NC0063355_owner name change_19990811

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
August 11, 1999
Mr. Jerry H. Tweed
Heater Utilities, Inc.
P.O. Box 4889
Cary, North Carolina 27519
01
JLA�
,
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: NPDES Permit Modification - Ownership Change
Permit NCO063355
Killian Crossroads WWTP
Catawba County
Dear Mr. Tweed:
In accordance with your request received June 22, 1999, the Division is forwarding the subject permit
modification. This modification documents the change in ownership at the subject facility. Also, monitoring for
instream conductivity, Total Nitrogen and Total Phosphorus has been deleted. All other terms and conditions in
the original permit remain unchanged and in full effect. This permit modification is issued under the
requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between North
Carolina and the U. S. Environmental Protection Agency dated December 6. 1983.
If any parts, measurement frequencies or sampling requirements contained in this permit modification
are unacceptable to you, you have the right to an adjudicatory hearing upon written request within thirty (30)
days following receipt of this letter. This request must be a written petition conforming to Chapter 150B of the
North Carolina General Statutes, fled with the Office of Administrative Hearings, Post Office Drawer 27447,
Raleigh, North Carolina 27611-7447. Unless such demand is made, this decision shall be final and binding.
This permit does not affect the legal requirement to obtain other permits which may be required by the
Division of Water Quality, the Division of Land Resources, Coastal Area Management Act, or any other Federal or
Local government permit that may be required. If you have any questions concerning this permit, please contact
Charles Weaver at the telephone number or address listed below.
cc: Central Files
Mooresville Regional Office, Water Quality Section
NPDES Unit
Point Source Compliance Enforcement Unit
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
An Equal Opportunity Affirmative Action Employer
Sincerely. 11 /
err T. Stevens
919 733.5083, extension 5l l (fax) 919 733-0719
Charles_Weaver® h2o.enr.stale.nc.us

Permit NCO063355
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Heater Utilities, Inc.
is hereby authorized to discharge wastewater from a facility located at the
Killian Crossroads
NCSR 1849
west of Terrell
Catawba County
to receiving waters designated as Lake Norman (Reed Creek Arm) in the Catawba
River Basin
in accordance with effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective August 11, 1999.
This permit and authorization to discharge shall expire at midnight on June 30, 2000.
Signed this day August 11, 1999.
01
rr T. Stevens, DirectAr
Division of Water Quality
By Authority of the Environmental Management Commission

Permit NCO063355
SUPPLEMENT TO PERMIT COVER SHEET
Heater Utilities, Inc., is hereby authorized to:
1. Continue to operate an existing 0.05 MGD wastewater treatment system which
includes the following components:
➢ Influent surge tank
➢ Bar screen
➢ Dual aeration basins with diffused air
➢ Dual clarifiers
➢ Tertiary filters
➢ Chlorine disinfection
➢ Diffused air post -aeration
➢ Dechlorination
➢ Cascade post -aeration
➢ Aerated sludge holding tank
➢ Standby power generator
This wastewater treatment system is located at the Killian Crossroads WWTP on
NCSR 1849 west of Terrell in Catawba County.
2. After receiving an Authorization to Construct from the Division, construct the
necessary components to upgrade the wastewater treatment system to 0.075
MGD.
3. Discharge from said treatment works at the location specified on the attached
map into Lake Norman (Reed Creek Arm), classified WS-IV CA waters in the
Catawba River Basin.

C
L Ubile: Sf5 .'35"
L.osgiitude mr55"
Receiving Stream Cahn Now
saeamcia * WS-W Ca
Subbasin: 30932
NCO063355
Heater Utilities
Killian Crossroads
cat
DOWN STREMI SAMPL•IIvG ' 1 —
Facility ="-F
Location J
North SCALE 1 :24000

