820025_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 20K
Please do not leave any question unanswered Please verify all. information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
I . Farm Number: 82-0025 Certificate Of Coverage Number: AWS820025
2. Facility Name: Pork Plus
3. Landowner's Name (same as on the Waste Management Plan): Faison Investments LLC
4. Landowner's Mailing Address: PO Box 1015
City: Clinton State: NC Zip: 28329
Telephone Number: 910-260-0220 Ext. E-mail:
5. Facility's Physical Address: 915 Bill Williams Rd
City: Turkev State: NC Zip: 28393
6. County where Facility is located: Sampson
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code): C)
9. Integrator's Name (if there is not an Integrator, write "None"): M=hv-Brown LLC
10. Operator Name (OIC): Henry Elias Faison Phone No.: 944-240-OKI OIC #: 24806
11. Lessee's Name (if there is not a Lessee, write "None"): cT 10 14 6 6.12- o
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Swine - Feeder to Finish
Operation Types:
Swine
Cattle
Wean to Finish
Dairy Calf
Wean to Feeder
Dairy Heifer
Farrow to Finish
Milk Cow
Feeder to Finish
Dry Cow
Farrow to Wean
Beef Stocker Calf
Farrow to Feeder
BeefFeeder
Boar/Stud
Beef Broad Cow
Gilts
Other
Other
4,200
Dry Poultry
Other Types
Non Laying Chickens
Horses - Horses
Laying Chickens
Horses - Other
Pullers
Sheep - Sheep
Turkeys
Sheep - Other
Turkey Pullet
Wet Poultm
Non Laying Pullet
Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
1
19.00
PP
95,832.00
19.68
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The i-nost recent Waste Utilization Plan (WUP), signed by the owner and a certified -technical specialist', contauung:
a. The method by which waste is applied. to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wedand determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, Please include the additional components with your submittal
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package� you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.613, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C,
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporatio signati4re should be by a principal executi e officer of the corporation):
1n;1e_VYXcAiS
�A
7-D
Name: M q Title: ill Y
Signature: Date:
Yit '-�. ^
Name:
Signature:
Name:
Signature:
Title:
Date:
Title:
Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: 20l9PermitRenewa1Cancdcnr.gov
FORM: RENEWAL -STATE GENERAL 02/2019

Ploy COOPER
3"� ..
MtCHAEL 3. REGAN
APR 0 3
secrefflty
LINDA CULPEPPEk
NORTH CAROLINA
01redor
EnvironmentalQualfty
wow-awhy
juglunai Olwavons SGC*M
February 27, 2019
Faison Investments LLC
Pork Plus
PO Box 10 15
Clinton, NC 28329
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Pennittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non-Dischairge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at htips:Hdeg.nc.pov/about/divisions/Water-resources/Water-qualit%!-rep-ional-ooerations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure vour continued coverage under the State Non-Dischari--e General Permits- vou must submit an annlication for
permit coveLage to the Division. Enclosed you will find a "Eauest for Certificate of Cover&e Facilily Currenth Covered b�, an
Expiring State Non -Discharge General Permit." The ggplication form must be completed- signed and returned b%. Antil 3. 2019.
Please note that Non mus include one (1) copy of the Certified Animal Waste ManaRement Plan (CAWMPi with the
completed and siuned application form. A list of items included in the CAVVMP can be found on 12&e 2 of the renewal
Uplication form,
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9 100.
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Enclosures
cc (w/o enclosures): Fayetteville Regional Office, Water Quality Regional Operations Section
Sampson County Soil and Water Conservation District
AFOG Section Central Files - AWS820025
Murnhy-Brown LLC
Nor& Zs-o �ts Depaqire�t ffEr),.'ro- rre�ta r,.t.9 ty 1 0 Vs 2, M Water.Resmrces
512 N_ So -=b .,y St. 1 1636 V a' S--%- 3e Ze� � 7 1 Re e'e , No itt Cerc , a 2769M836
gig-737SWO

J95r-Own's of Carolina 5/19/2011 Hwy 24 East
Warsaw, NC 2839S
NUTRIENT UTILIZATION �PLAN
Grower(sy
Farm Name:
arm
Faisor Investments, Lu;
Pork Plus
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
L- Feeder to Finish 'dpnn�
Storage Strudur—e:
StOrage:Period:
Application Method:
180 days
Irrigation
The waste from your animal facility must be land applied at a. specified. rate to prevent pollution
of surface water andtor groundwater. The plant. nutrients in the animal waste should be used
fe
to reduce the amount of commercial fertilizer required for the c in the fields where the waste
rops
is to be applied..
This waste utilization plan uses nitrogen as the limiting nutrient, Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for re I* f ids of the c
alist yie rop to.be grown.
SSVOral factOrs,are important in implementing your waste utilization plan in. order to maximize
the fertilizer Value of the waste and to ensure that it is applied in an environmentally safe manner
I - AJWaYs-aPPlY Waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not . apply more nitrogen than the crop can utilize.
2. Soil typ" are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available waterholding capacities.
I Normally waste shall be applied to land eroding at les s than 5 tons per acre per
year. Waste may be applied toland eroding at 5 or more tons per ac re annu . ally, but
less than 10 tons per acre per year providing I . hat adequate filter strips are established.
4. Do not apply waste on saturated sails, when it is raining, or when the surface is frozen.
Faher of these conditions may result in runoff to surface w aters which is not allowed
under DWQ regulations.
5.. Wind conditions should also be conside, red to avoid drift and downwind odor
problems.
6, To maximize the value*of the nu . tr ients for crop production and to reduce the potential
for Pollution, the waste should be applied to a growing crop or applied �not more than
3Q days prior to plantinga crop or forages breaking dormancy. Injecting the waste or
disking will coriserve nutrients and reduce odor problems,
RECE1VFD;MC;r.1='A1R
i of 8
APR 0 3 290
Reg!Mll.ri---

