i t- I I :_ ' I. .., I -7 I I �j -I- .L :-: I I '._:_
... ' • ., :�;>�,.-_.. I 1 •I i f ! t 1.1 I !_ i. .i. t _L.f .I..F.., _ ! i
. �`. 1 ..... � I � 1 Q� ! j i.I i. I.1 i t 1�,�• I t� :,� i I i. I ., ..j ! ; i ' .i .I I.�..7 j i i �.j.I r{�—I � i I
i"
i
�.. .. .. : ..._I. .. . ._..... c. ...:•� - - ..i .�_.�. 1...1-!---t--i- .,..., ._i. ..i �._L_ �•,._ _I_I _ I_-'.' ----.y_.
1 '
j..
... :... .. ,_._�..;. . .. •. ,. 1 . .� , -1 .t !:.!...I- .'.. -. "I. t� - 1 h..!.� _.�..I .�- -' 1_L'i- —�•� - _' - +---Ll_}_.�_�+.,1.,_t_...
I .
' 40
7. f
l: 1- .I
I
�1
,..t: .., _«..i..
1..
t i-
t
r
•i....L.l._j`.L..� _
' I
' S /O$S•�U19 � � ' 1 '.�. I � t � t .� .� 1 i ! i...I.l..._I.}. ..L i .I_t ! i i ..L � .,._' ,. I
. .. .
13-
:..:..... t- .. �.y-- .-.--. - •,---'_. :--.-- -.-;........-- � -- --'-*•-1 I i ' .i..!..I ! i. I , i'- .I l..t. t_ i '_.�..1_ .�_.�. t. I 1__
>�cl o',
. ... j . ,. . , . . On oLf. <� ,C.Lr�;al• �, t2, S`f�i I 61 ( /1�J' :y:cr; AG�� '..$'C _'E(v�•_.5 .8..
F/ C L i i . .. .':S /,14�I �C,�tlLc�e,>_c� J� .�iQ �'.`�-;C t-t4�J��j-tto� �� ' ���•��1^�c'.�iF. I i i.I � , L t. :� _ i i I ..
NPI
. 1J
L
i

1 i
I
i
t
t - -
- , — - -
- - Z
y
IF
:
t -1
". ._ 5w1:" Tab
a�.
'Yel
• _3/
zoo
o �a Z.007 �; o,

Waste Utilization Plan
Producer: Bobby (Quinn) Howard County: Duplin
Name of Farm: Pack Farm 1-3 (Tom)
Location: 145 Buck Branch Drive Warsaw, NC 28398
0
Phone: [phone]
Type of Operation: Feed-Fin
Number of Animal: 2205
Storage Structure: Anaerobic Lagoon
Method of Application: Irrigation
Amount of waste produced per year: 4190 ton/year
Amount of plant available N (PAN) produced/year: 5072 lbs./year
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface water and/or groundwater. The plant nutrients in the animal waste
should be used to reduce the amount of commercial fertilizer required for the crops in the
fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in the implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environmentally
safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall not be applied to land eroding at more than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are
established.
4. Do not apply waste on saturated soils , when it is raining, or when the surface is
frozen. Either of these conditions may in runoff to the surface waters which is not
allowed under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor problems.
6. To maximize the value of the nutrients for crops production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy. Injecting the waste or disking will
conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change methods
in the future, you need to revise this plan. Nutrient levels for different applications methods are
not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have plant analysis made, which
Pack Farm 1-3 (Tom) Page 2

could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible so as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract No. Field No. :GjoA
ype Crop Yield/Ac Lbs. N Acres ;Lb N Month to Lbs. N
Code unit d Apply Per Ac.
4201 1 A Soybeans 38 bU 3.91 4.88859 4/1-9115 176
4201 1 Rye 65 bu 2.09 4.88 49$ 9/1-3131 102*
4201 2 AuB Soybeans 30 bu 3.98 4.3 512 4/1-9/15 119
4201 2 AuB Rye 45 bu 2.32 4.3 335 9/1-3/31 78*
4201 Pivot NbA Soybeans 45 bu 3.91 12.60 2218 4/1-9/15 176
4201 Pivot NbA Rye 60 bu 2.09 12.6 1575 9/1-3/31 125
Total 43.56 5996lbs.
Available Nitrogen 5072 lbs.
Surplus or deficit -925 lbs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to apply
the waste in a timely manner.
*WA already has a 25% reduction to accommodate grazing

could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible so as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract No. Field No. Soil Type Crop Yield/Ac2L:bs- N Acres Lbs N Month to Lbs. NCode nit Used Apply PerAc.
4201 1 GoA corn 186 bu 0.79 4.88 717 Al-91'5 147
4201 1 OoA Rye 65 bu 2.09 4.88 498 911-3/31 136
4201 2 AuB corn 132 bu 0.78 4.3 443 4/1-9/15 103
4201 2 AuB Rye 45 bu 2.32 4.3 335 9/1-3/31 78"
4201 Pivot NbA corn 168 bu 0.78 12.60 1651 4/1-9/15 131
4201 Pivot NbA Rye 60 bu 209 12.6 1575 9/1-3/31 125
Total 43.56 52191bs.
Available Nitrogen 5072 lbs.
Surplus or deficit -147 lbs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to apply
the waste in a timely manner.
TWA already has a 25% reduction to accommodate grazing

