740094_Permit Renewal Application 2019_20190410

On September 30, 2019,
expire. As required by (I
Non -Discharge General Per
must be received by the Divis
Please do not leave any
APplicardon insist be signed at
1. Farm Number: 74-00
2� Facility Name: Horne
3. Landowner's Name (same
4. Landowner's Mailing Add
City. Fountain
Telephone Number: 2
State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
icility Currently covered by an Expiring Sate Non -Discharge General Pennit
North Carolina Slate Non-Dischiltige General Pennits for Animal Waste Management Systems will
permits, facilities that have been issued Certificates of Coverage to operate tinder these Slate
s must apply for renewal at least 190 days prior to their expiration date. Therefore, all applications
Of Water Resources by no later than April 3,2019.
uestion unanswered. P100se V810Y 411 i"forinadon and make any necessary corrections below.
fated by the Perniftlee.
oil the Waste Management Plan):
s: 6514 NC Hwv 222
Cerlifloate Of Coverage Number:
1=�Othv Brian Burne
State: h[Cc
E-mail: tiburnettAcolonytire,com
5. Facility's Physical Add... 3004 Emina Bumette Ln
City: SO—Untam State: N—C
6. County where Facility is lot ated: Pitt
7. Farm Manager's Name (if di Terent from Laridowner):
8. Farm Managees telephone n imber (include area code):
9. integrator'& Name (if there i! not an integrator, writa,,None,,):
10. Operator Name (OIC): Roland E. Allen Jr.
11. Le5sces Name (if them is n4t a Lessee, write "Nort,"):
12. Indicate animal operation
Current Permit:
Overittims Irynes-
sAi"
Wean to Finish
Wcam to F"de,
Fimo� to Finish
Feeder to Finish
Farrow to Wei,
Fallow to Feeder
Boar/Stud
Gilts
Other
and number.
Swine - Wean to
Cattle
Dairy Calf
Dairy Heifer
Milk Cow
Dry Cow
Beef Stucker Calf
13cerFreell,
Beel'Bruad Cow
Other
Timothy Brian Barnette
252-749-4135 Ext,
Murphy-Browri LLC
Phone No.: 252-733-2744
Allowable Count
4,330
Dry Poultry
Noa Laying Chickens
Laying Chickens
pollots
Turkeys
Turkey Pullet
Wet Penn
Non Laying Pullet
Layers
AWS740094
Zip: 27829
Zip: 27829
OIC 9: L9273
Other T"es
Homes - Homes
Horses - Other
slicep - Sheep
Sheep - Other

13. Waste Treatment and Stora xe Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide ml sing data.)
Stmetuic
Estimated
Dat�
Built
Liner Type
[Clay, Symbeli,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Are.
(Square Feet)
Deiag. Freclioard
"Redline"
(Inches)
Mail One (1) copy of the �erlifiecl Anm121 Waste Management Plan (CAY1rMP) with this completed and signed application
25 required by NC General Sta tes 143-215JOC(d) to the address below.
The CAWMP must include the Itlawing components:
1. The most recen Wastt Utilization plan (WUp), signed bY the owner and a certified technical specialist, containing:
a. The method by w nch waste is applied to the disposal fields (e.g- irrigation, injection, etc-)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series pin sent on every land application field
d. The crops grown in "cry land application field
e� The Realistic Yie d Expectation (RYE) for every crop shown in the WUP
f. The maximum P/ N to be applied to every land application field
g. The waste applies tion windows for every crop utilized in the WUP
h- The required NRGS Standard specifications
2. A site map/schematic
3. Emergency Action Pla i
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklis with chosen best management practices noted
6. Mortality Control Cho( Islist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoontstorage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also pronde any site evaltuitions, wedand determinations, or hazard classifications that may be applicable to
your facility'
8. Operation and Mainten[mce Plan
If your CAWMP includes
(C-9, composting, digesters, m
As a second option to
application and all the CA
components not shown an this list, please include the additional components with your submittal.
transfers, etc-)
ng paper copies of the application package, you eon scan and email one signed copy of the
items above to: 2019Permi([e-mail]

I atIcSt that this application been revievved by me and is accurate and complete to the best of my k,,,Icdgc. I understand that,
if all required parts of Illiss application are not completed and that if all required supporting information and anachments, are not
included, this appli�arjen packa 'e%iliberet�edroiilcasimompletc
Note: In accordance ith N,� Garcia Su,mcs 143-215.6A and 143-215.68� any person who knowingly nvikes any raise statement,
representation, or coni icidon in my application my be subject to civil penalties up to $25,000 per violation. (iti L.S.C.
'qect'rm 1001 Provides I punishment by a fine Of not More than SIOX00 or imprisonment or n in r h ye o to
a similar offense-) Or 0 a I an 5 air, r broth r
printed t4ame Of Signing Official Landowner, Or if multiple Landowners all landowners should sign. If Landomer is a
corporation, signature should be by a principal o,,culive officer of he cogimsfion):
Name: a)y Title:
Signature
Name; Title
Signature: Date
Name: Title -
Signature: Date:
THE C )MPLETED APPLICATION SHOULD B2 SENT TO THE FOLLOWING ADDUSS:
NCDEQ-DWR
Animal V"119 Operatfons Program
1636 Mail Service Center
Raleigh, North C�roljna 27(,99,.1636
Tillellaftcl!16 Humber: (919) 707-9joe
E-maili 2019PermitRtne�[e-mail]
FORIkk RMWAL-STATIR0,*CRAL0212019