This Plan is based an the waste application method shown above. if you choose to change
methods in the future, you need to revise this plan. Nutrient
levels for different application
methods are not the same,
The estimated acres needed to apply the animal waste Is based on typical nutrient co . ntent
for this We of facility. In some cam you may want to have plant ana"s made,,which could
allow additional waste to be applied. ProvWons, "I be made for ft area recelvin g waste.to
be f1eW6 so a rd to accommodate cha%lng waste analysis . content and crop type. Ume must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if.carried out, meets the re . quirements for compliance wi I th 15A NCAC
2H .0217 ado I pted by the Environmental Management Commisslom
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, W, tons, ellz):
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR Qbs):
Farrow to Feeder
.6.5 lbs/yr
p
[�;;r
Farrow to Finish
26 lbstyr
lbs/yr
Weanto Feeder
0.48 ftlyr
lb*
Feeder to Finish
2,3
Applying the above amount Of Waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utfization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of - nitrogen that the
crops under irrigation m take, ajqd uflfize
ay UP
'in the normal growing season.
Total Irrigated Acrftp:
53.91
TOMI.N. Required I St. Year:
13769.45
Total N Required 2nd Year:
lan.19
Ave" Anirtual NItr0W ftquimnuint of Crops- 15,229-32
Total NI"en Produced by Farm: 9,660.00
NitroWm Balar" for Crops: (5,569.32)
The following table describes the specifications of the hydrants and fields that contain the crops
d8slgf6t8d for Utilization of the nitrogen produced 0 1 n fts facility. This chart describe$ the size,
soil characteristics, and uptake rate for each crop In +he.VW!fied crop f0talion schedufa for this
facility,
2of8

This plan does not include commercial fertilizer. The farm should producv adequate plant
available nitrogen to Satisfy the requirements of the crops listed above.
The. applicator is cautioned that P and K may be over a . pplied while meeting the N requirements.
In the -fuWre, regulations may require farmers In some parts of North Carolina to have a nutrient
management. plan that addresses all nutrients. This plan o . nly . addresses n . itrog*n.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage mutt be removed
through grazing, hay,. and/or silage.- Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when: plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be.exeicised not to let small grain reach maturity,
especially late in the Season (iA
April or May). Shading may result if small grain gets too high and this will definat6ly interfere
with stand of bermudagrass. This lost of stand Y411 result in reduced yields and less nitro . gen
bein � Utilized. Rather
9 than cutting small grain for hay or silage just before heading as is
the normal situation,, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season. ..
depending on the
time small grain is planted in the falli
The ideaffirne to interplant small grain, atc, is late September or early October Drilling
recommended over broadcasting. Bermudagrass should be grazed or out to a height of
about two inchesbefore drilling for best results.
CROP CODE LEGEND
Crop Code Crop
Lbs N utilized I unit, yield
.A
Barley
1.6 lbs N / bushet
B
Hybrid Bermudagrass - Grazed
50 ft I N /ton
C
Hybrid Bermudagrass - Hay
60 lbs N / ton
D
Corn - Grain
1-25 Ibs N / bushel
E
Corn - Silage
12 The N I ton
F
G
Cotton
0. 12 lbs N / ibs lint
Fescue- Grazed
60 lbs N / ton
H
Fescue- Ha y
so 1178 N I ton
Oatt
I . .3 . lbs N / bushel
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 . lbs N I acre
L
Small Grain - Hay
50 lbs N / acre
M
Grain Sorghum
2.5 lbs N I cwt
N
Wheat
Z4 lbs N / bushel
0
Soybean
4.0 lbs N I bushel
P
Pine Trees
40 lbs N I acre / yr
Acres, Shown in ft Preceding table are considered to be the usable ac excluding
res
required buffers.. filter strips along ditches, odd
areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations.
Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables,
See attached MaP Showing the tield
s to be used for the utfizadon of animal waste.
4 of 8

