820073_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 82-0073
2. Facility Name: R & J Fanns 7-12
3. Landowner's Name (same as on the Waste Management Plan):
Certificate Of Coverage Number: AWS820073
Randall N Barefoot
4. Landowner's Mailing Address: PO Box 589
Citv: Clinton State: NC Zip: 28329
Telephone Number: E-mail: rand,. barefoot it prestagefarms.com
5. Facility's Physical Address: 10905 Old Mintz H%vv 411
City: Garland State: NC
6. County where Facility is located: Samoson
7. Farm Manager's Name (if different from Landowner):
8. Farrn Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"):
10. Operator Name (OIC): Randall N. Barefoot
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type
Swine - Feeder to Finish
Operation Types:
Swine
Cattle
Wean to Finish
Dairy Calf
Wean to Feeder
Dairy Heifer
Farrow to Finish
Milk Cow
Feeder to Finish
Dry Cow
Farrow to Wean
Beef Stocker Calf
Farrow to Feeder
Beef Feeder
Boar/Stud
Beef Broad Cow
Gilts
Other
Other
Prestaae Farms Inc
Phone No.: 910-592-5771
Allowable Count
4,410
Zip: 28441
OIC 4: 17796
Dry Poultry
Other Types
Non Laying Chickens
Horses - Horses
Laying Chickens
Horses - Other
Pullets
Sheep - Sheep
Turkeys
Sheep - Other
Turkey Pullet
Wet Poultr-v
Non Laying Pullet
Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown) I
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
#1 17-9
1 q9A
dl4q
q3 5 320
4T,916.00
#2 10.-M
C14j
65,340.00
1
19.00
1
22.60
2
19.00
2
22.60
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
I . The most recent Waste Utilization Plan (WUP), signed by the owner and a certified technical specialist. containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: 2019PermitRenewai*ncdenr.gov

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting inforination and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.613, any person, who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name: 91W0.41-t- Al.
Title:
Signature:
Date:
Name:
Signature:
Name.
Signature:
Title:
Date:
Title:
Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: 2019PermitRenewal Cit nedenr.gov
FORM: RENEWAL -STATE GENERAL 02/2019

PLOY COOPER
Comm"
MICHAEL $. REGAN
Sil—farr
LINDA CULPEPPER,
01redol
&
NORTH CAROLINA
Enyko.nmenrafQma&,y
February 27, 2019
Randall N Barefoot
R & J Farms 7-12
PO Box 589
Clinton, NC 28329
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
r jAL2;:JW
�4SCSIVEV
seon
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General' Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https:Hdeg.nc.gov/about/divisions/water-resources/Water-Qualit�,-recional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non -Discharge General Permits, ,ou must submit an application for
nermit covergge to the Division. Enclosed jou will find a "Request for Certificate of Coverage Faciliv. CurrentIN Covered by an
Expiring State Non-DischaMe General Permit," The "i lication form must be completed, signed and returned b., April 3, 2019a
Please note that -,ou must include one (1) coin of the Certified Animal Waste Management Plan ICAWNIP) with the
comUleted and si2ned an0ication form. A list of items included in the CAWMP can be found on page 2 of the renewal
atmlication form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Sincerely,
A0P �*�
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Enclosures
cc (w/o enclosures): Fayetteville Regional Office, Water Quality Regional Operations Section
SMpson County Soil and Water Conservation District
AFOG Section Central Files - AWS820073
PrestaL,e Farms Inc
NiTt,C5r:) raDepsrvre-t.�fE­0.�r—eta Quz'ty I D'Vs'DoMatc-Resources
512 W Se st. I St 1 1.626 f'e- Se,v ze :er tof I Re e'o, Nort Ca-c a 2789-9-ie-i a
SiS,7077SZOD

Producer: Randall N. Barefoot
Name of Farm: R&J Farms 7-12
Location, P.O. Box 589
Clinton N.C. 28329
Phone: [phone]
Type of Operation: Feed -Finish
Number of Animal: 4410
Storage Structure: Anaerobic Lagoon
Method of Application: Irrigation
Amount of waste produced per year:
Amount of plant available N (PAN) produced/year:
County: Sampson
8379 ton/year
6636 lbs./year
Based on On -Farm Records
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface water and/or groundwater. The plant nutrients in the animal waste
should be used to reduce the amount of commercial fertilizer required for the crops in the
fields where the waste is to be applied.
.q '" - -73
r" 1/1 ry # 8a
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
. Several factors are important in the implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environmentally
safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall not be applied to land eroding at more than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are
established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may in runoff to the surface waters which is not
allowed under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor problems.
6. To maximize the value of the nutrients for crops production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy. Injecting the waste or disking will
conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change methods
in the future, you need to revise this plan. Nutrient levels for different applications methods are
not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have plant analysis made, which