Notification of Change of Ownership
Animal Waste Management Facility
type or print all information that does not require a signature)
In accordance with the requi ements of 15A NCAC 2H .0217(a)(1)(H)(xii) this form is official notification to the Division
or Water Quality (DWQ) of the transfer of ownership of an Animal Waste Management FacifitY. This form must be
submitted to DWQ no later th in 60 days following the transfer of ownership.
General Information-
NameofFarm:—
Previous Owner(s)
Now Owner(s) Nat
Mailing Address:_
C
vNoi -74/ - 9 Ll
liop 791-y�31
No:—;L� 7V9 —�135—
Form Location: Latitude nd Longitude: =��V
11 L 3,*' ;to' Courry: ph�
Please attach a copy of a co road map with location identified and describe below (Be specific: road names, directions,
— ut
milepost, etc.):
Operation Description:
Type of Swine Xo� of
1XWean to Feeder
11 Feeder to Finish
El Farrow to Wean
0 Farrow to Feeder
11 Farrow to Finish
11 Gilts
0 Boars
K
Type of Poultry No. OfAnunals
0 Layer
0 Pallets
Other Type of Livestock.
TypeofCattle No.ofAniinals
0 Dairy
11 Beef
Number ofAninuils:_
Acreage Available for Applica�on: Required Acreage: 2 �1.
Number of Lagoons / Storage tends Total Capacity: Y, 0/ 3 Cubic Feet (ft3)
Owner I Manager Agreerm
I (we) verify that all the abo,
and maintenance procedures
above and will implement th
of the waste treatment and st
animals are stocked. I (we)
system to surface waters of fl
the 25-year, 24-hour stormai
facility may be covered by a
Division of Water Quality to
Name of Previous Land Ow
Name of New Land
Name of Manager(if
Please sign and return this
information is correct and will be updated upon changing. I (we) understand the operation
tablished in the Certified Animal Waste Management Plan (CAWMP) for the farm named
procedures. I (we) know that any modification or expansion to the existing design capacity
ige system or construction of new facilities will require a permit modification before the now
iderstand that there must be no discharge of animal waste from the storage or application
state either directly through a man-made conveyance or from a storm event less severe than
there must not be ran -off from the application of animal waste. I (we) understand that this
ate Non -Discharge Permit or a NPDES Permit and completion of this form authorizes the
ric the required permit to the new land owner.
to: N. C. Division of Water Quality
Aquifer Protection Section
Animal Feeding Operations Unit
1636 Mail Service Center
November 1, 2004

Murphy -Brown, LLC 1116/2014 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Storage Period:
Application Method:
Brian Burnette
Burnette Farms, Fac, No.. 74-94
Pitt
>1 80 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1 Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
6. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6, To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 11

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied While meeting the N requirements
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
in interplanted fields ( i.e. small grain, etc, finterseeded in bermude), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage. care
should be exercised not to let small grain reach maturity, especially late in the season (i,e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as Is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermuclagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N bushel
B
Hybrid Bermudagi-ass - Grazed
50 lbs N ton
C
Hybrid Bermudagrass - Hay
50 Ids N I ton
D
Corn - Grain
1.25 lbs N / bushel
E
Corn - Silage
12 lbs N / ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue - Grazed
50 lbs N / ton
H
Fescue - Hay
50 lbs N I ton
I
Oats
1.3 lbs N / bushel
J
Rye
2.4 lbs IN / bushel
K
Small Grain - Grazed
50 lbs N / acre
L
Small Grain - Hay
50 lbs N I acre
M
Grain Sorghum
2.6 lbs N I cwt
IN
Wheat
2.4 lbs N / bushel
0
Soybean
4.0 lbs N / bushel
P
Pine Trees
40 lbs N I acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 11

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
in1hr
Inches
T10038-Fl
1
Norfolk
D
0.5
1
T10038-Fl
2
Norfolk
D
0.5
1
T10038-Fl
3
Norfolk
D
0.5
T10038-Fl
4
Norfolk
D
0.5
T10037-Fl,:
5
Norfolk
D
0.5
T10037-Fl,:
6
Norfolk
D
0.5
T10037-Fl,:
7
Norfolk
D
0.5
T10037-Fl,:
8
Norfolk
D
0.5
T10037-Fl.:
9
Norfolk
D
0.5
T10037-Fl,:
10
Norfolk
D
0.5
T10037-Fl,:
11
Norfolk
D
0.5
6 of 11

Additional Comments:
This plan revised to reflect the addition of T1 0037-Fl & 2, the conversion
of the solid set system to reel pulls, and the conversion from bermudagrass
to row
7 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs. and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible, Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds,
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
11 of 11

SEEDING SPECIFICATIONS
----------------------
AREA TO BE SEE D: 1 .0 ACRES
USE TH TURE INDICATED AS FOLLOWS:
0.0 LBS. 4ESCUE GRASS AT 60 LBS./ACRE
l(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 1 TO NOVEMBER 30
FEBRUARY I TO MARCH 30
0.0 LBS. ',YE GRAIN AT 30 LES./ACRE (NURSERY FOR FESCUE)
0.0 LES. PENSACOLA' BAHIA GRASS AT 60 LBS-/ACRE
�SEE FOOTNOTE NO. 1)
3EEDING DATES: MARCH 15 TO JUNE 15
10.0 LES. 4ULLED COMMON BERMUDA GRASS AT 8 LBS./ACRE
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
0.0 LES. NHULLED COMMON BERMUDA GRASS AT 10 LBS./ACRE
SEEDING DATES: JANUARY 1 TO MARCH 30
0.0 LES. YE GRASS AT 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER I TO MARCH 30
LES.
APPLY THE FOLZOWING:
1000.0 LES. [F 10-10-10 FERTILIZER (1000 LBPS./ACRE)
2-0 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
100.0 BALE OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE D INS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED1 'EA IATELY AFTER EARTH MOVING IS COMPLETED.
Ap THEN DISK TO PREPARE A 3 TO 4 INCH
APPLY LIME A .0 FERTI�MZD
SMOOTH SEEDBEO. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER.
OR SIMILAR EfPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOO OR NETTING.
1. pENSACOL�. BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMOI�
BERMUDA C SS WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRI OF �OMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAT JAGRASS I S ESTABLISHED.

Community or
Estimated Depth
Date of Field Hazard
Evaluation by reach
dam failure.
CLASSIFICATION DATA SHEET FOR LAGOONS
County—Z,--7Lq- — .
Conservation Plan
Top of Darn
Length of Flood Pool j)o t.
plain downstream to the point of estimated minor effect from sudden
—�F
Fst-Elev-
Est. Elev.
F ev-
Reach
Length
I
lidth
Slope
Land
Kind of
�e:nts
Improvements
prov
each
of Breach
of B
Use
Improvements
Above Flood
Floodwater Abov,
P lw�
kin
It
Flood Plain
F t-
Ft
%
Ft
Ft.
2
3
Describe potential for
loss of He and damagge to existin.g or
probable future
downstrearn
improvements from a
>udden breach
IV',4 /'077V';4C-
g9F I_ly'zLc- oe .5M-b�f7ZJA-6=S
Hazard Classification
Dam 19b, c) (s NEM-Part 520.211)
Dam Cla�s- 4,-on (L
Z�, IV, V)
By
Date f4-2-61r,(�
ej
(tide)
Concurred By
(name
J (fide)
Date
NOTE: 1. Instructid
sonreverseside.
2. Attach a,
ditional sheets as needed.

