820537_Permit Renewal Application 2019_20190410

r
State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 82-0537 Certificate Of Coverage Number:
2. Facility Name: Pope's Pig Palace
3. Landowner's Name (same as on the Waste Management Plan): Kay Pope
4. Landowner's Mailing Address: 10723 Keener Rd
City: Faison State: NC
Telephone Number: 910-385-7731 Ext. E-mail:
5. Facility's Physical Address: 237 Beaver Rd
City: Clinton State:
6. County where Facility is located: Sampson
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"):
10. Operator Name (OIC): Charles K. Pope
NC
Kevin Pone
910-533-2615 Ext.
11. Lessee's Name (if there is not a Lessee, write "None"): .,JO]V g
Murphy -Brown LLC
Phone No.: 910-385-6719
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Swine - Wean to Feeder
Operation Types:
5,000
AWS820537
Zip: 28341-5709
Zip: 28328
OIC #: 19105
Swine
Cattle
Dry Poultry
Other Types
Wean to Finish
Dairy Calf
Non Laying Chickens
Horses - Horses
Wean to Feeder
Dairy Heifer
Laying Chickens
Horses - Other
Farrow to Finish
Milk Cow
Pullets
Sheep - Sheep
Feeder to Finish
Dry Cow
Turkeys
Sheep - Other
Farrow to Wean
Beef Stocker Calf
Turkey Pullet
Farrow to Feeder
Beef Feeder
Boaz/Stud
Beef Broad Cow
Wet Poultry
Gilts
Other
Non Laying Pullet
Other
Layers
rrn"'1f'^�r�r r�i
APR 0 2 2019.

ROY COOPER
Governor
MICHAEL S. REGAN
5ecrerary
LIN©A CULPEPPER
Director
M
NORTH CAROLINA
Environmental Quality
February 27, 2019
Kay Pope
Pope's Pig Palace
10723 Keener Rd
Faison, NC 28341-5709
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https://dN.nc.gov/about/divisions/water-resources/water-qualirv-regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non -Discharge General Permits, you must submit an application for
Permit covers *e to the Division. Enclosed you will find a "Request for Certificate of Coverage Facility Currently Covered byan
Expiring State Non -Discharge General Permit." The application form must be completed, signed and returned by April 3. 2019.
Please note that You must include one 1 co v of the Certified Animal Waste Management Plan CAWMP with the
completed and signed analication form. A list of items included in the CAWMP can be found on payee 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Enclosures
cc (w/o enclosures): Favetteville Regional Office, Water Quality Regional Operations Section
Sampson County Soil and Water Conservation District
AFOG Section Central Files - AWS820537
Mur hhv-Brown LLC
North<Ca€o rtsDzpaarrentof=so-so.nma;taQuaty I nusonofWats,Resour-s
.512 N. Sa sbun• St. 11_ZE Ma 6a egg, North Caro na 27SSLIAL 3£.

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
82-537-1
`781&ak.
52.
19.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), shined by the owner and a certified technical specialist, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to „civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
J
Name: 4 — Title: '
Signature: _ LUA Date:
Name:
Signature:
Name:
Signature:
Title:
Date:
Title:
Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

3/27/2019
ConnectGIS Feature Report
Sampso
CON V EC ! I
Printed March
WE6liG5r9NG See Below for Disclaimer
19
aimerimer
F_ Parcels (Yellow)
A � '
r.
Centerlines
L
Sampson County
NC Counties
r * - Primary Roads
` — us
Municipal limits
y.
k.
E .� f � } S"S' iV•
i r rr_
j•:
JE �w•� �� .r'
_
t . 318 Feet
S
re are continually editing our maps to improve accuracy of position and information. This information should not be relied upon by anyone as a determination of the
ocation ownership, or market value of properly. Always refer to the recorded deed for all lecial pureoses. Use of this web site indicates your acce tance of these terms.
https://sampson.connectgis.com/DownloadFile.ashx?i=_ags_map4eO5aaO557fO487191 bb84al968ab5d3x.htm&t=print 1/1

• :. - �a-� i vii� .r
r •,•.
F �' yip
t
-
■.
^ � • f
� s �, �firr' �
i..
•s'
5 �
s
1
■
r
4
r ,
t
,
i'

200 ft.
Buffer
Occupied
Dwelling
Hog
Houses
100 ft.
Buffer C
(WELL)
100-ft.
Buffer
(WELL)
a
7V
Charles E. Pope
Pope's Pig Palace
82-537
91 Beaver Road
Clinton, NC 28328
5000 Swine Nursery
:Scale: 1 inch = 300 feet

0
WASTE UTILIZATION PLAN
PRODUCER: Kay Pope
FARM NAME: Pope's Pig Palace
FACILITY NUMBER: 82-537
LOCATION: 217 Beaver Road, Clinton, NC 28328 Sampson County
TELEPHONE: [phone]
TYPE OPERATION: WEAN - FEEDER
NUMBER OF ANIMALS: 5000 Wean - Feeder
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should
be used to reduce the amount of commercial fertilizer required for the crops in the fields
where the waste is to be applied. This waste utilization plan uses nitrogen as the
limiting nutrient. Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be balanced for realistic
yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to
be grown and the nutrient content of the waste. Do not apply more nitrogen than the
crop can utilize. Soil types are important as they have different infiltration rates,
leaching potentials, cation exchange capacities, and available water holding capacities.
Normally waste shall not be applied to land eroding at greater than 5 tons per acre per
year. With special precautions, waste may be applied to land eroding at up to 10 tons
per acre per year. Do not apply waste on saturated soils, when it is raining, or when
the surface is frozen. Either of these conditions may result in runoff to surface waters
which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of
nutrients for crop production and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied to bare ground not more than 30 days prior to
planting. Injecting the waste or disking will conserve nutrients and reduce odor
problems.
The estimated acres needed to apply the animal waste is based on typical nutrient
content for this type of facility. Acreage requirements should be based on the waste
analysis report from your waste management facility. Attached you will find information
on proper sampling techniques, preparation, and transfer of waste samples to the lab
for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with
15A NCAC 21-1.0217 adopted by the Environmental Management Commission.
Page 1

