310244_Application_20240328

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non-Discharge General Permit
On September 30, 2024, the North Carolina State Non-Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non-Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore,all applications
must be received by the Division of Water Resources by no later than April 3,2024.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Certificate Of Coverage Number: AWS310244
2. Facility Name: Next Generation 2
3. Permittee's Name(same as on the Waste Management Plan): Next Generation Family Ventures LLC
4. Permittee's Mailing Address: 314 Willard Edwards Rd
City: Beulaville State: NC Zip: 28518
Telephone Number: 910-298-3012 Ext. E-mail:
5. Facility's Physical Address: 363 Willard Edwards Rd
City: Beulaville State: NC Zip: 28518
6. County where Facility is located: Du tin
7. Farm Manager's Name(if different from Landowner):
8. Farm Manager's telephone number(include area code):
9. Integrator's Name(if there is not an Integrator,write "None"): Murphy-Brown LLC
10. Operator Name(OIC): Nicholas Edwards Phone No.: 910-290-0531 OIC#: 996567
11. Lessee's Name(if there is not a Lessee,write"None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Swine-Feeder to Finish 2,880
Operation Types:
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses-Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses-Other
Farrow to Finish Milk Cow Pullets Sheep-Sheep
Feeder to Finish Dry Cow Turkeys Sheep-Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment Lagoons,Digesters and Waste Storage Ponds(WSP):(Fill/Verify the following information.
Make all necessary corrections and provide missing data.)
Structure Type Estimated Liner Type Estimated Design Freeboard
Structure (Lagoon/Digester/ Date (Clay,Synthetic, Capacity Surface Area 'Redline"
Name WSP) Built Unknown) (Cubic Feet) (Square Feet) (Inches)
DP Lagoon 7/22/1993 Full,clay 579,929.00 68,800.00 19.50
I L I I I I I
Submit one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed
application as required by NC General Statutes 143-215.10C(d), either by mailing to the address below or sending it via
email to the email address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan(WUP),signed by the owner and a certified technical specialist,containing:
a. The method by which waste is applied to the disposal fields(e.g.irrigation,injection,etc.)
b. A map of every field used for land application(for example:irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation(RYE)for every crop shown in the WUP
£ The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3.Emergency Action Plan
4.Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6.Mortality Control Checklist with selected method noted-Use the enclosed updated Mortality Control Checklist
7.Lagoon/storage pond capacity documentation(design,calculations,etc.) Please be sure the above table is
accurate and complete. Also provide any site evaluations,wetland determinations,or hazard classifications that may be
applicable to your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list,please include the additional components with your submittal.
(e.g.composting,digesters,solids separators,sludge drying system,waste transfers,etc.)
I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included,this application package will be returned to me as incomplete.

Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false
statement, representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18
U.S.C. Section 1001 provides a punishment by a fine of not more than$10,000 or imprisonment of not more than 5 years,or both
for a similar offense.)
Print the Name of the Permittee/Landowner/Signing Official and Sign below.(If multiple Landowners exist,all landowners
should sign. If Landowner is a corporation,signature should be by a principal executive officer of the corporation):
Name(Print): r` �t C3lc) Title:
Signature: '�J`�s!C t,J Date:
Name(Print): J V t C 'kv-S �I o r•�a Title: ' O h�y
Signature: Date: a,'p'l$ .Z-T
Name(Print): Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
E-mail: [e-mail]
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699-1636

Murphy-Brown, LLC 3/10/2014 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s): Dexter Edwards AJ41<Y
Farm Name: D & P Farm 614''t'�°`
County: Du lin
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 2880
Storage Structure: Anaerobic Lagoon
Storage Period: >180 days
Application Method: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made,which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons,ft',tons,etc.):
Ca acit T e Waste Produced Per Animal Total
Farrow to Wean 3212 gal/yr galtyr
Farrow to Feeder 4015 gal/yr gal/yr
Farrow to Finish 10585 galtyr gal/yr
Wean to Feeder 223 gal/yr gal/yr
2880 Feeder to Finish 986 gal/yr 2,839,680 gai/yr
Total 2,839,680 gall r
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Ca acit T e Nitro en Produced -or Animal Total
Farrow to Wean 5.4 Ibs/yr Ibs/yr
Farrow to Feeder 6.5 lbs/yr Ibs/yr
Farrow to Finish 26 Ibs/yr Ibs/yr
Wean to Feeder 0.48 Ibs/yr Ibs/yr
2880 Feeder to Finish 2.3 Ibstyr 6,624 Ibstyr
Total 6,624 Ibs r
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 22.46
Total N Required 1st Year: 6860.3
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 6,850.30
Total Nitrogen Produced by Farm: 6,624.00
Nitrogen Balance for Crops: (226.30)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics,and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