I
could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible so as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management 6ommission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract No.
—
Field No.
Soil Type
Crop
Code
Yield/Ac
Lbs. N
unit
Acres
Lbs N
Used
Month to
Apply
Lbs. N
Per Ac.
4062
1
Fo
CB -Graze
4.5
50
4.40
990
MAR-OCT
225
4062
2
Fo
CB -Graze
4.5
50
4.52
1017
MAR-OCT
225
4062
3
Fo
CB -Graze
4.5
50
2.34
527
MAR-OCT
225
4062
4
Au
CB -Graze
4.1
50
2.40
492
MAR-OCT
205
4062
5
Au
CB -Graze
4.1
-50
4.20
861
MAR-OCT
205
4062
6
Au
CB -Graze
4.1
50
3.60
738
MAR-OCT
205
4062
7
Au
CB -Graze
4.1
50
2.61
535.
MAR-OCT
205
4062
8
Au
CB -Graze
4.1
50
1.31
269
MAR-OCT
205
4062
9
Fo
CB -Graze
4.5
50
1.61
599
MAR-OCT
225
4062
10
Fo
CB -Graze
4.5
50
2.66
598
MAR-OCT
225
4062
1 11
GoA
CB -Graze
4.9
50
3.171
777
MAR-OCT
245
4062
1 1-11
Fo,Au
OS -Graze
1.0
50
'32. 21
1483,
OCT-MAR
5
Total 32.82 8886 lbs.
Available Nitrogen 6636 lbs.
Surplus or deficit -2250 lbs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to apply
the waste, in a timely manner.

The applicator is cautioned that P and K may be over applied while meeting the N requirements. In the future,
regulations may require farmers in some parts of North Carolina to have a nutrient management plan that
addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (i.e. small grain, etc. interseeded in bermudagrass), forage must be removed through
grazing, hay and /or silage. Where grazing, plants should be grazed when they reach a height of six to nine
inches. Cattle should be removed when plants are grazed to a height of four inches. In fields where small grain
etc. is to be removed for hay or silage, care should be exercis ' ed not to let small grain to reach materity,
especially late in the season ( i.e. April or May) Shading may result if small grain gets too high and this will
definitely interfere with the stand of bermudagrass. This loss of stand will result in reduced yields and less
nitrogen being utilized. Rather than cutting small grain for hay or silage just before heading as is the normal
situation, you are encouraged to cut the small grain earlier. You may want to consider harvesting hay or silage
two to three times during the season, depending on the time small grain is planted in the fall.
The ideal time to interplant small grain, etc. is late September or early October. Drilling. is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a height of about two inches before drilling for best
results.
Caution must be exercised in grazing or haying summer annuals under stressed conditions. Nitrate poisoning
may occur in livestock. Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres excluding required buffers, filters strips along
ditches, odd areas unable to be irrigated, and perimeter areas not receiving full application rates due to
equipment limitations. Actual total acres in the field listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at agronomi ' c rates.
The sludge will be nutdent rich and will require precautionary measures to prevent over application of nutrients
or other elements. Your production facility will produce approximately 1588 lbs. of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years you will have approximately 7938 lbs. of PAN to utilize. Assuming
you apply this PAN to hybrid bermudagrass hayland at the rate of 300 lbs/acre you will need 26
acres of land. If you apply the sludge to corn at the rate of 125 lbs. of nitrogen per acre you will need 64
acres of land. Please be aware that these are only estmates of the PAN and the land needed. Actual
requirements could vary by 25% depending on the sludge waste analysis, soil types, realistic yields, and
application methods.
F-11 u WK"-, -9 411119 Z 11151111;1111, 1 � � � 111 �� � � � � ii ii � � ii � I "Ok
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation such that
runoff or ponding occurs. This rate is limited by initial soil moisture content, soil structure, soil texture, water
droplet size, and organic solids. The application amount should not exceed the available water holding capacity

of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is installed to properly irrngate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table is provided as a guide for establishing application rates and amounts.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
4062
1
Fo
CB -Graze
0.5
1.0
4062
2
Fo
CB -Graze
0.5
1.0
4062
3
Fo
CB -Graze
0.5
1.0
4062
4
Au
CB -Graze
0.5
1.0
4062
5
Au
CB-Graz—e
0.5
1.0
4062
6
Au
CB -Graze
0.5
1.0
4062
7
Au
CB -Graze
0.5
1.0
4062
8
Au
CB -Graze
0.5
1.0
4062
9
Fo
CB -Graze
0.5
1.0
4062
10
Fo
CB -Graze
0.5
1.0
4062
GoA
CB -Graze
0.5
1.0
1-11
FoAu
OS -Graze
0.5

This is the maximum application amount allowed for the soil assuming the amount of nitrogen allowed for the
crop is not over applied. In many situations the application amount shown cannot be applied because of the
nitrogen limitations. The maximum application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on the
average of once every 6 months. In no instances should the volume of the waste be stored in your structure
be within the 25 year 24 hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and the waste applicator to ensure that the spreader equipment is operated
properly to apply the correct rates shown in the tables. Failure to apply the recommended rates and amounts of
nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you have receive the waste analysis report for assistance in determining the
amount of waste per acre and the proper application rate prior to appling the waste.
NARRATIVE OF OPERATION
This plan has been revised due to change of ownership on 9/11/2008.

