HomeMy WebLinkAboutNC0073539_Authorization to Construct_20090507North Carolina
Beverly Eaves Perdue
Governor
NCDENR
Department of Environment and Natural Resources
Division of Water Quality
Mr. Michael Melton
Aqua North Carolina, Inc.
4163 Sinclair Street
Denver, North Carolina 28307
Dear Mr. Melton:
Cole H. Sullins Di RECENED
Director
May 7, 2009
MAY 13 2009
DENR - WATER OUALITY
POINT SOURCE BRANCH
SUBJECT: Authorization to Construct
A to C No. 073539A02
Aqua North Carolina, Inc.
Willowbrook Subdivision W WTP
Mecklenburg County
A letter of request for an Authorization to Construct was received September 8, 2008, by
the Division of Water Quality (Division), and final plans and specifications for the subject
project have been reviewed and found to be satisfactory. Authorization is hereby granted for the
construction of modifications to the existing 0.048 MGD Wastewater Treatment Plant, with
discharge of treated wastewater into Ramah Creek in the Yadkin -Pee Dee River Basin.
This authorization results in no increase in design or permitted capacity and is awarded
for the construction of the following specific modifications:
Installation of a 9,900 gallon steel flow equalization tank with two (2) 144 CFM
blowers and diffuser assembly, duplex 83.3 GPM submersible pumps, flow
divider box, including all piping, electrical controls, and other appurtenances
necessary to provide a complete system, in conformity with the project plans,
specifications, and other supporting data subsequently filed and approved by the
Department of Environment and Natural Resources.
This Authorization to Construct is issued in accordance with Part III, Paragraph A of
NPDES Permit No. NCO073539 issued October 7, 2008, and shall be subject to revocation
unless the wastewater treatment facilities are constructed in accordance with the conditions and
limitations specified in Permit No. NC0073539.
The sludge generated from these treatment facilities must be disposed of in accordance
with G.S. 143-215.1 and in a manner approved by the Division.
1617 Mail Service Center, Ralegh, North Carolina 27699-1617 One
512 N. Salisbury St. Raleigh. North Carolina 27604 NorthCarolina
Phone: 919-807-63001 FAX: 919-807-64921 Customer Service: 1-877-623-6748
Internet: mm.ncwaterquality.org �atura!!�
An Equal Opponunily 1 ARmialive Action Employer
Mr. Michael Melton
May 7, 2009
Page 2
.;." X.-1. �„ �
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the; Permittee shall take immediate corrective action, including those as may
be required by the Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
The Mooresville Regional Office, telephone number (704) 663-1699, shall be notified at
least lorty-eight (4%hours in advance of operation of the installed facilities so that an on site
inspection can be mg&.. Suchliotification to the regional supervisor shall be made during the
normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State
Holidays.
Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a professional engineer certifying that the permitted facility
has been installed in accordance with the NPDES Permit, this Authorization to Construct and the
approved plans and specifications. Mail the Certification to: Construction Grants & Loans,
DWQ/DENR, 1633 Mail Service Center, Raleigh, NC 27699-1633.
Upon classification of the facility by the Certification Commission, the Permittee shall
employ a certified wastewater treatment plant operator to be in responsible charge (ORC) of the
wastewater treatment facilities. The operator must hold a certificate of the type and grade at
least equivalent to or greater than the classification assigned to the wastewater treatment
facilities by the Certification Commission.
The Permittee must also employ a certified back-up operator of the appropriate type and
grade to comply with the conditions of T15A:8G.0202. The ORC of the facility must visit each
Class 1 facility at least weekly and each Class II, III and IV facility at least daily, excluding
weekends and holidays, must properly manage the facility, must document daily operation and
maintenance of the facility, and must comply with all other conditions of T I 5A:8G.0202.
A copy of the approved plans and specifications shall be maintained on file by the
Permittee for the life of the facility.
During the construction of the proposed additions/modifications, the permittee shall
continue to properly maintain and operate the existing wastewater treatment facilities at all times,
and in such a manner, as necessary to comply with the effluent limits specified in the NPDES
Permit.
You are reminded that it is mandatory for the project to be constructed in accordance
with the North Carolina Sedimentation Pollution Control Act, and when applicable, the North
Carolina Dam Safety Act. In addition, the specifications must clearly state what the contractor's
responsibilities shall be in complying with these Acts.
Mr. Michael Melton
May 7, 2009
Page 3
Prior to entering into any contract(s) for construction, the recipient must have obtained all
applicable permits from the State.
Failure to abide by the requirements contained in this Authorization to Construct may
subject the Permittee to an enforcement action by the Division in accordance with North
Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from
complying with any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.
One (1) set of approved plans and specifications is being forwarded to you. If you have
any questions or need additional information, please contact Seth Robertson, P.E. at telephone
number (919) 715-6206.
Sincerely,
r/ Coleen H. Sullins
AR:sr
cc: J. Thurman Horne, P.E. - Horizon Engineering & Consulting, Inc., 2510 Walker Rd.,
Mount Pleasant, NC 28124
Mecklenburg County Health Department
DWQ Mooresville Regional Office, Surface Water Protection
Technical Assistance and Certification Unit
Point Source Branch, NPDES Program
Daniel Blaisdell, P.E.
Anita E. Reed, P.E.
ATC File
Aqua North Carolina, Inc.
A To C No. 073539A02
Issued May 7, 2009
Engineer's Certification
I, , as a duly registered Professional Engineer in
the State of North Carolina, having been authorized to observe (periodically/weekly/full time)
the construction of the modifications and improvements to the Willowbrook Subdivision
W WTP, located off NC Highway 73 in Mecklenburg County for Aqua North Carolina, Inc.,
hereby state that, to the best of my abilities, due care and diligence was used in the observation
of the following construction:
Installation of a 9,900 gallon steel flow equalization tank with two (2) 144 CFM
blowers and diffuser assembly, duplex 83.3 GPM submersible pumps, flow
divider box, including all piping, electrical controls, and other appurtenances
necessary to provide a complete system,
I certify that the construction of the above referenced project was observed to be built within
substantial compliance and intent of the approved plans and specifications.
Signature
Date
Registration No.
Send to: Construction Grants & Loans
DENR/DWQ
1633 Mail Service Center1
Raleigh, NC 27699-1633