NC0063762_Permit Issuance_20081208

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
December 8, 2008
Mr. Lenwood Ham, Owner
Carolina Village Mobile Home Park
6210 Wilkenson Boulevard
Charlotte, NC 28214
Subject: Issuance of NPDES
Permit NCO063762
Carolina Village MHP WWTP
Cabarrus County
Dear Mr. Ham:
Division personnel have reviewed and approved your application for renewal of the subject
permit. Accordingly, we are forwarding the attached NPDES discharge permit. This permit is issued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of
Agreement between North Carolina and the U.S. Environmental Protection Agency dated October 15,
2007 (or as subsequently amended).
This permit includes no major changes from the draft permit sent to you on October 8,
2008.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to an adjudicatory hearing upon written request within thirty (30)
days following receipt of this letter. This request must be in the form of a written petition, conforming to
Chapter 150B of the North Carolina General Statutes, and filed with the Office of Administrative Hearings
(6714 Mail Service Center, Raleigh, North Carolina 27699-6714). Unless such demand is made, this
decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division
may require modification or revocation and reissuance of the permit. This permit does not affect the legal
requirements to obtain other permits which may be required by the Division of Water Quality or permits
required by the Division of Land Resources, the Coastal Area Management Act or any other Federal or
Local governmental permit that may be required. If you have any questions concerning this permit, please
contact Bob Guerra at telephone number [phone].
incerely*
/ TColeen
H. Sullins
Enclosure: NPDES Permit NCO063762
cc: Central Files
Mooresville Regional Office / Surface Water Protection
NPDES Unit
Mailing Address Phone [phone] Location IV�Y�`t1tCarolina
1617 Mail Service Center Fax [phone] N. Salisbury St. r/VRt1lCR��lf
Raleigh, NC 27699.1617 Raleigh, NC 27604
Internet: www.ncwaleroualitv.or¢ Customer Service 1-877-623-6748
An Equal Opportunity/Alfirmative Action Employer— 5W6 Recycled/l 0% Post Consumer Paper

Permit NCO063762
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF ENVIRONMENTAL MANAGEMENT
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General Statute 143-
215.1, other lawful standards and regulations promulgated and adopted by the
North Carolina Environmental Management Commission, and the Federal
Water Pollution Control Act, as amended,
Lenwood E. Ham
is hereby authorized to discharge wastewater from a facility located at the
Carolina Village Mobile Home Park
Concord
Cabarrus County
to receiving waters designated as the Rocky River in the Yadkin -Pee Dee River Basin,
in accordance with effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective January 1, 2009.
This permit and authorization to discharge shall expire at midnight on
November 30, 2013.
Signed this day December 8, 2008.
k
oleenH. Sullins, Director
nofWater Quality
By Authority of the Environmental Management Commission

Permit NCO063762
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or
discharge are hereby revoked. As of this permit issuance, any previously
issued permit bearing this number is no longer effective. Therefore, the
exclusive authority to operate and discharge from this facility arises under the
permit conditions, requirements, terms, and provisions included herein.
Leawood E. Ham is hereby authorized to:
1. Continue to operate the existing 0.09 MGD wastewater treatment facility
that includes the following components:
➢ Influent lift station
➢ Bar screen
➢' Aerated EQ (Contact)
➢ Re -aeration basin
➢ Clarifier
➢ Aerobic digester
➢ Tablet chlorination
➢ Contact basin
➢ Tablet dechlorination
➢ Effluent flow measurement
2. This facility is located at the Carolina Village Mobile Home Park WWTP in
Cabarrus County.
3. Discharge from said treatment works at the location specified on the
attached map into the Rocky River, currently classified C waters in the
Yadkin -Pee Dee River Basin.