Reception Area Specifications
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs N/Ac Lbs N Total Ibs N 2nd Crop Time to 2nd Crop 2nd Crop Lbs N/Ac Lbs N Total Ibs N Total Total lbs N
Acres e T Code A Yield Its N/Unit Residual /Ac Utilized Code I Yield Ibs N/Unit Residual /Ac Utilized Lbs N/Ac Utilized
4936 Pivot 12.76 F0 B Mar-Se 5.1 50 255 3253.8 K S
e 50
2A 2.2 Fo B Mar-Se 5.1 50 50 6�8320553691.8
255 561 K 50 50 1 671
26 1 Fo B Mar-Se 5.1 50 255 255 K 50 50 50 305 305
2C 0.5 Fo B Mar-Se 5.1 50 255 127.5 K 50 50 25 305 152.5
3A 4.5 Fo B Mar-Se 5.1 50 255 1147.5 K 50 50 225 305 1372.5
3B 1.5 Fo B Mar Set 5.1 50 255 382.5 K Sept-Apr 1 50 50 75 305 457.5
L1-L8 23.24 NbA *see cro options list ed below
Q Ma-Au ust 3.0 50 150
D Feb15-June 117.0 1.14 133.38
F it-Au us 883.0 0.089 78.587
N Se t-A ril 61.0 2.09 riFAu u 127.49
O A sl 40.0 4 1
K Sept-April 1.0 50 50
Totals: 22.48 5727.3 1123 6850.3
3(a)of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields(i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season(i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop Lbs N utilized/unit yield
Barley B 1.6 Ibs N/bushel
Hybrid Bermudagrass-Grazed 50 Ibs N/ton
C Hybrid Bermudagrass- Hay 50 Ibs N/ton
D Corn-Grain 1.25 Ibs N/bushel
E Corn-Silage 12 Ibs N/ton
F Cotton 0.12 Ibs N/Ibs lint
G Fescue-Grazed Ibs N/ton
H Fescue-Hay I Oats 50 Ibs N/ton
1.3 Ibs N/bushel
Rye K Small Grain-Grazed 2.4 Ibs N I bushel
50 Ibs N/acre
L Small Grain - Hay 50 Ibs N/acre
M Grain Sorghum 2.5 Ibs N/cwt
N Wheat
O Soybean 2.4 Ibs N/bushel
p 4.0 Ibs N/bushel
Pine Trees 40 Ibs N/acre/yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

r_ SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/ r/animal Farm TotaUvr
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
2880 Feeder to Finish 0.36 1036.8
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 1036.8 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 5184 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre,you will need 17 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre,you will need 41.472 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop,and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
,.. APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content,soil
structure, soil texture, water droplet size,and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations,the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for>180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil Application Rate Application Amount
Tract Hydrant Tvpe Crop in/hr * inches
4936 Pivot Fo B 0.5 1
2A Fo B 0.5 1
2B Fo B 0.5 1
2C Fo B 0.5 1
3A Fo B 0.5 1
3B Fo B 0.5 1
L1-L8 NbA *see crop 0.4 1
Q *N/A #N/A
#N/A #N/A
6of8

Additional Comments:
Additional land shown is not re juired for the plan to balance, but may be
used if desired. Acres shown on this land are 'wetted acres', with SB515
setbacks applied.
Pulls 1AA, 1A&1B have been replaced with Pivot, per irrigation design b
Kevin Westin.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: D &P Farm �-
Owner: Dexter Edwards
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. Itwe know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Dexter Edwards
—�o y
Signature:
Date
Name of Manager(if different from owner):
Signature:
Date
Name of Technical Specialist: Toni W. Kin
Affiliation: Murphy-Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 866
Warsaw, NC 28398
Telephone: [phone]
Signature:
Date _
8of8

Required Specifications For Animal Waste Management
I. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during operation
or land application. Any discharge of waste that reaches surface water is
prohibited.
2. There must be documentation in the design folder that the producer either owns
or has an agreement for use of adequate land on which to properly apply the
waste. If the producer does not own adequate land to properly dispose of the
waste, he/she shall provide evidence of an agreement with a landowner, who is
within a reasonable proximity, allowing him/her the use of the land for waste
application. It is the responsibility of the owner of the waste production facility to
secure an update of the Nutrient Management Plan when there is a change in the
operation, increase in the number of animals, method of application, receiving
crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for
realistic crop yields based upon soil type, available moisture, historical data,
climatic conditions, and level of management, unless there are regulations that
restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year.
Waste may be applied to land eroding at more than 5 tons per acre per year but
less than 10 tons per acre per year provided grass filter strips are installed where
runoff leaves the field (see USDA, NRCS Field Office Technical Guide Standard
393 - Filter Strips).
S. Odors can be reduced by injecting the waste or by disking after waste application.
Waste should not be applied when there is danger of drift from the land
application field.
6. When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to
conservation tilled crops or grassland, the waste may be broadcast provided the
application does not occur during a season prone to flooding (see "Weather and
Climate in North Carolina" for guidance).
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such
that runoff does not occur offsite or to surface waters and in a method which does
not cause drift from the site during application. No ponding should occur in order
to control odor and flies.
-------- ---- --- - --^--- -- ________
176392 -- --- --------
------------
Database Version,.1 Date Printed: 3/23/201 1 Specification Page I

