820178_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 82-0178 Certificate Of Coverage Number:
2. Facility Name: Cannadv's Bacon
3. Landowner's Name (same as on the Waste Management Plan): Clarence L Cannad.
4. Landowner's Mailing Address: 1• d Sox 3.25 `i T
City: Clinton State: NC
Telephone Number: 910-564-2687 Ext. E-mail: bacon806 u intrstar.net
5• Facility's Physical Address: 2777 Odom Rd
City: Clinton State:
6. County where Facility is located: Sampson
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"):
10. Operator Name (OIC): Clarence L. Cannadv
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current. Permit: Operations Type
Swine - Wean to Feeder
Operation Tyoes:
NC
AWS820178
Zip: 28328 a:) 9 3 �
Zip: 28328
Clarence L Cannad-,•
-W8364--268-7�Ext. q 10_ �{ O ^ 3 `{ ?
Pr sta a Farms Inc
Phone No.: 910-990-3647
Allowable Count
3,040
OIC #: 20167
Swine
Cattle
Dry Poultry
Other Types
Wean to Finish
Dairy Calf
Non Laying Chickens
Horses - Horses
Wean to Feeder
Dairy Heifer
Laying Chickens
Horses - Other
Farrow to Finish
Milk Cow
Pullets
Sheep- Sheep
Feeder to Finish
Dry Cow
Turkeys
Sheep - Other
Farrow to Wean
Beef Stocker Calf
Turkey Pullet
Farrow to Feeder
Beef Feeder
Boar/Stud
Beef Broad Cow
Wet Poultry
Gilts
Other
Non Laying Pullet
Other
Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
I
CLA
/64769
Z6199'
19.00
X
.�9
Y
�as�ee—
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), sh ned b% the owner and a certified technical specialist, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoonistorage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWNIP items above to: 2019PermitRenewalnncdenr_gnv

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.613, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name: � ( rN1ye4 e v, G�� � Title: _ OWJ fr A)0'V'.X �w
Signature: Date: / 9
Name:
Signature: _
Title:
Date:
Name: _ _ Title:
Signature: _ Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER
Cotivmor
MICHAEL S. REGAtN
seemr&y
LINDA CULPE:PPER
Direefor
Clarence L Cannady
Cannady's Bacon
2777 Odom Rd
Clinton, NC 28328
a Si pF�n.
1
NORT4 CAROLINA
€nvfranmentof o"Itty
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
February 27, 2019
APR 012019
i� ni.nng Al •i rr E:'�y"in,'1
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at hit s://de .nc. Lov/about/divisions/water-resources/water uality-regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure tour continued coverage under the State Non-Disch a General Permits ou must submit an application for
Permit coverage to the Division. Enclosed you will find a "R uest for Certificate of Covera a Facility C Ex irin State Non-Dischar a General Permit." Turrently Covered b an
Please note that you must include one he nr
application form must be co m ]ete si aed and returned by Ail 3. 2019.
completed and signed1 co of the Certified Animal Waste Mana ement Plan CAWMP with the
application form. annlication form A list of items included in the CAWMP can be found on a e 2 of the renewal
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Enclosures
cc (w/o enclosures):etteyille Regional Office, Water Quality Regional Operations Section
Samnson County Soil and Water Conservation District
AFOG Section Central Files - AWS 20178
Prestaee Farms Inc
Norti-.sm'naD2partmentof,EnVronments.Q.La-,Iy I D:VsbnofWater Rescurces
r 512 N. Se sbcr}' St- 1 IR36 Me Sera De Zerter I Re a 9. North Zsr6 ^a 276ge-IS3£

Waste Utilization Plan
Producer: Lee Cannady
Name of Farm: Cannady's Bacon County: Sampson
Location: 2777 Odom Rd.
Clinton NC 28328
Phone: [phone]
Type of Operation: Wean -Feeder
Number of Animal: 3040
Storage Structure: Anaerobic Lagoon
Method of Application: Irrigation
Amount of waste produced per year:
PAN 1284 ton/year
Amount of plant available N
(PAN) 1459 lbs./year
The waste from yoL.r animal facility must be land applied at a specified rate to prevent
Pollution of surface water and/or groundwater. The plant nutrients in the animal waste
should be used to reduce the amount of commercial fertilizer required for the crops in the
fields where the was a is to be applied.
This waste utilizati n plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balaPced for realistic yields of the crop to be grown.
Several factors are important in the implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environmentally
safe manner.
1. Always Ipply waste based on the needs of the crop to be grown and the nutrient
content bf the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil type are important as they have different infiltration rates, leaching potentials,
cation a change capacities, and available water holding capacities.
3. Normall II waste shall not be applied to land eroding at more than 5 tons per acre per
year. Walste may be applied to land eroding at 5 or more tons per acre annually, but
less than110 tons per acre per year providing that adequate filter strips are
established.
i
4. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Dither of these conditions may in runoff to the surface waters which is not
allowed (uInder DWQ regulations.
S. Wind coyI' clitions should also be considered to avoid drift and downwind odor problems.
6. To ma4ize the value of the nutrients for crops production and to reduce the potential for
pollutio1, the waste should be applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy. Injecting the waste or disking will
conserv� nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change methods
in the future, you need to revise this plan. Nutrient levels for different applications methods are
not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste manager -lent facility. In some cases you may want to have plant analysis made, which