SLUDGE APIPUCATION:
The following table describes the annual nitrogen accumulation rate p er animal
in the lagoon sludge
Farm Specifications PAN/yr/animal Farm Total/y
Farrow to Wean 0.84
Farrow to Feeder I I
Farrow to Finish 4 ' 1
Wean to. Feeder 0.072
L_ 4200 Feeder to Finish 0.36 1619
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge Will be nutrient rich and 1A411 require precautionary measures to
prevent over application of nutrients or other elements. Your prodt; tionfacilit
ic . y will produce
approximately 1512 pounds 61 plant available nitrogen per year Will accumulate in: the lagoon
studge based on the rates of accumulation listed above.
If you remove the sludge every.5 years, you Will have approximately 75.60 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda. rass hayland at ft
rate of 3M pounds of nitrogen per acre, you will need 25 acreas of. land. If you apply the slu I dge
to com at a rate of 125 pounds per acre, you Will need 60.48 acres of land. Please n . ote. that these
are only estimates of the PAN produced and the land required to utill . ze that PAN, Actual valuot
may only. be.determined by sampling ft sludge forptant available nitrogen content pnorto application
AcWal utilization rates Wit vary With soil type, crop, and realistic yield expectations. for the specific
application fields designatecl for sludge apprication at time ot removal.
APPUCATION I OF WASTE BY IRRIGATION -
The "ation application rate s . hould not exceed the intake rateof the soil at the time ofirrigation
such that runoff or ponding occurs. This rate is limited by Initial soil moisture content soil
structUre..soil texture, Water droplet size, and organic solids. The . application amount shGuld.not
exceed the available water holding capac*4 of the soil at the. t I of irri ation nor should the
me 9
p4antavailable nitrogen applied exceed the nitrogen needs of the crop -
If surface irrigation Is the method of land application for this plan, it is the responsibility of the
producer and. irrigation designer to . ensure that an irrigation system is installed to properly
irrigate the acres shown, in the preceding table. Faflure toapply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid -
*This is the maximurn application. amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied- In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. Th I e maximum
application amount shown can be applied'under optimum soil conditions -
Your facility is designed for >1 8.0, days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no Instance should the volume of the
waste stored in your eftucture be within the 25 year 24 hour storm storage or one foot of
fresbOard except in the event of the yew 24 hour storm.
It Is the * responsibility of the. producer and waste applicator to ensure that the spreader equipment
is operated property to apply the correct rates to the acres shown in the tables. Faflure'toapply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after u
yo receive the waste analysis report for assistance In
determining the amount of waste par acre and the proper application prior to applying the waste.
.5 of 8

Application Rate Guide
The following is Provided as a guide fer.establishing application rates and amounts.
soil Application Rate Application Amount
Tract Hydrant Type Crop In/hr Inches
6,A
Goldsboro
0
.0.4
6B
Goldsboro
0
0.4
6C
Goldsboro
(5
0.4
6D
Goldsboro
0
�0.4
6E
Goldsboro
0
0.4
6F
Goldsboro
0
0,4
6G
Goldsboro
0
0.4
6H
Goldsboro
0
0.4
s6b2
Norfolk
B
0.5
Sub6a-f
Goldsboro
0
sub6g&h
Goldsboro
0
OA
6 of 8

Additional Comments:
This plan includes an-22tional croe rotation of Millet(Rve which may be
use in any year. Field specifications for this rotation are listed. onpage
Small. grain hey after soybeans is an optional crop.
7 of 8

NUTRIENT UTILIZAIION PLAN CERTIFICATION
Name -of Form. Pork. Plus
Owner.. Faison Inveements, LLC
Manager.:,
Ownier/Manager Aereernent:
I/We. understand and Will follow and implement the spec'ifications and the operati . on and
maintenance procedures established in. the approved animal waste nutrient management
plan for the farm named above, IMe know that any expan . sion to the existing des! n I capacity
of the waste treatment and/or storage system, or construction of new facilities, will, require a
now nutrient management plaman . d a new ce0cation to be . su . bm . itted to DWQ before the new
animals are stocked.
(ANe understand that, I must own or have access to equipment, primarily irrigation equipment,
to. land apply the animal waste described in this nutrie . nt management plan. This equipment
must:be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also, certify that the waste w I ill be applie . d on . the land
,according to this plan at the appropriate times and at rates which produce no runoff.,
This plan, Will. be filed on site at the farm office and at the office of the local Soil and Water
Conservation. District and will.be available for review by NCDWQ upon request.
Name of Facility Owt
Signature:
Name of Manager (If
Signature:
Date
IName of Technical Specialist:
Affillatl6h:
Addjresse
Telephone:
Signature:
8 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECnCATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct appllcation� or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
Theremust be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properl�y applythe waste.. If the producer
does. not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, Who. is. within a reasonable proximity,
allowing him/her the use, of the land for waste application. It is . the �responsibility of the
owner of the waste production facility to secuire an update of the Nutrient U I tilization Plan
When there Is a change in the. operation, increase in the number of animals, method of
application, recieving crop tMe, or available land.
Animal waste.shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soH type, available mois lure, I historical data, climatic conditions, and
level of management, 'unless there are regulations that restrict the rate of applicat s for
ion
other nutrients.
Animal waste shall be applied to land eroding less than 5 tons per acre per I year. Waste
may be applied to land eroding at more than 5 tons per acre I per year but less than 10 tons
per acre per year provided grass fiftet strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips),
Odors can be reduced by injecting the wasteor disking after waste application. Waste
should. not be applied. when there is danger of drift from the land application field.
When animal waste is to be applied on acres subject to flooding, was te will be soil
Incorporated on conventionally tilled cropland. When waste is appli
ed to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a, season prone to flooding (See 'Weather and Climate In North CarollnW' to r
guidance).
Uquid waste shall be applied at rates not to exceed the soil inf 11tration rate such that runoff
does not occur oftsitt Or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
Animal waste shall notbe applied to saturated soils, du ing rai fall events, or when the
n n
surface, it f�ozen.
I Of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATI ONS
,(continued)
12 Animal waste shall be applied on act
ivety growing crops in. such a manner that the crop is
not covered with waste toa. depth that. would inhibit growth. The potential for salt.damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or, winter. for. spring planted crops on soils
with a high potential for leaching. Wastelinutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take upr released nutrients.
waste shall not be applied more than 30 days prior to planting of the. crop or . forages
breaking dormancy.
11 Any new swine facility sited on or After October 1, 1995 shall, comply with the following,
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall beat least 50 feet from any. residential pro rtyboundary
pe
and canal, Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall hot be applied closer than 25 feet to perennial waters.
12 Animal waste shall notbe applied closerthan, 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the. landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways-
15 Animal waste shall not be discharged into surface waters, dral-nageways, or wetlands by
discharge or by over'spraying. Animal waste may be applied to prior converted cropland
Provided the fields have. been approved as A land application site by a "techni
Cal
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be app . lied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, eto., shall
not be discharged into the animal. waste management system.
R EC E lVEDMC'L'0;M101qP-
A"PP 0 12019
wpwrowily
2 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary,� to
.protect the vegetation. Vegetation such as trees,.shrubs, and other Woody species, etc...
are limited to areas Where considered appropriate. Lagoon areas sh I ould be kept mowed
.and accessible. Berms. and structures should be Inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to. be . suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan* which, Will eliminate the
possibility of an illegal, discharge, pollution and en . osion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
,.basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can. be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be, installed, to mark the t . op and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons Pumping shall be
managed to maintain the liquid level between the rnarkers, A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and sol - I shall be tested at least annually
at crop site$ where waste products are applied. � Nitrogen shall be this rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate, Z and co
nc pOer levels in
the soil shall be monitored and altramative crop sites shall be used When these metals
approach excessive. levels. PH, shall be adjusted and maintained for opfimu
m crop
prodLction Soll and waste analysis records shall be kept for a minimum of rive years.
Poultry dry wasteapplicationrecords shall be maintained for a minimum of three years.
Waste. application records for all other Waste shall be maintained for a minimum of five
yem
28 Dead animals will be disposed of in -a manner that meets North Carolina regulations.
3 of 3