Carolina Village MHP WWTP Facility
Location
Latitude: 35° 22' 16" N State Grid: Harrisbur- not to Scale
Longitude: 80140' 58" W Permitted Flow: 0.090 MGD
Ruching Stream: Rocky River Drainage Basin: Yadkin -Pee Dee River Basin NPDES Permit No. NCO063762
Stream Class: C Sub -Basin: 03-07-11 North IF Cabarrus County

Permit NCO063762
A. (1) EFFLUENT LDUTATIONS AND MONITORING REQUIREMENTS
During the period beginning on the effective date of this permit and lasting until expiration, the
Permittee is authorized to discharge treated wastewater from outfall 001. Such discharges shall
be limited and monitored by the Permittee as specified below:
PARAMETER
LIMITS
MONITORING REQUIREMENTS
Monthly
Average
Daily
Maximum
Measurement
Frequency
Sample
Type
Sample
Locationl
Flow
0.09 MGD
Continuous
Recording
I or E
BOD, 5-day, 20°C
30.0 m /L
45.0 mO/L
WeeklyComposite
E
Total Suspended Solids
30.0 m /L
45.0 mWeekl
Com osite
E
NH3 as N
(April 1- Oct 31)
20.0 mg/L
35.0 m
Weekly
Composite
E
NH3 as N
(Nov 1 - March 31)
Weekly
Composite
E
H2
Weekly
Grab
E
Total Residual Chlorines
2S.0 µg/L
2/Week
Grab
E
Total Nitrogen
(NO2 + NO3 + TKN
Quarterly
Composite
E
Total Phosphorus
Quarterly
Composite
E
Dissolved Oxygen
Weekly
Grab
E, U & D
Fecal Coliform
(geometric mean)
200/ 100 ml
400/ 100 ml
Weekly
Grab
E, U & D
Temperature, °C
I I
Dafly
Grab
E, U & D
Footnotes:
1. I = Influent. E= Effluent. U: upstream at least 100 feet from the outfall. D: downstream
at US Highway 29.
2. The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units.
3. TRC - Because low-level TRC is currently difficult to quantify in a wastewater
matrix, the Division shall consider all effluent TRC values reported below 50 µg/L
to be "in compliance" with the permit. However, the Permittee shall continue to
record and submit all values reported by North Carolina -certified field and lab test
methods, even if these values fall below 50 µg/L.
All samples collected should be from a representative discharge event.
There shall be no discharge of floating solids or visible foam in other than
trace amounts.

Permit NCO063762
A. (2) FLOOD PLAIN ANALYSIS
The facility shall conduct a flood plain analysis evaluating the 100-year flood
plain. At a mi_n I this report shall include an analysis of whether the
treatment plant is within the 100-year flood plain and plans (with a time
schedule) to address the problem. This report is due 45 days after the effective
date of the permit and should be submitted in triplicate.
A. (3) ENGINEERING ALTERNATIVE ANALYSIS MAN
No later than 90 days following the effective date of this permit, the permittee
shall submit a detailed analysis of all available means to dispose of this
facility's wastewater, including connection to any existing or future Wastewater
Interceptor lines. This EAA shall be prepared in compliance with the Divisions
guidance document for EAA's.
If no EAA is submitted, the Division may reopen and modify this permit to
increase monitoring frequencies or change effluent limits as necessary to
protect the receiving stream.

717
W7
i ' "
,`• - ,J// J ,,/a �--'�-�- � . i.. w _� � �` ..-�,.`: • is!��.�•iYu��1(11A/yfl'/VY�IiI�Y
_ .

ry
I

4 , I
The Charlotte Observer Publishing Co.
Charlotte, NC
North Carolina ) ss Affidavit of Publication
Mecklenburg County)
THE CHARLOTTE OBSERVER
DINA SPRINKLE
NCDENR/DWD/POINT SOURCE BRANCH
1617 MAIL SERVICE CENTER
RALEIGH NC 27699
REFERENCE: 30063432
6255993 Wastewater Permit
Before the undersigned, a Notary Public of said
County and State, duly authorized to administer
oaths affirmations, etc., personally appeared,
being duly sworn or affirmed according to law,
Cloth depose and say that he/she is a
representative of The Charlotte Observer
Publishing Company, a corporation organized and
doing business under the laws of the State of
Delaware, and publishing a newspaper known as The
Charlotte Observer in the city of Charlotte,
County of Mecklenburg, and State of North Carolina
and that as such he/she is familiar with the
books, records, files, and business of said
Corporation and by reference to the files of said
publication, the attached advertisement was
inserted. The following is correctly copied from
the books and files of the aforesaid Corporation
and Publication. I
PUBLISHED ON: 10/10
AD SPACE: 124 LINE
FILED ON: 10/17/08
PUBLIC NOTICE
STATE OF NORTH CAROLINA
ENVIRONMEPR 1EMANAGE1AIL MENT SERVICE MMISSI NINPOEa UNIT'
CENTER
RALEICH. NC 27699�1617
NOTN�SOyy,STEWtATER PERFIWNTTOMIT E A
of N(
8:00 aim. anI SM P.m. to rin,, ...M,..._—t NC8889782 for NC
Its
CemGra Wierr IeevaHl W NPDES perms dun.631621.
pae appbes nw,wtl w 'hgdlel to
Carding Village MHP Wastewater Tredmed Plant M Ca
County Thu Permin, ledlitY Blschat9.
Rocky Pn I the amatl River Gas"' ,1011t lY, ammcnia
'i m i arced lulure allocations In file portion of
n antl total resitlual chiotine am water quality limited �s
Eiscnatge Y
the walershetl.
The Clty d Concord Na19 o�tainia its Cotltlle GPam n dtb tl scmerge
NPOES permit NCIx183 The laciltN rs par
plant in Caherms County.
Veatetl tiller lxuMwaeh Trot^one ouMallmtoanunnnin tnCu ary
to egtltlw Gewr I^ fis wateklqud ry limitetl. TTh d Ch.ge My
Bowl resitlual chlorirtal
Xect future N N5 po,tgn of thaw p eBox 241Y308, Cherbtl�,
LP 5999
NAME: TITLE:
DATE:
In Testimony Whereof I have hereunto set my hand and affixed my seal, the
day and year afore id.
l y T -"iu0 My Commission Expires May 17. 2011
Notary? ( 1 "`'" My Commission Expires: _/_/

v
F-I

gr
YY +i'
�y
ro
1 4�
� 1
a�

+s"..,Q^�+sJ�1y< it :^.�.'w�t^ .?C -
..y —_ .. _
.� A
*
�
,�.
-
- -
r ..� ,� y �. - Lr _4T _
,. _
L
���
�.� .�/ " ItYr YS �
_ -
_
_
� ��:,1 A
i.
_ _
_
Y.. �.a-:' � �. i-rr S
e _ X
=L
i �i i r 'far"�,. .y
1 J: `y 1 4
�
Sl-�.
� y� r
-_
_a..wf _ __._ ,. _ i._
--

I • � 7Ji
i.
R..
Ott! •_�R�: •e.
:r-
mT
t.
-�� Yf, 5 �+�i-fir `• ` •�P 4 \ � ��' ._.. \ • _ ,

SOC PRIORITY PROJECT: No
To: Western NPDES Unit
Surface Water Protection Section
Attention: Susan Wilson
MAY 2 2 2008
Date: May 19 2008
NPDES STAFF REPORT AND RECOMMENDATION
County: Cabarrus
NPDES Permit No.: NCO063762
PART I - GENERAL INFORMATION
1. Facility and address: Carolina Village MHP
6210 Wilkinson Boulevard
Charlotte, NC 28214
2. Date of investigation: May 15, 2008
3. Report prepared by: Michael L. Parker, Environmental Engineer II
4. Person contacted and telephone number: Lenwood Ham, [phone].
5. Directions to site: From the jct. of Poplar Tent Road (SR1394) and Pitt School Road
(SRI305) in western Cabanas County, travel southeast on Pitt School Road 2.2 miles to
the junction with Plantation Road (SRI583). A sign marks the entrance to Silver Maple
Mobile Estates, which shares the entrance road with Carolina Village MHP. Turn right
onto Plantation Road and travel 0.15 mile. Turn left onto Lancaster Street and travel 0.2
mile to the junction with Monroe Court. Turn left onto Monroe Court, and the W WT
facility is located at the end of Monroe Court.
6. Discharge point(s), list for all discharge points: -
Latitude: 350 22' 16"
Longitude: 800 40' 58"
Attach a USGS Map Extract and indicate treatment plant site and discharge point on map.
USGS QuadNo.:F16SW
7. Site size and expansion area consistent with application: Yes. There is limited area for
future W WTP construction, if necessary.
8. Topography (relationship to flood plain included): The WWTP site slopes toward the
receiving stream at a rate of 3 - 5%. The site is not located in a flood plain.

Page Two
9. Location of nearest dwelling: Approx. 200 feet from the WWTP site.
10. Receiving stream or affected surface waters: Rocky River
a. Classification: C
b. River Basin and Subbasin No.: Yadkin 030711
C. Describe receiving stream features and pertinent downstream uses: Rocky River is
approximately 40 feet wide and carries significant flow at the point of discharge.
There is a second permitted discharger = 100 yards upstream (Silver Maple MHP
- N00047091).
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1. a. Volume of wastewater: 0.090 MGD (Design Capacity)
b. What is the current permitted capacity: 0.090 MGD
C. Actual treatment capacity of current facility (current design capacity): 0.090
MGD
d. Date(s) and construction activities allowed by previous ATCs issued in the
previous two years: There have been no ATCs issued to this permittee in the past
two years.
e. Description of existing or substantially constructed WWT facilities: The existing
WWT facility is a contact stabilization WWTP consisting of an influent lift
station followed by a bar screen, an aerated contact equalization basin, a
reaeration basin, a clarifier, an aerobic digester, tablet chlorination with contact
basin, tablet dechlorination, and effluent flow measurement.
f. Description of proposed WWT facilities: There are no WWT facilities proposed at
this time.
g. Possible toxic impacts to surface waters: Chlorine is added to the waste stream,
however, dechlorination is provided.
h. Pretreatment Program (POTWs only): Not Needed.
2. Residual handling and utilization/disposal scheme: Residuals are removed as necessary
by Liquid Waste, Inc.
3. Treatment plant classification: Class II (no change from previous rating).
4. SIC Code(s): 6515 Wastewater Code(s): 08 MTU Code(s): 09007

Page Three
PART III - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction Grant Funds or are any public monies
involved (municipals only)? No public monies were used in the construction of this
facility.
2. Special monitoring or limitations (including toxicity) requests: None at this time.
3. Important SOC/JOC or Compliance Schedule dates: This facility is neither under an SOC
nor is one being considered at this time.
4. Alternative analysis evaluation: There is no known alternative to a discharge at this time.
PART IV - EVALUATION AND RECOMMENDATIONS
The permittee has requested renewal of the subject permit. There have been no changes
to the permit since the last renewal. Changes to the existing WWT facility include the addition
of dechlorination in 2005.
Pending receipt and approval of the draft permit for this facility, it is recommended that
the subject permit be renewed as requested.
.�/9 Dom"
Signature of Report Preparer bate
Water Quality g' nal Supervisor Date
hAdsrldsr081carov1ge.doc

May 1, 2008
NCDENR I`D
1617 Mail Service Center I
Raleigh, NC 27699-1617
Re: Renewal Notice
NPDES Permit NC0063762
Carolina Village Mobile Home Park
Cabarrus County
To Whom It May Concern:
YELP''
MAY 2008
DENR • WATER QUALP
We would like to request a renewal of our permit for the above noted property. We
have also included documents for the modifications of the Carolina Village
Subdivision Dechlorination System. If you have any questions please do not hesitate
to contact me.
Thanks,
Lenwood Ham
Owner

XPDEti kPPL CATION - FO NA D
For privately owned treatment ny. :ems treating 10 % doaxme4'_1 , ;tewa7.ters <1.0 Mow
Mail tl t : complete application to:
N. C. Uepaxtment 4; f Environment and Nattuaal Reso:irees
Division of Water Quality / 111.9DES Unit
1617 Mail Service Center, Raleigh, NC 27699- .617
NPDIXS Permit C00
Please print or type.
I. Contact Information:
Owner Name
Facility Name
Mailing Address 10 U) I, [ K I �j LY)
City
State / Zip Code
Telephone Number
Fax Number
e-mail Address
(go T A 9 -00'-
(qo q)jqqq � ti
, _5N g I
2. Location cof firpcilityr producing disc agf;¢n:
Check here if same address as above ❑
Street Address or State Road M ON\
City
State / Zip Code
County
3. Operator 1.11l'orma4:hm:
Name of the finn, public organization or other entity that operates the facility.
referring to the Operator in .Responsible Charge or ORC)
Name
Mailing Address
City
State / Zip Code
Telephone Number
Fax Number
(Note that this is not
I of 3 Foi-tri--D 4/0r)

F or privately owned treatmeat systems treating 100% domestic wastewaters <1.0 MGM
I.. Descriptions of wastewater:
Facility Generating
Wastevwater(check all that apply): .
Industrial
❑
Number of Employees
Commercial
❑
Number of Employees
Residential
�4
Number of Homes
School
❑
Number of Students/ Staff
Other
❑
Explain:
Describe the sources) of wastewater (example: subdivision, mobile home park, shopping centers,
restaurants, etc.):
Mnb l �e �bmeP�
Population served:
S. Type of collection systesa
�] Separate (sanitary sewer only) ❑ Combined (storm sewer and sanitary sewer)
rf . Out-ft E orxgaz,ti®aa:
Mumber of separate discharge points I
00fall Mck--ecirxcdation sin mt hers)
Is the outfall equipped with a difl'El Yes ❑ No
7. Name of receiving strearn(s'j) (Provide a map showing the exact location of each outfall):
3. 1<,requency of Discharge: ❑ Continuous ❑ Intermittent
If intermittent:
Days per week discharge occurs: Duration: _
9. Deaceibe the treatment systein
List all installed components, including capacities, provide design removal for BOD, TSS, nitrogen and
phosphorus. If the space provided is not sufficient, attach the description of the treatment system in a
separate sheet of paper.
it
a4u �A
IUD
Ffthle-4
Qry1f��
2of3 h` Oi 1' Ull�
EPPCOeM4 �tOuO
Form-U V05

For privately owned treatment systerns treating l00% domestic %wastewate:rs <l..m Ti G)D
10. FIL-o v Information:
Treatment Plant Design flow MGD
Annual Average daily glow --�tQ .MG D (for the previous 3 years)
I1lffaa.imum daily flog 0. WGD (for the previous 3 years)
11. Is this facility located on Indian countajr?
❑ Yes 1� No
12. Effluent Data
Provide data for the parameters listed. Fecal Coliform, Temperature and p.Hshall be grab samples, for all other
parameters 24-hour composite sampling shall be used. If more than one analysis is reported, report daily maximum
and monthly average. If only one analysis is reported, report as daily maximum.
as aanetex
Daily
Arinnimurn
Monthly
Average
�] nits of
Measurement
ment
Biochemical Oxygen Demand (BOD5)
�� ID
d
I
Fecal Coliforrn
�2onlo'-A-/L4
AnomL
Total Suspended Solids
Temperature (Summer)
(}�—�
1
Temperature (Winter)
pH
C
,,
13. List all pe7rxxAts, constar actio-. approvals and/or applications:
Type Po rmLit Number hype per Lnait 1 1-mrAl-Wr
Hazardous Waste (RCRA) NESHAPS (CAA)
UIC (SDWA) Ocean Dumping (MPRSA)
NPDES ���,(���; Dredge or fill (Section 404 or CWA)
PSD (CAA) Other
Non --attainment program (CAA)
14. APP LICL:A.MT CER`I'AFICN..VION
I cox t:if that I a w, fanailiax with trio Inform antl:iorn contained in the applicat lon, azrad tlna t to the
best ofnay knowledge and belief such information is true, complete, and aceurrate.
Lef\uno A ___ afL\ 0 U)
Printed narne of Person Signing Title
ture of Applicant
Date
North Carolina General Statute 143-215.6 (b)(2) states: Any person who knowingly makes any false statement representation, or certification in any
application, record, report, plan, or other document files or required to be maintained under Article 21 or regulations of the Environmental Management
Commission implementing that Article, or who falsifies, tampers with, or knowly renders inaccurate any recording or monitoring device or molhod required
to be operated or maintained under Article 21 or regulations of the Environmental Management Commission implementing that Articlo, shall be guilty of a
misdemeanor punishable by a fine not to exceed $25,000, or by imprisonment not to exceed six months, or by both. (18 U.S.C. Section 1001 provides a
punishment by a fine of not more than $25,000 or imprisonment not more than 5 years, or both, for a similar offense.)
3 of 3 Foo m-ta 4/0t1