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply waste. If the producer
does not own adequate land to properly dispose of waste', he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic. crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
standard 393 - Filter Strip).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate that runoff
does not occur offsite or to the surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9� Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potentual for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residenrial property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).

REQUIRED SPECIFICATIONS
(continued)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned
by he landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist'.
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
17. A protective cover of appropriate vegtation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidences of
erosion, leakage or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illigal discharge, pollution and erosion.
19. Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetation and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications of animal waste
during the crop season.
21. Highly visible markers shall be installed to mark the top and the bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five (5) years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.

, t.
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: R&J Farms 7-12
Owner/Manager Agreement Randall N. Barefoot
I (we) understand and will follow and implement the specifications and the operation and maintenance proce-
dures established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the North Carolina Division of Water Quality
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to the surface waters of the state from a storm event less severe than the 25-year, 24 hour
storm.The approved plan will be filed on -site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Randall N. Barefoot
Signature:
Name of Manager (if different from owner)
Signature:
Name of Person Preparing Plan: James L. Lamb
Affiliation: Prestage Farms, Inc.
Address: P.O. Box 438
Clinton, NC 28329
Signature:
Phone: [phone]
Date: 911110e
Date:
Date:
rC�:VJDWR
RECEVV01%,
onsSOM

3/29/2019 Prestage Farms Swine Locations App
x
CD
r2.
0
a
)>
�i*
Lid
Sl -(IF A, AP
0
-@ 4
u
,
-rl
��O,
4-
SPAM r-JeLVS
600ft
hftps:Hpfi.maps.arcgis.com/apps/W�ebappviewer/index.html?id=bcd3l c72d7d04bceac9388b38ba3l6e6

SAMEPSON COUNTY
EMERGENCY ACTION PLAN
DIVISION OF WATER RESOURCES (DWR) 910-433-3300
EMERGENCY MANAGEMENT SERVICES (EMS) 910-592-8996
SOIL & WATER CONSERVATION DISTRICT (SWCD) 910-592-7963
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) 910-592-7963
COOPERATIVE EXTENSION SERVICE (CES) 910-592-7161
This plan will be implemented in the event that waste from your operation are leaking,
overflowing, or running off the site. You should NOT wait until wastes reach surface
waters or leave your property to consider that you have a problem. You should make
every effort to ensure that this does not happen. This plan should be posted in an
accessible location for all employees at the facility. The following are some action items
you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested response to problems are listed below:
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam, any permanent alteration of the
dam should be approved by a qualified technical specialist.
b. Pump wastes to field at an acceptable rate. '
c. Stop all additional flow to the lagoon, hold wastes in the house if possible.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from wastes application field -action include:
a. Immediately stop wastes application.
b. Create a temporary diversion or berm to contain the waste.
c. Incorporate waste to reduce further runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinkler -action includes:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pwnp.
c. Close values to eliminate ftuther discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush system, houses, solids separators -action includes:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Make sure no siphon effect has been created.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks -possible action:

a. Dig a small sump or ditch to catch all seepage, put in a submersible pump, and
pump back into lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes
and compact with a clay type soil.
c. Have a professional evaluate the condition of the sidewalls and the lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, call your DWR (Division of Water Resources)
regional office, at 910-433-3300, after hours, emergency number: 1-800-858-
0368. Your phone call should include: YOUR NAME, FACILITY
NUMBER, TELEPHONE NUM[BER, THE DETAILS OF TE INCIDENT
FROM ITEM #2 ABOVE, THE EXACT LOCATION OF THE FACILITY,
AND THE LOCATION OR DIRECTION OF MOVEMENT OF THE
SPILL, WEATIHER AND WIND CONDITIONS, THE CORRECTIVE
MEASURES THAT HAVE BEEN UNDER TAKEN, AND THE
SERIOUSNESS OF THE SITUATION.
b. If the spill leaves the property or enters surface waters, call local (EMS)
Emergency Management Services at 910-592-8996.
c. Instruct EMS to contact local Health Department.
d. Contact local Soil and Water Conservation District, Natural Resources
Conservation Service office at 910-592-7963 and Cooperative Extension
Service at 910-592-7161 for advice/technical assistance.
4. If none of the above works call 911 or the sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair of the problem to minimize off -
site damage.
a. Contractors Name:
b. Contractors Address:
c. Contractors Phone: .-y10-5r9-7-1r1-11
Page 2

6. Contact the technical specialist who certified the lagoon.
a. Name: If.4maw-g- 1J. &+"Ar-r
b. Phone: 910,5-9,R-577[
7. Implement procedures as advised by DWR and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
8. If you are a contract swine grower associated with a swine company integrator,
contact the company representative at 910-592-5771.
Page 3

