820449_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
mast be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 82-0449 Certificate Of Coverage Number:
2. Facility Name: P-12 A-D
3. Landowners Name (same as on the Waste Management Plan): Prestage Farms Inc
4. Landowner's Mailing Address: PO Box 438
City: Clinton State: NC
Telephone Number: 910-596-5749 Ext. E-mail: glenneteprestggefarms.com
5. Facility's Physical Address: 901 Pig Nose Ln
City: Roseboro State: NC
6. County where Facility is located: Sampson
7. Farm Manager's Name (if different from Landowner):
g. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"):
10. Operator Name (OIC): James Elton Weeks
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type
Swine - Farrow to Wean
Operation Types:
Swine
Cattle
Wean to Finish
Dairy Calf
Wean to Feeder
Dairy Heifer
Farrow to Finish
Milk Cow
Feeder to Finish
Dry Cow
Farrow to Wean
Beef Stocker Calf
Farrow to Feeder
Beef Feeder
Boar/Stud
Beef Broad Cow
Gilts
Other
Other
Prestage Farms Inc
Phone No.: 910-305-0420
Allowable Count
4,800
AWS820449
Zip: 28329
Zip: 28382
OIC #: 1003320
Dry Poultry
Other Types
Non Laying Chickens
Horses - Horses
Laying Chickens
Horses - Other
Pullets
Sheep- Sheep
Turkeys
Sheep - Other
Turkey Pullet
Wet Poultry
Non Laying Pullet
Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
'Redline"
(Inches)
A
22.60
B
19.00
C
19.00
D
4LI7gg0
19.00
P12A-A
1 9q !
Glq
69,696.00
P12'A-B
! qn7 y
C 14
3 4 u 0 b 0
52,272.00
P12B-A
/ 9t3 1
r, 14t('7
�e�q p
60,984.00
P12B-B
/ q q
C 1,4
3 b S 8 "d 0
52,272.00
P12C
99 r i99
7 70 7(, .
104,544.00
P12D
99J /99Y
C1 6
81329N
100,188.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.1OC(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), signed by the owner and a certified technical sliecialist_, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.613, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name: &GI ���G�,�J./ I��� Title: lV,./ r St44:4Ui= f ,w)'
Signature: lff Date:
Name:
Signature:
Name:
Signature:
Title:
Date:
Title:
Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: 2019PermitRenewal@ncden r.gov
FORM: RENEWAL -STATE GENERAL 02/2019

WASTE UTILIZATION PLAN
c Producer-----:Prestage Farms, Inc. County:Sampson
Name of Ferm-:P-12 A-D
Location-----:P. O. Box 436
Clinton NC 28329
Phone -------- :910-592-5771
Type Operation ------------- :FAR -WEAN
Number of Animal ----------- : 4800
Storage Structure ---------- :Anaerobic Lagoon
Method of application ------ :Irrigation
Amount of waste..produced per year --------------- : 29252 tons/year
Amount of plant available N (PAN) produced/year-: 25920 lbs./year
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be use
to reduce the amount of commercial fertilizer required for the
crops in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle.
Annual soil teats are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of the
waste and to ensure that it is applied in an environmentally safe
manner:
1. Always apply waste based on the needs of the crop to be grown
and the nutrient content of the waste. Do not apply more
nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall not be applied to land eroding at more
than 5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining, or
when the surface is frozen. Either of these conditions may
in runoff to the surface waters which is not allowed under DWQ
regulations.
5. Wind conditions should also be considered to avoild drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production and
to reduce the potential for pollution, the waste should be
applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise
this plan. Nutrient levels for different application methods are
not the same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have

Page 2
plant analysis made, which could allow additional waste to be
applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content
and the crop type. Lime must be applied to maintain pH in the
optimum range -for specific crop production.
This waste utilization plan, if carried out, meets the
requirements for compliance with 15A NCAC 2H .0217 adopted by the
Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract Field Soil Crop Yield Lbs. N Acres Lbs. N Month to
No. No. Type Code /Acre /Unit Used Apply
10316 8 CaB B 4 50.00 28.4 5680 MAR-OCT
10316 8 CaB K N/A 50.00 28.4 1420 S-APRIL
10316 9 CaB B 4 50.00 55.9 11180 MAR-OCT
10316 9 CaB K N/A 50.00 x 55.9 2795 S-APRIL
10316 10 CaB B 4 50.00 23.0 4600 MAR-OCT
10316 10 CaB K N/A 50.00 23.0 1150 S-APRIL
----- ----- ----- ----- ----- ----- ----- ----- ------
Total 107.3 26825
Available Nitrogen (includes commercial) 25920
Surplus Or Deficit -905
Crop codes: Crop -unit
A=Barley-bu.
B=Bermudagrass(graze)-tone
C=Bermudagrass(hay)-tone
D=Corn(grain)-bu.
E=Corn(silage)-tons
F=Cotton-lbs. lint
G=Fescue(graze)-tans
H=Fescue(hay)-tons
I=Oats-bu.
J=Rye-bu.
K=Small grain(grd7e)-acre
L=Small grain(hay)-acre
M=Sorghum(grain)-cwt.
W=Wheat-bu.
Y=Fescue(pasture)-tons
Z=Bermudagrass(pasture)-tone
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a'timely
manner.

The applicator is cautioned that P and K may be over applied while
meeting the N requirements. In the future, regulations may require
farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only
�• addresses nitrogen.
In interplanted fields (i.e. small grain, etc, interaeeded in
bermudagrass), forage must be removed through grazing, hay and/or
silage. Where grazing, plants should be grazed when they reach a
height of six to nine inches. Cattle should be removed when plants
are grazed to a height of four inches. In fields where small grain
etc, is to be removed for hay or silage, care should be exercised
not to to let small grain to reach maturity, especially late in
the season (i.e. April or May). Shading may result if small grain
gets too high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced yields and
less nitrogen being utilized. Father than cutting small grain for
hay or silage just before heading as is the normal situation, you
are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the
season, depending on time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September
or early October. drilling is recommended over broadcasting.
Bermudagrass should be grazed or mowed to a height of about two
inches before drilling for best results.
Caution must be exercised in grazing or haying summer annuals
under stressed conditions. Nitrate poisoning may occur in
livestock. Sampling forage or hay for nitrate levels is
recommended.
Acres shown in the tables are considered to be the usable acres
excluding required buffers , filter strips along ditches, odd
areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the field listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization
of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provision for periodic
land application of sludge at agronomic rates. The sludge will be
nutrient rich and will require precautionary measures to prevent
over application of nutrients or other elements. Your production
facility will produce approximately 4032 lbs, of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years, you will have approximately
20160 lbs. of PAN to utilize. assuming you apply this PAN to
hybrid bermudagrass hayland at the rate of 300 lbs. of nitrogen
per acre, you will need 67 acres of land. If you apply the
sludge to corn at the rate of 125 lbs. of nitrogen per acre, you
will need 161 acres of land. Please be aware that these are
only estimates of the PAN and land needed. Actual requirements
could vary by 25% depending on your sludge waste analysis, soil
types, realistic yields, and application methods.

