710034_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered Please verify all information and retake any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 71-0034 Certificate Of Coverage Number: AWS710034
2. Facility Name: Beaver Branch Farms, LLC
3. Landowner's Name (same as on the Waste Management Plan): Jerry D 1--Iedge
4. Landowner's Mailing Address: PO Box 911
City: Writsvlle Bch
Telephone Number: 910-39221 E7T
5. Facility's Physical Address: 375 Fennelltown Rd
State: NC
E-mail: jhedge`r ec.rr.com
Zip: 28480
City: Burgaw State: NC Zip: 28425
6. County where Facility is located: Pender
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code): {O{ to) C
9. Integrator's Name (if there is not an Integrator, write "None"): Murphy -Brown LLC
1 p. Operator Name (OIC): Jerry D. Hedge
11,
Lessee's Name (if there is not a Lessee; write "None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type
Operation Types:
Phone No.: 910-617-2913 OIC #: 24125
Allowable Count
Swine - Feeder to Finish 2,448
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Lavers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
LAGOON 141
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
CLt
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(inches)
1c ---
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes I43-215.10C(d) to the address below.
The CAWMP must include the following components:
I. The most recent Waste Utilization Plan (WUP), signed by the owner and a certified technical specialist. containing:
a. The method by which waste is applied to the disposal fields {e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required MRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility_
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal _
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: 2019PermitRenewal(a�ncdenr.gov

l attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. 1 understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will he returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner. or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name: `� ��1 ��b" Title:
Signature: Date:
Name: Title:
Signature: Date:
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
ncdenr.gov
FORM: RENEWAL -STATE GENERAL 02/2019

I- 34(
EMERGENCY ACTION PLAN
PHONE NUMBERS I C
DWQ
EMERGENCY MANAGEMENT SYSTEM 910—
SWCD
NRCSWCD.,g
G�
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or leave
your property to consider that you have a problem. You should make every effort to ensure that
this does not happen. This plan should be posted in an accessible location for all employees at the
facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
1 December 18, 1996

D: Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing
leaks- possible action:
a. Dig a small sump or ditch away from the embankment to catch all seepage, put in a
submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon bottom as soon
as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality) regional office;
Phone - - . After hours, emergency number: 919-733-3942. Your phone call
should include: your name, facility, telephone number, the details of the incident from item
2 above, the exact location of the facility, the location or direction of movement of the
spill, weather and wind conditions. The corrective measures that have been under taken,
and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number - -
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number - - , local SWCD office phone number - - , and
local NRCS office for advice/technical assistance phone number - -
2 December 18, 1996

4: If none of the above works call 911 or the Sheriffs Department and explain your problem to
them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site damage.
a. Contractors Name:
b. Contractors Address:
c. Contractors Phone:
6: Contact the technical specialist who certified the lagoon (NRCS, Consulting Engineer, etc.)
a. Name:
b. Phone: 1
7: Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.
3 December 18, 1996

SHEET 1 OF 2
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 yr - 24 hr storm for the location and a
heavy rain factor. The volume of waste generated from a given number
of animals will be fairly constant throughout the year and from year to
year, but excess rainfall will vary from year to year. The heavy rain
factor and 25 yr rainfall will not be a factor to consider in an annual
pumping cycle, but this storage volume must always be available.
The waste produced by the animals shall be utilized in accordance with
an approved waste utilization plan. Highly visible markers shall be
installed to mark the upper and lower elevations of the temporary
storage (pumping volume). Pumping shall be done as necessary to
maintain the liquid level between these markers.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. Before wastes are introduced, the waste treatment lagoon shall be
charged to 1/2 its treatment volume to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 46.30 as marked by permanent marker. Stop pump -
out when the fluid level reaches elevation 44.30 . This temporary
storage less 25 yr and heavy rain contains 51,663 cubic feet or
386,437 gallons.