NUTRIENT UTILIZATION PLAN AMENDMENT
Grower(s)i
Farm Name:
Faison investments. LL-C
Pork Plus
Farrow to Wean
Farrow to Fe eder
Farrow to Finish
Wean to fee der
Feecler to Finish 4-?W
Storage Structurc
Storage Period.:
Application Method:
> 180 days
Ifrigatior
This i's a 1 -year amendment f . or T 12412 Fields 1,2 30 for the 2011/2012 crop year only.
-#1
Own anager
Teithnical Swial,
7-i�4u�(f
Date
15 - \k-e-
NET

P.0 rk�
5-
v -
71L
T
- . �� 6 0
:'� k!,f
L
;Q11, lr,!��
Yj
4,s 0�:
Lr
%
Al
tz
T"
%
-72
'�W
IL
i;
A
Atr-,o) i
IN . J.
v
Lz�
VX
I-T. kk�
Yf
jv.
aw,
Li
ZZA
:tr
AC
Lk
'd.
2
.,e,- &12;
_-w 9-
Q
j
W71
r
COOIOI010086
800119140248

G, rower, Pork I-Ilus
Address: PO Box 856
Warsaw, NC 28398
County: Sampson
uesignea L-sy: �,�,bvv
Checked By: DSE
Date: 03/05/09
Sheet 1 of 7
ANAEROBIC WASTE
LAGOON DESIGN
FARM INFORMATION
Farm Pooulation"
Nursery:
0
Wean to Finish:
0
Finishing:
4 2 06 I-ic,
Farrow to weanling.- ----------------
0
Farrow to feeder:
0
Farrow to finish: ---------------------
0
Boars:
0
Storage Period:
90 Days
25 Yr. 124 Hr Storm Event
7.0 In.
"Heavy Rain" Factor
Rainfall in Excess of Evaporation ----------- -- --------
7.0 In.
Additional Water Usage: ---------------
0
Additional Drainage Area:
LAGOON INFORMATION
Is Lagoon Designed as an Irregular Shape?
(Y/N)
------------
Y
Does Operator Want Emergency Spillway?
(YIN)
------------
N
Was This Design Built Prior to Sept. 1996?
(Y/N)
------------
Y
is Drain Tile Req'd to Lower SHWT?
(YIN.)
------------
N
Seasonal High Water Table Elev:
0.00
Freeboard,
I—C
Ft.
Emergency Spillway Flow Depth:
Side Slopes:
3
Top of Dike Elevation:
Depth
99.40
Ft.
Finished Bottom Elevation: BOTTOM E
-113,20
Ft.
86.20
Ft.
Start Pump Elevation:
19.68
In.
97.76
Ft.
Stop Pump Elevation-,
38.64
In.
96.18
Ft.
LAGOON VOLUME REQUIRED VOL.
DESIGN VOLUMES
%�REQ'P�
Storm Stor = 52207 (Cu.Ft.)
52,410
(Cu.Ft.)
Temporary = 121439 (Cu.Ft.)
122,039
(Cu.Ft.)
JC,.0.A9%
Permanent = 567000 (Cu.Ft.)
582,044
(Cu,Ft.)
Total Volume 740,646 (Cu.Ft.)
756,494
(CLI.Ft.)
t �nt Volume
I yf rj�
283,500
(Cu.Ft.)
1/2 Treatment Volume Elevation
92.04
Ft.
88.33
1r.
90 Temporary Storac e Volume Elevation
NIA
Ft.
WA
1 r i,
Min. Required Liner Thickness
1.9
Fr.
Lagoon Surface Area: (inside TOO)
89,497
S.F�
Murphy-Brov-1n, LLC Engla6aring P.O. Box 856,Vlarsairv. NC 2839B 293-3434

