820043_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered Please verify all information and make any necessmy corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 82-0043
2. Faciljtv Name: M&R Farm.s
3. Landowner's Name (same as on the Waste Management Plan)
4. Landowner's Mailing Address: 1458 Wildcat Rd
City: Harrells State:
Telephone Number: 910-532-4016 Ext. E-mail
5. Facility's Physical Address: 1118 Buckhom Rd
City: Willard State:
6. County where Facility is located: Sampson
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None")
10. Operator Name (OIC): Michael S. Roeers
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type
Swine - Feeder to Finish
Operation Types:
Swine
Cattle
Wean to Finish
Dairy Calf
Wean to Feeder
Dairy Heifer
Farrow to Finish
Milk Cow
Feeder to Finish
Dry Cow
Farrow to Wean
Beef Stocker Calf
Farrow to Feeder
BeefFeeder
Boar/Stud
Beef Broad Cow
Gilts
Other
Other
Certificate Of Coverage Number: AWS820043
Michael S Rogers
NC Zip: 28444-7818
rogerssl ig intrstar. net
NC Zip: 28478
Michael S Rooers
910-532-4016 Ext.
Prestae Farms Inc
Phone No.: 910-473-1181 OIC 4: 17899
Allowable Count
5,880
Dry Poult
Other Types
Non Laying Chickens
Horses - Horses
Laying Chickens
Horses - Other
Pullets
Sheep - Sheep
Turkeys
Sheep - Other
Turkey Pullet
Wet Poultry
Non Laying Pullet
Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
I
L4-4,'- 9�'r
c to,
0 1
19.00
1
19.00
1
148,104.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
A. The most recent Waste Utilization Plan (WUP), signed by the owner and a certified technical suecialist, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
V 3. Emergency Action Plan
P-"' 4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: 2019PermitRenewaloancdenr.gov

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.613, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S'C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name: 17 S' RO K e- 41 Title: MY ;7 e. �' A-)W C, "--7 /0
Signature: Zv'-L4�c� 'X I j;gL� Date:
4,Z
Name:
Title:
Signature:
Date:
Name:
Title:
Signature:
Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: 2019PcrmitRenewal Citnedenr.gov
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER
covefflor
MICHAEL $. REGAN
seererary
LINDACULPEPPER
atreaor
NORTH CAROUNA
Enwiraninental Qua&y
February 27, 2019
Michael S Rogers
M&R Farms
1458 Wildcat Rd
Harrells, NC 28444-7818
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permitice:
APR 0 2 2019
Your 'facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https://deg.nc.,-,ov/about/divisions/Water-resources/Water-Qualil% -regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure vour continued coverne under the State Non -Discharge General Permits- you must submit an aimlication for
I)ermit covergae to the Division. Enclosed you will find a "Reguest for Certificate of Coverage Facilii,� Currenth Covered by an
ExpirmL State Non-DischaEge General Permit." The &iplication form must be completed. signed and returned b�, April 3. 2019.
Please note that �ou must include one (1i com of the Certified Animal Waste Manat!ement Plan iCAWMP) with the
completed and signed application form. A list of items included in the CAWMP can be found on gape 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9 100.
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Enclosures
cc (w/o enclosures): Fayetteville Regional Office, Water Quality Regional Operations Section
Sampson County Soil and Water Conservation District
AFOG Section Central Files - AWS820043
Prestaee Farms Inc
e3eparlyrertofE,Vor�erts Qua'15 I D%ftz�-ofWaterfieso_-Ces
512 W Se sb L fy St. I ISSE Wa_ Se—% --- :e� te.r I Ra egP , Nwit :arc r a 276919-Me
9i9.777S:3Z

PRODUCER:
LOCATION:
TELEPHONE:
TYPE OPERATION:
NUMBER OF ANIMALS:
(Design Capacity)
WASTE UTI , UZ&-i-
Mike Rogers
1458 Wildcat Rd.
Harrells, NC 28444
[phone]
Feeder - Finish
5880
The waste from your animal facility must be land applied at a specified rate to Prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the GrOPS in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching Potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for Pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
this type Of facility. Acreage requirements should be based on the waste analysis fo
The estimated acres needed to apply the animal waste is based on typical nutrient content r
report from
your waste management facility. Attached You will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
21-1.0217 adopted by the Environmental Management Commission.
Page I