8. Animal waste shall not be applied to saturated soils, during rainfall events, or
when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that
the crop is not covered with waste to a depth that would inhibit growth. The
potential for salt damage from animal waste should also be considered.
10. Nutrients from waste shall not be applied in fall or winter for spring planted
crops on soils with a high potential for leaching. Waste/nutrient loading rates on
these soils should be held to a minimum and a suitable winter cover crop planted
to take up released nutrients. Waste shall not be applied more than 30 days prior
to planting of the crop or forages breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the
following: The outer perimeter of the land area onto which waste is applied from
a lagoon that is a component of a swine farm shall be at least 50 feet from any
residential property boundary and canal. Animal waste, other than swine waste
from facilities sited on or after October 1, 1995, shall not be applied closer that 25
feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than
those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public
right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or
wetlands by a discharge or by over-spraying. Animal waste may be applied to
prior converted cropland provided the fields have been approved as a land
application site by a "technical specialist". Animal waste shall not be applied on
grassed waterways that discharge directly into water courses, and on other
grassed waterways, waste shall be applied at agronomic rates in a manner that
causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks,
etc., shall not be discharged into the animal waste management system.
-----------
176392 Database Version 3.1 - _ ----- -
Date Printed: 3/23/201 1 Specification Pale 2

-� 17. A protective cover of appropriate vegetation will be established on all disturbed
areas (lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as
necessary, to protect the vegetation. Vegetation such as trees, shrubs, and other
woody species, etc., are limited to areas where considered appropriate. Lagoon
areas should be kept mowed and accessible. Berms and structures should be
inspected regularly for evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate
the possibility of an illegal discharge, pollution, and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a
regular basis to prevent breakdowns, leaks, and spills. A regular maintenance
checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops
for direct human consumption. However, if animal waste is used on crops for
direct human consumption, it should only be applied pre-plant with no further
applications of animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom elevations of
the temporary storage (pumping volume) of all waste treatment lagoons.
Pumping shall be managed to maintain the liquid level between the markers. A
marker will be required to mark the maximum storage volume for waste storage
ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the
rate-determining nutrient, unless other restrictions require waste to be applied
based on other nutrients, resulting in a lower application rate than a nitrogen
based rate. Zinc and copper levels in the soils shall be monitored and alternative
crop sites shall be used when these metals approach excessive levels. pH shall be
adjusted and maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of five years. Poultry dry waste application
records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for five (5)
years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
----- --- ------------ _
176392 Database Version 3.1 Date Printed: 3/23/201 1
Specification Page 3

Crop Notes
The following crop note applies to field(s): 3A, 313, 3C, 31), 4A,413,4C
Small Grain: CP,Mineral Soil, medium leachable
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from
October 15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5%for
each week seeding is delayed beyond the optimum time. See the seeding rates table for applicable
seeding rate modifications in the current NCSU "Small Grain Production Guide". Also, increase the
initial seeding rate by at least 10%when planting no-till. Oats should be planted at 2 bushels/acre and
rye at 1-1 1/2 bushels/acre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is
essential. Review the NCSU Official Variety "green book" and information from private companies to
select a high yielding variety with the characteristics needed for your area and conditions. Apply no more
than 30 lbs/acre N at planting. Phosphorus and potash recommended by a soil test can also be applied at
this time. The remaining N should be applied during the months of February-March.
The following crop note applies to field(s): IA, 1B
Small Grain: CP, Mineral Soil, medium leachable
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from
October 15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for
-- each week seeding is delayed beyond the optimum time. See the seeding rates table for applicable
seeding rate modifications in the current NCSU "Small Grain Production Guide". Also, increase the
initial seeding rate by at least 10% when planting no-till. Oats should be planted at 2 bushels/acre and
rye at 1-1 1/2 bushels/acre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is
essential. Review the NCSU Official Variety "green book" and information from private companies to
select a high yielding variety with the characteristics needed for your area and conditions. Apply no more
than 30 lbs/acre N at planting. Phosphorus and potash recommended by a soil test can also be applied at
this time. The remaining N should be applied during the months of February-March.
176392 Database Version 3.1 Date Printed: 03-23-2011 Crop Note Page Page 1 of 2