SHEET 2 OF 2
4. The recommended maximum amount to apply per irrigation and
recommended maximum application rate is shown in the waste utilization
plan. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. Repair areas of the embankment that settle below the design settled
height or areas where cracking, sloughing, or' jug" holes develop.
8. Repair waste inlet pipes that develop cracks or separate at the
joints.
9. Remove undesirable vegetative growth and floating or lodged debris.
10. All surface runoff is to be diverted from the lagoon to stable
outlets when not included as part of the design temporary storage.
11. After five years the waste treatment lagoon shall be checked for
sludge accumulation annually. If sludge has encroached into the
treatment volume, the sludge will be removed and applied at agronomic
rates based on analysis of the sludge. Treatment volume must have
a minimum of 4 feet of depth free of sludge at all times.
12. In December 1992, the Environmental Management Commission (EMC)
in North Carolina revised water quality regulations that address
animal operations. These rules became effective on February 1,
1993 (15A NCAC 2H .0200). This animal operation shall be operated
within the requirements of these rules and regulations.
13. Pipes that are used for recycling effluent to use as flush water
and irrigation intakes must be placed 18 inches below the surface and
as far from the inlet discharge pipes as possible in order to provide
a cleaner effluent for flushing and to reduce odors when irrigating on
land. When these pipes are placed through the embankment, they should
be installed no more than two feet below top of embankment and not in
the highest section of fill. The pipe trench shall be compacted with
clayey material or other material as approved by an engineer.

ROY COOPER
covetruo
MICHAEL S. FtEGAN
Seurrerry
LINDA CULPE.PPER
Arreetor
Jerry D Hedge
Beaver Branch Farms, LLC
PO Box 911
Writsvlle Bch, NC 28480
NORTH CAROL]NA
Envi'ro, mental Quality
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Pennittee:
February 27, 2019
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at httpsa/deq.nc.gov/about/divisions/water-resources/water-quality-regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636 f
Telephone number [phone] 7 G `' � i j i fi o r Li+� soi."
L 9tin s L-O„.r ram.— Cl 14 70 3 CP 7 �t c(e
In order to assure your continued coverage under the State Non -Discharge General Permits, you must submit an application for
permit coverage to the Division. Enclosed you will find a "Request for Certificate of Coverage Facility Currently Covered by an
Expiring State Non -Discharge General Permit." The application form must be completed. signed and returned by April 3, 2019.
Please note that you must include one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with the
completed and signed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to S25,000 per day.
If von have any questions about the State Non -Discharge General Permits. the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Wilmington Regional Office, Water Quality Regional Operations Section
Pender County Soil and Water Conservation District
AFOG Section Central Files - AWS710034
Murphy -Brown LLC
North Cam'- fte Department of Er, v %_ r a' ., = 2g ia Xa re of Water Resources
512 Eii. Sauer St_ l 1636 i Sery, ;teeter j Rsa:Q , North Ca c'tn5.276aS; 26a6
915.70`t

Primary Secondary
❑ ❑
❑ ❑
• o
❑ ❑
❑ ❑
Version —November 25, 2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opiniorof the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be.done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Libb ill
ture of Farm Owner/Manager Date
Signature of Technical Specialist Date

Jerry Hedge
From: Jerry Hedge <[e-mail]>
Sent: Friday, October 11, 2019 12:20 PM
To: 'A J Linton ([e-mail])'
Subject: FW: Additional Info Requested - Application no. AW5710034
Attachments: AWS710034_app_sent.pdf; Mortality management checklist 11_26_2018.pdf; Insect
Control Checklist 1996.pdf; Swine Odor Checklist APPROVED 07252019.pdf
From: Robinson, Heath C <[e-mail]>
Sent: Tuesday, August 20, 2019 3:51 PM
To: [e-mail]
Cc: Edwards, Sam <[e-mail]>
Subject: Additional Info Requested - Application no. AWS710034
August 20, 2019
Jerry D Hedge
Beaver Branch Farms, LLC
PO Box 911
Wrightsville Beach, NC 28480
Subject: Additional Information Request
Application No. AW
Beaver Branch Farms, LLC
Pender County
Dear Jerry Hedge
The Animal Feeding Operations Program of the Division of Water Resources (Division) has completed a preliminary
review of your renewal permit application package. Additional information is required before we may continue our
review. Please address and submit the following item(s) within 30 (thirty) days of receipt of this letter:
J Waste Utilization Plan: Our records show either a portion of or entire copy of the Waste Utilization plan (WUP)
or nutrient management plan (NMP) is missing from your permit application. One or more of the following
components is missing:
o The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
o A map of every field used for land application (for example: irrigation map)
o The soil series present on every land application field
o The crops grown on every land application field
o The Realistic Yield Expectation (RYE) for every crop shown in the WUP
o The maximum PAN to be applied to every land application field
o The waste application windows for every crop utilized in the WUP
o The required NRCS Standard specifications
/Copies of Site Map/Field Maps: Our record show that the copies of the field maps are missing in your WUP or
NMP.
J' E eergency Action Plan
1

