820415_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the ?North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 82-0415 Certificate Of Coverage Number:
2. Facility Name: P=1
3. Landowner's Name (same as on the Waste Management Plan): Prestage Farms Inc
4. Landowner's Mailing Address: PO Box 438
City: Clinton State: NC
Telephone Number: 910-596-5749 Ext. E-mail: lg ennc6Dprestagefarms.com
5. Facility's Physical Address: 2490 Wilbur Pridgen Rd
City: Harrells State: NC
6. County where Facility is located: Sampson
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"):
10. Operator Name (OIC):
AIAN F4VU4101
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type
Swine - Farrow to Wean
Operation Types:
Swine
Cattle
Wean to Finish
Dairy Calf
Wean to Feeder
Dairy Heifer
Farrow to Finish
Milk Cow
Feeder to Finish
Dry Cow
Farrow to Wean
Beef Stocker Calf
Farrow to Feeder
Beef Feeder
Boar/Stud
Beef Broad Cow
Gilts
Other
Other
Prestage Farms Inc
Phone No.: 910-592-5771
Allowable Count
2,000
AWS820415
Zip: 28329
Zip: 28444
OIC #:
9910 ut(o
Dry Poultry
Other Types
Non Laying Chickens
Horses - Horses
Laying Chickens
Horses - Other
Pullets
Sheep- Sheep
Turkeys
Sheep - Other
Turkey Pullet
Wet Poultry
Non Laying Pullet
Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
'Redline"
(Inches)
A
19.00
B
19.00
P-lA
1905e,�,a
6goo108,900.00
P-113
9 (o
5ga 133
82,764.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.1OC(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), signed by the owner and a certified technical specialist containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.613, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name: L AuUA/ Title: V,
Signature:Y*40::: Date:
4-01
Name:
Signature:
Title:
Date:
Name:
Title:
Signature:
Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

Waste Utilization Plan
Producer:
Name of Farm:
Location:
Phone:
Type of Operation:
Number of Animal:
Prestage Farms, Inc.
P-1
P. 0. Box 438
Clinton NC 28329
910-569-5771
Farrow -Wean
2000
County: Sampson
Storage Structure: Anaerobic Lagoon
Method of Application: Irrigation
Amount of waste produced per year: 12188 ton/year
Amount of plant available N (PAN) produced/year: 10800 lbs./year
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface water and/or groundwater. The plant nutrients in the animal waste
should be used to reduce the amount of commercial fertilizer required for the crops in the
fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in the implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environmentally
safe manner._
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall not be applied to land eroding at more than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are
established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may in runoff to the surface waters which is not
allowed under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor problems.
6. To maximize the value of the nutrients for crops production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy. Injecting the waste or disking will
conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change methods
in the future, you need to revise this plan. Nutrient levels for different applications methods are
not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have plant analysis made, which

P-1
Page 2
could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible so as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract No.
Field No.
Soil Type
Crop
Code
Yield/Ac
Lbs. N
unit
Acres
Lbs N
Used
Month to
Apply
Lbs. N
Per Ac.
10986
1
CaB
CB -Hay
3.9
50
45
8775
MAR-OCT
195
10986
1
CaB
CB -Hay
1
50
45
2250
SEP-APR
50
Total 45 11025 lbs.
Available Nitrogen 10800 lbs.
Surplus or deficit -225 lbs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to apply
the waste in a timely manner.

P-1 Page 3
The applicator is cautioned that P and K may be over applied while meeting the N requirements. In the future,
!�. regulations may require farmers in some parts of North Carolina to have a nutrient management plan that
addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (i.e. small grain, etc. interseeded in bermudagrass), forage must be removed through
grazing, hay and /or silage. Where grazing, plants should be grazed when they reach a height of six to nine
inches. Cattle should be removed when plants are grazed to a height of four inches. In fields where small grain
etc. is to be removed for hay or silage, care should be exercised not to let small grain to reach materity,
especially late in the season ( i.e. April or May) Shading may result if small grain gets too high and this will
definitely interfere with the stand of bermudagrass. This loss of stand will result in reduced yields and less
nitrogen being utilized. Rather than cutting small grain for hay or silage just before heading as is the normal
situation, you are encouraged to cut the small grain earlier. You may want to consider harvesting hay or silage
two to three times during the season, depending on the time small grain is planted in the fall.
The ideal time to interplant small grain, etc. is late September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a height of about two inches before drilling for best
results.
Caution must be exercised in grazing or haying summer annuals under stressed conditions. Nitrate poisoning
may occur in livestock. Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres excluding required buffers, filters strips along
ditches, odd areas unable to be irrigated, and perimeter areas not receiving full application rates due to
equipment limitations. Actual total acres in the field listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions -for periodic land application of sludge at agronomic rates.
The sludge will be nutrient rich and will require precautionary measures to prevent over application of nutrients
or other elements. Your production facility will produce approximately 1680 lbs. of plant available
nitrogen per year in the sludge.
If you remove -sludge every 5 years you will have approximately 8400 lbs. of PAN to utilize. Assuming
you apply this PAN to hybrid bermudagrass hayland at the rate of 300 lbs/acre you will need 28
acres of land. If you apply the sludge to corn at the rate of 125 lbs. of nitrogen per acre you will need 67
acres of land. Please be aware that these are only estmates of the PAN and the land needed. Actual
requirements could vary by 25% depending on the sludge waste analysis, soil types, realistic yields, and
application methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation such that
runoff or ponding occurs. This rate is limited by initial soil moisture content, soil structure, soil texture, water
droplet size, and organic solids. The application amount should not exceed the available water holding capacity