North Carolina Di,
Water Quality Sec
Non -Discharge PE
1617 Mail Service
Raleigh, North Ca
To whom it may
Mr. Timothy Brian
purchase property
recently operated
SSLW), registered
grandfather). The
empty. Mr. Burnel
application area in(
to accommodate 4
Mr. Burnette reque
lagoon; all adjoinin
be reconstructed t(
structures. The ex
standards. An app
items pertaining to
AIN CONSULTING SERVICES, INC.
May 31, 2006
of water Quality
Unit
27699-1617
mette is under agreement with a family member in Pitt County to
�t includes existing swine buildings and lagoon. The facility most
a 300 head swine farrow to wean pig operation (129,900 Lb
Facility # 74-94 and known as the Paul Burnette Farm (Brian's
-ility was operated until approximately 1999 and has since been
will purchase the property with buildings, lagoon and land
Jed and now desires to upgrade the existing lagoon and buildings
0 pigs wean -feeder (129,900 Lb SSLW).
Its issuance of a General Permit based on existing facilities and
property remains in his grandmother's possession. Buildings will
meet modern requirements in the same location as existing
ting lagoon is to be improved and brought up to current design
-ation is included, along with all components of a CAWIMP except
he Swine Farm Siting Act, since this is an existing facility.
Due to current overgrowth, liquid volumes, and other obstacles, further details on
elevations, liner materials, etc., for the proposed waste treatment lagoon are to be
incorporated into filial design pending permitting. Therefore, details may be revised
once the site modif cations begin.
Thank you for your consideration, and if you have any questions regarding the technical
or design aspects cl ' the proposed updated facilities, please do not hesitate to contact
me.
Sincerely,
R. Gregory Swain,
President
SWAIN CONSULTING SERVICES, INC.
150 Cabin Creek Lane Clinton, NC 28328
[phone] Fax [phone] email [e-mail]

SITE
GENERAL
ANIMAL WASTE OPERATION
PERMIT APPLICATION PACKAGE
TABLE OF CONTENTS
TRANSFER DOCUMENTATION
'APPLICATION
LAGOON MODIFICATION DESIGN
LAGOON OP, --RATION & MAINTENANCE PLAN
LAGOON CO �,TSTRUCTION & SEEDING SPECIFICATIONS
HAZARD CLASSIFICATION DATA SHEET
WASTE UTILIZATION PLAN & SPECIFICATIONS
INSECT CONTROL CHECKLIST
ODOR CONT�ROL CHECKLIST
MORTALITY IMANAGEMENT METHOD CHECKLIST
ACTION PLAN
ANIMAL WA�TE MANAGEMENT PLAN CERTIFICATION

NAME OF FARIVI: B
OWNER I MANA(
I (we) understand and
maintenance precedu
named above. I (we)
treatment and/or stor�
pl2n and a new certifi(
I (we) understand tha
to land apply the anin
be available at the ap
in a 25-year 1 -day stc
according to this plan
NAME OF FACILITY
SIGNATURE:
NAME OF MAI`
SIGNATURE: -
NAME OF TE(
AFFILIATION:
ADDRESS (A(
mette Farms' 74-94
;ER AGREEMENT
Nill follow and implement the specifications and the operation and
n estalished in the approved animal waste utilization plan for the farm
now that any expansion to the existing design capacity of the waste
3e system or construction of new facilities will require a new utilization
ation to be submitted to DEM before the new animals are stocked.
I must own or have acces to equipment, primarily irrigation equipment,
a[ waste described in this waste utilization plan. This equipment must
)ropriate pumping time such that no discharge occurs from the lagoon
-m event. i also certify that the waste will be applied on the land
at the appropriate times and at rates that no runoff occurs.
OWNER: Timothy Brian Burnette
�Z7 DATIE.
(if different from owner):
please print
DATE:
SPECIALIST: Curtis Barwick
) V,4fr-
/ 0 3 60� 64� L C�,k
Clinton, NC 28328
(910) 592- qdq 0
D a. �-- -7 P—e7i,
ATI
Page 9 of 9

Operator: Brian Burnette
County: Oitt
Date:
05124/06
Has the site evaluation bee
i completed & approved:
y
1. AVERAGE LIVE WEIW
7 (ALW)
0 sows (farrow to
finish)
x
1417 tbs,
0
tbs
0 sows (farrow to
feeder)
x
522 tbs.
0
tbs
0 head (finishing
only)
X,
135 tbs.
0
tbs
0 sows (farrow to
wean)
x
433 lb&
0
tbs
4330 head (wean to
feeder)
x
30 tbs.
129900
tbs
Describe other
0
tbs
Total Average Live Weight
129900
tbs
2. MINIMUM REQUIRED IREATMENT VOLUME OF LAGOON
Volume 129900 cubic ft (includes 0 cu. ft. aft treat. vol.)
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume
32475.0 cubic feet
4. TOTAL DESIGNED VOI
UME
Inside top leng
h (feet)-- 310.0
Inside top widt
i (feet)----- 130.0
Top of dike ale
iatlon. (feet) 47.50
Bottom of lagoon
elevation (feet)--- 34.00
Freeboard (fee
t)--- 1.00
Emergency spi
tway depth of flow(fieet)— 0.00
Side slopes (inside
tagoon)- 3.0 :1
Total design vc
lume using prismaidal fon-nula
SSIEND1 �
S/END2 SS/SIDEI SSISIDE2 LENGTH WIDTH DEPTH
3.0
3.0 3.0 3.0 304:0 1124.0 12.50
AREA OF TOF
LENGTH * W
DTH
304.0
124.0
37696 (AREA OF TOP)
AREA OF BOI
TOM
LENGTH * W
DTH
229.0
49.0
11221 (AREA OF BOTTOM)
AREA OF MID
iECTION
LENGTH - W
DTH - 4
266.5
86.5
92209 (AREA OF MIDSECTION 4)
CU. FT. = [ARI
A TOP + (4*AREA MIDSECTION) + AREA BOTTOhq DEPTH/6
37696
92209 11221 2.08
Total Designed Volume Available 294013 CU. FT.
I