The following crop note applies to field(s): 3A, 313, 3C, 3D, 4A,413, 4C
Berinudagrass: CP,Mineral Soil,Moderately Well Drained.
Adaptation: Well-adapted.
In the Coastal Plain,hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31, Cover sprigs 1"to 3"
deep(1.5"optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2'to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing
conditions.Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization
of Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance.
The following crop note applies to field(s): 1 A, 1 B
Bermudagrass: CP, Mineral Soil, Moderately Well Drained.
Adaptation: Well-adapted.
>.� In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs l"to 3"
deep(1.5"optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce frill groundcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime,phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization
of Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance.
176392 Database Version 3.1 Date Printed: 03-23-2011 Crop Note Page Page 2 of 2

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based upon soil type, available moisture, historical data, climatic conditions,
and level of management, unless there are regulations that restrict the rate of applications
for other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but I
per acre per year provided grass filter strips are istalled here runoff leaves the feld
(See USDA, MRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and
flies.
—' 8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
Any new swine facility sited on or after October 1, 1995 shall comply with the following:
11 The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property
boundary and canal. Animal waste, other than swine waste from facilities sited on or after
October 1, 1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
Animal waste shall not be applied closer than 200 feet of dwellings other than those
13 owned by the landowner.
Waste shall be applied in a manner not to reach other property and public right-of-ways.
14
Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over-spraying. Animal waste may be applied to prior converted cropland
15 provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
16
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
19 basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
Animal waste can be used in a rotation that includes vegetables and other crops for direct
20 human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre-plant with no further applications of animal
waste during the crop season.
Highly visible markers shall be installed to mark the top and bottom elevations of the
21 temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate-determining
22 nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
Dead animals will be disposed of in a manner that meets North Carolina regulations.
23
3of3

Next Generation Form , _ � � • n, .1:�'�� a �5 i ���'Zrr�`��1 � • `J •� �yP= f ..
Fay -
New . P ivo
�► Specifications:
Valley Pivot
360 Machine Length
1 00' End Gun Radius
d
PPi
9.35 Ac, w/o End Gun
Y 12.76 Ac. w/End Gun E
y'•�4i �tY r�
0
` g '0029 t9
Designed 'id Installed cry
Benchrm 'Buildings,& irrigcr � #
1 1�

U$PFam IAA
Q 1B
O
O
1A 28
1AA- 5.2 sA
1A - 4.5
18 - 4.5
2A - 2.239
2B - 1.0
2C - 0.5
3A - 4.5
3B - 1.5

3i-aV-Y
Swine Farm Waste Management Odor Control Checklist
Source Cause BMPs to Minimize Odor Site Specific Practices
Farmstead • Swine production M Vegetative or wooded buffers;
tR Recommended best management practices;
© Good judgment and common sense
Animal body surfaces • Dirty manure-covered animals O Dry floors
Floor surfaces o Wet manure-covered floors M Slotted floors; --
Gi~ Waterers located over slotted floors;
O Feeders at high end of solid floors;
O Scrape manure buildup from floors;
O Underfloor ventilation for drying
Manure collection pits 0 Urine; Q.-Frequent manure removal b flush
,,pit recharge,
• Partial microbial decomposition or scrape;
O Underfloor ventilation
Ventitation exhaust fans o Volatile gases; d Fan maintenance; -
Dust Cl Efficient air movement
Indoor surfaces • Dust lT Washdown between groups of animals;
O Feed additives;
O Feeder covers;
O Feed delivery downspout extenders to feeder
_ covers
Flush tanks 0 Agitation of recycled lagoon O Flush lank covers;
liquid while tanks are filling O Extend fill lines to near bottom of tanks with
anti-siphon vents
Flush alleys • Agitation during wastewater O Underfloor flush with underfloor ventilation
conveyance
Pit recharge points • Agitation of recycled lagoon O Extend recharge lines to near bottom of pits
liquid while pits are filling with anti-siphon vents
Lift stations • Agitation during sump tank O Sump tank covers
filling and drawdown
Outside drain collection a Agitation during wastewater O Box covers
or junction boxes conveyance
AMOr November 11, 1996, Page 3
! s