rac►c Farm 1-3 (Tom)
Page 3
The applicator is cautioned that P and K may be over applied while meeting the N requirements. In the future,
regulations may require farmers in some parts of North Carolina to have a nutrient management plan that
addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (i.e. small grain, etc. interseeded in bermudagrass), forage must be removed through
grazing, hay and /or silage. Where grazing, plants should be grazed when they reach a height of six to nine
inches. Cattle should be removed when plants are grazed to a height of four inches. In fields where small grain
etc. is to be removed for hay or silage, care should be exercised not to let small grain to reach materity,
especially late in the season ( i.e. April or May) Shading may result if small grain gets too high and this will
definitely interfere with the stand of bermudagrass. This IOSS of stand will result in reduced yields and less
nitrogen being utilized. Rather than cutting small grain for hay or silage just before heading as is the normal
situation, you are encouraged to cut the small grain earlier. You may want to consider harvesting hay or silage
two to three times during the season, depending on the time small grain is planted in the fall.
The ideal time to interplant small grain, etc. is late September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a height of about two inches before drilling for best
results.
Caution must be exercised in grazing or haying summer annuals under stressed conditions. Nitrate poisoning
may occur in livestock. Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres excluding required buffers, filters strips along
ditches, odd areas unable to be irrigated, and perimeter areas not receiving full application rates due to
equipment limitations. Actual total acres in the field listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at agronomic rates,
The sludge will be nutrient rich and will require precautionary measures to prevent over application of nutrients
or other elements. Your production facility will produce approximately 794 lbs, of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years you will have approximately 3969 lbs. of PAN to utilize. Assuming
you apply this PAN to hybrid bermudagrass hayland at the rate of 300 lbs/acre you will need
13
acres of land. If you apply the sludge to corn at the rate of 125 lbs. of nitrogen per acre you will need 32
acres of land. Please be aware that these are only estmates of the PAN and the land needed. Actual
requirements could vary by 25% depending on the sludge waste analysis, soil types, realistic yields, and
application methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation such that
runoff or ponding occurs. This rate is limited by initial soil moisture content, soil structure, soil texture, water
droplet size, and organic solids. The application amount should not exceed the available water holding capacity

Pack Farm 1-3 (Tom)
Page 4
of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is installed to properly irrrigate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table is provided as a guide for establishing application rates and amounts.
Tract No. Field No. Soil Type Crop Applic. Applic.
Code Rate(in/hr) Amount
4201 Pull1 GoA SB/Rye 0.5 1
4201 Pull AuB SB/Rye 0.5 1
4201 Pivot NbA SB/Rye 0.5 1

Pack Farm 1-3(Tom)
Page 4
of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is installed to properly irrrigate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table is provided as a guide for establishing application rates and amounts.
Tract No. Fiel7No. oil Type Crop Applic. Applic.
Code Rate(in/hr) Amount
4201 Pu1 GoA Corn/Rye 0.5 1
4201 Pull AuB Corn/Rye 0.5 1
4201 Pivot NbA Corn/Rye 0.5 1

Pack Farm 1-3 (Tom)
Page 5
This is the maximum application amount allowed for the soil assuming the amount of nitrogen allowed for the
crop is not over applied. In many situations the application amount shown cannot be applied because of the
nitrogen limitations. The maximum application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on the
average of once every 6 months. In no instances should the volume of the waste be stored in your structure
be within the 25 year 24 hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and the waste applicator to ensure that the spreader equipment is operated
properly to apply the correct rates shown in the tables. Failure to apply the recommended rates and amounts of
nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you have receive the waste analysis report for assistance in determining the
amount of waste per acre and the proper application rate prior to appling the waste.
NARRATIVE OF OPERATION

Pack Farm 1-3 (Tom)
Page 6
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply waste. If the producer
does not own adequate land to properly dispose of waste , he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
standard 393- Filter Strip).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See"Weather and Climate in North Carolina"for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate that runoff
does not occur offsite or to the surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potentuai for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residenrial property boundary
and from any perennial stream or river(other than an irrigation ditch or canal. Animal

waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393- Filter Strips).
Pack Farm 1-3 (Tom)
Page 7
REQUIRED SPECIFICATIONS
(continued)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned
by he landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over-spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a"technical specialist'.
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
17. A protective cover of appropriate vegtation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidences of
erosion, leakage or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a"closure plan"which will eliminate the
possibility of an illigal discharge, pollution and erosion.
19. Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetation and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre-plant with no further applications of animal waste
during the crop season.
21. Highly visible markers shall be installed to mark the top and the bottom elevations of the
temporary storage(pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate-determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
Optimum crop production and maintained. Soil and waste analysis records shall be kept
for five (5)years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.

L�. Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 8
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Pack Farm 1-3 (Tom)
Owner/Manager Agreement Bobby(Quinn) Howard
I (we) understand and will follow and implement the specifications and the operation and maintenance proce-
dures established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the North Carolina Division of Water Quality
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to the surface waters of the state from a storm event less severe than the 25-year, 24 hour
storm.The approved plan will be filed on-site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Bobby(Quinn) Howard
Signature: ( �1, i 141—
14 Date: 1 a-3- �,3
Name of Manager(if different from owner)
Signature:
Date:
Name of Person Preparing Plan:
Affiliation:
Address: Phone:
Signature: Q,1-1C— ,
Date:

rr-�-
O r'
m m ,, -U G3
o -nr- om
m � -, z
0 00 2
rn
ul
t ;k
� I
0)
00
D o - WO TJ
C-)X 0 c
cn T1 cn
\ o ° o CD M
\ C 7 l cn o
;:o
CD © cm
`—° -<
low
Cly
`� C o in
;m
.
p \\� N �9 ,b2o;�•
"f'� Z ice'9i �•h iiii
woe
0 00
Z 4s.

g
WN
OR zzard
Tc Farm
ac 3 1 -304 _
a
Scale 1 _ 250
,� R