WASTE UTILIZATION PLAN APR 0 1
P Year igallons, ft- 'ons. eic.,
5680 aritri @!s X. 1.9 11.172.0 0�,ns-waste/year.
F 4 N P F rC�,ImUCed Per �'eaf
5880 animals 2.3 PANianimai/year 13,524.0 lbs. PAN/year, (PAN from
Tech
waste is a big . should ' Qlan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based or, the crop to be grown and
surface application,
ACPF.1; OWNED BY PRODUCER
Acres Lbs. N Month of
Per Acre Otilizeu
35.46 i3,597.0(;
waste '�V I, cL;-1r.t-j!0'S ofi,e-? -o�.rces sucr? as Goapa)erc.,at!
'r7,e 1v Li�- bs-�E-o qr�,, oa!;sv!�
caurionea triar F aria K may ve ovet appfied while Fneeting we 1v
requiremen ts, Beginning in 1996 the Coasfal Zone Management Acr will require far(ners ;n Some
eastem counnes or fyorTp Larolint, to nave a riarrierit manacement pian rhat addresses a;., owrienis,
hIs Oan only addresses Nirrouen.

r
WASTE UTILIZATION PLAN
fable 2: ACRES'WiTH AGREEMENT OR LONG TERM LEA,5F-
i.Atirtemrnl with inndnwnpr rriuq! be -Artached)
(Required only if operator does not own adequate -d [see
'I raci
Field
S
No,
T)
1'.�WS6
4
GoA
T_�T` - _f
C_�� fr"n.; . -; , — _
Lbs. N Acres Lbs. N Month of
Pei Acle Appilcation
OPTIONAL LAND IF NEEDED
NOT REOUIRH)
Bermucia(G) I 9,�I, March - Sept.
Small Grain 50 331 SepL - Apr I
Bermuda�G) 275�1 13.941 '3834 March - Sek
Stnall Gr-,im
T
Of K�
L b!�. N
Uti47 - �! �i
1. 4
f �T(_)6
NOTE: The Waste Utilization Plan must conflam provisions for periodic land appliCarion of sludge at
aqronomic rates The sjucfge will be nuldem! rich and will rvquire precautionary measures m provent over
F 1) olica Mon of n U I rie "t of - Oth er ei em e V ts
Pa r- r '�.

WASTE UTILIZATION- PLAN
See afr2ched train showina Ithe fiekfs to he used for the utilization of waste V.,Bier.
. f: -S�j,j TVr,-
tB" -.iwL,
must be
of waste
,)" b,,. �rp)Qatirjr-,
Applicabori A�xAcatjw-,
Ra?e on)H.)
I

-ATO
WASTEUTILIZ . I NPLAN)",
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

� ;- —1 T­.111� ­­ - - - -1-1 1 --- - -1 - � --'-
WASTE � UITILIZATION11 -PLAN I
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that courses no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

WASTE, UTILIZATI NPLAN
'0
REQUIRED SPECIPICATIONS
(continued)
17 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
18 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
19 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre plant with no further applications animal waste
during the crop season.
20 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
21 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
22 Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

WASTE UTILIZATION PLAN
*ASTE UTILIZATION PLAN AGREEMENT
NI&R Farrps
Agreement
. and implement the - Def-Fri,611kj:-zz -, u v!r! operation and
maintenance procedures established p 7 5� t k
farm named above. I (we) know that any expansion to the existing design capacity of the
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm
office ano at the office of the local Soil and Water will
available for review by DEM upon request.
'S� igr atu re
diff erent
Pr'vate
1635 W, Wards Bridge Rd.
Warsaw. NC 28456

= 0
oil; f. - f
10 Pei,—
. . . . . . .. .
^fir
46-
40
4#4
INA
J'14W
PF
40
410 &
Ar
du