P-1
Page 4
of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
if surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is installed to properly irrrigate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table is provided as a guide for establishing application rates and amounts.
Tract No.
Field No.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
10986
1
CaB
CB -Hay
0.6
1.0
10986
1
CaB
CB -Hay
0.6
1.0
APR �, � ?91-
WeterQua ft
Regional Operations SecOm

P-1
Page 5
This is the maximum application amount allowed for the soil assuming the amount of nitrogen allowed for the
�.. crop is not over applied. In many situations the application amount shown cannot be applied because of the
nitrogen limitations. The maximum application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on the
average of once every 6 months. In no instances should the volume of the waste be stored in your structure
be within the 25 year 24 hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and the waste applicator to ensure that the spreader equipment is operated
properly to apply the correct rates shown in the tables. Failure to apply the recommended rates and amounts of
nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you have receive the waste analysis report for assistance in determining the
amount of waste per acre and the proper application rate prior to appling the waste.
NARRATIVE OF OPERATION

SrMt
�
ROY COOPER
RECEIVE6W""
MICHAELS.REGAN
- �. •��;
A PR 0 3 Nil 2019
s��r
LCULPEPPER
RviroutQa1A
W �i��ll j►' "1�i4!
Dirtaor
anmenatry
R40W10p&0t0n5
February 27, 2019
Prestage Farms Inc
P-1
PO Box 438
Clinton, NC 28329
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at hUs://d2g.nc.gov/about/divisions/water-resources/water-civaliregional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non -Discharge General Permits. you must submit an application for
ermi�ge to the Division. Enclosed you will find a "Request for Certificate of Coverage Facility Currently Covered by an
Expiring State Non -Discharge General Permit." The gpplication form must be completed, signed and returned by April 3. 2019.
Please note that you must include one (1) cop. of the Certified Animal Waste Management Plan (CAWMP) with the
completed and signed application form. A list of items included in the CAWMP can be found on Vase 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Enclosures
cc (w/o enclosures): Fayetteville Regional Office, Water Quality Regional Operations Section
Sampson County Soil and Water Conservation District
AFOG Section Central Files - AWS820415
Presta, ee Farms
North Caro-na Departmentof Erc+rrovnerts.' Qua -ty I DvsonofWater Ressurces
BU N. Sa sbury St. 1163S Me 8 Serv"ce canter I Ra a gh, Nort?t Carona 27 93-1S36
319.707 2WO

P-1
WASTE UTILIZATION PLAN
Page 6
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land. .
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
standard 393 - Filter Strip).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate that runoff
does not occur offsite or to the surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potentual for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residenrial property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1,1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).

P-1
Page 7
REQUIRED SPECIFICATIONS
(continued)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned
by he landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to, prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
17. A protective cover of appropriate vegtation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidences of
erosion, leakage or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illigal discharge, pollution and erosion.
19. Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetation and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications of animal waste
during the crop season.
21. Highly visible markers shall be installed to mark the top and the bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five (5) years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.

Page 8
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: P-1
Owner/Manager Agreement Prestage Farms, Inc.
I (we) understand and will follow and implement the specifications and the operation and maintenance proce-
dures established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the North Carolina Division of Water Quality
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to the surface waters of the state from a storm event less severe than the 25-year, 24 hour
storm.The approved plan will be filed on -site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Prestage Farms, Inc.
Signature: p2rEs A6E FPR►tiS INC. C- 4
Name of Manager (If different from owner)
Signature:
Name of Person Preparing Plan: G. Glenn Clifton
Affiliation: Prestage Farms, Inc.
Address: P.O. Box 438
Clinton, NC 28329
Signature: , r; (,.,.__ CL J- -6',
Phone: [phone]
Date: 9/ i i /o8
Date:
Date: 9 i' 19 I v 8

