710073_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore,. all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 71-0073 Certificate Of Coverage Number: AWS710073
2. Facility Name: Hairr II
3. Landowner's Name (same as on the Waste Management Plan): Wesley C Hairr
4. Landowner's Mailing Address: 1188 Veach's Mill Rd
City: Warsaw State: NC Zip: 28398
Telephone Number: 910-293-3036 Ext. E-mail:
5. Facility's Physical Address: 1397 Fox Pen Rd
City: Ivanhoe State: NC Zip: 28447
6. County where Facility is located: Pender
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"): Murphy -Brown LLC
10. Operator Name (OIC): Wesle\ C. Hairr Phone No.: 910-293-3036 OIC #: 19957
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit:
Operation Types:
Operations Type Allowable Count
Swine - Wean to Feeder 500
Swine - Feeder to Finish 1,000
Swine - Farrow to Wean 3,600
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Daily Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

ROY COOPER
Gamma-
MICHAEL S. REGAN
Secretary
LINDA CULPEPPER
Director
Wesley C Hairr
llenrr 11
1 188 Veach's Mill Rd
Warsaw, NC 28398
NORTH CAROLIt A
Environmental Quality
February 27, 2019
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https://degnc.eov/about/divisions/water-resources/water-duality-regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non-Dischaue General Permits. v ou must submit an application for
permit coverage to the Division. Enclosed you will find a "Request for Certificate of Coverage Facility Currentl4 Covered by an
Expiring State Non -Discharge General Permit." The application form must be completed, signed and returned bs April 3, 2019.
Please note that sou must include one 11) coot of the Certified Animal Waste Manasement Plan (CAWMP1 with the
completed and signed application form. A list of items included in the CAWMP can be found on pace 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Wilmington Regional Office, Water Quality Regional Operations Section
Pender County Soil and Water Conservation District
AFOG Section Central Files - AWS710073
Murphy -Brown LLC
CAE1
�.1.
NNttt^ Cam -a Departrert. f Erv'r;rr erta t.a t;° 1 D"va z.' f Water Res4a.roes
vie tt_ Sa at“.. I) St. 1 i:'sl: f.'s. Srei, x 2erte 1 Rs a gF N rt"r Caro • a 27899.1S3S
919.7D7 9:D

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
t l s +
Name: 1 y !'"i Qt (! C,1%5_ 4&* (PrTitle: O u ►i e ►�
Signature: ' Ld j T1r1.4J! Date: 3 r 1'S
Name: Title:
Signature: Date:
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
1
19.50
1
261,360.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), signed b. the owner and a certified technical specialist, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

WASTE UTILIZATION PLAN
PRODUCER: Wesley Hairr - Hairr II
LOCATION: 1610 Fox Pen rd.
Ivanhoe, NC
TELEPHONE: [phone]
TYPE OPERATION: Farrow - Wean
NUMBER OF ANIMALS: 3600 sows
(Design Capacity) 1000 finishing
500 nursery
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1

WASTE UTILIZATION PLAN
Amount of Waste Produced Per Year i gallons, ft, tons. etc.
5,100 animals X 4_8 (tons) waste/animal/year = 24,020 (tons) waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
5,100 animals X 4.4
Guide Std. 633)
lbs. PAN/animal/year = 21,980 lbs. PAN/year. (PAN from N.C.
Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Tract
Field*
No.
Soil
Type
Table 1: ACRES OWNED BY PRODUCER
Crop Lbs. N Acres Lbs. N
Per Acre Utilized
Month of
Application
Hairr 2
1A
GoA
Corn
133
20.12
2676
Feb 15 - June
Hairr 2
1A
GoA
Wheat
68
20.12
1368
Sept - April
Hairr 2
1B
GoA
Corn
133
37.03
4925
Feb 15 - June
Hairr 2
1 B
GoA
Wheat
68
37.03
2518
Sept - April
Hairr 2
2
GoA
Corn
133
32.44
4315
Feb 15 - June
Hairr 2
2
GoA
Wheat
68
33.44
2274
Sept - April
Hairr 2
3
GoA
Crabgrass H/G
203
25.63
5203
March - Sept.
Hairr 2 _
4
GoA
Bermuda H/G
284
2.82
801
March - Sept.
Hairr 2
5
AuB
Bermuda H/G
244
18.07
4409
March - Sept.
Hairr 2
Sub 1 a-1 b
GoA
Corn
133
17.25
2294
Feb 15 - June
Hairr 2
Sub 2
GoA
Corn
133
6.56
872
Feb 15 - June
Hairr 2
Sub 3
GoA
Crabgrass H/G
203
7.77
1577
March - Sept.
Hairr 2
Sub 4
GoA
Bermuda H/G
284
2.88
818
March - Sept.
Hairr 2
Sub 5
AuB
Bermuda H/G
244
13.53
3301
March - Sept.
Hairr 2
Sub 1a-1 b
GoA
Wheat
68
17.25
1173
Sept - April
Hairr 2
Sub 2
GoA
Wheat
68
6.56
446
Sept - April
Hairr 2
3-5
GoA,AuB
Small Grain
50
70.70
3535
Sept - April
Total 1 184.101 42,505.80
*This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
NUP Page 2 YEAR 1