SAMPSON COUNTY
EMERGENCY ACTION PLAN
DIVISION OF WATER RESOURCES (DWR)
910-433-3300
EMERGENCY MANAGEMENT SERVICES (EMS)
910-592-8996
SOIL & WATER CONSERVATION DISTRICT (SWCD)
910-592-7963
NATURAL RESOURCES CONSERVATION SERVICE (NRCS)
910-592-7963
COOPERATIVE EXTENSION SERVICE (CES)
910-592-7161
This plan will be implemented in the event that waste from your operation are leaking,
overflowing, or running off the site. You should NOT wait until wastes reach surface
waters or leave your property to consider that you have a problem. You should make
every effort to ensure that this does not happen. This plan should be posted in an
accessible location for all employees at the facility. The following are some action items
you should take.
I. Stop the release of wastes. Depending on the situation, this mayor may not be
possible. Suggested response to problems are listed below:
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of darn, any permanent alteration of the
dam should be approved by a qualified technical specialist.
b. Pump wastes to field at an acceptable rate.
c. Stop all additional flow to the lagoon, hold wastes in the house if possible.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from wastes application field -action include:
a. Immediately stop wastes application.
b. Create a temporary diversion or berm to contain the waste.
C. Incorporate waste to reduce further runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinkler -action includes:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Close values to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush system, houses, solids separators -action includes:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Make sure no siphon effect has been created.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks -possible action:

6. Contact the technical specialist who certified the lagoon.
a. Name: �Rmes L—.PmL
b. Phone: - q 10 -!�U - S 17 !7 1
7. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
If you are a contract swine grower associated with a swine company integrator,
contact the company representative at 910-592-5771.
Page 3

Insect Control Checklist for Animal Operatiolls
tis I I C' —u 1-1—C r
ol solids
S III',
I"Xcessivevegelalive DMI),ill't �e
Growill b, V'Clalioll
1"CUCICIIS a
Feed -Sior.1 ,.
0 1-'Illsll
CIII -is designed and opel-41IC(I
S"fricic"IlY 10 remove accumulated solids ri-oll,
gullers as designed.
CI Remove bridging ofaccullitilmed Solids at
discharge
Mailli'lill lagoons, Sefflilig basills Illd pits where
I)CS1 brecdillps 11111.11-cm to III-illil)lizc 111C
c"Uslilig ofsolids to a depth orllo I'lorc than 6 -
8 inches over "'Ore (Ilan 30% ofstlrI--,jce.
maillfaill vegelat
jan "11 ve c0l'(1*01 along banks of
't'00lls all(I 011'er il"Polindinews to pi-6vell,
accumilia(ioll ofdccnyi,ig vege,qltive 111allcr
-110fig Water's cdge 01) ill 1pol Indment's perillicter-
Feed Spillage Dry Sysicills
1)esigil, 011crate and Illainlain rVCd Systems (e.g.,
bunkers and Irotil,711s) to ll1illill1j7
I accullitil. C Ile
atioll of decaying wastage.
Clean [I') 51)"'age oil a 1.0111 ille basis (e.g., 7 - 10
day iliterval during stimmer; 15-30 day illici-val
(Itli'llig %Vill(er).
Accuintilatiolls Offeed residues 0 Reducc illois(til-C
"cCLInjuli
, lioll Within and
"J'Ot"'d ill"llediale perimeter of feed storage
areas by insuring dl,,jillage alvay fi-oill site
"Ildlor providing idequale coil (ain iliell I
covered bill r()'* brewer's graiij and sililifal. Iligil
I'loislurc graill producls).
0 IllsPrc( for and re'llove or break up acCtil))Llla(cd*
solids ill fifter strips around fccd storage as
needed.
AM IC November 11, 1996, page I
Sve
dices

