820681_Permit Renewal Application 2019_20190410

State of worth Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Co; crage
Facility Currently covered by an I \htritts Sate Non-Di,,charLc Ocnrr,1k Permit
On September 30, 2019, the North Carolina State Thin-Dt,,h,trge General Permits for Anini,tl Waste Management Systems will
expire. As required by these permits, facilities that have t en issued Certificates of Co;. rage to operate under these State
Non -Discharge General Permits must apply for renewal at Ie:,,i 180 d.ts prior to their exph,nion date. Therefore, all applications
must be received by the Division of Water Resources by no Lilt t than April 3, 2019.
Please do not leave any question unanswered. Please verJ& all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1.
Farm Number: 82-0681_
Certificate Of Coverage Number: AWS820681
2.
Facility Name: \Voek, I ,trm 111C. 1 inidhir>C
3.
Landownees Name (>amr ,ts on the F\ mte \1;ma ntent Plan):
Weeks Farms Inc
4.
Landownees MailingAddross: P(n Roy
City: Dunn State:
NC Zip: 28335
Telephone Number: 910-892-3930 Ext. E-mail:
5.
Facility's 2915 Green Path
I
Physical Address: Rd
�1
City: Dunn State:
NC Zip: 28334
6.
County where Facility is located: Sampson
7.
Farm Manager's Name (if different from Landowner):
St' 5 50M%�
8•
Farm Manager's telephone number (include area code):
2+-E*t-- I O — 8qa - % q'�
f
9.
Integrator's Name (if there is not an Integrator, write "None"):
10.
Operator Name (OIC): M. , k Sej5oM.) Phone No.: 910-892-3930 OIC #: •-t 97-7—
11.
Lessee's Name (if there is not a Lessee, write "None"): /l on Z
to �'�� CCI
12.
Indicate animal operation type and number:
Current Permit: Operations Type
Allowable Count
Swine - Feeder to Finish
3,840
Operation Types:
Swine Cattle
Dn Poultry Other"rvpes
Wean to Finish Dairy Calf
Non L:n_ in (liicl.cn, Horses - Horses
Wean to Feeder Dairy Heifer
Layln,, t hickcn, Horses - Other
Farrow to Finish Milk Cow
Pullcts Sheep - Sheep
Feeder to Finish Dry Cow
Tprkcys Sheep - Other
Farrow to Wean Beef Stocker Calf
Turkcv Pullet
Farrow to Feeder Beef Feeder
Boar!Stud Beef Broad Cow
Wet Poultry
Gilts Other
Non Laying Pullet
Other
Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
I
19.00
I
239,580.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.1OC(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), signed by the owner and a certified technical specialist, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215AA and 143-215.613, any person who knowingly makes any false statement,
repretientation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
u ,imilar ot3�n,e.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name: l i AA Se �)V ek S A Title: (/ /"
Name: Title:
Signature: Date:
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: (919) 707-9I00
E-mail. [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

I
ROY COOPER
Gnernor
MICHAEL S. REGAN
5-rewr
LINDA CULPEPPER
bdo" Oftwfor
Weeks Farms, Inc.
Weeks Farms, Inc. Finishing
PO Box 787
Dunn, NC 28335
Dear Weeks Farms, Inc.:
i V
NORTH CAROLINA
EnWronmental Quality
December 12, 2018
Subject: Certificate of Coverage No. AWS820681
Weeks Farms, Inc. Finishing
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your December 4, 2018, Notification of Change of Ownership, we are hereby
forwarding to you this Certificate of Coverage (COC) issued to Weeks Farms, Inc., authorizing the
operation of the subject animal waste management system in accordance with General Permit AWG100000.
This approval shall consist of the continued operation of the existing animal waste management system
including, but not limited to, the management and land application of animal waste as specified in the
facility's Certified Animal Waste Management Plan (CAWMP) for Weeks Farms, Inc. Finishing, located
in Sampson County, with a swine animal capacity of no greater than the following annual averages:
Wean to Finish: Feeder to Finish: 3840 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019 and shall hereby void
Certificate of Coverage Number AWS820681 dated October 1, 2014. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as specified
in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting and
maintaining the required monitoring data and operational information must be established for this facility.
Any increase in waste production greater than the certified design capacity or increase in number of animals
authorized by this COC (as provided above) will require a modification to the CAWMP and this COC and
must be completed prior to actual increase in either wastewater flow or number of animals.
Nwr
North Carolina Department of Environmental Quality I Division of Water Resources I AFOGW Section
512 North Salisbury Street 11636 Mail Service Center f Raleigh, North Carolina 27699-1636
919.707.9129

Please read this COC and the enclosed State General Permit carefully. Please pay careful attention to the
record keeping and monitoring conditions in this permit. Record kee
.Ring forms are unchanged with this
General Permit. Please continue to use the same record keepin forms.
orms.
If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per NRCS standards a 100-foot separation shall be maintained between water supply wells and any lagoon,
storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition 11.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You may
find detailed watch/warning information for your county by calling the Wilmington, NC
National Weather Service office at [phone], or by visiting their website at: www.weather.gov/ilm/­
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office staff
may be reached at [phone]. If you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
for Linda Culpepper
Director, Division of Water Resources
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Water Quality Regional Operations Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
AFOGWS Central Files (Permit No. AWS820681
North Carolina Department of Environmental Quality I Division of Water Resources I AFOGW Section
512 North Salisbury Street 11636 Mail Service Center I Raleigh, North Carolina 27699-1636
919.707.9129

eb 05 2018 05:41 PM HP Fax page 2
WASTE UTILIZATION PLAN
Saturday, February 06, 2010 iY A i-"� .2 - 5 _/0-' _
Producer: Weeks Forms, Inc.
Farm Name. Weeks Farms Inc. Finishing 82-681
P 0 Box 787
Dunn,NC 23335
Telephone # : [phone]
Type of Operation : Feeder to Finish Swine
Number of Animals: 3840 hogs design capacity
Application Method: irrigation
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the fields where
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
contents of the waste. Do not apply more nitrogen than the crop can utilize, Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and avaialable water holding capacities. Normally waste shall not be applied to
land eroding at greater than 5 tons per acre per year. With special pre -cautions, waste may
be applied to land eroding at up to 10 tons per acre per year. Do not apply waste on
saturated soils, when it is raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To
maximize the value of the nutrients for crop production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied to bare ground not more
than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems. This plan is based on waste application through irrigation for this is
the manner in which you have chosen to apply your waste. If you choose to inject the waste
in the future, you need to revise this plan. Nutrient levels for injecting waste and irrigating
waste are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis report
from your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananlysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Pagel of 11