WASTE UTILIZATION PLAN
Amount of Waste Produced Per Year (gallons. ft. tons. etc.
5,100 animals X 4.8 (tons) waste/animal/year = 24,020 (tons) waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
5,100 animals X 4_4
Guide Std. 633)
lbs. PAN/animal/year = 21,980 lbs. PAN/year. (PAN from N.C.
Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Tract
Field*
No.
Soil
Type
Table 1: ACRES OWNED BY PRODUCER
Crop Lbs. N Acres Lbs. N
Per Acre Utilized
Month of
Application
Hairr 2
1A
GoA
Soybeans
149
20.12
2998
Apr - Sep 15
Hairr 2
1A
GoA
Wheat
68
20.12
1368
Sept - April
Hairr 2
1 B
GoA
Soybeans
149
37.03
5517
Apr - Sep 15
Hairr 2
1 B
GoA
Wheat
68
37.03
2518
Sept - April
Hairr 2
2
GoA
Soybeans
149
32.44
4834
Apr - Sep 15
Hairr 2
2
GoA
Wheat
68
33.44
2274
Sept - April
Hairr 2
3
GoA
Crabgrass H/G
203
25.63
5203
March - Sept.
Hairr 2
4
GoA
Bermuda H/G
284
2.82
801
March - Sept.
Hairr 2
5
AuB
Bermuda H/G
244
18.07
4409
March - Sept.
Hairr2
Sub 1a-1b
GoA
Soybeans
149
17.25
2570
Apr -Aep 15
Hairr 2
Sub 2
GoA
Soybeans
149
6.56
977
Apr - Aep 15
Hairr 2
Sub 3
GoA
Crabgrass H/G
203
7.77
1577
March - Sept.
Hairr 2
Sub 4
GoA
Bermuda H/G
284
2.88
818
March - Sept.
Hairr 2
Sub 5
AuB
Bermuda H/G
244
13.53
3301
March - Sept.
Hairr 2
Sub 1a-1 b
GoA
Wheat
68
17.25
1173
Sept - April
Hairr 2
Sub 2
GoA
Wheat _
68
6.56
446
Sept - April
Hairr 2
3-5
GoA,AuB
Small Grain
50
70.70
3535
Sept - April
Total 184.10 44,320.20
*This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
NUP Page 2 YEAR 2

WASTE UTILIZATION PLAN
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own adequate land [see
Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre* Utilized Application
* See footnote for Table 1
Total
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 Year 1
Table 1 Year 2
Table 2
Total Year 1
Total Year 2
Amount of N Produced
Surplus or Deficit Y1
Surplus or Deficit Y2
184.10
42,506
184.10
44,320
0.00
184.10
42,506
184.10
44,320
21,980
(20,526)
(22,340)
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

WASTE UTILIZATION PLAN_..
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Crop
Field
No.
Soil Type
Application
Rate (In/Hr)
Application
Amount (In.
1,2
GoA
Row Crops
0.5
1
3
GoA
Crabgrass
0.5
1
4
GoA
Bermuda
0.5
1
5
AuB
Bermuda
0.6
1
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE WILL
BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for _ 180 days of temporary storage and the temporary storage must
be removed on the average o once every 6 MONTHS. In no instance should the volume of
waste being stored in your structure exceed Eletion *see lagoon design.
. CaII the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation:
The corn N has been reduced by 15 Ibs for the residual of the soybeans.
The wheat N was divided in half since it is in two crop years.
On the crabgrass the N rates and tons per acre were determined by using the abstracts attached.
to WUP. The crabgrass is being treated as common since it is not going to be planted.
Page 4
•

1
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has
an agreement for use of adequate land on which to properly apply the waste. If the
producer does not own adequate land to properly dispose of waste, he/she shall provide
a copy of an agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application. It is the responsibility of the owner of
the facility to secure an update of the Waste Utilization Plan when there is a change in
the operation, increase in the number of animals, method of utilization, or available land.
3
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of application for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but Tess than 10 tons per acre
per year providing grass filter strips are installed where runoff leaves the field. (See
FOTG Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservation tilled crops
or grassland, the waste may be broadcast provided the application does not occur during
a season prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7
8
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
Page 5

WASTE UTILIZATION PLAN
9
10
11
12
13
14
REQUIRED SPECIFICATIONS
(continued)
Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to
a minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property
boundary and from any perennial stream or river (other than an irrigation ditch or canal.
Animal waste other than swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters. (See Standard 393 - Filter
Strips).
Animal waste shall not be applied closer than 100 feet to wells.
Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that courses no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

Page 6

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18
If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
Animal waste can be used in a rotation that includes vegetables and other crops for direct
20 human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
Highly visible markers shall be installed to mark the top and bottom elevations of the
21 temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
22 element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Hairr II
Owner / Manager Agreement
I? (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event Tess
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm
office and at the office of the local. Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner:
(Please print)
Signature:
Wesley Hairr
Name of Manager (If different from owner):
Date:
- I /
Signature: _ Date:
Name of Technical Specialist: (Please print)
AJ Linton
Affiliation: Murphy Family Ventures LLC
Address (Agency): PO Box 1139
Signature: / 4"
Wallace, NC 28466
Page 8
Date: 7 —o7� ��

WASTE UTILIZATION PLAN
ANIMAL WASTE UTILIZATION AGREEMENT
(Needed only if additional land has to be leased, etc.)
, hereby give
permission to apply animal waste from his Waste Utilization System on acres
of my land for the duration of time shown below.
I understand that this waste contains nitrogen, phosphorous, potassium, and other
trace elements and when properly applied should not harm my land or crops. I also
understand that the use of waste will reduce my needed for commercial fertilizer.
Adjacent Landowner: Date:
Waste Producer: Date:
Technical Representative: Date:
SWCD Representative: Date:
Term of Agreement: , 20 to , 20
(Minimum of Ten Years on Cost Shared Items)
(See Required Specification No. 2)
Page 9

1 inch equals 500 feet

• 1
4.‹ • .•
)
•
""kr. ••• "1 •
• g
• 1-1
livr.'"A.,1k4"0•11
-r • 1%,;!,1.'.1F,p,
4 -?'" • •• f
; 4• Ci• IL:4 di>
,f .t.—:•• • e 1
!ri
r. • d <1.41. 41/ •h• .r
4,1 'I. tgl".•Si ,r"1; P t
t' • te ' • • - r,. r — •
,,,,f 4 tra,c11 ./ .1+5;1•.% i4 1.10
or, 4o.
4.0*. IA •
111111Priellogrrra-r7x1rm•ov.,..voroor,r-,-x-.—
01.), • .• , .
%". 4. •
•,V1
•Le
• t•tt,i •
r .. - o I • ""-;',"1. . ,..• .,... 2,-,•'d -a , ••-.13,3;44.‘
• • ' fi ' V 19J110'; : :' j -
;11 . • .....'. ,tItst.>„#,:te_itz:.,,-.•,_•
., e 0Lvf—w'd%0 0 p-•::t; 'X•10 '`,,t •
.• k . •''„ „t "40! •-.,..41,,,, , :1.•14‘,.•.;.!,6',04,,_ '' f'ho )14 iit yb,..1. ..1,.
„;VN,11.,"•-
•' k • - ". •04.1.r.••
....7,.• •
,•'' 6—

AuG
n
•
fn•`•
;• `; Y
i Go
Fi2
c:,_
if
cn
NoAr.
M00202060076.
•
•
•

1 inch equals 100,000000 feet

Ha
Animm Feet
0 75 150 300 450 600

0
R
g { t 1 (.,1\
11
Sce
''T1-a.,Je14e
` I. i G 1S y .' .0 `c A107
—! "4.,•a.x :;; Soo
L

H/1ER 11 Fpit\
e
1-11 .talfirs i te`1 (co.% P1C4G.S
-1 5,13S I A OW
A
k.)2-)3i5 Lk
1 03,01 :Iv) .75 N
oc) I D90 dA
10
1000
85o,
,s4 /VA
15,59
•15(5 -aaso` .!5.(00
553' a‘ol
\\IV
S-----141 1,..VST--------_—•
0 r5
,3 1
Is Isol a3cD/
ot V6.501 3c5i ,G9 .56
IS i '6501 f
l `61-t01 ,(29
\"1 SIDI . 2-141 .15 .GQ
1'8 C)b, I 4A L1 1 5‘
0' 15o/
1000 q60 ,-15 HvA (.1
,-75 •
AtA
75 AirA
:cc LsS G.97
,S5
a•SD. H
•x.L, 00' Z60( 5 I1
• 1
qS6 • Llol 7-C .3 1 .35.-r-) 1 _1
2s IL-tol
320
-a31 (005/
47e:
•" .55
To -TA L_t.
4- 30,7' ID:
M00202060077

Sheet?
Maximum. Mainline Friction Loss
Most distant, hydrant:
Total distance: feet
Friction Loss is figured using Hazen/William's Equation
Friction Loss= #DIV/0! fe.et/100 feet
Max. Mainline Loss = #DIV/0.!. feet or #DIV/01 psi
Total Dynamic Head
Sprinkler Pressure: 60 psi
Loss through traveller: psi
Elevation head:. psi
Mainline loss: #DIV/0! psi
Suction head and lift: psi
5% fitting loss: #DIV/0! psi
TOTAL(TDH) = #DIV/0! psi or #DIV/0! feet
Horsepower Required
Horsepower = Flowrate x TDH(feet) / 3960 / Pump effeciency
Pump Description:
Pump Efficiency.
Horsepower Required: #DIV/0! Hp
Thrust Blocking
Thrust Block Area = Thrust / Soil Bearing Strength
Thrust:
Soil Bearing Strength:
feet
feet
End Cap: #DIV/0! ft2
90 degree elbow: #DIV/01. ft2
Tee: #DIV/0! ft2
45 degree elbow: #DIV/0! ft2
Pipe Pressure Rating i Check:
Pressure Rating of Pipe to. be Used: psi
Max. Pressure orrsystem when running: #DIV/0! psi
70% of Pressure. Rating: 0 psi
If Max.. Pressure on system is less than 70% of Pressure Rating, OK
Net Positive Suction: Head Check
Page 16