Grower: Pork Plus Designed Oy: KBW
Address- PO Box 856 Checked By: DSE
Warsaw, NC 28398 Date: 03/05/09
County: ampson Sheet 2 of 7 ----
ACTUAL DESIGN
VOLUME CALCULATIONS
BASE VOLUME:
�11�
Cu. Ft.
LAGOON STAGE -AREA VOLUMES
Contour
Elevation (FT.)
Area (SF)
Incr. Vol. (Cu. FT)
Cumul. Vol. (Cu.-FT
87.00
45,698
22,599
88.00
49,447
47,573
70,172
89.00
53,237
51,342
121,514
90.00
57,062
55,150
176,663
91.00
59,685
58,374
235,037
92.00
62,347
61,016
296,053
93.00
65,245
63,796
369,849
94.00
68,073
66,659
426,508
95.00
70,961
69,517
496,025
96.00
73,910
72,436
568,460
97.00
77,027
75,469
643,929
98.00
81,276
79,152
723,080
99.00
85,792
83,534
806,614
99.40
89,497
35,058
841,672
These volumes were calculated usin the vertical averaQ_q end area method.
TOTAL REQD VOL
740,646
CF
CUMULATIVE
V OL.
END PUMP==
96.18
FT
582,044 CF
TR'MT
START PUMP =
97.76
FT
704,084 CF
TEMP
MAX STORAGE
98.40
FT
756,494 CF
STORI
ZONE VOL.
102,14%
582,044
102.65%
122,039
100.49%
52,410
100.39%
Murphy -Brown, LLC Engineefing P.O. Box 856, Warsaw, NC 28398 �9110) 293-3434

Grower: Pork Plus
Address: PO Box 856
Warsaw, NC 28398
County: Sampson
MINIMUM REQUIRED VOLUME CALCULATIONS
Permanent Storage:
Required Treatment Volume:
Designed By:
Checked By:
Date:
Sheet 3 of 7
capacity ALW (cu.ft./lb) �Iotal
Nursery
0
30
1.00
0
Wean to Finish
0
115
1.00
0
Finishing
4,200
135
1.00
567,000
Farrow to weanling
0
433
1.00
0
Farrow to feeder
0
M
1.00
Farrow to finish
0
1,417
1.00
0
Boars
0
400
1.00
0
Total Required Treatment Volume (cu. ft.)= 567,000
Sludge Storage Voitime:
Rn —ima-I I Ype Capacity ALW ?cu.ft./lb) L1018,1
-Nursery
0
30
0.00
0
Wean to Finish
0
115
0.00
0
Finishing
___�F2_00
135
433
0.00
0
Farrow to weanling
0
0.00
0
Farrow to feeder
0
522
0.00
0
Farrow to finiih
Boars
0
1,417
0.00
0
Jotal Required Sludge Storage Volume (cu. ft.)= 0
Temporary Storage Volume.
Manure Production:
Nursery
0
90
0.30
0
Wean to Finish
0
90
1.17
0
F Fniih _in9­__'
4-.2'-00--
9-0
1 . 3'-7'
-5-17'- -
.860
Farrow to weanfinq
0
90
90
530
0
0
Farrow to feeder
0
Farro�� to _fjnis� ------ -
0
.3
0
Boars 0 -T
90 4.06 0
0.
Total Manure Production (gals.)= 517,860
Total Manure Production (cu.ft.)= 69,233
Excess Fresh Water:
M1111FIal I ype f-apacity - oio. renoo:i.icay) i oEai
Nursery
0
90
0.00
Wean to Finish
0
90
0.00
0.00
0
0
Finishing
4,200
90
go
Farrow to weanling
0;
Farrow to feeder
0
Farrow to finish
0
90
0.00
0
Boars 907 0.00
Total Fresh Water Excess (gals.)= 0
Total Fresh Water Excess (cu.ft.)= 0
NOUS]
DSE
03/05/09

Grower: Pork Plus Designed By: KBW
Address: PO Box 856 Checked By: DSE
Warsaw, NC 28398 Date: 03/05/09
County: Sampson Sheet 4 of 7
TemRorary Storage Volume: (Cont.
Rainfall in Excess of Evaporation:
Vol.=(Lagoon Surface Area + Additional Drainage Area) * Rainfall 12in./ft
Vol.= (89497 sq.ft, + 0 sq.ft.) ' 7 in. /12 infft.
Total Required Volume for Rainfall in Excess of Evap. (cu.ft.)= 52,207
Storm Storage:
Vol.=(Lagoon Surl. Area + Addt'l Drainage Area) * 25Yr./24Hr. Storrn(in) / 12in./ft.
Vol.= (89497 sq.ft + 0 sq.ft.) * 7.0 in. /12 in./ft.
Total Required Volume for 25YO24Hr. Storm Event (cu.ft)= 52,207
"Heavy Rain" Storage
Vol.=(Lagoon Surf. Area + Addfl Drainage Area) * "Heavy Rain" Factor (in) / 12in./ft.
Vol.= (89497 sq.ft + 0 sq.ft.) * 0.0 in. /12 in./ft.
Total Required Volume for "Heavy Rain" (cu.ft.) = 0
(for Extended Periods of Chronic Rainfall)
Additional Water Storage:
No Additional Water Storage is Required
0 0
Total Required Storm Storage
(25Yr. / 24Hr. Storm + 'Heavy Rain')= 52,207 (CU.FT)
Total Required Temporary Storage
(Manure Prod. + Excess Fr. Water + Rainfall Excess + Additional Water Storage) 121,439 (CUYT)
I I
I Total Required Permanent Storage