3/22/2019 Prestage Farms Swine Locations App
5 itky 6 1,0S
0.2mi
https://pfi.maps.arcgis.com/apps/webappviewer/index.html?id=bcd3l c72d7d04bceac9388b38ba316e6

$AMPSQN.COUNTY
EMERGENCY ACTION PLAN.
D.IVISION,:OF WATER RESOURCES. (DWR) . 910433-3300
EMERGENCY MANAGEMENT SERVICES. '(EMS) .. 910=592-8996
SOIL & WATER:_CONSERVATIQN DISTRICT E(SWCD) '.910=592-7963
NATURAL RESOURCES CONSERVATION SERVICR (NRCS) - . 91,0=592-7963
COOPERATIVE EXTENSION SERVICE (CES) 910-592-7161
This plan will be implemented in the event,that w:aste:from your operatioxi;are:Jeaking,
overflowing, or running; off .the site.: Youshould NOT: wait until wastes reach surface
waters or;leave your,property to:.eonsider that you have a; -problem. ; You; should make
every effort to ensure that this does not happen. This..,plan_should be:posted u :an
accessible location for --all _employees at the: facility- The followuig are some' action: items
you should take._
1. Stop the release of wastes. Depending on the s tuation, this,may or may not be
possible. Suggested response to problems are listed below:
A; La goon.overflow-possible.solutions are
Add soil to berm t%increase elevation..of dam; any permanent: alteration of the
dam should .e approved by a quahfied;technical-specialist. .
b Pump -wastes to field at an: acceptable rate.
c:; Stop all additional;flow tolhelagoon -hold' Wastes. in the house. f=possible.
d:' Call app :g. .um in contractor:.
e. Make sure no surface watt,.isl entenig lagoon:
B. Runoff from wastes application field-action:.nclude:
a Immediately stop wastes application:: -
b. Create a temporary ;divers on or -berm t61 contain .the: -waste.: :
c. Incorporate waste to reduce furtl er.;runoff
d. Evaluate and;elimiriate :the reasons-):tl at caused the runoff..: .
e. Evaluate the: appl. ication rates .for the. fields .where runoff : occurred.'.
C. Leakage from the waste pipes and sprinkler -action includes:
a:. Stop recycle;.(flushulg system) .pump
b. Stop irrigation pump
c. Close values to.eliminate further discharge.
d ; Repair a111eaks prior to restarting pumps
D. Leakage from flush system, Houses,: solids_separators=action:includes: .
a. Stop recycle (flushing system)_ pump...
b. Stop irrigation pump. . :
c. Make sure no siphon effect has been created,
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks -possible action:

a. Dig a small sump or ditch t-lo-;catch all seepage, put in a submersible pump, and
pump back into lagOon:
b. If holes are caused by burrowing an als, trap or remove anima s and` Alfh6ies
and compact with a clay type soil:
c.- Have a professional evaluatethe do ifibne of "the sidd w"alls a nd Ifielagbon
bottom as soon as poiss--ible
2. Assess the extent of the spill and note any obvious damages.
& Did the waste reach any 'surface waters?
b,- Approximately -how inuchWas released andwhat duration? -
C. Any damage noted, such, as employee injury.; fish kills brpropertydainagd?:
d. -D-idthe-.spill,.IoaLvethe :pr.ope-4 . y?
e. Does the spill. have the potential to -reach surfacavaters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water' wells in danger (either on or off of the property)?
h. How much reached surface waters?.'
3. Contact appropriate agencies.
a. During normal business hours, call- your DWQ(Division of Water Quality)
regional office, at,910-433-3300, afterhours, emergency number:, 1--800-858-
0368. Yourphone call should -include, YOUR 'NAMEE, FACILITY:
i
NUMBER, TELEPHONE-NUMEBERI:THE DETAILS OF TEINCIDENT
FROM ITEM #2 ABOVE, THE EXACT LOCATION OF TFMFACELITY,
AND THE LOCATION OR DIRECTION OF -MOVEMENT OFTHE -
SPILL, WEATHER AND WIND CONDITIONS, THE CORRECTIVE
MEASURES THAT HAVE BEEN UNDER TAKEN, AND THE
SERIOUSNESS OF THE SITUATION.
b. If the spill leaves the property ors enwgsurface waters,- call 10''cal-(EMS)
Emergency Management Services' it-910-592 8996.
c. Instruct EMS to contact local Health',Department,
d. Contact lobal;Soitaiid Water- Conservation District, Natural Resources
Conservation Service office. at 9 10-592;;7963 and Cooperative'Ext.e.*n'sion
Service at 910-592-7161 for advice/technical assistance.
4. If none of the above works call 911 or the -sheriffs' Department and explain your
problem to them and ask that person to contact the proper -agencies for you. -
problem 5. Contact the contractor of your choicatot begin repair of the; rdbl ' tof-mitiftnize off -
site damage.
a. Contractors Name:
b. Contractors Address:
c. Contractors Phone: _9/0-:5:9R;-f77/­
Page 2