Permit NCO063355
A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS — FINAL
During the period beginning on the effective date of the permit and lasting until expansion above
0.050 MGD, the Permittee is authorized to discharge from outfall 001. Such discharges shall be
limited and monitored by the Permittee as specified below:
EFFLUENT
CHARACTERISTICS
LIMITS
MONITORING REQUIREMENTS
Monthly
Average
Daily
Maximum
Measurement
Frequency_
Sample Type
Sample Locationl
Flow
0.050 MGD
Continuous
Recording
Influent or Effluent
BOD, 5 day (202C)
15.0 mg/L
22.5 mg/L
Weekly
Composite
Effluent
Total Suspended Residue
30.0 mg/L
45.0 mg/L
Weekly
Composite
Effluent
NH3 as N
4.0 mg/L
Weekly
Composite
Effluent
Dissolved Oxygen2
Weekly
Grab
Effluent
U stream & Downstream
Fecal Colfform (geometric mean)
200 / 100 ml
400 / 100 ml
Weekly
Grab
Effluent
s ream
Total Residual Chlorine3
28.0 Ng/L
2/Week
Grab
Effluent
Temperature
Daily
Grab
Effluent
Temperature
Weekly
Grab
Upstream & Downstream
Total Nitrogen (NO2+NG3+TKN)
Quarterly
Composite
Effluent
Total Phosphorus
Quarterly
Composite
Effluent
Oil and Grease
30.0 mg/L
60.0 mg/L
2/Month
Grab
Effluent
MBAS
8.9 mg/L
2/Month
Composite
Effluent
pH4
Weekly
Grab
Effluent
Footnotes:
1 Upstream = at NCSR 1849: Downstream = at the "Downstream Monitoring site" noted on the
attached map.
2. The daffy average dissolved oxygen concentration shall not be less than 6.0 mg/L.
3. If chlorine disinfection is used, dechlorination shall be employed.
4. The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units and shall be
monitored weekly at the effluent by grab sample
There shall be no discharge of floating solids or visible foam in other than trace amounts.

Permit NCO063355
A. (2.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS - FINAL
During the period beginning after expansion above 0.050 MGD and lasting until expiration, the
Permittee is authorized to discharge from outfall 001. Such discharges shall be limited and
monitored by the Permittee as specified below:
• '
�:.�
y._ 4 `{
.
•�
4r,2.• $L :5`xT
`T".'"lw 9 .�
R ^ '�,
�
••.rG'_'_^ ���5'R'r'�'
.. 1'ri
Flow
0.075 MGD
Continuous
Recording
Influent or Effluent
BOD, 5 day (20°C)
15.0 mg/L
22.5 mg/L
Weekly
Composite
Effluent
Total Suspended Residue
30.0 mg/L
45.0 mg/L
Weekly
Composite
Effluent
NI 13 as N
4.0 mg/L
Weekly
Composite
Effluent
Dissolved Oxygen2
Weekly
Grab
Effluent
U stream & Downstream
Fecal Coliform (geometric mean)
200 / 100 ml
400 / 100 ml
Weekly
Grab
Effluent
Downstream
Total Residual Chlorine3
28.0 Ng/L
2/Week
Grab
Effluent
Temperature
Daily
Grab
Effluent
Temperature
Weekly
Grab
Upstream & Downstream
Total Nitrogen (NO2+NO3+TKN)
Quarterly
Composite
Effluent
Total Phosphorus
Quarterly
Composite
Effluent
Oil and Grease
30.0 mg/L
60.0 mg/L
2/Month
Grab
Effluent
MBAS
6.1 mg/L
2/Month
Composite
Effluent
pH4
Weekly
Grab
Effluent
Footnotes:
1 Upstream = at NCSR 1849; Downstream = at the "Downstream Monitoring site" noted on the
attached map.
2. The daily average dissolved oxygen concentration shall not be less than 6.0 mg/L.
3. If chlorine disinfection is used, dechlorination shall be employed.
4. The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units and shall be
monitored weekly at the effluent by grab sample
There shall be no discharge of floating solids or visible foam in other than trace amounts.

•= State of North Carolina
Department of Environment, LIC
Health and Natural Resources i • •
Division of Water Quality r
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary ED F1
A. Preston Howard, Jr., P.E., Director
WATER QUALITY SECTION
PERMIT NA E/OWMRSHIP CHANGE FORM
permit Number. Nc/-L/-L/L./-Ij 3 /_L/ 5
1. permitholdeesname: MID SOUTH WATER SYSTEM - KILLIAN CROSS DS (CATAWBA)
2. permit's signing official's name and title: THOMAS CARROLL WEBER
(person legally resperosible for permit) .
PRESIDENT
(Title)
` . Mailing address- P.O. BOX 127 cit.. SHERRILLS FOR
state: NC Zap Cod& 28673 phcm(828) 478-2785 _
Ilk. RMAAU!1111�191ftm- V1912
1. This'request,fbr i name change is a result of ,
"9. Gunge in ownership of property/company
��. Name change only
�—c. Other (please explain):
2. New omwes tame (name to be put on peratit)• HEATER . UT LL I T I ES I NC
JERRY H. TWEED
3. New owner's or signing official's name and title. --,(person legallyponsible for permit)
VICE PRESIDENT
(Title)
4. Mailing a d dress.
P.O. DRAWER 4889 cty: CARRY
Sraw NC Zip Code• 27519 p1 ( 919) 467-8712 , EXT . 37
p.0. Bax 29535. Raleigh. North Card 27626-0535 ToE,ephona (919) 7335063 FAX [phone]
An Equal opportunity AffYrrnative Action Employer Soy. recycled / 107• past -consumer paper