Cannady's Bacon
Page 2
could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible! o as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract No.
Pull No. .
Soil Type
Crop
Code
Yield/Ac
Lbs. N
unit
Acres
Lbs N
Used
Month to
Apply
Lbs. N
Per Ac.
11135
F2-HA
WaB
Millet (Graze)
4.9
40.6
1.20
239
MAR15-AUG
199
11135
F2-HI3
WaB
Millet (Graze)
4.9
40.6
1.00
199
MAR15-AUG
199
11135
F2-H$
WaB
Millet (Graze)
4.9
40.6
0.91
181
MAR15-AUG
199
11135
F2-1­10
WaB
Millet (Graze)
4.9
40.6
0.81
161
MAR15-AUG
199
11135
F2-HI1
WaB
Millet (Graze)
4.9
40.6
0.55
109
MAR15-AUG
199
11135
F2)HA+E
WaB
SG -Graze
1
75
4.47
335
SEP-MAR
75
11135
F3-HA
WaB
CB (Graze)
4.05
49
1.20
239
MAR-SEP
198
11135
F3-HB
WaB
CB (Graze)
4.05
49
1.20
239
MAR-SEP
198
11135
F3-HC
WaB
CB (Graze) 1
4.05
49
1.03
205
MAR-SEP
198
11135
(F3)HA-HC
WaB
SG -Graze
1
75
3.43
257
SEP-MAR
75
Total 7.90 2164lbs.
Available Nitrogen 1459 lbs.
Surplus or deficit -705 lbs.
Field(s) to apply waste by honey wagon
Tract No.
Field Nb.
Soil Type
Crop
Code
Yield/Ac
Lbs. N
unit
Acres
Lbs N
Used
Month to
Apply
Lbs. N
Per Ac.
11135
1
WaB
CB
5.4
49
0.9
238
MAR-SEP
264
3577
41
NoB
CB
6.4
46
18.3
5362
MAR-SEP
293
13972
5
NoB
Corn
138
0.95
3.0
393
FEB15-JUN
131
13972
5
NoB
Wheat/SG
59
2.09
3.0
369
SEP-MAR
123
13972
5
NoB
Soybeans
35
3.91
3.0
411
APR-SEP15
137
14687
6
NoB
Corn
138
0.95
6.2
812
FEB15-JUN
131
14687
14867
6
6
NoB
NoB
Wheat/SG
Soybeans
59
35
2.09
3.91
6.2
6.2
763
849
SEP-MAR
APR-SEP15
123
137
14687
7
Ra
Fescue G)
3.37
43
5.5
798
AUG-JUL
145
14750
8
NoA
Fescue (G)
2.63
46
3.1
375
AUG-JUL
121
14687
9
Ra
Fescue (G)
3.37
43
8.6
1247
AUG-JUL
145
13972
10
Ln
Fescue (G)
3.37 1
43
6.0
870
AUG-JUL
145
total 60.8 12486 lbs.
Field(s) are reduced by half to cover a two-year rotation of corn, wheat/small grain, and soybeans.
Use on IRR-2 form
Field
Acres
5
6.0
6
12.4
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to apply
the waste in a timely manner

Cannady's Bacon Page 3
The applicator is cautioned that P and K may be over applied while meeting the N requirements. In the future,
—� regulations may require farmers in some parts of North Carolina to have a nutrient management plan that
addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (i.e. small grain, etc. interseeded in bermudagrass), forage must be removed through
grazing, hay and /or silage. Where grazing, plants should be grazed when they reach a height of six to nine
inches. Cattle should be removed when plants are grazed to a height of four inches. In fields where small grain
etc. is to be remove for hay or silage, care should be exercised not to let small grain to reach maturity,
especially late in the season ( i.e. April or May) Shading may result if small grain gets too high and this will
definitely interfere With the stand of bermudagrass. This loss of stand will result in reduced yields and less
nitrogen being utilized. Rather than cutting small grain for hay or silage just before heading as is the normal
situation, you are encouraged to cut the small grain earlier. You may want to consider harvesting hay or silage
two to three times during the season, depending on the time small grain is planted in the fall.
The ideal time to interplant small grain, etc. is late September or early October. Drilling is recommended over
broadcasting. Bermu agrass should be grazed or mowed to a height of about two inches before drilling for best
resu Its.
Caution must be exercised in grazing or haying summer annuals under stressed conditions. Nitrate poisoning
may occur in livestock. Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres excluding required buffers, filters strips along
ditches, odd areas u able to be irrigated, and perimeter areas not receiving full application rates due to
equipment limitatio s. Actual total acres in the field listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at agronomic rates.
The sludge will be nutrient rich and will require precautionary measures to prevent over application of nutrients
or other elements. Yqur production facility will produce approximately 219 lbs. of plant available
nitrogen per year in he sludge.
If you remove sludge every 5 years you will have approximately 1094 lbs. of PAN to utilize. Assuming
you apply this PAN to hybrid bermudagrass hayland at the rate of 300 lbs/acre you will need
acres of land. If you apply the sludge to corn at the rate of 125 lbs. of nitrogen per acre you will need
acres of land. Please be aware that these are only estimates of the PAN and the land needed. Actual
requirements could ary by 25% depending on the sludge waste analysis, soil types, realistic yields, and
application methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation applic ion rate should not exceed the intake rate of the soil at the time of irrigation such that
runoff or ponding occurs. This rate is limited by initial soil moisture content, soil structure, soil texture, water
droplet size, and organic solids. The application amount should not exceed the available water holding capacity
4