5.TEMPORARYSTORAGE
DRAINAGE AF
Lagoon (top of
Length
310.0
Buildings
Design ternpora
SA, Volume of waste produc
Faces & urine p
Volume =
Volume =
5B. Volume of excess water
Volume =
Volume a
5C. Volume of rainfall in exc
Use period of tir
180 day
180 day
Volume =
Volume =
Volume =
50. Volume of 25 year 24 hc
Volume of "Heavy Rain"
Volume =
Volume =
th ) + Surfare area of connecting waste facility
130.0 0.0
40300,0 squarefeet
I lot water) or impervious area
0.0 square feet Describe this area.
�1- DA 40300.0 square feet
storage period to b4 Nod to b a 180 days.
In galdday per 135 lb. ALW 1.37
tbs, ALM 36 tbs. ALW * 1.37 gaYday 180 days
gals. or 31722.5 cubic feet
870.9 gallons/day 180 days storage/7.48 gallons
per CF
957.2 cubic feet
;S of evaporation
when rainfall exceeds evaporation by largest amount.
evaporation 0.0 inches
rainfall S. I inches
8.1 in * DA 112 in. per ft. 27035 cubic feet runoff
0.0 in *lagoon DA112 in./It= 0 cubic feet evap.
!7035 cubic feet
r storm 6.8 in.
6,8 in.
13.6 inches 112 inches per foot * DA
45673 cubic feet

5.E. Additional volume as
TOTAL
5A-
5B.
5C.
5D.
5E.
6. SUMMARY
Temporary sto
Rainfall during
Evaporation dL
25 year - 24 hc
Heavy rain�—
Side slopes�—
Inside top lengtl
Inside top width
Emergency spill
Top of dike elelu
Bottom of lagoo
Top of sludge a
Total required v
Actual design v4
Seasonal high v
Stop pumping a
Must be > or =
Must be > or =
Mim Required Ill
Volume at stop
Start pumping a
Must be at boll
Act. vol, less 25
Volume at start
Required volum
Actual volume p
Min. thickness c
7. DESIGNED BY:
DATE:
TEMPORARYSTORAGE
31722 cubic feet
20957 cubic feet
27035 cubic feet
45673 cubic feet
0 cubic feet
125386 cubic feet
a
180
days
ittest period of storage===>
8.1
inches
g storage period===========>
0.0
inches
6.8
inches
6.8
Inches
1.00
feet
3,0
: 1
310.0
feet
130.0
feet
ay elevation(if planned)—=>
46.50
feet
47.60
feet
34.00
feet
36.50
feet
287763
cu. ft.
294013
cu. fl.
itertable elevation (SHVVT)===.-
40.40
feet
42.60
feet
) the SHWT
40.40
feet
) min. req. treatment at.=>
40.00
feet
atment volume=�—= ===-- >
129900
cu. I'L
JmPing elevationx==z==="===>
132363
cu. fl.
45.20
feet
m of F.B. & 25 yr. rainfall & heavy rain
r. and heavy rainfall==�->
248339
cu. fL
imping elevation======—==>
247151
Cu. I'L
to be pumped======�—==—=>
79714
cu. ft.
nned to be pumped====�—==>
81335
cu. ft.
soil liner when required==>
1.8
feet
APPROVED BY
DATE:
SEAL
16415

I attest that this application I as becrt revietyed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required Parts Of this application are not completed and Thai it all required SUPPorling infiorrmition and attachments are not
inchadc,cl, this application packa ;e will be returned to me as incomplete,
Note: In accordance with N, � Gcjtml Statutes 143-215.6A =it 143-215-68, any person who knowingly maikes any raise statement,
representation, or corri leaden in RAY application my be subject to civil penalties up to S25,000 per violation. (13 UZZ-
Section 1001 provides k punishment by a tin, of no' more than 510400 Or imprisonment of not more (ban 5 years, or buth for
a similar officase.)
Printed Name of Sipmg (( Ificia( Landownea, or if multiple Landowners all landowners should sip, if Landowner is a
corPOM1011, sillramne should be by a principal executive officer of the corporation):
Nam: --tLy- I �0_ yst,�12_4_� Title;
Sip3MM Date: .05
Name: Tide
Signamme: Date:
Name: Title-
signanaro� Date:
THE C )MPLETTED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS�
NCDEQ.DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number. [phone]
E-mail: 2([e-mail]
FORM: RENEWALSTATECEAEFIALOM019

Information pir
conditions with
over time as ec
to reduce oper
increase in the
wetted diampte
You should be;
alter the appli
uniformity. For
droplets, greats
of nozzles can i
will reduce cps
coverage diaME
For the above
proper applical
recommended.
the application
determine the
graduated scal
additional caICL
opening and c
transferred to a
For stationary sl
application arez
should be locai
collection contal
should compute
windless day, vs
You should cont
,9�-9�A
System Calibration
ad in manufacturer's charts are based on average operation
vely new equipment. Discharge rates and application rates change
)nt gets older and components wear. In particular, pump wear tends
pressure and flow. With continued use, nozzle wear results in an
opening which will increase the discharge rate while decreasing the
Vare that operating the system differently than assumed in the design will
ition rate, diameter of coverage, and subsequently the application
�xample, operating the system with excessive pressure results in smaller
potential for drift, and accelerates wear of the sprinkler nozzle. Clogging
suit in pressure increase. Plugged intakes or crystallization of mainlines
ating pressure. Operating below design pressure greatly reduces the
�r and application uniformity.
ason, you should calibrate your equipment on a regular basis to ensure
ri rates and uniformity. Calibration at least once every three years is
�Alibration involves collecting and measuring flow at several locations in
irea. Any number of containers can be used to collect flow and
)plication rate. Rain gauges work best because they already have a
from which to read the application amount without having to perform
tions. However, pans, plastic buckets, jars, or anything with a uniform
ss-section can be used provided the liquid collected can be easily
,aled container for measuring.
inklers, collection containers should be located randomly throughout the
at several distances from sprinklers. For traveling guns, sprinklers
d along a transect perpendicular to the direction of pull. Set out
Brs 25 feet apart along the transect on both sides of the gun cart. You
ie average application rate for all nonuniformity of the application. On a
ation between containers of more than 30 percent is cause for concern.
,t your irrigation dealer or technical specialist for assistance -
*Reprinted for Catlifitation Training tar Operations of Animal Waste Management Systems Manual