Source Cause
to Control In
Holding. Area—s— * �Accumulations of animal Va—stes 13 Bliminate low
and- feed wgitAgg areas tb"'trap moisture along
fii6iS An other-16catid *hete--w
accumulates and disturbance by animals is
minimal.
Mal.
. Intain fem rows and jilter strips around
animal holding a= to minimize . .
accumulations of wastes 1g.e., inspect for and
remove or breik up Accumulated solids as
neeAed).
Dry Manure Handling Accum@j—ations —of anim
Systems ilwastes--1-3—R—ern—oV—eS]Dillaffeanam"t...16....I-- ' 'A
PPI age on a routine basis (e.g., 1 - 10
day'interval. during summer; 15-30 dAy interval
during winter) wher6 manure is loaded for land
application or disposal.
0 Provide for adequate drainage around manure
StQckpiles. -
0 Inspect for and remove or break up accumulated
wastes in filter strilis aw.und stuckpiles and
manure handling areas as Adeded.
For more infOrmation contact the Cooperative Extcinsion Service, Departgndnt of Entomology, Ej
Raleigh, NC, 27695-7613. Ox 7613. North Carolina State.University,
AMIC - November 11, 1996. Page 2

bource
Swine Farm. Waste Management Od6r Control Ch ' Mist,
ec
Cause
to
pruUmalon M Vegetative or wooded buffers;
8 Recommended best management practices;
0 Good judgment and common sense
Animal body surfaces 0 Dirty manure -covered animals 0 Dry floors
Floorsurfaces 0 Wet manure -covered floors
Pe sl -d floors;
6 Waterers located over slottedMoors;
13 Feeders at high end of solid floors;
1.3 Scrapef manure buildup from floors;
0 Undorfloor ventilation for'drying
a a at.&MUM
Manure collection pits
0
Uri,ne;
0
Frequent manure removal byfliusb, pit recharge,.
0
Partial microbial decomposition
or sc r�pe;
Ell
Underfloor. ventilation
Ventilation exhaust fans
Volatile gases-.
4
Fan maintenance;
Dust
9
Efficient air movement
Indoor urfaces
I)Ugt
M
Washdown between groups of anknals:
0
* Feed additives,
(3
Feeder covers;
M
F664 delivery downspout extenders to feeder
Flush tanks
Agitation of recy.cled lagoon
0
covers
Flush tank covers;
!iquid while tanks are filling
0
Extend fill lines to near''bottom of tanks with
anti -siphon. vents
Flush alleys
Agitation during wastewater
13
Underflbor flush with underfloor ventilation
conveyance
Pit recharge points
Agitation of recycled la'
. goon
_N
Extend recharge lines to near bottom of pits
liquid while pits are filling.
with anti -siphon vents
Lift stations
Agitation during.sump tank
a
'Sump tank covers
filling and dz:awdown
Outside drain collection
Agitation during wastewater
0
6ox covers
or junction boxes
conveyance
AMOC - November 11, 1996, Page 3

%�Kuxv * BmFs to Minimize Od6r Site Spec
End of drah�pipes at Agitation during wastmatef Cl Extend dischaW point of pipes.undemeath
lagoon:..: come, wo_ lagoon liquid- level-.
Y
Lagoon surfaces Volatile gas emissions; 0 Proper lagoo4 liquid capacity;
Practices
* Biological mixinss,
6
COUVd lagoon Startup procedures;. '
* Agitation
C3
Minimum sudhce arear-to-volume ratio;
X
Minimum agitation whenpumping;
0
Mechanical aeration;
C3
Proven biological additives
Irrigation sprinkler High pressure agitation;
nozzles
=
Irrigate on chy days with Ilitle or xio wind;
Wind &ift
a
Miimum recommended operating pressure;
10
Pump intake near lagoon liquid surface;
C1
Ptunp.from second -stage lagoon
Storage tank or basin 4 Partial microbial decomposition;
BqttiDm or. midlevel loading;
surface 0 Mixing while filling;
13
Tank covers;
* Agitation wheik. emptying
13
Basin 'surfacemats of solids;
13 Proven biological additives or oxidants
Settling basin surfim -6 Partial microbial, decomposkion; 13 Extend drainpipe outlets und'
emeath liquid
a NO% while filling; level;
* Agitation when emptying 13 Remove settled solids regularly
Manure, sl�_ny or_s_1Cdje_ e Agitation.when.slifeading; 0 -Soil iiijection of slurry/sludges;
spreader outlets 0 Volatile gas emissions C3 * Wash residual manuie from sprea4er after use;
13 Proven biological additives or oxidants
Uncoveredhm—a—mire, _Vo_jatjjeg2�$ einissions. while 0 Soil inj�ction of slurry/sludges
slurry.or sludge on field' drying I
surfaces E! Soil incorporation within 48 hrs.;
13 Spread in thin uniform ldyeFs for rapid drying;
C3 Proven'blological additives or oxidants
Dead -animals Carcass dec.omposition 0 Proper disposition of carcasses
Dead animal - disposal Carcass decomposition. 13 Complete covering of carcasses in burial pits;
pits.
(3 Proper location/construction of disposal pits
hicinerators. Incomplote.combustidn 13 Second;�stack burners
ANC'..". November 11, 1.996, Page 4

