310247_Application_20240328

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2024, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2024.
Please do not leave any question unanswered: Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Certificate Of Coverage Number: AWS310247
2. Facility Name: White Flash Hoe Farm
3. Permittee's Name (same as on the Waste Management Plan): Paul D Grady
4. Permittee's Mailing Address: 787 White Flash Rd
City: Mount Olive State: NC
Telephone Number: 919-658-3461 Ext. E-mail:
5. Facility's Physical Address: 133 Jeff Outlaw Rd
City: Mount Olive State: NC
6. County where Facility is located: Dualin
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write 'None"):
10. Operator Name (OIC): tielae.24. hell Jr.
6 y�
11. Lessees Name (if there is not a Lessee, write 'None"):
Smithfield Hog Production
Phone No.: 919-74&35$.4—
yo.z-ON
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Swine - Wean to Finish 3,380
Operation Types:
Swine
Cattle
Dry Poultry
Wean to Finish
Dairy Calf
Non Laying Chickens
Wean to Feeder
Dairy Heifer
Laying Chickens
Farrow to Finish
Milk Cow
Pullets
Feeder to Finish
Dry Cow
Turkeys
Farrow to Wean
Beef Stocker Calf
Turkey Pullet
Farrow to Feeder
Beef Feeder
Boar/Stud
Beef Broad Cow
Wet Poultry
Gilts
Other
Non Laying Pullet
Other
Layers
Zip: 28365
Zip: 28365
OIC 4: _146�
i ky
.4, d
Other Types
Horses - Horses
Horses - Other
Sheep- Sheep
Sheep - Other

13. Waste Treatment Lagoons, Digesters and Waste Storage Ponds (WSP): (Fill/Verify the following information.
Make all necessary corrections and provide missing data.)
Structure
Name
Structure Type
(Lagoon/Digester/
WSP)
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
1
Lagoon
1/12/1993
Full, clay
589,149.00
72,745.00
19.50
Submit one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed
application as required by NC General Statutes 143-215.1OC(d), either by mailing to the address below or sending it via
email to the email address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), sig-rted by the owner and a certified technical sueciali§t, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required MRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is
accurate and complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be
applicable to your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, solids separators, sludge drying system, waste transfers, etc.)
I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.

Note: In accordance with NC General Statutes 143-215.6A and 143-215.613, any person who knowingly makes any false
statement, representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18
U.S.C. Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both
for a similar offense.)
Print the Name of the Permittee/Landowner/Signing Official and Sign below. (If multiple Landowners exist, all landowners
should sign. If Landowner is a corporation, signature should be by a principal executive officer of the corporation):
Name (Print): Gilt / a �r el Title: O U'-, e ,—
Signature: ,8 Date: .2 - .23 " _1_0 X s,[
Name (Print): 1 '0 J-­' • Title: 0 f u--) V_ +—
Signature: Date: 13 -2-07 L Zs
Name (Print):
Signature:
Title:
Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
E-mail: [e-mail]
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636

WASTE UTILIZATION PLAN
Thursday, November 03, 2022
Producer: Paul Grady, Jr.
Farm Name: White Flash Farm 31-247
787 White Flash Rd
Mt. Qlive,NC 28365
Telephone # : [phone]
Type of Operation : Wew% to Finish Swine
Number of Animals: 3380 hogs design capacity
Application Method: Irrigation
e waste from your animal facility must be land applied at a specified rate to prevent
Pollution of surface and/or groundwater. The plant nutrients in the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the fields where
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle_ Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
contents of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and avaialable water holding capacities. Normally waste shall not be applied to
land eroding at greater than 5 tons per acre per year. With special pre -cautions, waste may
be applied to land eroding at up to 10 tons per acre per year. Do not apply waste on
saturated soils, when it is raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To
maximize the value of the nutrients for crop production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied to bare ground not more
than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems. This plan is based on waste application through irrigation for this is
the manner in which you have chosen to apply your waste. if y
waste are not the same. ou choose to inject the waste
in the future, you need to revise this plan. Nutrient levels for in waste and irrigating
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananlysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1 of 9

AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
3380 hogs X 1.62 tons waste/hogs/year = 6422 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3380 hogs X 1,4 Ibs PAN/hogs/year = 4732 PAN/year
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage Will be needed for waste application based on the crop to be grown,
soil type and suface application.
TABLE 1 : ACRES OWNED BY PRODUCER
TRACT FIELD SOIL TYPE &CLASS- CROP YIELD LBS AW COMM ACRES LBS AW APPLIC.
DETERMINING PHASE CODE N/ACRE NIACRF i icGn TINR=
I _ 4137
4137
1
1
- -- - r- --- ---
PANTEGO DRAINED C 1921 150.144
_C-
PANTEGO DRAINED - W � 105i 120.0 5-
0 6.23
935.397
FEB15-JUN
0
6.23
747.693
SEP-APR
4137
* 1
PANTEGO DRAINED
i SB
r---
42j
- -
163.30
0
8.23
1017.66
APR-SEP 1b
4137
1
JPANTEGO DRAINED
SG
1
50
0
6.23
311.5
SEP-MAY
4137
10
RAINS
I C
180
135
0
5.01
676.35
FEB15 JUN
4137
10
RAINS
W
100
106
0
5.01
531.06
SEP-APR
4137
4137
* 10
* 10
RAINS SB
RAINS - -- -
SG
1PANTEGO DRAINED C
IPANTEGO DRAINED W -
! PANTEGO DRAINED _ _ i SB T
3PANTEGO DRAINED _ i S;
PANTEGO DRAINED C
�PANTEGO DRACNED i w �
371 143.19
11 501
192: 150.144
-105�_ 20.015
0
0
5.01
5.01
717.382
250.5
APR-SEP 15
SEP-MAY
4137
* 2
0
5.62
643.809
FEB15-JUN
4137
I* 2
F
0
5.62
674.484
SEP-APR
4137
��r
4137
4137
4137
2
2
* 3
3
42
V
1921
105
163.38
501
150.144
120.015I
0
- a
Q
0
0
0
5.62
5.62
5.62
5.62
5.62
5.62
918.196
281
843.809
674.484
918.196
281
APR-SEP 15
SEP-MAY
FE615-JUN
SEP APR
APR-SEP 15
SEP-MAY
4137
3
PANTEGO DRAINED
�SB I 42j
PANTEGO DRAINED] SG ; 1 f
163.38
50
4137
* 3
4137
4
PANTEGO DRAINED C i ' 192', 150A44
0
01
5.3
5.3
795Y63
636.08
FEB15-JUN
SEP-APR
4137
_
I* 4
PANTEGO DRAINED w �-
_ i` 105i 120.015
{PANTEGO DRAINED SB 421 163.38
4137
4
0
5.3
865.914
APR-SEP 15
{ 4137
* 4
{PANTEGO DRAINED SG j 1 i 50
0
0
5.3
1.02
265
153.147
SEP MAY
FES15-JUN
4137
5 _
PANTEGO DRAINED i C I 1921 150.144
4137
5
PANTEGO DRAINED w � 105 120.015
0
1.02
�I22.4as
SEP-APR_
4137
5
PANTEGO DRAINED SB 42i 163.38
0
1.02
166.648
APR-SEP 15
4137
* 5
(PANTEGO DRAINED ! SG 1150i
0
1.02
51
SEP-MAY
4137
6
PANTEGO DRAINED C-r 192i' 150.1441
4.2
630.605
FEB15-JUN
4137 i*
4137
6
* 6
PANTEGO DRAINED t W i105{ 120.015
AANTEGO DRAINED TSB j 421 163.38
_ 0
o
4.2
4.2
504.063
686. 996
SEP-APR
APR-SEP 15
i 4137 I*
6
PANTEGO DRAINED i SG 1 50
0
4.2
210
SEP-MAY
�4137
411 37
* 7
* 7 !PANTEGO
PANTEGO DRAINED C { 192 150.1441
DRAINED W 105; 120.015
PANTEGODRAINED SB 42; 163.38±
--- ._
DRAINED SG 1.__. 5Q
Rows C i 160 1351
---- '
RAINS 100
W ` 106
�C
0
0
5.24
5.24
786.755
628.879
FE615 JUN
SEP APR
j 4137
_7
_
0
5.24
856.111
APR-SEP 15
C4137 {*
7 IPANTEGO
Oi
_
5.24
- 262
SEP MAY
4137 {=
4_ 137 _
s
* 8
-
0
4.85
668.25
FEB15-JUN
SEP-APR
0
4.95
524.7
413
- 8
RAINS
SB f 371 143.19
0
4.95
708.791
APR-SEP 15
4137 {*
8 {RAINS
}
SG 1 5U
0
4.95
247.5
SEP-MAY
4137
41377
* 9 {RAINS
- 9 - tRglhlg
-
_
-_ '
C j 180 135
0
4.68
331.8
FE1315-JUN
W 100; 106�
0
4.68
496.08
SEP-APR
{ 4137 !*
9
RAINS SB 377 143,191
RAINS -_ SG L _ 1 50i
0
4.68
670.1291APR-SEP
15
413
9
0
4.68
234
SEP-MAY
TUTALS: 11212.3
Page 2 of 9

Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirments. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of NC to have a nutrient management plan that addresses all
nutrients. This plan only addresses Nitrogen.

TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land. See required specifications 2.)
There are no Acres Leased
N Indicates that this field is Being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
* Acreage figures may exceed total acreage in field due to overseeding.
—Lbs AW N (animal waste nitrogen) equals total required nitrogen less any commercial
nitrogen (COMM N) supplied.
The following legend explains the crop codes used in TABLES 1 and 2 above
CROP CODE CROP
UNITS
LBS N/UNIT
C i iCORN
BUSHELS
1.25
SG SMALL GRAIN OVERSEEDEDAC
SB ISOYBEANS
BUSHELS
50
—=
4
W WHEAT _
_
—+ - - BUSHELS --
2.4
;W WHEAT
- - ---
Page 4 of 9

TOTALS FROM TABLES 1 AND 2
ACRES LBS AW
N USED
(TABLE 1 47.87 11,212
TOTALS: 47.87 - — 11,212
AMOUNT OF N PRODUCED: 4,732
'BALANCE -6,480
*** This number must be less than or equal to 0 in order to fully utilize the animal waste N
produced.
Acres show in each of the preceeding tables are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter
areas not receiving full application rates due to equipment limitations. Actual total acres in the
fields listed may, and most likely will be, more than the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of
sludge at agronomic rates. The sludge will be nurturient rich and will require precautionary
measures to prevent over application of nutrients or other elements. Your production facility
will produce approximately 1250.6 pounds of plant available nitrogen (PAN) per year in the
sludge that will need to be removed on a periodic basis. This figure is PAN when
broadcasting the sludge. Please be aware that additional acres of land, as well special
equipment, may be needed when you remove this sludge.
See the attached map showing the fields to be used for the utilization of waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of
irrigation such that runoff or ponding occurs. This rate is limited by initial soil moisture
content, soil structure, soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of the
crop.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 5.92 months. In no instance should the volume of
waste being stored in your structure be within 1.625 feet of the top of the dike.
If surface irrigation is the method of land application for this plan, it is the responsiblity of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application rates and amounts.
APPLICATION APPLICATION
TRACT FIELD SOIL TYPE CROP !(ATE ever 1:......-
4137
4137
*10, *8, *9--
--- - -
RAINS -
RAINS
RAINS
RAINS
-- —------
PANTEGO DRAINED
PANTEGO DRAINED
--
NTE—
PAGO DRAINEn—
- —
PANTEGO DRAINED
- w
SG
SB
C
—3—
.1
~l0, ~8, -9
0.40
4137
*10, *8, *9
0.40
*1
14137
-- -
4137
4
4137
a137
*t0 *8,*9
- -
*t *2, *s #a fi5, *6 *�
_t, _7, _3, _4, _5, 6, ~7
_ _ _
*t, *2, *3, *4, *5, *6, *7
- , *4, *�s-
*i, *z, *3, *6, *�
0.40
----
*1
W
SG
SB
--$--
0.45
0.45
0.45 y
0.45
*1
*1
�
This is the maximum application amount allowed for the soil assuming the amount of
nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Page 5 of 9

NARRATIVE OF OPERATION
Farm is switching to wean to finish. The latset RYE table and nitrogen coefficient were used
to develop this plan. Cotton may be planted and fertilized at the rate 66 Ibs of nitrogen on
pulls 1-7 and 56 Ibs of nitrogen on pulls 8-10.
Page 6 of 10