IIhV,k l(t •L rtL t' .i;i_dy z+•_ ;'n, P:.SR�1P`.
MURP
FAMILY FARMS
May 12, 1995
Mr. Jeff Raifsnider
District Conservationist
USDA - Natural Resource Conservation Service
P: O. Box 248
Burgaw, NC 28425
RE: ifairrOi 3600 Sow Farrow to Wean
Dear Mr. Raifsnider:
Enclosed for your review is the completed Animal Waste Management Plan for the
above referenced swine farm. Specific items included in this package are as follows:
- Location Map
SCS Soil Survey Map
- SoiIs Investigation Report
- Lagoon Design Spreadsheet
- Operation & Maintenance Plan for Lagoon
- Construction Specifications for Lagoon
- Site Seeding Requirements
- Earthwork Calculations
- Site Plan with Construction Details
It is my understanding that the Waste Utilization Plan for this farm will be developed
by Murphy Family Farms personnel.
Please contact me at [phone], ext. 4629 if you have any questions concerning
this package.
M00801070188
Pnct I Mr.., r7jn »- TT 11 Lr

A r4: V'id Rya. 10
LAGOON SITE SOILS INVESTIGATION
PROJECT: /I),,F
FIELD INVESTIGATION BY: 16,_)
COUNTY: 17E-,,,pFx.
DATE: v/ /s/95
SITE SKETCH
C1.
Ai
L2
BORING
DEPTH WT
SCALE
?J
4
BORING NUMBER AND PROFILE
1
!%-1, H.Sui (/ A,,,o
, - /D•5/ ' _ME 5iirO CL,91- GL/+i�
K
®
y,-.f
p' /
5.,.�,o
S!Sin-
/i / 5-
///Nor CL A
/e. s
CA r
- -
i.,A7ri ,�a,✓,✓,.,, 6,
„v ".f
/D.S'/y
Ca.+PSf
5AAo
D '' l 3 0 S,,,o fA� 1'
.,- c
i i'
p'- 4 6'' Mo.
I
- T S , 5+9Nni 4,4
'
Elli.,AflL .r i,4•�'aME
PIM
l'1,-)0
i/wr
<<ar
mill
/ern
C
i 3 •.
BORING / SAMPLING METHOD: oc‘doe SIGNATURE:
MOOS01n7n1AP

Operator:HAIRR2
County: Pender
)istance to nearest residence (other than owner):
Date: 04/25/95
0.0 feet
1. AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish) x 1417 lbs. = 0 lbs
0 sows (farrow to feeder) x 522 lbs. = 0 lbs
1000 head (finishing only) x 135 lbs. = 135000 lbs
3600 sows (farrow to wean) x 433 lbs. = 1558800 lbs
500 head.,(wean to feeder) x 30 lbs. = 15000 lbs
Describe other
• 0
4.
Total Average Live Weight =
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
y..
Volume =
0.0 cubic feet
4. TOTAL DESIGNED VOLUME
1708300 lbs
Inside top length (feet) 690.0
Inside top width (feet) 490.0
Top of dike elevation (feet) 96.0
Bottom of lagoon elevation (feet) 86.0
Freeboard (feet) 1.0
Side slopes (inside lagoon) 3.0 : 1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH.
3.0 3.0 3.0 3.0 684.0 484.0 9.0
AREA OF TOP.
LENGTH * WIDTH =
684.0 484.0
AREA OF BOTTOM
LENGTH * WIDTH =
630.0 430.0
AREA OF MIDSECTION
LENGT}l * WIDTH * 4
657.,0 457.0
CU. FT. = [AREA TOP
331056. 0
331056 (AREA OF TOP)
270900 (AREA OF BOTTOM)
1200996 (AREA OF MIDSECTION * 4)
(4*AREA MIDSECTION) * AREA BOTTDM7
********* 270900.0
* DEPTH/6
1.5
Total Designed Volume Available = 2704428 CU. FT.
M00801070193

1 h �r4. ",•: �` 'i�pw"I�I. i::S aka +} �::�;''�� Ott .V��✓1 {�0�t� f�,�.r,%�,I ,1.��
TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
69.0 490.0 338100.0 square feet
Buildings (roof and lot water)
7760.0 square feet Describe this area.
TOTAL DA 345860.0 square feet
Design temporary storage period to be 180 days.
5A. Volume cvf waste produced
Feces & urine production in gal'./day per 135 lb. ALW 1.37
Volume = 1708800 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 3121406 gals. or 417300.5 cubic feet
Aim. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume =
0.0 gallons/day X 180 days storage/7.48 gallons
Volume = 0.0 cubic feet
Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall
Volume = 7.0 in * DA / 12 inches per foot
Volume = 201751.7 cubic feet
per CF
7.0 inches
Monnriin7nloA