1418 05'41 PM HP Fax page 3
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
3840 hogs X 1.9 tons waste/hogs/year = 7296 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3840 hogs X 2.3 Ibs PAN/hogs/year = 8832 PAN/year
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type and suface application.
TABLE 1 : ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE &CLASS-
CROP
YIELD LBS AW COMM ACRES
LBS AW APPLIC.
DETERMINING PHASE
CODE
NIACRE NIACRE
USED TIME
527
1-1
WAGRAM 0-6%
C
88;
90.2
0
4
360.8: FEB 15-JUN
' 527
!• 1-1
WAGRAM 0-6%
W
39!
91.26
0
4
365.04 SEP-APR
527
1-1
_
WAGRRAM 0-6°.fr
SB
23
90.62.
0
4;
362.48 APR-SEP 15
527
;• 1-1
..._ - -...
_ WAGRAM 0-6°rb
WA
1
30•
0•
41
120: SEP-ARP
504
I' 1-1
-� ......1-1
.NORFOLK 2-6%
C
138
131.1
0'
S.2�
681.72 FEB 15-JUN
_ ...
NORFOLK 2-6%
_.
W
60.
125.4
0:
5.2:
652.08` SEP-APR
-_
504
_....
• 1-1
..._
INORFOLK 2-6%
SB
35
. ...
137.2
_
0
r
5.2:
.
713.44 APR-SEP 15
504
1-1
-NORFOLK 2-6%
WA
1
30•
0:
5.21
156. SEP-ARP
L__ 527
1-2
WAGRAM 0-6%
BP
4.1
205
0
5
!.
1025 MAR-SEP
527
...1_._. .-._.._.
I- 1-2
,WAGRAM 0-6%
SG
1
60
0
5i
300: SEP-MAY
504
'• 1-2
iNORFOLK 2-6%
C
138
131.1
0
5.91
773.49 FEB 15 JUN
504
1-2
INORFOLK 2-6%
_
W
60
125
0
5.9i
739.86 SEP-APR
504
�• 1-2
�.4
tNORFOLK2-6%
SB
35
137.2•.
0;
5.9
809.481APR-SEP 15
504
I--
1-2
-
'NOR
- '
WA
WA
1
30;
�
0
__...
5.9
177; SEP-ARP
527
1-3
IWAGRAM 0-6%
BP
4.1;
205:
0;
3.3
--....
676.5 MAR-SEP
527
1-3
TWAGRAM O-6%
SG
1
_
-60
0
3.3`
198 SEP-MAY
527
2-1
WAGRAM 0-6%
BP
4.1
205;
0,
2.6
533 MAR-SEP
527
2-1
!WAGRAM Ofi%
SG
1
60
0':
2.6
156; SEP-MAY
527
3-1
-WAGRAM 0-6%
BP
4.1
205
0:
2.9
594.5• MAR-SEP
527
- 3-1
�WAGRAM D 6%
SG
1
60
0
2.9!
174 SEP-MAY
527
_t_ 3-2
!WAGRAM 0-6%
BP
4.1
205
0
4.41
902 MAR-SEP
527
_.... ..._.._
3-2
WAGRAM 0-6%
_._...
SG
1.
60i
0._...
4.41
264- SEP-MAY
527
3-3
IWAGRAM 0-6%
C
88i
90.2
0:
5.3
476.061 FEB 15 JUN
527
3-3
!WAGRAM 0-8%
W
39
91.26
0
5.31
483.678 SEP-APR
527
3-3
WAGRAM 0-6%
56
23
90-16
0•
5.3.
477.848:APR-SEP 15
527
I • 3-3
,WAG 0-6% °
-
WA
1
30
•
0
5.3,
159' SEP-ARP
-....527
-
3-4
•WAGRAM 0-6%
'
C
88
90.2
0
2,5;
225.5 FEB 15-JUN
527
-34
:.WAGRAM 0-6%
- .
W
39
91.26,
0
2.5!
228.15 SEP APR
--
I 527
�• 3-4
WAGRAM 0-6%
SB
23;
90.16
0
2.51
225.4iAPR-SEP 15
_i527
3-0
GRAM 0-6%
WA
1,
30
0.
2.5
75: SEP-ARP
527
4-1
BIBB OCCAS
BP
2.7'
135!
0.
2.8
378 M_AR-SEP
527
r-527
_-�.
- 4-1
5-1
_
;BIBB OCCAS
_..
;FORESTON ALL
SG
--
BP
1;
- --
4,5i
225
---
L
Oj
2.8
2
- -
188� SEP-MAY
.
4501;.MAR AR-
SEP
527
-�= 5-1
1FORESTON ALL --
' SG
11
60!
0
2
1201 SEP-MAY
527
5-2
IFORESTON ALL
BP
4.5
225
0
4;
900• MAR-SEP
527
- 5-2
IFORESTON ALL
SG
1
60
0
4i
240 SEP-MAY
527
7-1
NORFOLK 2-6%
C
138
131.1:
0;
2.57:
336.927; FEB 15-JUN
527
7-1
:NORFOLK 2-6%
W
60.
125.4
0
2.57'
322.278: SEP-APR
527
:• 7-1
'NORFOLK 2-6%
SB
35
137.2
0
2.57 352.604 APR-SEP 15
527
7-1
NORFOLK 2-6%
WA
1
30 '
0' -2.571
-"
- 77.1 SEP-ARP
527 7-2
AhokFOLK 2-6%
-
C
' -
138:
131.1
0
7.41, 971.451 FEB 15-JUN
Page 2 of 11