PLANS & SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division of Water Quality for every
day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land to properly dispose of waste. If the producer
does not own adequate land to properly dispose of waste, he shall provide MRCS with a copy
of a written agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climate conditions, and level of
management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS) or
an Alternative Conservation System (ACS). if an ACS is used the soil loss shall be no greater
than 10 tons per acre per year and appropriate filter strips will be used where runoff leaves
the field. These filter strips will be in addition to "Buffers" required by DEM. (See FOTG
Stantard 393 - Filter Strips and Standard 390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland, the
waste may be broadcast provided the application does not occur during a season prone to
flooding. (See 'Weather and Climate in North Carolina" in the NRCS Technical Reference -
Environment file for guidance.)
*7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control conditions
conducive to odor or flies and to provide uniformity of application_
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of a crop on bare soil.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following. -
the outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from anv perennial stream or river (other that an irrioation ditch or canal. Animal waste
Page 7 of 9

other than swine waste from facilities sited on or after October 1, 1995), shall not be applied
closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal Waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landownwer.
14. Waste shall be applied in a manner not to reach other property and public right - of ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted croplands
provided they have been approved as a land application site by a "technical specialist".
Animal waste should not be applied on grassed waterways that discharge directly into water
courses, except when applied at agronomic rates and the application causes no runoff or drift
from the site.
*16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
*17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon berms
and structures should be inspected regularly for evidence of erosion, leakage or discharge.
*18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the possibility
of an illegal discharge, pollution and erosion.
*19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied as a preemergence with no other applications of
animal waste during the crop season.
*21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume fpr waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soils shall be monitored and alternative crop sites
shall be used when these metals approach excessive levels. pH shall be adjusted for
optimum crop production amd maintained. Soil and waste analysis records shall be kept for
five (5) years. Poultry dry waste application records shall be maintained for three (3) years.
Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina Department of
Agriculture regulations.
* Liquid Systems
Page 8 of 9

NAME OF FARM: White Flash Farm 31-247
OWNER l MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications and the operation and
maintenance precedures estalished in the approved animal waste utilization plan for the farm
named above. I (we) know that any expansion to the existing design capacity of the waste
treatment andlor storage system or construction of new facilities will require a new utilization
plan and a new certification to be submitted to DEM before the new animals are stocked.
I (we) understand that 1 must own or have acces to equipment, primarily irrigation equipment,
to land apply the animal waste described in this waste utilization plan. This equipment must
be available at the appropriate pumping time such that no discharge occurs from the lagoon
in a 25-year 1-day storm event. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY OWNER: Paul Grady, Jr. /
SIGNATURE:- 4L DATE:
NAME OF MANAGER (if different from ner):
please print
SIGNATURE: DATE:
NAME OF TECHNICAL SPECIALIST: Curtis Barwick
AFFILIATION: Barwick Ag Services
ADDRESS (AGENCY): 103 Country Club Circle
Clinton, NC 28328
'� {910) 385-1000
SIGNATURE:"'" DATE: 1/ — 3 — `Z-,2
Page 10 of 9

�, � ` '• r { ` _ �`-ram_• _.✓,
't^ •. � ' ! is :� � l-� 'b' a a �
l ♦ 3:- - ).. as • r � � -1 ...,. �3 -� -) .. t.. + )
f. v► , -'9 �{ 4 ' il,��t' 1+ .i �a 1, •'a1.�
t-"�'._r.�-p�?`!it {� �� ° �1 � � �\ f�Rr. PATIO --- ` •hw� �
�, , 1 •fir
_ F F' / y� ` • y. � �. a -.. +�r �� �� " � - �+ i�� , .FJ -; t� L` � t
74
Ick
1.
Mao
\ 4-V