6. Contact the technical specialist who certified the lagoon.
a. Name: N . &.41Z Fo�7
b. Phone: ?la . 02.57V
7. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
8. ff you are a contract swine grower associated with a swine company integrator,
contact the company representative at 910-592-5771.
Page 3

Insect Control Checklist for Animal Operations
Source Cause �� IIAIPs to Control 1115CCIS — — ,
Site Specific I I. actices
Liquid S)'slen►s
11►.ISh Gutters • Accnnnrlation u!"solids O I-Itrsh system.is designed and operate((
sufficiently to remove accumulated solids front
gutters as designed.
0 (remove bridging oraccumulatcd solids at
discharge
La,uons and Pits Crusted Solids --115 Maintain lagoons, SCIIIIng basins an(I pil:5 where
Pest brMling.is apparew to n••inin►izc the
crusting of solids to a depth of no more than 6 -
__ _ 3 inches Overmore than 30% of surface.
;I.U%Vsth ive Vegetative s Uccayinb i'ebclaliun -- ■ Maintain vegetative control along hanks or
—
lagoons lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
— along miler's edge on impoundment's perimctcr.
1
UI'y Syslelils Iced Spillage i Uesig", operale and maintain feed systems (e.g., -
bunkers and troughs) to minimize the
accumtrlalion of decaying wastage.
w Clean ujl spillage on a routine basis (e.g., 7 - IU
(lay interval during summer; 15-30 day inlcrval
during winter).
feed Slorage -- Accumulations o!• feed residues O lteduce Itloisture accumulation wilhin and-- — -- — --
al'otlnd intnlcdiatc perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequatc containn►enl (e.g.,.
covered bits for brewer's grain and similar high
nloislurc grain products).
Cl Inspect for and reinove or break up acculnulaled
solids in filler strips around fee([ storage as
needed.
AM IC - November t I, 1996, Page I

f.
Source
Animal Holding Areas
ause
• � Accun utlatio s ofanimal wastes ®
�
Mh to Control Insects. Site Specirc Practices
Elimigate low areas tbat,trap moisture, along
and -feed wastage
.
fences and other :locatiotys where waste
accumulates and disturbance by animals is
minimal.
®
Maintain fence rows and filter strips around
animal holding areas to minimize
accumulations of wastes (i.e., inspect for and
remove or break up accumulated solids as
Dry Manure Handling
Systems
® --ni-
Accumulations of amal wastes ®
needed). ,
Remove spillage on a joutine basis (e
g.,
daiinterval during summer,15-30 day interval
during winter) where manure is loaded for land
application or disposal.
,O
Provide for adequate drainage around manure
stockpiles.
®
Inspect for and remove or break up accumulated
wastes in filter .strips around stockpiles and
manure handling areas as needed.
For more information contact the Cooperative Extension Service, Depadment of Entomology, Box 7013, North Carolina State-universi , _ l
Raleigh, NC, 27695-7613. h
AMIC - November 11, 1996, Page 2

rxa iit ` JI .. \ -
J 1 J
Swine Farm Waste Management Odor. Control Checklist
""'%'° Cause
amps"' NinimlleOdor
Farmatt:ad � Swine produaction on � Site Specific Practices
Vegctative.or wooded buffers;
■ , Recommended. -best management practices;
■ Goo_ d judgment and common sense
Animal body surfaces Dirty manure-covercd animals ■. Dry floors
Floor surfaces Wet manure -covered floors ® Slotted floors;
■ Waterers located over slotted floors;
f] Feeders at high. end of solid floors;
IT. Scrape manure:buildup from floors;
0 Underfloor ventilation for drying -
Manure collection pits • Urine; ■ Frequent immure removal by- flush, pit recharge, :.
• Partial microbial decomposition orscrape;
■ .Underfloor t chlilation
Ventllatlon exhaust fans Volatile gases; g ■ ..Fan maintenance; -
Dust ■ Efficient air: ovement
Indoor aurfaccs Dust ■ Wasltdown bctvrecn groups of animals;
■ Fced�additives; .
O Fecder.covers;
■ Feed delivery downspout extenders.to feeder
covers
Flush tanks • Agitation of recycled lagoon O Flush tank covers; — -- -- r�
liquid while tanks arc filling p Extend fill lincs.to near bottom 'of. tanks with
rium aueys Agitation di
conveyance
VMS.'
wamcwatcr ! Underfloor flush with underfloor ventilation
Pit recharge points Agitation of recycled lagoon ®' Extend recharge lines to near bottom of pits
liquid while pits are -filling %, .. !III anti -siphon vents
Lift stations • Agitation during sump tank O Sump tank covers'
tilling and.drawdown .
outside drain collection • Agitation during wastewater O Box covers
or junction boxes conveyance
AMOC- November 11, 1996, Page 3