Page 4
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate
of the soil at the time of irrigation such that runoff or ponding
occurs. This rate is limited by initial soil moisture content,
soil structure, soil texture, water droplet size, and organic
solids. The application amount should not exceed the available
water holding capacity of the soil at the time of irrigation nor
should the plant available nitrogen applied exceed the nitrogen
needs of the crop.
If surface irrigation is the method of land application for this
plan, it is the responsibility of the producer and irrigation
designer to ensure that an irrigation system is installed to
properly irrigate the acres shown in tables. Failure to apply the
recommended rates and amounts of nitrogen shown in the table may
make this plan invalid.
The following table is provided as a guide for establishing
application rates and amounts.
Tract
Field
Soil
Crop Applic
No.
No.
Type
Rate
(inlhr)
I o 31 L
8
Cag
0 31
—9
Ca Q
Cg-Czed1� o
10316
10
CaQ
c.g-GeAt� , by
Applic
Amount
(inches)
•9'S
.9c
This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations the application amount shown cannot be
applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.

Page 5
Your facility is designed for 180 days of temporary storage and
the temporary storage must be removed on the average of once every
6 months. In no instances should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or
one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply
the correct rates to the acres shown in the tables. Failure to
apply the recommended rates and amounts of nitrogen shown in the
tables may make this plan invalid.
Call your technical specialist after you receive the waste
analysis report for assistance in determining the amount of waste
per acre and the proper application rate prior to applying the
waste.
NARRATIVE OF OPERATION
RECEftMDWC ;;=WR
APR 03?019
wSWQueily
Regional operavonsSedon

RECEIVED NCZEMWR
ROY COOPER
Governor
MICHAEL S. REGAN
Secretary
LIND7A CULPEPPER
s rar
StATE
NOt2'tHGAROLINA
Enriranmentat Quality
February 27, 2019
Prestage Farms Inc
P-12 A-D
PO Box 438
Clinton, NC 28329
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
APR 0 S ?-Pig
WaterOUIRy
Regional 6peratio"SSection
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at htt s://de .nc. ov/about/divisions/water-resources/water ualit% -rev ional-o erations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure vour continued covers a under the State Non-Discharee General Permits. , ou must submit an mlication for
permit coverage to the Division. Enclosed you will find a 'Request for Certificate of Coverage Facility Currently Covered b►� an
ENRiring State Non -Discharge General Permit." The application form must be completed. signed and returned by_ April 3, 2019.
Please note that you must include one ill co v of the Certified Animal Waste ManRmcment Plan CAWMP with the
completed and, sinned application form. A list of items included in the CAWMP can be found on page 2 of the renewal.
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Sincerely,
A OP �'�
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Enclosures
cc (w/o enclosures): Fayetteville Regional Office, Water Quality Regional Operations Section
Sampson County Soil and Water Conservation District
AFOG Section Central Files - AWS820449
Prestage Farms Inc
Nt n''-Ca^ Q091% ( "i='a�ofY:eter�,esc cues
512 N.5i .yb.y() 3t. 1163SVa ".at-rr, wa-:.erter I Rae•gt,Nzrtt rare'^a27et9-MG
- — . 312.737.3333

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. An_imal waste shall not reach surface waters of the sta`e by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the,operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runof= leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed to soil
infiltration rate such that runoff does not occur offsi"e or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to contrcl odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would in=bit growth. The potential for salt damage from animal
waste shculd also be considered.

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than-100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly inton water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsibly fcr obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be re.cru.ired to mark the maximum storage volume for waste
storage ponds.
�'. 22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when thes
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina requlations.

Page 6
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: P-12 A-D
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of
the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water duality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to the surface waters
of the state from a storm event less severe than the 25-year, 24-
hour storm. The approved plan will be filed on -cite at the farm
office and at the office of the local Soil and Water Conservation
District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Prestage Farms, Inc.
(please print)
-� Signature:'t'RE3TA6E FARtitiS,xr�C^., �.I��.�t,_ti.� Date:�3�97
U
Name of Manager(If different from owner):
Signature:
Name of person Preparing Plan:
(Please print:)
Affiliation: Prestage Farms, Inc.
Address: P 0 Box 438
Clinton NC 28329
n
Signature: AK
te:
G. Glenn Clifton
Phone: [phone]
Date. 5113 37

3/19/2019 Prestage Farms Swine Locations App
51-re Ake
M
SpakyF1rths
0.2mi
NC CGIA, USDA
— - ddiiii
https://pfi.maps.arcgis.com/appslwebappviewerlindex.html?id=bcd3l c72d7dO4bceacg388b38ba3l 6e6 1I1

SA1Vtl'SON COUNTY
EMERGENCY ACTION PLAN_
D-NISION, OF WATER RESOURCES,: EDWRY 910=433-3300
EMERGENCY MANAGEMENT SERVICES (EMS) 910=592-8996
SOIL & WATER. CONSERVATION DISTRICT,(SWCD) 910=592-7963
NATURAL RESOURCES CONSERVATION SERVICE-(NRCS) : 910=592-7963
COOPERATIVE EXTENSION SERVICE (CES) 910-592-7161
This plan will be implemented in the event ihat waste from your operation; are'Jeaking,
overflowing, or running: off ,the site.>Youshould NOT'wait until wastes reach surface
waters or:leave. your;property to .consider that you; have a.problem You:should make
every effort to ensure that this does not happen: -This plan should be.posted in -an
accessible location for all _employees,at the facility. The followuig are some'action;items
you should take::
1. Stop the release of wastes. Depending on. the :situation, this,inay or may not be
possible. Suggested response to problems are listed below:
A.; Lagoonn overflow -possible: solutions are.
a..:Add>soil to berm to increase elevation -of dam- any�permanent::alteration of the
damahould::be approved.by a quahfxed techiucalapecialist.
b: _Pump. astestot field at an; acceptable rate
C.. Stop all additional ;flow to the :lagoon,, hold -:wastes. in the house::f possible.
d :
.:'Call. a=pumping contractor.
e. Make sure no;' surface water is ea enng lagoon
B. Runoff from wastes application. floW,action:
a.,, Immediately stop?:w.astes:application:.:
b. Create a temporary'.diversion orberm to :contain.tl ..thewaste..
c. Incorporate waste to reduce further runoff
d. - Evaluate and,elimu atc the; reason(s); that caused: the runoff.
e. Evaluate the:. application rates for. the°° fields .where runoff .occurred.
C. Leakage from the waste pipes and sprinkler -action includes:
a: .Stop recycle:_(flushing system): pump:
b. Stop:.irrigation pump
c. Close values to.eliminate further discharge.
dt. Rep Air;all leaks prior to restarting pumps+ .
D. Leakage from flush system, houses„sohidssepartors=action:includes:
a. Stop recycle (flushing system). pump._
b. Stop irrigation pump.
c. Make sure no siphon effect h' been?created..
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks -possible action:

a. Dig a small sump or ditch i&datchall seepage, put in a submersible pump, and
PUMP back into lago04.
b,. If libles are caused by burrowing animals, trap or re-
move animals and fill -holes:
and- compact with a clay typo, so 'il
c.- - Have a professional evaluatethe c-ohd -sidiew-ilfs� and '6
iti6n, of the- th lagoon
bottom as soon'"p0siibI6."
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b.; Approximately how much-. was releaged Andwhat duration?.
C. Any,damage noted, such as employee injury -fish kills; orproperty` :d.a1hag&?:
d. Did the -spill heave .the .pr-Q.pert3r9
e. Does the spill have lth-6 potential to 'reach surface- -waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface! waters?
3. Contact appropriate agencies.
' a During normal business hours, call- your DWQ (Division- of Water Quality) -
regional office,: at.910-433-3300, after --hours, emergency number 1--800-858-
03 6 8. Your'phone, call should include¢ YOUR, NAME:, FACILITY
NUMBER, TELEPHONE 'NUM BERf-THE DETAILS OF TE, INCIDENT
FROM ITEM #2 ABOVE, -THE -EXACT LOCATION OF THE FACILITY,
AND THE LOCATION OR DIRECTION OFMOVEMENT- OF THE
SPILL, WEATHER AND;WRqD CONDITIONS; THE CORRECTIVE
MEASURES THAT HAVE BEEN UNDER TAKEN, AND THE
SERIOUSNESS OF THE SITUATION.,
b. If the spill leaves the property or enters - surface -waters, call., Ideal- (EMS)
Emergency Management -Services k910=692-8,996-
c. Instruct EMS to contact loda1;Health'2Dep9rtment,,
d. Contact local 1Soil and. Water: Conservation Distnct,! Natural Resources
Conservation Service office at. 910-592;-7963'and Cooperative Extension
Service at 910-592-7161 for advice/technical assistance.
4. If none of the above works call 911 or the shetiffsLDepartmefit and explain your
problem to them and ask that person to contact the propet'ageilcies :for you.
5. Contact the contractor of your choice, tolbegmi -repair -of theproblem to minimize off -
site damage.
a. Contractors Name:
b. Contractors Address:
A 65-Wen Vc-
c. Contractors Phone: 910-,!M-13771
Page 2

6. Contact the technical specialist who certified the lagoon.
a. Name: RAIJOALL n►. S.4jZ!F "'r
b. Phone: 9/0. 592 • 5*771
7. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
8. If you are a contract swine grower associated with a swine company integrator,
contact the company representative at 910-592-5771.
Page 3

Insect Control Checklist for Animal Operations
Source y Cause
UNITS to Cpnlrol Insects — --
Sitc SI)ccific 1'1•acticcs
Lilluitl S3•slelus
. nccunrt►lation ol'solids
La0utnls and fits Crllsled Solids
I .Xccssivc vcgcl;lt.ivc • Decaying vc 6cl;Il ion
Growtll
------------
❑ Flush syS(Clll.is designed and operated
sufficicnlly to remove accumulated solids fr'oul
gu(Icrs as designed.
Cl Remove bridging ol'aectllllt►ltlled solids a(
discharge
li Maintain lagoons, scaling basins and Mils �t here
')CS( brccding-is appal'cnl to nriniuliZe (lac
crusting orsolids to a dep(h of no more Ihan G -
3 inches over more than 30% of surface.
■ Maintain vege('11ivc con(rol along balks of �— —
lagoons and other impolutdlltenls to prevent
accunnda(ioll of decaying vege(ative matter
along waler's edge on impoundment's perimeter.
I�ccdcrs --
I'CC(1 $I)111agC
Ury 5yslcnls — -
11 Design, operate and maintain reed syS(CII1s(C.g.,
bunkers and troughs) to nlininlize alc
accun)ula(ioll of decaying wastage.
Cleall all) sl)ilhlge 011 a I'011lillc basis (e.g., % - 10
day interval during summer; 15-30 day iulcrval
ccd Stora c - -
g Accumulations
or reed residues
during winlrr).
❑
Reduce moisture accumtllalionw thin and 4
aa'otmd immediate perimeter of reed storage
areas by insuring drainage away front si(c
and/or providing adequa(c coil (ainnlen(
covered bill for brewer's
grain and similar high
m
Moisture grail) products).
O Inspect for and remove or break up accuuullaled
solids in filler strips around feed
storage as
needed.
Na
�
CJ
G
AN41C-Novelllbel. II, 1996, Page l

Source .
Animal i°Inldin Areas
g.
Cause
• Accumulations of animal wastes
1BKft to Control Insects. ,
®
and.feed wastago.
Blgninate. lbw at,eas that. tray moisture. along
fences anti other--.: locations
where waste
accumulates and disturbance by animals is
minimal.
Q Maintain fence rows and filter strips around
animal holding areas10 minimize .
accumulations of wastes (i.e., inspect for and
remove or break up accumulated solids as
Dry Manure Handling.
Accumulations of animal wastes
needed). ;
® Remove Will age on a routine; basis
(e g.,
day interval during summer;15.30 day interval
during winter) where manure is loaded for land
application or disposal.
'13 Provide for adequate drainage around manure
stockpiles.
® Inspect for and remove or break up accumulated
wastes in filter .strips around stockpiles and
4 . ..... _.... -
manure handling areas as needed.
Carolina StatUy,
For more information contact the Cooperative F-xtension Service, Department of Entomology, Box 7f 13, North State -University,
Raleigh, NC, 27695-7613, ty,
AMIC - November 11, 1996, Page 2
{
Practices