Insect Control Checklist for Animal Operations
Sullf-Ce
Cause
1IMPS to Control 111scos Site Specific Pratfices
Flush Gullers
Accumulation of-sol-id ----------------------
0-----j.�111
Liquid Sysielils
SYNSICen't.is t1kcsigned a I op - (a
lit CI. -I
StIffic iclitly Io 1-cmoveaccuillul.1led soli(js ri-oll,
91111c'S as designed.
0
Remove bridghig orlicc,1111111-11cd solids a(
L-agOons and pits
0
0 Crusle
discharge
cl-tlstillg ofsolids to a dcpih orno more than 6 -
I1-'-XCcssivC Vegetative
0 I)cc.lyill.. �Cgclafloll
8 illches ovel- more thali 30% orsul-l'.-Ice.
Growill
Maintain vcgc(.ilivc C01111,01 jljollg 1),tilks: or
lagoons and other impoundmews to prevent
acclill"llation of dccaying vegel-.1jivc matter
along %valers edge oil impoundment's perimeter.
Fectlers
Feed Spillage
a
Design ' operate and maimlin recd sys(cills (e.g.,
bunkcrS and Iroughs) to millimin (lie
f1ccli'llulation of dccayinp, wastam.
V n
- V—S%; 0 Acamitilatiolls offeed rcsiducs
AM I C - Novern ber 11, 1996, 11age I
9
Cleall 1116 -Spillagc Oil I 1*011filte basis (e.g., 7 . 10
diy in(erval during summer; 15-30 day intcl-v.11
during willtel.).
0 Reduce mois(ure acct,111111,11ioll %vi(Ilill and
-11.0tilld illilliCEliale peritnetel- of reed storage
'11'eas bY ills"ring drainage away fi-oll, site
and/or providingadcquate containment (e.g.,.
Covered bill ror breweils grah'i and similar high
Moisture grain pro(lucis).
0 IllsPcc1 ror mid re'llovc or break ul) accumulated
solids in filter S(rips around fccd storage -Is
nceded.

Source Cause
Allimid Holdjkg-�as �Accum�jujatjons of an Wal wastes
IRMPS to Control Insects.
13 Eliminate
and feed W, '
istago
:.Ibwaraasthat,trapmoii�u aleng�
feiCis�ild-other-.16OW6
accumulates and disturbance by animab is
minimal.
13. W. Intain'fence rows and fifter strips around
animalholding armjoMWMiW . .
accumulations Of Wastes (i.e., iftsPect for and
remove or breik up Accumulated solids as
DrY Manure Handling. Accumulations o inunal wastes
Systems
needed).
13 Remove spillage on routme basis (C.g.f 7 10
day "interval during sumnier, 15-30 day interval
during winter) whoa manure is loaded for land
application or disposal.
0 Provide for adequate drainage around manure
stopkpil6s. -
13 Inspect: for and remove or break up accumulated
wastes in flite'r strips around stockpiles and
Manure handling areas as needed.
For in -ore information contact the cooperative Extension Service, Department of Entomology, Box
PAleigh, NC, 27695-7613. 7613, North.carouna, Statevniversity,
AMIC - November 11, 1996, Page 2

I
C
Swine Farm. Waste Management Od6r Co'ntrof Chddklist
pr
Cause
to
0 Vegetative 6r wooded buffirs,
5 Recommended best management practices;
0 aood judgment and common sew@
Animal body surfaces Dirty manure-Covezed animals
a Dry floors
Floor surfaces Wetm.anure-covered ors 0 SlottrA floors;
0 Watem located over slotted'floors;
13 Feeders at high end of solid floors;
13 Scrape manure buildup from floors;
D Underfloor Ventilation forArying
Manure collection pits 0 Urine;
S Frequent manure removal by flush, pit recharge,.
& Partial microbial decomposition or scrape,
13 Undeffloor.ventilatioh
Ventilation exhaust fans G volatile pses; ---A Fa_n maintenance;
Dust 8 Efficient air movement
Indoor surfaces Dust oups of anu"nals;
f,% W' shdown beiw—e—en g—r—
Y
0 Feed additives;
Feeder covers;
I*J Fe6d delivery downspout extenders to feeder
Practices-
Agitation of recycled_Fal�own_
0
covers
�Flus-
h tank covers;
!iquid while -tanks are filling
(3
Extend fill lines to near"bouom of tanks with
Flush alleys
Xgiiatibn during wastewater
0
anti -siphon. vents
UnderflOr flush with underfloor ventilation
conveyance
Pit recharge points
Agitation of �ec�cled lagoon
2
E t
- xtend recharge. lines to near bottom of pi s
liquid while pits are filling.
with anti -siphon vents
Lift sCiions
Agitation during.sump —
MOK
13
Sump tank covers
filling and dKawdown
Outside drain collection .*
Agiotloii during. wastewater
13
liox: covers
or junction boxes
conveyance
AMO-C -. November 11, 1996, - Page 3