05:41PM HP Fax
page 4
527 .*
7-2
;NORFOLK 2-6%
- W
60
125.4`
0
-- 7.41
929.214, SEP-APR
!
527
7-2 :NORFOLK 2-6%
SB
35
137.2,
0
7.41
1016.65 APR-SEP .6
527
'
7-2 NORFOLK2-6%
WA_
1
30'
0
7.41�
222.3, SEP-ARP
527
7-3
NORFOLK 2-6%
C
138,
131.1
0•
5.1
868.61 FEB 15-JUN
.--
-,
527
,-....
___ . ___ ._
7-3 NORFOLK 2-6%
7-3 NORFOLK 2-8%
_`
W
SB
- i-
601
35
125.4
137 22
0� 5.1
0' 5.1
639.54� SEP-APR
699.72!APR SEP 15
527
•
T-3
NORF6LK2-6%
WA •
1:
_
30i
D
5.1s
163 SEP-ARP
'
527
6-1 !NORFOLK 2-6%
SP
4.6;
230'
0!
6.9
1587 + MAR-SEP
527
8 1 �NORFOLK 2-6%
SG
1.
80;
0
6.9
,
414! SEP MAY
527
=
a2
NORFOLK 2-6%
_ C
138`
131.1 •
0
71
. .._..
917.7 FEB 15 J N
527
_
&2
;NORFOLK 2-6%
w
60+
125.4
0
7'
877.8 SEP-APR
527
•.•
8-2
'NORFOLK 2-6%
SB
35-
137.2
0_
7
960.4 APR-SEP 15
527
8-2
2-6%
WA
1
30•
0+
7
210: SEP-AR
_
!
527
•
83
_iNORFOLK
NORFOLK 2-60A
C
138
131.1
0
6.4
839.04 FEB 15-JUN
527
•
8-3
NORFOLK 2-6%
W
60
125.4
0
6.41
802.56 SEP-APR
527
!�
8 3
PNORFOLK 2-6%
SS
35
137.2
0
6.41
878.08'APR-SEP 15
1
527
_
1•
8-3
iNORF6LK 2-6%
WA
1,
30
192 SEP-ARP
_.. - ._ ..
527
8-4
�NORFOLK 2-6%
c
138
131.1
0:
5.4
707.94 FEQ 15-JUN
..
•
527
8 4
NORFOLK 2-6%
_
W
60
125.4
0
5.41
677.16 SEP-APR
527
:'
8-4
NORFO_LK 2-6%
Be
35
137.2
0•
5.4
740.88 APR-SEP 15
527
!■
8-4
INORFOLK 2-6% ---
WA -
1_
.
0=
5.4�
idSEP-ARP
•_
527
- �•
9-1
INORFOLK 2-6%
C
138:
131.1'
0:
2.01.
263.511 FEB 15-JUN
527
Y..
_ .
9-1
'NORFOLK 2-6%
W
60
125.4
0
2,01!
252.054: SEP-APR
527 !+
9-1
;NORFOLK 2.6%
SB
35
137.2:
0-
2.01i
275.772:APR-SEP 15
527
9-1 NORFOLK 2-6%
WA
0:
2.01!
60.3: SEP-ARP
TOTALS:
20815.3
-Indicates that this field is being overseeded (i.e. !nterplanted) or winter annuals follow
summer annuals-
" Indicates a Crop Rotation
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirments. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastem counties of NC to have a nutrient management plan that addresses all
nutrients. This plan only addresses Nitrogen.
Page 3 of 11

ROY COOPER
covemor
MICHAEL S. REGAN
Secretary
LINDA CULPEPPER
Director
T
NORTH CAROLN a
Environmentat Quality
February 27, 2019
eeks Farms Inc
�1 eehti Farm Inc. Finishing
Pt) Flo% -87
Dunn. \(' 8335
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which e\pire on Septcm)cr 30, 2019. Copics of the new animal waste operation State Non -Discharge General Permits are available
at hilt, �1c(pic.LoN ah„ut diN k ons' ,NMCr-W',OUFLC =%, ater_gu.ility-re ioQ nal-omrations/afo or by writing or calling:
NCDEQ-D%N'R
\nimal I-eeding Op.�rauous Program
1616 Marl Service Center
Raleigh. North Carolina 27699-1636
I clephone number: (1)19) 70 7 -1)100
In order it, a,,€Pre \ow eontinueLi CONCIaee under_ lice Stale _Nun Di,dharTe ('enu:!1_Lcrnkil;,you Inu;l submil_ an application for
Permit 10 the Dni,irn. Inr_I„rd you �611_tind a "lt_,:iucst 1011' C'crrifit_ati__0i lOr CraLc Facility C'urrentiv (_oNercd_bht an
I sjnimtii,nr_,'\011 DI,,_jYarCC C,cncral Permit." The application form Inu,t he cr,ut rlctrrl. _si_ed and returned b� Aprii�019.
Ple.t,r n„i� that you must include one (1) copy of the Certified Animal Waste_ Slanaaement Plan (CAWMP) with the
Completed and signed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application lornt.
Failure to request renC%�;d ,,i Nr,ur C0%1'laL=e under a general permit within the time period specified may result in a civil penalty.
Operation of )our Li,iliu_ uthuut CO%LTr1,C under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessntertts of en i1 Pcnailic, 01 up I,, Sa`,000 put da).
If Vou havo an\ questions about the Statc Aon-Dischar-,c General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Enclosures
cc (w/o enclosures): I_€� cl:e• i I IC Regional Office, W.3ter Quality Regional Operations Section
Sam „un COMM Soil and Water Conser%ation District
AI-OG Section Ccntial I iles - A%1 S82U651

18 05:41 PM HP Fax
page 5
TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land. See required specifications 2,)
There are no Acres Leased
-- Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
`' Acreage figures may exceed total acreage in field due to overseeding.
**Lbs AW N (animal waste nitrogen) equals total required nitrogen less any commercial
nitrogen (COMM N) supplied,
The following legend explains the crop codes used in TABLES 1 and 2 above:
CROP CODE CROP UNITS
LBS N/UNIT
C 1 CORN BUSHELS
1•25
- -�-- - -- TONS
BP HYBRID BERMUDAGRASS-PASTURE
50
1
Sn SMALL GRAIN OVERSEEDED AC
50
I5B iSOYBEANS BUSHELS
4
W ! WHEAT BUSHELS
2.4
1 AC
4WA ; WINTER ANNUALS
100
Page 4 of 11