ErInsect Control Checklist with chosen best management practices noted. Enclosed is a copy of the Insect Control
Checklist for your review and submittal. The Insect Control Checklist can also be found online at
hops://www.ncagr.gov/SWC/tech/guidancedocuments.html.
Er Odor Control Checklist with chosen best management practices noted. Enclosed is a copy of the Odor Control
Checklist for your review and submittal. The Odor Control Checklist can also be found online at
https://www.ncagr.gov/SWC/tech/guidancedocuments.htm I.
T= "Mortality Control Checklist with selected method noted, and signed by a technical specialist_ Enclosed is a copy
of the Mortality Control Checklist for your review and submittal. The Mortality Control Checklist can also be
found online at https://www.ncagr.gov/SWC/tech/guidancedocuments.html.
I Lagoon/storage pond capacity documentation (design, calculations, etc.) Also provide any site evaluations,
wetland determinations, or hazard classifications that may be applicable to your facility.
L'J Operation and Maintenance Plan for the lagoon/storage pond structures
Please reference the subject application number when providing the requested information. All revised and/or additional
documentation shall be signed, dated and sent to my attention at the address below. The Information can also be
submitted electronically at heath.robinsoncncdenr.gov
Please feel free to contact me at 919-707-3705. if you have any questions regarding this letter,
Sincerely,
Animal Feeding Operations Program
Heath C. Robinson
Waste to Energy Engineer I
Division of Water Resources
Animal Feeding Operations
Office: 919-707-3705
[e-mail]
Email correspondence to and from this address is subject to the North Carolina Public Records Law and may be disclosed to third
parties.
North Carolina Department of Environmental Quality i Division of Water Resources
512 North Salisbury Street f 1636 h>as"f Service Center 1 Raleigh, North Carolina Z7699-1636
919107.9000
cc: Wilmington Regional Office, Water Quality Regional Operations Section
AFOGS Section Files -- AWS710034
2

Nutrient Management Plan For Animal Waste Utilization
11-16-2005
This plan has been prepared for:
&aver H e I a.- i L L C
716Q-1-1 L' r 7 7 Axw
JERRYHEDGE
412 DOGWOOD LANE
WILMINGTON, NC 28409
910-617-2913
This plan has been developed by:
JASON TURNER
PENDER SWCD
PO BOX 248
801 S. WALKER ST.
BURGAW, NC28425
910-259-9123 Ext. #3
veloper Signature
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance procedures
established in this nutrient management plan which includes an animal waste utilization plan for
the farm named above. I have read and understand the Required Specifications concerning anima]
waste management that are included with this plan.
j/-/6 --or
Date
i% iG o,--
gnature (manager or producer) Date
This plan meets the minimum standards and specifications of the U.S. Department of Agriculture -
Natural Resources Conservation Service or the standard of practices adopted by the Soil and Water
Conservation Commission.
Plan Approved By:
chnical Specialist Signature Date
633520 Database Version 3.1 Date Printed: 11-16-2005
Cover Page 1