1 Grower: Pork -Plus
Address: PC Box 856
Warsaw, NC 28398
COLJfltY: Sampson
LAGOON DESIGN SUMMARY
Designed By: KBW
Checked By: DSE
Date: 0311151119
Sheet 5 of 7
Top of Dike Elevation --------
99.40
FT.
Emergency Spillway Crest Elevation
Not Al Applicable
Top of 25Yr. / 24Hr. Storm Storage --- — ---------
98.40
FT.
Top of "Heavy Rain" Storage ------- -- --------
Not
Applicable
Start Pump Elevation
97.76
FT.
End Pump Elevation — ... .. .... ------
96.18
FT.
Top of Sludge Storage
Not
Applicable
Seasonal High Watertable Elev. ---
0.00
Finished Bottom Elevation
86.20
FT.
inside Top Length
Not
Applicable
Inside Top Width
Not
Applicable
Side Slopes
3:1
H:V
Lagoon Surface Area ...........
89,497
SF
Min. Liner Thickness (if required)
1.9
FT.
Freeboard Depth
1.00
FT.
Temporary Storage Period
90
Days
Zone Depths:
TOTAL DESIGN VOLUME = 756494 (CU.FT.)
Treatment I Sludge Storage Zone Depth 10.0 FT.
Temporary Storage Zone Depth 1.6 FT.
Freeboard / Storm Storage Zone Depth 1.6 FT.
To—talEa-g­oo-n-djpt�i 13.2 FT.
Murphv-Brown, I -LC Etminoorhia P.O. Box 656, Warsa w A/C 28398

Grower: Pork Plus Desiogne KBV,,�-
Address: PO Box 856 Checke(DSE
Warsaw, NC 28398 Date: 03/05109
Countv: Samr)son Sheet 6 of 7
ZONE ELEVATIONS
TOP OF DIKE ELEV = 99.40
TQP OF STORM ELEV = 98.40
STRT PMP EL.= 97.76 TOP OF TEMP STORAGE ELEV = 97.76
END PMP EL. 96.18 TOP OF TREAT E LEV = 96 � 18 SHWT O�00
FINISHED BOTTOM ELEV = 86.20
Murphy -Brown, LLC Engineering P-0. Box 856, Warsaw NC 28398 (910.) 293-3434

A VA L.L A
FARMS INC
*Yiii -00 Crye.)
oz,
iA4/
ENCINEERING DEPARTMENT
C At C'I JI ATE D e
2111. &)rr P. a vox 7jo
14OR Of CARaLWA
",.pux,�. fl
IR
5 r me r-
0 3
B00119140198

L'i
. ke
. N
-PP
ook;
C,&, M 1 -..2-
0 C
lll,ao� CQ9 Pjll!AIGI,�t'vl Is! C.
lma.�c 'J' DA'F.l,m �f!:.l-.,- Abe�L)o.l
9- . v.# U
'A

J4
C00101010087
B00119140182

Swine Farm Waste Management Odor Control Checklist
Source
Cause
BMPs to Minimize Odor
Farmstead
Swine production
lative or wooded buffers;
51"" Recommended best management practices;
Or' Good judgment and common sense
Animal body surfaces
0 Dirty manure -covered animals
PF —Dry floors
Floor surfaces
0 Wet manure -covered floors
CKSlotled floors;
Or" Waterers located over slotted floors;
CI Feeders at high end of solid floors;
Gr Scrape manure buildup from floors;
13 Undcrfioor ventilation for dry ing
Manure collection pits
a Urine;
R"'Frequent manure removal by flush, pit recharge,
0 Partial microbial decomposition
or scrape;
0 Underfloor ventilation
-V-e-n ii -1 aa i o ­nc A na us t- fain
-se- Volatile gases;
9"' Fan maintenance;
Dust
ff"Efficieni air movement
hn-d-o—orsurfaces- ____
Flush tanks
Cr4-asildown between groups of animals;
(3 Feed additives;
13 Feeder covers;
Nr Feed delivery downspout extenders to feeder
covers
(3 Flush tank covers;
(3 Extend rill lines to near bonom of tanks whit
anti -siphon vents
Flush alleys 0 Agitation during wastewater 13 Underfloor flush Willi underfloor ventilation
conveyance
Pit rechargc: points 0 A Silation of recycled lagoon 57Exlend recharge lines to near bottoin of pits
liquid While pits are filling Willi anti -siphon velds
Lift stations 0 Agitation during sump lank 13 Sump tank covers
filling and drawdown
-dudii-de--ldia-in coll—ectio-n-j" --- -Agil a-1-i-o in-d-ur-in-g -w—astewater 0 -B-ox-cow—ers-
or junction boxes conveyance
0 Dust
Agitation of recycled lagoon
liquid while tanks are filling
AMOC - November 11, 1996. Page 3
BOMW40260
C00107021353
I