Cannady's Bacon
Page 4
of the soil at the tim of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
If surface irrigation i the method of land application for this plan, it is the responsibility of the producer and
irrigation designer tensure that an irrigation system is installed to properly irrigate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table is provided as a guide for establishing application rates and amounts.
Tract No.
Field No.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
11135
F2-HA
WaB
Millet (Graze)
0.5
1.0
11135
F2-H9
WaB
Millet (Graze)
0.5
1.0
11135
F2-HC
WaB
Millet (Graze)
0.5
1.0
11135
F2-Ha
WaB
Millet (Graze)
0.5
1.0
11135
1`2-5k
WaB
Millet (Graze)
0.5
1.0
11135
F2)HA=HE
WaB
SG -Graze
0.5
1.0
11135
F3-HA
WaB
CB/Graze
0.5
1.0
11135
F3-HB
WaB
CB/Graze
0.5
1.0
11135
F3-HC
WaB
CB/Graze
0.5
1.0
11135
(F3)HA-;HC
WaB
SG -Graze
0.5
1.0
Tract No.
Field No.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
11135
1
WaB
CB
0.5
1.0
3577
4
NoB
CB
0.5
1.0
13972
5
NoB
Corn
0.5
1.0
13972
5
NoB
Wheat/SG
0.5
1.0
13972
5
NoB
Soybeans
0.5
1.0
14687
6
NoB
Corn
0.5
1.0
14687
6
(
NoB
Wheat/SG
0.5
1.0
14867
6
NoB
Soybeans
0.5
1.0
14687
7
Ra
Fescue (G)
0.5
1.0
14750
8
NoA
Fescue (G)
0.5
1.0
14687
9
Ra
Fescue (G)
0.5
1.0
13972
10
Ln
Fescue G)
0.5
1.0

Cannady's Bacon Page 5
This is the maximum application amount allowed for the soil assuming the amount of nitrogen allowed for the
crop is not over applied. In many situations the application amount shown cannot be applied because of the
nitrogen limitations. The maximum application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on the
average of once everf 6 months. In no instances should the volume of the waste be stored in your structure
be within the 25 year 24 hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and the waste applicator to ensure that the spreader equipment is operated
properly to apply the correct rates shown in the tables. Failure to apply the recommended rates and amounts of
nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you have receive the waste analysis report for assistance in determining the
amount of waste per acre and the proper application rate prior to applying the waste.
NARRATIVE OF OPER TION

Cannady's Bacon Page 6
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2. There m ist be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3. Animal aste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields bzsed on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
4. Animal (waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may beapplied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year pro Ading grass filter strips are installed where runoff leaves the field. (See FOTG
standard 393 -Filter Strip).
5. Odors cdn be reduced by injecting the waste or disking after waste application. Waste
should root be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conv .ntionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone tc flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid w� ste shall be applied at rates not to exceed the soil infiltration rate that runoff
does nooccur offsite or to the surface waters and in a method which does not cause drift
from th site during application. No ponding should occur in order to control odor or flies.
8. Animal %kaste shall not be applied to saturated soils, during rainfall events, or when the
surface ids frozen.
9. Animal waste shall be applied on actively growing crops in such'a manner that the crop is
not COVE red with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10. Waste nlutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall no� be applied more than 30 days prior to planting of the crop or forages breaking
dormanrv.
11. Any need swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and fromII any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).

Cannady's Bacon Page 7
REQUIRED SPECIFICATIONS
(continued)
APR 01 Z019
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned' =� ' F
by he lailidowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animalaste shall not be discharged into surface waters, drainage ways, or wetlands by
dischargi2 or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner ithat causes no runoff or drift from the site.
16. Domestic and industrial waste from wash down facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidences of
erosion, leakage or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to �revent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20. Animal taste can be used in a rotation that includes vegetation and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications of animal waste
during the crop season.
21. Highly v'sible markers shall be installed to mark the top and the bottom elevations of the
tempor ry storage (pumping volume) of all waste treatment lagoons. Pumping shall be
manage I to maintain the liquid level between the markers. A marker will be required to
mark th maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimun� crop production and maintained. Soil and waste analysis records shall be kept
for five (5) years. Poultry dry waste application records shall be maintained for three (3)
years. 'Haste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.