Operator: White Flash Farm County: D� zplin Date:
11/03/22
-- Distance to nearest residence (other than owner): 1500.0
feet
1. AVERAGE LIVE WEIGHT (ALW)
0 saws (farrow to finish) x 1417 lbs. =
0 Ibs
0 sows (farrow to feeder) x 522 lbs, =
0 lbs
3380 head (finishing only) x 115 lbs. =
388700 Ibs
0 sows (farrow to wean) x 433 Ibs. =
0 Ibs
0 head (wean to feeder) x 30 lbs. =
0 lbs
Describe other:
0
Total Average Live Weight =
388700 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 388700 lbs. ALW x Treatment Volume(CF)/Ib. ALW
Treatment Volume(CF)/Ib. ALW = 1 CF/lb, ALW
Volume = 388700 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
4. TOTAL DESIGNED VOLUME
Inside top length (feet)------------------- 325.0
Inside top width (feet)---------------------- 226.0
Top of dike elevation (feet)----------------- 52.5
Bottom of lagoon elevation (feet)------------ 40.5
Freeboard (feet)----------------------------- 1.0
Side slopes (inside lagoon)----------------- 3.0
:1
Total design volume using prismoidal formula
SSIENDI SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH
DEPTH
3.0 3.0 3.0 3.0 319.0 219.0
11.0
AREA OF TOP
LENGTH * WIDTH _
319.0 219.0 69861 (AREA OF TOP)
AREA OF BOTTOM
LENGTH * WIDTH =
253.0 153.0 38709 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
286.0 186.0 212784 (AREA OF MIDSECTION * 4)
CU. FT. = {AREA TOP + WAREA MIDSECTION) + AREA BOTTOM] *
DEPTH/6
69861.0 212784.0 38709.0
1.8

Total Designed Volume Available = 589149 CU. FT.
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
3250 225.0 73125.0 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
TOTAL DA 73125.0 square feet
Design temporary storage period to Hod to b e 180 days.
5A. Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
Volume = 388700 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 710025 gals. or 94923.2 cubic feet
56. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the la000n water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallons
Volume = 0.0 cubic feet per CIF
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.0 inches
Volume = 7.0 in * DA 112 inches per foot
Volume = 42656.3 cubic feet
5D. Volume of 25 year - 24 hour storm

Volume = 7.5 inches 112 inches per foot * DA
Volume = 45703.1 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 94923 cubic feet
5B. 0 cubic feet
5C. 42656 cubic feet
5D. 45703 cubic feet
TOTAL 183283 cubic feet
6. SUMMARY
Temporary storage period====================>
180
days
Rainfall in excess of evaporation===========>
7.0
inches
25 year - 24 hour rainfall=== ==============>
7.5
inches
Freeboard== ===============================>
1.0
feet
Side slopes====_____________________________>
3.0
: 1
Inside toplength====_______________________>
325.0
feet
Inside top width============================>
225.0
feet
Top of dike elevation=======================>
52.5
feet
Bottom of lagoon elevation==================>
40.5
feet
Total required volume=======================>
571983
cu. ft.
Actual design volume========================>
589149
cu. ft.
Seasonal high watertable elevation (SHWT)===>
46.0
feet
Stop pumping elev.__________________________>
48.7
feet
Must be > or = to the SHWT elev.==========>
46.0
feet
Must be > or = to min. req. treatment el.=>
46.5
feet
Required minimum treatment volume===========>
388700
cu. ft.
Volume at stop pumping elevation============>
404707
cu. ft.
Start pumping elev._________________________>
50.8
feet
Must be at bottom of freeboard & 25 yr_ rainfall
Actual volume less 25 yr.- 24 hr. rainfall==>
543446
cu. ft.
Volume at start pumping elevation===========>
543063
cu. ft.
Required volume to be pumped================>
137579
cu. ft.
Actual volume planned to be pumped==========>
138356
cu. ft.
Min. thickness of soil liner when required==>..
1.8
feet
7. DESIGNED BY: 1 APPROVED
BY:t
DATE: l2-y DATE
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
n
j f
COMMENTS:_ Ei..` Cat l it 5