End of drainpipes at
Cause
Agitation duruig %yastewaier
El
IIMPs to Minimize 0(16r
Extend discharge point of pipes underneath
lagoon
conveyance
lagoon liquid level
Lagoms—ur6cm—s
Volatile gas emissions;
Er
Proper lagoon liquid capacity;
Biological mixing;
0
Correct lagoon startup procedures;
Agitation
D"'Minimum surface arcaLlo-volume ratio;
0-'Mininium agitation when.puinping.,
Cl
Mechanical aeration;
0
Proven biological additives
Irrigation sprinkler
nozzles
11 igli pressure agitation;
0
]frigate on dry days with little or no wind;
Wind drift
D""Minimum recommended operating pressure;
W Pump intake near lagoon liquid surface;
0
Pump from second -stage lagoon
Storage tank or basin
surface
Partial microbial decomposition-,
0
Bottom or midlevel loading;
Mixing while filling;
0
Tank covers;
Agiiation when emptying
0
Basin surface mats of solids;
0
Proven biological additives or oxidants
Scaling basin surface
Partial microbial decomposition;
0
Extend drainpipe outlets undenicaili liquid
Mixing while 1111ing;
level.
Agitation when emptying
0
Remove settled solids regularly
Manure, slurry or sludge
9 Agitation when spreading;
0
Soil injection of slurryisludgcs;
spreader outlets
a Volatile ga-s emissions
13
* Wash residual manure from spreader after use;
0
Proven biological additives or oxidants
Uncovered manure, Volatile gas emissions while
slurry or sludge on field drying
surfaces
Dead animals * Carcass decomposition
Dead animal disposal . C;JrC;Iss dCcoI_II_J)_O`s_I(_I_O_n___
pits
Incinerators IFIC0110cle _Conibusfiun
ANf. November 11, 1996, llagc;
Cl Soil injection of slurry/sludges
11 Soil incorporation within 48 firs.;
0 Spread in thin uniform layers for rapid drying;
0 Proven biological additives or oxidanis
Proper disposition of carcasses
0 Complete covering of carcasses in bilrial pits;
0 Proper lOCafiOR/COIISIFLJCfiOIJ ot'disposal pils
0 Secondary siack bLIfflCrS
B00119140261
C00107021354
i
L
le

Source Cause DIVIPS 10-Minknize . Odor
Standing water around Improper drainage;
facilities ra C and landscape such that water drains
Microbial decomposition of away from facilities
organic matter
Manure tracked onto J'00"IY maintzined access roads--&7-Fa-ni-'- a--cco—ssroad maintenance
public roads from I-ann
access
Addi(ional Inforniation :
Swine Manure Management ; 0200 Rule/BMP Packet
Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recliarge, - Lagoon Treatment ; EBAE 128-88
Swine Production, Facility Manure Management: Underfloor Flush - Lagoon Treatment; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatinent and Storage; EBAE 10-83
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
Controlling Odors from Swine Buildings ; P11-1-33
Environmenial ASSUMI)CC 1'rograin ; NPPC Manual
Options for Managing Odor ; a report from the Swine Odor Task Force
Nuisance C011cerris in Animal tvIalitire Ma"a8c,licill: Odors and Flies -. PRO107, 1995 Conference Proceedings
a
AMOC - NUVO IIbCr 1], 1996, Page 5
Available I-rom -.
NCSIJ, County Extension Cenler
NCSU - 13AE
NCSU-BAE
NCSU - BAE
NCSU-BAE
NCSU-BAE
NCSU - Swine Extension
NC Pork Producers Assoc
NCSU Agri Communications
Florida Cooperative ExIension
BOOIJ9140262
C00107021355

OPERATION AND MAINTENANCE PLAN SHEET I OF 2
------------------------------
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed tempgrary storage consists of &1- 180 days storage fo
(1) waste from animals and (2) excess rainfall afterf evaporation. ­
included is storage for the 25 year'- 24 hour storm r the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from'*
lon''to It"" ,
buildifig(s) . If the outlet pipe is not installed at the elevat
begin pumping, a permanent marker must be installed at this elevation'
to indicate when pumping should begin. An elevation must be establish4"a
to stop pumping to maintain lagoon treatment depth.
t
Pumping can be started or stopped at any �ime between these wo
elevations for operating convenience as site conditions permit,- uch! 'a"s'
weather, soils, crop, and equipment in order to apply waste'withot�t'-t'
runoff or leaching.
6
Ale
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid
P
center pivot, guns, and traveling gun irrigation. Care shoul b
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1 - It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should b eii
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 0. 0 as marked by permanent marker. Stop pump -
out when the fluid level reaches elevation 0.0 - This temporary
storage, less 25 yr- 24 hr storm, contains 0 cubic feet or
0 gallons.
B00119140201
C00107021346