Source Cause
Bhm to Minimize ONO Site Sp ific Pradices
End of draft�pipes at Xg-itation during viabiew-ater Extend discharge point �of pipes.-undemeath
come. lagoopliquid-levial.
Y
Lagoon surfitces Volatile gas emissions; 0 Propet lagoon liquid capacity;
Biological mkingj' N Conect lagoon startup procedures;.
Agitation 13 Minimum . surface arew4o-volume ratio;
0 Minimum agitation whenpumping;
0 Mechanical aeration;
13 Proven biological additives
Irrigation sprinkler
nozzles
High pressure agitation;
E.
Irrigati on drY days with little or no wind;
Wind drift
0
Minimum recommended operating pressure;
10
Pump intake near lagoon liquid surface;
C3.
PiunpArom second-Mge lagoon
Storag6 tank or basin
Partial microbial decbrdposition,�
13
Bottom or. midlevel loading;
surface
Mixing while fillmig;
13
Tank covers;
Agitation w1unt emptying
0
Basin surface'snats of solids;
0
Proven biological additives or oxidants
Settling basin surface
-4
Partial microbial decomposition;
13
Extend drainpipe outlets underneath liquid.
a
Mixing While filling;
level;
e
Agitation w-ben emptying
13
Removd settled solids regularly
Manure, slurry or sludge
e
Agitation -when.sofitding;
-Soil iiijection of sluixy/sludges;
spteader outlets
a
Volatile gas emissions
Wash residual ma.n'ur'e.from spreader after use;
13
Proven biologipal additives or oxidants -
Uncove manure,
0
Volatile 9" doissions while
0
Soil injection of sluiTy/sludges
slurry.or sludge on field
surfaces
drying -
1:3
Soil incorporation within 48 hrs.;
0
Spread in thin uniform 14yers for rapid drying;
0
Proven'biological additives or oxidants
Dead.animals,
0
Carcass deciomposition
19
Proper disposition of carcasses
Dead animai'disposal
Carcass decomposition.
I . 3
Complete covering of carcasses in burial pits;
pits.
Cl
Proper location/con'struction of disposal pits
incinerators.
Incomplotecombastidn
13
Secondary stack burners
Novernbef 11, 1.996, Page 4 J4W&

s6ume
%w &wx4sw,l#=.ijuur Site S
btandmg water ground 0 Improper age-,, Gmde sad such -that ins pecific Practices
facilities
0 'Microbial dec'onposition of away fiam facilities
?Tanure �tracked onto poorly
public toads frm farm
Swine Manure Management ; 0200 RulaffiWP_Pa_c_k,
S a . ot----
wine Production Farm Potential Odor Sources and Remedies EBAE Fact Sheet
Swine Productionfacility Manure,Management. pit Rac4arge L g 0 Tr a t ; EBA
A 6 a catin n E 128_98
Swine Production Facility Llama Managernient"Underfloor Flush - Lagoon Treatment; EBAR 1�9_S8
Lagoon Design and M=Rgement for Livestodic Ma . me. Treatihent and Storage ; EBAH 103-93
Calibrati�p of Manure Afid Wastewater APPlicatiOn'Equipment; EBAH Fact Sheet
Controlling Odors from Swine, Buildings - PIH-33
Enviroatnental As ' surance Fr6gram ; NPFC blap"al
Options for Managing -Odor a ireport from the -Swine Odor Task Force
Nuisance Concerns in Animal Manure M"agement: Odors and Flies, PRol.o7, 1995 Conference pwdeedings
AMOC -November 11, 1996, page 5
Available From:
NCSU. County Extension Car
NCSU-'BAE
NCSU - BAE
NCSu-BAE
NCSU-BAE
NCSU-BAE
NCSU - Swine Exten
. I sion
NC Pork Producers Assoc
NCSU Agri-COmmunications
Florida COOPerative Extension

version —November 26, 2018
ity Management Methods
Indicate which method(s) w1// be implemented.
When selecting mulfiPle methods -indicate a primary ve secondary option.
Methods other then th9se 118ted mU3tbe approlled by: rsus
the Ztate Veterinarian.
Prim, ary Secondary Routine mortality
BuriaLthree feet beneath -the surface of the ground within 2.4 hourg of knowledge of animal
death' This burial must be at least 800-feet from any -flowing stream or public body of water
(G.S.1-06-403). The bottom. of the -burial pit'should beat least one foot.'above the seasonal
high water table. Attach buriat location map- and- plan.
F-I F-1 Landfill at municipal solid. waste facility permitted by NC DEQ under GS 16A NCAC
138.0260.
F-1 M Complete incineration according to 02 NCAC 52t .0102.
A composting system approved -and -permitted 6
� !he' NC Department of Agriculture & Con-
sumer Setvices Veterinary Division (attach copy. of pprmit). if compost is.distributed -off-firm,
additionallrequirenriiints'must be met and a Oeirmit is required from NC DEQ.
In the: case -of dead. pciultry.only,. placingin a disposal -pit. of -a sizej-.a'hd design approved by the
El NC Department of Agriculture & Consumer -Services -(G.S. 106-549.70).
F-1 Any methodwhich, 1
n the professional opinionipf the State Veterinarian, would. make possible
the salvage- of part of a dead ailimai; s valuew.1tho'Ut endangering human or' animal .. health; -
(Written approval by the State Veterifiatian m Ust be atta '
ched).
Mas.8 Mortality Plan
'Mass mortality plans -are required for -farms covered.by an NPDES permit. These plans are
alsOtecommended. for all animal -op
eratlon,s. This plan outlines farm-spec'ific mortality man-
age.ment. methodsto. be. used for mass: mortality. The NCDA&CS Veterinary Division, sup-
ports, a variety of emergency mottal . it disposal option contact the: Division for guidance.
S.
• A catastrophic mortality disposal plan is partof the %Cility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rate s .
Veterinarian. s a. specified by the State
• Burial must be�done in accordance with NC General Statutes and NCDA&CS Veterinary
Div , ision regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the"event of ii-nminerit threatof a disease emergency, the State Veterinarian may enact
additional temporary prbcedures.or measures for disposal according to G.S. 1-0�-390.4.
L
Signature of Farm Owner/Manager Date
Signature of Tevc6&I Specialist' Date

