820639_Permit Renewal Application 2019_20190410

'State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 82-0639
2. Facility Name: C&B Farms 1-20
3. Landowner's Name (same as on the Waste Management Plan):
4. Landowner's Mailing Address: PO Box 6338
City: Ralei State:
Telephone Number: 919-881-0338 Ext. E-mail:
5. Facility's Physical Address: 1180 Sharecake Rd
City: Clinton State:
6. County where Facility is located: Sampson
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"):
10. Operator Name (OIC): Anthony W. Robinson
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit: Onerations Tvoe
Operation Types:
Swine
Wean to Finish
Wean to Feeder
Farrow to Finish
Feeder to Finish
Farrow to Wean
Farrow to Feeder
Boar/Stud
Gilts
Other
Swine - Feeder to Finish
Cattle
Dairy Calf
Dairy Heifer
Milk Cow
Dry Cow
Beef Stocker Calf
Beef Feeder
Beef Broad Cow
Other
Certificate Of Coverage Number:
NC
NC
Bode Associates
Prestage Farms Inc
Phone No.: 910-590-7498
Allowable Count
12,860
Dry Poultry
Non Laying Chickens
Laying Chickens
Pullets
Turkeys
Turkey Pullet
Wet Poultry
Non Laying Pullet
Layers
AWS820639
Zip: 27628-6338
Zip: 28328
OIC #: 989092
Other Types
Horses - Horses
Horses - Other
Sheep- Sheep
Sheep - Other

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
1-8
i 2
C!a
! ! to 9 7 8$
113,256.00
19
17-20
1995
C
S 8 H 669
78,408.00
19
9-16
/5
f✓�d
% y p b V8
130,680.00
7
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), signed by the owner and a certified technical specialist, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.613, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name:y "3 rl Vl, Title:
Signature: Date:4z V Z_
O
Name:
Signature:
Name:
Title:
Date:
Title:
Signature: ^ _ Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

ANIMAL WASTE UTILIZATION PLAN
Producer: CAROLINA PACKERS i3oDrSSuL1dTC S
Location: RT. 3 SHARECAKE ROAD
CLINTON NC 28328
Telephone: awamm 91D . S9'R • 577%
Type Operation: Existing Feeder to Finish Swine
Number of Animals: 12860.00 hogs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application'cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be `grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching.potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall not be applied to land eroding at less
than 5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DEM regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report,from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
12860 hogs x 1.9 tons waste/hogs/year = 24434 tons
AMOUNT OF PLANT AVAILABLE. NITROGEN (PAN) PRODUCED PER YEAR
12860 hogs x 2.3 lbs PAN/hogs/year = 29578 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
APR �,
:0�
WONQuality
Regional C,peraVons Sect n
Page: 2

ANIMAL WASTE UTILIZATION PLAN
TRACT
TABLE 1: ACRES OWNED BY PRODUCER
FIELD] SOIL TYPE & CLASS -
DETERMINING PHASE
4832 �1 IBoB
J
4832 12 BOB
4.832 3 WaB
END
CROP
YIELD
LBS
CODE
AW N'
PER AC
APPLY -
METH
BH
8.0
400
I
BH
8.0
400
I
�':���Ma k
I
I
COMM
N **
* LBS
PER
ACRES
AW.N
AC
USED
or
-------
RESID.
APPLIC
N
TIME
38.38
15352
MAR-OCT
23.3119324
''
MAR-OCT
23.14
6942
�`t
MAR-OCT
TOTAL 1, 31618
3 ( , �23
Indicates that this field is being overseeded (i.e. interplanted)
or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations may
require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This plan
only addresses nitrogen.
�e��s � ��S I�WN.p��f1C re�/tc�'' old walk j�l0.yt
C�
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACTIELD SOIL TYPE & CLASS- CROP JYIELD LBS COMM N **
DETERMINING PHASE CODE AW N PER JACRES
_-_-- PER AC AC
or
APPLY RESID.
,METH I N
END
* LBS
AW N
USED
APPLIC
TIME
TOTAL10
Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CRUP
BH j HYBRID BERMUDAGRASS-HAY
TABLE 1
F TABLE 2
TOTALS FROM TABLES 1 AND 2
I ACRES
84.83
1 0
I LBS AW N USED
0
UNITS IPER UNIT
TONS 150
Page: 4

ANIMAL WASTE UTILIZATION.PLAN
TOTAL 8 4 . 8 3 31618 du —
BALANCE - 2 0 4 0 .1_ 3
-------------------
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
N-A,rro-4 1 V e
a Cr S �vlCl u,& CA �'S -P I'-1
i ,� i K I -k-D q t t4-
At P
� II
l 5 4D a 1
SD r�
�o
Page: 5