Page 8
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Cannady's Bacon
Owner/Manager Agreement Lee Cannady
I (we) understand an will follow and implement the specifications and the operation and maintenance proce-
dures established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the North Carolina Division of Water Quality
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to the surface waters of the state from a storm event less severe than the 25-year, 24 hour
storm. The approved plan will be filed on -site at the farm office and at the office of the local Soil and Water
Conservation District, and will be available for review by NCDWQ upon request.
Name of Facility
Signature:
_ LJ
Name of Manager (if different from owner)
Signature:
Name of Person Preparing Plan: G. Glenn Clifton
Affiliation: Prestage Farms, Inc. Phone: [phone]
Address: P.O. Box 438
Clinton, ANC 28329
Signature:.
Date: // 8
Date:
Date: ) 8

I F f Fl* F-1-T -l-q-'r- --- i -T-7r- F 1_17
j 1 4
..... ..... . . . . . . . .
E,
-I- F -I-
r
r r
F I
i .1 7
A
. . . . . . . . ....
. . . . . . . . . .
Ir
i _77
it
p
-T
4 1-
t
A L.
F: E
_4_44+
L
I ------- ---
7--F
r
11-4.
T=
'T T
GA T
�TA
1-1 4-
f
F "["T
1.
L I
r r r -
t
t I---
! , - , f. -
I F I r 1, r

OKMJ.
Cannady's Bacon
Lea
.: Cannady �.
�.- -Spray Field(s)
Sampson County ,
Al
Pw
T. C
;ITIL4
�r =t 1 inch = 500-feet
� - -i _ r. �it�"�C- 1A • o: r u[iae ii=•To I Cl jy[R+3[' G11i F1' n

:r'-'ir:Lee Cannady County: Sampson
Date:
07/11/94
'ance to nearest residence (other
than owner):
1000.0
feet
AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish)
0
x 1417
lbs.
sows (farrow to feeder)
0 head (finishing only)
x 522
lbs. -_
0
0
lbs
lbs
0 sows (farrow to wean)
3040 head (wean
x 135
x 433
lbs. _
lbs. =
0
0
lbs
lbs
to feeder)
Describe other
x 30
.lbs. =
91200
lbs
0
Tota
Average Live Weight =
91200
lbs
MINIMUM REQUIRED TREATMENT VOLUME
OF LAGOON
Volume = 91200 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb. ALW
Volume = 91200 cubic feet
STORAGE VOLUME FOR SLUDGE ACCUMULATION Sludge Accumulation Not Computed At
Volume = Owners Request Remove Sludge
0.0 cubic feet As Needed
'."OTAL DESIGNED VOLUME
Inside top length (feet)---------------------
Inside top width (feet) --------
120.0
Top of dike elevation (feet) ---------- 151.0
Bottom of lagoon elevation (feet)------------ 5.0
Freeboard (feet) ---- _ ___ 40.0
1.0
Side slopes (inside lagoon) ---------_ ------
_- 3.0
1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDEI SS/SIDE2 LENGTH WIDTH
3.0 3.0
DEPTH
3.0• 3.0 204.0 114.0
10.0
AREA OF TOP_
LENGTH * WIDTH =
204.0 114.0 23256 (AREA OF TOP)
AREA OF BOTTOM
LENGTH * WIDTH =
144.0 . 54.0 7776 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
174.0 89 58464 (AREA OF MIDSECTION
* 4)
CU. FT. _ [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM]
23256.0
* DEPTH/6
58464.0 7776.0
1.7
Total Designed Volume Available =
149160 CU. FT.

TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
210.0 120.0 25200:0 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
TOTAL DA 25200.0 square feet
Design temporary storage period to be 180 days.
Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
-� Volume = 91200 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 166592 gals. or 22271.7 cubic feet
Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 14700.0 cubic feet

D. Volume of 25 year - 24 hour storm
Volume = 7.0 inches t 12 inches per foot * DA
Volume = 14700.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
2227.2
cubic
feet
5B.
0
cubic
feet
5C.
14700
cubic
feet
5D.
14700
cubic
feet
TOTAL 51672 cubic feet
SUMMARY
Temporary storage period____________________>
180
days "
Rainfall in excess of evaporation=====______>
7.0
inches '
25 year - 24 hour rainfall__________________>
7.0
inches
Freeboard___________________________________>
1.0
feet
Side slopes_________________________________>
3.0
1
Inside top length___________________________>
210.0
feet
Inside top width____________________________>
120.0
feet
Top of dike elevation_______________________>
51.0
feet '
Bottom of lagoon elevation__________________>
40.0
feet
Total required volume_______________________>
142872
cu ft.
Actual design volume________________________>
149160
cu. ft.
Seasonal high watertable elevation (SHWT)===>
46.2
feet
Stop pumping elev.__________________________>
47;2
feet
Must be > or = to the SHWT elev.====______>
46.2
feet
Must be > or = to min. req. treatment el.=>
46.0
feet
Required minimum treatment volume=====______>
91200
cu. ft.•
Volume at stop pumping elevation=====_______>
91259
cu. ft.-
Start pumping elev.------------------------->
49.3
feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25'yr.- 24 hr. rainfall=*
134460
cu. ft.,-
Volume at start pumping elevation=====______>
133344
cu. ft.
Required volume to be pumped________________>
36972
cu. ft.
Actual volume planned to be pumped=====_____>
42085
cu. ft.v
Min. thickness of soil liner when required=*
1.6
feet
DESIGNED BY: Lanier & Houston CHECKED BY:� n'a
DATE: 7 ! 1./ / i `t DATE: ? 31 19
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS:
*