PERMIT NAME / OWNERSHIP CHANGE FORM
THIS APPLICATION PACKAGE WILL NOT BE ACCEPTED BY THE DIVISION OF WATER QUALITY
UNLESS ALL OF THE APPLICABLE- ITEMS LISTED BELOW ARE INCLUDED WITH THE SUBMITTAL
REQUIRED ITEMS:
1. This completed application
2. Processing fee of $100.00 (Checks to be made payable to DEI-L\M)
3. Legal documentation of the transfer of ownership (such as a contract, deed, articles of
incorporation)
Certification must be completed and signed by both_ the current permit holder and the
new applicant in the case of change of ownership. For name change only, complete and
sign the application certification -
Current Permittee's Certification.
I THOMAS CARROLL WEBER attest that this application for
name/ownership change has been reviewed and is accurate and complete to the best of
my knowledge. I understand that if all required parts of this application are not
completed and that if all required supporting information and attachments are not
included, this
/application package will be returned as incomplete.
SignaturL< J� C� L`li� ;�I�iLG4� Date: 6117 /9 q
Applicant's Certification.
T. JERRY H. TWEED attest that this application for a
name/ownership change has been reviewed and is accurate and complete to the best of
my knowledge. I understand that if an required parts of this application are not
completed and that if all required supporting information and attachments are not
included, this application packer \e will be, returned as incomplete.
Signature:Date: hlhz
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING
INFORMATION & MATERIALS, SHOULD BE SENT TO THE FOLLOWING ADDDRESS:
NC DEHNR, Division of Water Quality
Water Quality Section, Permits and Engineering Unit
P. O. Box 29535
Raleigh, North Carolina 27626-OS35

� Heater a V jZ �2MaDthCar ling
Court
J `• 15 �" Cary, North Caroline 27511
�� (,
phone : [phone]
Utilitie
faz: 919.460.1788
Noy
WATER AND WASTEWATER SERVI ES 2D1999P.O. DraNer4889, Cary, NC27519
- 4TERQUALITY
^u%Aji� 23, 1 99
Mr. Charles H. Weaver, Jr.
NC DENR/DWQ/NPDES
1617 Mail Service Center
Raleigh, NC 27626-0535
Dear Mr. Weaver:
Enclosed are the original and two copies of applications for renewal of
the discharge permits for 11 wastewater treatment plants which Heater
Utilities, Inc. (Heater) purchased from Mid South Water Systems, Inc. (Mid
South) on June 17, 1999.
The following is a list of the enclosed renewal applications:
NPDES PERMIT NUMBER
NCO075205
NCO056154
NCO058742
NCO074772
NCO067784
NCO063355
NCO062481
NCO074535
NCO062456
NCO060593
NCO080691
SERVICE AREA
Alexander Island
Bridgeport
Country Valley
Diamond Head
Governor's Island
Killian Crossroads
Mallard Head
Pier 16 Marina
Riverwood Estates
Spinnaker Bay
Windemere
Also enclosed is a copy of the sludge management plan previously
submitted by Mid South. Heater will use the same plan. Most of the waste
sludge will be removed by contract septage haulers and disposed of in various
municipal systems as permitted by the septage hauler and municipality.
If I can provide further information, please do not hesitate to contact
me.
Sincerely,
rr . weed
ice President
JHT/rt
Enclosures

SLUDGE {MANAGEMENT PLAN
for
MID SOUTH WATER SYSTEMS, INC.
No sludge will be freafed on any wasfewafer, freafinenf plant sife operated by Mid Soufh Wafer Systems, Jnc.
Where practical, sludge removed from a laid South f acitify will be fransporfed via a contract hauler fo another Mid South
3acilify for fhe purpose of "seeding" a new or under loaded ptanf.
Unusable (or "dead") sludge will be removed by a confracf hauler and properly disposed of in accordance with 11C f S 143-
215.1. Confraef haulers used by laid South will be requ:ped iv pe sort the quanfify of sludge fransporfed and idenfi f y fhe
location of fhe proposed disposal site if fhe sludge is not Taken fo an existing plant operafed by Mid Soufh. Mid Soufh has
not entered info any agreement fo accept sludge info ifs f acitifies from plants not owned by fhem.
Mid Soufh Wafer Systems, Jnc, will keep records on fhe quanfify of sludge removed from each f acit fy, fhe name of fhe
confraef hauler, and fhe desfinafion of fhe sludge (whether used in another plant or disposed of). The inf ormafion will be
kepf on file and wilt be made available fo any regulatory agency having jurisdiction over sludge freafinenf or disposal.
4