t
Source Cause BWs to Minimize Odor Site Specific Practices
End of drainpipes at • Agitation during wastewater 11 Extend discharge point of pipes. underneath
lagoon conveyance:.. -. lagoon liquid level.
Lagoon surfaces • Volatile gas emissions; ■ Proper lagoon liquid capacity;
• Biological mixing;- R Correct lagoon startup procedures;.
• Agitation 0 Minimum surface area to -volume ratio;
6 Minimum agitation when.pumping;
® Mechanical aeration;
0 Proven biological additives
Irrigation sprinkler
• High pressure agitation;
a
Irrigate on dry days with little or no wind;
nozzles
® Wind drift
0
Minimum recommended operating
p g pressure;
Pump intake near lagoon liquid surface;
®
Pump from second -stage lagoon
Storage tank or basin
Partial microbial decomposition;
0
Bottom or midlevel loading;
surface
• Mixing while fillin
g+ 0 Tank covers;
• Agitation when emptying t3 Basin surface'mats of solids;
0
Proven biological additives or oxidants
Settling basin surface
:
Partial microbial decomposition;
a
Extend drainpipe outlets underneath liquid
•
Mixing while filling;
level;
•
Agitation when emptying
0
Remove settled solids regularly
Manure, slurry or sludge
•
Agitation when.spreading;
O
-Soil injection of slurry/sludges;
spreader outlets
.
Volatile gas emissions
O
Wash residual manure from spreader after use;
0
Proven biological additives or oxidants
Uncovered manure,
o
Volatile gas emissions while
O
Soil injection of slurry/sludges
slurryor sludge on field
surfaces
drying
®
Soil incorporation within 49 hrs.;
0
Spread in thin uniform layers for rapid drying;
0
Proven'biological additives or oxidants
Dead. animals ,
•
Carcass decomposition
■
Proper disposition of carcasses
Dead animal disposal
•
Carcass decomposition.
0
Complete covering of carcasses in burial pits;
pits
0
Proper location/construction of disposal pits
Incinerators
•
Incomplete combustion
0
Secondary stack burners
AK._'.'. November 11, 1996,
Page 4
"-"`

Source Cause BMPs to Minimize. Odor Site Specific Practices
Standing water around Improper drainage; 0 Grade and landscape such that water drains
facilities Microbial decomposition of away from facilities
organic matter
Manuro tracked onto Poorly maintained access roads O Farm access -road maintenance
public roads from farm
access
Additional Information : Available From :
Swine Manure Management ; 0200 RuIcBMP Packet NCSU, County Extension Center
Swine Production Faun Potential Odor Sources and Remedies ; EBAE Fact Sheet NCSU -BAE
Swine Production Facility Manure Management: Pat Recharge - Lagoon Treatment; EBAE 128-88 NCSU - BAE
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment ; EBAE 129-88 NCSU - BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage ; EBAE 103-83 NCSU - BAE
Calibration of Manure and Wastewater Application Equipment ; EBAE Fact Sheet NCSU - BAE
Controlling Odors from Swine Buildings; PIH-33 NCSU - Swine Extension
Environmental Assurance Program ; NPPC Manual NC Pork Producers Assoc
Options for Managing Odor; a report from the Swine Odor Task Force NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedings Florida Cooperative E.xtcnsion
AMOC -November 11, 1996, Page 5

Version —November 26, 2018
Mortality Management Methods.
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option_
Methods other than those listed must .be approved by the State Veterinarian.
Primary Secondary Routine Mortality
a D Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottomof the 1burial pit should beat least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
JRPndwdna.xendedn"tant .---
Complete incineration according to 02 NCAC 52C .0102.
© A composting system approved and permitted 6'the NC Department of Agriculture & Con-
sumer Services Veterinary Division (.attach.copy-of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
Q In the: case of dead,poultry.only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method.which, in the professional opinion�pf the State Veterinarian, would -make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
'Mass mortality plans are required for farms covered, by an NPDES permit. These plans are
also recommended: for all animal operations. This plan outlines farm -specific mortality man-
agement methods tobe. used for mass mortality. The NCDA&CS Veterinary Division. sup-
port& a_variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is .activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be -done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
i4
Signature of Farm Owner/Manager Date
-9 it 2-Pi
Signature of Tech ical pecialist Date

PRESTAGE FEEDS
Please review the attached plan and specifications carefully. Retain this plan
for your use and records. It is strongly recommended that you, your contractor
and Soil Conservation Service personnel are in agreement as to how the waste
lagoon is to be constructed . SCS personnel will meet with all concerned parties
and walk over the site to explain all flags and markings. It is important that
everyone understand what is expected so that final construction meets plans and
specification and the job can -be certified for payment (if ACP cost sharing is
involved).
Contact: Soil Conservation Service
303-D East Rowan ST.
Clinton, N.C. 28-928
Phone [phone]
1�.
C'&A5 5
G 4,A)Qe 17 r Wig, 3-79 4 . �.