jg 05:41PM HP Fax page 6
vz: ;
TOTALS FROM TABLES 1 AND 2
ACRES LBS AW
N USED
TABLE 1-_--_ - _92 691 20,815
TOTALS: 92-69J 20,815
AMOUN7 OF N PRODUCED: 8,832
'"BALANCE -11,983
*** This number must be less than or equal to 0 in order to fully utilize the animal waste N
produced.
Acres show in each of the preceeding tables are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter
areas not receiving full application rates due to equipment limitations. Actual total acres in
the fields listed may, and most likely will be, more than the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of
sludge at agronomic rates. The sludge will be nurturient rich and will require precautionary
measures to prevent over application of nutrients or other elements- Your production facility
will produce approximately 1420.8 pounds of plant available nitrogen (PAN) per year In the
sludge that will need to be removed on a periodic basis. This figure is PAN when
broadcasting the sludge. Please be aware that additional acres of land, as well special
equipment, may be needed when you remove this sludge.
See the attached map showing the fields to be used for the utilization of waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of
irrigation such that runoff or ponding occurs. This rate is limited by initial soil moisture
content, soil structure, soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of the
crop.
Your facility is designed for 1130 days of temporary storage and the temporary storage must
be removed on the average of once every 5.92 months. In no instance should the volume of
waste being stored in your structure be within 1.56 feet of the top of the dike.
If surface irrigation is the method of land application for this plan, it is the responsiblity of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application rates and amounts,
TRACT
FIELD
SOIL TYPE
504
'1-I,'I-2
!NORFOLK 2-6%
504
•1-1,11-2
jNORFOLK2-6%
504
�l-I,-I-2
:NORFOLK2-6%
504
iNORFOLK 2-6%
527
•8.3,'84,
NORFOLK 2-6%
iSS27 -
-- — -
4,11
-4-1
BIBB OCCAS
BIBB OCCAS
'527
.527
5•1.5-2
FORESTON ALL
I527
a -I
NORFOLK 2-69/o
1527
WAGRAM 0-6%
527
,'9-3,'84,'INORFOLK
2-6%
.527
-B-I
'NORFOLK 2-6%
527
`7-3,' i-3, •$-2,'8-J, •B-4,
INORFOLK 2.6%
APPLICATION APPLICATION
CROP RATE (Inthr) AMT (inches)
SS
0-50
'1
W
0.5D
'1
WA
0.5D
'1
c
0,50
C
0.50
`1
BP
0.00
'1
SG
0,00
'1
8P
0.50
"1
I
BP
0.50
`1
wA
0.60
'1
SR
0-50
'1
SG
0.50
'1
W
0.50
' 1
Page 6 of 11

,lg 05:41PM HP Fax
page 7
,527
-7-2, -7.3, -8-2. -5.3. -8-4. NORFOLK 2-6%
WA
0.50
'1
527 -
1-2.1-3,2-1,3-1,3.2 ,WAGRAM0-6%
BP
0.60
527
'1.1,'3-3,'3.4
IWAGRAM 0-6%
c `
0.60
`1
527
41.1,-3-3,'3-4
_
WAGRAM 0-6%
SB f
0.60
"1 -
527 —
—
_1 .^, 1-3,-2-1,-3-1,-3-2
WAGRAMO-6°r6
-
5G- f._
0.60 _
'1
527
•1.1,'3-3, •3-4
--_-
WAGRAM 0-6%
W I
0.60
1527
*
-5-1, -5-2 FORESTON ALL
t II
5G
d f the soil assuming
0.50
the
amount of
This is the maximum application amoun a owe or
nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Page 6 of 11

1PM HP Fax page 8
NARRATIVE OF OPERATION
Field information is based on irrigation designs completed by Dr. Ron Sneed on 12-30-96
and Mr. Frank Evans on 8-17-01.
Page 7 of 11

4Hp Fax page 9
PLANS & SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division of Water Quality for every
day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land to properly dispose of waste. If the producer
does not own adequate land to properly dispose of waste, he shall provide NRCS with a copy
of a written agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, climate conditions, and
level of management, unless there are regulations that restrict the rate of application for
other nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS) or
an Alternative Conservation System (ACS). If an ACS is used the soil loss shall be no
greater than 10 tons per acre per year and appropriate filter strips will be used where runoff
leaves the field. These filter strips will be in addition to "Buffers" required by DEM. (See
FOTG Stantard 393 - Filter Strips and Standard 390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6, When animal waste is to be applied an acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland, the
waste may be broadcast provided the application does not occur during a season prone to
flooding. (See "Weather and Climate in North Carolina" in the NRCS Technical Reference -
Environment file for guidance.)
*7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control conditions
conducive to odor or flies and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of a crop on bare soil.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
the outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from anv oerennial stream or river (other that an irrigation ditch or canal_ Animal waste
Page 8 of 11

FPr 71OP Fax page 10
other than swine waste from facilities sited on or after October 1, 1995), shall not be applied
closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells
13. Animal Waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landownwer.
14. Waste shall be applied in a manner not to reach other property and public right - of ways
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted croplands
provided they have been approved as a land application site by a "technical specialist".
Animal waste should not be applied on grassed waterways that discharge directly into water
courses, except when applied at agronomic rates and the application causes no runoff or
drift from the site.
*16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
*17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon berms
and structures should be inspected regularly for evidence of erosion, leakage or discharge.
*18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
*19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for
direct human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied as a preemergence with no other applications of
animal waste during the crop season.
*21_ Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume fpr waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate -
determining element. Zinc and copper levels in the soils shall be monitored and alternative
crop sites shall be used when these metals approach excessive levels. pH shall be adjusted
for optimum crop production amid maintained. Soil and waste analysis records shall be kept
for five (5) years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina Department of
Agriculture regulations.
* Liquid Systems
Page 9 of 11

page 12
NpME OF FARM: Weeks Farms Inc. Finishing 82-681
OWNER ! MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications and the operation and
maintenance precedures estalished in the approved animal waste utilization plan for the farm
mrow named above. I (we) know that any expansion to the existing design capacity of the waste
treatment and/or storage system or construction of new facilities will require a new utilization
plan and a new certification to be submitted to DEM before the new animals are stocked.
I (we) understand that I must own or have acces to equipment, primarily irrigation equipment,
to land apply the animal waste described in this waste utilization plan. This equipment must
be available at the appropriate pumping time such that no discharge occurs from the lagoon
in a 25-year 1-day storm event. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY OWNER: Weeks Farms, Inc.
SIGNATURE:
NAME OF M�
SIGNATURE:
DATE: 9--- 5- r �-`
please print
DATE: Z _ S" I F
NAME OF TECHNICAL SPECIALIST: Curtis Barwick
AFFILIATION: Barwick Ag Services
ADDRESS (AGENCY): 103 Country Club Circle
Clinton, NC 28328
10 85-100
l�' -
SIGNATURE DATE:_.
Page 11 of 11