' OPERATION AND MAINTENANCE PLAN SHEET 1 OF 2
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined, in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation50-3,4+-S� as marked by permanent marker. Stop pump -
out when the fluid level reaches elevation17.4,47-r2-. This temporary
storage, less 25 yr- 24 hr storm, contains 36972 cubic feet or
276548 gallons.

SHEET 2 OF 2
4. The recommended maximum amount to apply per irrigation is
one (1).inch and the recommended maximum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. Seep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8. Seep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Wa-ste:shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits .the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

TYPICAL VIEW OF A ONE -STAGE LAGOON SYSTEM
Confinment Building Top Width-Ldsiti•G ���
Settled Top Elevation
Pipe Invert Elevation
it -
Pit 1; Ss 3 :I
TREATMENT
LAGOON
sS_L:i
—
11 Pipe (Needs to he adequately
supported)
Bottom Slevation 0,0
NOTE: RIP -RAP, FLEXIBLE PIPE OR OTHER SUITABLE MATERIAL WILL BE
PLACED AT PIPE OUTLETS TO PREVENT EROSION OF CLAY LINER

PLAN OF EXCAVATED WASTE STORAGE PIT
NAME: ee cl,'\n Date:
county: ,\ "�:a
Address:
See io�'� rf�o�/ Ca�aon"E Houses
SIDE SLOPE— •• to 1
a EYE. TOP ELEV. /�O`r.
/ ! EVE. BOTTOM ELEV. /
L_
(Sw bmt for Vot+aa eateuletiaw)
Use of facility:
Capacity: S G Ions J 4 9 1 1, n Ft3
Soil -Type:
Bench Mark Descr ptoon a:1 J.,z + ,� ^ P) , A k n
Bottom �
Elev. ,0
Normal Liquid Level Elev. 7 5
Storage for normal Precip. (+) _ Ft.
Maximum Liquid Level Elev. a-3
25 yr. Storm Storage+� t.
Crest M Elev.
Max.Flow Depth (+) Ft.
Freeboard {+) Ft.
Top of Dam
Y,

1.
ti
FILL
AV=ACi C:Mrw r7i n
/, �
OAMr MArQIAL VARIABLE �
t
AD CLAY
�.6 FEET THIC
CLAY LINER
SOM CLAY -CLAY
TYPICAL CROSS-S&CTION OF
LAGOON CONSTRUCTION WITH •
PARTIAL CLAY LINER
1 . (o
�FFET THICK CLAY LINER
(N IN IMMI )
RXCAVATS THIS AREA AND
�I3ACKFILL WITH CLAY
EXCAVATE
FILL
—r - — AVERAGE GRAD
VARIABLE SANDY MATERIAL
No CLAY
FEET THICK 1, 6'
CLAY LINER
SANDY CLAY -CLAY
fu
' MMITIONAW EXCAVATION DUE TO LINERS
WEIIIlCE DEPTH TO CLAY _ :2�x f ,6 FEET THICK X DISTANCE � .� 3 CUBIC FEET =
���_C UD I C YAItDi,
CIE: WWN AREAS OF UNSUITABLE MATERIAL ARE ENECOMITERED, TKY WILL NEED TO BE EXCAVATE
I. FEET BELOW GRADE, BACKFILLED AND COWACTED WITH A SCS APPROVED MD A MIIM1�il1M OF
ATERIAL (SC. CL. CFI),

Lee C-nnmdy
30 40 wea n ! Feeder
0+00 1 toy ztoo 3tov
A 4q,g- TaM - Eke. Smo
Wo .4cN-;I ll" Piro WOODS
A +qg. A Ir
30
Olt
b %}°fir 41
—)I 49
K N p S F
cl c 48-
S61 .�
ejeV 40.0
C 5! :r S s S0 7. �� 4q'4 `F8 N 'fig
Sal oo b'roodl
3d n+0041.1 G}SU
� SO 9 SI •3 __ --- ~— +fib•
PATP
E Sl •b 4q•8 4$• atroWS
N
r�
ScR�
"=100�

L LI ne.
jvtfp yvenni feed-f
5o
4S
u0
2I
r.
EoeA Work Volume-f
r—Kcat.-as+;b.•. -- 4S73 t..ydj
Frlt
hike — /Y-07 cuyd!
Pool -' 1796 cuyofj
To+a I -- 3203 0 - yd1
GuffFill Ra+io— 1"f/1.0
0.,+14 P
Elev. 4q
Dike el'.. S2.0,
blk a W r d+h I.2.0
,,i;ke. 0.4, 51.0,
D; K,- w'.AU, 11IN.
7tu.G aSiDrcr ��! J_U•�, I
rEle
LYJ in PVynoi/IG� r
IPerm. S+orp'�/ EIC� µ7.2'—
t=�j I
I I
II I I.6 Compacted C�ay ner Where ursv�4blc
Aoffom Oev, ' matey al ib founj
40.0

August 11, 2003
APR U' 1
Cannady's Bacon
Clarence Lee Cannady
Facility h 82-178
2777 Odom Rd
Clinton I,C 28328
Specifications to raise dam of existing lagoon 1.0 foot in elevation:
1. Remove vegetation and topsoil in area to be filled and stock pile.
2. Place sandy clay (SC} material from borrow pit located on site with dozer
maintaining a 3:1 side slope and a 12 foot top at elevation 52.0.
3. Soread stockpiled material over fill area 2-3 inches thick. Areas that are not
cowered sprig to centipede grass.
4. Lime and fertilize to soil test recommendations.
5. Lagoon level gauge will be installed to reflect the increase in height of dam.
G. Glenn Clifton
Technical Specialist
Prestage Farms, Inc.

perator:Lee Cannady County: Sampson
-i stance to nearest residence (other than owner):
AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish)
0 sows (farrow to feeder)
0 head (finishing only)
0 sows (farrow to wean)
3040 head (wean to feeder)
Describe. other :
x
x
x
x
x
Date: 06/12/03
1000.0 feet
1417
lbs. _
0
lbs
522
lbs. _
0
lbs
135
lbs. _
0
lbs
433
lbs. _
0
lbs
30
lba. _
91200 lbs
0
Total Average Live Weight = 91200 lbs
�. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 91200 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb. ALW
Volume = 91200 cubic feet
STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
1. TOTAL DESIGNED VOLUME
SLUDGE ACCUMULATION NOT COMPUTED
AT OWNERS REQUEST. REMOVE SLUDGE
AS NEEDED.
Inside tp length (feet) ---------------------
Inside tap width (feet) ----------------------
Top of dike elevation (feet) -----------------
Bottom of lagoon elevation (feet)------------
Freeboarl (feet) -----------------------------
Side slopes (inside lagoon) ------------------
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH
3.0 3.0 3.0 3.0 207.0
AREA OF TOP
LENGTH * WIDTH =
207.0 117.0
AREA OF BOTTOM
LENGTH * WIDTH =
141.0 51.0
213.0
123.0
52.0
40.0
1.0
3.0 : 1
WIDTH DEPTH
117.0 11.0
24219 (AREA OF TOP)
7191 (AREA OF BOTTOM)
AREA OF
MIDSECTION
LENGTH
WIDTH x 4
174.0
94.0
58464 (AREA
OF MIDSECTION - 4)
CU. FT.
_ [AREA TOP
+ (4*AREA MIDSECTION)
+ AREA BOTTOM] DEPTH/6
24219.0
58464.0
7191.0 1.8
Total Designed Volume
Available = 164769 CU. FT.

- . TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (,top of dike)
Length Width =
123.0 26199.0 square feet
Suildin4a (roof and lot water)
@.� square feet Describe this area.
TOTAL DA 26199.0 square feet
Design tlemperary storage period to be 180 days.
n. Volume of wal to produced
Feces & urine production ion in gal./day per 135 lb. ALW 1.97
Volume = 91200 lbs. ALW1135 lbs. ALW * 1.37 gal/day 180 days
Volume = 166592 gels. or 22271.7 cubic feet
�+ Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume =i 0.0 gallons/day 180 days storagel7.48 gallons
Volume =0.0 cubic feet per CF
Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.0 inches
Volume =i 7.0 in T DA / 12 inches per foot
Volume = 15282.8 cubic feet

5D. Volume of 25 year - 24 hour storm
Volume = 7.0 inches / 12 inches per foot x DA
Volume = 1582.E cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
22272
cubic
feet
58.
0
cubic
feet
5O.
15263
cubic
feet
5D.
15283
cubic
feet
TOTAL 52837 cubic feet
Q. SUMMARY
Temporary
storage period____________________>
180
days
Rainfall
in excess of evaporation=====______>
7.0
inches
25 year
- 24 hour rainfall__________________>
7.0
inches
1.0
feet
Side slopes_________________________________>
3.0
: 1
Inside
op length___________________________>
213.0
feet
Inside top
width____________________________>
123.0
feet
Top of dike
elevation_______________________>
52.0
feet
Bottom of
lagoon elevation__________________>
40.0
feet
Total r
quired volume_______________________>
144037
cu. it.
Actual
esigr, volume==______________________>
164769
cu. ft.
Seasonal)
high watertable- elevation
46.2
feet
Stop pumping
-(SHWT)===>
elev. ------------------>
47.4
feet
Must bye
> or = to the SHWT elev.====______>
46.2
feet
Must be
> or = to min. req. treatment el.=>
46.0
feet
Required
minimum treatment volume=====______>
91200
cu. St.
Volume at
stop pumping elevation=====_______>
89618
cu. it.
Start pumping
elev._________________________>
50.3
feet
Must be
at bottom of freeboard & 25 yr. rainfall
Actual volume
leas 25 yr.- 24 hr. rainfall==>
149486
cu. ft.
Volume at
start pumping elevation=====______>
148288
cu. ft.
Required
volume to be pumped________________>
37554
cu. ft.
Actual volume
planned to be pumped=====_____>
58670
cu, It.
7 . COMPUTATIONS �Y: A .,A(, mv,
PA, 4 4y 4wue w, A-c- ,
DATE: $/ 11
103
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTSI:

a
«
/«E zzwGTx _ kzi3
�eE C�NwAQ/
2040 w2Aw.rt!§F
6 o ,- .w6jza use
•& DAM £levik 2,»
-ro
&;@un R/=
EE*AG� F;k»\

SAMPSON COUNTY
EMERGENCY ACTION PLAN
DIVISION OF WATER RESOURCES (DWR)
910-433-3300
EMERGENCY MANAGEMENT SERVICES (EMS)
910-592-8996
SOIL & WATER CONSERVATION DISTRICT (SWCD)
910-592-7963
NATURAL RESOURCES CONSERVATION SERVICE (NRCS)
910-592-7963
COOPERATIVE EXTENSION SERVICE (CES)
910-592-7161
This plan will be implemented in the event that waste from your operation are leaking,
overflowing, or running off the site. You should NOT wait until wastes reach surface
waters or leave your property to consider that you have a problem. You should make
every effort to ensure that this does not happen. This plan should be posted in an
accessible location for all employees at the facility. The following are some action items
you should take.
Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested response to problems are listed below:
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam, any permanent alteration of the
dam should be approved by a qualified technical specialist.
b. Pump wastes to field at an acceptable rate.
c. Stop all additional flow to the lagoon, hold wastes in the house if possible.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from wastes application field -action include:
a. Immediately stop wastes application.
b. Create a temporary diversion or berm to contain the waste.
c. Incorporate waste to reduce further runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinkler -action includes:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Close values to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush system, houses, solids separators -action includes:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Make sure no siphon effect has been created.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks -possible action:

a. Dig a small sump or ditch to catch all seepage, put in a submersible pump, and
pump back into lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes
and compact with a clay type soil.
c. Have a professional evaluate the condition of the sidewalls and the lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, call your DWR (Division of Water Resources)
regional office, at 910-433-3300, after hours, emergency number: 1-800-858-
0368. Your phone call should include: YOUR NAME, FACILITY
NUMBER, TELEPHONE NUMBER, THE DETAILS OF TE INCIDENT
FROM ITEM #2 ABOVE, THE EXACT LOCATION OF THE FACILITY,
AND THE LOCATION OR DIRECTION OF MOVEMENT OF THE
SPILL, WEATHER AND WIND CONDITIONS, THE CORRECTIVE
MEASURES THAT HAVE BEEN UNDER TAKEN, AND THE
SERIOUSNESS OF THE SITUATION.
b. If the spill leaves the property or enters surface waters, call local (EMS)
Emergency Management Services at 910-592-8996.
c. Instruct EMS to contact local Health Department.
d. Contact local Soil and Water Conservation District, Natural Resources
Conservation Service office at 910-592-7963 and Cooperative Extension
Service at 910-592-7161 for advice/technical assistance.
4. If none of the above works call 911 or the sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair of the problem to minimize off -
site damage.
a. Contractors Name:
b. Contractors Address:
mp'a is 2A o2
L't r of 7'i N c-
c. Contractors Phone: /D - 5')0 - 4-513
Page 2

6. Contact the technical specialist who certified the lagoon.
a. Name: G LEN nl C L 1 F7v 4
b. Phone: / a - 5 9-L - S-7 4-110/"
7. Implement procedures as advised by DWR and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
8. If you are a contract swine grower associated with a swine company integrator,
contact the company representative at 910-592-5771.
Page 3

Insect Control Checklist for Animal Operations
Ps to Control Insects Site S
Practices
_
Flush Gutters • Accumulation of solids
aaa'NaN YJJ�4�Ni
0' Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed.
CI Remove bridging of accumulated solids at
discharge
Lagoons and Pits Crusted Solids
0 Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
Cxcessive Vegetative . Decaying vegetation
T O Maintain vegetative control along banks of
Growth
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
Dry Systems
Feeders • Feed Spillage cl Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
accumulation of decaying wastage.
CI Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
during winter).
Feed Storage • Accumulations of feed residues 0 Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
moisture grain products).
0 Inspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AMIC -November 11, 1996, Page I