5D. Volume of 25 year - 24 hour storm
Volume = 8.0 inches / 12 inches per foot * DA
Volume = 230573.3 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 417301 cubic feet
5B.
0 cubic feet
5C. 201752 cubic feet
5D. 230573 cubic feet
TOTAL 849626 cubic feet
G. SUMMARY
Temporary storage period
Rainfall in excess of evaporation > 180 days
2S year - 24 hour rainfall > 7.0 inches
Freeboard > 8.0 inches
Side slopes > 1.0 feet.
Inside top length 3.0 : 1
Inside top width > 690.0 feet
Top of dike elevation > 490.0 feet
Bottom of lagoon elevation 86.0 feet
Total required volume 6.0 feet
Actual design volume > 2558426 cu. ft.
Seasonal high watertable elevation (SHWT)==_> 2704428 cu. ft.
Stop pumping elev. 92.0 feet
Must be > or = to the SHWT elev. 92. feet
Must be > or = to min. req. 'treatment el.=> 92. 0 feet
Required minimum treatment volume _ 9� 0 feet
Volume at stop pumping elevation > 1708800 cu. ft.
Start pumping elev, > 1804679 ft.
Must be at bottom of freeboard & 25 94.2 feet
Actual volume less yr. rainfall
Volume at start pumping relevation r. rainfall==> 2473855 cu. ft.
Required volume to be pumped > 2441820 cu. ft.
Actual volume planned to be pumped > 619052 cu. ft.
Min. thickness of fig; i liner when 637140 cu. ft.
7. DESIGNED BY:
DATE:
APPROVED BY
DATE: 5/1Zif
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS:
M00801070195

OPERATION AND MAINTENANCE PLAN
5liE.E:11 LW 2
1 lagoon is designed for waste treatment (permanent storage) and
�:180 days of temporary storage. The time required for the planned
i}y'!d level (permanent and temporary storage) to be reached may vary
i u'e to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.'
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and .(2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volurne,,of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year, rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to 'indicate when pumping should'begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application, include solid set,
center pivot, guns, and traveling gun irrigation. Care should, be
taken when applying waste to prevent damage to crcts.
The following items 'are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging is -complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 94.2 as marked by permanent marker.. Stop pump -
out when the fluid level reaches elevation 92.2 . This temporary
storage, less 25 yr- 24 hr storm, contains 619052 cubic feet or
4630510 gallons.
M00801070196

f Ifi rl;x(. �"IP ?. `,S i.^e F �-4i� fl.`
SHEET 2 OF 2
4. The recomended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. Kfep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain'a vigorous stand.
E. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All,, urface runoff is to be diverted from the lagoon to stable
outlets.s
8. Keep'a minimum of.25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste gill
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. .Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. Th4 Clean Water Act of 1977 prohibits 'the discharge of
pollutants into waters of the United States, The Department of
Environment, Health, and Natural Resources, Division of Environ-
mentalvManagement, has the responsibility for enforcing this law.
M00801070197

SHEET 1. OF 2
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
,Tkc
FOUNDATION PREPARATION:
The foundation area of the lagoon embankment and building
cleared of trees, logs, stumps, roots, , brush, boulders, sodpaddsr bb be
Satisfactory disposition, will be made c,
the lagaor, and pad area shouldf all debris. ubbiom
p^ be s The topsoil from
the dike and pad ar.ea�,, tripped and stockpiled for use
thlae di embankment and .After
stripping, the foundation area of °e
to placing the first building pad shall be thoroughly the
lift of fill material to 9 o loosenedbprior
'`f' get a good bond.
EXCAVATION -AND -EARTHFILL-PLACEMENT:
The completed excavation and earthfill shall conform to the lines,
grades, and elevations shown on the
be free of material plans. Earthfill material ,shall
free
such as s t
r:c-:.. - -. -,.; _.,-t _... _ `.., sod, roots, frozen soil, stones over
:.! L objectionable material.
they aFe suitable To the extent
, excavated materials can be used as
shall Le brought uF, in appraxirnatel
shall
in thickness y horizontal layers The exceed1
will b ; when loose and prior to compaction. not
layer
o 9
compacted by complete coverage with the hauling and re
equipment -or standard tamping Yer
Compaction will ne p g roller or other.equivalent method.ading
considered adequate when fill material is observed
'to consolidate to tide Point that NOTE THE SPECIAL REQUIREMENTS FOR vPLACEMENT OF ttlement is not readily
SECTION OF THIS � detectible.
SPECIFICATION. LINER, IN THE LINER
installed using the more impervious materialembankmestfrornof tthehe lrequir•edall be
excavations. Construction of fill heights shall include 5
settlement. Dikes over 15 feet in height and with an impoundment
capacitypercent for
of 10 acre-feet or more fall under the jurisdiction, of the NC
Dam Safety Law. The height is
defined
from the constructed height to thedownstream toe fof difference
dikelevation
Precautions shall be taken Burin e
n
erosion and sedimentation. g construction to prevent excessi
ve
LINER:
THE -MINIMUM -REQUIRED THICKNESS SHALL BE
-
NOTE: LINERS (PARTIAL OR FULL) ARE REQUIRED WHEN TH-
INVESTIGATION REPORT SO INDICATES E MTTE AL
ENCOUNTERED DURING CONSTRUCTION.
WHEN UNSUITABLE MATERIAL IS
STRUCTION, A TYPICAL CROSS SECTION
IS INCLUDED IN THE DESIGN WHEN LINERS ARE REQUIRED BYTHE OSOILS REPORT.R
When, areas of unsuitable material are encountered, they will
excavated below finish grade to the specified depth as me
perpendicular to the finish grade. be over-
seified to The foundation shall beubackfilled
asREFER TO THE SOILS
with a SCS approved material (i'e
CONSIDERATIONS. INVESTIGATION INFORMATION IN THE PLANS CFOR CSPECIAL
M00801070198