Swine Farm. Waste Management Odor Control Checklist
auarce
Farmstead
Cause
Swine production
■
BA4Ps #o Minimize Odor' $Ite Sprciflc Practices,
Vegetative or wooded but%rs,
■
Recommended best management practices;
0
Oood judgment and common sense
Animal body surfaces
a
Dirty manure -covered animals
■
Dry floors
Floor surfaces
a
Wet manure -covered floors
■
Slotted floors;
■
Waterers located over slotted'floors;
17
Feeders at high end of solid floors;
®
Scrape manure buildup from floors;
17
Underfloor ventilation for drying
Manure collection pits
Urine;
■
.
Frequent manure removal by flush, pit recharge,.
a
Partial microbial decomposition
or scrape;
17
Underfloor.ventilation
Ventilation exhaust fans
a
Volatile gases;
■
Fan maintenance;
Dust
■
Efficient air movement
Indoor surfaces
a
bust
N
Washdown between groups of animals;
-®
Feed additives;
a
r
Feeder covers;
N
Feed delivery downspout extenders to feeder
Flush tanks
®
Agitation of recycled lagoon
®
covers
Flush tank covers;
liquid while tanks are filling
O
Extend fill lines to near bottom of tanks with
Flush alleys
a
Agitation during wastewater
13
anti -siphon. vents
Underfloor flush with underfloor ventilation
conveyance
Pit recharge points
o
Agitation of recycled lagoon
®
Extend recharge lines to near bottom of pits
liquid while pits are filling.
with anti -siphon vents
Lift stations
a
Agitation during .sump tank
®
Sump tank covers
filling and drawdlown
Outside drain collection
.a
Agitation during wastewater
®
fox covers
or junction boxes
conveyance
AMO.0 - November 11,1996, Page 3

r
Source Cruse BhM to Minimize_ bddtr Site Specite Practices
• End of drainpipes at o Agitation during wastewater 13 Extend discharge point of pipes.vndemeath
lagoon_:. conveyance::.:. lagoon liquid level
Lagoon surfaces ® Volatile gas emissions;0 Propec lagoon liquid capacity;
i Biological mixing;' IN Correct lagoon startup procedures; .
• Agitation 13 Minimum surface area= -to -volume ratio;
OR Minimum agitation when•pumping;
® Mechanical aeration;
® Proven biological additives
Irrigation sprinkler . • High pressure agitation; A Irrigate on dry days with little or no wind;
nozzles o Wind drift ® Minimum recommended operating pressure;
Pump intake near lagoon liquid surface;
[•7 Primp from second -stage lagoon
Storage tank or basin o partial microbial decomposition; Bottom or. midlevel loading;
surface Mixing while filling; O Tank covers;
Agitation when emptying I3 Basin surface'mats of solids;
_ 0 Proven biological additives or oxidants
Settling basin surface o Partial microbial decomposition; ® Extend drainpipe outlets underneath liquid
a Mixing while filling; level;
0 Agitation when emptying ® Removd settled solids regularly
Manure, slurry or sludge ® Agitation-when.spreading; X3 -Soil injection of slurry/sludges;
spreader outlets ® Volatile gas emissions ® Wash residual manure from spreader after use;
® Proven biological additives or oxidants
Uncovered inanure, ® Volatile gas emissions while O Soil injection of slurry/sludges
slurry or sludge on field drying a S
surfaces oil incorporation within 48 hrs.;
® Spread in thin uniform layers for rapid drying;
® Proven'biological additives or oxidants
Dead. animals ® Carcass decomposition Ili Proper disposition of carcasses
Dead animal disposal • Carcass d=ompositioi. ® Complete covering of carcasses in burial pits;
pits ® Proper location/construction of disposal pits
Incinerators. Incomploter combustion Cl Secondary stack burners
e-- ,
Ah V = November 11, 1996, Page 4 ,

Standing water around • Impmp� eirainage; W-s iO�!Odor Site Specific Practices
facilities - Grade and landscape such that water drains
• 'Microbial decomposition of away from facilities ,
o am rV . g ' a rk�tattes : .
Manure tracked onto ® Poorly maintained access roads ® Farm access road maintenance public roads from faun
access
Additional Infortnation
Swine Manure Management ; 0200 Ruld. BMP Packet Available From
Swim+e Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet NCSU, County Extension Center
Swine Production -Facility Manure•Man' Cent, Pit Rec NCSU = BAE
!large -Lagoon Treatment; EBAE 128-88 NCSU - BAE
Swine Production Facility Manure l�lanagetnent,•Underfloor Flush - Lagoon Treatment; EBAE 129-88
Lagoon Design and Meaagement for Uyestook-Manure Treatment and Storage ; EBAE 103=83 NCSU -BAE
Calibrati9p. of Manure. and Wastewater Applications Equipment ; EBAE ZOO Sheet NCSU - BAE
Controiling Odors from Swine Buildings ; p H 33 NCSU - BAE
Enviromnental Assurance Program ; NppC M moal NCSU - Swine Extension
Options for Managing Odor; a report from the Swine Odor Task Force NC Pork Producers Assoc
Nuisance Concerns in Animal Manure Mahagement: Odors and Flies; PRU 107,1995 Conference procedin NCSU Agri Communications
c
gs Florida Cooperative Extension
AMOC -November 11, 1996, Page S

Version —November 26, 2018
MortalityManagement: Methods.
Indicate which method(s) will be implemented.
When selecting multiple methods indicate. a primary versus secondary option.
Methods other than .those listed must'be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom. of the.burial pit should be at least one foot above the seasonal
high water, table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
_ -_.___ . Bec�deirag a r:_eDderinglantJicpns d under-G-3-J-06-1: Z`_
0 Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by ,the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach.copyof permit). If compost is.distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of. dead poultry.only,. placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
DAny method.which, in the professional opiniono the State Veterinarian, would. make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for, -farms covered. by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be. used for mass mortality. The NCDA&CS Veterinary Division. sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is .activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be -done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of. imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
G
y
�Signature of Farm Owner/Manager Date-
—ZGGfi� � 3'iJ'f2o! p _
Signature ofTe nica Specialist Date

