NC0037508_Authorization to Construct_19911213

State of North Carolina
Department of Environment, Health and Natural Resources
Division of Environmental Management
512 North Salisbury Street • Raleigh, North Carolina 27626-0535
James G. Martin, Governor George T. Everett, Ph.D.
William W. Cobey, Jr., Secretary Director
December 13, 1991
Mr. Gary Frick
County of Moore
Post Office Box 905
Carthage, North Carolina 28327
Subject: Permit No. N00037508
Authorization to Construct
Moore County Water Pollution Control Plant
Wastewater Treatment Facility
Moore County
Dear Mr. Frick:
A letter of request for an Authorization to Construct was received October 29, 1991 by the
Division and final plans and specifications for the subject project have been reviewed and found to
be satisfactory. Authorization is hereby granted for the construction of dechlorination facilities and
associated chlorination facilities consisting of dual /2 horse power, outdoor service, 1,000 GPM
impeller flow rate mixers mounted at the end of the chlorine contact tank effluent, dual diffuser
assemblies mounted in front of the mixers, a sulfonator system for solution feed of sulfur dioxide
gas with programmable automatic sensors for feed control, a separate prefabricated building for
housing the sulfonator system, two trunnion scales for holding a one -ton cylinder of chlorine gas,
a chlorinator system for solution feed of chlorine gas with automatic sensors for feed controls, the
existing downward opening aluminum slide gates and slides replaced by stainless steel gates, and
all associated piping, valves, controls, flow meters and recorders, and appurtenances with
discharge of treated wastewater into Aberdeen Creek, classified Class C waters.
This Authorization to Construct is issued in accordance with Part III paragraph A of
NPDES Permit No. NCO037508 issued April 23, 1987, and shall be subject to revocation unless
the wastewater treatment facilities are constructed in accordance with the conditions and limitations
specified in Permit No. NC0037508.
The sludge generated from these treatment facilities must be disposed of in accordance with
G.S. 143-215.1 and in a manner approved by the North Carolina Division of Environmental
Management.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as may be
required by this Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
Pollution Prevention Pays
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

The Fayetteville Regional Office, phone no. 919/ 486-1541 shall be notified at least
forty-eight (48) hours in advance of operation of the installed facilities so that an in -place
inspection can be made. Such notification to the regional supervisor shall be made during the
normal office hours from 8:00 a.m, until 5:00 p.m. on Monday through Friday, excluding State
Holidays.
Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a professional engineer certifying that the permitted facility has
been installed in accordance with the NPDES Permit, this Authorization to Construct and the
approved plans and specifications. Mail the Certification to the Permits and Engineering Unit,
P.O. Box 29535, Raleigh, NC 27626-0535.
Upon classification of the facility by the Certification Commission, the Permittee shall
employ a certified wastewater treatment plant operator to be in responsible charge of the
wastewater treatment facilities. The operator must hold a certificate of the type and grade at least
equivalent to the classification assigned to the wastewater treatment facilities by the Certification
Commission.
A copy of the approved plans and specifications shall be maintained on file by the Permittee
for the life of the facility.
Failure to abide by the requirements contained in this Authorization to Construct may
subject the Permittee to an enforcement action by the Division of Environmental Management in
accordance with North Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from
complying with any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.
One (1) set of approved plans and specification
any questions or need additional information, please
number 9191733-5083. ��
yl
OR
cc: Moore County Health Dep ent
Fayetteville Regional Office
Training and Certification Unit
Facilities Assessment Unit
s is being forwarded to you. If you have
contact Mr. John Seymour, telephone