'i ��� ._•u. ,aye,, �..�.
.n,16Na4 .. Pi .J�,' (�! r + ..rl.�:+ i, +,� • .. f 1� f;lll.�r%� ;{!({�
SHEET 2 OF 2
Soil liner rn}t.erial shall come from an approved
minimum watex•-content of the liner materialshall.beooptimum moisture
content which relates to that moisture content when the soil is
in the hand it will_ form a ball which does not readily separate
Water
shall be kneaded
added -to borrow as necessary to insure proper moisture content
during pla,,ement of the liner.
material shall not be less than The moisture content of the liner
um
The maximum water content relates ptomthe wsoil mater rialnt dbeing too wet
for efficient use of hauling equipment andproper g Placement..
compaction of the liner includes ii ch lifts
compacted to at Least 90 Placement in 9 inch lilts and Proper
Percent of the maximum ASTM DG98 Dry Unit
Weight of the liner material. When Smooth or hard, the previous lift
shall b&scarified and moistened as needed before placement of the
lift.
next
The single most important factor affecting the overall compacte
ability of a clay "liner, other thar, the type of clay
liner, is yp � perme-
ability efficient construction processing of the scompacted ed for Cliner.
The sequence of equipment use and the routing
estab-
lished pattern helps assure uniformity of whole
ent an
y in the whole placement and
compact.ion process. For most
roller..is the clay soils, a tamping or sheepsfoot
preferable type of compaction equipment.
The soil liner shall be protected from the discharge
pipes. "'his czar, be done byusinof waste outlet
or us flexible uwst some type of energy dissipatar(rocks)
using outlets on waste pipes.
Alternative: to soil liners these are synthetic liners and bentonite sealant.
are specified, additional construction s
included with this ConstructionS ,ecifipecificatcr,, are
Fcation.
CUTOFF TRENCH:
A f cuttoftrench shall he cons
Ahua t ,' constructed under the embankment area whenYFica1 cross section in the plans. The final depth of the
cutoff trench shall be determined by observation of the .foundation
materials.
VEGETATION:
All exposed embankment and other bare constructed areas s
to the planned type of vegetation as soon as fall be a
construc-
tion according to the sceded
seeding specifications.P osoisoi ashou ac
on areas of the dike and padgtc,,Topsoil should be placed
shall be used if the recommended permanent vegetation isry of season
dates for seedinc, seeding or mulch
J permanent vegetation should be established as soon
as possible during the next period of approved seeding dates_.
REMOVAL OF EXISTING TILE DRAINS
When the drains are encountered, the tile will be removed to a miriimu
of 10 feet beyond the outside toe of slope of the dike.
trench shallm
be backfilled and compacted with good material esuch eas
► cor CH.
M00801070199

SEEDING SPECIFICATIONS
-04
AREA TO BE SEEDED: 18.0 ACRES
USE THE SEED MIXTURE INDICATED AS FOLLOWS:
0. 0 LBS. FESCUE GRASS AT 60 LBS. /ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 1 TO NOVEMBER 30
FEBRUARY 1 TO MARCH 30
0.0 LBS. RYE GRAIN AT 30 LBS./ACRE (NURSERY FOR FESCUE)
1080.0 LBS. 'PENSACOLA' BAHIA GRASS AT 60 LBS./ACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES: MARCH 15 TO JUNE 15
144.0 LBS. HULLED COMMON BERMUDA GRASS AT 8 LBS./ACRE
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
0.0 LBS. UNHULLED COMMON BERMUDA GRASS AT 10 LBS./ACRE
SEEDING DATES: JANUARY 1 TO MARCH 30
0.0 LBS. RYE GRASS AT 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDINGDATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THE FOLLOWING:
15000.0 LBS. OF 10-10-10 FERTILIZER (1000 LBS./ACRE)
36.0 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
1800.0 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAHIAGRASS IS ESTABLISHED.
M008010702nn

e
MORE RIGHT THAN N R _.._.
RAIPd
Irrigation- System Proposal
Customer Information
HaizrII482'Chrom.Ni.175,156,118 Dealer Information
RAINMAN IRRIGATION, INC.
P.O. BOX 1137 429 E. HWY 55
MOUNT OLIVE, NC 28365
[phone]
[phone]
[phone]
System Information
System Type: Center Pivot
System GPM: 400 GPM
Elevation:, 6 feet
Pivot Pressure: 54.51 PSI
End Pressure
Hours to Apply an Inch:
Span Information
Number
1
2
3
EB
C Y
3-lf-395D
RAINMAN IRRIGATION, INC.
Phone:
FAX:
Mobile:
E-Mail:
Model:
System Length:
System Acres:
50.00 PSI End Gun Acres:
27.30 Hours Total Acres:
iimm �r
6"
6"
6"
6"
Irrigation System Proposal
Hairr II 482' Ch'rom.Nl.
Customer Name:
175,156,118
12/16/2003
E2660-G/57"
475 feet
Le-- ij
175'
156'
118'
23'
16.50 Acres
3.57 Acres
20.06 Acres
cLT rick
177'
333'
451'
475'
Page 1 of 5
12/16/2003

Insect Control Checklist for Animal Operations
Source Cause BMPs to Control Insects Site Specific Practices
Flush gutters • Accumulation of solids
Lagoons and pits • Crusted solids
Excessive vegetative • Decaying vegetation
growth
Liquid Systems
C3 Flush system is designed and operated sufficiently
to remove accumulated solids from gutters as
designed
Remove bridging of accumulated solids at
discharge
CI -Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the crusting
of solids to a depth of no more than 6 to 8 inches
over more than 30 percent of surface
Pr Maintain vegetative control along banks of
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter along
water's edge on impoundment's perimeter.
Dry Systems
Feeders • Feed spillage 0 Design, operate, and maintain feed systems
(e.g., bunkers and troughs) to minimize the
accumulation of decaying wastage
O Clean up spillage on a routine basis (e.g., 7- to 10-
day interval during summer; 15- to 30-day interval
during winter)
AMIC - November 11, 1996, page 1

Insect Control Checklist for Animal Operations
Source Cause BMPs to Control Insects
Feed storage • Accumulations of feed 'Reduce moisture accumulation within and around
residues immediate perimeter of feed storage areas by
ensuring drainage is away from site and/or providing
adequate containment (e.g., covered bin for
brewer's grain and similar high moisture grain
products)
❑ Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed
Animal holding areas • Accumulations of animal ❑ Eliminate low areas that trap moisture along fences
wastes and feed wastage and other locations where waste accumulates and
disturbance by animals is minimal
❑ Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e., inspect for and remove or break up
accumulated solids as needed)
Dry manure handling • Accumulations of animal ❑ Remove spillage on a routine basis (e.g.,
systems wastes 7- to 10-day interval during summer; 15- to 30-day
interval during winter) where manure is loaded for
land application or disposal
❑ Provide for adequate drainage around manure
stockpiles
❑ Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and manure
handling areas as needed
Site Specific Practices
For more information contact:
Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University, Raleigh, NC 27695-7613.
AMIC - November 11, 1996, page 2

Swine Farm Waste Management Odor Control Checklist
Source
Farmstead
Cause
• Swine production
Animal body • Dirty manure -covered
surfaces animals
BMPs to Minimize Odor
Er Vegetative or wooded buffers
1 Recommended best management practices
a --Good judgment and common sense
Site Specific Practices
Er -Dry floors
Floor surfaces • Wet manure -covered floors
Manure collection • Urine
pits • Partial microbial
decomposition
Ventilation exhaust • Volatile gases
fans
• Dust
Indoor surfaces • Dust
Flush tanks
Er -Slotted floors
0--Waterers located over slotted floors
O Feeders at high end of solid floors
O Scrape manure buildup from floors
O Underfloor ventilation for drying
A —Frequent manure removal by flush, pit recharge,
or scrape
O Underfloor ventilation
Orman maintenance
OEfficient air movement
O--Washdown between groups of animals
O Feed additives
O Feeder covers
Ca'1eed delivery downspout extenders to feeder
covers
Flush alleys
• Agitation of recycled lagoon O Flush tank covers
liquid while tanks are filling O Extend fill lines to near bottom of tanks with
anti -siphon vents
• Agitation during wastewater 0 Underfloor flush with underfloor ventilation
conveyance
AMOC - November 11, 1996, page 1

Source
Pit recharge points
Lift stations
Swine Farm Waste Management Odor Control Checklist
Cause
• Agitation of recycled lagoon
liquid while pits are filling
BMPs to Minimize Odor
Extend recharge lines to near bottom of pits with
anti -siphon vents
• Agitation during sump tank
filling and drawdown
Outside drain • Agitation during wastewater
collection or junction conveyance
boxes
End of drainpipes • Agitation during wastewater
at lagoon conveyance
Lagoon surfaces
• Volatile gas emissions
• Biological mixing
• Agitation
O Sump tank covers
Site Specific Practices
O Box covers
2-Extend discharge point of pipes underneath
lagoon liquid level
Irrigation sprinkler • High pressure agitation
nozzles
Storage tank or
basin surface
• Wind drift
Proper lagoon liquid capacity
Er —Correct lagoon startup procedures
O Minimum surface area -to -volume ratio
O Minimum agitation when pumping
O Mechanical aeration
O Proven biological additives
• Partial microbial
decomposition
• Mixing while filling
• Agitation when emptying
AMOC - November 11, 1996, page 2
O Irrigate on dry days with little or no wind
O Minimum recommended operating pressure
O Pump intake near lagoon liquid surface
O Pump from second -stage lagoon
O Bottom or midlevel loading
O Tank covers
O Basin surface mats of solids
O Proven biological additives or oxidants