a t•- ' � .]w Zr .Try r �2 � �RL, ,•�.is .1,.
.� yam. c] Y
„'Y ` e`.•%rNO OAN Sol
�..7F
i�� ��„ r st -,. .a.''-�+� $tom •� '^t ; ` � � �5�
41
a.7 �;. ,��o-"F.<^mot `S.+e'. �3'•.� �4',._��*'`� �. _r` � t{al ��i -` 'p, a,l �
Ro t , �•q•� �yi � �b'?�c Y r,
Orr; 101;,�a�:
a*
7,y
10
75
10
' fit+ `•' .,ti ,a.
1 il;.'_ -
} -may �`. •, �.�o ° Y ' -�1 � �°�.'`! p„� v "`" vwc• �. _ i �1: "� .�- �
CZ
p� s rr
v"Y t e

g_0
quo
EMERGENCY ACTION PLAN �e
3317
PHONE NUMBERS cl I a L133 3300
EMERGENCY vIA I DGENIENT SYSTEM , l - ��D • 636
S`VCD ���o- �,�-'-►5��
MRCS Cilu
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation. this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e, Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c- Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e- Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarring pumps.
D: Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house. tlush systems, or solid separators.
18. 1996

e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of la`*oon. Often this is seepage as opposed to
flowing leaks- possible action:
a. Dig a small sumo or ditch away from the embankment to catch all seepage.
put in a submersible pump. and pump back to lagoon.
b. If holes are caused by burrowing animals. trap or remove arnimais and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Anv damage noted, such as employee injury, fish hills. or property damage?
d. Did the spill leave the property'?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
a. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal. business hours, call your DWQ (Division of Water Quality)
re,ziorL office; Phone After hours, emergency number. 919-733-3942.
Your phone call should include: your name, facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility, the location or
direction of movement of the spill, weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EIS Phone number -
c. Instruct EVtS to contact local Health Department.
d. Contact CES, phone numbers-' . 0`5 'local SWCD office phone number -'`)= ' J
an!i local 4_ CS office for advice/technical assistance phone number `�`
4: If none of the above works call 911 or the Sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
-i: Contact the contractor of your choice to begin repair of problem to minimize off -site
damage.
a. Contractors Name:�-�-
b. Contractors Address: _
c. Contractors Phone: 7R 2- "7 d '4 2--

6: Contact the technical specialist who certified the lagoon (ARCS. Consulting
EnL7ineer. etc.)
a. Name: P A rah s
b. Phone: Io- 223 `7Zr�Ir7C �l- S�
is Implement procedures as advised by D`VQ and technical assistance agencies to
rectif,,! the damage. repair the system. and reassess the caste management plan to
keep problems with release of wastes from happening again.
i S. 1906

0
Swine Farm Waste Management Odor Control Checklist
R.. Source Cause BMPs to Minimize Odor Site specific Praetims
Farmstead • Swine produminn Vcgwtive or wooded buffets;
a/Recommcodod best maaagerncat practices;
fl'*"Good judgment and common sense
Animal body surfaces Dirty manure-covcrcd animals Dry floors
Floor surfaces Wet manur-coverod floors 0,"Slotte d floors;
,,-
CYWatcrers located over sinned floors;
V
Breeders at higb end of solid floors;
`
D Scrape manurt buildup froze► fiooss;
Cdr Underfloor verStmiao For dryins
Manure coliactioa pier
Urine;
Fwqu M n a>>un by ilnk pt wchagm } r
Pwaj In�obial pn x�sitiou
Serve; + I
t
yyor
m'�U4derfkner
treatilaliat t
� l
Vembim aabaca faai
a VoLmle Criss;
Fenn mai vienanoe;
Dun
Me""ETrcimit air movement
lndoor surfaces
• Dust
Wa_shdvtrn between gJ'oops of annuals;
D Feed additives;
D Feeder covers;
f Feed delivery downspout extendas to feeda
covers
-J Flush tanLs
Agitation of recycled lagoon
D Flush tank covers;
el'
liquid white tanks rue filling
13 Extend fill lines to near bottom of tanks with
anti -siphon vents
F[Lnh alleys
• Agn3tion during wasiewaacr
D Underilnor flush with underfloor ventilation
conveyance
Pit rccJiargc POirnts
• Agitation of recycled lagoon
17 F-xsend recharge lines in near bouorn of pill
liquid while pitsare filling
with anti -siphon vents
Lih saaaions
• Agitation daring sump tank-
f7l Sump tank: covers
filling and drdwdown
Outside drain collection
■ Agitation during wastewater
D Box covers
or junction boxes
conveyance
AMOC - November } 1, 1995, Page,

sours
Caase
laNil's to Miaimiu Odor Site Specific Prnclices
fsd of drainpipes at
0 Agitation during wastewater
Extend discharge point of pipes underneath
'
lagoon
eonvcyanoe
lagoon liquid level
,
Lagoon
+ Volatile
O lagoon
o
surfaces
gns em"Ons,
Proper kquid capacity;
c
• Biological mixing;
Q Correctg PIn non starter procedures;
`?
' Agitation
O Mirtiruwn surface area-to-volurne ratio;
ao
Minirnum agitation when ptunping;
C3 Mechanical aeration;
0 roven biological additives
co
lrrigawm sprinkler
• High pressutc agitatiou,
In igate on dry days with little or no wind,
aouJes
• Wind drill
O Miruirnum rcromrnendcd o m sure;
pffy gPR
L,
l3 Pu,np intakt near lagoon liquid surface;
a Pump from secood-stage lagoon
Smfvciaak or basic
0
Partial microbial docarrpaaitirw;
©
Borlora a midk:vel toadrag; I ,
SM060C
•
eft Whik filliac
o
Tame a4ers;
1
•
its I I
J4g�m ���- • I• j, �+
I
t]
, r •l �• �' 11 1'
s�tr>4tpe '�
,
0
Piuna biological additives or ixidants
Scttlog i—wt tt (sue
•
P=Ud taticubial d xOnVea mi;
0
Extend drainpipe otalets w4mucaub liquid
•
1AWWW61k fd6r,
level; i
' •
Agkotion alto coplying
d
Remove settled solids regularly
Manure, sorry or sludge
•
Agitation when sptiadiag;
0
Soil injecem of slnrryhhrdges;
spreader mdM
VOLAR; g"ertrissim
O
Wash residual rnanurc from sprpder after usc;
__j D Proven biological additives or oxidants
I,,
Uecovemd manure, • Voli,tik gas rruissi wa while lQ Soil injcc ion of Ourrylsludges
slurry or sludge on fitld drying ❑ W incorporation within 4g hr-s.;
mu fakes
a Spread in thin uniform layers for rapid drying;
0 Proven biological additives or oxidants
Dead arun"k • Carcass decan4 sWun Proper disposition of carcasses
Dead acmul dispoW • Cturass decurnposwon O Compkic covcriug of c,arcassas in burial pies;
pits Cl Proper latiatiwilconslruetion of diypoaat pits
howk en"" • lawmpku combustion O Secundary slack bumess
AMOC - November 11, 1996, Page 4

