NC0063762_Permit Issuance_20000410

State of North Carolina
Department of Environment
'and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
April 10, 2000
Mr. Lenwood Ham
Carolina Village MHP
6210 Wilkinson Boulevard
Charlotte, North Carolina 28214
A-
NCDENR
Subject: NPDES Permit Issuance
Permit No. NCO063762
Carolina Village Mobile Home Park
Cabarrus County
Dear Mr. Ham:
Division personnel have reviewed and approved your application for renewal of the subject permit.
Accordingly, we are forwarding the attached NPDES discharge permit. The Division appreciates your
cooperation in assessing the feasibility of combining your discharge with nearby discharges. If Division
personnel can be of assistance, as you complete the Engineering Alternatives Analysis, please do hesitate to
contact us at our Mooresville Regional Office (704-663-1699) or the phone number provided below.
This permit is issued pursuant to the requirements of North Carolina General Statute 143-215.1 and
the Memorandum of Agreement between North Carolina and the U.S. Environmental Protection Agency
dated May 9, 1994 (or as subsequently amended).
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to an adjudicatory hearing upon written request within thirty (30)
days following receipt of this letter. This request must be in the form of a written petition, conforming to
Chapter 150B of the North Carolina General Statutes, and filed with the Office of Administrative Hearings
(6714 Mail Service Center, Raleigh, North Carolina 27699-6714). Unless such demand is made, this decision
shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may
require modification or revocation and reissuance of the permit. This permit does not affect the legal
requirements to obtain other permits which may be required by the Division of Water Quality or permits
required by the Division of Land Resources, the Coastal Area Management Act or any other Federal or Local
governmental permit that may be required.
If you have any questions concerning this permit, please contact Michael Myers at telephone number
[phone], extension 508.
Sincerely,
Original Signed By
David A. Goodrich
Kerr T. Stevens
cc: Central Files
Mooresville Regional Office/Water Quality Section
NPDES Unit
Point Source Compliance Enforcement Unit
1617 MAIL SERVICE CENTER, RALEIGH, NORTH CAROLINA 27699-161 7 -TELEPHONE [phone]/FAX [phone]
AN EQUAL OPPORTUNITY AFFIRMATIVE ACTION EMPLOYER - 50% RECYCLED/ 1 0% POST -CONSUMER PAPER
VISIT US ON THE INTERNET 0 http://h2o.enr.state.nc.us/NPDES

NPDES Permit: NCO063762
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and
the Federal Water Pollution Control Act, as amended,
Lenwood E. Ham
is hereby authorized to discharge wastewater from a facility located at
Carolina Village Mobile Home Park
end of Monroe Court
N 'sbfirrg Coot cord,
Cabamts County
to receiving waters designated as Rocky River in the Yadkin -Pee Dee River Basin in accordance
with effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III
and IV hereof.
This permit shall become effective May 1, 2000.
This permit and authorization to discharge shall expire at midnight on November 30, 2003.
Signed this day April 10, 2000.
Original Signed BY
David A. Goodrich
Kerr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission

NPDES Permit: NCO063762
SUPPLEMENT TO PERMIT COVER SHEET
Lenwood E. Ham
is hereby authorized to:
1. Continue operation of an existing 0.09 MGD wastewater treatment system, located at the Carolina
Village Mobile Home Park in Cabarrus County and consisting of the following treatment units:
• Influent lift station
• Bar screen
• Aerated flow equalization basin
• Aeration basin
• Reaeration basin
• Clarifier
• Aerobic sludge digester (diffused air)
• Tablet chlorination with contact basin
• Effluent flow measurement
2. Discharge treated wastewater from said treatment works at the location specified on the attached
map through outfall 001 into Rocky River which is classified C waters in the Yadkin -Pee Dee River
Basin.