Source Cause
End of drainpipes BMWs to minimize Odor
oon P�� • Agitation during wastewater O Site Spec-
lagoon la Extend ic 1'nctices
g conveyance discharge Pout of pipes underneath
Lagoon surfaces . lagoon liquid level
Volatile gas emissions; &Y"pro r lagoon liquid capacity;
Pe
• Biological mixing; C�''"Correct lagoon stator -
• Agitation p procedures;
O Minimum surface area-to-volume ratio;
❑ Minimum agitation when.putnping;
0 Mechanical aeration;
Irrigation sprinkler a High pressure agitation; 9-"'Proven biological additives
nozzies LI Irrigate on dry days with little Or no wind;
• Wind drift O""'Minimum recommended operating Pe g pressure;
B``Pump intake near lagoon liquid surface;
LPump from second-stage oon
Storage tank or basin • Partial microbial decomposition-
surface O Bottom or midlevel loading;
• Mixing while filling; O Tank covers;
• Agitation when emptying O Basin surface mats of solids;
0 Proven biological additives or oxidants
Settling basin surface • Partial microbial decom position; O Extend drainpipe outlets underneath liquid
• Mixing while filling; level; .
• Agitation when emptying O Remove settled solids regularly
Manure,slurry or sludge • Agitation when spreading;
spreader outlets O Soil injection of slung/sludges;
• Volatile gas emissions Cl Wash residual manure from spreader after use;
Uncovered manure, Volatile gas emissions while ❑ Proven biological additives or oxidants
slurry or sludge on Geld drying Cl drying injection of slurry/sludges �---
surfaces ❑ Soil incorporation within 48 hrs.;
O Spread in thin uniform layers for rapid drying;
Dead animals
❑ Proven biological additives or oxidants
• Carcass decomposition
Dead animal disposal • Carcass decomposition 3`!'roper disposition of carcasses
pits 0 Complete covering of carcasses in burial pits;
• Incomplete combustion O Proper location/construction of disposal pits
Incinerators
O Secondary stack burners
AMOC-November 11, 1996, Page 4

Source Cause
Standing water around . BMPs to Miaimin Odor
Proper drainage; 13°"Grade and landscape such that water drains Site Slecific rractkes
facilities
• Microbial decomposition of away from facilities
organic matter
Manure tracked onto • Poorly maintained access roads public roads from farm [a''"Fatm access road maintenance
access
Additional Information
Swine Manure Management; o200 Rule1BMP Packet Available From:
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet NCSU,County Extension Center
Swine Production Facility Manure Management:Pit Recliarge-Lagoon Treatment; EBAE 12&88 NCSU-BAE
Swine Production Facility Manure Management:Underfloor Flush-Lagoon Treatment; EBAE 129-88 NCSU-SAE
or Livestock Manure Treatment and Storage; EBAE 103-83 NCSU-BAE
Lagoon Design and Management f
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet NCSU-BAE
Controlling Odors from Swine Buildings; PIH-33 NCSU-BAE
Environmental Assurance Program; NPPC Manual NCSU-Swine Extension
Options for Managing Odor; a report from the Swine Odor Task Force NC Pork Producers Assoc
Nuisance Concerns in Animal Manure Management:Odors and Flies; PRO107, 1995 Conference Proceedin s NCSU Agri Communications
g Florida Cooperative Extension
AMOC-November 11, 1996, Page 5

Insect Control Checklist for Animal Operations
IIA91's to confroi Insects
blush t iwtcis Liquid Systeulls
.solids �� - - Sites Specific 1'ractires - ---
Accuo►ulatiun of - _ - - -- - - ---------
f'lusll syslem is designed and operated -
sufficiently to remove accuntttlated solids from -
�,,/utters as designed.
t�' Remove bridging of accnmulaled solids at
ag�,uos and fits .-- Crusted Solids - discharge
f Maintain lagoons,settling basins and 1►its where -
pest breeding is apparent to ntiniutize file -- -- -
crosting of solids to a depth of no more than 6-
l.ae.csI,iVc VcLctative- -. - --- - -- -- uteltes over more than 30%ofstn lace.I)ccaying vegetation _
r u u�ti th Iblaintain vegetative control along
lagoons attd other impoundments to prevent
accumulation of decaying vegetative matter
- - ---- -- —- __ ----- --- along water's edge on imporurrlmcnt's periutelcr.
-- _ 1)1-ysyslettt! ��—
• Iced Spillage --- -------- -- -- -- — - --
�' Uesign,operate and maintain feed syslertts —
bunkers and trouc;hs)to minimize file -- -
�cctltnulation of decaynng wastage.
t't ('lean ap Village on if rowine basis(e_g-, 7- 10
day interval during summer, 15-30 day iulerval
l�cd titer.,} nurlatiuns Of It.ed residue inring wuper).
Accu
I� ticducc moisUtre accamul:rliou witl:ir�anej- -- - - --.
around immediate periutcler of fcrxl slurat;e
areas by insuring drainage away!icon silt.
and/or providing adeytl:rte crnuaintnettt(e_g.,
coverer!bin for brewer's gr:►io and similar hil;it
nroisture grain producls).
f7 inspect titr anc!retl►ovc or bicak up ae r�anulated
solids in filler Wilts around feed slorage as
needed.
AN - I(�,tcii�her 1I, tc3:}G, I'age 1

