820173_Application - Split into Two Permits_20200716 (2)

To: Whom It May Concern,
I, Tommy Tyndall ownerof Tommy Tyndall Farm,COC# AWS820173 am
requesting a modification to my COC to split it into two separate farms with separate COC's.
Owne Signa ure Date

Animal Waste Management Plan Certification
(Please type or print all information that does not require a signature)
Existing or New or Expanded lease circle one
General Information: Permit No: AWG100000
Name of Farm: Aaron Tyndall Farm #2 Facility No: --
Owner(s) Name: Aaron Thomas Tyndall Phone No: 910-263-9461
Mailing Address: 6500 Maxwell Road, Autryville, NC 28318
Farm Location: County Farm is located in: Sampson
Latitude and Longitude: 35 05' 18" / -78 36' 22" Integrator: Smithfield Hog Prod.
Please attach a copy of a county road map with location identified and describe below (Be specific: road
names, directions, milepost, etc.): From Autryville take SR 1414 (Minnie Hall Rd) N pprox. 5 miles and
turn left on SR 1430 (Carroll Store Rd), go approx. 3.5 miles and turn right on Triple B Lane, Farm 42 is
approx. 0.4 miles on left.
Operation Description:
Type of Swine
No. of Animals
X Wean to Feeder
3040
o Feeder to Finish
o Farrow to Wean
o Farrow to Feeder
o Farrow to Finish
o Gilts
o Boars
Type ofPoultry No. of Animals
o Layer
o Non -Layer
Type of Beef No. of Animals
• Brood
o Feeders
o Stockers
Other Type of Livestock:
Type of Dairy
• Milking
•Dry
o Heifers
• Calves
No. of Animals
Number of Animals:
Expanding Operation Only
Previous Design Capacity: Additional Design Capacity: Total Design Capacity:
Acreage Available for Application: 19.65
Number of waste structures:
Are subsurface drains present on the farm: YES or NO
Required Acreage: 19.65
Total Capacity: 145,560 Cubic Feet (ft3)
(please circle one)
If YES: are subsurface drains present in the area of the waste structures (please circle one or both as applicable)
Owner / Manager Agreement
I (we) verify that all the above information is correct and will be updated upon changing. I (we) understand the operation and
maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or construction of new facilities will require a permit application and a new certification to be submitted to the
Division of Water Resources (DWR) and permit approval received before the new animals are stocked. I (we) understand that
there must be no discharge of animal waste from the storage system to surface waters of the state unless specifically allowed
under a permit from DWR and there must not be run-off from the application of animal waste. I (we) understand that run-off
of pollutants from lounging and heavy use areas must be minimized using technical standards developed by the USDA -
Natural Resources Conservation Service (MRCS). The approved plan will be filed at the farm and at the DWR Regional
Office and the office of the local Soil and Water Conservation District (SWCD). I (we) know that any modification must be
approved by a technical specialist and submitted to the DWR Regional Office and local SWCD and required approvals
received from DWR prior to implementation. A change in farm ownership requires a permit application to be sent to DWR
along with a new certification (if the approved plan is changed).
Name of Land Owner: Aaron Thomas Tyndall
Signature: ,% � o �fL Date: 7,1 /zdza
Name of Manager (if different from owner):
Signature: Date:
AWC - September 18, 2006

Technical Specialist Certification
1 As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant to 15A
NCAC 6H .0104, I certify that the animal waste management system for the farm named above has an animal waste
management plan that meets or exceeds standards and specifications of the Division of Water Resources as specified in 15A
NCAC 2T .1300 (formerly 2H .0217) and the USDA -Natural Resources Conservation Service and/or the North Carolina Soil
and Water Conservation Commission pursuant to 15A NCAC 2T .1300 (formerly 2H .0217) and 15A NCAC 6F .0101-.0105.
The following elements are included in the plan as applicable. While each category designates a technical specialist who
may sign each certification (SD, SI, WUP, RC, I), the technical specialist should only certify parts for which they are
technically competent.
IL Certification of Design
A) Collection, Storage, Treatment System
Check the appropriate box
X Existing facility without retrofit (SD or WUP)
Storage volume is adequate for operation capacity; storage capability consistent with waste utilization
requirements.
o New, expanded or retrofitted facility (SD)
Animal waste storage and treatment structures, such as but not limited to collection systems, lagoons and ponds,
have been designed to meet or exceed the minimum standards and specifications.
Name of Technical Specialist (Please Print): M. Kevin Weston
Affiliation Murphy -Brown, LLC dba Smithfield Hog Production Date Work Completed: 1993
Address
Phone No.:[phone]
Date: 7/io�iezo
B) Land Application Site (WUP)
The plan provides for minimum separations (buffers); adequate amount of land for waste utilization; chosen crop is suitable
for waste management; and the hydraulic and nutrient loading rates are appropriate for the site and receiving crop.
Name of Technical Specialist (Please Print): M. Kevin Weston
Affiliation Murphy -Brown, LLC dba Smithfield Hog Production Date Work Completed: 1993
Address (Agency): P.O. Box 856 Warsaw, NC 28398 Phone No.:[phone]
Signature: Date: 2o
C) Runoff Controls from Exterior Lots
Check the appropriate box
X Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been designed in
accordance with technical standards developed by NRCS.
Name of Technical Specialist (Please Print): M. Kevin Weston
Affiliation_ Murphy -Brown, LLC dba Smithfield Hog Production Date Work Completed: 1993
Address (Agency):. P.O. Box 856 Warsaw, NC 28398 Phone No.:[phone]
Signature: If I- ,t—I G✓ Date: 1-olZoLu
AWC - September 18, 2006