7—q
/~-Irator:LINWOOD BROWN County: SAMPSON Date: 12/19/91
Distance to nearest residence (other than owner): 1000.0 feet
1. STEADY STATE LIVE WEIGHT
4.
0
sows
(farrow to
finish)
x
1417
!bs. =
0
|bs
0
sows
(farrow to
feeder)
x
522
|bs. =
0
!bs
2205
head
(finishing
only)
x
135
|bs. =
297675
ibs
0
sows
(farrow to
wean)
x
433
|bs. =
0
}bs
0
head
(wean to feeder)
x
30
|bs. =
0
/bs
TOTAL
STEADY STATE
LIVE
WEIGHT
(SSLW) =
297675
/bs
MINIMUM
REQUIRED
TREATMENT
VOLUME
OF
LAGOON
Volume = 29T675 |bs. SSLW x Treatment Vo}ume(CF)/}b. SSLW
Treatment Vo|ume(CF)/lb. SSLW::-- 1 CF/!b. SSLW
Volume = 297675 cubic feet
STORAGE VOLUME FOR
SLUDGE ACCUMULATION
Volume =
0,' cubic feet
; "Owner
requests no sludge storage.
Sludge
will be removed as needed."
TOTAL DESIGN VOLUME
Inside top length 225.0 feet ; Inside top width 220.0 feet
Top of dike at elevation 57.0 feet
Frecboard 1.3 feet : Side s!unpq TM " i /r".iA" /..^..`
Fota| design lagoon liquid level at elevation 55.7 f6et
Bottom of lagoon elevation 43.0 feet
Seasonal high water table elevation 46.0 feet
Total design volume using prismo/dal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
2.5 2.5 2.5 2.5 218.5 213.5 12.7
AREA OF TOP
LENGTH in WIDTH =
218.5 213.5
AREA OF BOTTOM
LENGTH * WIDTH =
155.0 150.0
AREA OF MIDSECTION
LEN8TH * WIDTH * 4
186.8 i81.8
46649.8 (AREA OF TOP)
23250.0 (AREA OF BOTTOM)
135767.3 (AREA OF MIDSECTION * 4)
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/6
46649.8 135767.3 23250.0 2.1
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = �
-

"\ TEMPORARY STORA8E REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
225.0 220.0 49500.0 square fee -'--
Buildings (roof and lot water)
Length * Width =
0.0 0.0 0.0 square feet
TOTAL DA 49500.0 square f�et
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00136
Vo|ume = 297673 Lbs. SSLW * CF of Waste/Lb./Day * 180 days
Volume = 72694 cubic feet
Volume of wash water
This is the amount of fresh water used for washinS floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallons
Volume = 0.0 cubic feet per CF
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 28875.0 cubic feet

Vo|ume of 25 year - 24 hour storm
Vo|ume = 7.0 i,.ches / 12 inches per foot * DA
Vo|ume = 28875.0 cubic feet
TOTAL REQUIRED
TEMPORARY STORAGE
5A.
T2694
cubIc
feet
5B.
0
cubic
feet
5C.
28875
cubic
feet
5D.
28875
cubic
feet
TOTAL
130444
cubic
feet
Tota| required voiume 428119 cubic feet
Tot�| desi8n vo|ume avai�. 435328 cubic feet
Min. req. treatment vo|ume �|us s|udSe accumu|ation
2976T5 cubic fee
*� eiev.
�J.V feet ;
Vo|ume is
317083
cubic feet
(end pumpinS�
Tota} desi8n
vomss
25yr-24hr storm
is
406453
cub}c
feet
At e|ev.
55.0Vo|ume
is
403200
cub}c feet
(start pumpin3)
Seasona| hi8h
water tab|e
e}evatioo
'46.0
feet
7. DESIGNED BY:
APPROVED
8Y:
DATE:'
DATE:
/-7
NOTE: SEE AT�ACHED WASTE UTILIZATION PLAN