Source
blanchug. water around 0 linproper drainAge; ­— - -k— site Snecific Practices -
facilities /` a Grade and landscape sUch-diat wow drains
e 'Microbial, ocomposition of away from facilities
r. Atter.
Man ire tracked onto Poorly maintained access roads 13 Farm
public toads from, farm access mad maintenance
Swine Manure Management; 0200 RuleffiMP, Packet
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet
Swine Production -Facility Manure-ManAgement: Pit Recilarge -Lagoon Treatment; EBAE 128-88
Swine Production Facility ManUm management,'Underfloor Flush - Lagoon Treatment; EBAE 1�9_gg
Lagoon Design and Man for L
agernent WOW Manu Treatment and Storage ; EBAE 103.g3
Uibratio.a. of Manuragh4 Wastewater Application . Equipment; EBAB FOct Sheet
Controlling Odors fiam, SWineBuildings; PIH-33
Enviromnental Assurance Program - NppC Manual
Options for Managing -Odor; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Mmagdatent: Odors and Flies; pRO107, 1995 Conference proceedings
Available From :
NCSU, Co�_n �Exjen�sion Ce�nter
NCSU-BAE
NCSU-BAE
NCSU-BAE
NCSU-BAE
NCSU-RAE
NCSU - Swine Extension
NC Pork Producers Assoc
NCSU Agri- Communications
Florida Cooperative Extension
AMOC - November 11, 1996, Page 5

Version —November 26, 2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When, selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill -at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
F] 1:1 1313.0200.
171 17 Rendering at a rendering plant licensed under G.S. 106-168.7.
1-1 1-1 Complete incineration according to 02 N6AC 52C .0102.
A ciomposting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
-additional requirements must be met and a permit is -required from NC DEQ.
In the caseof dead, poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 1061-549.70).
Any method which', inJhe professional opinion of the State Veterinarian, would make possible
the: salvage of part of a dead animal's value without endangering human or animal health.
Mritten approval by the State Veterinarian must be attached).
71 Mass Mortality Plan
Mass mortality� plans are required for farms covered by an NPDES permit. Theseplans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods:to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• Xcatastrophic mortality disposal plan is part. -of the facility's CAWMP and.is activated
when numbers.of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• "Buriahmust be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
/ e 9�44
Signature of Farm Owner/Manager Date
Qnt, f DO / dns� 3--24� —
/ Signature of Technical Specialist Date