11
0
WASTE UTILIZATION PLAN
Amount of Waste Produced Per Year 'rya chs ft tcns. etc
5,000 animals X 0.42 ,tc—s waste ar_-na''year =
Amount of Plant Ava;"ab-e N trcgen tPAN` PFrf..oed Per Year
5,000 animals X 0_48 :;s Pr4 ar r-a" year =
Guide Std. 6331
Applying the above a-ncur: c. Aas'e .s a t: g ,a Yci should plan time and have
appropriate equipment m a":i t-e Aas'.e n a t Tre'y manner.
The following acreage A oe reefed':- rwas*e appi,cat:on based on the crop to be growl
and surface app'.:at::^
2,100 (amt.) waste/year.
2,100 TONS
2,400 lbs. PAN/year. (PAN from N.C. Tech.
2,400 # PANNEAR
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soa Crop RYE N Lbs. N
41 iv- T,r.,� Factor Per Acre
Acres Lbs. N Month of
Utilized Aaplication
11328
3 r ar .e _ : t a, r:.d Bermuda Pasture - Grazed
6.5
37.5
243.75
2.20
536.25
Mar -Se
11328
4a %a^ra- H.-:-J Bermuda Pasture - Grazed
5.5
37.5
206.25
1.10
226.875
Mar -Se
11328
4b Bermuda Pasture - Grazed
6.5
37.5
243.75
2.60
633.75
Mar -Se
11328
5 .7ac a- crd Bermuda Pasture - Grazed
5.5
37.5
206.25
1.10
226.875
Mar -Sep
11328 3 thrs 5 %Va & C- Small grain o dlon - girazed
1
50
50
7.00
350
Oct - Mar
*This N is from animal waste only. If nutrients from other sources such as commercial
fertilizer are appHed, they must be accounted for. N must be based on realistic yield
exc ectation.
NOTE. The applicator is cautioned that P and K maybe over applied while meeting the N
requirements. Beginning in 1998 the Coastal Zone Management Act will require farmers in
some eastern counties of North Carolina to have a nutrient management plan that addresses
all nutrients. This plan only addresses Nitrogen.
1 Vwl I I.V. ! ,.. .�
Page 2

0
WASTE UTILIZATION PLAN
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
[Required only if operator does not own
adequate land [see Required Specification 21)
Tract Field Soil Crop RYE N Lbs. N Acres
tt Nn_ Tvnp tractor Per Acre
Lbs. N Month of
Utilized Anolication
11328
laa
Wa-,ram
H.brid Bermuda Pasture - Gazed
5 5
37 5
236 25
0 90
18563
Mar -Se
11328
la
Wag ram
H:cnd Bermuda Pasture - Grazed
55
375
20625
108
22275
Mar -Se
11328
lb
Wa ram
M'et - Grazed
5
41 25
23625
228
47025
Apr - Sep 15
11328
2a
Wa ram
Herr"d Bermt:da Pasture - Gazed
55
375
206 25
3 e5
13406
Mar -See
11328
2b
Wacram
M°"et - Grazed
5
4' 25
2C6 25
121
24956 !
Apr - Sep 15
11328
1 a thru 2bi ',Nacram
Srra Gra_i O.erseed
SC
SC 1
612
346 C3
Oct Mar
See footnote for Table 1
Totals frc:r above Tables
Table 1
Table 2
Total
Amount of N Produced
Surplus or Deficit
Acres Lbs. N
Utilized
7.00 1,973.75
6.12 1,568.25
13.12 3,542.00
2,400.00
1,142.00
total 1 b.1Z 7,76tS.Zb
Acres shown in each of the preceeding tables are considered to be useable acres excluding required
buffers, filter strips along ditched, odd areas unable to be irrigated, and perimeter areas not receiving full
application rates due to equipment limitations. Actual total acres in the fields listed may, and most
likely will be, more than the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient rich and will
require precautionary measures to prevent over application of nutrient or other
elements.
See the attached map showing the fields to be used for the utilization of waste water.
Page 3

WASTE UTILIZATION PLAN
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own
adequate land [see Required Specification 2])
Tract Field Soil Crop RYE N Lbs. N Acres
tt Nn Tvna Factor Per Acre
Lbs. N Month of
Utilized ADDlication
11328
1aa
Wa ram
I Hybrid Bermuda Pasture - Grazed
5.5
37.5
206.25
0.90
185.63 Mar -Sea
11328
to
Wa ram
Hybrid Bermuda Pasture - Grazed
5.5
37.5
206,25
1.08
222.75
Mar -Se
11328
1 b
Wa ram
Millet - Grazed
5
41.25
206.25
2.28
470.25
Apr - Sep 15
11328
2a
Wa ram
Hybrid Bermuda Pasture - Grazed
5.5
37.5 206.25
0.65
134,06
Mar -Se
11328
2b
Wa ram
Millet - Grazed
5
41.25 206.25
1.21
249.56
Apr - Sep 15
11328
11a thru 2b
Wa ram
Small Grain Overseed
1
50 50
6.12
306.00
Oct - Mar
Total
6.12
1,568.25
See footnote for Table 1.
Totals from above Tables
Table 1
Table 2
Total
Amount of N Produced
Surplus or Deficit
Acres Lbs. N
Utilized
7.00 1,973.76
6.12 1,668.25
13.12 3,542.00
2,400.00
1,142.00
ark Acres shown in each of the preceeding tables are considered to be useable acres excluding required
qW buffers, filter strips along ditched, odd areas unable to be irrigated, and perimeter areas not receiving full
application rates due to equipment limitations. Actual total acres in the fields listed may, and most
likely will be, more than the acres shown in the tables.
41
NOTE: The Waste Utilization Plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient rich and will
require precautionary measures to prevent over application of nutrient or other
elements.
See the attached map showing the fields to be used for the utilization of waste water.
Page 3