ADDRESS: Clinton, NC 28328
. /
I�T�ODUCTION:
------------
Prestage Farms Farms plans to construct a 624 sow farrow to feeder operation in the
Parkersburg area. Plans are to establish 10acres of coastar bermuda hay|and
to receive the effluent from the waste treatment lagoon. The lagoon will not
be designed for sludge accumulation at owners request. Sludge will be removed
as needed.
SITE CONDITIONS:
----------------
The site
is mapped (CaB)
Cainhoy sand, 0
to 5
% slopes.
THE SIDE
SLOPES AND THE
BOTTOM OF THE LAGOON
SHALL BE LINED WITH SANDY CLAY
MATERIAL'
BECAUSE OF THE
SAND, AND FINE
SAND
FOUND IN THE SOIL PROFILE. UPON
FARTHER
INVESTIGATION IT
WAS RECOMMENDED
THAT
THE SAND CLAY MATERIAL BE
BORROWED
OFF SITE.
TYPE AND SIZE FARROW -FEEDER
OF OPERATION 624
CLASS III
DESIGNED BY G. Glenn Clifton
DATE
APPROVED BY .
DATE
PERMAMENT STORAGE
624 Hogs ` 502 |bs per hog 1 '' Ft ` r |b. 8257ZS Cu Ft
TEMPORARY STORAGE -
325728 |bs of animal x 1.35 cu. ft. of waste per day 79152 Cu Ft
per 1000 |bs of animal wt. x 180 days
_
RAINFALL LESS EVAPORATION
7" X 64575 sq. ft. surface area per 12"per ft 37669 Cu Ft
RAINFALL - 25 YR. 1 DAY STORM
7" X 64575 sq. ft^ of surface area per 12" per ft. 37669 Cu Ft
DESIGN STORAGE NEEDED --------------------------------------- 442549 Cu Ft
(PERMANENT STORAGE +TEMPORARY STORAGE + RAINFALL) 16391 Cu Yds
DESIGN STORAGE AVAILABLE ------------------------------------ r
'_ QJQR-9510 C'u. Ft
TOTAL,STORAGE \ STORAGE ----------------------------------------------- (_. 48O217 Cu(F
��
(PERMANENT STORAGE + TEMPORARY STORAGE + RAINFALL + 25 YR) 17786 Cu ����
�
MANURE AND URINE PRODUCTION
624
hogs
x
7.4 tons
per
year
4618
T./yr.
NITROGEN
IN WASTE
325728
}bs
of anima!
x
.48 }bs
x
365 day/yr.
per
1000 |bs
of
animal
wt.
N = 57068
|bs/yr.
PHOSPHORUS
IN
E,
325728
|bs
of animal
x
.14�/bs
x
365 da /' .
per
1000 |bs
of
ar'ima|
wt.
P = 16645
|bs/yr.
POTASSIUM
IN
WASTE
325728
|bs
of animal
x
.21 |bs
x
365 day/yr.
^
per
1000 |bi
of
animal
wt.
K = 24967
lbs/yr.
�

p-/2.4- v,)�'
"
Toial design volume usirg prismcidal formula
SS/END! SS/END2 SS/SIDE! SS/SIDE2 LENGTH WID7H
3.0 O.0 3.0 3.0 245.0 210.0
AREA OF TOP
LENGTH * WIDTH =
245.0 210.0
51450 (AREA OF TOP'',
DEPTH
10.0
AREA OF
BOTTO�
LENGTH
* WIDTH �
185.0
150.0
27750
(AREA
OF
BOTTOM)
AREA OF
MIDSECTION
LENGTH
* WIDTH A 4
215.0
180.0
154800
(AREA
OF
MIDSECTION
* 4)
CU. FT!
= [AREA TOP +
(4*AREA MIDSECTION)
+
AREP
BOTTOM] * DEPTH/6
51450.0
154800.0
27750.0
1.7
Total Designed Volume Available =(10;:10)FT.

U. S. DEPARTMENT Of AGRICULTURE MC-ENG-GO
Soil Camervatian swvict Rev. 7/91
p.izx op
PLAN OF EXCAVATED WASTE STORAGE PIT
NAME: hes- Arc- FaRntiS Tne. -1ZA EY-PAnsrorl Date: 6 12 •/
County: S A M P 5o
Address:
LENG74 2-"
� SIDE SLOPE •.L TO I /
AVE. TOP ELEV. 4�
G 0
/ I
AVE. BOTTOM ELEV. %
[Sw beck for va(r calculations)
Use of facility: WAS Tc r',e
Capacity:
Soil Type: Ca.3
Bench Mark Description nx
I%- jn $Ase OF P,nG
/00 WE -r OF HOG 9y/C y6
Bottom
Normal Liquid Level
Storage for normal Precip.
Maximum Liquid Level
25 yr. Storm Storage
Crest ESW
Max.Flow Depth
Freeboard
Top of Dam
A
Elev.
33.0
Elev.
—
(+)
Ft.
(+)
►. o
Ft.
Elev.3
. a

~
ADDRESS: Clinton, NC 28328
'
INTRODUCTION: �4
_____________ )/.(
PrestaSe Farms plans to construct a 624 sow farrow to feeder operation in the
Parkersburg area. Plans are to establish 10 acres of coastaF bermuda hay|and
to receive the effluent from the waste treatment lagoon. The lagoon will not
be designed for sludge accumulation at owners request. Sludge will be removed
as needed.
SITE CONDITIONS:
The site
is mapped (CaB)
Cainhoy sand, 0 to 5
% slopes.
THE SIDE
SLOPES AND THE
BOTTOM OF THE LAGOON
SHALL BE LINED WITH SANDY CLAY
MATERIAL,
BECAUSE OF THE
SAND, AND FINE SAND
FOUND IN THE SOIL PROFILE. UPON
FARTHER INVESTIGATION
IT
WAS RECOMMENDED THAT
THE SAND CLAY MATERIAL BE
BORROWED
OFF SITE.
TYPE AND SIZE
OF OPERATION
CLASS III
DESIGNED BY
DATE
APPROVED BY
DATE '
PERMANENT STORAGE
FARROW -FEEDER
624
G. Glenn Clifton
624 Hogs x 522 |bs per hog 1 Cu Ft per |b. 325728 Cu Ft
TEMPORARY STORAGE
325728 |bs of animal x 1.35 cu. it. of waste per day 79152 Cu Ft
per 1000 lbs of animal wt. x 180 days
RAINFALL LESS EVAPORATION
7" X 64575 sq. ft. surface area per 12"per ft 37669 Cu Ft
RAINFALL - 25 YR. 1 DAY STORM
7" X 64575 sq. ft. of surface area per 12" per ft. 37669 Cu Ft
DESIGN STORAGE NEEDED --------------------------------------- 442549 Cu Ft
(PERMANENT STORAGE + TEMPORARY STORAGE + RAINFALL) 16391 Cu Yds
DESIGN STORAGE AVAILABLE ------------------------------------ u Ft-
Cu Yds
Yds
TOTAL STORAGE ----------------------------------------------- 480217 Cu Ft~
(PERMANENT STORAGE + TEMPORARY STORAGE + RAINFALL + 25 YR) 17786 Cu Ft
MANURE AND URINE PRODUCTION
624
hogs x
7.4 tons
per
year
4618
?F./yr.
NITROGEN
IN WASTE
325728
|bs of animal
x
.48 |bs
x
365 day/yr.
per 1000 lbs
of
animal
wt.
N = 57068
|bs/yr.
PHOSPHORUS
-IN WASTE
325728
|bs^zf anima|Kx
.14 }bs
x
365 day/yr.
per 1000 |bs
of
animal
wt.
P = 16645
|bs/yr.
POTASSIUM
IN WASTE
325728
|bs of animal
x
.21 |bs
x
365 day/yr,
per 1000 |bi
of
animal
wt.
K = 24967
Abs/yr.

