NC0075027_Permit Issuance_20170315

ROY COOPER
Gownior
Water Resources
ENVIRONMENTAL QUALITY
March 15, 2017
Mr. Bradley Flynt
Cainsway Homeowners Association
P.O. Boa 846
Walkertown, NC 27051-0846
MICHAEL S. REGAN
Secretary
S. JAY ZIMMERMAN
Subject: Issuance of NPDES Permit NCO075027
Cainsway MHP WWTP
Forsyth County
Class WW-2
Dear Mr. Flynt:
Dimcior
Division personnel have reviewed and approved your application for renewal of the subject permit.
Accordingly, we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to
the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between
North Carolina and the U.S. Environmental Protection Agency dated October 15, 2007 (or as subsequently
amended).
This final permit includes no major changes from the draft permit sent to you on January
26, 2017.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to an adjudicatory hearing upon written request within thirty (30)
days following receipt of this letter. This request must be in the form of a written petition, conforming to
Chapter 150B of the North Carolina General Statutes, and filed with the Office of Administrative Hearings
(6714 Mail Service Center, Raleigh, North Carolina 27699-6714). Unless such demand is made, this
decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may
require modification or revocation and reissuance of the permit. This permit does not affect the legal
requirements to obtain any other Federal, State, or Local governmental permit that may be required. If you
have any questions concerning this permit, please contact Charles H. Weaver at telephone number (919)
807-6391.
inter y, -
S. Jay Zimmerman, P. .
Director. Division of Water Resources
cc: Central Files
Winston-Salem Regional Office
NPDES Unit
State of North Carolina I Environmental Quality I Water Resources
1617 Mail Service Center I Raleigh, NC 27699-1617
919 807 6300 919-807-6389 FAX
https:lldcq.nc.gDvlabouttdivisions/water-resourceslwater-resources-permitslwastewater-branchlnpdes-wastewater-permits

Permit NCO075027
STATE -OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENTAL QUALITY
DIVISION OF WATER RESOURCES
PERMIT
TO DISCHARGE WASTEWATER U14DER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended, the
Cainsway Homeowners Association
is hereby authorized to discharge wastewater from a facility located at the
Cainsway Mobile Home Park WWTP
Pinehall Road
North of Walkertown
Forsyth County
to receiving waters designated as Ader Creek in subbasin 03-02-01 of the Roanoke River Basin
in accordance with effluent limitations, monitoring requirements, and other conditions set
forth in Parts I, II, III and IV hereof.
This permit shall become effective April 1, 2017.
This permit and authorization to discharge shall expire at midnight on February 28, 2022.
Signed this day March 15, 2017
S,�Zimmerman, P.G., DirecW!5--..
Division of Water Resources
By Authority of the Environmental Management Commission
Page 1 of 6

Permit NCO075027
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are hereby
revoked, and as of this issuance, any previously issued permit bearing this number is no longer
effective. Therefore, the exclusive authority to operate and discharge from this facility arises under the
permit conditions, requirements, terms, and provisions included herein.
The Cainsway Homeowners Association
is hereby authorized to:
1. Continue to operate an existing 0.0432 MGD wastewater treatment system that
includes the following components:
♦ Aerated equalization basin
♦ Bar screen
♦ Splitter box
♦ Dual extended aeration basins
♦ Clarifier
♦ Tertiary filters
♦ Chlorinator
♦ Dechlorinator
The facility is located at Cainsway Mobile Home Park on Pinehall Road, north of
Walkertown, in Forsyth County.
2. Discharge from said treatment works via, Outfall 001, at the location specified on
the attached map into Ader Creek [22-25-14-1 ] currently classified C waters in
subbasin 03-02-01 [HUC: 03010103021 of the Roanoke River Basin.
Page 2 of 6