USDA-SCS
Raleigh, N. C.
Rev. 2182
ANIMAL WASTE MANAGEMENT SYSTEM
Engineering Design Work Sheet
Field Office Clinton Design H. '.Hobson Date 12-17-$5 by — -
Owner's Hamer Prestage Feeds
Location Approximately mile SW of SR 1121 and approximately 2 miles
NW of SR 1007 attach .watershed location sketch)
Popu hato.n'(est) within'1/4 mi. 0 Mo. of inhabited houses within
1/4 mi.` 0 Distance -to no arest.inhabited-house'other than
operator's 32001
T-nn ^f iivpctnck Hogs Type of op:eration,(check one)
Farrow :to-fl Aish Farrow to:feeder pig
x Finish Other
�ouse'9s,
pe t facility (flush, pit, number of houses, dimension.of
etc. )- i- F!
Type of waste treatment: Anaerobic lagoon & holding pond
Anaerobic
lagoon with holding volume x holding pond Pit or tank --,
other
Method.of.handling waste when design.capacity is reached (i.e., pump & irrigation,
honeywagon, etc.)Irrigation (center pivot planned)
Lagoon & Storage Design Data
Type, number, and sizes of .li'vestock:-
1248. sows, x 522�1bs 651,456 lbs
boars x. lbs = lbs
4
pigs x lbs = lbs
_ pigs.x lbs lbs
Total No. for design or: Total lbs for design 651,456 lbs.
RFCEIVED;ti
APR201J .
w6wQualfty
[ mvdonsSecdon

-z-
s.i�n Ca achy for Anaerobic La oon Treatment and Odor Control
De cu. ft./animal.
1 cu. ft./lb. or
Use _ - ft/animal) =
(
1. (lbs) or (animals) X �� cu.ft./lb) or cu,.
651 456 Cu.-ft. ss
x
2. Estimate size of lagoon': ength d h
Cu. ft.
D_es i ' n _for Pond days,. (Longest anticipated period„ before pumpout)
Des i gn period. 90
Zb-year storm
7 i:nches..Normal precipitation less evaporation
for design period 4 _ inches.
-Waste production = 0.00135 lbs/day/lb. live
456'bs. live A. x .00135
3. Volume of waste=��65�,_�.1
X g�days 7 cu . ft.
al/da 7animal x
animals
4. Volume of wastewater = 7,5 gal cu ft,
days 0 cu. ft.:
n-surface for.design period
evaoration on lagoon =
5. Normal precipitation less p 34,816 cu. ft.
ft. X 204 eft: =
in. x 512 -
-� width-
�n/ft_ en t213 cu: ft and surface for design pE
33 x 80,x 80)
6. Normal precipitation less evapora ion on holding p
� ft. x
ft. _ �� cu•` ft.
inches x
length width
1.2 in/ft
7; Storage_req.uired-for.25-year storm ft.
on.lagoon surface
ft. x .. ft... =
Cu.
i n . X. t�-
ength
12�t
pond surface',_
a. Storage required for 25-year storm on holding ,_.. Cu f
leng;ft. x :'ft: _
in. x th width
12 in/ft

-3-
9. Total capacity needed for holding pond (add #'s 3, 4, 5, 6, 7, & 8) _
114,181 1 qu: ft.
10. Total capacity needed for treatment lagoon (add #'s 1 & 9 when treatment
lagoon & holding pond are one component) = 765,637 Cu. ft.=28,357 cu. yds.
Planned Capacity for Treatment Lagoon
500 ft. x 192 ft. 10 ft. w/ 3 1 ss =
avg. length avg. width avg. depth
764,400 cu. ft. = 28,311 cu. yds.
PLUS x 10 w/3:.1 = 1,068 cu. yds. Total
Planned Capacity for Holdin4_Pond 29,379 cu* yds.
ft. x ft. x ft. w/ ss =
avg. length avg. width avg. depth
o cu. ft.
Design for Disposal Area
Annual nitrogen production in fresh waste =
I -VILS Sows
92 l bs N/l b/day x 1,poe,_ }kCA�t. x xWOudaM _ _ 1 bs. N / i'R
Assume 75 % N loss during anaerobic lagoon treatment, storage & land application.
Estimated N available for crop =-92-j-&N 1 bs x_?5% 1 bs .
Type of vegetation or crop to be grown at the disposal. site coastal
Timing and rate of application 600 lbs/ac
Estimated acres needed for effluent disposal -39 -ac•