D). Application and Handling Equipment
Check the appropriate box
X Existing or expanding facility with existing waste application equipment (WUP or I)
Animal waste application equipment specified in the plan has been either field calibrated or evaluated in
accordance with existing design charts and tables and is able to apply waste as necessary to accommodate the
waste management plan: (existing application equipment can cover the area required by the plan at rates not to
exceed either the specified hydraulic or nutrient loading rates, a schedule for timing of applications has been
established; required buffers can be maintained and calibration and adjustment guidance are contained as part of
the plan).
New, expanded, or existing facility without existing waste application equipment for spray irrigation.(I)
Animal waste application equipment specified in the plan has been designed to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; required buffers can be maintained; calibration and adjustment guidance are
contained as part of the plan).
New, expanded or existing facility without existing waste application equipment for land spreading not using
spray irrigation. (WUP or I)
Animal waste application equipment specified in the plan has been selected to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; required buffers can be maintained; calibration and adjustment guidance are
contained as part of the plan).
Name of Technical Specialist (Please Print): M. Kevin Weston
Affiliation Murphy -Brown, LLC dba Smithfield Hog Production Date Work Completed: 1993
Address (Agency): P.O. Box 856 Warsaw, NC 28398 Phone No.:[phone]
Signature: 'W Date: 1/7oz-6
E) Odor Control, Insect Control, Mortality Management and Emereencv Action Plan (SD
SI, WUP, RC or I)
The waste management plan for this facility includes a Waste Management Odor Control Checklist, an Insect Control
Checklist, a Mortality Management Checklist and an Emergency Action Plan. Sources of both odors and insects
have been evaluated with respect to this site and Best Management Practices to Minimize Odors and Best
Management Practices to Control Insects have been selected and included in the waste management plan. Both the
Mortality Management Plan and the Emergency Action Plan are complete and can be implemented by this facility.
Name of Technical Specialist (Please Print): M. Kevin Weston
Affiliation Murphy -Brown, LLC dba Smithfield Hog Production Date Work Completed: 1993
Address (Agency): P.O. Box 856 Warsaw, NC 28398 Phone No.:[phone]
Signature: iy_ Date: w
F) Written Notice of New or Expanding Swine Farm
The following signature block is only to be used for new or expanding swine farms that begin construction after June
21, 1996. If the facility was built before June 21, 1996, when was it constructed or last expanded
I (we) certify that I (we) have attempted to contact by certified mail all adjoining property owners and all property owners
who own property located across a public road, street, or highway from this new or expanding swine farm. The notice was in
compliance with the requirements of NCGS 106-805. A copy of the notice and a list of the property owners notified are
attached.
Name of Land Owner:
Signature: Date:
Name of Manager (if different from owner):
Signature: Date:
AWC - September 18, 2006 3