0
Field
No.
WASTE UTILIZATION PLAN
Application of Waste by Irrigation
Soil Type Crop Application Application
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION,
HOWEVER A SIMILAR TABLE WILL BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for _180 days of temporary storage and the temporary
storage must be removed on the average of once every _6_Months. In no
instance should the volume of waste being stored in your structure exceed
Elevation *see lagoon staff gauges.
Call the local Natural Resources Conservation Service (formerly Soil
Conservation Service) or Soil and Water Conservation District office after you
receive the waste analysis report for assistance in determining the amount per
acre to apply and the proper application rate prior to applying the waste.
Narrative of operation:
Rate (In/Hr)
This facility utilizes a hard hose traveling irri ation reel and above around aluminum pipe.
The following denotes the methods of nutrient removal:
All of the Bermuda and millet produced on this site will be removed by grazing.
All of the small grain overseed will be removed by grazing.
Page 4

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1 Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or
has and agreement for use of adequate land on which to properly dispose of waste,
he/she shall provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for waste application. It
is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for
realistic crop yields based on soil type, available moisture, historical data, climatic
conditions, and level of management, unless there are regulations that restrict the
rate of application for other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year.
' Waste may be applied to land that is eroding at 5 or more tons, but less than 10
tons per acre per year providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application.
Waste should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to flooding. (See "Weather and Climate in North
Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not
cause drift from the site during application. No ponding should occur in order to
control odor or flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when
the surface is frozen.
Page 5

A. WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the
crop is not covered with waste to a depth that would inhibit growth. The potential
for salt damage from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste nutrient loading rates on these soils
should be held to a minimum and a suitable winter cover crop planted to take up
released nutrients. Waste shall not be applied more than 30 days prior to planting
of the crop or forages breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the
following: The outer perimeter of the land area onto which waste is applied from a
lagoon that is a component of a swine farm shall be at least 50 feet from any
residential property boundary and from any perennial stream or river (other than an
irrigation ditch or canal. Animal waste other than swine waste from facilities sited
on or after October 1, 1995), shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner no to reach other property and public right -of
ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or
wetlands by a discharge or by over -spraying. Animal waste may be applied to prior
converted croplands provided they have been approved as a land application site by
a "technical specialist". Animal waste shall not be applied on grassed waterways
that discharge directly into water courses, and on other grassed waterways, waste
shall be applied at agronomic rates in a manner that causes no runoff or drift from
the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
Page 6

0
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a
regular basis to prevent breakdowns, leaks, and spills. A regular maintenance
checklist should be kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for
direct human consumption. However, if animal waste is used on crops for direct
human consumption it should only be applied preplant with no further applications
of animal waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of
the temporary storage (pumping volume) of all waste treatment lagoons. Pumping
shall be managed to maintain the liquid level between markers. A marker will be
required to mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate -
determining nutrient, unless other restrictions require waste to be applied based on other
nutrients, resulting in a lower application rate than a nitrogen based rate. Zinc and
copper levels in the soils shall be monitored and alternative crop sites shall be used
when these metals approach excessive levels. pH shall be adjusted and maintained for
optimum crop production. Soil and waste analysis records shall be kept for a minimum
of five years. Poultry dry waste application records shall be maintained for a minimum of
three years Waste application records for all other waste shall be maintained for a
minimum of five years.
23 Dead animals will be disposed of in a manner that meets North Carolina
regulations.
Page 7
rtxr� „?.cx�::.:��'�:�".. ...�� -'� _... _ �.�i.' x �. z rw�. _ � _ �-�, x.- -� - .-.i .� • ^.e =� - .rs�rT - - -

0 WASTE UTILIZATION PLAN
1 r;
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Pope's Pig Palace
Owner / Manager Agreement
I (we) understand and will follow and implement the specifications and the operation
and maintenance procedures established in the approved animal waste utilization plan
for the farm named above. I (we) also understand that there must be
no discharge of animal waste from this system to surface waters of the state from a
storm event less severe than the 25-year, 24-Hour storm. The approved plan will be
filed on -site at the farm office, at the office of the local Soil and Water Conservation
District and the DWQ Regional Office.
Name of Facility Owner: Kay Pope
(please print)
Signature: 1.1 Date:
Name of Manager (If different from owner):
Signature:
Date:
Name of Technical Specialist: (please print) : Kevin Pore
Affiliation: Private Technical Specialist
Address (Agency): 91 Beaver Road, Clinton, NC 28328
Signature: - Date:
S-21-1.3
S_ - C9 1 1.,3
Page 8

0
0
WASTE UTILIZATION PLAN
ANIMAL WASTE UTILIZATION AGREEMENT
(Needed only if additional land has to be leased, etc.)
I, Kevin Poc:e hereby give Kay Pope (Pope's Pia_Palace�
permission to apply animal waste from his Waste Utilization System on 6.12 acres
of my land for the duration of time shown below.
I understand that this waste contains nitrogen, phosphorous, potassium, and other
trace elements and when properly applied should not harm my land or crops. I also
understand that the use of waste will reduce my needed for commercial fertilizer.
Adjacent Landowner: ' �' _ Date: S Z 13
Waste Producer: no.-L. Date:
Technical Representative: _ Date:
SWCD Representative:
Date:
Term of Agreement: May 2013 to May 2023
(Minimum of Ten Years on Cost Shared Items)
(See Required Specification No. 2)
Page 9

�J
0
0
EMERGENCY ACTION PLAN
PHONE NUMBERS
DWQ
EMERGENCY MANAGEMENT SYSTEM
SWCD
NRCS
10- 433-3360
C'l l
910 - qM 133 co _
'710- S 912- 7176'?
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or leave
your property to consider that you have a problem. You should make every effort to ensure that
this does not happen. This plan should be posted in an accessible location for all employees at the
facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
December 18, 1996