_ .tiuyrcc
An;ural!luldirtb q sr ,tst ,r -- ---�-- Cause -
Accumnlations ofanintal wastes IIMPs fo Control Insects - -
and feed wastage Eliminate low - --
areas Ilia!trap ntotsture alonb -- _ ~�
fences st,ec;r- IC ract ces-
and other locations where waste accumulates and disturbance by animals is y
minimal.
n Maintain fence rows and filter strips around
animal holding areas to minimize
g; accumulations of wastes(i.e.,inspect for and
iA Y I+lanurc Ilaurllin `- remove or break up accumulated solids as
S)Stcnts Acctuuulatiorts of animal+vaster needed).
[7 R day
ve
during winter)whe
spillage on a routine basis e-•--da interval during surnmer; 15-30�1.ry ir>ferv�l
re manure is loaded for lane! ~--- ---
application or disposal.
rl Provide li)r adequate drainage around manure
stockpiles.
- n Inspect for an('remove or break tip accttrntrlaterl
----_- ..
- - - wastes in I;Iter strips around stockpiles and
I'ur mute intunttatiun contact the Cooperative I:xtcnsiup .�---- rnantire handling areas as needed.
k,,lcrl,l+, !J[ Service,!)el►artntcnt of l:ntomolo• , _._.--__ --
65. Rox 7(!3,PJurth('arolur,t State IJuivr•tsity, ---- ---- - ---
140venj13,;r !!. !rl')G, !'a8e2
i

EMERGENCE' ACTION PLAN
PHONE NUMBERS
DWQ Ord -79.1 .. 7.zis
EMERGENCY MANAGEMENT SYSTEM 7//
SWCD 1 21 �-c
NRCS — a��s.6-;PeLv
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow-possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field-actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers-action include:
a. Stop recycle pump.
b. Stop irrigation pump. — —
c. Close valves to eliminate further discharge.
d. Repair all Ieaks prior to restarting pumps.
D: Leakage from flush systems, houses, solid separators-action include:
a. Stop recycle pump.
b. Stop irrigation pump. i
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
-. 1 December 18, 1996

e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks- possible action:
a. Dig a small sump or ditch away from the embankment to catchall seepage,
put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger(either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality)
regional office; Phone - . After hours, emergency number: 919-733-3942.
Your phone call should include: your name, facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility,the location or
direction of movement of the spill,weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number -
c. Instruct EMS to contact Iocal Health Department.
d. Contact CES, phone number - - , local SWCD office phone number
and local NRCS office for advice/technical assistance phone number - -
4: If none of the above works call 911 or the Sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off-site
damage.
a. Contractors Name:
b. Contractors Address:
c. Contractors Phone:
2 December 18, 1995

6: Contact the technical specialist who certified the lagoon (NRCS, Consulting
Engineer, etc.)
a. Name:
b. Phone:
7: Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
3 December 18, 1996

� 1" o2TT
Version—November 26,2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary.versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should beat least one foot above the seasonal
high water table.Attach burial location map and plan.
a Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture&Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off-farm,
additional requirements must be met and a permit is required from NC DEQ.
D In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture&Consumer Services(G.S. 106-549.70).
a Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
aMass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm-specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measwres for disposal according to G.S. 106-399.4.
nature of Farm Owner/Manager - Date
Signature of Technical Specialist Date

.i
&-ator:DEXTER EDWARDS County: DUPLIN Date: 07/22/93
)istance to nearest residence (other than owner) : 2000.0 feet
1. STEADY STATE LIVE WEIGHT
0 sows (farrow to finish) x 1417 lbs. 0 lbs
0 sows (farrow to feeder) x 522 lbs. 0 lbs
2880 head (finishing only) x 135 lbs. - 388800 lbs
0 sows (farrow to wean) x 433 lbs. 0 lbs
0 head (wean to feeder) x 30 lbs. = 0 lbs
TOTAL STEADY STATE LIVE WEIGHT (SSLW) = 388800 lbs
7. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 388800 lbs. SSLW x Treatment; Volume(CF)/lb. SSLW
Treatment Volume(CF)/lb. SSLW= 1 cF/lb. SSLW
Volume = 388800 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet % „Owner Sludge rwillsbe removed ts no gassneeded."
4. TOTAL DESIGN VOLUME
Inside top length 320.0 feet ; Inside top width 215.0 feet
Top of dike at elevation -48.5 feet
Freeboard 1.0 feet ; Side slopes 2.5 : 1 (Inside lagoon)
Total design lagoon liquid level at elevation 47.5 feet
Bottom of lagoon elevation 36.5 feet
Seasonal high water table elevation 42.0 feet
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
2.5 2.5 2.5 2.5 315.0 210.0 11.0
AREA OF TOP
LENGTH * WIDTH =
315.0 210.0 66150.0 (AREA OF TOP)
AREA OF BOTTOM
LENGTH * WIDTH =
260.0 155.0 40300.0 (AREA of BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
287.5 182.5 209875.0 (AREA OF MIDSECTION * 4)
CU. FT. = AAREA TOP + (4*AREA MIDSECTION) + AREA BOTTOMU * DEPTH/6
66150.0 209875.0 40300.0 1.8
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 579929 CU. FT.
C0010115052!