Proper lagoon m;
levels so that you
Maximum stora
dormant (such ;
thunderstorm si
later winter / eE
whenever the [a
the lagoon for fL
to the low mart
maintain the la!
plan will allow it.
OPERATION & MAINTENANCE PLAN
nagement should be a year-round prionty- It is especially important to manage
to not have problems during extended rainy and wet periods.
capacity should be available in the lagoon for periods when the receiving crop is
.vintertime for bermudagrass) or when there are extended rainy spells such as a
on in the summertime. This means that at the first sign of plant growth in the
spring, irrigation according to a farm waste management plan should be done
in dry enough to receive lagoon liquid. This will make storage space available in
ewetperiods. In the late summer/ early fall the lagoon should be pumped down
(see Figure 2-1) to allow for winter storage, Every effort should be made to
in close to the minimum liquid level as long as the weather and waste utilization
Waiting until the l4goon has reached its maximum storage capacity before starting to irrigated does
not leave room foi stoning excess water during extended wet periods. Overflow from the lagoon for
any reason excepi a 25-year, 24-hour storm is a violation of state law and subject to penalty action.
The routine
NOTE: If ve
water. Such
Maintenance ii
and at least m(
as a minimum,
1 .
2.
3.
4.
of a lagoon involves the following:
enance of a vegetative cover for the darn. Fescue or common bermudagrass
ie most common vegetative covers. The vegetation should be fertilized each
if needed, to maintain a vigorous stand. The amount of fertilized applied
d be based on a soils test, but in the event that it is not practical to obtain a
test each year, the lagoon embankment and surrounding areas should be
.ad with 800 pounds peracre of 10-10-10, orequivalent.
and trees on the embankment must be controlled. This may be done by
9, spraying, grazing, chopping, or a combination of these practices. This
be done at least once a year and possibly twice in years that weather
)ns are favorable for heavy vegetative growth.
is controlled by spraying, the herbicide must not be allowed to enter the lagoon
als could harm the bacteria in the lagoon that are treating the waste,
ions of the entire lagoon should be made during the initial filling of the lagoon
and after major rainfall and storm events. Items to be checked should include,
11-1:...
ste Inlet Pipes, Recycling Pipes, and Overflow Pipes -- look for:
separation of joints
cracks or breaks
accumulation of salts or minerals
overall condition of pipes

loon surface -- look for:
undesirable vegetative growth
floating or lodged debris
bankment — took for:
settlement, cracking, or "jug" holes
side slope stability -- slumps or bulges
wet or damp areas on the back slope
erosion due to lack or vegetation or as a result of wave action
rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon dam.
A good stand oi vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the lagoon may be
used to reduce Me wave impacts.
Any of these features could lead to erosion and weakening of the dam. If your lagoon
has any of these features, you should call an appropriate expert familiar with design and
construction of 'vaste lagoons. You may need to provide a temporary fix if there is a
threat of a waste discharge. However. a permanent solution should be reviewed by the
technical expert Any digging into a lagoon dam with heavy equipment is a serious
undertaking will- potentially serious consequences and should riot be conducted unless
recommended b I an appropriate technical expert.
T ansfer Pumps -- check for proper operation of:
1 - recycling pumps
2.1 irrigation pumps
Check for leaks loose fittings, and overall pump operation. An unusually loud or grinding
noise, or a larg amount of vibration, may indicate that the pump is in need of repair or
replacement.
NOTE: Pumping systems should be inspected and operated frequently enough so that
you are not completely "surprised" by equipment failure. You should perform your
pumping system maintenance at a time when your lagoon is at its low level. This will
allow some safely time should major repairs be required. Having a nearly full lagoon is
not the time to think about switching, repairing, or borrowing pumps. Probably, if your
lagoon is full, ycur neighbor's lagoon is full also. You should consider maintaining an
inventory of spare parts or pumps.
Surace water diversion features are designed to carry at/ surface drainage
waters (such as rainfall runoff, roof drainage, gutter outlets, and parking lot
runoff) away from your lagoon and other waste treatment or storage
stru-tures. The only water that should be coming from your lagoon is that
which comes from your flushing (washing) system pipes and the rainfall that
hits the lagoon directly. You should inspect your diversion system for the
following:
1. adequate vegetation
2. diversion capacity
3. ridge berm height

Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an overfloN problem from a surface water diversion or there may be seepage into
the lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immedia ely after construction establish a complete sod cover on bare soil
surfaceslio avoid erosion.
2. Fill new agoon design treatment volume at least half full of water before waste
loading t agins, taking care not to erode lining or bank slopes.
3 Drainpipes into the lagoon should have a flexible pipe extender on the end of the
pipe to ( ischarge near the bottom of the lagoon during initial filling or another
means ol slowing the incoming water to avoid erosion of the lining.
4. When pc ssible, begin loading new lagoons in the spring to maximize bacterial
establishi nent (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working :;wine lagoon in the amount of 0.25 percent of the full lagoon liquid
volu . me. I This seeding should occur at least two weeks prior to the addition of
6. Maintain � periodic check on the lagoon liquid pH. If the pH falls below 7.0, add
agriculturol lime at the rate of 1 pound per 1000 cubic feet of lagoon liquid volume
until the qH rises above 7.0. Optimum lagoon liquid pH is between 7.5 and 8.0.
7. A dark
activity.
Loading:
The more frequf
lagoon will funct
are optimum for
drained and rech
lor, lack of bubbling, and excessive odor signals inadequate biological
Consultation with a technical specialist is recommended if these
occur for prolonged periods, especially during the warm season,
ntly and regularly that wastewater is added to a lagoon, the better the
:)n. Flush systems that wash waste into the lagoon several times daily
treatment. Pit recharge systems, in which one or more buildings are
3rged each day, also work well.