D: Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing
leaks- possible action:
a. Dig a small sump or ditch away from the embankment to catch all seepage, put in a
submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon bottom as soon
as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
40 c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
0
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality) regional office;
Phone A°'-103-V3 After hours, emergency number: 919-733-3942. Your phone call
should include: your name, facility, telephone number, the details of the incident from item
2 above, the exact location of the facility, the location or direction of movement of the
spill, weather and wind conditions. The corrective measures that have been under taken,
and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number - -
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number - - , local SWCD office phone number - - and
local NRCS office for advice/technical assistance phone number - -
December 18, 1996

Ll
4: If none of the above works call 911 or the Sheriffs Department and explain your problem to
them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site damage.
a.
b.
C.
Contractors Name:
Contractors Address:
Contractors Phone:
6: Contact the technical specialist who certified the lagoon (NRCS, Consulting Engineer, etc.)
a. Name:
b. 'Phone:
7: Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.
3 December 18, 1996
.. .. _ � ..r .� .._. w - . Y. .. — ... .... r, .,,an. a;?e-. � �.. `uz_"`fi.♦ 1+3-.. t. ���

0 0 0
Insect Control Checklist for Animal Operations
Source Cause BMPs to Control Insects Site Specific Practices
Liquid Systems _
Flush gutters • Accumulation of solids O Flush system is designed and operated sufficiently
to remove accumulated solids from gutters as
designed
0 Remove bridging of accumulated solids at
discharge _
Lagoons and pits • Crusted solids 0 Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the crusting
of solids to a depth of no more than 6 to 8 inches
over more than 30 percent of surface
Excessive vegetative . Decaying vegetation O Maintain vegetative control along banks of
growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter along
water's edge on impoundment's perimeter.
Dry Systems
Feeders • Feed spillage 0 Design, operate, and maintain feed systems
(e.g., bunkers and troughs) to minimize the
accumulation of decaying wastage
O Clean up spillage on a routine basis (e.g., 7- to 10-
day interval during summer; 15- to 30-day interval
during winter)
a
d'
AN11( Novcit7her 11, 1996, va-,c I

Insect Control Checklist for Animal Operations
Source Cause _ BMPs to Control Insects Site Specific Practices
Feed storage Accumulations of feed 0 Reduce moisture accumulation within and around
residues immediate perimeter of feed storage areas by
ensuring drainage is away from site and/or providing
adequate containment (e.g., covered bin for
brewer's grain and similar high moisture grain
products)
0 Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed
Animal holding areas • Accumulations of animal 0 Eliminate low areas that trap moisture along fences
wastes and feed wastage and other locations where waste accumulates and
disturbance by animals is minimal
O Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e., inspect for and remove or break up
accumulated solids as needed)
Dry manure handling • Accumulations of animal 0 Remove spillage on a routine basis (e.g.,
systems wastes 7- to 10-day interval during summer, 15- to 30-day
interval during winter) where manure is loaded 1br
land application or disposal
0 Provide for adequate drainage around manure
stockpiles
0 Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and manure
handling areas as needed
For more information contact:
Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University, Raleigh, NC 27695-7613..
AM1C - November 11, 1996, page 2

I
0 0
Swine Farm Waste Management Odor Control Checklist
Source Cause BMPs to Minimize Odor Site Specific Practices
Farmstead • Swine production O Vegetative or wooded buffers
O Recommended best management practices
O Good judgment and common sense
Animal body • Dirty manure -covered 0 Dry floors
surfaces animals
Floor surfaces
Wet manure -covered floors
0
Slotted floors
0
Waterers located over slotted floors
O
Feeders at high end of solid floors
O
Scrape manure buildup from floors
0
Underfloor ventilation for drying
Manure collection
• Urine
O
Frequent manure removal by flush, pit recharge,
pits
• Partial microbial
or scrape
decomposition
O
Underfloor ventilation
Ventilation exhaust
. Volatile gases
O
Fan maintenance
fans
• Dust
0
Efficient air movement
Indoor surfaces • Dust O Washdown between groups of animals
0 Feed additives
0 Feeder covers
0 Feed delivery downspout extenders to feeder
covers
Flush tanks • Agitation of recycled lagoon 0 Flush tank covers
liquid while tanks are filling 0 Extend fill lines to near bottom of tanks with
anti -siphon vents
Flush alleys • Agitation during wastewater 0 Underfloor flush with underfloor ventilation
conveyance
AMOC - November 11. 1996. dace 1

Swine Farm Waste Management Odor Control Checklist
Source Cause BMPs to Minimize Odor Site Specific Practices
Pit recharge points • Agitation of recycled lagoon ❑ Extend recharge lines to near bottom of pits with
liquid while pits are filling anti -siphon vents
Lift stations • Agitation during sump tank ❑ Sump tank covers
tilling and drawdown
Outside drain • Agitation during wastewater ❑ Box covers
collection or junction conveyance
boxes
End of drainpipes . Agitation during wastewater ❑ Extend discharge point of pipes underneath T
at lagoon conveyance lagoon liquid level
Lagoon surfaces • Volatile gas emissions
• Biological mixing
• Agitation
Irrigation sprinkler • High pressure agitation
nozzles . Wind drift
Storage tank or • Partial microbial
basin surface decomposition
• Mixing while filling
• Agitation when emptying
❑ Proper lagoon liquid capacity
❑ Correct lagoon startup procedures
❑ Minimum surface area -to -volume ratio
❑ Minimum agitation when pumping
❑ Mechanical aeration
❑ Proven biological additives
❑ irrigate on dry days with little or no wind
❑ Minimum recommended operating pressure
❑ Pump intake near lagoon liquid surface
❑ Pump from second -stage lagoon
❑ Bottom or midlevel loading
❑ Tank covers
❑ Basin surface mats of solids
❑ Proven biological additives or oxidants
AMOC - November 11, 1996, page 2