�-arator:JW Mott County: Sampson
Date:
04/05/94
Distance to nearest residence (other
than owner):
11000.0 feet
AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish)
x 1417
lbs.
0 lbs
0 sows (farrow to feeder)
x 522
lbs.
0- lbs
5880 head (finishing only)
x 135
lbs.
793800 lbs
0 sows (farrow to wean)
x tj3
lbs.
0 Ibs
b0 head (wean to feeder)
x 30
lbs.
0 lbs
escribe other
0
Total
Average
793800 lbs
MINIMUM REQUIRED TREATMENT VOLUME
OF LAGOON
Volume = 793800 lbs. ALW x
Treatment Volume(CF)/lb.
ALM
Treatment Volume(CF)/lb. ALW
I CF/lb. ALW
Volume 793800 cubic feet
STORAGE VOLUME FOR SLUDGE ACCUMULATION Sivd
,5 e
Volume 0.0 cubic feet
0"A 11"J
ej-,t- , Rem o e S)., ds R
TOTAL DESIG-NED VOLUME
heeded.
Inside top length (feet) --------------------- 680.0
Inside top width (feet) ---------------------- 209.7
Top of dike elevation (feet) ----------------- 55.5
Bottom of lagoon elevation (feet) ------------ 43.5
Freeboard (feet) ----------------------------- 1.0
Side.slopes (inside lagoon) ------------------ 3.0 : I
Total design volume using prismoidal formula
SS/END1 SSIEND2 SS."SIDE1. SS/SIDE2 LENGTH WIDTH' DEPTH
3.0 3.0 1,0 , 111.0
203.7 L J-
- 3 .0 674.0 �v
AREA OF TOP
LENGTH * WIDTH
203.7 137276 (AREA OF TOP)
674.0
AREA OF BOTTOM
LENGTH * WIDTH
13-7.7 83706 (AREA� OF BOTTO-M)
608;0 L I
AREA OF MIDSECTION
LENGTH WIDTH * 4
641.0 170.7 437608 (AREA OF MIDSErTION
CU. FT. [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] DEPTH/6
137276.3 4137608.1 . 83705.8 1.8
Total Designed Volume Available = 1207415 CU. FT.

11
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
680.0 209.7 142578.3 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
TOTAL DA 142690.0 square feet,./
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
Volume = 793800 lbs. ALW/135 lbs. ALW *t 1.37 gal/day 180 days
Volume = 1450008 gals. or 193851.3 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
5C. Volume of rainfall in ex.cess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall 7.0 inches
Volume = 7.0 in * DA / 12� inches per foot tj W1
7�
Volume = 83235.8 cubic feet

5D. Volume of 25 year - 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume = 83235.8 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
193851
cubic
feet
5B.
0
cubic
feet
5C.
83236
cubic
feet
5D.
83236
cubic
feet
TOTAL 360323 cubic feet
6. SUMMARY
Temporary storage period====================>
180
days
Rainfall in excess of evaporation===========>
7.0
inches
25 year - 24 hour rainfall==================>
7.0
inches
Freeboard================P==================>
1.0
feet
Side
3.0
: 1
Inside top
680.0
feet
Inside top width============================>
209.7
feet
Top of dike elevation=======================>
55.5
feet
Bottom of lagoon elevation==================>
43.5
feet
Total required volume=======================>
1154123
cu. ft.
Actual design volume========================>
1207415
cu. ft.,
Seasonal high watertable elevation (SHWT)===>
50.8
feet''
Stop pumping
51.3
feet'
Must be > or = to the SHWT elev.==========>
50.8
feetv/
Must be > o r = to min. req. treatment el.=>
49.5
feet
'
Required minimum treatment volume===========>
793800
cu. ft.
Volume at stop pumping elevation============>
794700
cu. ft-
Start pumping
53.8
feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall==>
1124180
cu. ft.
Volume at start pumping elevation===========>
1112608
cu. ft.
Required volume to be pumped================>
277087
cu. ft.
Actual volume planned to be pumped==========>
317908
cu. ft.
Min. thickness of soil liner when required=0
1.8
eet
7. DESIGNED BY: 13 As , IS
V �* APPROVED BY: lalo.- & -
L
DATE: 4-s--q� DATE: -5�- le - C7 *
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS:

SHEET I OF 2
OPERATION AND MAINTENANCE PLAN
------------------------------
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (41) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is -recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2''its capacity to prevent excessive odors during
start-u.p. Pre-charg4ng reduces the c-oncentration cf the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging is complete,
flush buildings with.recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before 'Land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
3 0 as marked by permanent marker. Stop pump -
reaches th�e elevation 155.._
out when the fluid level reaches elevation 51.3 This temporary
storage, less 25 24 hr storm, contains _277087 cubic feel-- or
20721612 gallons.

SHEET 2 OF 20
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as,needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. Ail surface runoff is to be diverted from the�Iagoon to stable
outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the -discharge of
pollutants into waters of the United States. The Department of
Environment, Hea-lth, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.