Source Gust Mrs to hliniulirc Odor$rand"ulb water Woulld • knpro wr dmtage; Site Specific Practices
Lcilities • Urrade and kmLLcapcsuch dial water L"jIX,
Miaubial r1CCUmiiUS+t1(yl of away Gum facilities
0 orgwic matter
Marture tracked ottto Poorly mair.rtaiunl access roads
U public roads kutu [arm tff Fantr access twirl mavttrnance
Q
•• access
Co
r` Add111Um1 II&011llaii0u :
c'3 SWYIc Manure hfindgculcr>t ; 02D0 Rultl[3MP Packet Available Fruul :
a Swine Production Farm Potrmial Odor Snluces andAealedies ; EQAE Fact 51ttel NCSU, County l xleusict Certler
Swine Produttitm Fac"ky Manors Mara aoatt: Pit Rest NCSU -BAE
JS i�lse - Vgtxic'ireauntni ; E[l<A;i: l78_gg NCSU - i3AE
0 Swine Production Facility Manioc Ma mgm= : Undcrfkxor Fltrsll - lagoon Treatment ; EBAE 129-88
�+ Lagaao Design and NCSU - BAE
lsrlsnagerue�t for Livestock Manwe Trattntrx itlrl Storage ; El3AE 103-L3 NCSU - IIAi
CRUbration of Maolrro sod Wastcv AW Applicalioo Egvipwcw EiA ; EE Faci Slicrt
Conbul"S Odm Emm Swisc IBnildiags ; PUI-33 NCSU _ SyowAC
Env�orltocntal A$wmm p�= ; NPPC MWW2f
Hai �9 Odor; s nepalit ftum the Swbm UdW IFS# Fbsv6 WIMi"b rime PQ*
Pr com - L '► r� +
coorerus � At.itall ll�e
Ms+ � O�xs strd Floes ; tlCOfU7, 1g1g5 Optt�wrx Prscraliogs Fle56 Cooperative &6Lt iorl
A-MOC - Novrmix-mr 11, 1996, Page 5

Insect Control Checklist for Animal Operations
�n
Source
CRUM
BMPs to Control insects Site Specific Practices
` Y
Liquid Systems
Flush (cutters •
Accumulation of solids
Hush system is designed and oparated
sufficiently to remove accumulated solids from
hers as designed,
a Remove bridging of accumulated solids at
discharge
T`
Lagoons and Pits •
Gusted Solids
O Maintain lagoons, settling basins and pits where
4 ;
pest breeding i, apparrut to minimise the
crusting of solids to a dep& of no more [ban 6 -
9 inches over more than 10°%ofswface.
u
Excessive Vegexative •
Dxsying relcmdon
Maintain vegetative coaW aloag banks of
aagoom and Wwr impoundmaus to prrnot
i accumulaitigq of dccaYing vtg4�Mivt Mau" I
akaorg watted's odgc ow ithp�o�dsteaa
. `t
l!
-
-
•
Feed SpilFags
D6i;r, u"raoe' &W maaait ieed sy (a6
bmkm nerd trou&s) to Mmi min the
&wu=Wiod of decaying waaraee.
DCit an up spillage on a rouliac basis (e g.' 7 - 16 ,
day inuml during suQ ncr, !S-3Dday viuval
during winter).
Feed storage •
Aecamubum of feed residues
Reduce moisture uxurnulation within and
-j
around immediate perimeter offered storage
`,—'
areas by insuring drainage away Dart site
and/or providing adequate containment (c g.,
covered bin for brewer's grain and similar bigh
/nWisture gram products).
Gr losptct for and remove or break up accumulated
solids in triter strips around feed storage as
needed
ALi1C - Normber 11. 1996, Page 1

2�7—
Source
Aoirxal Holding Arctzs •
Cause
ACCuulrlllBirOItS OFiI{U[I1I W.�S1Cs
13A1Ys to Control losccl5
&le S[Wdlie Pr9elk
Eiuninate low areas that trap nloislurr aIDJIg
and Cced wastagefcaces
and oil►cr locations wlicic waste
o
accumulates asxl disturbance by arriawk is
�
m ulinial.
.
tD
❑
N'1 intain Ceske rows and jilicr str4bs Lj-o Ultl
anmwt Molding areas to INiniatizc
accucuulatious ofwastes (i.c., inspccl fur and
remove or break up accumulatcd solids as
•- •= u; LI: i ;.•� t,: -�_• at r .�,
!
needed).
Vry t.taiwre liwidling
Accumulations of animal ►rccsks
D
Reu►ava spillage on a routine basis (c,g., 7 " f G
- - : •., . .r�= _
Tf *
�
5rslaus
day interval during surnnier; 15-30 day ialccva[
,f t ` �- . _
%r . '•. _.
cv
duruib winter) where manure is loaded Cur land
+ •
application or disposal.
~•''l'-'
U
O
Provide for adequate drainage around tumurc
:
t':=::,',
stockpiles
D
iaspecc for awl mawve or break up accuinulatcd
-
-=
wastes iu filter strips arousal sfoapi�* and
;-' `tm
mmum 6ardl4% me s as oeWed
Y
la,
For ware ia[n:aualiofl. Goer d
lbe coopermun Extcnsim Sciv'frae, beparcoent •f Eutmwlogy, Box 7613, l odh CaroUi a Swc
Universiv.
kaki k NC, 27695-7613.
}- '
AMIC - November 11. 1996, PW 2