7-9
OPE�ATION AND MAINTENANCEPLAN
- - - - - - - - - - - - - - - - - - -
-----------
This |aSoon is desi8ned for waste treatment with minimum odor
contro|. The time required for the p|anned f|uid |eve/ to be
rpached may vary duc to soi| condit}ons,f/ushin8 operations, and
the amount of fresh water added to the system.
Lan� app}ication of waste water is reco8nized as an acceptab|e
method of disposa|. Methods of app|ication inc|ude so|id set,
center pivot, 8uon. Care shou�d be
taken when app|yinS waste to prevent runoff from the fie�d or dama8e
to crops.
The fo||owin3 items are to be carr�ed out:
stronS�y recommended that the treatment iagoon be pre
-
charSed to 1/2 its capacity to prevent excessive odors durin8
start-up. Pre-char8in8 reduces the concentration of the �n�tia/
waste enter|nS the /aSoon thereby reducin8 odors. So|ids shou|d be
covered w�th eff|ue:t at a)| times.
2. The attached waste uti!iowed. Th�s
p|an recommends samp|ing and test/n8 of waste (see Attachment B)
before iand app|ication.
3. 8e8inpump-out of the /aSoon when f|uid /eve| reaches
marked by permanent markers. Stop pump -out when
the f|uid |eve/ reaches e|evation 53.0 or before f/uid depth is
|ess thnit, s the ioss of favorab|e
bacteria) .
4. The recommended maximum amount to app|y per irriSation is
one (1) incb and the recommended maximum app|ication rate is 0.4
inch per hour.
KeeC, v�8etation on the embankment and areas adJacent to the
�a800n mowed annua�iy. Ve8etation shou�d be ferti|ized as needed
` to maintain a vi8orous stand.
6. Repair any eroded areas or areas damaged by rodents and
estab}ishin ve8etation.
7. A|� surface runoff �s to be diverted from the |a800n to stab}e
out|ets.
8. The C|ean Water Act of 1977 prohibits the discharSe of
po|/utants into waters of the United States. The Department of
Environment, Hea|th, and Natura| Resources, Division of Environ-
menta{ Management, has the respons�bi|ity for enforcin8 this |aw.

�
. . -
Uperator:LlNWUOD BROWN Couinty: SAMPSON
`'
-
^
Distance to nearest residence (other than owner):
����
"~ "~,
Date: 10/12/92
1' STEADY
STATE LIVE WEIGH]''
0
Sows
(farrow to finish) X
1417 |bs.
0
Sows
(farrow to feeder) X
522 |bs.
2205
Head
(finishing only) X
135 |bs.
0
Sows
(farrow to wean) X
433 |bs.
0
Head
(wean to feeder) X
30 | It: s.
TOTAL STEADY STATE LIVE
WEIGHT (SSLW)
1000 feet
= 0
= 0
= 297675
= 0
= 297675
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 297675
|bs. SSLW X Treatment Volume
CF/|b. SSLW
Treatment Volume CF/|b.
SSLW:.--: 1.0
CF/|b. SSLW
Volume = 297675
cubic feet '
3. STORAGE VOLUME FOR SLUDY
'
ACCUMULATION ' ^
Volume = 0
cubic feet
'
4. TOTAL DESIGN VOLUME
Inside top: length
260 feet ; width
225 feet
Top of dike at elevation
47.00 feet
. Freeboard 1.3
feet Side slopes
3.0:1(inside)
Total design lagoon
liquid level at elevation
45.70 feet
`~~ Bottom of lagoon at
elevation 35.00
feet
Seasonal high water
table elevation 35.00
feet
Total design volume
using prismoida| formula:
8S/END1 SS/END2
SS/SIDE1 SS/END2 LENGTH
WIDTH DEPTH
3.0 3.0
3.0 3.0 252.2
211.2 10.70
AREA OF TOP
1 EN6TH X WIDTH
252 217
AREA OF BOTTOM
LENGTH X WIDTH =
188 153
54778 (Area of Top)
28764 (Area of Bottom)
` AREA
OF MIDSECTION
LENGTH
X WIDTH X 4
220 185
162962 (Area of
Midsection X 4)
CU.
FT.- [Area top+(4XArea
Midsection)+Area
Bottom] X Depth/6
~
54778
162962 28764
2
VOL.
OF LAGOON AT TOTAL
DESIGN LIQUID LEVEL =