Permit NCO075027
Part I
A. (1) EFFLUENT LOUTATIONS AND MONITORING REQUIREMENTS
[15A NCAC 02B.0400 et seq., 15A NCAC 02B.0500 et seq.]
Beginning with the effective date of this permit and lasting until expiration, the Permittee is
authorized to discharge treated wastewater from Outfall 001. Such discharges shall be limited
and monitored' by the Permittee as specified below:
PARAMETER
EFFLUENT LIMITATIONS
MONITORING REQUIREMENTS
Monthly
Daily
Ill �uremed
$ample
Sample
Parameter Code
Average
Maximum
Freq.
Type'
Location
Flow 50050
0.0432 MGD
Continuous
Recording
Influent or
Effluent
BOD, 5-day,. (20°C) — Swnmer* C0310
11.0 mg/L
16.5 mgA.
� ' Weekly
Composite
Effluent
BOD, 5-day, (20°C) — Writers' CO3.10
22.0 mg/L
33.0 mg/L
Weekly
Composite
Effluent
Total Suspended Solids C0530
30.0 mg/L
45.0 mg/L
Weekly
Composite
Effluent
NH3 as N — Swnmer= C0610
2.0 mg/L
10.0 mg/L
Weekly
Composite
Effluent
NH3 as N — Winter* C0610
6.0 mg/L
30.0 mg/L
Weekly
Composite
Effluent
Dissolved Oxygen 00300
Daily average > 5.0 mg/L
Weekly
Grab
Effluent
Fecal Cofform31616
(geometric mean)
200/100 ml
400/100 ml
Weekly
Grab
Effluent
Total Residual Chorine 2 50060
28 Ng/L
2/Week
Grab
Effluent
Temperature (°C) 00010
Daily
Grab
Effluent
pH�
> 6.0 and < 9.0
Weekly
Grab
Effluent
standard units
I
Dissolved Oxygen 00300
Weely '
Grab
Upstream &
Downstream
Temperature (°C) 00010
Weekly
Grab
Upstream 3
Downstream
*SWn=r: April 1- OCtDbw 31
*Winer: Novembef 1- Mara 31
Footnotes:
1. The permittee shall submit discharge monitoring reports electronically using the NC DWR's eDMR
application system [see A. (2)].
2. The Division shall consider all effluent TRC values reported below 50 µg/1 to be in compliance with
the permit. However, the Permittee shall continue to record and submit all values reported by a
North Carolina certified laboratory (including field certified), even if these values fail below 50 µg/l.
3. Upstream = at least 100 feet above discharge point; Downstreain = at NCSR 1979.
THERE SHALL BE NO DISCHARGE OF FLOATING SOLIDS OR VISIBLE FOAM IN OTHER THAN
TRACE AMOUNTS.
Page 3 of 6

Permit NCO075027
A. (2) ELECTRONIC REPORTING OF MONITORING REPORTS
[NCGS 143-215.1 (b)]
Federal regulations require electronic submittal of all discharge monitoring reports
(DMRs) and progragn reports. The final NPDES Electronic Reporting Rule was adopted
and became effective on December 21, 2015.
NOTE: This special condition supplements or supersedes the following sections within
Part II of this permit (Standard Conditions for "DES Permits):
• Section B. (11.) Signatory Requirements
• Section D. (2.) Reporting
• Section D. (6.) Records Retention
• Section E. (5.) Monitoring Reports
1. R�2ortia�E Requirements [Supersedes Section D. (2.) and Section E. �S.j �a�]
The permittee shall report discharge monitoring data electronically using the NC DWR's
Electronic Discharge Monitoring Report (eDMR) internet application.
Monitoring results obtained during the previous month(s) shall be summarized for each
month and submitted electronically using eDMR. The eDMR system allows permitted
facilities to enter monitoring data and submit DMRs electronically using the internet.
Until such time that the state's eDMR application is compliant with EPA's Cross -Media
Electronic Reporting Regulation (CROMERR), permittees will be required to submit all
discharge monitoring data to the state electronically using eDMR and will be required to
complete the eDMR submission by printing, signing, and submitting one signed original
and a copy of the computer printed eDMR to the following address:
NC DEQ / Division of Water Resources / Water Quality Permitting Section
ATTENTION: Central Files
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
If a permittee is unable to use the eDMR system due to a demonstrated hardship or due
to the facility being physically located in an area where less than 10 percent of the
households have broadband access, then a temporary waiver from the NPDES electronic
reporting requirements may be granted and discharge monitoring data may be submitted
on paper DMR forms (MR 1, 1. 1, 2, 3) or alternative forms approved .by the Director.
Duplicate signed copies shall be submitted to the mailing address above. See "How to
Request a Waiver from Electronic Reporting" section below.
Regardless of the submission method, the first DMR is due on the last day of the month
following the issuance of the permit or in the case of a new facility, on the last day of the
month following the commencement of discharge.
Starting on December 21, 2020, the permittee must electronically report the following
compliance monitoring data and reports, when applicable:
Page 4of6

Permit NCO075027
• Sewer Overflow/Bypass Event Reports;
• Pretreatment Program Annual Reports; and
• Clean Water Act (CWA) Section 316(b) Annual Reports.
The permittee may seek an electronic reporting waiver from the Division (see "How to
Request a Waiver from Electronic Reporting" section below).
2. Electronic Submissions
In accordance with 40 CFR 122.410) (9), the permittee roust identify the initial recipient
at the time of each electronic submission. The permittee should use ' the EPA's website
resources to identify_ the initial recipient for the electronic submission.
Initial recipient of electronic NPDES information from NPDES-regulated facilities means
the entity (EPA or the state authorized by EPA to implement the NPDES pmgrYam) that is
the designated entity for receiving electronic NPDES data [see 40 CFR 127.2(b)].
EPA plans to establish a website that will also link to the appropriate electronic reporting
tool for each type of electronic submission and for each state. Instructions on how to
access and use the appropriate electronic reporting tool will be available as well.
Information on ,EPA's NPDES Electronic Reporting Rule is found at:
http: I Iwww2.epa.gov jcomplianceIfinal-national-pollutant-discharize-elimination-
system-npdes-electronic-reporting-rule.
Electronic submissions must start by the dates listed in the "Reporting Requirements"
section above.
3. How to Request a Waiver from Electronic Reporting
The permittee may seek a temporary electronic reporting waiver from the Division. To
obtain an electronic reporting waiver, a permittee must first submit an electronic
reporting waiver request to the Division. Requests for temporary electronic reporting
waivers must be submitted in writing to the Division for written approval at least sixty
(60) days prior to the date the facility would be required under this permit to begin
submitting monitoring data and reports. The duration of a temporary waiver shall not
exceed 5 years and shall thereupon expire. At such time, monitoring data and reports
shall be submitted electronically to the Division unless the permittee re -applies for and is
granted a new temporary electronic reporting waiver by the Division. Approved electronic
reporting waivers are not transferrable. Only permittees with an approved reporting
waiver request may submit monitoring data and reports on paper to the Division for the
period that the approved reporting waiver request is effective.
Information on eDMR and the application for a temporary electronic reporting waiver are
found on the following web page:
httD: / /dea.nc.Lvov /about/divisions/ water -resources /edmr
4. Signato RequireSection B. ill.) lb) and §ncersedes
Section B.111.11d11 .
All eDMRs submitted to the permit issuing authority shall be signed by a person
described in Part II, Section B. (11.)(a) or by a duly authorized representative of that
person as described in Part II, Section B. (11.)(b). A person, and not a position, must be
delegated signatory authority for eDMR reporting purposes.
Page 5 of 6

Permit NCO075027
For eDMR submissions, the person signing and submitting the DMR must obtain an
eDMR user account and login credentials to access. the eDMR system. For more
information on North Carolina's eDMR system, registering for eDMR and obtaining an
eDMR user account, please visit the following web page:
htt,p://deg.nc.gov/about/divisionslwater-tesourcesIedmr
Certification. Any person submitting an electronic DMR using the state's eDMR system
shall make the following certification [40 CFR 122.22]. NO OTHER STATEMENTS OF
CERTIFICATION WILL BE ACCEPTED:
"I certify, under penalty of law, that this document and all attachments were prepared
under my direction or supervision in accordance with a system designed to assure that
qua4 ed personnel properly gather and evaluate the information submitted. Based on my
inquiry of the person or persons who manage the system or those persons directly
responsible for gatheruag the information, the information submitted is, to the best of my
knowledge and belief, true, accurate, and complete. I am aware that there are significant
penalties for submitting false information, including the poss& ty offines and
imprisonment for knowing violations."
5. Records Retention [Supplements Section D. 16.1]
The permittee shall retain records of all Discharge Monitoring Reports, including eDMR
submissions. These records or copies shall be maintained for a period of at least 3 years
from the date of the report This period may be extended by request of the Director at any
time [40 CFR 122.411.
Page 6 of 6

Winston-Salem Journal
Advertising Affidavit
P.O Box 3169
Winston-Salem, NC 27102
NCDENR/DWO/POINT SOURCE BRANCH
ATTN: WREN THEDFORD
1617 MAIL SERVICE CENTER
RALEIGH, NC 27699-1617
PO Number Order Category Description
Account Number
3376309
Date :1
February 03, 2017
0000311668 Legal Notices PUBLIC NOTICE North Carolina EnvironmentalManagement Commission/NPDES
Publisher of the
Winston-Salem Journal
Before the undersigned, a Notary Public of Guilford, North Carolina, duly commissioned,
qualified, and authorized by law to administer oaths, personally appeared the Publisher
Representative who by being duly sworn deposes and says: that he/she is the Publisher's
Representative of the Winston-Salem Journal, engaged in the publishing of a newspaper
known as Winston-Salem Journal, published, issued and entered as second class mail in the
City of Winston-Salem, in said County and State: that he/she is authorized to make this
affidavit and sworn statement: that the notice or other legal advertisement, a copy of which
is attached hereto, was published in the Winston-Salem Journal on the following dates:
01 /27/2017
and that the said newspaper in which such notice, paper document, or legal advertisement
was published was, at the time of each and every such publication, a newspaper meeting all
the requirements and qualifications of Section 1-597 of the General Statutes of North
Carolina and was a qualified newspaper within the meaning of Section 1-597 of the General
Statutes of North Carolina.
signature 4ofpersoalong adav/t)
Sworn to and subscribed before me the 3 day Sw 1
LEA ANNE LAMB
NOTARY PUBLIC
STATE OF NORTH CAROLINA
GUILFORD COUNTY
MY COMMISSION EXPIRES 06-15-19
(Notary Public)
THIS IS NOT A BILL. PLEASE PAY FROM INVOICE. THANK YOU

PUBLIC NOTICE
North Carolina Environmental
Management Commission/
NPDES Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
Notice of Intent to Issue a
NPDES Wastewater Permit
The North Carolina Environmental
Management Commission proposes
to issue a NPDES wastewater dis-
charge permit to the person(s). listed
below. Written comments regarding
the proposed permit will be accept-
ed until 30 days after the publish
date of this notice. The Director of
the NC Division of Water Resources
(DWR) may hold a public hearing
should there be a significant degree
of public interest. Please mail com-
ments and/or Information requests
to DWR at the above address. Inter-
ested persons may visit the DWR at
512 N. Salisbury Street, Raleigh, NC
to review information on file. Addi-
tional information on NPDES permits
and this notice may be found on our
website: http✓/deq.nc.gov/about/di
visions/water-resources/water-
resources-permits/wastewater-
branch/npdes-wastewater/public-
nodces,or by calling [phone].
Cainsway Homeowner's Association
requested renewal of NPDES permit
NC0075027/Cainsway Mobile Home
Park W WTP/Forsyth County. Facility
discharges to Ader Creek/Roanoke
River Basin. Currently, BCD, ammon-
ia -nitrogen, fecal coliform, dissolved
oxygen, and total residual chlorine
are water quality limited.
R.H Johnson Construction Company
requested renewal of permit NC0079
049 for its treatment plant off NCSR
1920, North of Winston-Salem; For-
syth County. This permitted facility
discharges treated wastewater to
Rough Fork; Roanoke River Basin.
WSI: January 27, 2017

FACT SHEET FOR EXPEDITED PERMIT RENEWALS
This form must be completed by Permit Writers for all expedited permits which do not require
full Fact Sheets. Expedited permits are generally simple 100% domestics (e.g., schools, mobile
home parks, etc) that can be administratively renewed with minor changes, but can include
facilities with more complex issues (Special Conditions, 303(d) listed water, toxicity testing,
instream monitoring, compliance concerns).
Basic Information for Expedited Permit Renewals
Permit Writer/Date
Meredith L. Wojcik — 9/2/2016
Permit Number
NCO075027
Facility Name
Cain Way Mobile Home Park WWTP
Basin Name/Sub-basin number
Roanoke / 03-02-01
Receiving Stream
Ader Creek
Stream Classification in Permit
C Stream Index: 22-25-14-1
Does permit need Daily Max NH3 limits?
No
Does permit need TRC limits/language?
No
Does permit have toxicity testing?
No
Does permit have Special Conditions?
No
Does permit have instream monitoring?
Yes — Temperature & DO
Is the stream impaired (on 303(d) list)?
No
Any obvious compliance concerns?
No. No enforcements for the current permit
cycle. Few NOVs for BOD exceedances
during the current permit cycle. These occur
primarily during the warmer months.
Chlorine, fecal coliform, and nitrogen
exceedances occurred but did not result in
NOVs or enforcements.
Any permit mods since lastpermit?
No
New expiration date
2/28/2022
Changes to 2011 Permit?
Added eDMR requirements
Added regulatory citations
Changes to Draft Permit?
Most Commonly Used Expedited Language:
• 303(d) language for Draft/Final Cover Letters: "Please note that the receiving stream
is listed as an impaired waterbody on the North Carolina 303(d) Impaired Waters List.
Addressing impaired waters is a high priority with the Division, and instream data will
continue to be evaluated. If there is noncompliance with permitted effluent limits and
stream impairment can be attributed to your facility, then mitigative measures may be
required".
• TRC language for Compliance Level for Cover Letters/Effluent Sheet Footnote:
"The facility shall report all effluent TRC values reported by a NC certified laboratory
including field certified. However, effluent values below 50 µg/L will be treated as zero
for compliance purposes."

Subject: NPDES Permit #NC0075027
Cainsway WWTP
Forsyth County
Sludge Management Plan
Sludge produced at this WWTP is wasted to an aerated digester. Supernatant
from the digester is pumped into an aerated holding tank where all screenings
from the plant is also stored. Supernatant from holding tank is pumped into the
activated sludge aeration basin. All thickened sludge and holding tank contents
are pumped out by a septic hauler on an as needed basis and hauled to the City of
Winston-Salem, Achie Elledge WWTP for final disposal.
Bradley Flynt
ka MTt -
ORC, Cainsway WWTP