•r, :�.� poas;`f GQ Cc t 28 ' 97 8 : 46 No .002 P . 08
MortaUty Mafteement Methods
(check which method(s) are being implemented)
U Burial three feet beneath the surfai*e of the ground within 24 hours after
knowledge of the death. The butza3-must be at feast 300 feet from any flowing
stream or public body of water.
U Rendering at a rendering plant liccmd tinder G.S. 106.3 68.7
Complete incineration -
O In the rase of dead poultry Only, p cry , piacins. in a disposal pit of a size and design
approved by the Department of Ariculun
© Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written apptvval of the State Veterinarian must be
attached)
.. .
r
bccember I8. 1996
I

Version-,oye'ne,
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
a Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
a A composting system approved and permitted by the NC Department of Agriculture & Con-
[71 Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
a Any method which, in the professional opinionrof the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
7 Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations, This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
,
Signature of Farm Owner/Manager
Signature of Technical Specialist
Date
.,3"z3 :�
Date

UZ/24/00 11 :20 91 U 93T n-->8914�462 ECM Pg . 02/05
--wv �I.:,.:.i.4J•�. .�D Li:Li.. .. v.. .r., TYPICA.., ��P,05S _q ECrCC�
l
S(tttled top of darn: �3�•'O --
oe
�Y+" oe-
Top Width
24
f 3 v COi'i--tr'UCt trip Of dlL1111
Fill Yardage: 4�
Naturnl ground -el ev--_------ w--- - - - - - - - - —
CLA. 0i f seal
---}-� U*-pth dotLrini nc by
Di?C:, un gyrai P lfo-nt --y,I --� ; ,CS on <ii tL-
4EA4ER66A;C-7 sPicycdA y — E tV. ; 33 • G
�EMDv�' 4,44e- 7/Lt .41.*JFS jE-1VCauN7iFWED -- SEE- C6,VSr: Sp�f
Start land application Stoo 14nd application
elev. 31. elev. fL9, q
_'Temporary Vol.uuie-
r
Bon t
support
9Lo
botto,n elev. U
Trgdtment Volume
Top of l"dge
SiudgG•-4�CCumcdl�t,c�r�_._...._.,....__
Lagoon size: Length 4FO Width _IciDnt
BENCH NAM:. UES RIFT I �Dr4:
GENERAL INFORMATION
JOB CLASS: M._
HAZARD CLASS: "c9
ANIMAL TYPE 6 NU'FbER'
KIND OF OPERATION: tlryi� �r c
NOTE: If construction I:, nrit
started wl'thin ane yc*ar, this
piAn t5 not valid until re--
,wval�,tatiarl bf ftu00 plaid -fur
-La•funty hazard its aiacle-4.
.r
/�7
-fo S a i`1s
lope I �
C:u. Ycls. e:r. ~u,.t d 4A. 34-Z--
f-OR CiN IT 1.iL w,,cTE
<SINGLE STriGE)
E _ FARM
dNiPS�,!J _Ak4ri--) � COUNTY
- C . STATE
U. S. DEBAR INENT car AGRICULTURE
�I SOIL CQNSC RVAT i ON SERVICE
DESIGNED W; ejAejs
I3f-TE;

/24/00 11:21 9108932795
-->8914462
ECM Pg. 03/05
)et, ,ztor:WF.EK_q f-AfiM INC. Couni:.y: SAMPSON (HARNETT) U.Rte: Iv: 1cs!9C
_LArtce to nearest re 5i cer.ce (otF.er than owner.,.- -.800.0 Lee"-,
AVtF(s-OF 1_1VE
WEIGH i
0 SOWS
0arrow t:i
iiniFlh)
x
1417
Il;S.
0
( farrov$ tc_;
fearj,=_!-
522
1bs.
- 0
i.bs
. 840 1ter:t
tfirl:shirtg
on-1y)
::
135
1b
_ �II14 00
ibs
433
1 b .
--• 0
l bs
0 i-et`ttC.(
(Wean to ftvz✓dee
?
Y.
LQ
1l7_.
-. 0
1bs
gets(..r .I:t
❑t{-er _
0.
To -Lai Average Live Weict:t = '310400 P%
1,1171.11NUM REGUIRED I'RGF1TP'1EWT VOLUME OF LAGOON
VoIi;,me = 51B400 lbs. ALW x Treatment VAlurrL-(Cr}
Treatment Vo]Ltmle��l^((�CF)/Ib. Ai.W _ 2 �:F/:b_ AL.bl
YCA i_ili7H 1036600 cuDi a_ eet
STOR,A E FOR SLUDGE ACC Li MULAT I C N
�.'e! urtre = 268300.0 cubic f eet-
TGTAL DESIGNED VO_LINE
Inside top
ienyUin (fret) _. _----------------
480.0
inside toga
4vidJi {-Feet) ------------------------
5�ci7t, ti
Top ci dike elevation (FoRet)-------------------
Bottom of
lagc,on eievatiQn
123.3
F:-EE:bi7art3
ifee't!----------.........__.....__ -----
Si ce slopes
(inside lagoon) -----------------.--
t. 1
f ut nl des. -an %wol ,- mie i.tsa ng pri smni dal f 0t"!ttul a
3S/EIgFjI
SS/END2 SS/SIDE1 5S/SIDE2 LENGTH
Fwl -sui'H
?_ 5
2-5 2.5 1'. 5 470.0
.190.0
AREA JP T Jr'
i-7,r;). o 490.0
r'iR&i OF Di-,TTOM
LENSTH r WIDTH =
427. 447.E
AREA UF MIDSEC 1'IGN
LENSTH * WIDTH x- 4
1346.9 466.E
2Na1001 ( AREA OF r'L)F- i
191306 ( AREA UI '1C3 1 [ L•1"1 i
841406 (AREA OF MIDSEC?ION 4 4)
CU. FT. _ rAFFP T 1F +- (rijF,-�EA VIDSECTION) - APEA M'TT0!v3 -4 DEPTH/6
230300.0 8414@6 ; 1!1.'10IL. 1 . `i
Tofz,­ ties_gner; Volume Hvai. i Ebic = 1714'?"269 C:..t_ � r.