Practice
leaking i
Minimize f
amount of
Management:
• Maintain la�
temporary si
• Place visible
and the max
• Start irricati
summer
provide i
Thelagoon
damoreml:
• Don not pur
you are rem
• Locate float
as far away
• Prevent add
feed, plastic
• Frequently
wherever thE
• Maintain stri(
• Do not allow
Remove slu
before it fills
a If animal
Sludge
Rate of lagoon
conservation --- minimize building water usage and spillage from
�, broken pipes and washdown through proper maintenance and water
wastage and spillage by keeping feeders adjusted. This will reduce the
Js entering the lagoon.
liquid level between the permanent storage level and the full
level.
markers or stakes on the lagoon bank to show the minimum liquid level
-nurn liquid level. (Figure 2-1).
9 at the earliest possible date in the spring based on nutrient
and soil moisture so that temporary storage will be maximized for the
Jerstorm season. Similarly, irrigate in the late summer / early fall to
turn lagoon storage for the winter.
le . vel should never be closer than I foot to the lowest point of the
) the lagoon liquid level lower than the permanent storage level unless
,ing sludge.
imp intakes approximately 18 inches underneath the liquid surface and
)m the drainpipe inlets as possible.
ons of bedding materials, long-stemmed forage or vegetation, molded
(ringes, or other foreign materials into the lagoon.
move solids from catch basins at end of confinement houses or
are installed.
vegetation, rodent, and varmint control near lagoon edges.
ees or large bushes to grow on lagoon dam or embankment.
e from the lagoon either when the sludge storage capacity is full or
) percent of the permanent storage volume.
uction is to be terminated, the owner is responsible for obtaining and
� closure plan to eliminate the possibility of a pollutant discharge.
buildup can be reduced by:
5

prop lagoon sizing,
mechanical solids separation of flushed waste,
gravit i settling of flushed waste solids in an appropriately designed basin, or
miniry izing feed wastage and spillage.
Lagoon sludge t[iat is removed annually rather than stored long term will:
• have ore nutrients,
• have ore odor, and
• requir more land to properly use the nutrients.
Removal
0 Hire alcustom applicator
• Mix th � sludge and lagoon liquid with a chopper - agitator impeller pump through large -
bore s )rinkler irrigation system onto nearby cropland; and soil incorporate,
• Dewal Br the upper part of lagoon by irrigatIon onto nearby cropland or forageland; mix
remair ing sludge, pump into liquid sludge applicator; haul and spread onto cropland or
forage and; and soil incorporate.
• Dewat �r the upper part of lagoon by irrigation onto nearby cropland or forageland;
dredg isludtge from lagoon with dragline or sludge barge,- berm an area beside lagoon
to rec ve he sludge so that liquids can drain back into lagoon; allow sludge to
dewat r; haul and spread with manure spreader onto cropland or forageland; and soil
Regardless Of I metlod�ulyou must have the sludge material analyzed for waste
just�e
constituents Is you w Id your lagoon water. The sludge will contain different
nutrient and metlal values from the liquid. The application of the sludge to fields will be
limited by these �utrients as well as any Previous waste applications to that field and crop
requirement. Wqste application rates will be discussed in detail in Chapter 3,
When removing
Close attention
remains intact.
should stop the 4
be removed wift
possible.
Sludge removed
than liquid. Bec�
metal levels, as i
Note that if the E
applied only at I
always have you
5ludge, you must also pay attention to the liner to prevent damage.
y the pumper or drag -line operator will ensure that the lagoon liner
You see soil material or the synthetic liner material being disturbed, you
�tivity immediately and not resume until you are sure that the sludge can
,ut liner injury. If the liner is damaged it must be repaired as soon as
Irorn the lagoon has a much higher phosphorus and heavy metal content
use of this it should probably be applied to land with low phosphorus and
idicated by a soil test, and incorporated to reduce the chance of erosion.
udge is applied to fields with very high soil -test phosphors, it should be
Ites equal to the crop removal of phosphorus. As with other wastes,
lagoon sludge analyzed for its nutrient value.

The application
Extra precautiot
could increase t
)f sludge will increase the amount of odor at the waste application site.
should be used to observe the wind direction and other conditions which
e concern of neighbors.
Possible Caus m of Lagoon Failure
Lagoon failures result in the unplanned discharge of wastewater from the Structure.
Types of failure� include leakage through the bottom or sides, overtopping, and breach of
the dam. Assur iing proper design and construction, the owner has the responsibility for
ensuring structu a safety. Items which may lead to lagoon failures include:
• Modlfi -.ation of the lagoon structure -- an example is the placement of a pipe in the dam
withOL t proper design and construction. (Consult an expert in lagoon design before
placin) any pipes in dams.)
• Lagoon liquid levels — high levels are a safety risk.
• Failure to inspect and maintain the dam.
• Exces s surface water flowing into the lagoon.
• Liner ntegrity — protect from inlet pipe scouring, damage during sludge removal, or
ruptur � from lowering lagoon liquid level below groundwater table.
NOTE: If lagoop water is allowed to overtop the dam, the moving water will soon cause
gullies to form n the dam. Once this damage starts. it can quickly cause a large
discharge of wastewater and possible dam failure.
7