RGY COOPER
6~mwr
MICHAEL S. REGAN
Secretary
LINDA CULPEPPER
Director
tYORT" CA ROL I NA.
Environmental Quality
February 27, 2019
Bode Associates
C&B Farms 1-20
PO Box 6338
Raleigh, NC 27628-6338
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
ApR �► � Z��g
10Sio�vl+n�"at10i15
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https://deg.nc.gov/about/divisions/water-resources/water-quality-regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Prograun
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure vour continued coverage under the State Nan -Discharge General Permits. you must submit an application for
permit coverage to the Division. Enclosed you will find a "Request for Certificate of Coverage Facilijy Currently Covered by an
Expiring State Non -Discharge General Permit." The application form must be completed, signed and 'returned by_ April 3, 2019.
Please note that you must include one ill conv of the Certified Animal Waste Manaeement Plan (CAWMP) with the
completed and signed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Enclosures
cc (w/o enclosures): Fa. etteville Regional Office, Water Quality Regional Operations Section
Sampson County Soil and Water Conservation District
AFOG Section Central Files - AWS820639
Prestage Farms Inc
Nerth.Sa'r,s eeart7:a^tfr=lSer rmCe ts,I t s�2N-:-aof ro.fz 278-aa-I
�S 512 N. �s "s�cn° art. � 1"c�fi his"I �erv.� Ge.^.L � Rs = fir. NorV Csra as �75��-1S38
9137 7fl^;O

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated,, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than the
acres shown in the tables.
See attached map showing the field-s to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 4758.2 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 23791
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 79.3033333333 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 190.328 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 259a depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the re-sponsibility of t-he producer and irrigation designer to ensure
�. that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 6

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
Tract Field
4832 1
4832 2
4832
3-5
Soil Type
BOB
BOB
WaB
Crop
BH
BH
BH
Application Rate
(in/hr)
0.75
0.75
ow
Applic. Amount
(inches)
*0.65
*0.65
*0.96
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and the
temporary storage must be removed on the average of once every 6.00
months. In no instance should the volume of the waste be stored in
your stracture be within the 25 year 24 hour storm storage or one foot
of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
Page: 7

WASTE UTILIZATION PLAN
REQUIRED SPECIFI,CATI:ONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 8

WASTE iTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 -,Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly inton water courses,
-and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when thes
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina requlations.
Page: 10

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:C&B FARMS
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Environmental Management (NCDEM) before
the new animals are stocked. I (we) also understand that there
must be no discharge of animal waste from this system to surface
wasters of the state from a storm event less severe than the 25-
year, 24-hour storm. The approved plan will be filed on -site at
the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDEM
upon request.
Name of Facility owner: CAROLIN CKERS %30At';' 4JSdCAAIY6
(Please print)
Signature: Date: .
Name of Manag (if different from owner):
Signature: Date:
Name of Person Preparing Plans (Please print)Wilson Spencer
Affiliation:NRCS
Address (Agency) :
Phone No.
84 County Complex Rd.
Clinton NC 28328
Signature: Uate: �L -`�-�_
W�Qau�l°rty
Page: 11

3/29/2019 Prestage Farms Swine Locations App
NC CGIA, USDA FSA
Xzl
o01
- 10 5pa A.y �rbz ns
3
o
600ft
https://pfi.maps.arcgis.com/apps/webappviewerlindex.html?id=bcd3l c72d7d04bceac9388b38ba316e6

SAMPSON COUNTY
EMERGENCY ACTION PLAN
DIVISION OF WATER RESOURCES (DWR)
910-433-3300
EMERGENCY MANAGEMENT SERVICES (EMS)
910-592-8996
SOIL & WATER CONSERVATION DISTRICT (SWCD)
910-592-7963
NATURAL RESOURCES CONSERVATION SERVICE (NRCS)
910-592-7963
COOPERATIVE EXTENSION SERVICE (CES)
910-592-7161
This plan will be implemented in the event that waste from your operation are leaking,
overflowing, or running off the site. You should NOT wait until wastes reach surface
waters or leave your property to consider that you have a problem. You should make
every effort to ensure that this does not happen. This plan should be posted in an
accessible location for all employees at the facility. The following are some action items
you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested response to problems are listed below:
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam, any permanent alteration of the
dam should be approved by a qualified technical specialist.
b. Pump wastes to field at an acceptable rate.
c. Stop all additional flow to the lagoon, hold wastes in the house if possible.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from wastes application field -action include:
a. Immediately stop wastes application.
b. Create a temporary diversion or berm to contain the waste.
c. Incorporate waste to reduce further runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinkler -action includes:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Close values to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage. from flush system, houses, solids separators -action includes:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Make sure no siphon effect has been created.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks -possible action:

a. Dig a small sump or ditch to catch all seepage, put in a submersible pump, and
pump back into lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes
and compact with a clay type soil.
c. Have a professional evaluate the condition of the sidewalls and the lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, call your DWR (Division of Water Resources)
regional office, at 910-433-3300, after hours, emergency number: 1-800-858-
0368. Your phone call should include: YOUR NAME, FACILITY
NUMBER, TELEPHONE NUMBER, THE DETAILS OF TE INCIDENT
FROM ITEM #2 ABOVE, THE EXACT LOCATION OF THE FACILITY,
AND THE LOCATION OR DIRECTION OF MOVEMENT OF THE
SPILL, WEATHER AND WIND CONDITIONS, THE CORRECTIVE
MEASURES THAT HAVE BEEN UNDER TAKEN, AND THE
SERIOUSNESS OF THE SITUATION.
b. If the spill leaves the property or enters surface waters, call local (EMS)
Emergency Management Services at 910-592-8996.
c. Instruct EMS to contact local Health Department.
d. Contact local Soil and Water Conservation District, Natural Resources
Conservation Service office at 910-592-7963 and Cooperative Extension
Service at 910-592-7161 for advice/technical assistance.
4. If none of the above works call 911 or the sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5. Contact.the contractor of your choice to begin repair of the problem to minimize off -
site damage.
a. Contractors Name: ARES7A�i6 J 0MS Zjc
b. Contractors Address:
c. Contractors Phone: /0 • S9a • 5171
Page 2

6. Contact the technical specialist who certified the lagoon.
a. Name: _Amyge4 Al. 9A+RtArT
b. Phone: 910, 5'9,R - 5 771
7. Implement procedures as advised by DWR and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
8. If you are a contract swine grower associated with a swine company integrator,
contact the company representative at 910-592-5771.
Page 3

I.I1sect Control Checklist for Animal Operations
'Source Cause -
131111's to Cp.n(rol lilsec(s - -
Liquid Fl
Accuundaljolt uJ'sulids S)stents Site Specific l'raelices ush i�ullcrs
O f-lnsh syS(eill .is desigiled and operalcd
sufficicnlly to rclttove accuululaled solids fr'onl
gullers as designed.
O Itentove bridging ofaecunn►ia1ccl solids al
Lagoons and I'ils r����t,..r c.:r.l_ discharge
:I : cescive vegetative
`` �ll'UII'lll
Tcct(crs
■ Mainlaiu lagoons, selding basins anti Ails uhcrc
pest brceding.is appal -CM to nrininiizc Ilse
cruslinb of solids to a depth of no more than G
t)CCill•111 �!
S inches over more than 30% of surface.
• V.CPclnliu,n
• feed Spillage
s- . nccuntulatrorts of feed residues
AM IC - November 11. 1996, Page I
m;untaut vcgclalive conlrol along banks of
lagoons and other impouttdrnenls to prevent
accirnttllatiun of decaying vegelative ntaucr
along water's edge on impoundment's perimeter.
■ Design, operate and maintain feed syslcnis (e.g.,
bunkers and lr'oughs) to minimize the
accuntulalionl of decaying wastage. -
■ Clean ujl spillage oil a roulinc basis (e.g., 7 - 10
day interval dul'ing sulnnter; 15-30 day interval
during winter).
O !seduce moisture accuntulalion %vitllin and
around intnlctliale perimeter of feed sloragc
areas by insuring drainage away front site
and/or providing adqua(c coil tainulenl
covered bill for brewer's grain and similar high
nluislurc grain products).
(� Itrspect for and reiuove or break up accumulated
solids in filler strips around fee(f storagens
needed.

_ Source .
Animal Holding Areas
Ca. ;e
• Accumulations of animal wastes
BA�11"s to Control insects. !
andfeedwastage -
17 Eliminate low areas that trap moisture. along
-
fences and other'.1ocations. where waste
accumulates and disturbance by animals is
minimal.
® Maintain fence rows and filter strips around
animal holding arem.to minimize u
accutnudatlons of wastes (i.e., inspect for and
remove or break up accumulated solids as /
Dry Manure Handling.
Accumulations of animal wastes
needed) ;
® Removes Village p lage on a aoutine basis (e.g.,!
-.10
day"interval during summer; 15-30 day interval
during winter) when manure is loaded for land
application or disposal.
13 Provide for adequate drainage around manure
stockpiles.
13 Inspect for and remove or break up accumulated
wastes in filter .strips around stockpiles and
manure handling, areas as needed.
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7(13, North Carotins
Raleigh, NC, 27695-7613.
State -University,
AM1C - November 11, 1996, Page 2

i
Source
Aermticad
Manurc col
Swine Farm. Waste Management Odor Control Checklist
DMPsa6 hhilnlinlzo Odolr
• Swine production .� Site S
M
NEWIM
--••y ivaAIUIG-GUYCrca an
• Wff mannra_...,..s
. �gctauvc:or wooded butrers-
■ Recommended: best management practices;
■. t3ood judgment and common sense
■ Dry. • floors
-- -- -•-" °..,.,.�
IR% blotted floors; .
■ • Watcrers.located over slotted floors;
17
Feeders at. high end of solid floors;
f7..
Scrape mAhurcbttildup from floors;
lection pits • Urine;
A
: Underfloor Ventilatloa for drying . .
• Partial microblai.decomposition
■
. Frequent trlinurc removal by flush, pit recharge,
or.scrape;
exhaust fans volatile gases;
■
.Underfloor vehillatlon
Dust
■
.Fan maintenance;
■
EMcicnt air movernent
ces • Dust
■
Waslidown -between groups of animals;
A
Feed additives; - .
O .
Feeder covers;
IN
Feed delivery downspout extenders.to feeder
• Agitation of recyoled lagoon
liquid while tanks are flling
O,
covers -
Flush tank covers;
p
Extend fill lines to near bottomof tanks will)
anti-si l
rlusn alle S • loll•ventS
Y Agitation during wastewater
■ Under. oor (lush with'underfloor ventilation
conveyance
Pit recharge points • Agitation of recycled lagoon ® Bxtend recharge lines to near bottom liquid while pits are filling s � of pits
M111 arltl•sipilon vents
LiR stations • Agitation during sump tank
filling and.drawdown ... 0 Sump tank covers
Outside drain collection • Ag.'itation during wastewater Ell .orlunetion boxes Box covers
conveyance
AMOC - November 11, 1996, Pagb 3
0,

`-AMU , HMPs to Minimin Oddi• Site Specitc Practices
End of dra4pipes at •. Agitation during wastewater C3 Extend discharge point of pipes: underneath
lagoon ..:..:. convoypow.. .......
agoonliquid level . •
Lagoon surfaces • Volatile gas emissions; ■ proper lagoon liquid capacity;_ -
4 �
• Biological mixing;, a Correct lagoon SM. u � p procures; .
• Agitation 13 Minimum surface w4 to -volume ratio;
Minimum agitation when pumping;
0 Mechanical aeration;
® Proven biological additives
Irrigation sprinkler. • High pressure agitation; ■ irrigate on dry days with little or no wind;
nozzles • Wind drift
® Minimum recommended operating pressure;
Pump intake near lagoon liquid surface;
Pump from second -stage lagoon
Storage tank or basin Partial microbial decomposition;
fa ® Bottom or. midlevel loading;
sur ce . Mixing while filling;
. ® Tank covers;
• Agitation whey emptying b Basin surface'mats of solids;
13 Proven biological additives or oxidants
Settling basin surface ® Partial microbial decomposition; 13 Extend drainpipe outlets underneath liquid
• Mixing while filling, level;
® Agitation When emptying ® Itemovd settled solids regularly
Manure, slurry or sludge ® Agitation wr>hen spreading; ® •Soil injection of slurry/sludges;
spreader outlets ® Volatile gas emissions
® Wash residual manure from spreader after use;
®
Proven biological additives or oxidants
Uncovered manure,
® Volatile gas emissions while
®
Soil injection of slurry/sludges
slurry.or sludge on field
surfaces
drying
®
Soil incorporation within 48 hrs.;
®
Spread in thin uniform layers for rapid drying;
®
Proven' biological additives or oxidants
Dead.animals •
® Carcass decomposition
®
Proper disposition of carcasses - -_- - --- -
Dead animal disposal
a Carcass decomposition.
Cl
Complete covering of carcasses in burial
pits
pits;
® Proper location/construction of disposal pits
incinerators. . incomplete combustion CI Secondary stack burners
.--\
AN(._'.'.November 11, 1996, Page 4

aouree Cause BMPs to Minimize. Odor Site Specific Practic
Standing water around • improper drainage; M Grade and landscape such that water drains
facilities . Microbial decomposition of away from facilities
organic matter
Manure tracked onto . Poorly maintained access roads O Farm access -road maintenance
public roads from farm
access
Additional Information : Available From :
Swine Manure Management ; 0200 Rulel'BMP Packet NCSU, County Extension Center
Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact.Shcet NCSU - BAE
Swine Production Facility Manure Managenient:' Pat Recharge - Lagoon Treatment; EBAE 128-88 NCSU - BAE
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment; EBAE 129-88 NCSU - BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage ; EBAE 103-83 NCSU - BAE
Calibration of Manure and Wastewater Application Equipment ; EBAE*Fact Sheet NCSU - BAE
Controlling Odors from Swine Buildings ; PIH-33 NCSU - Swine Extension
Environmental Assurance Program ; NPPC Manual NC Pork Producers Assoc
Options for Managin6 Odor ; a report from the Swine Odor Task Force NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies i PRO107, 1995 Conference Proceedings Florida Cooperative Extension
AMOC - November 11, 1996, Page 5

version —November 26, 2018
Mortality Management-, Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other that► those listed must be approved by:the. &ate Veterinarian.
Primary Secondary Routine Mortality
a Q Buriat-three feet beneath. the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300-feet from any flowing stream or public body of water
(G.S.106-403). The bottom.of the�buriai pitshould be at least one foot above the seasonal
high water table. Attach burial iocatibn map and- plan.
a Landfill at municipal solid waste facility permitted. by NC DEQ unde
1315.0200. r GS 15A NCAC
j' R��cteringxat-a-re ering lant'.Iicensecl vender C�St106
aComplete incineration according to 02 NCAC 520 .0102.
Con -
El A composting system approved. and. permitted py the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach.copy of permit). If compost is -distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the: case: of dead poultry,only,. placing in a disposal -pit. of -a size. and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any methodwh .. i
.n the. professional opinionipf the State Veterinarian, wculd.make possible
the salvage of part of a dead animals value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
'Mass mortality plans are required for farms covered. by an NPDES permit. These plans are
also.tecommended for all animal -operations. This plan outlinesfarm-specific mortality man-
agement. nlethods,to. be. used for mass: mortality. The NCDA&CS Veterinary Division. sup-
ports avariety of emergency mortality disposal options; contact then Division for guidance.
• A catastrophic mortality disposalplan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as sp
Veterinarian. ecified by the State
• Burial must b&done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
aste management system permit).
• I the' event of.imminent threat of a disease emergency, the State Veterinarian may enact
a ditionai temporary procedures or measures for disposal according to G.S. 1.06-399.4.
D
L 3 zs 20!
Signature of Technical Specialist Date

.
�
Operator:CAROLINA PACKERS County: SAMPSON
Date:
Distance to nearest resideHce (other than
owner) :
1000
feet
1. STEADY STATE LIVE WEIGH-:-
0 Bows (farrow to finish) X
1417
|bs.
= 0
0 Sows (farrow to feeder) X
522
|bs.
= 0
5880 Head (finishing only) X
133
/bs.
= 79380(),
0 Sows (farrow to wean) X
433
|bs.
= 0
0 Head (wean to feeder) X
30
|bs.
= 0
TOTAL STEADY STATE LIVE
WEIGHT
(SSLW)
= 793800
2. MlNlMUM REQUIRED TREATMENT VOLUME OF 1
A8O0�
.Volume = 793800 | bs. SSLW X Treatment
Volume
CF/ Ib. SSLW
Treatment Volume CF/lb, SSLW=
1.0
CF/}b.
SSLW
Vo!ume = 793800 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
'
Volume = 0 cub;c feet
4. TOTAL ZESI8N VOLUME
Inside top: length 700
feet
;
width
205
feet
Top of dike at elevation
50.00
feet
Freeboard 1.3 feet
Side slopes
3.0:1(inside)
Total design lagoon liquid
}eve\ at elevation
48.70
feet
Bottom of lagoon at elevation
38.00
feet
Seasonal high water table elevation
0.00
feet
Tota} design volume usin8 prismoida/
formula:
SE/END! SS/END2 SS/SIDE!
SS/END2
LENGTH
WIDTH
DEPTH
3.0 3.0 3.0
3.0
692.2
197.2
10.70
AREA OF TOP
LEN07H X WIDTH
692 197
136502
(Area of
Top)
AREA OF BOTTOM
LEN6TH X WIDTH =
628 133
83524
(Area of
Bvttom)
AREA OF MIDSECTION
LEN8TH X WIDTH X 4
660 165
435930
(Arch of
MidseLtion
X 4)
CU. FT. = [Area Lop+(4XArea
Midsect9oo)+Area
Bottom]
X
Depth/6
136502
435930
83524
2
VOL. OF LAGOON AT TOTAL DESIGN LIQUID
LEVEL =

�. TEMPUHARY STORAGE REQUIRED
Drainage
Area:
Lagoon (top of dike)
Length X Width =
700 205 143500 Square
Feet
Buildings (roof and lot water)
Length X Width =
� 0 O Square
Feet
TOTAL DA 143500 Square
Feet
===>
Desion temporary storage to be
180 days.
A.
Volume of waste produced
Approximate daily production of manure
in
CF/LB SSiW 0.00136
Volume = 793800 Lbs. SSLW X CF
of waste/lb/day
X 180
Volume = 194322 Cubic feet
D.
Volume of wash water
This is the amount of fresh water
used for
w&5h!n3 floors or
volume of fresh water used for a
f|ush system.
Flush systems
that rocirculats the lagoon water
are accounted
for in 5A.
Volume = 0 Gallons/day X
180 days stora8e/7.48
gallons per CF
Vo}ume = 0 Cubic feet
C.
Volume of rainfa|l in excess of evaporation
Use period of time when rainfall
exceeds evaporation
by
largest amount.
180 days exdess rainfall
=
7.0 inches
Volume = 7.0 Inches X DA /
12 inches
per foot
Vo!une = 83708.333 CubiL feet
D.
Volume of 25 year - 24 hour storm
Volume = 7.0 inches / 12 inches
per
foot X DA
Volume = 83708 Cubic feet
TOTAL
REQUIRED TEMPORARY STORAGE
5A. 194322 Cubic
feet
OD. 0 Cubic
feet
5C. 83708 Cubic
feet
5D. 83708 Cubic
feet
TOTAL 361739 Cubic
feet

Tota1 re�uired vo/ume =
1�55539
Cub�c
feet
Totu� desigo
voiume av^i).=
11�9788
Cubic
feet
Min. reqrd.
trtmnt.
vo|.
�|u� s!ud3e
acc-kJ m.=
79�800 Cu. Ft.
At e/ev.
��°"�
0.00 Ft; Vo|=
-535724
Cubic
feet
(end pumping>
Tota� des�3n
vo�ume
/ess
25yr-24hr storm =
1086080 Cu. Ft.
�
At e|ev.
�0�N�N�
0.00Ft; Vo[=
-53.... T24
Cubi
art
pumpinS)
Seasona!
h��h
water tab|e
e/evation is
0.00
Feet,
which
must
be |ower
than
the e�evativn
of top of
treatment
vo/ume O.00
DESI8NED BY: APPROVED BY:
__.... _.... ..... ....
DATE:
..... .... .....
.... ..... ..... ..... ..... ..... _..... ...
_____
..... ... ..... ..... ..... ....
_..... ... ..... ... ____________________
DATE:�
NOlE:
SEE
ATTACHED
WASTE
UTILIZATION PLAN '
ADDITIONALNOTES: ..... ..... ..... ..... ..... ..... ..... .... .... .... ..... .... ..... _..... ... ..... _..... ..... ___..... _____... ...... _____... .... ..... ......
_
.... ..... ..... ..... .... ..... ... ..... .... ..... _____.......... .... .... ..... ..... _....... _... ..... _..... ..... ..... ..... ..... ..... ..... ..... ..... ..... .... .... ..... ..... ................................. ..... ... ..... ... .... ..... ..... ..... ... .... ..... ..... .... ____
... ..... .... ..... ..... .... . .. ..... ......... ... �..... ..... ..... ..... .... ��.... ..... .... ... ..... ..... .... .... .... ..... .... ..... ..... ..... .... ... .... .... ..... .... ..... .... .... .... .... ..
���... ..... ..... ..... .... ���.... ..... ..... �... ����.... .... �.... ..... .... .... ..... ����������.... .... ..... .... ... ..... ..... .... .... �..... ���..... ..... ... .... ��..... �..... .... ������..... ..... .... .....

f ' OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (Permanent star 9L-
_g-
The time required for the planned fluid level to be
min. Odor control tQ
reached (permanent + temporary storage) may vary due to S-011 cohdi'
flushing Operations, and the amount of fresh water a,4400 to the s
The designed 6 months temporary storage is an -estimated Volume
basedo-B nwaste from animals'; 2) excess rainfall after- evaporatiop;
anal 3-) the largest 24 hour (one day) rainfall that occurs on the
average Of once every 25 Years. The- vOluffi-- Of KaLste generated ft-ow,
a given nu-m-ber of animals will be fairly constant throughout the year and fro-m year to year. This
estimate is based on 7 inches of exces's
rainfall which is equal. to or exceeds the highest 6 months excess in
a Year. The average annual excess rainfall is approximately 9 inches.
.L
Therefore, an average of 9 inchesofexcess rainfall will need to be
PUM.-Ped each year. The 2,05- year rainfaI7 Will not be a faftor'tb Cr
L
if
.in an a nual Pumping Cycle,
'5U4 `s storage volume must always be
available. A maximum elevation 'is determined in each design to b
pumping and thi s '
' iis usually -'--
he Outlet invert of pipe(s) from eqin
building(`). If the outlet P'Pe 45 not installed on "t, #�iq P.umpin-g a he elevation to
P , P!er Ane"It Sa
to lohieih PU r must be install d dn this
c
n e!LaVatibn -must
to stop Pumping to maintaij tr ...'sftabi fwd
Pa linimum treatment depth (6 'feet -).
*Oxng can be started or 4,-opped at any time
e14L�'Vatl&Ons for operating U. between these. two
Wea-th.er. soils, tIng convenience assiteconditions permit., such as
Cropp and equipment in order to apply wast
or leach-ng. * without
L
Land aPPlication of Waste water is recognized as
'-han acceptable
ce
method bf disposal� Methods of application i pclude solid set,
nter pivot , guns, and traveling gun .
take-41 when applying waste to D I Ai. rrigationCare should be
revent damage to crops.
The following items are to be Carried out..
'I
i.; It i * s strongly recommended that the treatment charged to 11/2 its capacity lagoon be pre -
charged - itY to prevent excessi%,je Odors during
"-=rt-Up= Pre -charging reduces the C-01-1centratjor
thereby reducing Odors. Sojids S_
wckste entering the lagoon .1 of the initial
covered with effluent at ail 4-* hould be
4 '-Imes- When prechargina is complete,
flush buildings With recycled lagoor -fen?
J-d. Fresh water should not
be used for flushing after inItial f 11 Iing
9� 1 h
4!
- �e attached waste
p
plan shall be -If011owed. lan recommends sampliI- 7 1 This
sampling and testing of Waste (see attach before land application, . mer,t)
3- Begin DUMP-OUt of the lagoon
tion 0 lagoon When fluid lev,-=l reaches eleva-
Lis 3"' as marked by permanent marker. Stop
the fluid level 4. reaches elevaPumP-out when
Clon 4/4-3 or before the flLti,
less than 6 feet. deep (this prevents the Joss of N id depth Js
bacteria). The design te 4' favorable
mporary storage-5 less 25 year irm
is L
cubic feet Or 9;t7j 393 gazllOnsx As Stated before, this
volume Will vary considerably fl-.Om year to year.

7..
Wr. Of f J tO bL- dame. 449* F urm 'e.rted fr-cmB the la,900n to stable
.U.t
8- Keep a 10-miftaffl of 25 feet of 9- ass vegetated buffer* around
4--aste utilization fields adJacent pe-rennial streams. Waste will
not be aP-Plied in open ditches. Dd- '* it PLUMP wit-hin 2-0-10 feet of a
re-sidep.aLm or Wi.4-hin 100 of a ... U. "011.
9. The CILL*44r. Water Act Of 1977 prohibits the discharge of
pollutants into waters of the Unit�d Sta,,,*S. The ire Partwent of
an€ t -a I
SIB
RiviSiOn of Eniviron-
1. AM' Et had thy. 8Sr-Pit fororcins law.

L7~1&°
3perator:CAROLINA PACKERS County: SAMPSON Date:
Distance to nearest residence (other than owner): /��un"0 f-------
1. AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish) x 1417 lbs. =" 0 lbs
0 sows (farrow to feeder) x 522 lbs. = 0 lbs
7350 head (finishing only) x 135 lbs. = 992250 lbs
0 sows (farrow to wean) x 433 lbs. = 0 lbs
0 head (wean to feeder) x 30 lbs. = 0 lbs
Describe other :
-------------
: 0
."`a^ Average Live weight = 992250 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 992250 lbs. ALW x Treatment Volume(CF)/lb ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb ^
Volume = 992250 cubic feet ^ ALW
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet SLUDGE ACCUMULATION NOT COMPUTED
AT OWNERS REQUEST. REMOVE SLUDGE
4^ TOTAL DESIGNED VOLUME AS NEEDED.
Inside top length (feet)----------__
Inside top width (feet)-----______- --------- 790^O
---------- 250.0
----
Top of dike elevation (feet) -------- ^
Bottom of lagoon elevation (feet) ------------
61^5
Freeboard (feet) .............................
51.5
Side slopes (inside lagoon) --______ --------- 1^O
---------- 3.0 : 1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 784.0 244.0 9.0
AREA OF TOP
LENGTH * WIDTH =
784.0 244.0 191296 (AREA OF TOP)
AREA OF BOTTOM
LENGTH I WIDTH =
730.0 190.0 138700 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
757.0 217.0 657076 (AREA OF MIDSECTION * 4)
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM3 * DEPTH/6
191296.0 657076.0 138700.0 1.5
Total Designed Volume Available

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
790.0 250.0 197500.0 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
TOTAL DA 197500.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
Volume = 992250 lbs. ALW/135 Ibs. ALW * 1.37 gal/day 180
days
Volume = 1812510 gals. or 242314.2 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48
gallons
Volume = 0.0 cubic feet
per Cl'--
jC. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest
amount.
180 days excess rainfall = 7.0 inches
Volume = 7.0 in $ DA / 12 inches per foot
Volume = 115208.3 cubic feet

` .
'
5D. Volume of 25 year - 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume = 115208.3 cubic feet
,
.�
�A.
242314
cubic
feet
5B.
0
cubic
feet
5C.
115208
cubic
feet
5D.
115208
cubic
feet
TOTAL
472731
cubic
feet
6. SUMMARY
Temporary storage > 180 days
Rainfall in excess of evaporation===========> 7.0 inches
25 year - 24 hour rainfall===== =============> 7.0 inches
Freeboard==================== feet
Side slopes=================================> 3.0 : 1
Inside top length===========================> 790.0 feet
Inside top width============================> 250.0 feet
Top of dike elevation=====�==== =============> 61"5 feet
Bottom of lagoon elevati====> 51.5 feet
Total required volume=======================> 1464981
Actual design
1480608 cu ft *
Seasonal hi|h watertable elevation (GHWT)=.... ..... .... 55.0 fe^t ^
Stop pumping elev.==========================> 57.8 feet *
Must be > or = to the SHWT elev.==========> 55.0 fet
Must be > or = to min. req. treatment el.=> 57.5 fe~t
Required minimum treatment volume===========> 992250 cu~ ft
Vo1ume at stop pumping elevation============> 986355 cu^ ft^
Start pumping elev.===============�=========> 59.8 fe~^t ^ *
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume lessL25 yr.- 24 hr. rainfall==> 1365400 cu ft
Volume at start pumping elevation==========�> 1348208 cu^ ft"
Required volume to be pumped=======�======�=> 357523 cu^ ft^ *
Actual volume p1anned to be pumped==========> 361853 cu^ ft^ *
Min. thickness of 1501:1 liner when requ'red==> 1.5 fe"t ^
DESIGNED BY: JX. C-4�m, AppROyED By: &y
/ ~r
-^-°.
14
f1^ ` u
t:f

SHEET 1 OF 2
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) and
180 days,of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generathd from agiven number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin .
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed at the elevation to
begin pumping: a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptabb--,
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops"
The following items are to be carried out:
I. It is strongly recommended that the treatment lagoon be pre -,-.-
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 59.8 as marked by permanent marker. Stop pump -
out when the fluid level reaches elevation 57.8 . This temporary
storage, less 25 yr- 24 hr storm, contains 357523 cubic feet or
2674268 gallons.

GHEET 2 OF 2
4" The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maxibum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
S. Keep a minimum Of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
Pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

Operator:C & B
FARMS County:
.
SAMPSON
Date4
Distance to nearest residence (other
than
owner):
1000 feet
1. STEADY STATE LIVE WEIGH]"
0 Sows
(farrow to finish)
X
1417
/bs. =
0
0 Sows
(farrow to feeder)
X
522
!bs. =
0
2940 Head
(finishing only)
X
135
|bs. =
396900
0 Sows
(farrow to wean)
X
433
|bs. =
0
0 Head
(wean to feeder)
X
30
lbs. =
0
TOTAL STEADY STATE LIVE
WEIGHT
(SSLW) =
396900
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume =
396900 |bs.
SSLW X Treatment
Volume CF/|b" SSLW
Treatment
Vo|Ume CF/|b"
SSLW---
1"() CF/|b"
SSLW
Volume =
396900 cubic
feet
3. STORAGE VOLUME
FOR SLUDGE ACCUMULATION
OWNER REQUESTS
NO SLUDGE STORAGE
SLUDGE WILL BE
REMOVED AS NEEDED
Volume =
0 cubic
feet
4. TOTAL DESIGN VOLUME
Inside top: length 350 feet ; width 215 feet
Top of dike at elevation 52.50 feet
Freeboard 1.3 feet Side slopes 3.0:1(inside)
Total design lagoon liquid level at elevation 51,20 feet
Bottom of lagoon at elevation 40.50 feet
Seasonal high water table elevation 44.10 feet
Total design volume using prismoida| formula:
SS/END1 SS/END2 SS/8IDE1 SS/END2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 342.2 207.2 10.70
AREA OF TOP
LENGTH X WIDTH
342 207,
AREA OF BOTTOM
LEN6TH X WIDTH =
278 143
AREA OF MIDSECTION
LENGTH X WIDTH X 4
310 175
70904 (Area of Top)
39754 (Area of Bottom)
217194 (Area of Midsection X 4)
CU. FT. = [Area top+(4XArea Midsection)+Area Bottom] X Depth/6
70904 217194 39754 2
VOL. OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = ~`-`
'.___--------_ -_~

5. TEMPORARY STORAGE REQUIRED
Drainage Area:
Lagoon (top of dike)
Length X Width =
350 215 75250 Square Feet
Buildings (roof and lot water)
Length X Width =
0 0 0 Square Feet
TOTAL DA 75250 Square Feet
===> Design temporary storage to be 180 days.
A. Volume Of waste pr0dU'9d
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 396900 Lbs. SSLW X CF of waste/lb/day X 180
Volume = 97161 Cubic feet
B. Volume of wash water
This is the amount of fresh water used for washing floors or
volume of fresh water used for a flush system. Flush systems
that recirculate the lagoon water are accounted for in 5A.
Volume = 0 Gallons/day X 180 days stura8e/7.48
Volume = 0 Cubic feet gallons per CF
C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by
largest amount.
` 180 days excess rainfall = 7.0 inches
Volume = 7.0 Inches X DA / 12 inches per foot
Volume = 43895.833 Cubic feet
D. Volume of 25 year - 24 hour storm
Volume = 7.0 inches / 12 inches per foot X DA
Volume = 43896 Cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 97161 Cubic feet
5B. 0 Cubic feet
5C. 43896 Cubic feet
5D. 43896 Cubic feet
TOTAL 184953 Cubic feet

6. SUMMARY
Total required volume =
581853
Cubic
feet
Total design volume
avai|.=
584669
Cubic
feet
Min. reqrd. trtmnt.
vol. plus
sludge
accum.=
396900
Cu. Ft.
At elev. 48.40
Ft; Vo|=
398797
Cubic
feet
(end pumping)
Total design volume
less 25yr-24hr
storm
=
540773
Cu. Ft.
At elev. 50.50
Ft; Vn|=
535840
Cubic
feet
(start
pumping)
Seasonal high water
table
elevation is
44.10 Feet, which
must
be lower than the elevation
of top of
treatment
volume
48.40
DESIGNED BY: APPROVED BY:
------^-----7�----------- --___
DATE: DATE: '�~��-����
________----
NOTE: SEE
ATTACHED WASTE
UTILIZATION PLAN
ADDITIONAL
NOTES: .......................................................

OPERATION AND MAINTENANCE PLAN
---------~---------------~----
This lagoon is designed for waste treatment (permanent storage) with
minimum odor control. The time required for the planned fluid level
to be reached (permanent + temporary storage) may vary due to
flushing operations and the amount of fresh water to be added to the
system.
The designed 6 months temporary storage is an estimated volume
based on : 1) waste from animals; 2) excess rainfall after
evaporation; and 3) the largest 24 hour (one day) rainfall that
occurs on the average of once every 25 years. The volume of
waste generated from a given number of animals will be fairly
constant throughout the year and from year to year. This
estimate is based on 7 inches of excess rainfall which is
equal to or exceeds the highest 6 months excess in a year.
The,average annual excess raiDfa!l is approximately 8 inches.
Therefore, an average of 8 inches ;f excess rainfall will
need to be pumped each year. The 25 year rainfall will not be a
factor to consider in an annual Pumping cycle, but this storage
volume must always be available. A maximum elevation is
determined in each design to begin pumping and this is usually
the out/et invert of pipe(s) from bui|d|n8(s). If the outlet
pipe is not installed on the elevation to begin liumping, a
permanent marker must be installed on this elevation to
indicate when pumping should begin. An elevation must be
established to stop Pumping to maintain minimum treatment depth
(6 feet). Pumping can be started or stopped any time between
these two elevations for operating convenience as site
conditions permit (weather, soi>s, crop, and equipment to apply
waste without runoff or leaching).
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, Suns, and traveling Sun irrigation. Care should
be taken when applying waste to prevent runoff from the field
or damage to crops.
The following items are to be carried out:
1. It is strongly recommended tha the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids
should be covered with effluent at all times. When pre --
charging is completed, flush buildings with recycled lagoon
liquid. Fresh water should not be used for flushing after
initial filling.
2. The attached waste utilization plan shall be followed.
This plan recommends sampling and testing of waste (see
Attachment B> before land application.

3. Begin pump -out of the lagoon when fluid level reaches eleva-
tion 50.50 as marked by permanent markers. Stop pump -out
when the fluid level reaches elevation 48.40 or before
fluid depth is less than 6 feet deep (this prevents the loss of
favorable bacteria). The design temporary storage, less 25 year
storm is 141057 cubic feet or 1055106 gallons. As stated
before, this volume will vary considerably from year to year.
4. The recommended maximum amount to apply per irrigation is one
(1) inch and the recommended maximum aPp|ication rate is 0.4
inches Per hour.
5. Keep vegetation on embankment and areas adjacent to the lagoon
mowed annually. Vegetation should be fertilized as needed to
maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is 'to be diverted from the lagoon to
stable outlets.
8" Keep a minimum of 100 feet cropland buffer or 25 feet of grass
vegetated buffer around waste utilization fields, particularly adjacent
to pondsv lakes, streams, open ditches, etc. Do not pump within
300 feet of a residence or within 100 feet of a well.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.