Facility Information
Facility
latiWe:
35'2Z16" Sub-Bwtl 03-07-11
Location
x
largftu e:
QLjad
F16SW
Shears Class:
Receiving Stm
C
Rocky River
North
Leawood G ilam
N00063762
Pernft cd Flow:
0.09 MGD
Cmbmi Village Mobile Home Park

NPDES Permit: NCO063762
A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
During the period beginning on the effective date of the permit and lasting until expiration, the
Permittee is authorized to discharge treated wastewater from outfall(s) 001. Such discharges
shall be limited and monitored by the Permittee as specified below:
Effluent Ghracteiscs-
- 1'-. .1 : "
{1�'o�lit+DCi11q���(uil'ie�t7rlts
_.. ...
Monthly
Averagee4
Wei
very f,
.,.
Q0dy
Max�tnua
,, to
Measurement
r 0
n.T
:; ..oaa�W .�
Flow
0.09 MGD
Continuous
Recording
I or E
BOD, 5-day, 200C
30.0 m
45.0 m
Weekly
Composite
E
Total Suspended Residue
30.0 m
45.0 m
Weekly
Composite
E
NH3-N (Summer)2
20.0 m L
Weekly
Composite
E
NH3-N (Winter)2
Weekly
Composite
E
Dissolved Oxygen
Weekly
Grab
E
Fecal Coliform3
200/100ml
400/100mi
Weekly
Grab
E
H4
Weekly
Grab
E
Total Residual Chlorine
2/Week
Grab
E
Temperature, °C
Daily
Grab
E
Total Nitro en NO2+NO3+TKN
Quarter
Composite
E
Total Phosphorus
Quarterly
Composite
E
Temperature, °C
Daily
Grab
U, D
Dissolved Oxygen
Weekly
Grab
U, D
Fecal Coliform3
Weekly
Grab
U, D
Footnotes:
1. Sample Location: E — Effluent, I — Influent, U — Upstream at least 100 feet from the outfall,
D — Downstream at US Highway 29.
2. Summer is defined as the period from April 1 through October 31, while winter is defined
as November 1 through March 31.
3. Fecal Coliform shall be calculated using the geometric mean, according to the procedure
detailed in Part II. Section A, Paragraph 9b.
4. The pH of the effluent shall not be less than 6.0 nor greater than 9.0 (on the standard units
scale).
There shall be no discharge of floating solids or visible foam in other than trace amounts.

The Independent Tribune, I
od 00
NORTH CAROLINA OENR - WATER QUALITY
CABARRUS COUNTY (� , POO� NN�T SOURCE BRANCH
PUBLIC NOTICE On this, the (\ day of 1�ti 19
STATE OF NORTH
CAROLINA t♦/4/"'
ENVIRONMENTAL
MANAGEMENT
COMMISSION (NPDES UNIT
of THE INDEPENDENT TRIBUNE, Inc., after being duly
1617 MAIL SERVICE
CENTER sworn, says that the annexed advertisement was duly
RALEIGH, NO 27699-1617 inserted in the paper on the following dates:
NOTIFICATION OF INTENT
TO ISSUE A NPDES
WASTEWATER PERMIT T
On the basis of thorough staff
review and application of NO
General Statute 143,21.
Public lase 92 500 and other
;awful standards and
regulations, the North
Carolina Environmental
Management Commission
proposes to issue a National
'Pollutant Discharge
Elimination System (NPDES)
wastewater discharge permit
to the persons) listed an the
attached pages effective 45
days from the publish date at
this notice.
Written comments regarding
the proposed permit will be
accepted until 30 days after
the publish date of this notice,
Ail comments received prior
to that dale are considered is
W. final determinations
regarding the proposed
perm0_ The Director of the NO
Division of Water Quality may
'decide to hold a public
'meeting far the proposed
permit should the Division
,receive a significant degree of
public interest.
Cppies of m drop permit and
'other supporting Information
op file used to determine
'conditions present in the draft
phim it are available upon
request and payment of the
costs of reproduction, Mail
comments and/or requests for
irRormation to the NO Division
of Water Quality at the above
-%%dress or call Ids. Christie
Jackson at [phone].
extension 538. Please include
One NPDES permit number
(attached) Ia any
communication. Interested
.persons may also visit the
.Division of water Quality at
612 N. Salisbury Street,
4jaleigh, NO 27604- 1148
_t,tweon the hours of B'. DO
-a.m. and ':Do P.M. to review
information on file.
NPDES Permit Number
NC0070289, RIDGEWOOD
FARMS SUBDIVISION, P.O.'
BOX 25242, CHARLOTTE.
NO 28229 has applied for a
permit renewal for a facility
located in CABARRUS
County discharging treated
wastewater Into CALOWELL
CREEK in the YADKIN-PEE
DEE River Basin. Currently
BOD5, NH3, Dissolved
Oxygen, and fecal Callahan
are water quality limited. This
discharge may affect future
allocations in this portion of
the receiving stream.
and was published therein once a week for -11
weeks. The total cost of this advertisement $L�
Subscribed and sworn to the day (above first mentioned.
My Commission Expires
NPDES Permit Number
NC0067172, MOgRiS GLEN
ASSOCIATION WWTP, PC
BOX 716, HARRISBURG, NC
28075 has applied for a for a
facility located in CABARRUS
County discharging
wastewater into ROCKY
RIVER iq the YADKIN PEE
DBE River Basin. Currently
are water quality limited. This
discharge may a"a,, futureG
allocations in this podion of
the receiving stream.
NPDES Permit Number
NC0063762, Carolina Village
Mobile Home Park, 6210
Wilkinson Economic,
Gnerlmie. -
NO 28214 has applied far a
Permit renewal for a facility
located in Canards County
discharging treated
wastewater into Rocky River
'n the YadkinPeeDee River
Basin; Currently ammonia,
fecal colilonn, and dissolved
oxygen are water quality
limited. This discharge may
affect future allocations in this
Portion of the
receiving stream.
No. 122 Feb. 24, 2000

DENR/DWQ
FACT SHEET FOR NPDES PERMIT DEVELOPMENT
NPDES No. NCO063762
FacHity Information
Applicant/Facility Name:
Carolina Village Mobile Home Park
Applicant Address:
6210 Wilkanson Boulevard
Facility Address:
End of Monroe Court, north of Harrisburg
Permitted Flow
0.09 MGD
Type of Waste:
Domestic
Facility/Permit Status:
Renewal
County:
Cabarrus
Miscellaneous
Receiving Stream:
Rocky River
Regional Office:
Mooresville
Stream Classification:
C
USGS Topo Quad:
F 16 SW
303(d) Listed?:
Yes
Permit Writer:
Michael Myers
Subbasin:
03-07-11
Date:
January 31, 2000
Drainage Area (mi2):
86.2
Summer 7Q10 (cfs)
6.9
Winter 7Q10 (cfs):
13
Average Flow (cfs):
103
IWC (%):
Primary SIC Code:
6515
SUMMARY
The Carolina Village Mobile Home Park discharges treated wastewater through one outfall, 001. The
discharge is into Rocky River in the Yadkin -Pee Dee River Basin. The facility serves 260 mobile homes and
is located within 200 feet of a sewer line. Rocky River has been classified as class C waters and is rated as
partially supporting for fecal coliform and sediment.
Silver Maple Mobile Home Park is located 300 feet upstream of the outfall and has a permitted discharge of 0.04
MOD.
TOXICITY TESTING:
Current Requirement: none
Recommended Requirement: none
COMPLIANCE SUMMARY:
1999 — February — NOV and civil assessment — for flow and fecal limit violations.
1998 — October — Civil assessment — for BOD, TSS, fecal and flow violations.�---._.___ _ _
August - NOV —Compliance inspection report. I D � %; � ---
February — NOV — flow lh I'�
January —NOV —flow, BOD, and TSS
1997 _ November — NOV — flow I
t October — NOV — flow F E B 2 2 2000 1 h;
✓ September — NOV — flow
August — NOD — Self monitoring program
April —NOV —fecal coliform Orr1R - W4iER OlLttlTy
February — NOV —Flow _Ii S0 '+ . Skgp Cll
✓ January — NOV — Flow
1996 —April — NOV\7_POD
The facility has violated their monthly average flow limit 9 times, BOD limit 2 times, TSS limit once, ammonia limit
once, and fecal coliform limit once over the past four years.
INSTREAM MONITORING:
Fact Sh.cet
XPDL•.S Renewal
Pa"', 1,