III. Certification of Installation
A) Collection, Storage, Treatment Installation
New, expanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds, have been installed in
accordance with the approved plan to meet or exceed the minimum standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation Date Work Completed:
Address (Agency): Phone
B) Land Application Site (WUP)
The cropping system is in place on all land as specified in the animal waste management plan.
Name of Technical Specialist (Please Print): M. Kevin Weston
Affiliation Murphy -Brown, LLC dba Smithfield Hog Production Date Work Completed: 1993
Address (Agency): P.O. Box 856 Warsaw, NC 28398 Phone No.:[phone]
Signature: .+!. /"') —4} Date: 71o�zor�
C) Runoff Controls from Exterior Lots (RC)
Facility with exterior lots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been installed as specified
in the plan.
For facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print):
Work Completed:
Address (Agency):
D) Application and Handling Equipment Installation (WUP or I)
X Animal waste application and handling equipment specified in the plan is on site and ready for use; calibration
and adjustment materials have been provided to the owners and are contained as part of the plan.
o Animal waste application and handling equipment specified in the plan has not been installed but the owner
has proposed leasing or third party application and has provided a signed contract; equipment specified in the
contract agrees with the requirements of the plan; required buffers can be maintained; calibration and
adjustment guidance have been provided to the owners and are contained as part of the plan.
Name of Technical Specialist (Please Print): M. Kevin Weston
Affiliation Murphy -Brown, LLC dba Smithfield Hog Production Date Work Completed: 1993
Address
Signature:
Phone
AWC - September 18, 2006

E) Odor Control, Insect Control and Mortality Management (SD, SI, WUP, RC or I)
Methods to control odors and insects as specified in the Plan have been installed and are operational. The
mortality management system as specified in the Plan has also been installed and is operational.
Name of Technical Specialist (Please Print): M. Kevin Weston
Affiliation Murphy -Brown, LLC dba Smithfield Hog Production Date Work Completed: 1993
Address (Agency): P.O. Box 856 Warsaw, NC 28398 Phone No.:[phone]
Zo zp
Please return the completed form to the Division of Water Resources at the following address:
Department of Environment and Natural Resources
Division of Water Resources
Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, NC 27699-1636
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the DWR Regional Office and the local Soil and Water Conservation
District Office and to keep a copy in your files with your Animal Waste Management Plan.
AWC - September 18, 2006

y
w
w
H
Cw
L
IL
z
w
0
w
}
y
z
O
F-
a
0
E
E
0
U
C
b
d
N_
N0)
a)
r
ui
c
C
O
N
O
U
Co U1
E 0 � L
U
Q aL
a
a�
rn
d cu
d)
fn
E o
.
U
N Q
E 0 d L
W
U
_ Co �
'CL C
_
Q
a
0
U
N
E 00
LLf0
N
— U
m Z (0
C a) �
F n a M
o
o
C F` > N
O Z
O
O
(6 O
Q M Q Q)
(n
N i/1
N N
N C
U
O
Z a L
F
o a
O Q 0)
—
0
0
N
U)
o
C
r
O
N
� 65
C
Em
N
E N
3
U
d
a
X
O
d
.X Z U
c0 (D o co
c
fq
a
o.
�
m
J
v
Q
N
LL
N
E
a
LL n
z
AI�111

9-
N
C
d
N
c
C9
0
O
A
rn
rn
c
A
F
N
W
J
m
Q
F
i 0
m E D
Cu
W
111111
I��
1
INIII

m
0) �
C C
0 E2 N
Q fl
00
N
01a)
C
U N
C m
d
C M
m c
v` 0
S
0
0
E
z
0
z�
'o C
m
O

v
N
L
N
U)
W
W
U)
Z
O
a
U
LL
U
W W
a=
U U
(n Q
LU
Q
H
U
LQL
D
C Z
O n
O p W
W
a �:: cn
a)
a
o
co
C
O
m
c
C,
O
>
Fn
O
>
Fn
V
O
>
c
i.D
75
U
C
aJ
C
O_
M
O
N
N
L6
V
cc
O
N
#
U
N
U
L
C
O
W
cr,i
a1
N
OCL
C_
a
N
a1
O
c
()
c
a)
O
E
W
cr
cl
cl
N
m°
U
O
a)
O
d
U
N
Y
()
N
a)
C
d
N
U)
t
O
a
m
J
o
3
a`
cuLLOo
=w
Ha
aE
Y
U
0
m
-
CO
�O
aO
(O
N
V1
C)
C)
0
0
�
Q
2
of
F-Q
Y
U
0
m
Cl)
O—
O
M
2
W
2
H
Q
Y
U
0
m
CO
N
V
N
n
Of
W
H
Q
y
c
0
U
U
N
U
O
CO
a
a
L
N
O
d
c
>
H
a
w
j
m
U
a
a
-o
Co
d
0
a
Hto
11
-1.0)

§
}
\
,
\
\
}
§
/
\
\
\
0
)
!
;
)
a
\§
§
[0
■
\\
0RL
0
0
f
_
\
E
\}\k
\
_
]t#\
4tlk4k«(
(
}f)\§E
}
{)
k
\
\
d
/
\
/kE
)
Ij!!{//o
;
:
an
\}
EEa
<00
0
w/w\a}/{0
bi
0

/
$
ƒ
c
k
�
_ 2
)2
0_
4
a
,
,
=
=
§)
/E
/K
§)k
{
{
kE
k\
§0M
}(
%a
%)
4)
-
/\�
%\
CL
%D
--
\
fr
k0
(
�7
-_-
))
>
)®
)
/k
)ƒ}
\ƒ
})�
��
a/
-�
-�
I/
���
¥
�I`t®
�$k�)\k
_
CU /CUF
)k®
/$
®
§
_
)//
a)
§
co
a
cc
/)k
I
-
-
2 cL
2D
\/)
f
-co
\\�
_
(§
-
\(/
ac
'a
}E
EE
_ccu
}{[
]
7(U
fQ}
_
7 \/
\
\ _
-_ C
_
_2
\
E®k
E®k
\cu
_ƒ
\\�)
7�(
)j/
LL
°
fR
GEƒ
«EK
/n=0
)0
!/§
3&a
§2z
/»z

Sheet7
Sprinkler Specifications
Sprinkler Type:
Nelson 150
Nozzle Size:
1.18 inches
Sprinkler Pressure:
60 psi
Flowrate(GPM):
225 gpm
Wetted Diameter:
285 feet
Lane Spacings
CALCULATIONS
* Reflects a 10% reduction from chart
Desired Spacing (%): 70 %
Design Spacing(feet): 199.5 *PVC irrigation pipe normally comes in 20' pieces,
so round to the nearest multiple of 20.
Actual Spacing (feet): 200 feet
Actual Spacing (%): 70 %
Application Rate
Application Rate = (96.3xFlowrate)/(3.1415x(.9xradius)squared)
Design App. Rate =
0.42 in/hr
300 degree arc =
0.50 in/hr 330 degree arc = 0.46 in/hr
220 degree arc =
0.69 in/hr
180 degree arc =
0.84 in/hr
Traveller Speed
Travel speed = 1.605 x Flowrate / Desired application amount x Lane Spacing
Desired app. (in.) = 0.5 inches
300 degree arc = 4.33 ft/min
220 degree arc = 5.78 ft/min
180 degree arc = 7.22 ft/min
Mainline Velocity
360 degree arc = 3.61 ft/min
330 degree arc = 3.94 ft/min
Velocity = .408 x Flowrate / pipe diameter squared feet/sec.**
**For buried pipelines, velocity should be below 5 feet per second
Pipe size: 4 inches
Velocity= 5.74 ft/sec.
Page 1

i
Iw
W
r
M!O
0
0
C.
0
0
0
0
00
Co
O;O
Co
0
0
0
0
N-7
(O
cr�
CoCDO.O
O
O
O
O
O
O
O
O
O
O
O
O
O
CDN
l0
U
LD
M"r
0
0
0
O:o
O
O
O
0
0
O
O
O
C.
o
O
0,0
M
F
1
�
a
I
I
I
N
W'
a
.o
m
O
v
Ln
m
r�
v
0
0
7
0
06
0
0
O
0
0
o
0
0
0
0
0
0
0
0
0
0
00
00
0
O
0
Oi0
0
0
0
0
00
0
0
0
0
0
0
0
o
0
0
0
0
0
0
0
0
0
0
00
0
O
0
0
O10
0
0
o
0
0
0
O
0
0
0
O
0
0
U
a
U)F
0
(D
0
�y
l0
0
0
0
00
0
0
00
0
0
O10
O
O
O
010
O
U)
LU Ll
(O
m
(O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
v
(O
U0
(O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
NO
(0
0
0
0
0
0
0
0
C.
0
0
00
0
0
0
0
00
0
0
0
O
N
O
U)
M
N
0)
c
Nf-
U'-NM
O
0
Cl)
00000
00000000000010
N
C
a
N
0
O
0
O
N
N
0
O
0
O
0
O
0
O
0
O
0
O
0
O
C.
O
0
O
0
O
0
O
0
O
0
O
0
O
0
O
0
O
0
O
0
O
Occ
-O
M
N
M
O
o
0
0
0
0
0
0
0
0
0
0
0
�O
O
O
O
O
LL
�
O'
~
N
U
N
IN
M
Cl)
0
0
0
0
00
0
O
o
0
0
0
00
0
000
HU
N
a)
U
.O
O
N
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
c
coU
N
0)(O
N
O
O
O
'O
0
0
0
0
00
0
C.
0
0
0
0
0
0
O
O
Q
-�_
CO
N
M
0
0
0'O
0
0
0
0
0
Oi0
0
0
0
0
0
0
0
Q0
E
I
II I
I
o(D�
o�o
o
0
0
0
o
CDO.I'O
oll,o
o
O
o'O
o
OII
r1
rn
O
Oi�
m
0
0
00000000
>�rl�
oO�O
o
01000I�
� O
O
C',I
d'
1
I
d
rn
m
a