F-)-Z6 '..
U. S. DEPARIMM OF AGRICULTURE we,-Emc-
Soil Conservation Service 5/83
LOCATION CODE .2-o7o
PLAN OF EXCAVATED WASTE ST2RA I —OE PtIp
NAM !PR CS 7-AG E I=ARMS ACP # DATE 3/-25 DISTRICTSAPAP&J-,
t. ENG TM
81 DE SLOPE J-6TO I
j
7
45 -0 ,4D
4-3
AVE. TOP ELEV.
00,
R
-!L, U."Upt- 1Y-
04�
V*j,UM,e m(-area
of top) + (area of bettea) + (4 x area
6'
Lisa Of facility A.W. LA.6pe5.f)
Capacity 3 350-965 Gallons
Volume.Cost-sharing Cu. Ft.
Soil type CC,&'R) CAIn�0y SAnlj-,
B. M. descirt tion &14..
p . n _ -- _j r
&E Pins_ T&94- 60 C A, Q
-&-
Bottom
Elm
Normal liq%dd level
91ev.
+ 1. 0
Storage for ftermal precip.(Pt)
+ — -
Maximum . liquid level
Elev.
11 .0
Storale for:
25 Yr. freq. procip.
(Tt.)
+ 1 -0
Crean aw
Rate (ft.)
Fre"wd
+ i.0
Top of Dam

AREA OF TOP
LENGTH of WIDTH =
310.0 159.6
AREA OF BOTTOM
LENGTH S WIDTH =
250.0 99.6
49476 (AREA OF TJP>
24900 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH *
WIDTH * 4
280.0
129.6
145152 (AREA
OF MIDSECTION * 4)
CU. FT. =
[AREA TOP
+ (4*AREA MIDSECTION)
+ AREA BOTTOM] A DEPTH/6
49476.0
145152.0
24900.0 i.7
Total Designed Volume Avai2able = U. FT.

- U. S. DEPARTMENT OF AGNICULT1AtE NC-ENG-40 P 2 J1 C ��
Soit Conservation Service Rev. 7/91 l�
/99y
PLAN OF EXCAVATED WASTE STORAGE PIT
NAME: PP. srAGE FARMS Inc, p- 12 b ExPAnSIar1 Date: G1 1 c /9 1f-
County: c5' wtPSon Co.
Address: CLIATon
-* SEF Tope MAP
/Se
y 5D.
W rt---
�El16TN
31 DE
AVE. TOP ELEV.
/moo �o
r1O SECTION /
AVE. taOTTOY ELEV. !
f _ f
r — L EN6211 —
i
(See back for robs oaleuLations)
Use of facility: WAS-4 & -rtC 7 AeEn r LA6,00n
Capacity: 2 (o`r o 7 Co GdllorLs 31 (o +5 Ft3
Soil Type: C a
Bench Mark Description Top OF CEMEnr PRoAEtTy artAkxt,e 1.oc,o r2o
A PP A o x oo' . E' o c a f. o •. ._.�_. .
Bottom
Normal Liquid Level
Storage for normal Precip.
Maximum Liquid Level
25 yr. Storm Storage
Crest ESW
Max. Flout Depth
Freeboard
Top of Dam
Elev.
40.1
Elev.
+$.N-
(+)
Ft.
Elev. 48. 41--
(+)
.7 Ft.
Elev.
Elev.

^ +*m,
"qcmuc
' o*Ww,
I rrestalQlarMs piano to
con1t t sow
farrow to
feeder operat}oninthe
['� 0 are4. Plans
-
areto astabl igh 10 'apres
of coasia
i 6ermuda hay] and
�
ar �
o receive theeffluent-fromthe
t tr
. waste t
t aS»
| oi
`^ The lagoon -wi| inot
e desiSr gd 'for'�s | accumu|ati on at ownerf
�request.
iue wi | | ']»e'removed
S' d8`
s oeeded� ' �-
' �` �
,
ATE CONDITIONS-,
-`--�-----------
Xe s} te.j s ma_ped�(CaB)
Cai nhoy sand, O to
5 % s |opes
^ `
_��HE� ��IDE ��LOPES AND THE
BqT OF THE LAGOON
SHAL' .SELINEn
WITH'SANDY C' `
/HE
, ]BECAUSE OF�INyESIGAT
_nM
SAND, AN SAND
ND IN
| '�OIL PRO! I'` . '' �
-aARTHFR4TERIAL
IO`TI
-TN T
�w*u | i�* `
'' THE SAND
`
CLAY MATERIAL BE
�ORF OWEDOFF! SlTE.
-RECOMMENDED��
ryPFAND SIZE FARROW -FEEDER
`>F' OPERATInN 624
�
ILASS III
OESIGNEDA» G. Glenn C|Ffton
gATE 4/1091'
. `
AP VED BY �
DATE
_
T ST[RA8E
Hoss x 1522 |bsper
`
YEMPORARY
STORASE
32,5720 }bs ofanimai 1 1.35cy
. ' per 1000 |bs'of amma|wt.
`�
hog 1 Cu Ft Per it.
ft,`of.vaste pe��day
x18() days`
,
RA INFALM LESS EVAPORATION ,
X� `64756 s q ,- ft . �_purfa ce area. per '12p ber ft'
,
'
RAINFALL— 25 YR. 1l}AY' STORM
7" X _ ' 64750 s. ft° of`rface area,�per:12" per� ft.
qsu~
DESIGN STORA8E'nNEEI)ED _------_-W_---_-~_�_-------r----.......
(PERMANENT STOOGE + TEMPORARY STORAGE 1. RAINFALLr
'
DESIGN ' AVAILABLE-- --------
AQ ------- - ' - - '-
.`^.�^- ". " -`- _ -- ---_----- -_ - _--_----_----_----
(PERMANENT STORAGE -~ TEMPORARY ST8R16E + RAINFALL + 25 ')
MANURE'INQ URINE
ON.
' � 124 f»ogs x ' 7,4�tnos per year `
NI I�1 ' `
''� �32�57I�8��b�~` of i �--| x`..�8`|bsx'36��da* .r.
� �loer 1�0<)E� !b��� of� az�i' � | */t �' '
3��728Cu`f`t
79152 Cu'Ft
�37771
`
Cm
Ft.
442651`WFt
16394�Cu
Yds
'
-
'
tn°
u
\rds
480
CvFt
17793:CU
Ft
^��'
7«— -07068 |bs/yr.
Poo