S. DEPARTMENT OF AGRICULTURE
Soil ConservationService
LOCATION CODE Z o -7O
PLAN.OF EXCAVATED WASTE STORAGE POND
i
i
NAME 57-Aa E F2-7eD5 ACP #
NC-ENG-40
5/83
DATE /Z- /8-85 DISTRICT �,pM�salV
LENGTH 5E)C>I r=NSt0a rLL)I1�)
SI DE SLOPE 3 TO 1 /
C,q 1 c O AYE, TOP ELM
�
,� �/—_�-----MAID SECTION
/ I \ Uj // 1
I
f
� f � o AYE. BOTTOIA ELEY. /
LENGTH �1
Volume depth [(area of top) + (area of bottom) + (4 x area midsection = 7_� Cu. Ft.
6
SUMMARY
Use of facility W As7-E 7W0,4-r-,WGA 7"
Capacity $ 7 / 7 7/2- Gallons
Volume Cost -sharing
Cu. Ft.
Soil type Zg -CA VD 455-01-110 W Soils
B. M. description A1.416 /M BAilz o;-
��Wc 2 DoG �oc.a - 2oX•
ST,4 m*c o L ,,y aF'
v m 6 t) Elev. `7 a -a o
Bottom
Elev.
3.8•0
Normal liquid level
Elev.
li$ v _
Storage for normal precip.(Ft)
+ _
Maximum liquid level
Elev..y
Storage for:
25 yr. freq. precip.'
(Ft.)
+ /, O
Crest ESW
Elev.
Stage (Ft.)
+
Freeboard (Ft.)
+ /•�
Top of Dam
Elev.
�50 i7

OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment with minimum odor control. The
time required for the planned fluid level to be reached may vary due to soil
conditions, flushing operations, and the amount of fresh water added to the
system.
Land application of waste water is recognized as an acceptable method of dis-
posal* Methods of application include honey wagons (sprayer or injection) and
irrigation (center pivot, guns, or travelers). Care needs to be taken when
applying waste to prevent damage to crops or runoff from the field.
The following items are to be carried out:
1. Begin pump -out of th.e lagoon when fluid level is 1 foot below the
outlet pipes.
2. Stop pump -out before fluid depth is less than 3 feet deep (this
prevents the loss of favorable bacteria).
3. It is strongly recommended that the treatment lagoon be prechar.ged
to i its capacity to prevent excessive odors during startup. Pre -
charging reduces the concentration of the initial waste entering
the lagoon thereby reducing odors.
4. Keep vegetation on the embankment and areas adjacent to the lagoon
mowed.
5. Repair any eroded areas and establish in vegetation.
6. Recommend that a suitable fence be constructed around the lagoon
for safety purposes.
7. The Clean Water Act of 1977 prohibits the discharge of pollutants
into waters of the United States. The Department of Natural
Resources and Community Development (.DNRCD) - Wastewater Management
Section has the responsibility for enforcing, this law:'
NOTE: An analysis of -the waste water can be obtained at commercial
laboratories or at a fee of $3 per sample at:
N.C. Department of Agriculture Plant Analysis Lab
Agronomic Division
Blue Ridge Road Center
Raleigh, N.C. 27611
Ph. [phone]

LAGOON DESIGN
rator:PRESTAGE FARMS County: SAMPSON Date:08/30/96
P-1
��stance
to nearest residence (other than owner>:
.
AVERAGE LIVE WEIGHT (ALW)
NN
�
0 sows (farrow to finish) x 1417 lbs. =
0 lbs
0 sows (farrow to feeder) x 522 lbs. =
Cl lbs
0 head (finishing only> x 135 lbs. =
0 lbs
0 sows (farrow to wean) x 433 lbs. =
0 lbs
NN
0 head (wean to feeder) x 30 lbs. =
0 lbs
Describe other :
350880
NN
Total Average Live Weight =
350880 lbs
MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
�~
Volume = 350880 lbs. ALW x Treatment Volume(CF)/lb.
ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb. ALW
NN
�
Volume = 350880 cubic feet
�
`.
STORAGE VOLUME FOR SLUDGE ACCUMULATION
SLUDGE ACCUMULATION NOT COMPUTED
N0
Volume = 0.0 cubic feet AT OWNERS REQUEST.
REMOVE SLUDGE
AS NEEDED.
TOTAL DESIGNED VOLUME
mw
Inside top length (feet>--------------------- 235.0
Inside top width (feet)---------------------- 330.0
Top of dike elevation (feet)----------------- 45.0
Bottom of lagoon elevation (feet)------------ 35.0
Freeboard (feet>----------------------------- 1.0
Side slopes (inside lagoon)------------------ 3.0
: 1
-
Total design volume using prismoidal formula
�
�
�
SS/END! SS/EN1D2 SS/SIDE1 SS/SIDE2 H WIDTH
3.0 3.0 3.0 3.0 /229.0 324.0
AREA OF TOP
LENGTH * WIDTH =
229.0 324.0 74196 (AREA OF TOP)
AREA OF BOTTOM
LENGTH * WIDTH =
175.0 270.0
AREA OF MIDSECTION
LENGTH * WIDTH * 4 ,
202.0 297.0
47250 (AREA OF BOTTOM
DEPTH
9.0
239976 (AREA OF MIDSECTION * 4)
[AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/6
74196.0 239976.0 47250.0 1.5
. Total Designed Volume Available =
4 -------