uI6G
Swine Farm Waste Management Odor Control Checklist
to Minimize Odor
0 - Vegetative or wooded buffers;
111' Recommended best management practices;
W Good: judgment and common sense
Animal body surfaces • Dirty manure -covered animals W... Dr 'floors
Floor surfaces •" Wet manure -covered floors IT Slotted floors;
G' Waterers located over slotted floors;
0 Feeders at high end of solid floors;
W Scrape manure buildup from floors;
0 Underfloor ventilation for drying
• Urin.e; -Frequent manure removal by flush, pit recharge,
• Parilal microbial decomposition or scrape;
0 Underfloor ventilation
Ventilation. exhaust fans . Volatile gases; Q/Fan maintenance;
Dust P-2-1
Ril..
Practices
Indoor surfaces
• Dust
Efficient air movement
Washdown between groups of animals;
17
Feed additives;
0
Feeder covers;
A� Feed delivery downspout extenders to feeder
Flush tanks
Agitation of recycled lagoon
'3
covers "
Flush tank covers;
liquid while tanks are filling
0
Extend fill lines to near bottom of tanks with
Flush alleys
• Agitation during wastewater
11
anti -siphon vents
Underfloor flush with underfloor ventilation �"
conveyance
Pit recharge points
• Agitation of recycled lagoon la
g
liquid while pits are filling
O
Extend recharge lines to near bottom of pits
with anti -siphon vents
Lift stations
• Agitation during sump tank
O
Sump took covers
ftlling and drawdown
Outside drain collection
• ,Agitation during wastewater
l3ox covers
or junction boxes
conveyance
AMOC -November 11, 1996, Page 3

Source Cause
End of drainpipes at • Agitation during wastewater BMPs to Minimize Odor
lagoon W Extend discharge point of pipes underneath
. conveyance lagoon liquid level
Lagoon. surfaces Volatile. gas emissions; —�
C�' Proper lagoon liquid capacity;
• Biologlcni mlxing;
I -.Correct lagoon`startup procedures;
• Agitation
0- Minimum surface area -to -volume ratio;
W�Minimumagitation when.pumping;
❑ Mechanical aeration;
❑ Proven biological additives
irrigation sprinkler • High pressure agitation!
Site Specific Practices —y
nozzles
• Wind drill
W irrigate on dry.days with little or no wind; -
(,' Minimum recommended. operating pressure;
13,- Pump intake near lagoon liquid surface;
Storage tank or basin
• Partial microbial decomposition;
P
El Pump,fcom second -stage lagoon
surface
• Mixing while filling;
❑ Bottom. or midlevel loading; — — --
%❑
• Agitation when emptying
Tank covers;
C1 Basin surface mats of solids;
Settling basin
,surfacc�
_
: partial microbial decom osition•
P
13 Proven biological additives or oxidants
�
• Mixing while filling;
t] Extenddrainpipeoutlets underneath liquid
level; . .
Manure, slurry orsludee
• Agitation when emptying
. Anitari.,. —k-_
O Remove settled solids regularly
spreader outlets
Uncovered manure,
slurry or sludge on field
surfaces
• Volatile gas emissions
• Volatile gas
drying
a,caa animals • Carcass decomposition
Dead animal disposal Carcass decomposition
pits
lncin¢liors' . Incomplete combustion
AMC)C November 11, 1996, Page 4
U Soil injection of siurrylsludges;
C! Wash residual manure from spreader after use;
❑ Proven biological additives or oxidants
❑ Soil injection ofslurry%sludges
O Soil incorporation within 48 firs.;
❑ Spread in thin,uniform layers for rapid drying,
❑ Proven biological additives or oxidants
® Proper disposiliun of carcasses
❑ Complcic coVcri�g of `carcasses fir burial plis;
❑ Proper locati007consiruction ofdisposal pits
O Secondary stack burners
J

source Cause BMPs to Minimize. Odor Site Specific Practices
Standing water around • Improper drainage; M Grade and landscape such that water drains
v;,facliities a Microbial decomposition of away from facilities
organic matter
—UAnure hocked onto • Poorly maintained access roads O Farm access road maintenance
public roads from farm
access
_Additional Information : Available From
Swine Manure Management ; 0200 RuIeBMP Packet NCSU, County Extension Center
Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet NCSU -BAE
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment; EBAE 128-88 NCSU - BAE
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment; EBAE 129-88 NCSU - BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage ; EBAE 103-83 NCSU - BAE
Calibratlon of Manure and Wastewater Application Equipment; EBAE Fact Sheet NCSU - BAE
Controlling Odors from Swine Buildings; PIH-33 NCSU - Swine Extension
Environmental Assurance Program ; NPPC Manual NC Pork Producers Assoc
Options for Managing Odor; a report, from the Swine Odor Task Force NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies ; PRO107, 1995 Conference Proceedings Florida Cooperative Extension
AMOC - November 11, 1996, Page 5

Version —November 26, 2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
El 1:1 Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
1:1 El NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additi al a procedures or measures for disposal according to G.S. 106-399.4.
3/1719 / �
Signature of Farm er/Manager Date
Signature ofT .hnical Specialist Date