-
-�-- - ' '-----_�_
01
10 Squares to the Inch

nm�x
Operator:PRESTA8E FARMS D County: SAMPSON
Distance to nearest residence ,(other than owner):
Date: 01/10/91
2000.0 feet
1. STEADY STATE LIVE WEIGHT '
'
0 sows (farrow to finish) x
1417 !bs.
=
0
|bs
624 sows (farrow to feeder) x
522 |bs.
=
325728
As
0 head (finishing only) x
135 |bs.
=
O
|bs
0 sows (fakrowto wean) x
433 ibs.
=
0
|bs
0 head (wean to feeder) x
30 |bs.
=
0
|bs
TOTAL -STEADY STATE LIVE WEIGHT
(SSLW)
=
325728
lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 325718 \bs. SSLW x Treatment Vo|ume(CF)/|b.
'
SSLW
Treatment Volume(CF)/\b. SSLW---::
1 CF/|b. SSLW
Volume = 325728 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet ; "Owner
requests
no sludge
storage.
Sludge
will be
removed
as needed."
4. TOTAL DESIGN VOLUME
Inside top,length 390.0 feet
Inside top
170.0
;
width
feet
Top of dike at elevation 54.0
feet
Freeboard 1.3 feet ; Side slopes
3.0 :
1 (Inside
lagoon)
Total design lagoon liquid level at
elevation
52.7 feet
Bottom of lagoon elevation 42.0
feet
Seasonal high water table elevation
44.0 feet
Total design volume using prismoidal
formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2
LENGTH
WIDTH
DEPTH
3.0 3.0 3.0 3.0
38212
162.2
10.7
AREA OF
TOP
LENGTH
*
WIDTH =
382.2
162.2
AREA OF
BOTTOM
LEN8TH
*
WIDTH =
318.0
98.0
AREA OF
MIDSECTION
LENGTH
*
WIDTH * 4
350.1
130.1
61992.8 (AREA OF TOP)
31164.0 (AREA OF BOTTOM)
182192.0 (AREA OF MIDSECTION * 4)
CU. FT. =
[AREA TOP
+ (4*AREA MIDSECTION) + AREA
BOTTOM]
61992.8
182192.0 31164.0
VOLUME OF
LAGOON AT
TOTAL DESIGN LIQUID LEVEL =
* DEPTH/6
1.8
491039 CU. FT.

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
390.0 170.0 66300.0 square feet
Buildings (roof and lot water)
Length * Width =
0.0 0.0 0.0 square feet
TOTAL DA 66300.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 325728 Lbs. SSLW * CF of Waste/Lb./Day * 180 days
Volume = 79545 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days stora8e/7.48 gallons
per CF
Volume = 0.0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 38675.0 cubic feet

5D. Volume of 25 year - 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume = 38675.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 79545 cubic feet
5B. 0 cubic feet
5C. 38675 cubic feet
5D. 38675 cubic feet
TOTAL 156895 cubic feet
Total required volume
482623
cubic feet
Total design
volume avail.
491039
cubic feet
Min. req. treatment volume plus sludge
accumulation
325728 cubic fee
At elev.
49.8 feet ;
Volume is
324702 cubic
feet (end pumping)
Total design
volume less
25yr-24hr
storm is 452364
cubic feet
At elev.
52.0 feet ;
Volume is
448440 cubic
feet (start pumping)
Seasonal high
water table
elevation
44.0 feet
7. DESIGNED BY:
DATE:
APPROVED BY:
DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN

Operator:PRESTAGE FARMS County: SAMPSON,
P-12D EXPANSION
�
Distance to nearest residence (other than olner):
1. AVERAGE LIVE WEIGHT
(ALW)
0'
sows
(farrow to
finish)
x 1417
lbs.
0
sows
(farrow to
feeder)
x 522
lbs.
0
head
(finishing
only)
x 135
lbs.
1200
sows
(farrow to
wean)
x 433
lbs.
0
head
(wean to feeder)
x 30
lbs.
Describe
other :
�,/����J�^
[ ' ~ -//
y
/^. .q&�
�
Date: 7/28/94
2000.0 feet
= 0
lbs
= � 0
lbs
= 0
lbs
= 519600
lbs
= V
lbs
: 0
Total Average Live Weight = 519600 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 519600 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb, ALW = 1 CF/lb. ALW
Volume'= 519600 cubic feet
STORAGE
3.
Volume = 0.0 cubic feet
4. TOTAL DESIGNED VOLUME
SLUDGE ACCUMULATION NOT COMPUTED
AT OWNERS REQUEST. REMOVE SLUDGE
AS NEEDED.
Inside
top
length (feet)---------------------
610.0
Inside
top
width (feet) ---------- n-----------
168.5
Top of
dike
elevation (feet)-----------------
51.3
Bottom
of
lagoon elevation (feet)------------
39.3
Freeboard
(feet)-----------------------------
1.3
Side slopes
(inside lagoon)------------------
3.0 : 1
Total design volume using prismoidal formula
SS/END1 SS/EN02 SS/SIDE1 SS/SIDE2 LENGTH WIDTH
3.0 3.0 3.6 3.0 602.2 160.7
AREA OF TOP
LENGTH * WIDTH =
602.2 160.7 96788 (AREA OF TOP)
DEPTH
10.7
AREA OF
BOTTOM
LENGTH
* WIDTH =
538.0
96.5
51930 (AREA
OF BOTTOM)
AREA OF
MIDSECTION
LENGTH
It WIDTH * A.
570.1
128.6
293316 (AREA
OF MIDSECTION * 4)
CU. FT.
= [AREA TOP +
(4*AREA MIDSECTION)
+ AREA BOTTOM] * DEPTH/6
96788.3
293315.5
51930.2 1.�
`
Total Designed Volume Available =7SS294 CU. FT.