Source
Settling basin surface
Manure, slurry, or
sludge spreader
outlets
Uncovered manure,
slurry, or sludge on
field surfaces
Dead animals
Cause
Swine Farm Waste Management Odor Control Checklist
• Partial microbial
decomposition
• Mixing while filling
• Agitation when emptying
• Agitation when spreading
• Volatile gas emissions
BMPs to Minimize Odor
0 Extend drainpipe outlets underneath liquid level
0 Remove settled solids regularly
Site S ecific Practices
• Volatile gas emissions while
drying
• Carcass decomposition
Dead animal disposal • Carcass decomposition
pits
Incinerators
Standing water
around facilities
O Soil injection of slurry/sludges
O Wash residual manure from spreader after use
O Proven biological additives or oxidants
O Soil injection of slurry/sludges
O Soil incorporation within 48 hours
O Spread in thin uniform layers for rapid drying
O Proven biological additives or oxidants
Siroper disposition of carcasses
• Incomplete combustion
• Improper drainage
O Complete covering of carcasses in burial pits
O Proper location/construction of disposal pits
O Secondary stack burners
• Microbial decomposition of
organic matter
Manure tracked onto
public roads from
farm access
0 Grade and landscape such that water drains away
from facilities
• Poorly maintained access 0 _ f arm access road maintenance
roads
AMOC - November 11, 1996, page 3

Additional Information:
Swine Manure Management; .0200 Rule/BMP Packet
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge —Lagoon Treatment; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush —Lagoon Treatment; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
Controlling Odors from Swine Buildings; PIH-33
Environmental Assurance Program; NPPC Manual
Options for Managing Odor; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO 107, 1995 Conference Proceedings
AMOC - November 11, 1996, page 4
Available From:
NCSU, County Extension Center
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—Swine Extension
N.C. Pork Producers Assoc.
NCSU Agricultural Communications
Florida Cooperative Extension

EMERGENCY ACTION PLAN
DWQ U5 375 ,act o
EMERGENCY MANAGEMENT SYSTEM
SWCD q i .29roAlb()
NRCS IO 019Lv 1.1.0
we, 490 4, a11(3
PHONE NUMBERS
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or leave
your property to consider that you have a problem. You should make every effort to ensure that
this does not happen. This plan should be posted in an accessible location for all employees at the
facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runofffrom waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
1 December 18, 1996

D: Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing
leaks- possible action:
a. Dig a small sump or ditch away from the embankment to catch all seepage, put in a
submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon bottom as soon
as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality) regional office;
Phone - - . After hours, emergency number: 919-733-3942. Your phone call
should include: your name, facility, telephone number, the details of the incident from item
2 above, the exact location of the facility, the location or direction of movement of the
spill, weather and wind conditions. The corrective measures that have been under taken,
and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number -
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number - - , local SWCD office phone number -
local NRCS office for advice/technical assistance phone number - - , and
2 December 18, 1996

4: If none of the above works call 911 or the Sheriffs Department and explain your problem to
them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site damage.
a. Contractors Name: ,43r)u,. h y tgo.0 : y ��„� �� �G s
b. Contractors Address: /13 7 Idol / (,_ P A C a 2, i (0 (P
c. Contractors Phone:_ q 1® a2 1 S L
6: Contact the technical specialist who certified the lagoon (MRCS, Consulting Engineer, etc.)
a. Name: "'c._ / L= la„ L
b. Phone: / - , A.- 3
7: Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.
3 December 18, 1996

ROY COOPER
Governor
MICHAEL S. REGAN
secretary
LINDA CULPEPPER NORTH CAROLINA
Director Environmental Quality
April 22, 2019
Wesley C. Hairr
Hairr II
1188 Veach's Mill Rd
Warsaw NC 28398
Subject: Additional Information Request
Application No. AWS710073
Hairr II
Pender County
Dear Mr. Wesley C. Hairr,
The Animal Feeding Operation Program of the Division of Water Resources (Division) has completed a
preliminary review of your renewal permit application package. Additional information is required
before we may continue our review. Please address and submit the following item(s) within 30 (thirty)
days of receipt of this letter:
Mortality Control Checklist with selected method noted Use the enclosed updated Mortality
Control Checklist
Please reference the subject application number when providing the requested information. All revised
and/or additional documentation shall be signed, dated and sent to my attention at the address below. The
Information can also be submitted electronically at 2019PermitRenewalra;ncdenr.gov
Please feel free to contact me at 919-707-3702 if you have any questions regarding this letter,
rfECEIVVu/I,C0g(.?/D WR
61.9 2019
Reglanalopeingon%ahlYsecuon
Sincerely,
Ramesh Ravella
Animal Feeding Operations Program
cc: Wilmington Regional Office, Water Quality Regional Operations Section
AFOGS Section Files — AWS710073
North Carolina Department of Environmental Quality I Division of Water Resources
512 North Salisbury Street 11636 Mall Service Center I Raleigh, North Carolina 27699-1636
919.707.9000

Fr tiWl 16017 3
Version —November 26, 2018
Primary Secondary
O O
❑ O
O ❑
❑❑
❑ ❑
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
EDINCDECdiDWA agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
RezEN
ports a variety of emergency mortality disposal options; contact the Division for guidance.
J(' 09Z01S
Water Quality
Regtoeal Opel Sew
•
•
Sig
A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
ure of Farm Owner/Manager Date
Signature of Technical Specialist Date