r
'TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
320.0 215.0 68800.0 square feet
Buildings (roof and lot water)
Length * Width =
0.0 0.0 0.0 square feet
TOTAL DA 68800.0 square feet
Design temporary storage period to be 180 days.
R. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 388800 Lbs. SSLW * CF of Waste/Lb./Day * 180 days
Volume = 94947 cubic feet
:L. Volume of wash water
�% This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
�C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 40133.3 cubic feet
s�-
Ct)p10115o530

7
5D. Volume of 25 year - 24 hour storm
Volume = 7.5 inches / 12 inches per foot * DA
Volume = 43000.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 94947 cubic feet
58. 0 cubic feet
5C. 40133 cubic feet
5D. 43000 cubic feet
TOTAL 178081 cubic feet
� . SUMMARY
Total required volume 566881 cubic feet
Total design volume avail. 579929 cubic feet
Min. req. treatment volume plus sludge accumulation 388800 cubic feet
At elev. 44.5 feet ; Volume is 393067 cubic feet (end pumping)
Total design volume less 25yr-24hr storm is 536929 cubic feet
At elev. 46.9 feet ; Volume is 540710 cubic feet (start pumping)
Seasonal high water table elevation 42.0 feet
DESIGNED BY: i ` PPROVED BY:
DATE: as ''3/
J DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
-- � an4 A I I;A4i'lI.

OPERATION & MAINTENANCE PLAN
Proper lagoon liquid management should be a year-round priority, It is especially
important to manage levels so that you do not have problems during extended rainy and
wet periods,
Maximum storage capacity should be available in the lagoon for periods when the
receiving crop is dormant (such as wintertime for bermudagrass) or when there are
extended rainy spells such as the thunderstorm season in the summertime. This means
that at the first signs of plant growth in the later winter/early spring, irrigation accordi ry enough to
ng to
a farm waste management plan should be done whenever the land is d
receive lagoon liquid. This will make storage space available in the lagoon for future wet
Periods. In the late summer/early fall the lagoon should be pumped down to the low
marker (see Figure 2-1) to allow for winter storage. Every effort should be made to
maintain the lagoon close to the minimum liquid level as long as the weather and waste
utilization plan will allow it.
Waiting until the lagoon has reached its maximum storage capacity before starting to
irrigate does not leave room for storing excess water during extended wet periods.
Overflow from the lagoon for any reason except a 25-year, 24-hour storm is a violation of
state law and subject to penalty action.
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for the dam.
Fescue or common bermudagrass are the most common vegetative
covers. The vegetation should be fertilized each year, if needed, to
maintain a vigorous stand. The amount of fertilizer applied should be
based on a soils test, but in the event that it is not practical to obtain
a soils test each year, the lagoon embankment and surrounding areas
should be fertilized with 800 pounds per acre of 10-10-10, or
equivalent.
Brush and trees on the embankment must be controlled. This may be
done by mowing, spraying, grazing, chopping, or a combination of
these practices. This should be done at least once a year and
possibly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the herbicide must not be allowed to enter
the lagoon water. Such chemicals could harm the bacteria in the Iagoon that are treating
the waste.
Maintenance inspections of the entire lagoon should be made during the initial filling of
the lagoon and at least monthly and after major rainfall and storm events, Items to be
checked should include, as a minimum, the following:
Waste Inlet Pipes, Recycling Pipes, and Overflow Pipes---look for;
1. separation of joints
2. cracks or breaks
3, accumulation of salts or minerals
4, overall condition of pipes

-- Lagoon surface---look for:
1. undesirable vegetative growth
2. floating or lodged debris
Embankment---look for:
1. settlement, cracking, or "jug" holes
2. side slope stability---slumps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds, These waves can erode the lagoon sidewalls, thereby weakening the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the lagoon may be
used to reduce the wave impacts,
Any of these features could lead to erosion and weakening of the dam. If your lagoon has
any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a threat
of a waste discharge, However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps---check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, or a large amount of vibration, may indicate that the pump is in need or repair or
replacement.
NQTB: Pumping systems should be inspected and operated frequently enough so that you
are not completely "surprised" by equipment failure. You should perform your pumping
system maintenance at a time when your lagoon is at its low level. This will allow some
safety time should major repairs be required. Having a nearly full lagoon is not the time
to think about switching, repairing , or borrowing pumps. Probably, if your lagoon is full,
your neighbor's lagoon is full also. You should consider maintaining an inventory of spare
parts or pumps,
Surface water diversion features are designed to carry all surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parking lot runoff) away from your lagoon and other waste
treatment or storage structures. The only water that should be
coming from your lagoon is that which comes from your flushing
(washing) system pipes and the rainfall that flits the lagoon directly.
You should inspect your diversion system for the following,
l, adcquate vegetation
2, diversion capacity
3, ridge berm height

Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recordin4 your rainfall for this to work). Knowing this should help in
planning irrigation applications and storage, If your lagoon rises excessively, you may
have an inflow problem from a surface water diversion or there may be seepage into the
lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before
waste loading begins, taking care not to erode lining or bank slopes.
3. Drainpipes into the Iagoon should have a flexible pipe extender on the
end of the pipe to discharge near the bottom of the lagoon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining.
4. When possible, begin loading new lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon
liquid volume. This seeding should occour at least two weeks prior to the
addition of wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below
7.0, add agricultural lime at the rate of 1 pound per 1000 cubic feet of
lagoon liquid volume until the pH rises above 7.0. Optimum lagoon liquid
pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate
biological activity, Consultation with a technical specialist is recommended
if these conditions occur for prolonged periods, especially during the warm
season.
Loading:
The more frequently and regularly that wastewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily are
optimum for treatment. Pit recharge systems, in which one or more buildings are drained
and recharged each day, also work well.

Practice water conservation---minimize building water usage and
spillage from leaking waterers, broken pipes and washdown through
Proper maintenance and water conservation.
Minimize feed wastage and spillage by keeping feeders adjusted, This
will reduce the amount of solids entering the lagoon
Management:
• Maintain lagoon liquid level between the permanent storage level and
the full temporary storage level.
Place visible markers or stakes on the lagoon bank to show the
minimum liquid level and the maximum liquid lever (Figure 2-1).
Start irrigating at the earliest possible date in the spring based on
nutrient requirements and soil moisture so that temporary storage
will be maximized for the summer thunderstorm season. Similarly,
irrigate in the late summer/early fall to provide maximum lagoon
storage for the winter.
The lagoon liquid level should never be closer than 1 foot to the lowest
point of the dam or embankment.
• Do not pump the lagoon liquid level lower that the permanent storage
level unless you are removing sludge,
Locate float pump intakes approximately 18 inches underneath the liquid
surface and as far away from the drainpipe inlets as possible.
Prevent additions of bedding materials, long-stemmed forage or vegetation,
molded feed, plastic syringes, or other foreign materials into the lagoon.
Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed,
Maintain strict vegetation, rodent, and varmint control near lagoon edges.
Do not allow trees or large bushes to grow on lagoon dam or embankment.
• Remove sludge from the lagoon either when the sludge storage capacity is
full or before it fills 50 percent of the permanent storage volume.
If animal production is to be terminated, the owner is responsible for
obtaining and implementing a closure plan to eliminate the possibility of a
pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:

• proper lagoon sizing,
• mechanical solids separation of flushed waste,
• gravity settling of flushed waste solids in an appropriately designed basin, or
minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long term will:
have more nutrients,
have more odor, and
• require more land to properly use the nutrients.
Removal techniques:
Hire a custom applicator.
Mix the sludge and lagoon liquid with a chopper-agitator impeller
pump through large-bore sprinkler irrigation system onto nearby cropland;
and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; mix remaining sludge; pump into liquid sludge applicator; haul
and spread onto cropland or forageland; and soil incorporate.
• Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; dredge sludge from lagoon with dragline or sludge barge; berm
-- an area beside lagoon to receive the sludge so that liquids can drain back
into lagoon; allow sludge to dewater; haul and spread with manure spreader
onto cropland or forageland; and soil incorporate.
Regardless of the method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that field and crop
requirement. Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage. Close
attention by the pumper or drag-line operator will ensure that'the lagoon liner remains
intact. If you see soil material or the synthetic liner material being disturbed, you should
stop the activity immediately and not resume until you are sure that the sludge can be
removed without liner injury. If the liner is damaged it must be repaired as soon as
Possible.
Sludge removed from the lagoon has a much higher phosphorus and heavy metal content
than liquid. Because of this it should probably be applied to land with low phosphorus
and metal levels, as indicated by a soil test, and incorporated to reduce the chance of
erosion. Note that if the sludge is applied to fields with very high soil-test phosphores, it
should be applied only at rates equal to the crop removal of phosphorus. As with other
wastes, always have your lagoon sludge analyzed for its nutrient value.
The application of sludge will increase the amount of odor at the waste application site.
Extra precaution should be used to observe the wind direction and other conditions which
could increase the concern of neighbors.

- Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned discharge of wastewater from the structure. Types
Of failures include leakage through the bottom or sides, overtopping, and dam, AssumingPe g breach of the
ensuring structure.safety. Items which may lead o lagoon failuresinclude responsibility for
• Modification of the lagoon structure---an example is the placement of a pipe
in the dam without proper design and construction. (Consult an expert in
lagoon design before placing any pipes in dams,)
• Lagoon liquid levels---high levels are a safety risk.
Failure to inspect and maintain the dam,
Excess surface water flowing into the lagoon.
Liner integrity---protect from inlet pipe scouring, damage during sludge
removal, or rupture from lowering lagoon liquid level below groundwater
table.
NOTE: If lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the dam. Once this damage starts, it can quickly cause a large discharge
of wastewater and possible dam failure.