-
STORAGE REnU}REf)
~
Drainage
Area:
�
Lagoon (top of dike)
Length X Width =
260 225
58500 Square
Feet
Buildings (roof and
lot water)
.
Length X Width =
0 0
0 Square
Feet -
TOTAL DA
58500 Square
Feet
===>
Design temporary -storage
to be
180
days.
A.
Volume of waste produced
Appr6x(mate daily production
of manure
in CF/LB
SSLW
0.00136
Volume = 297675
Lbs. SSLW X CF
of waste/|b/day
X
' 180
Volume'- 72871
Cubic feet
B.
Volume of wash water
This is the amount
of fresh water
used for washing
floors
or
volume of fresh water
used for a
flush system.
Flush
systems
that recirculate the
lagoon water
are accounted
for
in 5A.
'
Vo|ume = 0
8a|(ons/day X
180
days storage/7.48
gal Ions
per CF
Vo|ume = 0
Cubic feet
C.
Volume of rainfall
in excess of evaporation
Use period of time
when rainfall
exceeds evaporation
by
largest amount.
180 days excess
rainfall
=
7.0
inches
Volume = 7.0
Inches X DA /
12 inches per
fopt
Volume = 34125
Cubic feet
'D.
Volume of 25 year -
24 hour storm
Volume = 7.0
inches / 12 inches
per foot
X DA
Volume = 34125
Cubic feet
TOTAL
REQUIRED TEMPORARY
STORAGE
5A.
72871 Cubic
feet
5B.
0 Cubic
feet
5C.
34125 Cubic
feet
.
5D.
34125 Cubic
feet
TOTAL
141121 Cubic
feet

6. SUMMARY
Total required
volume =
438796
Cubic feet
Total design
volume avail.-
439599
Cubic feet
Min. reqrd.
trtmnt.
vol. plus
sludge
accum.=
29T675 Cu.
Ft.
At elev.
42.90 Ft; Vol-
296997
Cubic feet
(end pumping)
Total design
volume less 25yr-24hr
storm
=
405474 Cu.
Ft.
At elev.
'
45.10'FtF voi-
*07236'Cubic
feet
(start pumping)
Seasonal
hi8hmater
table elevation
is
35.00 Feet,
which
must
be lower
than
the elevation
of top of
treatment
volume
42.90
� DESIGNED BY: APPROVED BY:
_________ ---- _____________________
DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
ADDITIONAL NOTES: _j____________________________________________________

. �
OARATlDNAND MAINTENANCE PLAN
---------------------------------
This lagoon is designed forwaste treatment (permanent storage) with
minimum odor control. The time required for the planned fluid level
to be reached (permanent + temporary storage) may vary due to
flushing operations and the amount of fresh water to be added to the
system.
The designed 6 months temporary storage is an estimated vo|uma
based on : 1) waste from animals; 2) excess rainfall after
evaporation; and 3> the largest 24 hour (one day) rainfall that
occurs on the average of once every 25 years. The volume of
waste generated from a given number of animals will be fairly
constant throughout the year and from year to year. This
estimate is based on 7 inches uf excess rainfall which is
equal to or exceeds the highest 6 months excess in a year.
The average annual excess rainfall is approximately 8 inches.
Therefore, an average of 8 inches of excess rainfall will
.need to be pumped each year. The 25 year rainfall will not be a
faltor to consider in an an6ua| pumping cycle, but this storage
volume must always be available. A maximum elevation is
determined in each design to begin pumping and this is usually
the outlet invert of pipe(s) from bui}din8(s). If ±he outlet
pipe is not installed on the elevation to begin pumping, a
permanent marker must be installed on this elevation to
indicate when pumping should begin. An elevation must be
.estab| i shed to stop pumping to maintain minimum treatment depth
(6 feet) . Pumping can be started or stopped any time between
these two elevations Ow operat i n8 conven i ence as site
conditions permit (weather, soils, crop, and equipment to apply
waste without runoff or leaching).
Land application of waste water is recognized as an acceptable
method of d}sposa|. Methods of application include solid set,
center pivot, guns, and traveling Sun irrigation. Care should
be taken when applying waste to prevent runoff from the field
or damage to crops.
The following items are to be carried out:
1. It is strongly recommended tha the treatment lagoon be pre
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids
should be covered with effluent at all times. When pre
charging is completed, flush buildings with recycled lagoon
liquid. Fresh water should not be used for flushing after
initial filling.
2. The attached waste utilization plan shall be followed.
This plan recommends sampling and testing of waste (see
Attachment B) before }and application.

3. Be8in pump -out of the lagoon when fluid level reaches eleva-
tion 45.10 as marked by permanent markers. Stop pump -out
when the fluid level reaches elevation 42.90 or before
fluid depth is less than 6 feet deep (this prevents the loss of
favorable bacteria). The design temporary storage, less 25 year
storm is 106996 cubic feet or 800329 gallons. As stated
before, this'vo|ume will vary considerably from year to year.
4. The recommended maximum amount to apply per irrigation is one
(1) inch and the recommended maximum application rate is 0.4
inches per hour.
5. Keep vegetation on embankment and areas adjacent to the |a
8»»»
mowed annually. Vegetation should be fertilized as needed to
maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to
stable outlets.
81 Keep a minimum it 100 feet cropland buffer or 25 feet of grass
�
vegetated buffer around waste utilization fields, particularly adjacent
to ponds, lakes, streams, open ditches, etc. Do not pump within
300 feet of a residence or within 100 feet of a well.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
menta! Management, has the responsibility for enforcing this law.
'
NOTES: