100036_Application_20240326

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2024, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2024,
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
I. Certificate Of Coverage Number: AWS100036
2. Facility Name: Funston Farms - Old.& New
3. Permittee's Name (same as on the Waste Management Plan): A JeffEw
4. Permittee's Mailing Address: 7406 Funston Rd SE
City: Winnabow State: NC
Telephone Number: 910-253-5643 Ext. E-mail: mare reen75Aa ahoo.com
5. Facility's Physical Address: 7406 Fuston Rd
City: Winnabow State: NC
6. County where Facility is located. Brunswick
7. Farm Manager's Name (if different from Landowner): Marc D Green
g. Farm Manager's telephone number (include area code): 910-876-5686 Ext.
9. Integrator's Name (if there is not an Integrator, write "None"): Murphy -Brown LLC
10. Operator Name (OIC): Marc D. Green Phone No.: 910-876-5686
11, Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type
Swine - Feeder to Finish
Swine - Farrow to Wean
Operation Types:
Swine
Wean to Finish
Wean to Feeder
Farrow to Finish
Feeder to Finish
Farrow to Wean
Farrow to Feeder
Boar/Stud
Gilts
Other
Cattle
Dairy Calf
Dairy Heifer
Milk Cow
Dry Cow
Beef Stocker Calf
Beef Feeder
Beef Broad Cow
Other
en....hip rn,int
r,/ru
2,900
Dry Poultry
Non Laying Chickens
Laying Chickens
Pullets
Turkeys
Turkey Pullet
Wet Poultry
Non Laying Pullet
Layers
Zip: 28479
Zip: 28479
OTC #: 999054
Other Times
Horses - Horses
Horses - Other
Sheep - Sheep
Sheep - Other

13. Waste Treatment Lagoons, Digesters and Waste Storage Ponds (WSP): (Fill/Verify the following information.
Make all necessary corrections and provide missing data.)
Structure
Name
Structure Type
(Lagoon/Digester/
WSP)
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
FINISHER
Lagoon
1/1/1987
Full, clay
505,759.00
84,071.00
20.00
SOW
Lagoon
1/1/1990
Full, clay
1,819,001.00
169,884.00
20.00
I
Submit one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed
application as required by NC General Statutes 143-215.10C(d), either by mailing to the address below or sending it via
email to the email address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), signed by the owner and a certified technical sr-)ecialist, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is
accurate and complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be
applicable to your facility.
S. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, solids separators, sludge drying system, waste transfers, etc.)
I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.

Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false
statement, representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18
U.S.C. Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both
for a similar offense.)
Print the Name of the Permittee/Landowner/Signing Official and Sign below. (If multiple Landowners exist, all landowners
should sign. If Landowner is a corporation, signature should be by a principal executive officer of the corporation):
Name (Print): a� � L f f Title: ' 1-q ..-C 1 < r
Signature: _ _ � _ _ Date: fI ��-1
Name (Print):
Signature:
Name (Print):
Signature:
Title:
Date:
Title: _
Date: _
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
E-mail: [e-mail]
deq.ne.gov
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636

ROY COOPER
Governor
EUZABETH S. BISER
Secretary
RICHARD E. ROGERS. JR.
Director
A Jeff Earp
Funston Farms - Old & New
7406 Funston Rd SE
Winnabow, NC 29479
-' �,LSrArE4ry.,
NORTH CAROLINA
Environmental Quality
February 12, 2024
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittec:
RECEIVED
MAR 2 6 2024
NC DEQ/DWR
Central Office
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2024. In order to ensure our continued covera a under the State Non -Di char a General
Permits, you must submit an application for permit coverage to the Division of Water Resources_{DWR) byApril, 3. 2024.
Enclosed you will find a "Request for Certificate of Coverage for Facility Currently Covered by an Expiring State
Non -Discharge General Permit." The aRplication form must be comoleted. si ned by the Permittee and returned to the DWR b
April 3, 2024.
Mailing Address: NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699 1636
Email: animal.onerations0,deq nc.eov
phone: [phone]
Please note that you must include one 1 covy of the Certified Animal Waste Mana ement Plan CAWMP with the
completed and sizoed application form.. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NC G.S. § 143-215.1
and could result in assessments of civil penalties of up to $25,000 per day.
Copies of the animal waste operation State Non -Discharge General Permits are available at
www.deg.nc.mov/animalnermits2024. General permits can be requested by writing to the address above.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please
feel free to contact the Animal Feeding Operations Branch staff at 919-707-9129.
Sincerely,
A.�
Michael Pjetraj, Deputy Director
Division of Water Resources
Enclosures: Reguest for Certificate of Coverage for Facility Currently Covered by an Expiringe State Non-Disc.harti e
General Permit
North Carolina Department of arinumantalQuality DisisianafWattrRtsounis
E s12North5allstwsStrul 1635Mail 5emcaCantir Rala;i��arrtkL'arvliaa 'b9�llfBb
- 91V079129

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 Ibs N / bushel
B
Hybrid Bermudagrass - Grazed
50 Ibs N 1 ton
C
Hybrid Bermudagrass - Hay
50 Ibs N / ton
D
Corn - Grain
1.25 Ibs N / bushel
E
Corn - Silage
12 Ibs N / ton
F
Cotton
0.12 Ibs N / Ibs lint
G
Fescue - Grazed
50 Ibs N / ton
H
Fescue- Hay
50 Ibs N / ton
I
Oats
1.3 Ibs N / bushel
J
Rye
2.4 Ibs N / bushel
K
Small Grain - Grazed
50 Ibs N 1 acre
L
Small Grain - Hay
50 Ibs N 1 acre
M
Grain Sorghum
2.5 Ibs N / cwt
N
Wheat
2.4 Ibs N / bushel
O
Soybean
4.0 Ibs N / bushel
P
Pine Trees
40 Ibs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based upon soil type, available moisture, historical data, climatic conditions,
and level of management, unless there are regulations that restrict the rate of applications
for other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field
(See USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and
flies,
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Anim l waste shall be applied on actively growing crops in such a manner that the crop is
not cr.,: ered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 {Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Wastelnutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
Any new swine facility sited on or after October 1, 1995 shall comply with the following:
11 The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property
boundary and canal. Animal waste, other than swine waste from facilities sited on or after
October 1, 1995, shall not be applied closer than 25 feet to perennial waters.
Animal waste shall not be applied closer than 100 feet to wells.
12
Animal waste shall not be applied closer than 200 feet of dwellings other than those
13 owned by the landowner.
Waste shall be applied in a manner not to reach other property and public right-of-ways.
14
Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
15 provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
IN
Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not.be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A proti.-tive cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are lin?ited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
19 basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
Animal waste can be used in a rotation that includes vegetables and other crops for direct
20 human, consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
21 managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
22 nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

Crop Notes
The following crop note applies to field(s): 5
Fescue: Coastal Fiain, Mineral Soil, Poorly Drained to Somewhat Poorly Drained.
Adaptation: :�4oderate to Marginal.
In the Coastal Plain, tall fescue can be planted Sept. 1 to Oct. 15 (best) and Feb, 15 to Mar. 20. For
pure -stand broadcast seedings use 20 to 30 lb/ac., for drilled use 15 to 20 lb/ac. seed. Use certified seed
to avoid introducing weeds or annual ryegrass. Plant seed 0.25" to 0.5" deep for pure stands, 0.25" in
mixture with -zlovers. Tali fescue will tolerate soil wetness but not flooding or prolonged saturation; use
Ladino clover for mixtures on these soils. Soil test for preplant and maintenance lime, phosphorus, and
potassium recommendations. Apply 40 to 60 lb/ac nitrogen at planting for pure stands only. Do not apply
N for mixtures with clovers but use proper legume inoculation techniques. Apply 150 to 200 lb/ac. N to
pure -stand fescue for hay production; reduce N rates by 25% for grazing. Apply N Feb. 1 to Mar. 20 and
Aug. 20 to Sept. 30, with equal amounts in each window. Refer to NCSU Technical Bulletin 305
Production and Utilization of Pastures and Forages in North Carolina for additional information or
consult your regional agronomist or extension agent for assistance.
The following crop note applies to field(s): 3, 4
Fescue: Coastal Plain, Mineral Soil, Poorly Drained to Somewhat Poorly Drained.
Adaptation: Moderate to Marginal.
In the Coastal- Plain, tall fescue can be planted Sept. 1 to Oct. 15 (best) and Feb. 15 to Mar. 20. For
pure -stand broadcast seednngs use 20 to 301b/ac., for drilled use 15 to 20 lb/ac. seed. Use certified seed
to avoid introducing weeds or annual ryegrass. Plant seed 0.25" to 0.5" deep for pure stands, 0.25" in
mixture with clovers. Tall fescue will tolerate soil wetness but not flooding or prolonged saturation; use
ladino clover for mixtures on these soils. Soil test for preplant and maintenance lime, phosphorus, and
potassium recommendations. Apply 40 to 60 lb/ac nitrogen at planting for pure stands only. Do not apply
N for mixtures with clovers but use proper legume inoculation techniques. Apply 150 to 200 1b/ac. N to
pure -stand fescue for hay production; reduce N rates by 25% for grazing. Apply N Feb. 1 to Mar. 20 and
Aug. 20 to Sept. 30, with equal amounts in each window. Refer to NCSU Technical Bulletin 305
Production and Utilization of Pastures and Forages in North Carolina for additional information or
consult your regional agronomist or extension agent for assistance.
--------------------------------------------------------------------------------------------------------------------------------
578863 Database Version 3.1 Date Printed: 04-02-2010 Crop Note Page 1 of 3

The following crop note applies to field(s): 11, 6, 7, 8
Fescue: Coastal Plair., Mineral Soil, Moderately Well Drained
Adaptation: Mar€i; ial.
In the Coastal Plain, tall fescue can be planted Sept. 1 to Oct. 15 (best) and Feb. 15 to Mar. 20. For
pure -stand br.)adcast seedings use 20 to 30 Ib/ac., for drilled use 15 to 201b/ac. seed. Use certified seed
to avoid introducing weeds or annual ryegrass. Plant seed 0.25" to 0.5" deep for pure stands, 0.25" in
mixture with clovers. Tall fescue requires adequate soil moisture for persistence and production. Soil test
for preplant and maintenance lime, phosphorus, and potassium recommendations. Apply 40 to 60 lb/ac
nitrogen at planting for pure stands only. Do not apply N for mixtures with clovers but use proper legume
inoculation tcchniques. Apply 150 to 2001b/ac. N to pure -stand fescue for hay production; reduce N rates
by 25% for grazing. Apply N Feb. 1 to Mar. 20 and Aug. 20 to Sept. 30, with equal amounts in each
window. Refer to NCSU Technical Bulletin 305 Production and Utilization of Pastures and Forages in
North Carolina for additional information or consult your regional agronomist or extension agent for
assistance.
The following crop note applies to field(s): 10, 9
Small Grain: CP,- Mineral Soil, low -leachable
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from
October 15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for
each week seeding is delayed beyond the optimum time. See the seeding rates table for applicable
seeding rate trnodifications in the current NCSU "Small Grain Production Guide". Also, increase the
initial seeding rate by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and
rye at 1-1 1/2 bushels/acre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is
essential. Review the NCSU Official Variety "green book" and information from private companies to
select a high yielding variety with the characteristics needed for your area and conditions. Apply no more
than 301bs/acre N at planting. Phosphorus and potash recommended by a soil test can also be applied at
this time. The remaining N should be applied during the months of February -March.
The following crop note applies to field(s): 1, 12, 2
Small Grain: CP, Mineral Soil, medium leachable
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from
October 15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for
each week seeding is delayed beyond the optimum time. See the seeding rates table for applicable
seeding rate modifications in the current NCSU "Small Grain Production Guide". Also, increase the
initial seeding rate by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and
rye at 1-1 1/2 bushels/acre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is
essential. Review the NCSU Official Variety "green book" and information from private companies to
select a high yielding variety with the characteristics needed for your area and conditions. Apply no more
than 30 lbs/acre N at planting. Phosphorus and potash recommended by a soil test can also be applied at
this time. The remaining N should be applied during the months of February -March.
------------------------------------------------------- -------------------------------------------------------------- ...........................
578863 Database Version 3.1 Date Printed: 04-02-2010 Crop Note Page 2 of 3

The following crop note applies to field(s): 10, 9
Bermudagrass CP, Mineral Soil, Poorly Drained to Somewhat Poorly Drained.
Adaptation: Effective artificial drainage MUST be in place to achieve Realistic Yield Expectations
provided for these soils.
In the Coastal 11lain, hybrid bennudagrass sprigs can be planted Mar. Ito Mar. 31. Cover sprigs I" to 3"
deep (1.5" oplirnai). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Q�astal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a
rate of 30 bulav is satisfactory to produce full groundcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced I' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus,
potassium anal micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization
of Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance.
The following crop note applies to field(s): 1, 2
Bermudagrass: CP, Mineral Soil, Moderately Well Drained.
Adaptation: Well -adapted.
r.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar, I to Mar. 31. Cover sprigs I" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced I' to 1.5' in row.
For broadcagi/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization
of Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance.
The following crop note applies to field(s): 12
Bahiagrassgrass: No Comment
------- ----------------------------------------------------------------------------------------------------------------............----------------...
578863 Database Version 3.1 Date Printed: 04-02-2010 CropNote Page 3 of 3

W2,2
;74
ic

O
2
±
O
W
a
IL
4
�
6
E
cu
@ \
,
U\
\�0
{O
\
§\k
WO
to_
\
_
{
§
clia)|
_
In
/{/0
e
I»
co,
m
kk
k
2
\
e%§§
/
y
E
§«�
_ƒ
\
,
\§§7
Oj
J\s
'a
-4
,/
—
qa»°
2�
\#
°mo�
_
ƒ\�
— e
e
\$2
?>
/
0 N Q
\)
t�
%)
§
.p/f)
~z33
f)
«\
\
#{�]
/(
{)$
9c
>T
cLm
. _
_
|k
2ƒ\
q
Rw #
cl}
/ \
/
/ -[,
}k
\\\
\/
/m
3
&S±7
!
_
(
3
-
cor
\
k
_
k
)
\
)
/ } \
k
\ \ /
E\
\ 2
/
k
\
)
r.`
8
_
/
:
LL
/ )
LL
2
•
5
a
o
!
W
/
(
e
<
E § #
CL /\ \ UJ
CD f} ./2
\)\ = \ i \
\\ \ \ \\j 03/ \ ) n n ) m
E x
a j k0 »

Custom Soil Resource Report
Map Unit Legend (Funston)
Brunswick County, North Carolina.(NC019)
Map Unit symbol
Map Wit Name
Acres in A01
Percent of A01
BaB
Baymeade fine sand, 1 to 6 percent slopes
56.1
13.9%
Bn8
Blanton fine sand, 0 to 5 percent slopes
19.3
4.8%
GoA
Goldsboro fine sandy loam. 0 to 2 percent slopes
55.5
13.7%
Lo
Leon fine sand
46.6
11.6%
Ly
I Lynchburg fine sandy loam
11.4
2.8%
MAN
Miscellaneous water
1.8
0.5%
Mk r
Muckalee loam
28.2
7.0%
Mu
Murville mucky fine sand
64.1
15.9%
NoB
Norfolk loamy fine sand, 2 to 6 percent slopes
50.1
12.4%
On
Onslow fine sandy loam
25.3
6.3%
Ra
Rains fine sandy loam
26.3
6.5%
Tm
Tomahawk loamy fine sand
16.7
4.1%
w -
Water
2.2
0.5%
Totals for Area of Interest
403.6
100,0%
Map Unit Descriptions (Funston)
The map units delineated on the detailed soil maps in a soil survey represent the soils
or miscellaneous areas in the survey area, The map unit descriptions, along with the
maps, can be used to determine the composition and properties of a unit.
A map unit delineation on a soil map represents an area dominated by one or more
major kinds of soil or miscellaneous areas. A map unit is identified and named
according to the taxonomic classification of the dominant soils. Within a taxonomic
class there are precisely defined limits for the properties of the soils. On the landscape,
however, the soils are natural phenomena, and they have the characteristic variability
of all natural phenomena. Thus, the range of some observed properties may extend
beyond the limits defined for a taxonomic class. Areas of soils of a single taxonomic
class rarely, if ever, can be mapped without including areas of other taxonomic
classes. Consequently, every map unit is made up of the soils or miscellaneous areas
forwhich it is named and some minor components that belong to taxonomic classes
other than those of the major soils.
Most minor soils have properties similar to those of the dominant soil or soils in the
map unit, and thus they do not affect use and management. These are called
noncontrasting, or similar, components. They may or may not be mentioned in a
particular map unit description. Other minor components, however, have properties
and behavioral characteristics divergent enough to affect use or to require different
management. These are called contrasting, or dissimilar, components. They generally
are in small areas and could not be mapped separately because of the scale used.
Some small areas of strongly contrasting soils or miscellaneous areas are identified
10

Custom Soil Resource Report
by a spF.cial symbol on the maps. If included in the database for a given area, the
cont!asting minor components are identified in the map unit descriptions along with
some characteristics of each. A few areas of minor components may not have been
o",served, and consequently they are not mentioned in the descriptions, especially
where the pattern was so complex that it was impractical to make enough observations
tj identify all the soils and miscellaneous areas on the landscape.
The presence of minor components in a map unit in no way diminishes the usefulness
or accuracy of the data. The objective of mapping is not to delineate pure taxonomic
classes but rather to separate the landscape into landforms or landform segments that
t-ave similar use and management requirements. The delineation of such segments
on the map provides sufficient information for the development of resource plans. If
intensive use of small areas is planned, however, onsite investigation is needed to
define and locate the soils and miscellaneous areas.
An identifying symbol precedes the map unit name in the map unit descriptions. Each
ilescription includes general facts about the unit and gives important soil properties
.=,nd qualities.
Soils that have profiles that are almost alike make up a soil series. Except for
differences in texture of the surface layer, all the soils of a series have major horizons
that are similar in composition, thickness, and arrangement.
Soils of one series can differ in texture of the surface layer, slope, stoniness, salinity,
dpgree of erosion, and other characteristics that affect their use. On the basis of such
differences, a soil series is divided into soil phases. Most of the areas shown on the
detailed soil maps are phases of soil series. The name of a soil phase commonly
indicates a feature that affects use or management. For example, Alpha silt loam, 0
to 2 percent slopes, is a phase of the Alpha series.
Some map units are made up of two or more major soils or miscellaneous areas.
These map units are complexes, associations, or undifferentiated groups.
A complex consists of two or more soils or miscellaneous areas in such an intricate
pattern or in such small areas that they cannot be shown separately on the maps. The
pattern and proportion of the soils or miscellaneous areas are somewhat similar in all
areas. Alpha -Beta complex, 0 to 6 percent slopes, is an example.
An association is made up of two or more geographically associated soils or
miscellaneous areas that are shown as one unit on the maps. Because of present or
anticipated uses of the map units in the survey area, it was not considered practical
or necessary to map the soils or miscellaneous areas separately. The pattern and
relative proportion of the soils or miscellaneous areas are somewhat similar. Alpha -
Beta association, 0 to 2 percent slopes, is an example.
An undifferentiated group is made up of two or more soils or miscellaneous areas that
could be mapped individually but are mapped as one unit because similar
interpretations can be made for use and management. The pattern and proportion of
the soils or miscellaneous areas in a mapped area are not uniform. An area can be
made up of only one of the major soils or miscellaneous areas, or it can be made up
of all of them. Alpha and Beta soils, 0 to 2 percent slopes, is an example,
Some surveys include miscellaneous areas. Such areas have little or no soil material
and support little or no vegetation. Rock outcrop is an example.
'11

Custom Soil Resource Report
Brunswick County, North Carolina
BaB—Baymeade fine sand, 1 to 6 percent slopes
Map Unit Setting
Elevation: 20 to 160 feet
Mean annual precipitation: 40 to 55 inches
Mean annual air temperature: 59 to 70 degrees F
Frost -free period: 200 to 280 days
Map Unit Composition
Baymeade and similar soils: 85 percent
Minor components: 8 percent
Description of Baymeade
:setting
Landform: Ridges on marine terraces
Landform position (two-dimensional): Shoulder, summit
Landform position (three-dimensional): Crest
Down -slope shape: Convex
Across -slope shape: Convex
Parent material: Loamy and sandy marine deposits
Properties and qualities
Slope: 0 to 6 percent
Depth to restrictive feature: More than 80 inches
Drainage class: Well drained
Capacity of the most limiting layer to transmit water (Ksat): High (1.98 to 5.95 in/hr)
Depth to water table: About 48 to 60 inches
Frequency of flooding: None
Frequency of ponding: None
Available water capacity: Low (about 3.6 inches)
Interpretive groups
Land capability (nonirrigated): 3s
Typical profile
0 to 2 inches: Fine sand
2 to 30 inches: Fine sand
30 to 40 inches: Fine sandy loam
40 to 80 inches: Loamy fine sand
Minor Components
Lynn haven, undrained
Percent of map unit: 2 percent
Landform: Flats on marine terraces
Down -slope shape: Linear
Across -slope shape. Linear
Murville, undrained
Percent of map unit: 2 percent
Landform: Depressions on marine terraces, flats on marine terraces
Down -slope shape: Concave
Across -slope shape: Concave
12
, i

Custom Soil Resource Report
Drainage class: Very poorly drained
Capacity of the most limiting layerto transmit water (Ksat): High (1,98 to 5.95 in/hr)
Depth to water table: About 0 inches
Frequency of flooding: Rare
Frequency of ponding: Frequent
Available watercapacity: Moderate (about 6.2 inches)
Interpretive groups
Land capability (nonirrigated): 5w
Typical profile
0 to 10 inches: Mucky fine sand
10 to 36 inches: Sand
36 to 80 inches: Sand
NoB--Norfolk loamy fine sand, 2 to 6 percent slopes
Map Unit Setting
Elevation: 20 to 160 feet
Mean annual precipitation: 40 to 55 inches
Mean annual air temperature: 59 to 70 degrees F
Frost -free period: 200 to 280 days
Map Unit Composition
Norfolk and similar soils: 85 percent
Minor components: 4 percent
Description of Norfolk
Setting
Landform: Broad interstream divides on marine terraces, ridges on marine terraces
Landform position (two-dimensional): Shoulder, summit
Landform position (three-dimensional): Crest
Down -slope shape: Convex
Across -slope shape: Convex
Parent material. Loamy marine deposits
Properties and qualities
Slope: 2 to 6 percent
Depth to restrictive feature: More than 80 inches
Drainage class: Well drained
Capacity of the most limiting layer to transmit water (Ksat): Moderately high to high
(0.57 to 1.98 in/hr)
Depth to water table. About 40 to 72 inches
Frequency of flooding: None
Frequency of ponding: None
Available water capacity: Moderate (about 7.7 inches)
Interpretive groups
Land capability (nonirrigated): 2e
Typical profile
0 to 14 inches: Loamy fine sand
19
p � l

Murphy -Brawn, LLC
Grog r(s):
Far, . Name:
C.• .n
L ;•'.rm Ca
i
1211712013
NUTRIENT UTILIZATION PLAN
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Pacarinr to Pinich
JI ,rage Structure:
:;forage Period:
Application Method:
2622 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
Funston Farms Facility 10-36
Jeff Earp
Brunswick
2900
1710
Anaerobic Lagoon
>180 days
Irrigation
The waste frc m your animal facility must be land applied at a specified rate to prevent pollution
of surface wa.er and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied. .
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
r
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2: Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based or the waste application method shown above. if you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not tl same.
The estimated J .:ies needed to apply the animal waste is based on typical nutrient content
for this type c,S..acility. In some cases you may want to have plant analysis made, which could
allow additir',al waste to be applied. Provisions shall be made for the area receiving waste to
be flexible 3o as to accommodate changing waste analysis content and crop type. Lime must
be applied to ,maintain pH in the optimum range for specific crop production.
This waste i.�.ilizatlon plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adepted by the Environmental Management Commission.
AMOUNT 0- WASTE PRODUCED PER YEAR ( gallons, ft1, tons, etc.):
l apacity Type Waste Produced per Animal Total
2900 Farrow to Wean 3212 gal/yr 9,314,800 gal/yr
Farrow to Feeder 4015 gal/yr gal/yr
Farrow to Finish 10585 gal/yr gal/yr
0 Wean to Feeder 223 gal/yr - gal/yr
1710 Feeder to Finish 986 gaUyr 1,686,060 gal/yr
Total 11,000,860 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Cdpacity Type Nitrogen Produced per Animal Total
2900
Farrow to Wean
5.4 Ibs/yr
15,660 Ibs/yr
Farrow to Feeder
6.5 Ibs/yr
Ibs/yr
Farrow to Finish
26 Ibs/yr
Ibslyr
0
Wean to Feeder
0.48 Ibs/yr
- Ibs/yr
1710
Feeder to Finish
2.3 Ibs/yr
3,933 Ibs/yr
Total 19,593 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 256.23
Total N Required 1st Year: 45166.0588
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 45,166.06
Total Nitrogen Produced by Farm: 19,593.00
Nitrogen Balance for Crops: (25,573.06)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

IN
1111111mollummillilill

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 Ibs N / bushel
B
Hybrid Bermudagrass - Grazed
50 Ibs N 1 ton
C
Hybrid Bermudagrass - Hay
50 Ibs N / ton
D
Corn - Grain
1.25 Ibs N / bushel
E
Corn - Silage
12 Ibs N / ton
F
Cotton
0.12 Ibs N / Ibs lint
G
Fescue - Grazed
50 Ibs N / ton
H
Fescue- Hay
50 Ibs N / ton
I
Oats
1.3 Ibs N / bushel
J
Rye
2.4 Ibs N / bushel
K
Small Grain - Grazed
50 Ibs N 1 acre
L
Small Grain - Hay
50 Ibs N 1 acre
M
Grain Sorghum
2.5 Ibs N / cwt
N
Wheat
2.4 Ibs N / bushel
O
Soybean
4.0 Ibs N / bushel
P
Pine Trees
40 Ibs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications
PAN/ r/animal
Farm Total/ r
2900 Farrow to Wean
0.84
2436
Farrow to Feeder
1
Farrow to Finish
4.1
1 0 Wean to Feeder
0.072
0
L 1710 Feeder to Finish
0.36
615.6
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 3051.6 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 15258 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 50 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 122.064 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Tract
Hydrant
Soil
Type
Crop
Application Rate
in/hr
Application Amount
*Inches
2982
10
GoA
B
0.4
1
2982
9
GoA
B
0.4
1
2984
1
Baymeade
B
0.35
1
2984
2
Baymeade
B
0.35
1
2984
3
GoA
G
0.4
1
2984
4
GoA
G
0.4
1
2984
5
Rains
G
0.4
1
2984
6
NoA
G
0.5
1
2984
7
NoA
G
0.5
1
2989
11
NoA
G
0.5
1
2989
12
Baymeade
B
0.35
1
2989
8
NoA
G
0.5
1
6of8

Additional Comments:
Fields 9 and 10 may be planted with Bermuda and Small Grain Overseed that
will be cut for hay instead. of pastured. If done, the bermuda rate can be
adjusted to 244 lbs. N per acre. The overseed rate will stay the same.
7 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm:
Owner:
Manager:
Owner/Menager Agreement:
Jeff Earp
Funston Farms Facility 10-36
Mark Greene
I/we underutand and will follow and implement the specifications and the operation and
maintenance: procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrien' management plan and a new certification to be submitted to DWQ before the new
animals an;. stocked.
I/we underss:and that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at.the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Fui
Signature:
a Farms Facilhy 10-36
Name of Manager (if different from owner):
Signature:.
Mark Greene
Name of Technical Specialist: Kraig Westerbeek
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Signature:
8 of 8
Date

OPERATION AND MAINTENANCE PLAN
------------------------------
This lagoon is designed for waste treatment (permanent storage) with
min. odor control. The time required for the planned fluid level to be
reached (permanent + temporary storage) may vary due to soil conditions
flushing operations, and the amount of fresh water added to the system.
The designed 6 months temporary storage is an estimated volume
based on: 1) waste from animals; 2) excess rainfall after evaporation;
and 3) the largest 24 hour (one day) rainfall that occurs on the
average of once every 25 years. The volume of waste generated from
a given number of animals will be fairly constant throughout the year
and from year to year. This estimate is based on 7 inches of excess
rainfall which is equal to or exceeds the highest 6 months excess in
a year. The average annual excess rainfall is approximately 8 inches.
Therefore, an average of 8 inches of excess rainfall will need to be
pumped each year. The 25 year rainfall will not be a factor to consider
in an annual pumping cycle, but this storage volume must always be
available. A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed on the elevation to
begin pumping, a permanent marker must be installed on this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain minimum treatment depth (6 feet).
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin pump -out of the lagoon when fluid
tion 48.7 as marked by permanent marker.
the fluid level reaches elevation 46.9 c
less than 6 feet deep (this prevents the los
bacteria). The design temporary storage, les
is 145578 cubic feet or 1088925 gallons.
level reaches eleva-
Stop pump -out when
r before the fluid depth is
s of favorable
s 25 year storm
As stated before, this
volume will vary considerably from year to year.

4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.3
inch per hour.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be -diverted from the lagoon to stable
outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

EMERGENCY ACTION PLAN
PHONE NUMBERS
DWQ ) 0 — 7f6— Is
EMERGENCY MANAGEMENT SYSTEM - G s
SWCD 200
NRCS Ala. as3 -2131
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or leave
your property to consider that you have a problem. You should make every effort to ensure that
this does not happen. This plan should be posted in an accessible location for all employees at the
facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
December 18, 1996

D: Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing
leaks- possible action:
a. Dig a small sump or ditch away from the embankment to catch all seepage, put in a
submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon bottom as soon
as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality) regional office;
Phone - - . After hours, emergency number: 919-733-3942. Your phone call
should include: your name, facility, telephone number, the details of the incident from item
2 above, the exact location of the facility, the location or direction of movement of the
spill, weather and wind conditions. The corrective measures that have been under taken,
and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number - -
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number - - , local SWCD office phone number - - , and
local NRCS office for advice/technical assistance phone number - -
2 December 18, 1996

4: If none of the above works call 911 or the Sheriffs Department and explain your problem to
them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site damage.
a.
b.
C.
Contractors Name:
Contractors Address:
Contractors Phone:
6: Contact the technical specialist who certified the lagoon (MRCS, Consulting Engineer, etc.)
a. Name:
b. Phone:
7: Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.
3 December 18, 1996

i
i
In
CD
CD
a.
CD
Ln
CD
C.
W
S
❑ ❑
CD
I'D' CT,
S 0
" rL t
Oq O C R
C O � p �• e
O • C1q � i
Oq
O D O Q.
w (42
Q CJqCDCD
CD w
-Ohs O
A� O
� m
r
o �
�
BCD
o
S ti
O
CD
C
Q
CD
ZD
CD
d
n
CD
CD
C.
y
o•
CD
o
0
CD CD
GQ o n. CD
CD uq
o- °o
(QED A* O 3 aLn
p -*, N
CD
¢ �• O � O O � �.
N (<'D O
AD C O.
-�
co
CDO Chi :3
CD CD
* < (D
.�� CD O oo n
CD
-
O
O CD �' CD
Uq Ln CIq
ii
❑ 1�4
CDCD
o CD o �
�Q� ' _r!
C v`D'
O CCD
O �
CD
C
Q
W -.
O P W
CD
CD O
R- O C-D
O
Oq f9
Q c o-
w C
CD
O n
F.
'-e
W.
b
ca
8
0
0
0
CO)
M.
O
-0
CD
y

S
2
•
❑ ❑ ❑
O_
CD CL
0 CD
� n �
O CD
O O
m
CD
o 0 o �.
-s O
a' C p.
CD
T
O
A�
� O
w
0
UQ
CD
W
cn
•
� Y
01
O
A�
C'D
O
m
CD
cD
w
m
m
-a
CD
0
74
CD
O
C)
CD
cn
im
y .
j O
O CD
CD
BCD
C CD
G
CD
CD
O
O.. CD
..i
Uq
(�
O
D w
pCD
i
a
CD
5
Q..
D P
O cam+
N � K
o
CD-
UCD
_
y
Q
D
CD
uq
CD
D
DCD<
p
Q
D
2
O
UP
W
M
b

.9
d
cm
M
N
O
ft
C1
�
v �
o
$
3
a
N
ON
N
rt
0
n
3'
m
d
0
❑ ❑ ❑
0 p vC, .N+ c n a c p
3 `ND m o n 0
r+ 3 OJ V 3 D O
O = C o
n •�-r
Z
ID p r 3 'G
O? N N M^ O C
n n 0 rt V 3LA
.
N o 00
rr O
(D d O d -j. m
SI rr
c rt — .0 ? O
M
3 3 m 3 3 Ol 0
rD m 0!
3 �
O Q. fvaaq D m 0
m of Di 3 m
r+ a rD a
rD
c
< _
n
(D
0
N
a
O
co <
N
3 IF
n0
C' err
CL
3
'a
°1 fD
a
(D
r+v
3
�. O.
m
a
�
� 3
.0 :r
0
0
3
<
N
3
O
D
r
a
z
GD1
rn
m
I
a
0
a
(D
0-
0'
as
rD
❑ ❑ ❑
=r 0 lu
3 CD
W •v v
CL
3 N Q
a N OJ N
(D rr n 3 n
N O rD a
(D 3 N (D
d
m m o < o
M. N rt rt
N (D
3 � �
6 :3 v
< 0 OIQ
rD v
3
rt
r+ m
v �
El
3 K
fD m
r+
a d
0 =•
(D (D
OrQ
rD
C rr+
O rt
c <
3 (D
Q
0)O
O
O
Q
!D
Q
rt
N
n fD <
7r
s
O
n--0
rD
3 3
N
rr
n
fD
fD
<
N'
N
Q
Op r
DJ
7
Q
=•
c
c
0 N
rN•r
(DD
Ln
y
pq
n
LnrF
v
n
fD
ii
rNr
CD Q
3
Q
Q
3
OQ
d
3
Q
a
7
rt
e-f
(D
d
d4
O 3
a Dq
O
O
`C
1
_ -1
(A3'
a
c
v3,
a
c3,
r*
`
d
N
N 0
O
a
2.
rt
(n p)
3
C
rcr
Q
<
_
0'
3
m
V
O
0
3
O
M
0
n
0
3
3
H
♦
♦
♦
♦
♦ ♦ z
z
1
n
0-
CL
(D�
3
Q
O
M=
CL
v
n
3
>
n
o
z
°�<
N
+0-<�
Cr
> 3 O
v
O
m
a
z
O V►
cp
3-
=
VI
a
fD
°
3- O
r)
a
(D cD 70
CD
00
N
Q
n
K- N
m
In
m
- T
a,
°''
N.
0
a
=
�
+
m
�
�
CL
n0
O
N
D,
g c
3
°�
m
— 0
(D
CM
1
O_
3ID
I
N
O
a G
n
c
O
c
m
<
N
3
(D 3
fD
3
MO
3 (D
p
O
T
O N
rt
<
1+
e••r
fD
t11
S rt
�(D
O_
Q
N c
W
w
•
N
N
G
(D Ln
i-
O
n
�
!rtD
lD
W
fD
H
7
fu
rr
C
I
m
XN
6N

Ln
(D
D
O
n
(D
rn
N
O_
a1
S (D .�-r (D y .N-r ryr rt p�
roa v�-0 v v a -a
ma"("D c -"' (D n—�(D
O_ (D (D ON 3 CL CD rD'<
(n O_ , SL �v (D O
a Q 7 O (D y rt� (D
aQ O Cr h cD �
y < u\i Ln 0 < S <
3 C S v' 0 v
e_r N —
fl1 Q In
'* O O O (D N tn
3 3 h
rD 3
N 0 0 0 0 3 0
C
m CL 0 >a- m
G O (D 'n
r+ UQ Q O v CL
v
`< <
m
fn
•
•
• •
•
Ln
0.
D
D
Q
N
O_
N
-
—
�+
°o
3
3 (D
O
<
rCL
v w
'*
A
(D
0 a
[(D
0
3
D'U
�
N
3
N
3
rt
S
(D
m
m
3
rD
t'
Ln
Ln
to
m
3
N
'•r
N
x
O
c
N
m
W
a
z
I
m
r-
O
O
a
a
z
v_
z
D
O
O
N
c
m
a
n
m
N
D D
-v
O T
(D o,
a c
3
0 d
O
3
0
3 v
O
3 3
0
(CA 3
°1 O
�2n
M y
-'h
v
w
to
m
LM
❑ ❑❑❑ ❑ ❑❑❑❑❑
S rD y 'N•r 3 eN•r j r0•r Q
Ln
00 d 0�1 C 7 0 (DD -oo
C
N rN•r ? N S rD y d S
(A Q N ° O of 3 v '+
-a (D X 3 Q 7' (D CO)
rD
rt '*
,+ < to O O 3" 3 ' (D
o- s m (fD Q 3+ •a 3-
H
to (D (D
(�D (D (D rN+ r3r rD
-s
3' (D — O_
cr
C r+ 0 O ram—+ Q
m w
r+ 0 h O 7 N
3
'n O O
3
O 0
K - - v
o A 4
3
0rD E n V N
o as -
rD
°1 0 (D (D
3 N
O c
Q i
EA R
C1 aQ
C N
3 -<
C V'
aJ (D
'•F
O to
3
x
O
c
H
m
a
�o
z
I
H
m
m
x
a
z
D
z
%i
W
V
O
3
O
(D
O
C.
O
q
m
O
3
3
h
V
m
rF
z
O

rD
D
O
0J
aq
rD
w
O
h
O v
CL c
O
0
c
Gl
D
N
Ems■ M-MI
O nC
C rt
? y
fD
o
rD
N
rD
pp rD
O
n
c OOrQ
'Or
D!
_
r+
o
< a
3
v�i h
rD
"
O' <
m rD
"O
� 3
O
O
-
c
DOi
Q
=r
rD
N
O
rt O
rt O
O
7
CLO
O
CD
Q
n
S
S
r+
3
N
O
M.
7
O_
rr
O
O
'*
N
N
O
cu
O
(D
N
n �
v �
m v
c :.
N
rD
CL rD
rt w
O <•
rD
rD S
fu C
X
S O-
N
C
N p+
rt r+
D)
O
rt
O
m
Ln
0
x
O
c
FA
m
a
�o
z
I
In
m
z
m
a
r
3 Q o
CA
3 O �*
O 0-
7 m
CL
c)
D,
rD
(A
00000
O c C T X0
rt N N (D rD N N
rD rD rDO_ 3 rr v 3 S 'a N
rDN -a < rD — 3 3 —
-0 0 CLo Q o o_
Q O_ _. n O_ (D N O n
"a n 5to CL< (D -.h d � <
rD ;E.
m \ m m °� C rD m
N C to .� r- N
N n Q a N ,< S G Q_
rD C N Al
O - DNl O S Q d
rD rD a_
n O .2 N 3 O- aq
m 3 m 0 °- 0
O y 0_ O C
O -h rD
CL rD X
rD rOr N N O_ r�D O.
C a- Q- X
of m
6 M
DJ
_N
N
m
tD
m m rD
m
c c c
a
N rD rD
�G
3 _
1• 1
Q Q CL
m
v w N
N
Ul
z
a
C
N N N
N
O
< < <
v m m
N
x
O
c
m
W
a
z
I
T
m
m
v
< o
O c
N
m
O
O
0
c
N
00
Ln
m
N
❑
❑
000
O
�
n 3
m
n
3
(D
m,y
o)
:3
°?
n
of
3
w
S
O r+
fD'
7
N
0
lD
r<D 3
rt
T.
�
rt N
x.-
3
W
O
c
wD!
rD
q
c
0 =
r(D
Ol
�'
rD
3
rD
rD
Q
N
CLrt
I
N
�^
S
rrb
c
Q.
3
-c
CD
Q.
•G
(D
O
rD
7
N
O
n
N
O
•
m
� a
CL m
c N
m Cr
m O
7 rr
rt (D
� 1
O
7 CD
� rt
D1 N
rt
(Dcr
�
Q c
S
3.
Q 04
cm 3.
O Q
7 Cr
3
rD
r+ �
S N
O
CL
x
O
c
m
m
W
a
z
I
m
z
O
z
�T
ri-
m
m
m
A
n
n
r+
n
m
N
m
T1
{y
3
IA
P+
m
9
Iv
d
f�D
(D
3
rt
Q
O
IN
A
O
r+
oN
O
A
S
m
A
N
r"F
V
r+
J
O

LA
M
D
O
n
G1
m
A
O
rn
♦
♦ S
O Z
_- v
°
o
N V
Oq A
M
O
Z
❑❑
❑❑®
fA
1 6
o c„ -a=
A 'C
ac M
r+
N
p O w
= m r+
:D 3
O 3
Q.
O
° 3
m a-=
3 3 fu
Q
V
—
(D 3
3
_
O �^
"
^
rr O
d O
�0 cm
'=
O
Q�
O
— M 3
3
=
0 3
(Am
O
O �`
0!
A
M 3
a
3 n
m
O
M
-0 C
c
Q CD
m
N
m
N O m
q• Q C
o�
a
� O
S 3 fD
O O 1-b
Ul
a
N 3 z
<
A
N N
O m F+
co
� � N
m
❑ ❑❑❑❑ ❑ ®❑❑❑ ❑ ❑
O m IA(A03,+ m a K m (A7- X Q
s m m m fD n, (D c m 3
jCL m °� am a- s 0�°—(D �m a m
m m.Q ryq (A to m m O O VI O
LAOJ O A (D (A M� Q 01 S
m m O m nl �' N fl) 3
3 AO °t N m 3� '1 m 0, j rt
AO < S O (MD C6 "O C 0,
C O_ C
I j F N 3 3 ° p r n vim+
0 0 v m C m O m 1
v Q 3 °+ o c° m
CL � o 3 ° 3
< 3 0� IAN (D
LA M
-7- O 04 O O
O m
7
V
0
3
0
0
of
3
3
m
v
m
3•
Ol
m
O
O
Q
H
A
n
c
3
c
v
0
3
•
O
m
M
M
G)
O
O
Z
a
m
4
O
a
m
C
C
m
m
n
O
3
m
3
rt
N
'v
M
rt
z
O

m
D
Z
O
r)
0 O
m 3
m n
N 0
m
0_ p
M m
N
m
M
m
m
m
ram+.
O
7
❑❑❑
Ln v E
m :E m =r
y a S
r+
N m m
rt r+
O M. S
E O Q
a 0 0
v d �
0 -0 c
0_
CU as
rt oh m
O� O �
7 7 �
C �
n r*
S O
d O
N
O
a-
O
0
N
ao
d
m
N
❑❑❑
D -�
� C31 •� y
n O 7 O
— m �. N
d O
O O m
0- m
n
rD O
m
� � N N
Q
OrL
_CrQ N m
_ m _S
:' of n
N
mLM
O N
O O 00
3
O_ r+
v
O
n m
m m
N
� N
_S m m
m ^ cCL
N
a a-
y S 000
y 7
r-r A Q
cc -0
O S -
O G
m
O N
r+O
0 O Q
d 0 OrQ
o
._+ 3
X
M r«
CL
o�
3
m
C
m
3
❑❑❑
❑ ❑
N N
O
T
rD S O
17
S m m
0
-O w
m `.
0
m
r+
O
W
O
n a 0i
m <
rp N
n--r
r+
O rD
G
Q
3
N
j d
w N m
3 °(A
IA
c
-O
rD .G
o
N
v
N n
-0N
N � rN+
V' O m
D)
M
tn
-0
0. 3
a
C
a, m
m 0
3
m
O1 m d
m
m r
a
�
o
d
N
* rt
Q N
N
-n
> m
ram+
3
Lq
O O O
N 3 N
m
<•
3 0'
O
N r
N
3
dq
Oq
C
7
�n
c
N
CD
r+
fu
N
�Q
O
v
.O
rD
O
M
Di C
FEINOWN
• •
D 3 M
n O_ O
N 6 N 3
0°+m 3
m 0 a Q
S
rt
v M
rQ
O_
4�- GQ
m
0 vim+
7 rny.
0 �' Q
O
O � d
0 0 m
v
CFO
n
0
3
m
N
7�
m
TI
a)
19
Iy
w
rF
m
3
aq
m
m
3
M
O
A
O
3
rh
O
A
m
A
rF

OZZZZZMMMMM
c n n D D D D D
0 v Z Z Z Z m m m m m
In A Cn(n(�N Di N N
m /f !1 /1 N 0 O
l� OD W
0 1+ 1+ 1+ h c c 00 00 00
� M � = = M (D ao 00 w
0 Q Q Q Q 0 rD 1 1 1
3 (D 0J 0) 0) C) r+ r+ Vf (Ar-
a Q O_ 0- Q I I �_ =. an
_• A W W V) (i 3 3 O
OQ 3 .0. N 00 Ln O1 M M 0
D N N O tD -V -V
Q 3 I I I 10 p� 0 0
0 3 "' rD _0 r+, Mo_ ,A
fD 0 O 0 0
D 0- 3
UQ
t�ii 3 rt rt 3
3 0Q 0-
r+
X X- M (T rD 0 3 3 3
3 O No
T T
O T rD 7 n n
r+ y =r 0) rr rr 3
0 CD
r* 3 3 d Q 3 N r+ -0 3 w w 3
Ort 0- 3 3 tD
Q rD* r- CLn 3 3
7 rr
3 rr r+ 3 rD v d O
r
fD Q N w w
O <
Q O S rD (DD m ram+
m0 D m m n
to Q
X, T
T_ N d C N
r+ 3 '+ :3
3 O 0- 7o
Q 3 (D rD rD
z �ms�
m O w
O 3 c 0
o m
V 0- 3 T m 3
O
lu
tD N 3 S 0Ln rt
rt
y O 7
O O -I
N
M 3 1 O
OQ
Nrp+• 3 M3 r+
rD
O 3
r ) rr
CD
(D
3
0'Q
(n
z
r)
0
n
O V)
O C
-0 O_
CD
d �
r+
. OrU
N <
m
x
m
3
Ln
0
3
LA
m
' v Cr Cr
Inii N Vni rD m rD m m
G C C 7 3 7 3 7
n n ri tA n
C) ONi N C C (A C C
O O O 0- 0- 0- Q Q
< < < cc c c c
D D
G)
Ln
00 N
Da°
ID
c� 3
CD
� rt
A �
0) �
rM N
o
3 n
M
N
°'. D
3 N
3 CD
CrQ tn
0 3
N
D 3
d 00
Ln
D
or
3
of
OQ
M
3
rD
3
N
rD
3
W
�c
fD
i
n:E
v g
rD
a
a_
00
r
m
m
m
O
C�
b

Version —November 26, 2018
Mortality Management Methods
indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should beat least one foot above the seasonal
high water table. Attach burial location map and plan.
ER Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted lip the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinionjof the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be.done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
fr
Signature of Farm Owner/Manager Date
Signature of Technical Specialist Date

Operator;________
County:==________
Dist.to nearest residence (other than owner):
sows (farrow to finish):__
sows (farrow to feeder):===________
head (finishing only):===- ----------------,
sows (farrow to wean):____
head (wean to feeder):____ ________
Ave. Live Weight for other operations(lbs.)=>
Storage volume for sludge accum. (cu. ft.):=>
Treatment Volume (min. 1 cu. ft./lb.)===____
25 Year - 24 Hour Rainfall
Rainfall in excess of evaporation (in.)===__
Drainage area of. buildings & lots (sq. ft.)=>
Volume of wash water (gallons/day)====______>
Temporary storage period
Freeboard
Side slopes (inside lagoon):________________
Inside top length
Inside top width
Top of dike elevation
Bottom of lagoon elevation
Seasonal high water table(SHWT) elev.(ft.):=>
Total required volume:==== ____====:1810996 cu.
ft.
Actual design volume:====- ----====,1818001 cu.
ft.
Stop pumping el.(> or = to 0.0 ft.SHWT):
(> or = to 30.0 ft.Min.)
Required minimum treatment volume: 1255700 cu.
ft.
Volume at stop pumping elevation: 1256288 cu.
ft.
Start pumping elev.:________________________
Volume at start pumping elevation: 1688307 cu.
ft.
Actual volume less 25yr-24hr rain: 1689667 cu.
ft.
NOTE: Verify that temp. storage is adequate:
Req. volume to be pumped:==== 426963 cu.
ft.
Actual volume to be pumped:== 432019 cu.
ft.
ft.
TO PRINT
ALT-P
O&M PLAN
ALT-O
CONSTRUCT
SPECS.
ALT-A
1
SEEDING
SPECS.
ALT-S
ft.
ft.
TO CLEAR
ALT-C
TO QUIT
LOTUS
ALT-Q

F ,.
Date: Feb, 26" 1�91
istance to nesrast residence (other than owner):
. STEADY STATE LIVE WEIGHT
0 sows : 0lbs. =
bnars x lbs. =
litters x pigs/litter x lbs./pig =
625 sows (farrow to finish) x 1417 lbs. =
625 sows (farrow to feeder) x 522 lbs. =
head (finishing only) x 135 lbs. =
TOTAL STEADY STATE LIVE WEIGHT (SSLW) =
. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
0 lbs
0 lbs
885625
326250
0 lbs
lbs
lbs
0
1211975 lbs
Volume = 1211875 lbs. SSLW x Treatment Volume(CF)/Ib' SSLW
Treatment Volume(CF)/lb. SSLW= 1.00 CF/lb. SSLW
Volums = 1211875 cubic feet
. DESIGN TREATMENT VOLUME
Maintain treatment lagoon liquid level at elevation 32.1 feet
Bottom of lagoon elevation 24'0 feet .
.-
Lagoon size (for treatment lagoon liquid volume) using prismodal formu|�
LENGTH WIDTH SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 DEPTH
523.6 323.6 3.0 3.0 3.0 3.0 8.1
AREA OF TOP
LENGTH * WIDTH =
523'6 323'6
AREA OF BOTTOM
Lb * Wb =
475.0 275'0
AREA OF MIDSECTION
169437.0 (AREA OF TOP)
130625.0 (AREA OF BOTTOM)
(Lm * Wm) *+ =
499,3 299.3 ' 597762.0 (AREA OF MIDSECTION * 4)
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/6
169437.0 597762.0 130625.0 1.350
VOLUME OF LAGOON AT TREOTMENT LIQUID LEVEL = 1212062 CU. FT.
+. TOP OF LAGOON ELEVATION (INCLUDES TEMPORARY STORAGE AND FREEBOARD)
Place spoil as a continuous dike to elevation 36.5 feet,

/ ..
. �EMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
550.0 350'0 192500.0 square feet
Buildings (roof and lot water)
Length * Width =
0.0 0.0 0.0 square feet
TOTAL DA 192500.0 square Met
Pumping cycle to be 180.0 days.
�. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00135
Volume = 1211B75 Lbs. SSLW * CF of Waste/Lb./Day * 180.0 days
Volume = 294485.6 cubic feet
B Volume of wash water
This is the amount of fresh water used for washing flocrs or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days in cycle / 7.48 gallons
per cu. ft.
Volume = 0.0 cubic feet
C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
Rainfall to = 50.0 inches
Evapor. = 42.5 inches
E:cess rainfall (difference) = 7.5 inches
Volume = 7.5 in * DA / 12 inches per foot
Volume = 120312.5 cubic feet

D. Volume of 25 year - 24 hour stcrm
Volume = S.0 inches / 12 inches per foot * DA
Volume = 128333.3 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 294485.6 cubic feet
5B. 0.0 cubic feet
5C. 120312.5 cubic feet
5D. 12B333.3 cubic feet
TOTAL 543131.5 cubic feet
�r� l��'� ^°� ��,� —�'�q� = /7���� �o7 c��
--� ' ' u
. DEPTH OF STORASE REQUIRED (ABOVE LAGOON TREATMENT VOLUME ELEVATION)
Depth required = Volume of temporary storage divided by the
average area of the temporary storage
Dspth required = 543131.5 cubic feet/ 17B286.5 square feet
Depth required = 3.0
Top of dike elevation = 36.5 feet
Lagoon treatment liquid elevation = 32.1 feet
Depth between top of dike and treatment liquid level = 4.4 feet
Deoth reQuired = 3.0
Freeboard =
1.0 feet
Total depth
required = 4.0 feet
NOTE: IF THE
DEPTH BETWEEN TOP OF DIKE AND
TREATMENT LIQUID LEVEL IS EOU."."
TO OR GREATER
THAN THE TOTAL DEPTH REQUIRED,
THEN
ADEQUATE STORAGE
HAS BEEN PROVIDED'
��� /--�r��� �v�'7~~=/'�/��
«*c c/c
'. LAND APPLICATION
OF EFFLUENT FOR NITROGEN DISPOSAL
*PRIMARY EFFLUENT DISPOSAL AREA*
TYPE OF OPERATION :Farrow -To -Finish
TYPE OF VEGETATION :Coastal Bermuda (HayIand)
ANIMAL UNITS : 625'0
ACRES / ANIMAL UNIT : 0.0660
TOTAL ACRES : 41.3
*SECONDARY EFFLUENT DISPOSAL AREA*
TYPE OF OPERATION :Farrow -To -Feeder
/ TYPE OF VEGETATION :Coastal Bermuda (Hayland)
ANIMAL UNITS : 625.0
ACRES / ANIMAL UNIT : 0.0160
TOTAL ACRES : 10,0
DESIGNED 8\': APPROVED 9Y:

THIS DESIGN IS FOR A SINGLE STAGE SWINE LAGOOIi-� C�
CLIENTS NAME __________________________> Funston Farms -Old
COUNTY ________________________________> Brunswick, NC
TODAYS DATE ___________________________> 3/30/99
SITING
LAW DISTANCES OKAY (YES OR NO) =>
Yes
NUMBER
OF
PIGS
WEANLING TO FEEDER =____>
0
NUMBER
OF
PIGS
FEEDER TO FINISH =======>
1710
NUMBER
OF
SOWS
FARROW TO WEANLING =____>
0
NUMBER
OF
SOWS
FARROW TO FEEDER =______>
0
NUMBER
OF
SOWS
FARROW TO FINISH =______>
0
NUMBER
OF
DEVELOPING GILTS =___________>
0
NUMBER
OF
STUD
BOARS OR GESTATING -SOWS >
0
NUMBER
OF
YEARS
OF SLUDGE ACCUMULATION >
5
(5
year
minimum unless retrofit)
TOP LENGTH AT NORMAL WATER LEVEL =_____> 276.0 FEET
TOP WIDTH AT NORMAL WATER LEVEL =______> 243.0 FEET
NORMAL WATER LEVEL ELEVATION ==========> 45.0 FEET
SEASONAL HIGH WATER TABLE ELEVATION =__> 43.0 FEET
LAGOON BOTTOM ELEVATION _______________> 39.5 FEET
Depth of Permanent Water 5.5 feet
(minimum depth including sludge = 6 feet)
(maximum depth of sludge = 2 feet)
SIDE SLOPES ___________________________> 3.0:1
Permanent Volume Required 288562.5 cubic feet
Permanent Volume Provided 323771.2 cubic feet
ADDITIONAL DA W/O EVAP. (VEGETATED) ___> 0 SQUARE FEET
ADDITIONAL DA W/0 EVAP. (NON-VEGET.) __> 0 SQUARE FEET
(i.e. feedlot & non -diverted area)
ADDITIONAL D. A. WITH EVAPORATION =____> 0 SQUARE FEET
(i.e. pumpout pond)
LENGTH OF PUMPING CYCLE _______________>
180
DAYS
GALLONS OF FRESH WATER ADDED DAILY =___>
0
GALLONS
NORMAL RAINFALL FOR PUMPING CYCLE _____>
20.6
INCHES 4P-0,
PERCENT RUNOFF ON VEGETATED AREAS =____>
30
PERCENT
PERCENT RUNOFF ON NON -VEGETATED AREAS =>
65
PERCENT
NOR2f.AL EVAPORATION FOR PUMPING CYCLE __>
0.0
INCHES
25YR/24HR STORM RAINFALL ______________>
7.0
INCHES
RUNOFF DEPTH FROM VEGETATED AREAS =____>
0.0
INCHES
RUNOFF DEPTH FROM NON -VEGETATED AREAS =>
0.0
INCHES
INCLUDE HEAVY RAIN (YES=1, NO=O) ______>
0
(NUMBER ONLY)
FREEBOARD _____________________________>
1.7
FEET — ' rt
ESTIMATED TOP OF DAM ELEVATION =_______>
50.0
FEET
Temporary Storage Volume Needed 217166.8 cubic feet
Temporary Storage Volume Provided 238711.4 cubic feet
Top of Dam Elevation = 50.0 feet
Inside Dimensions of Lagoon at Top of Dam
Length = 306.0 feet Width = 273.0 feet
ESTIMATED DEPTH TO PUMP = 0.0 FEET '
Volume To Be Pumped = 168436 cubic feet
Volume for Estimated Depth = 0 cubic feet
Begin Pumping Elevation = 45.0 feet
Stop Pumping Elevation = 45.0 feet

r
1. STEADY STATE LIVE WEIGHT
0
head
weanling to feeder
x 30 lbs. =
0
lbs
1710
head
feeder to finishing
x 135 lbs. =
230850
lbs
0
sows
farrow to weanling
x 433 lbs. =
0
lbs
0
sows
farrow to feeder x
522 lbs. =
0
lbs
0
sows
farrow to finish x
1417 lbs. =
0
lbs
0
developing gilts x 150
lbs. =
0
lbs
0
stud
boars or gestating
sows =
0
TOTAL STEADY STATE LIVE WEIGHT (SSLW) = 230850 lbs
2. SLUDGE ACCUMULATION
Sludge accumulates at varying rates.
0
pounds
weanling to feeder x 0.25 =
0
cu.
ft.
230850
pounds
feeder to finishing x 0.25 =
57712.5
cu.
ft.
0
pounds
farrow to weanling x 0.17 =
0
cu.
ft.
0
pounds
farrow to feeder x 0.17 =
0
cu.
ft.
0
pounds
farrow to finish x 0.25 =
0
cu.
ft.
0
pounds
of developing gilts x 0.25 =
0
cu.
ft.
0
lbs. of
boar studs or gest. sows * 0.125=
0
cu.
ft.
TOTAL SLUDGE ACCUMULATION = 57712 cu. ft.
3. REQUIRED LIQUID VOLUME OF LAGOON
Design Treatment Volume varies by animal type.
0
pounds
weanling to feeder x 1.0 =
0
cu.
ft.
230850
pounds
feeder to finishing x 1.0 =
230850
cu.
ft.
0
pounds
farrow to weanling x 0.67 =
0
cu.
ft.
0
pounds
farrow to feeder x 0.67 =
0
cu.
ft.
0
pounds
farrow to finish x 1.0 =
0
cu.
ft.
0
pounds
of developing gilts x 1.0 =
0
cu.
ft.
0
lbs. of
boar studs or gest. sows * 1 =
0
cu.
ft.
TOTAL LIQUID VOLUME REQUIRED FOR LAGOON = 230850 cu. ft.
TOTAL VOLUME FOR TREATMENT AND SLUDGE = 288562.5 cu. ft.
4. NORMAL LAGOON LIQUID LEVEL
Maintain normal lagoon liquid level at elevation 45.0 feet
Construct lagoon bottom elevation 39.5 feet
Lagoon size for normal lagoon liquid volume using prismodial formula
SS/END1 SS/END2
3.0 3.0
AREA OF TOP
LENGTH *WIDTH =
276.0 243.0
AREA OF BOTTOM
Lb * Wb =
243.0 210.0
AREA OF MIDSECTION
(Lm * Wm) _
259.5 226.5
SS/SIDE1 SS/SIDE2 DEPTH
3.0 3.0 5.5
67068.0 (AREA OF TOP)
51030.0 (AREA OF BOTTOM) -
58776.8 (AREA OF MIDSECTION)
CU. YD. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM) * DEPTH/6

67068.0 235107.0 51030.0 0.917
VOLUME OF LAGOON AT NORMAL LAGOON LIQUID LEVEL=23771.2 CU. FT.
VOLUME NEEDED = 288562.5 CU. FT.
THE SURFACE DIMENSIONS OF THE LAGOON AT NORMAL LIQUID LEVEL
ARE 276.0 FEET LONG BY 243.0 FEET WIDE
5. DAM
Place spoil as a continuous dam to elevation
50:0
feet.
6. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dam)
Length * Width =
306.0 273.0 83538 square feet
Additional Drainage Area Without Evaporation
Vegetated 0 square feet
Non -Vegetated 0 square feet
Additional Drainage Area With Evaporation
0 square feet
TOTAL DA 83538 square feet
Pumping cycle to be 180 days.
6A. Volume of waste produced
0 head weanling to feeder x 0.5 gals/day =
0
gals/day
1710 head feeder to finishing x 2.3 gals/day =
3933
gals/day
0 sows farrow to weanling x 7.2 gals/day =
0
gals/day
0 sows farrow to feeder x 8.0 gals/day =
0
gals/day
0 sows farrow to finish x 23.0 gals/day =
0
gals/day
0 developing gilts x 2.5 gals/day =
0
gals/day
0 stud boars or gest. sows x 6.7 gals/day =
0
gals/day
TOTAL VOLUME OF WASTE =
3933
gals/day
Volume = 3933 gals/day * 180 days in
the
pumping
cycle divided by.7.48 gallons per cu. ft.
Volume = 94644.4 cubic feet
6B. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by
largest
amount.
Excess rainfall (difference) = 10.6 inches
Volume = Volume from lagoon + volume from feedlots,
etc
+ volume from other ponds
Volume = 73791.9 cubic feet
6C. Volume of fresh water added •

This is the amount of fresh water used for washing floors or
volume of fresh water used for a flush system. Flush systems
that recycle the lagoon water are accounted for in 6A.
Volume = 0 gallons/day * 180 days in pumping
cycle divided by 7.48 gallons per cu. ft.
Volume = 0 cubic feet
6D. Volume of 25 year - 24 hour storm
Volume = Volume from lagoon + volume from feedlots, etc + volume from other ponds
Volume = 48730.5 cubic feet
6E. Volume of "Heavy Rain"
Volume = Volume from lagoon + volume from feedlots, etc + volume from other ponds
Volume = 0.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
6A. 94644.4 cubic feet of waste
6B. 73791.9 cubic feet of excess rainfall
6C. 0.0 cubic feet of fresh wash water
6D. 48730.5 cubic feet of 25yr-24hr storm water
6E. 0.0 cubic feet of heavy rainfall
TOTAL TEMPORARY STORAGE 217166.8 cubic feet
7. DEPTH OF STORAGE REQUIRED (ABOVE NORMAL LIQUID ELEVATION OF LAGOON)
VOLUME OF TEMPORARY STORAGE WHEN TOP OF DAM IS 50.0 FEET ELEV.
AREA OF BOTTOM = 67068.0 sq. ft.
AREA OF TOP = 77736.2 sq.-ft.
AREA OF MID -SECTION = 72304.1 sq. ft.
VOLUME PROVIDED = 238711.4 cubic feet
THE DIMENSIONS OF THE INSIDE EDGE OF THE DAM AT ELEVATION 50.0 FT.
ARE 306.0 FEET BY 273.0 FEET
8. SET BEGIN PUMPING ELEVATION
PUMPED STORAGE VOLUME
6A. 94644.4 cubic feet of waste
6B. 73791.9 cubic feet of excess rainfall
6C. .0.0 cubic feet of fresh wash water
TOTAL PUMPED VOLUME = 168436.3 cubic feet
VOLUME AT ESTIMATED PUMPING DEPTH
AREA OF BOTTOM = 67068.0 sq. ft.
AREA OF TOP = 67068.0 sq. ft.
AREA OF MID -SECTION = 67068.0 sq. ft.
VOLUME PROVIDED = 0.0 cubic feet
DESIGNED BY: APPROVED BY:
DATE: DATE:

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2024, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2024.
Please do not leave any question unanswered Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
l .
Certificate Of Coverage Number: AWS 100036
2.
Facility Name: Funston Farms - Old & New
3.
Pemuttee's Name (same as on the Waste Management Plan):
A JeffEam
4.
Permittee's Mailing Address: 7406 Funston Rd SE
City: Winnabow State: NC
Zip: 28479
Telephone Number: 910-253-5643 Ext. E-mail: marcUeen75@,yahoo.co
5.
Facility's Physical Address: 7406 Fuston Rd
City: Winnabow State: NC
Zip: 28479
6.
County where Facility is located: Brunswick
7.
Farm Manager's Name (if different from Landowner): Marc D Green
8.
Farm Manager's telephone number (include area code): 910-876-5686 Ext.
9.
Integrator's Name (if there is not an Integrator, write "None"):
Murphy -Brown LLC
10.
Operator Name (OIC): Marc D. Green
Phone No.: 910-876-5686
OIC #: 988054
11,
Lessee's Name (if there is not a Lessee, write "None"):
12.
Indicate animal operation type and number:
Current Permit: Operations Type
Allowable Count
Swine - Feeder to Finish
1,710
Swine - Farrow to Wean
2,900
Operation Types:
Swine Cattle
Dry Poultry
Other Types
Wean to Finish Dairy Calf
Non Laying Chickens
Horses - Horses
Wean to Feeder Dairy Heifer
Laying Chickens
Horses - Other
Farrow to Finish Milk Cow
Pullets
Sheep - Sheep
Feeder to Finish Dry Cow
Turkeys
Sheep - Other
Farrow to Wean Beef Stocker Calf
Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow
Wet Poultry
Gilts Other
Non Laying Pullet
Other
Layers

13. Waste Treatment Lagoons, Digesters and Waste Storage Ponds (WSP): (FillNerify the following information.
Make all necessary corrections and provide missing data.)
Structure
Name
Structure Type
(Lagoon/Digester/
WSP)
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
'Redline"
(Inches)
FINISHER
Lagoon
1/1/1987
Full, clay
505,759.00
84,071.00
20.00
SOW
Lagoon
1/l/1990
Full, clay
1,818,001.00
169,884.00
20.00
Submit one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed
application as required by NC General Statutes 143-215.1OC(d), either by mailing to the address below or sending it via
email to the email address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), signed by the owner and a certified technical specialist, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is
accurate and complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be
applicable to your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, solids separators, sludge drying system, waste transfers, etc.)
I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.

Note: In accordance with NC General Statutes 143-215.6A and 143-215.613, any person who knowingly makes any false
statement, representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18
U.S.C. Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both
for a similar offense.)
Print the Name of the Permittee/Landowner/Signing Official and Sign below. (If multiple Landowners exist, all landowners
should sign. If Landowner is a corporation, signature should be by a principal executive officer of the corporation):
Name (Print): s `.�1•,_� {�
Signature:
Name (Print):
Signature:
Name (Print):
Signature:
Title: ?? .4T\P_C
J
Date: _.')—C\ —.2). 4
Title:
Date:
Title:
Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
E-mail: [e-mail]
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636