This lagoon in ursi5ned for waste treateEnt n�erage> *ith
minimum odu'l L�,�rwl' 7'� tiM 0 req:i,- 0& 0 1� 1 n1 A j w � Z �^�
Lc Le peached vvyruany.'n + bemp:rary w:orage) mav �ar) -00
rlushing operations and the amount cf fresh water to ne added tu the
system.
The designed 6 months temporary storage is an estimated ,clune
based on : z) waste from animals; L> excess rainfall aftp.-
evaporation; and 3) the largest 24 hour (one day) rainfall that
cc-cors on the average of once every 25 years. The v0101e Of
waste generateA frn,. a 5ivon number or animals will be fai^lv
constant throughout the year and fru* ycar tc year. T'li�
estimate is based on 7 inches of excess rainfall which is
equal to or exceeds the highest 6 months excess in a year'
The average annual excess rainfall is approximately 8 inches.
Therefore, an average cf 8 inches of will
need to be pumped wanr. year. The R5 y+ar rainfall will `.DL 5= a
factor to consider in an annual pumping cycle, but Mis nturauo
'volume must always be available' A maximum eIOvaticn i~
determined in each design to begin pumping and this is us"ally
the outlet invert of pipe(s) from building(s)' If the outle_
' ipr is not installed on the ele,atio: tc be�in pumpir�. a
peruanent marker wust be installed on txis clevaticn t%
indicate when pvx|,in[ should begin. An clevafion euv� .�
established to stop pumping to mainhain minimum treatment depc/.
16 feet). Pukpiny can be startod or� stopped a:y tine bpWe,,�
these two elevatior.V for Operating Wonvenierce as sitc
conditions permit (we4the`\ soils,
waste without runoff or leaching).
Laoj applicati": cf waKe water is -an
nythad of disposal. Net|.ods of apulioatio, ir.vl�de solid inu`
center pivot, guns, ann! traveling
be taken when applying waste to prcveot ru,`off from the fiel-J
ur damage to rrops'
The following item� are tc be cut:
/
1. It is strongly recommended tha the t~eat*e�t lagoon be
charged to 1/E its capacity to prevent excessive odors durin�
start-up. Precharging reduces the c"..cer.tration or the inixiaz
waste entering the lagoon thereby reducing odors. Solid^
should be covered with effluent at all times' When pre -
charging is completed, flush buildings wit|. ,'�cycicd lag,:,
liquid' Fresh water should not be used for flushing a!L�~
initial filling.
- 2' The attached waste utilization plan shall be followed'
This plan recommends sampling and trsti,`g of waste (see
Attachment B) before land application.

3. Begin poWp-VWt cf the lagoon Vhao fiuAj I 4vel reaches el e,a-
t:1on 53'80 as marked by permanent marker" Ltop Pump -Out
when the fluid level reaches elevation 50 or1-zefore
fluid depth is less than 6 feet deep (this prevents the loss cf
favorable bacteria)' The design temporary svorage, less 25 yea~
_ storm is 137834 cubic feet or 1031002 gallons. As stated
befove, this volume will vary coxsid'^,ntl; Q-om year Lc year.
4' T�e reccmmendcd maxiuum amount Lo apply per irrigation A one
(1) inch and the recommended maxim,n application rate is 0.4
inches per hour.
5. Keep vegetation on embankment Ind areas adjacent to the
mewed a^nual}y. Vegotativo nhould Le to
mainta�n a vigurous stand.
6. Repair any eroded areas or areas damaged by rodents. and
��~�establish in vegetation'
-
�
7. A11 survace runcfp is to be divo~tcd frot U� 1aquur to
stable outlets-
'
8' Keep a minznum uf Dwm 1eet cropland buffer .�._eet of �,ass
ve1e1ated buffc^ wc�.ste "ci7 i n�tio,` 0e�j4 particularly adjen�`.
tD pcnds, lakes, st-eams, open di�c'.e^, ~nc D,' ,.ui '^/yp w1thl
3m0 [eat or a rosiuence cr wlthir Am .-oe! 'Z a neIl'
9' The Elean Water Pon u, 1077 pruhibils iho jisca,a,ge u�
p,llutants into watcry cf tne h:]Ve� SL=U.^.. -!� jecartne..4
Environuent` health, a:O Natural �e����c�', �.`��o/. cf
mental Management, has the responsibility fur enforcing this law'

Emergency Action Plan
This plan will be implemented in the event that wastes from you operations are leaking, overflowing,
or running off the site. You should NOT wait until wastes reach surface waters or leave your
property to consider that you have a problem. You should make very effort to ensure that this does
not happen. This plan should be available to all employees at the facility, as accidents, leaks, and
breaks can happen at any time.
1) Stop the release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to problems are listed below:
a) Lagoon overflow:
• add soil to the berm to increase the elevation of the dam
• pump wastes to fields at an acceptable rate
• stop all additional flow to the lagoon (waterers)
• call a pumping contractor
1� • make sure no surface water is entering the lagoon
Note: These activities should be started when your lagoon level has exceeded the temporary
storage level.
b) Runoff from waste application field:
• immediately stop waste application
• create a temporary diversion or berm to contain the waste on the field
• incorporate waste to reduce further runoff
c) Leaking from the waste distribution system:
i
• pipes and sprinklers:
© stop recycle (flushing system) pump
® stop irrigation pump
© close valves to eliminate further discharge
® separate pipes to create an air gap and stop flow
Page 1

11�
• flush system, houses, solids separators:
© stop recycle (flushing system) pump
® stop irrigation pump
p make sure no siphon effect has been created
® separate pipes to create an air gap and stop flow
d) Leakage from base or sidewall of the lagoon. Often these are seepage as opposed
to flowing leaks:
• dig a small well or ditch to catch all seepage, put in a submersible pump, and
pump back into the lagoon
0 if holes are caused by burrowing animals, trap or remove animals and fill holes
and compact with a clay type soil.
0 other holes may be likewise temporarily plugged with clay soil.
Note: For permanent repair measures, lagoon problems require the consultation of an individual
experienced in their design and installation.
2) Assess the extent of the spill and note any obvious damages.
a) Did the waste reach any surface waters?
b) Approximately how much was released and for what duration?
c) Any damage noted, such as employee injury, fish kills, or property damage?
3) Contact appropriate agencies.
a) During normal business hours, call your DWQ regional office: 910-395-3900; after hours,
emergency number: 800-858-0368 or 919-733-3942. Your phone call should include:
your name, facility, telephone number, the details of the incident, the exact location of the
facility, and the location or direction of movement of the spill, weather and wind
conditions, what corrective measures have been taken, and the seriousness of the
situation.
b) Your integrator: Goldsboro Hog Farms Division, Maxwell Foods, Inc.
919-778-3130 extension 1430
c) If the spill leaves the property or enters surface waters, call the local EMS:
910-296-2160 .
Page 2

d) Instruct EMS to contact the local Health Department: 910-296-2126.
e) (For technical assistance)
Contact CES: 910-296-2143
Local NRCS office: 910-296-2121
4) Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.
5) Contact contract pumping and/or irrigation equipment companies:
a)
b)
c)
6) Contact dirt moving and/or heavy equipment companies:
a)
b)
c)
duplin
Page 3

HE
r
O
c'
273
P
!i
G
c
a
'QII
C
a
fl
C
vi
J�
a
>
v
44
i
y
-u
[
Q u

.a
3
d
N
u
;a
'ob
• t•
,if
i

Vc!
a
M
O
V
i3i�
G
�
R
�
y
�r
R
°OLtd
b
4
0
D
U
a0i � a
•G
Q
14
C � �
�y W V E
R 2 O
UCSC4COCAC�c%l <U
4zZZ7-zzzzzLT.
n
p
?
U
Cs
..+
ou
4j
41 L
p
1 VI w
OP6
41
41
to
Cif p
CO
Old V
Q e0 t.
U
CS w �
O e v Q
�F`$rw a.
T.
W
rw w
00 w Q RCl
E. E O
s
1. H
�F.
Q0oo 3 .. m
3 E `� d
as u v e Q
o,00 �� m
+oaga
fcnrnv�70 UUW0z
9

a
C
O
4)
/.�
CL
E
0
to
.SC
t3
c
0
Q
a)
c
w
L,
a
V
U
s
•�
L"
�
00
O
C! b 10 O
i

so
0
CL
J2
i 0
R

Version —November 26, 2018
Mortality Management Methods
lndlcate which methods) will be implemented,
When selecting multiple methods indicate a primary versus secondary option.
Methods other then those listed must be approved by the State Veterinarian.
Primary
Secondary
Routine Mortality
El�"'l
i,_
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
38 .0200,
im
11
Rendering at a rendering plant licensed under G.S. 106-168.7.
DComplete incineration according to 02 NGAC 52C .0102.
j A composting system approved and permitted by the NC Department of Agriculture & Con-
Ie_�_J! sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
t! NC Department of Agriculture & Consumer Services (G,S. 106-549.70).
Any methodwhich, in the professional opinion of the State Veterinarian, would make possible
U the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
( —"( Mass Mortality Plan
u Mass mortality plans are required forfarms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NODA&00 Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399,4.
Signature of Farm OwnerAOa4ger
x
Signature of Technical Specialist
- z"
Date
Date