SHEET 2 OF 2
4. The recommended maximum amount to apply per irrigation is
One (1) inch and the recommended maximum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. 'Keep vegetation'on the embankment and areas adjIcent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair
any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 f�eet of a
residence or within loo feet of a well. Waste shall be 'applied in"a"
manne t to reach other property and public right-6f-ways
T
arg"'
A.
9. lean Water Act of 1977 prohibits the disc'h e of
Pollutants into waters of the United States. The Depart- ent'*'"o'f
Environment, Health, and Natural Resources, Division of mEnviron--..-t-k-
mental Management, has the responsibility for enforcing this law.,.*,-.*';�:',
A Z `C
B00119140202
C00107021347

Insect Control Checklist for Animal Operations
Source cause
BMPs to Control Insects
—AccumulatiOn
Liquid Systems
Mu—shGuller—s of solids 0
Flush system is designed and operat—ed
sufficierilly to remove accumulated solids from
gullers as designed.
0
Remove bridging of accumulated solids at
—ed
discharge
Lagoons and Pits Qr—us I S 0- 11 d's- —
Maintain lago6ns, settling basins and pils where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
Excessive Vegetative Decaying vegetation U-
Maintain vegelalive control along banks of
Growth
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along walces edge on ijupoutiduienes perimeter.
Dry Systems
Fccders Feed Spillage (3
Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize die
accumulation of decaying wastage.
13
Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
during winter).
Feed Storage Accumulations of feed residues-0
Re—ducenioislu re accumulation within and
around ininiediaie perimeter of feed storage
arm by insuring drainage away from site
andlor providing adequate cowaininent (e.g.,
covered bin for brewees grain and similar high
moisture grain products).
13
Inspect for and remove or break tip accuinulated
solids in filler strips around ficed storage as
needed.
AV' - - Novenibcr 11, 1996. Page I
B00119140259
C00107021356

EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ) (9101433-3300
EMERGENCY MANAGEMENT SERVICES (EMS) [phone]
SOIL AND WATER CONSERVATION DISTRICT (SWCD) [phone]
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) [phone]
COOPERATIVE EXTENSION SERVICE (CES) [phone]
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters or
leave your pr6perty to consider that you have a problem. You should make every effort
to ensure that this does not happen. This plan should be posted in an accessible
location for all employees at the facility. The following are some action items you should
take,
1.
Stop the release of wastes. Depending on the situation, this may or may not,be possible. Suggested
responses to some possible problems are listed below.
A.
Lagoon
overflow - possible solutions are:
a)
Add soil to berm to increase elevation of dam.
b)
Pump wastes to fields at an acceptable rate.
C)
Stop all flow to the lagoon immediately.
d)
Call a pumping contractor.
e)
Make sure no surface water is entering lagoon.
B.
Runoff
from waste application field -actions include:
a)
Immediately stop waste application.
b)
Create a temporary diversion to contain waste.
C)
Incorporate waste to reduce runoff.
d)
Evaluate and eliminate the reason(s) that cause the runoff.
e)
Evaluate the application rates for the fields where runoff occurred.
C.
Leakage from the waste pipes and sprinklers - action include:
a)
Stop recycle pump,
b)
Stop irrigation Pump.
C)
Close valves to eliminate further discharge.
d)
Repair all leaks prior to restarting pumps.
Leakage from flush systems, houses. solid separators - action include:
a)
Stop recycle JAIMP.
b)
Stop irrigation pump.
C)
Make sure siphon occurs.
d)
Stop all flow in the house, flush systems, or solid separators.
E.
Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing leaks -
possible action:
a)
Dig a Small sump or ditch from the embankment to catch all seepage, put in a submersible
pump, and punip back to lagoon.
b)
If holes are Caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
C)
Have a profossional evaluate the condition of the side walls and the lagoon bottom as
soon as possitilo,
12 5 2oo-

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone #, After hours,
emergency number: [phone]. Your phone call should include: your name,
facility number, telephone number, the details of the incident from item 2 above, the
exact location of the facility, the location or direction of the movement of the spill, weather
and- wind conditions. The corrective measures that have been under taken, and the
seriousness of the situation.
b. If the spill leaves property or enters surface waters, call local EMS phone number.
c. Instruct EMS to contact local Health Department.
d. Contact CE's phone number, local SWCD office phone number and the local NRCS
office for advice / technical assistance phone number.
If none of the above works call 911 or the Sheriff's Department and explain your problem to
them and ask the person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair or problem to minimize offsite damage.
a. Contractors Name: Murphy Brown, LLC
b. Contractors Address: P.O. Box 856, Warsaw, NC 2839
c. Contractors Phone: [phone]
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting Engineer, etc.)
Name: Kraig Westerbeek
Phone: (910) 293 - 5330
Implement procedures as advised by DWQ and technical assistance agencies to rectify
the damage, repair the system, and reassess the waste management plan to keep
problems with release of wastes from happening again.
12 5-2007

PAW
. Nk�
jowl .
ol
cl
lo
tL 11 A
1. LC,
lr,,j6o Farm 44
rj '. 1.0 E
go

C00101010087
B00119140182

Version —November 26, 2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.1 06-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by INIC DEQ under GS 1 5A NCAC
E] 13B .0200.
10-74 F7, Rendering at a rendering plant licensed under G.S. 106-168.7.
F] F-1 Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
E] F-1 sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPIDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• Inthe vent of 'imminent threat of a disease emergency, the State Veterinarian may enact
additi nail rocedures or measures for disposal according to G.S. 106-399.4.
0
Signature oft�W�Nanager Date
Signature of Technical Specialist Date