N

oc
V � p e
U 'm J
UIQ33NN y�
l+
i2•awa-...
/
I
Zl 'oV Eb'b
O _N
> d
n w
� v v
0 0
OL 'oV L9'E �•� I rim
o d
3 3 o I N c c
v va
8 'oV l l'S
1 � >
1 ca a
I a c i
IS
\ / p o
I C d C d
p C d C
O pp O
P NOd NL L
ry e 3 3 0 p o p
. n n
� L.--- o E d E
> J N J
n o n
gl o
I o 8 a
_--- ________________ o uio
c
a �
J
I �
I c n a
I I d'n c'n
N 1 c o N a xa z0 0
d
1 j U M I p
1 J c J o
1 N. 0 I O U• J O O
O w H
0 ma°dam
U. -
F V J O J d C
: QQQ�a�oJ a
n«mom
°tea ° o
`a Sri �c a - a ° w`
v E-
Cl)
T T 1 O W
p'O d
Jtioa o J Q-i C
0-1
1N d V O
ta_yI d N�N o
ad 1
C %riN rn�d NI>c�x�
072 O O d, p. co i
JN O✓
Z La E:E
'c� �Z�cox ww
a p
d E o c> m p
�n i�mwa ��I o
n

OPERATION & MAIN 1 ENANCE PLAN
Proper lagoon liquid management should he a year-round priority. It is especially
Important to manage levels so.ha: you do not have yioblei115 during extended rainy and
we'Periods,
Maximum storap capacity sho,:ld be avaiiable in the lagoon for period5 when the
rece:vine crop 15 dormant.Isuch as winteinime for hermudagrass) or when there are
extended ra,nv spells such as the thunderstorm season it the summertime. This.means
that of the first signs of plant growth in the later winter/early spring, irrigation according to
a farm-: waste management plan should be done whenever the land is dry enough to
receive lagoon liquid. This will make storage space available in the lagoon for future wet
periods. In the late summer/early Tali the lagoon should be pumped down to the low
marker ;See Figure 2-1) to allow for winter 5t072ze. every effort should be made to
maintain the lagoon close to the minimum liquid level as lor.g as the weather and waste
utilization plan .viif allow it.
%'Waiting until the lagoon has reached is maximum storage capaci ;' before sta..ine to,
irrigate does not leave room for storing excess water during extended wet periods.
Overflow from the lagoon for any reason except a 25-year, 24-hour storm is a violation of
state law and subject to penalty action.
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for the dam.
Fescue or common bermudagrass are the most common vegetative
covers. The vegetation should be fertilized each year, if needed, to
maintain a vigorous stand. The amount of fertilizer applied should be
based on a soils test, but in the event that it is not practical to obtain
a soils test each year, the lagoon embankment and surrounding areas
should be fertilized with 800 pounds per acre of 10-10-10, or
equivalent.
Brush, and trees or. the embankment must be controlled. This may be
done by mowing, spraying, grazing, choppping, or a combination „f
these practices. This should be done at least once a year and
possibly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the herbicide must not be alloyed to enter
the lagoon water. Such chemicals could harm the bacteria in the lagoon that are treating
the waste.
Maintenance inspections of the entire lagoon s ,.ould be made during the Initial iiliirg of
the lagoon and at leasr monthly and after major rainfall and storm events. Itens to be
checked should include, as a ninim�jn, the following:
Waste Inlet Pipes, Recycling Pipes, and Overflow Pipe.F--look for:
1. separation of joints
2. cracks or breaks
3. accumufatior, of salts or minera's
overall condition of pipes

Lagoon surface —look for:
1. undesirable vegetative growth
2. floating or lodged debris
Embankment —look for: . -
1. settlement, cracking, or "jug" holes
3 side slope stability-5IJ'n,7S or bulges
3. : wet or damp area: on the bast: slope
-4. erosion due to lack of vegetation or as a res it of wave"action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave a=ion caused by strong
winos. These waves can erode the lagoon sidewalls, thereby weakening tie lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the lagoon may be
used to reduce the wave impacts.
hnv of these features could lead to erosion and weakening of the da.n,. Ii your lagoon has
any of these features, you should call an appropriate exile„ iarnir?r with desten and
construction of waste lagoons. You may need to provide a temporary fix iith2re isa threat
of a waste discharge. however, a permanent solution should be reviewed by the
technical exp ert. Any digging into a lagoon dam with heavy equipm?nt is a serious
underaking with potentially serious consequences and should not -)e con,ducred unless
recommended by an appropriate technical expert.
^ Transfer Pumps —check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, ora large amount of vibration; may indicate that the pump is in need or repair or
replacement.
NOTE. Pumping systems should be inspected and operated frequently enough so ;nat you
are not comp!eteiy "surprised" by equipment failure. You should perform your pumping
system, ^-ainterance at a time when your lagoon is at its low level. This will allow some
sa`ety time shculd major repairs be required. Having a nearly ful! lagoon is not the time
to think about switching, repairing, or bcrrowing pumps. Probably, if your lagoon is full,
you, neighbor's lagoon is full also. You should consider maintaining an inventory of spare
parts or purr fps.
Surface water diversion features are designed to carry a!1 surface
drainage waters (such as rainfali runoff, roof drainage, gutter outlets,
and parking lot runoftl away irorn your lagoon and other waste
treatment or storage structures. The only water that should be
coming from your lagoon is that which comes from your flushing
(washing) system pipes and the rain. -all that hits the !agoon directly.
`rou should inspect your diversion system for the following:
1. adequate -vegetation
2. dit'?rsion capacity
�"� .3.ridge berm he:zht

identified problems should be corrected promptly. I: is aavisabfe to i.spect your system
during or immediately following a heavy rain. If technica; assistant._ is needed to
determine proper solutions, consult with appropriate experts. '
You should record the level of the lagoon just prior to when rain is predicted, and :hen
record :he level again 4 to b hours after the rain (assures there is no pumping). This will
give ,you an idea of how much your lagoon level w;ll rise with a certain rainfali amount
(you must also be recording your rainfall for this to work;. Knowing this should help in
planning irrigation applications and storage. if your lagoon rises excessively, you may .
have an inflow problem from a surface water diversion or there may be seepage into the
lagoon from the surrounding land.
La;oor, Operation
Startup:
1.
Immediately after construction establish a complete iod cover on bare soil
surfaces to avoid erosion,.
2.
Ml new lagoon design trea:m—,tent volume a: least )­•aif furl of water before
waste loading begins, taking care not to erode lining or bank slopes.
.3.
Drainpipes into the lagoon should have a flexible pipe extender on the
end of the pipe to discharge near the bottom of the lagoon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining.
4.
When possible, begin loading new lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
S.
it is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon
liquid voiu,;.e. TS seeding should occour at least two weeks prior to the
addition of wastewater.
0.
Maintain a periodic check on the lagoon liquid pH. ;,'the pH fails below
7.0, add agricultural firne at the rate of i pound per 7000 cubic feet of
lagoon liquid volume until the pH rises above 7.0. OOLIMUm lagoon licuid
pH is between 7.3 and B.O.
7.
A dark color, lack of bubbhria. arc excessive odor signais inadequate
biological activity. Consultation with a technical specialist is recommended
if these conditions occur for proionge= peficds, especially during the warm
season..
Loading.
The more frequently and regularly t^at wastewater is ached to a lagoon, the better the
lagoon will function. Flush systems that stiasn waste into the lagoon several tines daily are
opti-tum for
treatment. Pit recharge systems. in wh;ch one or more buildings are drained
and r_caar-,,ed each day, also won'. •.•.-el;.

Practice water c;onsen'at!on—minimize building "ater.usa, and
spillage fron leaking waterer_.; broken pipes and'.vashdown through
proper maintenance ar•d water conservation.
:Vcinlsn122 feed wastage and spillage by keeping feeders adjusted. This
KIII reduce the an;our,( of solids entering fine lagoon
Management:
Maintain lagoon :igjid level between the perm -anent storage level an --
the full temporary storage level.
Place visible r„arke;s or stakes on the lagoon bank to show the
rrdnimum liquid level and the maximum liquid lever (Figure 2-1).
dart irrigating at the earliest possible date in the spring based on
nutrient requirements and soil moisture so that temporary storage
: M be maaimizeo for the summer thunders.orn) seaso^. Similarly,
irrigate in 6e late s'.:.T:^ie."early fall to Provide raxirnum lavocr•,
storage for the winter.
The lagoon liquid level should never be closer than ! foot to the lowest
point of the dam or embankment.
�? Do not pump the lagoon liquid level lower that the permanent storage
level unless you are removing sludge.
"N
Locate float pump intakes approximately 18 inches underneath the liquid
surface and as far away from the drainpipe inle's as possible.
Prevent additions of bedding materials, tong-stennned forage or vegetation,
molded teed, plastic syringes, or other foreign materials into the lagoon.
Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed.
titaint2!n strict, vegeta:lc`n, rodent, and varmint cdrtroi near lagoon edo s.
Do not allow trees or large bus! es to grow or. lagoon dam or embankment.'
Remove sludge from the lagoon either when the sludge storage capacity is
full or before it n!is 50 perce;t of the per nnanent raj volume,
if animal production is to be terminafed, the owner is respor:sibie for
Obtaining and imp!e:,antng a ciesure p.an to e!ir ireie the possibility or a
Folfutant discharge.
Sludge Removal:
Pate or lagoon s!udge buildup Can be resuced by:

Po_s:ble Causes of I acoon Failure
Ia the Cn;)!2 nec .,7r a'a_a tt' si _t': ii: Si.. �u '=•a •-�.
Or rZl l!.'f=s !^.CIC,Ic lec�c :I':"C Jepw [ ,LJ " "i i. '•.1•� .. T!
+ F- h n3 v.ICT :�• ii•.: c?, a\'2'.'.7^. N'c, and
�G,'�. i'l]]e'r.. �[� � roper C?JI g7 2''rl� .. :.JLvul'�^ �r41j.'.fu• r- r!•10V•`•:r.: i"4. 4'il�. �. '..
saie4!r hems wh;Ch may i63d :.. ::? �_f?c II:�i:SC •?:
Of tl' e la Icon s: ,.. •-2.'. _';2'1� F - �:=.'.?2ri _f a ^i�=_
:ntnaCB:`?'n'i:no probe: des-,n._
dEil$n be'ore pla6ne a`—, I;tea_ inm7G.
_apon liquid le•:eis—l�lo:•1 !?ve!s are c Ks'
rd!ilirA to II'sps—C and ma;..2in trig Cn.T..
Li[^ rho
Mel Int erf''—•r rote" "3^1 ini?t pipe scoL'rif%e, IZT2es
re.'r1C'.''al, n.' rup ture :10:r;7 iOWeri^' 'a Con lr :FIB ieVpl �'i 1Y 'c•
,able,
NOTE: tF lagoon water is allowed to overtop the darn, the mevi-g water will soon cause
guiiies to form in the dam. Once tlis dama;e starts, It car) qu-ickIv Ca_'se a lar ge discharge
ot, War awater and possible dam Failure.

SAMPSON COUNTY
EMERGENCY ACTION PLAN
DIVISION OF WATER QUALITY (DWQ) 910-486-1541
EMERGENCY MANAGEMENT SERVICES (EMS) 910-592-8996
SOIL R WATER CONSERVATION DISTRICT (SWCD) 910-592-7963
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) 910-592-7963
COOPERATIVE EXTENSION SERVICE (CES) 910-592=7161
This plan will be implemented in the event that wastes from your
operation are leaking, overflowing, or running off the site. You should
NOT wait until wastes reach surface waters or• leave your property to
consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an
accessible location for all employees at the facility. The following
are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may
or may not be possible. Suggested responses to problems are
listed below:
A. Lagoon overflow -possible solutions are-
a. Add soil to berm to increase elevation of dam, any
permanent alteration of the dam should be approved by a
qualified technical specialist.
b. Pump wastes to field at an acceptable rate.
c. Stop all additional flow to the lagoon -hold waste in the
house if possible.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field -action include:
a. Immediately stop waste application.
b. Create a temporary diversion or berm to contain the
waste.
c. Incorporate waste to reduce further runoff.
d. Evaluate and eliminate the reason(s) that caused the
runoff.
e. Evaluate the application rates for the fields where
runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
e. Repair all leaks prior to restarting pumps.
D. Leakage from flush system, houses, solids separators -actions
include:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Make sure no siphon effect has been created.
d. Stop all flows in the house, flush systems, or solid
separators.
e. Repair all leaks prior to restarting pumps.

E. Leakage from base or sidewall of lagoon. Often this is seepage
as opposed to flowing leaks -possible action:
a. Dig a small sump or ditch to catch all seepage, put in a
submersible pump, and pump back into lagoon.
b. If holes are caused by burrowing animals, trap or remove
animals and fill holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side
walls and the lagoon bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what
duration?
c. Any damage noted, such as employee injury, fish kills, or
property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface
waters?
f. Could a future rain event cause the spill to reach
surface waters?
g. Are potable water- wells in danger (either on or off of
the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, call your DWO (Division of
Water (2uality) regional office, at 910-486-1541, after
hours, emergency numberel-800-858-0368. Your phone call
should include: YOUR NAME, FACILITY, TELEPHONE NUMBER,
THE DETAILS OF THE INCIDENT FROM ITEM #2 ABOVE, THE
EXACT LOCATION OF THE FACILITY, AND THE LOCATION OR
DIRECTION OF MOVEMENT OF THE SPILL, WEATHER AND WIND
CONDITIONS. THE CORRECTIVE MEASURES THAT HAVE BEEN UNDER
TAKEN, AND THE SERIOUSNESS OF THE SITUATION.
b. If spill leaves property or enters surface waters, call
local (EMS) Emergency Management Services at
910-592-8996.
c. Instri.tct EMS to contact local Health Department.
d. Contact local Soil and Water Conservation District
(SWCD), Natural Resources Conservation Service
(NRCS) office at 910-592-7963 and Cooperative Extension
Service (CES) at 910-592-7161 for advice/technical
assistance.
4. If none of the above works call 911.or the sheriffs Department
and explain your problem to them and ask that person to contact
the proper agencies for you.

S. Contact the contractor of your choice to begin repair of the
problem to minimize off -site damage.
a. Contractors Name: (AR�tStH Co A,r&ALTe Peg
b. Contractors Address: _AUTw t1iLi
c. Contractors phone: 9ro- 4B5- 3Lo7
6. Contact the technical specialist who certified the lagoon (MRCS,
Consulting Engineer, etc.)
a. Name: QWQXLENm Cwr-rav
b. phone: 910.592- 'V776 C-KT.zf
7. Implement procedures as advised by UWQl and technical assistance
agencies to rectify the damage, repair- the system, and reassess
the waste management plan to keep problems with release of wastes
from happening again.
8. If you are a contract swine grower associated with a swine
company integrator, contact the company representative at
1-910-592-5771

&
(A
32
k
k
k
0
k
�
£
�
■
§
2
k
$
k
§
B
§
$
&
\
%
7
§
f
§
«
ƒ
§]
e
f f
m b
n
b
o
■
k
ifl kI
\
�
{
)
%
$
0
±§nƒ
§d(&
3wlma
■6E6
�§,
)®
k
] t
e
§
2
)
\
�
Ll

32
avi
r
t�
c
c.>
`o
v
O
e
d
a)
cn
cc
A
d
Loi
L.
LL
m
c
d
L
O
Ed r
In
V
A
pp�
�p
�
W c6
C4
C�
Q
❑.
O
o °q
eo
O
T
N
N
T
aN
to
a
C6
O
3
Gad
.O
O
9
etl
o
>

V
N
• • e
•
C
C
[
CL
u
V
o
.y
O
R
•-
:c
3
3
�
0
3
0
o
u
p
•[
x_
�
:j
m
a
Q
bb 4
>
m
a
v
•D y
R A
y Oa 40 O
m ,� w
0
v
L N
y C gym'' >
_ w
O' C O
O
a
O ,C p
V
4)
>
c° o o
00 Go a
❑ ❑ ❑ ❑
cs
ba
"J
ti
v'
LJ
•
C
9
c

a
kl
i
ti
C•i y
O N
X U
C40
W �
Q Q Q Q Q 3 a
Illllla
�cn0cnEna�
UU U U U UU
z 4 z z z z z
00
W
m
0C-4
00 W
CN
d
W � W
v
o d E" to h
0
oa
ca ,a
0 6'
� � Qi y •'i
Eao-xa
aa�a,ya
co)a cd > Q a
20
4ca
wwb
N
o O o ' O Q
7? 7 m p d
C
Rf O O
C C C C 0-0 q Q
nticnrn aUUW
M

bQ N
y .q J7
3
ea y o0
90
w .+
q G 3i
q
O
- n
M
�p� p
00
a o 0
e Ci

a
k
§
J
k
2
a
¥
E
u
]
\
j

Version —November 26, 2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Q Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106.403). The bottom of the burial pit should beat least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
© Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
a ❑ A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
❑ a In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
a Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Signature of Farm Owner/Manager Date
"4-7. e-, z�
Signature of Technical Specialist Date