DIVISION OF
EMERGENCY
SOIL AND WA
NATURAL RE<
COOPERATIV
EMERGENCY ACTION PLAN
PHONE NUMBERS
,TER QUALITY (DWQ) L'- L�,- v� I
kNAGEMENT SERVICES (EMS) QL�j �-qg
R CONSERVATION DISTRICT (SWCD) k-lt-iico
URCES CONSERVATION SERVICE (NRCS) J--Itt-,J�j
:XTENSION SERVICE (CES) t--Ioq
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or rL Inning off site. You should not wait until wastes reach surface waters or
leave your Property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location
for all employees at the facility. The following are some action items you should take.
1 . Stop the releasif of wastes. Depending on the situation, this may or may not be possible. suggested
responses to solme possible problems are listed below,
A. Lagoon ovq"ow - possible solutions are:
a) Ac d soil to arm to increase elevation of dam.
b) PL mp wastes to fields at an acceptable rate.
0) St )p all flow to the lagoon immediately.
d) C� 11 a pumping contractor.
e) W ke sure no surface water is entering lagoon.
B. Runoff frorr waste application field -actions include:
a) Im iiediately stop waste application.
b) Cr We a temporary diversion to contain waste.
C) Incorporate waste to reduce runoff.
d) Evaluate and eliminate the reason(s) that cause the runoff.
a) Evaluate the application rates for the fields where runoff occurred.
C. Leakage fr* the waste pipes and sprinklers - action include:
a) St p ' ct
b) StIp ln-i;.t1!nup`u.Pp.
C) Cl4se valves to eliminate further discharge,
d) Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators - action include:
8) Stc p recycle pump.
b) Stc p irrigation pump.
C) Make sure siphon occurs.
d) Sic p all flow in the house, Rush systems, or solid separators.
E. Leakage fro Ti base or sidewall of lagoon. Often this is seepage as opposed to flowing leaks -
possible act on;
a) Dig a small sump or ditch from the embankment to catch all seepage. put in a submersible
pui rip, and pump back to lagoon.
b) If h Dies are caused by burrowing animals, trap or remove animals and fill holes and
cor ipact with a clay type soil.
C) Ha, fe a professional evaluate the condition of the side walls and the lagoon bottom as soon
as )ossible.

- - - - - .. I- - .— - - .. . - -'- - - . - - .' - . .�'. �� .... V'�.
a. Did i
b. Appi
c. Any
d. Did I
a. Doe
f. Coul
g. Are I
h. How
3. Contact appropri
a.
During r
emerger
number,
location
wind cc
seriousn
b.
If the sp
c.
Instruct
d.
Contact
office fc
4.
5.
� waste reach surface waters?
dmately how much was released and for what duration?
image notes, such as employee injury, fish kills, or property damage?
? spill leave the property?
he spill have the potential to reach surface waters?
a future rain event cause the spill to reach surface waters?
table water wells in danger (either on or off the property)?
iuch reached surface waters?
agencies.
mal business hours call your DWQ regional office Phone #, After hours,
number: [phone]. Your phone call should in�lude: your name, facility
ilephone number, the details of the incident from item 2 above, the exact
the facility. the location or direction of the movement of the spill, weather and
itions. The corrective measures that have been under taken, and the
s of the situation.
leaves property or enters surface waters, call local EMS phone number.
AS to contact local Health Department.
E's phone number, local SWCD office phone number and the local NIRCS
ldvice I technical assistance phone number.
If none of the abo� e works call 911 or the Sheriffs Department and explain your problem to
them and ask the )erson to contact the proper agencies for you.
Contact the contrE ctor of your choice to begin repair or problem to minimize offsite damage.
a. Contractoi s Name: Murphy Brown. LLC
b. Contractoi s Address: P.O. Box 856. Warsaw, NC 28398
c . Contractor � Phone: [phone]
Contact the techni al specialist who certified the lagoon (NRCS, Consulting Engineer, etc.)
a. Name: Krai esterbeek
b. Phone: (9101 93 - 5330
7. Implemenj procedures as advised by DWQ and technical assistance agencies to rectify the
damage, rppair the system, and reassess the waste management plan to keep problems
with releale of wastes from happening again.

CONTROL CHECKLIST FOR ANIMAL OPERATIONS
uruse 8MP's to Minimize Odor Site Specific Practices
Flush Gutters A 2umulat!Gn of solids Flush system is designed and Operated
sufficiently to remove accumulated
solids from gutters as designed.
Remove bridging of accumulated solids at
discharge
L72goons —and Pits C Uslea tiollas Maintain lagoons, settling basins and
Pits where post breeding is apparent to
minimize the crusting of solids to a depth
of no mom than 6-8 inches over more than
30% Of SUFF809,
Excessive DIcaying vegetation (�)Maintain vegetative control along banks —of
Vegetative Gruvvth lagoons and other impoundment's to prevent
accumulation of decaying vegetative matter
along waters edge on impoundment's perimeter.
Design. operate and maintain feed systems (e.g..
bunkers and troughs) to minimize the accumulation
of decaying wastage.
Clean UP spillage on a routine basis (e.g. 7-10 day
interval during summer, 15-30 day interval during winter).
--potivir �, P�u t Keauce moisture accumulation within and around
re� idues immediate perimeter of feed storage areas by
insuring drainage away from site and/or providing
adequate containment (e.g., covered bin for
brewers grain and Similar high moisture grain
products).
Inspect for and remove or break up accumulated
solids in filter ships around feed storage as needed.
Animal Holding Ac;umulation of animal Eliminate low area that trap moisture along fences
Areas we ;tes and feed wastage and other locations where waste accumulates and
disturbance by animals is minimal.
Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e. inspect for and remove or break up accumulated
solids as needed).
MIC — November 11, 1
U,

Dry Manure Handling
Systems
Accumulations or animal Remove Spillage on a routine basis (e.g. 7-10 day
W2SteS interval during summer; 15-30 days interval during
winter) where manure is loaded for land application
or disposal,
0 Provide for adequate drainage around manure stockpiles
InSPeCt for and remove or break up accumulated wastes
in filter strips around Stockpiles and manure handling
areas as needed.
The issues he
C"
ked pertain to this operation, The landowner / integrator agrees to use
sound judgMen
n applying insect control measures as practical.
I certify the a to rj
mentioned insect control Best Management Practices have been
reviewed with m
C -1,
(Landowner Signature)
For more information contact the Cooperative Extension Service, Department of Entomology, Box
7613, North Carolija State University, Raleigh, NC 27695-7613.
AMIC — Novembel-11 1, 1996