DRAINAGE AREM
Lagoon (top of dike)
Length * Width =
610,0 166.5 102800o0 square 'fee4.
Buildings (roof and lot `alci!i_.er
0.0 <_qUC?re feet f../>=t_`CY'ibe L{'i.!s area.
TOTAL DA 102200.0 square feet n
Design temporary y =itor-a", C period 3 180 days.
•._;,•••,n Volpiyle of waste produced
Feces & urine production in gal ./day per 135 lb. A W 1.37
Volume 519600 l b s a ii i:_ W 1-. 5 lips. ra t W * 1.37 gal/day 120
days
Volume ..... '-:s4 ?tom gals. or 126289.8 cubic feet
5B. Volume of wash water
This is 'i:.he amount of fresh water used for washing floors or volume
a:.:'1 fresh water used for a flush system, Flush systems that recirculate
the lagoon water are accounted for in 5A o
Vol u(r,m. = 0..0 gallons/day ie 180 days t r"age% .48 gallons
Volume = 0.0 cubic feet ,3 c. r C t=
5C_ Volume of rainfall in excess of evaporation
Use period of time whenrainfall F?`..:;=��' eds evaporation .y, n largest t t!-
r- t=1.7 ?t f :_Z .. iJ � ? Y" c. _ i �. �1 }% l r" � t�;`s amount,,
i � �_ ::
r. days excess rainfall
7.0 inches
Volume ^_ 7.0 in * rjA / 12 inches per foot
Volume =
rr-,rg66.7 cubic reset

5D. Vo.i.l.lfie {7f 25 year - 24 lour storm
-L{fi1e -- 7.0 inches /r 12 l,nr;i"jes peJ-
foot m DA
Vo.t.!_lme = 59966.7- cLlh c feet
TOTAL REOUIRED TEMPORARY STORAGE
5.A.
126890
cubic ic
feet
5B=
0
cubic-
feet
5C.
59967
cubic
feet
5D.
59967
cubic
feet
TOTAL_
246823
cubic
'feet
6. SUMMARY
^i F•i'!71po!' t!"y storage �}D-.'h 7. t�C�=:-= :: _:.^_:___.�.»�-..���= _•=. :•� �''> Ij /C
1i�•_ d
Rainfall l in excess of e;y a!pc, at =t'7n= :-.=::.:=:._:__.:==> 7.0 inches
25 year - 24 hour psi ri `cs l 1 y.:. _=----_-____ ---_ 7.0 inches
1.3 feet
inside top 610.0 feet
inside top 168.5 feet
Top of dile 51.3 feet
Bottom of 1;-sgoo{i �� 2�'rit.._ors-_._.._..._ _----.._-_ .-=c__=_ 39.3 feet
Total required '�.`i.J a L.{j(i¢a_.._-'••---_._._._�.._._......._..____........._.__. _..- . 766423 cu . f t .
Actual design 788294 cu. ft.
Seasonal high lei'=e'" tab ' != elevation I C%..iW7 j :.:__• 44.0 feet
Stop pumping 47.1 feet
Must be > or =•• to min. req. treatment :mil 45.3 feet
Required minimum m ti`-=c?.tilief'i'I vt:jL.{(rle-=__:.==== =' 519600 cu. f
Volume at stop j.3!_!t('tping eli?wfe;i%:yr".:P}==___.___..__===-. ,:).t'•'.65.,Z4 f 1, ft.
Start pumping . feet
Must be at bottom of freeboard &, Z yr. rainfall
Actual volume less 25 yi 24 f'i-. rainfall==> 74e327 C.1. ft.
Voil.l.:e at start pumping elc`•` atio('i:•.::=== === W_= 721660 cu. ft.
Required vL].1_lAme to be 1-l;,m1-er'=====-_-:-......_._.•-•-•====''• 186857
Actual volume pl-:x!?:-ed to be pumped--195096 '!_{. it.
Min. t!?ick!?k:=:csis of-_wi.1. liner when f t ii r s•+:--_ 8 feet
7. DrrSTSJNED BY: �.� CL+-�tfir.. APPROVED BY:
E.-ATE: -r/ Za/9q- DATE. y/Z���
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN!
A N;
CO3i'!11E1,,[T _ " �� >ro V�.�-. 04 NSF n i Cal��'d /o[► d
/n j�/ �1.1c sNcia✓1 d12;_ C%� j�J�.IS?!t..__...Y%t.-�I.GEI� D.C.. O
m
cf/fc -_-

OPERATION AND MAINTENANCE
This lagoon is designed for waste treatment with minimum odor
control. The time required for the planned fluid level to be
reached may vary due to the soil conditions and flushing oper-
ation.
Land application of waste water is recognized as an acceptable
method of disposal. Irrigation'by using solid set, center
piyot, gun, or traveler is the preferred and most efficient
method to dispose of the effluent from the lagoon. Care
should be taken when applying waste to prevent damage to the
crops and to prevent runoff from the fields.
The fo}|owinS items are to be carried out:
1. Begin pump -out of the lagoon when fluid level reaches
invert of the outlet pipes or at a pre -determined
elevation.
2. Stop pump -but before the lagoon depth is less than 6 feet
deep or at a pre -determined depth. (This prevents the
loss of favorable bacteria.) `
3. The recommended amount to apply per irrigation is one
inch, and maximum recommended application rate is 0.5
inch per hour.
4. It is recommended that the treatment lagoon be prechar8ed
to 1/2 of it's capacity to prevent excessive odors during
beginning stages of the operation. Prechar8inS reduces
the concentration of the initial waste entering the lagoon
thereby reducing odors. Solids should be covered with
water,at all times.
5. Keep vegetation on the embankment and areas around the
lagoon and building mowed.
6. Repair any eroded areas and establish in vegetation.
7. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The N. C.
Department of Environment, Health, and Natural Resources
(DEHNR), Wastewater Management Section, has the respon-
sib<|ity for enforcing this Aaw.
G. All surface water is to be diverted from the lagoon to an
adequate and stable outlet.
NOTE: An analysis of the waste water can be obtained at
commercial laboratories or at a fee uf.$4.00 per sample at. -
NC Department of Agriculture Plant Analysis Lab
Agronomic Division
Blue Ridge Road Center
Raleigh, NC 27611
Phone [phone]