The facility is required to monitor fecal coliform, dissolved oxygen, and conductivity, upstream and downstream of
the discharge location.
PROPOSED CHANGES:
Remove instream conductivity monitoring per Division policy.
PROPOSED SCHEDULE FOR PERMIT ISSUANCE:
Draft Permit to Public Notice:
Permit Scheduled to Issue:
STATE CONTACT:
If you have any questions on any of the above information or on the attached permit, please contact
MichaelMyers at [phone] ext. 508.
NAMES DATE:
Fa% t Sh(:ct
-iMF S €'.enoval
F'a c- 2

REGIONAL OFFICE COMMENT:
cogC'e'' i W- /fa f/
TE: 2 - 2/, 2�9a 0
EPA REGION IV COMMENT:
NAME: DATE:
f ac:t Slitct
NAI"D ES Renewni
Pave 3

Notes for Carolina Village Mobile Home Park
General Information
The facility treats 100% domestic wastewater prior to discharging into Rocky River. The
facility serves approximately 260 mobile homes and has a permitted discharge of 0.09
MGD.
Permit Writer: MJM
Permit #: NC0063762
Permit Review
In the current permit, the facility received technology based limits for BOD and TSS.
Issues with current permit:
• Check ammonia toxicity — The summer ammonia limit is 20 mg/L and there is no
winter ammonia limit.
• Dissolved oxygen - There is no limit for dissolved oxygen in the current permit.
• In the current permit the facility is only required to monitor the effluent from the
facility. This may be due to the fact that this is not a municipal facility so the 80%
removal efficiency is not required for this facility. Check on this.
• Ammonia monitoring is weekly. Check to see if 2/month is appropriate.
• Remove in -stream conductivity measurement.
• There is no toxicity test requirement. Check on this.
Permit File Review
Carolina Village Mobile Home Park operates a 0.09 MGD contact stabilization
wastewater treatment plant in Cabarrus county. The treatment plant services 260 mobile
homes and the untreated influent is 100% domestic. The facility is a Class II facility.
The treatment plant consist of the following unit:
• Influent lift station
• Bar screen
• Aerated flow equalization basin
• Aeration basin
• Re -aeration basin
• Clarifier
• Aerobic Sludge digester — diffused air
• Tablet chlorinator with contact basin
• Effluent flow measurement
The facility discharges treated wastewater into Rocky River, which has a stream
classification of C. The site is located in subbasin 03-07-11 in the Yadkin -Pee Dee River
Basin. Approximately, 300 feet upstream of the discharge location, another NPDES
individual permit holder (NC0047091) is dicharging treated wastewater into Rocky
River.
SIC:6515
Discharge Code: 08

Main Treatment Unit Code: 09007
Engineering Alternatives: The facility should conduct an engineering alternatives to
evaluate the feasability of connecting to the Water and Sewer Authority of Cabarrus
County. A sewer line belonging to the Water and Sewer Authority of Cabarrus County
lies within 200 feet of the site.
Wasteload Allocation File Review
The wasteload allocation states that the facility choose an ammonia limit in lieu of a
toxicity test. However, the facility has no winter ammonia limit.
The receiving stream has the following characteristics according to the WLA:
• Drainage area = 86.2 mi2
• Average stream flow = 103 cfs
• s7Q 10 = 6.9 cfs
• w7Q10 = 13 cfs
Silver Maple Mobile Home Park is located 300 feet upstream of the outfall and has a
permitted discharge of 0.04 MGD. It is probably worth investigating the possiblity of
adding both of these dischargers to the Water and Sewer authority.
Correspondence File Review
1999 — February — NOV and civil assessment — for flow and fecal limit violations.
1998 — October — Civil assessment — for BOD, TSS, fecal and flow violations.
August - NOV — Compliance inspection report.
February — NOV — flow
January — NOV — flow, BOD, and TSS
1997 — November — NOV — flow
October — NOV — flow
September — NOV — flow
August — NOD — Self monitoring program
April — NOV — fecal coliform
February — NOV — flow
January — NOV — flow
1996 — April — NOV — BOD
DMR Review - These violations represent the violations of monthly average limits,
not daily maximum.
The facility has violated their flow limit 9 times, BOD limit 2 times, TSS limit once,
ammonia limit once, and fecal coliform limit once over the past four years.
Basin Plan Review

The Rocky River has been rated as Partially Supporting for fecal coliform and
sedimentation. The recommendation is that new or expanding dischargers receive BAT
limits. The facility is not requesting an expansion in flow, therefore the established limits
will remain in effect. However, there is a realistic possibility that connection to a sewer
connection is viable. This would eliminate an oxygen consuming waste discharger from
the river.
According to the December 7, 1998 memo, from Steve Pellei, the facility will be required
to monitor N and P, quarterly.
General Comments
To encourage the facility to connect to the sewer line the permit (Draft cover letter and
final permit cover letter) should contain language requiring an engineering alternatives
analysis.

SOC PRIORITY PROJECT: Yes_ No X
If Yes, SOC No.
To: Permits and Engineering Unit
Water Quality Section
Attention: Charles Weaver
Date: July 15, 1999
NPDES STAFF REPORT AND RECOMMENDATION
County: Cabarrus
Permit No. NCO063762
PART I - GENERAL INFORMATION
1. Facility and Address: Carolina Village Mobile Home Park
6210 Wilkinson Boulevard
Charlotte, North Carolina 28214
2. Date of Investigation: 06-15-99
N 6 [ 9IN� n
JUL 2 1 19A J
DENR - WATER QUALITY
POINT SOURCE 9RANrH
3. Report Prepared By: Samar Bou-Ghazale, Env. Engineer I
4. Persons Contacted and Telephone Number: Mr. James Allison, ORC; [phone]
5. Directions to Site: From the junction of Poplar Tent Road (SR 1394) and Pitts School Road
(SR 1305) in western Cabarrus County, travel southeast on SR 1305 approximately 2.15
miles to the junction with Plantation Road (SR 1583). A sign marks Silver Maple Mobile
Estates, which shares the entrance with Carolina Village Mobile Home Park. Turn right onto
SR 1583 and proceed about 0.15 mile. Turn left onto Lancaster Street and proceed about
0.25 mile. Turn left onto Monroe Court; the facility is located at the end of Monroe Court
approximately 0.35 mile from the junction of Lancaster Street and Monroe Court.
6. Discharge Point(s). List for all discharge points:
Latitude: 35° 22' 16" Longitude: 80' 40' 58"
Attach a U.S.G.S. map extract and indicate treatment facility site and discharge point on
map.
USGS Quad No.: F 16 SW USGS Name: Harrisburg, NC

Site size and expansion are consistent with application?
Yes X No_ If No, explain:
8. Topography (relationship to flood plain included): Sloping south toward receiving stream
at the rate of 3-5%. The site is not located in a flood plain.
9. Location of nearest dwelling: Approximately 200 feet.
10. Receiving stream or affected surface waters: Rocky River
a. Classification: C
b. River Basin and Subbasin No.: Yadkin and 03-07-11
C. Describe receiving stream features and pertinent downstream uses: Rocky Creek is
approximately 40 feet wide and has significant flow near the point of discharge.
General C classification uses downstream. The subject discharge may interact with
the discharge from the Silver Maple Mobile Home Park's WWTP (NC0047091)
approximately 300 feet upstream.
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
a. Volume of wastewater to be permitted: 0.090 MGD (Ultimate Design Capacity)
b. What is the current permitted capacity of the wastewater treatment facility? 0.090
MGD.
C. Actual treatment capacity of the current facility (current design capacity)? 0.090
MGD.
d. Date(s) and construction activities allowed by previous Authorizations to Construct
issued in the previous two years: None.
e. Please provide a description of existing or substantially constructed wastewater
treatment facilities: The existing facility is a 90,000 GPD contact stabilization
wastewater treatment plant consisting of an influent lift station, a bar screen, an
aerated flow equalization basin, an aeration basin, a reaeration basin, a clarifier, a
sludge digester (diffused air), tablet chlorination with contact basin, and effluent flow
measurement.
f. Please provide a description of proposed wastewater treatment facilities: N/A.
g. Possible toxic impacts to surface waters: None other than chlorine.
h. Pretreatment Program (POTWs only): N/A.

2. Residuals handling and utilization/disposal scheme: N/A
a. Other disposal/utilization scheme (specify): Waste sludge is removed and
transported by Liquid Waste Management to a CMUD facility for disposal.
3. Treatment plant classification (attach completed rating sheet): Class II, see attached rating
sheet.
4. SIC Code(s): 6515
Primary: 08 Secondary:
Main Treatment Unit Code: 09007
PART III - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction Grant Funds or are any public monies
involved (municipals only)? N/A.
2. Special monitoring or limitations (including toxicity) requests: None.
3. Important SOC, JOC or Compliance Schedule dates: (please indicate) N/A.
4. Alternative Analysis Evaluation: Has the facility evaluated all of the non -discharge options
available. Please provide regional perspective for each option evaluated. N/A
5. Air Quality and/or Groundwater concerns or hazardous materials utilized at this facility that
may impact water quality, air quality or groundwater? No air quality or groundwater
concerns. No hazardous materials are used at this facility.
PART IV - EVALUATION AND RECOMMENDATIONS
The permittee, Carolina Village MHP, is applying for renewal of its permit to discharge
treated domestic wastewater. It should be noted that a sewer line belonging to the Water and Sewer
Authority of Cabarrus County is within 200 feet of this facility.
During the site investigation the wastewater treatment plant appeared to be in good
operational conditions.
It is recommended that the Permit be renewed as requested by the applicant. We would
suggest that the Mobile Home Park connect to the nearby area -wide sewer.

Signature of ReMrt Pr arer
/n
Water Quality 118gional Supervisor
-7
Date

Carolina Village MHP
Difference in Percent Dissolved Oxygen
Saturation between Upstream and Downstream
Sampling Location
5.00
4.50
0
u
4.00
3.50
a=i
3.00
.'�
2.50
2.00
1.50
a
1.00
0.50
0.00
MJM 1 NC0063762

March 23, 1999
Lenwood Ham
Carolinv Village MHP
6210 Wilkinson BLvd.
Charlotte, NC 28214
Mr. Charles H. Weaver, Jr.
NC DEHNR/DWQ/NPDES
P.O. Box 29535
Raleigh, NC 27626-0535
Subject: NPDES Permit NC0063762
Carolina Village MHP
Cabarrus County
SLUDGE MANAGEMENT =
r �
Dear DEHNR:
CJ ;
Sludge is hauled by Liquid Waste Management on a per need basis.
(determined by the ORC) to C.M.U.D. No sludge is discharged from
this facility.
Sincerel ,
Lenwood Ham
Owner/Permittee