/24/00 11:21
9108932795
-->8914462
ECM pg. 04/05
TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Length * Width �
460.0 500.0 240000.0 square +eet
Duj i Cl2 vg 5 (root And lot water)
0.0 square feet Dee(-t : be t }cl s area.
TOTAL CAA 24E000-0 squesre feet
Design temporary storage period to be i2o days -
A.. V4.jI r.ti{le r_..f 4•;c1-_LE' pr ocaice6
Focea a: urine pa'oduct i nn in gal./day per- 135 11J. Fli--W
Volume 51840E . bo. ALW/ 135 lbs. ALW k 1.77 qek ld i 180 days
Voiumc 9 &944 gals. or -26-996.B cubic i•eet_
n. Vui umt- j + viash water
This is rho anu un E o+ r" resh water- used 4 or vzei ih i n,2 or
of frysn water "sed for a +fits# system. Flush sVstvms Zhat r vcirc0!'K--
th4 : agoon water are .acuo"nted fAr in SA.
Vol r..,ms= = 1456.0 gal l ansi clay 18C1r days stLv a• ;ei 7- 43 gal l rins
per CF-'
VoF Lr:r:e - 3- 3165 . G VA-t„e C f (l0t
C. Volume o- raxniall in excess Of evapure1,or
ilse pVr';0d of tame when rairfali eNceeds evapUratiC" Ly largest aMOUnt_
l eo days ex LeS5 rai n'f a.i l = 7.0 : nr hes
Volume = ?.0 1n * Cif+ / 12 inchea per 400t
'Jrii tin+c _ 1-;0000. 0 cubic Feet

11:22 9108932795-->8914462 ECM Pg. 05/05
Vol uase o' ;'`, 'year -- 24 how, Storm
v'c? Gme _ 6.8 inches / 12 inches per i oot * DA
Rio: kmsre _ 1 ': S:000. 0 cubic Feet
TOTAL Rr::,QU I RED TEMPORARY STORAGE:
5A. 1265g7 cubic feet
5F,- a,-,I66 cubic •feet
140000 cubic feet
Ci. 1.36000 cubic T eet
"IT1 rAL. 4E576a cubi c feet
i'araspur �.r y storage"_--
R�nY",Fea11 in a;�Ce=s Of evaporation=== __====='` [ 3r:cheS
25 year .- 24 hour r jai n# al I =_------- _ 6. E3
2.0 vo'L
Side
drasid,� i+r;1
Ia7t�:13e top wiC3tn.y:.W—=-------=—_ i*�f !1 'vet
SFr cs- like 1-4. 4' rt,et
Bottom as layuon
ry1-' S c� » `: -
�i='�lAc�l ce�Siga� Vol urrse==-= w===== 179'32'c,6 cr_ _ •F .
SeaScr:a I'1ig>:=uatertab3e e3evakzan {SHWT}^==: 126.0 ? rret
'Co `Ji^ik1 E'I L V.=ie1+veyr_vra� i ,c:is. ra :� Eet
be or = 'r 3 rnirr. req. tr•eatsre vt e3. ; '_`rs.t; Frae'I
F;Pt,!.:; r ec mj n; mum tree.trnent valume--===''=��-�:�:%
at ctOp purtr il'tr r37 evatarsr-,===_= -'=-- 1 i6tJt::i CU. f..
SLer t
M.,5�:- ere .at boL ufn o+ freeboard & 2-.j yr.. •�ir'1Eaz:
r-rc_2
b'Lil:rrL , uss 25 yr. - 24 hr. Fa;infai?-=.
s1e:3 'r �.s
VoI ume At st_,Ar � rSr_If±41:; ] ng el evert i eys's===== _ -- -_ 167 4'71 /
Eir!r,i-,ircd vU1ltmN tCs Foe pLimp ecs====------___---, :?t}r,,;7;s CL;. :.
Actu.al viola:sra jsi.rirter7 i r3 Lae?'.-2 C .;. ' i .
Vi .r-1. th. L«r1eSs r:F rrci I 1 irser• when required- 1.5 fe.0
::iESi.GNED :<Y a, -ram CI-I-1 .
APPROVED EY: ��.+�� EJa
JN7' .. /d --.L-C - ?.S
W AB. LJTILIZFsTIDI� PLAN
f

SHEET i OF
OPERATION AND MAINTENANCE FLAN - '4-f s"
7,�hisgoon is designed for waste treatment (permanent storage) and
days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be retched may vary
due to site conditions, weather, flushing operations, and the a.niount
of fresh water added to the system.
The designed temporary storage consists of 18D days storage for:
(1) waste from animals and (2) excess rainfall after evaporatisor.. Also
included is storage for the '25 year - Z4 'hour storm for the locat.on.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but a>:cess
rainfall will vary from year to year. The 25 year rai of a:1 will not
be a factor to consider in an annual pumping cycle, but thi_ storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s)_ If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is .recognized as art acceptable
method of disposal. Methods of applicationinclude soliL se'_,
center pivot, guns, and traveling gun irrigation. Care =_.houlc: be
talfer when applying waste to prevent damage to crops.
'he fallowing items are to be carried OLit:
1. It is strongly recommended that the treatment lagoon-, be pre -
charged to 1./7 its Napa=i ty tc� prevent excessive odors dur i r°g
atar�_-up. F're-charging reduces the conceritratior of the 2nitia--
µpaste enter + nc the l acoon thereby reducing odors. Solids should be
cc•var-md µ.i'_h efflLiei:t at all '_Imes. When precharging is comp! eta,
1 :s_h bUi i di ngs wi tie recycles: I -.goon liquid. Fresh water should not
be used for flushing a-Fter initial filling.
The attached waste utilization plan shall be followed. ThiEi
plan recommends sampling and testing of waste (see at-_achment)
before land application..,�i�%
Begin temporary sto a Pump -out of tic
reaches the elevation as marked ay
out when the fluid level rea-hes ele/atiar:
storage, less '2a ter- 24 hr stor, contai ns
2JyagS'
e l agaan i•3hen f i :.;J c 1 eve l
perm3r-:? �rhe;- . St Jr- DUf-.:p -
1�+l�F' J�eT�-.i5 tem}:os-ar!
_ubic peel or
P�

SHEET 2 DF
i
The recommended mam i mum amount to apply per- i rr L gat i on is
n� .1) inch and the --ecc(nmended ma:: i mum appl i ca-L i can rate is O.
Refer to the waste utilization plan for f ur-ther details.
inch per hour.
�. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a rigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
B. Keep a minimum of 25 feet of grass vegetated buf : er crouno
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be aPPlied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.