SWINE
FARM WASTE MANAGEMENT ODOR CONTROL CHECKLIST
ii.—.,-c
iuse
BMP's to Minimize Odor Site Specific Practices
F.--Ste.dS,
ana production
V)Vegetafive or wooded bu ers:
V01ecommended best management
practices;
—body
(V)Good judgment and common sense
�Iimal
U,
ty manure
()DFY floors
surfaces
a
lened animals
W
�_tm1_1u­,,_,overed­_
(,')Slotted �floor,,
f1c
3rs
V)Waterera located over slotted floors;
(v)Feeders at high end of solid floors;
(,�)Scrape manure buildup from floors;
)Underfloof ventilation for drying
Wanure C0110crIOn
Ur
ne
(,v)Frequent manure removal �byflush, poll
pits
recharge or scrape
Partial
microbial
)Underfloor ventilation
de
�omposition
Ventilation
Vcl
i gases
(v)Fan maintenance;
exhaustfans
_rface
Ou
at
(,')Efficient air movement
Fn d o o r a u a
DuSE
(v)Washdown between groups of animals
)Feed additives;
)Feeder covers;
)Feed delivery downspout extenders to
feeder covers
Flush Tanks
Ag
ation of recycled
( )Flush tank covers
lag
3on liquid while tanks
( )Extend fill lines to near bottom of tanks
are
filling
with anti -siphon vents
Flush -[lays
Ag
trivon aunng waste
( )Underfloor flush with underfloor
—tech-rg-Ag
we
er conveyance ventilation
V,t
ration Or recycled
()Extend recharge lines to near bottom of
points
lag
mn liquid while pits
pits with anti -siphon vents
�statiOnsAgi
are
filling
Ulf
lation during sump
)Sump tank covers
—dratnAg,
tan(
filling and drawdown
Outside
collection or
water
conveyance
junction boxes
—drainAgnation
Tnd of
during waste
)Extend discharge point of pipes
pipes at lagoon
watsr
underneath lagoon liquid level
Lagoon surfaces
Vol
Iffle, gas emissrons
(V)Pmper lagoon liquid capacity
Blo
ogloal mixing
(v)Correct lagoon startup procedu res
Agi
ation
( )Minimum surface area -to -volume ratio
(�)Mirlmum agitation when pumping
)Mechanical aeration
)Proven biological additives
lrr'9'1'0' sprinkler
K19
I Pressure agitation
(V)Inigate on dry days with little or no wind
nozzles
Wir
d draft
V)Mimmum recommended operation pressure
(v')Pump intake near lagoon liquid surface
)Pump from second -stage lagoon
AMUU—NOVeMberil
iQQA
12

'�twage tank of P irtial microbial ( )Bottom or midlevel loading
basin surface cl, composition Mixing while ( lTank covers
fit ng Agitation when emptying( )Basin surface mats of solids
Wroven hiologicail additives or oxidants
Settling basin P; rtial microbial demm- ( )Extend drainpipe outlets underneath liquid
surface pc sition, Mixing while filling level
A, itartion when emptying ( )Remove settled solids regularly
Manure, slurry or N i ion when spreading ( )Soil injection of slurry/sludges
sludge spreader V atile gas emissions ( )Wash residual manure from spreader after use
ou tlets ( )Proven biological additives or oxidants
Dead —,nm,[. C� rcass cf,�wplffi.n �()Pmper ­dsplIfton of
Dead animal CE rcass deCOM DOsition ( )Complete covering of carcasses in burial pits
disposal pits ( )Proper location / construction of disposal pits
Tnc,.—e,,to,.In, omplete �wmb.slon( )�S.,o.dwy t,,k �bume,,
Standing —watr im nance
around facilities Microbial decomposition of away from facilities
orf anic, matter
Manum tracked Pq)rlY maintained access
onto public roads roz ds
from farm access
Tdditional In —formation Available From
Swine Manure Manage nent 0200 Rule / BMP Packet NCSU-County Extension Center
Swine Production Faur Potential Odor Sources and Remedies, EBAE Fact Sheet NCSU-BAE
Swine Production Facil ty Manure Managament:Pit Recharge —Lagoon TreatmenLEBAE128-88NCSU.BAE
Swine Production Facil ir Manure Management:Underfloor Fluse-Lagoon Treatment 12M8NCSU-BAE
Lagoon Design and Me iagement for Livestock Manure Treatment and Storage; EBAE103-83NCSU-BAE
Calibration of Manure E id Wastewater Application Equipment EBAE Fact Sheet NCSU-BAE
Controlling Odors from 3wine Buildings; PIH-33 NCSU-Swine Extension
Environmental Assurar :a Program: NPPC Manual NC Pork Producers
Assoc
Options for Managing C dor; a report from the Swine Odor Task Force NCSU Agri Communication
Nuisance Concerns injamal Manure Management: Odors and Flies; PRO101, Florida Cooperative Extension
1995 Conference Pr edings
s'
The issues d pertain to this operation. The landowner / integrator agrees to
use sound in applying odor Control measures as practical.
I certify the afore rientioned odor control Best Management Practices have been reviewed
with me.
(Landowner Signature)
13

V.,ston—Nave.be, 26,2018
Mortality Management Methods
Indicate which methodis) will be implemented.
selecting multiple methods indicate a primary versus secondary option.
)ds otherthan those listed must bo approved by the State Veterinarian.
Primary Secondary I Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should beat least one foot above the seasonal
high water table. Attach burial location map and plan,
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rencleiring at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 520.0102.
composting system approved and permitted by the NC Department of Agriculture & Con -
turner Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
dditional requirements must be met and a permit is required from NC DEQ.
ri the case of dead poultry only, placing In a disposal pit of a size and design approved by the
qC Department of Agriculture & Con -Sumer Services (G.S. 106-549.70).
\ny method which, in the professional opinion of the State Veterinarian, would moke possible
he salvage of part of a dead animal's value without endangering human or animal health,
Written approval by the State Veterinarian must be attached).
dass Mortality plan
4ass mortality plans are required for farms covered by an NPDES permit These plans are
ilso recommended for all animal operations. This plan outlines farm -specific mortality man-
Igement methods to be used for mass mortality. The NCDA&C$ Veterinary Division sup-
mrts a variety of emergency mortality disposal options; contact the Division for guidance.
A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
Builal must be done In accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
In the event of Imminent threat of a disease emergenc . the State Veterinarian may enact
additional temporary procedures or measures for dis . y
posel according to G.S. 106-399.4.
L
Signature of Farm Owner/Manager Date
Signature ofTechnlcal Specialls� Date

un
so
eb
SON -
'Opun n 0
kiaPQW��4. Inc (�l 20-06 Telc Atla5