TEMPORARY STORAGE REQUIRED
v
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
235.0 330.0 77550.0 square feet
Buildings (roof and lot water)
0.0 square feet
Describe this area.
�
�
TOTAL DA 77550.0 square feet
Design temporary storage period to be
180 days.
!A.
Volume of waste produced
Feces & urine production in gal./day per
135 lb. ALW 1.37
Volume = 350880 lbs. ALW/135 lbs. ALW *
1.37 gal/day 180 days
I
Volume = 640941 gals. or 85687.3 cubic
feet
�B.
Volume of wash water
This is the amoqnt of fresh water used for
washing floors or volume
�
of fresh water used for a flush system.
Flush systems that recirculate
the lagoon water are accounted for in 5A.
�
Volume = 0.0 gallons/day *
180 days storage/7.48 gallons
-
per CF-
I
Volume = 0.0 cubic feet
in evaporatior\
Volume of rainfell excess of
Use period of time when rainfall exceeds
evaporation by largest amount.
180 days excess rainfall =
7.0 inches
�
Volume = 7.0 in * DA / 12 inches per
foot
Volume = 45237.5cubic feet
5

.
Volume of 25 year..., 24 hour storm
Volume = 7.0 inches / 12 inches per foot
* DA
'
N�
Volume = 45237.5 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
~�
5A. 85687 cubic feet
52. 0 cubic feet
5C. 45238 cubic feet
U�
5D. 45238 cubic feet
TOTAL 176162 cubic feet
'
SUMMARY
Temporary storage period====================>
180
days
Rainfall in excess of evaporation===========>
7.0
inches
25 year - 24 hour rainfall==================>
7.0
inches
Freeboard=================================�==>
1.0
feet
Side
N�
Inside top length===========================>
Inside top width============================>
235.0
330.0
feet
feet
Top of dike0
feet
Bottom of lagoon
35.0
feet
U�
Total required volume=======================>
527042
cu.
ft.
�
~�
Actual design volume========================>
542133
cu.
ft.
Seasonal high wat
feet
Stop pumping
41.3
feet
NN
Must be > or = to the SHWT elev.==========>
��6.71
feet
Must be > or = tomin. req. treatment el.=>
41.0
feet
Required minimum treatment volume===========>
350880
cu.
ft.
NN
Volume at stop pumping elevation============>
353662
�
Start pumping
43.3
feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall==>
496896
cu.
ft.
U�
Volume at start pumping elevation===========>
491005
cu.
ft.
Required volume to be pumped================>
130925
cu.
ft.
N�
�
uped=========>
Actual volume planned to be pm =
Min. thickness of soil liner when required==>
137343
1.5
cu.
feet
ft.
/*�
DESIGNED BY:=.N ^��M* ' APPROVED BY: �� �mG�� ^ 41E
�
.
»� DATE: �13019jr.. DATENOT-! SEE ATTACHED WASTE \.UTILIZATION PLAN
COMMENTS:
*
*
*
*
6

SHEET 1 OF 2
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (perm�nent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year,.but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volumemust always be available.
A maximum elevation is determined Jr, each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s>. If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when,pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste. without
runoff or leachin9.
Land application of waste water is recognized as an acceptable
meth�d of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre�-
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing~pdors. Solids should be
covered with effluent at all times. When precharging is'complete�
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
NN pl^�n recommends sampling and testing of waste (see attachment)
before land application.
U� 3^ Begin temporary storage pump -out of the lagoon when fluid level
NN
reaches the elevation 43.3 as marked by permanent marker. Stop pump
-
out when the fluid level reaches e.levation 41.3 . This temporary
storage, less 25 yr- 24 hr storm, contains 130925 cubic feet or
979317 galions
,
I

..
SHEET 2 OF 2
4. The recommended maximum amount to apply per irrigation is
cme (1) inch and the recommended maximum application rate is 0.3
�r inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8. Keepa minimum of 25 feet of grass vegetated buffer around
N� waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
.anner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
N� pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.