0
9 0
Source
Settling basin surface
Swine Farm Waste Management Odor Control Checklist
Cause
• Partial microbial
decomposition
• Mixing while filling
• Agitation when emptying
BMI's to Minimize Odor Site Specific Practices
Cl C;xtend drainpipe outlets underneath liquid level
O Remove settled solids regularly
Manure, slurry, or
• Agitation when spreading
0
Soil injection of slurry/sludges
sludge spreader
• Volatile gas emissions
C3
Wash residual manure from spreader after use
outlets
C3
Proven biological additives or oxidants
Uncovered manure,
• Volatile gas emissions while
C3
Soil injection of slurry/sludges
slurry, or sludge on
drying
C3
Soil incorporation within 48 hours
field surfaces
0
Spread in thin uniform layers for rapid drying
0
Proven biological additives or oxidants
Dead animals
• Carcass decomposition
0
Proper disposition of carcasses
Dead animal disposal
• Carcass decomposition
C3
Complete covering of carcasses in burial pits
pits
O
Proper location/construction of disposal pits
Incinerators
• Incomplete combustion
0
Secondary stack burners
Standing water
• Improper drainage
0
Grade and landscape such that water drains away
around facilities
• Microbial decomposition of
from facilities
organic matter
Manure tracked onto • Poorly maintained access O Farm access road maintenance
public roads from roads
farm access
AMOC - November 11, 1996, page 3

Additional Information:
Swine Manure Management; .0200 RuleBMP Packet
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge —Lagoon Treatment; EMAl 128-88
Swine Production Facility Manure Management: Underfloor Flush —Lagoon Treatment; l;BA1? 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBA1; 103-83
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
Controlling Odors from Swine Buildings; PIH-33
Environmental Assurance Program; NPPC Manual
Options for Managing Odor; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedings
Available From-
NCSU, County Extension Center
NCSU—BAE
NCSU—BAE'
NCSIJ—BAE
NCSIJ—BAE
NCSU—BAE
NCSIJ—Swine Extension
N.C. Pork Producers Assoc.
NCSU Agricultural Communications
Florida Cooperative Extension
AMOC - November 11, 1996, page 4

Version —November 26, 2018
Mortality Management Methods
Indicate which method(s) will be implemented
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
® Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.1O6-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
® Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
o Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Signature of Farm Owner/Manager
Signature of Technical Specialist
Date

APR 0 2 2019
Mr. Alton Pope
Please review the attached plan and specifications 'carefully. Retain this plan
for your use and records. It is strongly recommended that you, your contractor
and Soil Conservation Service personnel are in agreement as to how the waste
lagoon is to be constructed . SCS personnel will meet with all concerned parties
and walk over the site to explain all flags and markings. 'It is important thar-
everyone understand what
is expected so that final construction
meets plans and
specification and the job
can be certified for payment (if ACP
cost shar4- i�
involved).
Contact: Soil Conservation Service
303-D East Rowan ST.
Clinton, N.C. 28-928
Phone [phone]
SPECIAL NOTES
Core to be dug at any area below fluid level. The core will
wide and to a depth down to sandy clay material. _
Topsoil will be stock piled to be later used on top of da-, siz7c-z
around houses. r
Planned capacity of treatment lagoon 300,583 cu. rt.
Amount to be excavated 3'723 cu. yd.
40 Amount to be used in embankment 3491 cu. yd.
Inside top dimenstions 3431 x 123T x 121

W.
qw,
ILI.
5 41
WA
All
'QW
4 S .
ar.
Iq
-ne
I W
YfAl
all
- - - - - - - - - -------

SCS-ENG-538 U. S. DEPARTMENT OF AGRICULTUR
Rev. 5-70 SOIL CONSERVATION SERVIC
■
9
SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITE
FARMER'S NAME A., •.
K V COUNTYi f P
WORK 1
WATERSHED AREA MEASUREMENTS
CROPLAND -ACRES PASTURE-ACRESv I) 14oasoN
WOODLAND -ACRES TOTAL -ACRES POND CLASS WORK UNIT CONSERVATIWIST
■■■
■■
MEN■■■
■■MILS■■
■■■■■
■■■■1■■■
■
■
M■■
■■■
■
■■■��■
■■■■
■■■■■■�■■■■■■■
■■■■■
■■
■■■
■■■■■
■■■
■■■■■n■■■
■■■■■■
■■■■■■■■■■■■■■■■■■■
■■■■■■■■■
HMI■■■■■■■■■■
OrDI
DI©I�I�Il7�fm!®1®Iml®I®Iml®Imlml�l®I�l.
®�I■I■I■I■1■I
I
■f■I■I■I■I■I■I■1■!■l■1■I■I■
®■11■I■I■I■1■I�I�■!■a■1■i■I■I■I■I■■!■i■1■i■1
®_�I■1■1■I■I■i■�■■I■�■I■I■i■I■I■I■I■1■i■1■1■1
®�I■�I��I�I�f��!�1�1�1■I�1�1■i■I■1■i■!■I■
®m!■�I�I��E�1�l�l�l�I�I�i�l�■I�I�I�Itl���l��
■!■I■I■I■I■I■I■�
I■!■I■i■:■1■I■i■i■�■1■I■�■i
�■
I■I■I■I■I■I■i�l■I■I■I■■i■!■�■I■I■■G■1■
��I■�■l■l■I■I■■l■I■i■!■
■I■f■I■I■C■!■■

Date December 3, 1985
ANIMAL WASTE MANAGEMENT PLAN
Mr. Alton Pope
SAMPSON COUNTY
INTRODUCTION
Mr. Pope plans to construct a 500 sow farrow to feeder operation contracting
with Murphy Farms. He plans to construct a one stage recycle flush system.
Mr. Pope has adequate land to meet the requirments for animal waste application.
SITE CONDITIONS
The site is located on Wagram loamy sand 0-6% slope. Their are no houses located
within 1400 feet of site.
PROPOSED PLAN
The system will consist of a treatment lagoon. Effluent from the hog house will
be flushed into the treatment lagoon. Anerobic activity will take place here.
Once the effluent reaches the relative elevation of 52.0 it will need to
be applied to the land. The lagoon will.be excavated with a 2 i
slope. All dams or dikes will have a combined slope of 5:1 with a 12
foot minium top width. The landowner will be responsible for obeying all local,
Gr=rpm and national laws and securing necessary permits.
All disturbed areas to be established in permanent vegetation. The following
grass will be established.
Prepare a suitable seedbed. Stockpile topsoil during construction
and place it in a 2" - 4" layer over dam and slopes if at all possible.
Apply lime at a rate of 100 lbs./1000 sq. ft. or 2 Cons/acre• Apply
fertilizer (10-10-10) at a rate of 20 lbA./1000 sq. ft. or 1000 lbs/ac.
Seed with tall fescue (KY-31) at a rate of 1.5 lbs./1000 sq. ft. or 50
lbs./acre. Run a cultipacker or other suitable equipment over area to
place seeds into ground. Seeding dates are February-`Marchrand
September - October.
X Establish in coastal or common bermudagrass. Sprigs may be broadcast
onto a suitable seedbed. Approximately 50 bushels of sprigs -is recom-
mended per acre. Disk in sprigs and use a cultipacker or other suitable
equipment to firm the soil after planting. Apply lime at a rate of 90
lbs./1000 sq. ft. or 1.5 tons per acre. Apply fertilizer (5-10-10 or
10-10-10) at a rate of 10 lbs./1000 sq, ft. or 500 pounds per acre.
Apply additional nitrogen as needed.
When seeding with common bermuda use 10 lbs. of hulled and seed in
April -July or 20 lbs. of unhulled and seed in January - Ilarch.

The maxium and minmum design levels for the lagoon is as follows:
MAXIUM DESIGN LEVEL
= Relative Elevation 52.0
= Invert of Pipe Discharging
into the Lagoon
MINIMUM DESIGN LEVEL
= Relative Elevation 46.0
Feet Below Discharge
Pipe
Disposal by land application is to be started before the fluid level in the lagoon
reaches the maximum design level. Removal of the effluent is to be stopped at or
above the minimum design level. It is recommended that effluent be pumped from the
lagoon both for flushing and land disposal. This lagoon is designed for waste treat-
ment.
OPERATION AND MAINTENANCE PLAN
1. Keep vegetation on embankment. and areas adjacent to the lagoon mowed.
2. Repair eroded areas and vegetate.
3. Apply lime and fertilizer annually or as needed.
4. It is strongly recommended that the treatment lagoon be precharged to
one-half of its capacity to prevent excessive odors during startup.
Precharging reduces the concentration of the initial waste entering the
lagoon thereby reducing orors.
5. Recommend that a suitable fence be constructed around the lagoon for
safety purposes.
.:sir ......a. _!v� �. ..a-. -� �: s.,� aa. �,... ,.�y > . . �-s�.... ^ar _� .., �. -. 'ri . _ �-.. rra:•. "A; - -��• '.��r�; �'r- : r

USDA-SCS
Raleigh, N. C.
Rev. 2/82
ANIMAL WASTE MANAGEMENT SYSTEM
Engineering Design Work Sheet
Field Office CLIN7-0M Design by CLIFiaN Date /z-3-Ss
Owner's Name ALTon! !°oPE r z c L 1 N'fo4 N, c. z83zs 5 33 - 3z5o
Location aPPROK . Z M1LE5 E ae P/Ne RIDGE ON S.R. /9"7
(attach watershed location sketch)
Population (est) within 1/4 mi. H oNe No. of inhabited houses within
1/4 mi. NONE Distance to nearest inhabited house other than
operator's 1 400
Type of livestock Type of operation (check one)
Farrow to finish Farrow to feeder pig ✓ Finish Other_
Type of confinement facility (flush, pit, number of houses, dimension.of
houses, etc.) r-j-UsH 77: ,err
Type of waste treatment: Anaerobic lagoon & holding pond, v�, Anaerobic
lagoon with holding volume.. ✓ holding pond pit or tank
other
Method of handling waste when design capacity is reached (i.e., pump & irrigation,
4
honeywagon, etc.) Pump A
La oon & Storage Desiqn Data
Type, number, and sizes of livestock:
O
Total No. for design
Soo sows x 5zz lbs = ZGI.Poolbs
boars x lbs = lbs
}
pigs x lbs = _ lbs
pigs x _1bs = lbs
or: Total lbs for design _ Z co r o o o _ lbs.
�.+.0 �.... ..... ... .,.e ..mow. ..+ ... .u. .. ., w _.. .r ^ Y;• �:$.4�% L .V '.. !4'E+e ^Sf';M2 ..{�.. ..... 4..;�3c.�....r 2 as�e.:.�.9 a.5-s. �.'S

-2-
Desi
Capacity for Anaerobic Lagoon Treatment and Odor Control
Use cu. ft./lb. or cu. ft./animal
(ibs) or (animals) x (cu.ft./lb) or (cu.ft./animal) _
cu. ft.
2. Estimate size of lagoon:
cu. ft.
Desin.n for Holding Pond
length
x x w/ ss =
wwi th ~ _'epth
Design period 15rO days. (Longest anticipated period before pumpout)
25-year storm 7" inches. Normal precipitation less evaporation
for design period 7— inches.
Waste production = lbs/day/lb. live wt.
3. Volume of waste =2EWoolbs. live wt. x .o o /3 5 lbs./da /lb.ly. wt.
62,4 Ibs/cu.ft.
x C20 days = _�3I -7 1, Zo,cu. ft.
4. Volume of wastewater = al/day/animal x animals
7.5 gal cu.ft.
x _ days = cu. ft.
5. Normal precipitation less evaporation on lagoon surface for design period =
,2. in. x__-3�_u ft. x !23 ft: - 7p32, cu, ft.
12 in/ft length wrath -
6. Normal precipitation less evaporation on holding pond surface for design period =
inches x ft. x ft. = cu. ft.
12 in/ft ___ length width
e
7. Storage required for 25-year storm on lagoon surface =
7 in. x 34,3 ft. x IZ3 ft. _Y.��o cu. ft.
12 in/ft ength� width
8. Storage required for 25-year storm on holding pond surface =
-- -- in. x ft. x _ ft. _
12 in/ft length width f -- ----T�
Fool oF- ST<nRA(�E
cu. ft. d
343 ' X 123' x I' = 4Z 1813 Cu. FT,

-3-
9. Total capacity needed for holding pond (add Vs 3, 4, 5, 6, 7, & 8) _
5874,+ cu. ft.
10. Total capacity needed for treatment lagoon (add #Is 1 & 9 when treatment
lagoon & holding pond are one component) = Z 9 9 74`f cu. ft.
Planned Capacity for Treatment Lagoon
335 ft. x 1 1 5 ft. / o ft.' w/ 2 r ss =
avg. length avg. width avg. dept
300 J g � cu. ft.
Planned Capacity for Holdinv Pond
ft. x ft. x ft. w/ ss =
avg. e_nggt ` avg. w t avg. epth
cu. -ft.
Desi n for Disposal'Area
Annual nitrogen production in fresh waste =
_ lbs N/lb/day x lbs live wt. x 365 days = lbs. N
Assume % N loss during anaerobic lagoon treatment, storage & land application.
Estimated N available for crop _ lbs x_ % = , lbs.
Type of vegetation or crop to be grown at the disposal site
Timing and rate of application
Estimated acres needed for effluent disposal
75% N. LOSS
CORN LANb NEEDEZ C9. I l AC f Sow x 500 SOWS = 55 Ac. .
COASTAL 45F_PRMUZ)A LAND NEEDED .OLf AC/5ovv K SOO Saws = .Z-O RC

1-0 N PC-
PLANNE-ll CAPACITY FcDfZ TREWrMe -r -I.Ar
555 �c
Z?-) z
Qa TS Fr-'

SAMOSON Ca
0
0
LAND APPLICATION DATA
31-7EZ, Cubic feet of waste 90
days
+ '703z Cubic feet of normal precipation/180 days
-- 387i'!-+ _ Total Cubic Feet
X 7.48 Gal/cubic foot
z 9 s Total gallons to be applied in90
NO days
X y'2 Two periods of 180 days
Total gallons to be applied/year
NUMBER OF TRIPS FOR A 1000 GALLON,HONEY WAGON:
--
! I 59ZZ Total Rallons —
1000 gallon/trip Trips
1 1 Trips X .5hrs/trip =
5 8 Total Hours
NUMBER OF HOURS RE IRED FOR SPRINKLER IRRIGATING:
289 Total Gallons —
3cco Gallon X 60min/hr. — + Total Hours
I8000 CGAi IHR.
The above is only a guide to be used for estimating the cr:
in land application of water.

U. S. DEPARTMENT OF AGRICULTURE
Soil Conservation'Service
LOCATION CODE
11
PLAN OF EXCAVATED WASTE STORAGE POND
I
NAME i o . c ACP #
NGTH
NC-ENG-40
5/83
DATE DISTRICT SrttllPSCl�
ri
i
SIDE SLOPE Z TO 1 /
AVE. TOP ELEV.
�p ti0
2 /
/
� � /\+�o �Z•O'AVE. BOTTOM ELEV. %
r.
LENGTH ."7S'
Volume = depth area of top) + (area of bottom) + (4 x area midsection] =_ Cr Cu. Ft.
6
Use of facilityyjA sT` -rR1EA'T/ACf/4`r
Capacity ?,may.-r 5C�;1 Gallons
Volume Cost -sharing
Cu. Ft.
Soil type I&A .i kA&I
B. M. description NAIL. ) N y-" C-14EA2 v
L F M 4,C K eZ2 ;ate e I FL F3 E: /4
Elev. 5,r�. o e�
9
SUMMARY
Bottom
Elev.
Z,
Normal liquid level
Elev.
Storage for normal precip.(Ft)
+ -
Maximum liquid level
Elev.
Storage for:
25 yr. freq. precip.
(Ft.)
+ I. C
Crest ESW
Elev.
-
Stage (Ft.)
+ -
Freeboard (Ft.)
+ I:C
Top of Dam
Elev.
5 14. C%
a ..

0 0
TYPICAL VIEW OF A ONE -STAGE LAGOON SYSTEM
Confinement Building J Top Width 12'
Pit
" Pipe (Needs to be adequately
supported)
Fluid Elevation 5Z.0
ii
n
�i SS Z.:�_ SS
/TREATMENT
LAGOON
Depth = )G'
Bottom Elevation '+7-.0
Settled Top Elevation 5,+. C)

0
U. S. DEPARTMENT OF AGRICULTURE NC-ENG-12
Soil Conservation Service Rev. 6/82
EARTHWORK COMPUTATION SHEET
EMM R��
E 1cC� v P,T! c3 N
Name L >`ToN 4)OPC
Address R7 Z CL►NTonl NC
Embankment: Top Width Side Slopes
STATION
FILL
HEIGHT
(Feet)
SUM OF
END AREA END AREAS DISTANCE
(Sq.Ft.) (Sq.Ft.) (Feet)
O -7 � )
7'+ I )5 ry
770
I C; 00
-77 O Oo
.7 `f 5
-7 -7 `+S I
DOUBLE
VOLUME
(Cu.Ft.)
O+oe
( 1 1 1 5
O 15
1 Z.O 0
©fi9�
1 S 1h000
+9
I i 00
+s
+ 10
! I 1 7
tZ5
-7,o a
Double Volume of Fill i 2 = . ;,3551 O Cu. Ft.
Volume of embankment fill (line 1 j 27) = S 7 23 Cu.
Allowance for settlement (5 or 10% of line 2) _
Total cubic yards (line 2 + line 3) = Cu.
Yds.
Cu. Yds.
Yds.
Computed by Low v �i1 Date 1 2 - 0 - �5

1 0
0
U. S. DEPARTMENT OF AGRICULTURE
Soil Conservation Service
EARTHWORK COMPUTATION SHEET
EARTH EMBANKMENT
Name AL7oN PoPE
Address P,-r Z CL-it4-FON r-)C,
Embankment: Top Width i Z'
Side Slopes 767-AL-
NC-ENG- 12
Rev. 6/82
STATION
FILL
HEIGHT
(Feet)
E , ND AREA
(Sq.Ft.)
SUM OF
END AREAS
(Sq.Ft.)
DISTANCE
(Feet)
DOUBLE
VOLUME
(Cu.Ft. )
C)
4?_0
4-, 0
*?_9
6.0
I Z
:3 Z Y
3
4 +GG
G.0
750
5+2-1
ro
q3
LP
c� 2-
Z10
3
-Zf5z
1. Double Volume of Fill + 2 7 Cu. Ft.
2. Volume of embankment fill (line 1 + 27) Cu. Yds.
3. Allowance for settlement (5 or � of line 2) Cu. Yds.
4. Total cubic yards (line.2 + line 3) = Cu. Yds.
Computed by Pate 30- 8,5_

r } - i
__ I
' ,
tt
_44
't �'t } + �. t� 1. +� tip, I �t
.,1-_-1 t-��- - } •-r- � •r t i-rl j y T.�-{ �r - t'�_ }.,�..�_1 ! �+ i - -� ir�-1 �t
{-
1
L �
- -�--- �r.4D---� - --�51� ••----•---- -�- •--,-.56.ro - .. 56.a - _.55,7 __—. -��- -- •- •---•-_. �-�-------- -i - --�
4-4
2.r00
123
RLTOnI -
Po06
A.W. L-AGOOj
SAMP6oN Co.
Ot00 .. '•FAL .. _7_ '. _ H5�8 .._ .. _ 46�Z . _ ....._--� T� . i {. _ •..1 • . - . a`:.T _.._ SNSIDE TOP 'g CA L+% I" =SQL_ - - . Cr✓/r /o.v 11-85 ..
9 0 0

3
r
v45;o
_ A
I � Y
7T _
.._.. ----.-'r .v---.,. __-._ _t ,� __-�,-;�- `-�F � ' ,-•� -.•- T-,. � --�-�- #-�-* _ -;.- PLToN POPE
-,- t
d A. W. LAGOON
+ 1-+,• + -4j i - SAHAP50
. -. { .� i - I_1 1 -t• rt{ - - - H1.
U. S-DEPARTMENT OF AGRICULTURE
i t
SOIL CONSERVATION SERVICE
�. It
4 Y ;r } K� ti }#F {{r1,f �f "F - t1t-,4 -._--.—._b�A-- —
�+1 - t-'
"J-Ha-N i
;»-'
.... �. .
4 t. .

+f5.o
5 to
ELEV. SZ,O rLUiD LEVEL
a.. i
f
t_I. iEp_,4... 1 !- —i- 4 AL i oN POPE `
A.vJ. LAGOON
h- i SAMPWN Co.+ + }1-_�--{_..—..__.-�-._.-----_--_----
U. S. DEPARTMENT OF AGRIC LIT URE
I
i-1 .. SOIL CONSERVATION SERl'ICF
--'----
i
r
---._
0

554
am"
770 SR F-r
A L-ro N POP F-
Aral, L-AGOON
i-f t4. --i -
Fm�
4
47Lt - U. S. DEPARTMENT OF AGRICULTURE
I I + SOIL CONSERVATION SERVICE
14-
T r

7-10 SQ FrT
Dtoo I t0-0 Zr o
L= J'A il At -TON PO PE
A, W, LAGOON
1 4,
14 S.
�:OIL CONSERVATIONSERVICE
71 -1 T. t
t 1 t
'1 6-
I
T.
.a

0
-7 45 SQ 7r.
0
I ti�e. 1�
AL -ro 4 P- Pe.
A , vJ. LA Cqoo tj
r 1
SAM PEON Co,
t,
14i -
U. S. DEPARTMENT OF AGRlf L UPURE
SOTT, CONSERVATION SERV-7
t
4
id
4 4
7i

OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment with minimum odor control. The
time required for the planned fluid level to be reached may vary due to soil
conditions, flushing operations; and the amount of fresh water added to the
system.
Land application of waste water is recognized as an acceptable method of dis-
posal, Methods of application include honey wagons (sprayer or injection) and
irrigation (center pivot, guns, or travelers). Care needs tc be taken when
applying waste to prevent damage to crops or runoff from the field.
The following items are to be carried out:
1. Begin pump -out of the lagoon when fluid level is 1 foot below the
outlet pipes.
2. Stop pump -out before fluid depth is less than 3 feet deep (this
prevents the loss of favorable bacteria).
3. It is strongly recommended that the treatment lagoon be precharged
to 2 its capacity to prevent excessive odors during startup. Pre -
charging reduces the concentration of the initial waste entering
the lagoon thereby reducing odors.
4. Keep vegetation on the embankment and areas adjacent to the lagoon
mowed.
5. Repair any eroded areas and establish in vegetation.
6. Recommend that a suitable fence be constructed around the lagoon
for safety purposes.
7. The Clean Water Act of 1977 prohibits the discharge of pollutants
into waters of the United States. The Department of Natural
Resources and Community Development (DNRCD) - Wastewater Management
Section has the responsibility for enforcing this law:
NOTE: An analysis of the waste water can be obtained at commercial
laboratories or at a fee of $3 per sample at:
N.C. Department of Agriculture Plant Analysis Lab
Agronomic Division
Blue Ridge Road Center
Raleigh, N.C. 27611
Ph. [phone]
0