Nutrients applied in accordance with this plan will be supplied from the following
source(s):
Commercial Fertilizer is not included in this plan.
S7
Swine Feeder -Finish Lagoon Liquid waste generated 2,269,296 gals/year by a 2,448
animal Swine Finishing Lagoon Liquid operation. This production facility has waste
storage capacities of approximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
5227
Incorporated
8976
Injected
9885
Irrigated
5681
Max. Avail.
PAN (lbs) *
Actual PAN
Applied (lbs)
PAN Surplus/
Deficit (lbs)
Actual Volume
Applied (Gallons)
Volume Surplus/
Deficit (Gallons)
Year 1
5,681
6941
-1,260
2,772,657
-503,361
Note: In source ID, S means standard source, U means user defined source.
* Max. Available PAN is calculated on the basis of the actual application method(s) identified in the plan for this source.
633520 Database Version 3.1 Date Printed: I 1-16-2005 Source Page Page 1 of 1

Narrative
The irrigation sprinklers have been split into 3 zones. 48 sprinlders per zone. There are 144 sprinkler
risers that are spaced at 80 ft. apart. 20 Sprinklers at 80 psi flowing 13.3 gallons 1 min. All zones
should be sprayed on before any prior zone is sprayed on. Wettable acres have been determined on this
farm. This waste mgt. plan should not be changed unless approved by an technical specialist.
Updated waste utilization table to show bermuda pumping dates 3-15-10-15 and overseeded rye
10-15-3-15 change made on 3-19-02 by Jason Turner, PSWCD.
This plan revision reflects a crop change by adding one cutting of Bermuda hay per year and rest of the
time the pasture will be grazed. The
grazed rate is 2601bs. per acre and the haying rate is 264 lbs. per acre. Change made on 11-26-03 by
Jason Turner, PSWCD.
633520 Database Version 3.1 Date Printed: 11-16-2005 Narrative Page Page 1 of 1

The table shown below provides a summary of the crops or rotations included in this plan for each field. Realistic Yield estimates
are also provided for each crop in the plan. In addition, the Leaching Index for each field is shown, where available.
Planned Crops Summary
Tract
Field
4
Total
Acres
Useable
Acres
Leaching
Index (LI)
Soi] Series
Crop Sequence
RYE
7060
1
8.00
7.87
N/A
Norfolk
Hybrid Bermudagrass Pasture
6.5 Tons
Small Grain Overseed
1.0 Tons
7060
2
8.00
7.87
N/A
Norfolk
_
Hybrid Bermudagrass Pasture
6.5 Tons
Small Grain Overseed
1.0 Tons
7060
3
8.00
7.87
N/A
Norfolk
Hybrid Bel nudagrass Pasture
Small Grain Overseed
6.5 Tons
1.0 Tons
LI
Potential Leaching
Technical Guidance
< 2
Low potential to contribute to soluble
nutrient leaching below the root zone.
None
2 &
<= 10
Moderate potential to contribute to soluble
nutrient leaching below the root zone.
Nutrient Management (590) should be planned.
10
High potential to contribute to soluble
nutrient leaching below the root zone.
Nutrient Management (590) should be planned. Other conservation practices that improve the soils
available water holding capacity and improve nutrient use efficiency should be considered.
Examples are Cover Crops (340) to scavenge nutrients, Sod -Based Rotations (328), Long -Term
No-Till(778), and edge -of -field practices such as Filter Strips (393) and Riparian Forest Buffers
(39I),
633520 Database Version 3.1 Date Printed 11/16/2005
NOTE: Symbol * means user entered data.
PCS Page Page 1 of 1

to of the number of acres of cr
0 C R
S?.G '
.A cl .O.
at
o • 5 °'
�a�.)y cd
O a=.. 4
El
a, 'Q o
0d]
-n . o
CO 0 Y
a) z as a)
a)o
.Oa)�M.b.E
4rci
4) �)
rd W
co u•.-N o
;-b .�.- O O N
- Q]
E"'. bA aa)) 'b g
%
.O O c1
.cl0 c� � O
PE cu
p O o
cr to ap 0
n
•
4) O '3)
40 . Z
O F. b
. 0 Q'
o 6" 0.7
ct
CU
a) o a)
i• o 0
as 2 O a) .0
"d Fes.
0 N
~ O W 0 R.i 0.,v O U O
a)
En
) 04 as N 'C ,b
) S. aJ P. 0 a)
.� 4•. b•ate`)
b 4 O W
,s„ ��., Y i� bD
6) UUy
y 0 F+
4 *O x cd g N
al En
cci AU -d 4oN bf Aed
ro
a � 5 0 .•N
y ' .-' U a3 •l+
-` 1 A p .
'.5 G U O 4�
a., ,ty .--.
'O ,9 ^d
o g p,...1...
G
O
0
O
0
0
O
O
0
O
O
0
0
O
0
O
O
0.001
-
0
O
0
O
0
O
0
0
0
•O u .d
C.-.
o
767.04
w
767.04
co
.-.
O
N
co
.
.l
n
N
N
0
f71
N
N
,..0
M
U
y b
7y y
C
p G c`a
rn . "
o:o
i '
0
0
O
O
0
O
O
0
0
O
0
O
C.
O
O
O
O
O
Total Applied, 1000 gallons
Total Produced, 1000 gallons
Balance, 1000 gallons
.
a
d
)
rTotal Produced, tons!
0
ro
CO
,u Q
2
.� G 2 ro
a av
O <
C ga
N
Cr
c-
O
a
'
V
CT
Cr,..c
a
a
N
aT
N
4
ChFA
Q
Q y d2 ,
za"
V
N
0
V
N
O
0
N
O
V
0. ��bb
P-+
Q
Yr
0
ap
z
0
0
a
0
0
0
a.v¢
E E¢
o 4) 0.-
zd
z
o
0
0
0
0
0
G
o d d o-¢
.b a. 70i a �
z
z
0-
w
0
00
v
�N
0
00
0
*
0
vl
V -,
oo
a 0
a a,
Q
vl
_O
M
N
N
p
v1
6-fV
N
p
8
M
N
N
p
�r
?
Q♦
w
F.
Ln
0
f•.
O
,-.
F-'
h
m
v
E-
O
,-.
-
..o
E-
O
'.
O
3.)
Hybrid Bermudagrass Pasture
Small Grain Overseed
Hybrid Bermudagrass Pasture
Small Grain Overseed
Hybrid Bermudagrass Pasture
Small Grain Overseed
N
i-
c-
00
c-
000
t-
c-
N
cn
CO
N
N
CO0'
N
m E
f--. Q
0
0
08
O
0
o0
0
0
00
0
O
0o
O
0
a
O
O
x
.39
on
z
z
Norfolk
z
z
z
U
0
co
00
0
0
00
03
0
m
'a:
'+
.+
N
CV
r (
f.l
V
e
F.N
O
0
O
00
N
O
0
N
O
00
N
0
00
c-
O
0
N
WUT Page Page 1 of 1
Date Printed: 11/16/2005
Database Version 3.1

The Irrigation Application Factors for each field in this plan are shown in the following table. Infiltration rate varies with soils. If
applying waste nutrients through an irrigation system, you must apply at a rate that will not result in runoff. This table provides the
maximum application rate per hour that may be applied to each field selected to receive wastewater. It also lists the maximum
application amount that each field may receive in any one application event.
Irrigation Application Factors
Tract
Field
Soil Series
Application Rate
(inches/hour)
Application Amount
(inches)
7060
1
Norfolk
0.50
1.0
7060
2
Norfolk
0.50
1.0
7060
3
Norfolk
0.50
1.0
633520 Database Version 3.1 Date Printed 11/16/2005 IAF Page Page 1 of 1
NOTE: Symbol * means user entered data.

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for sludge
utilization for the indicated accumulation period. These estimates are based on average nitrogen concentrations for each source,
the number of animals in the facility and the plant available nitrogen application rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At clean out, this
material must be utilized for crop production and applied at agronomic rates. In most cases, the priority nutrient is nitrogen but
other nutrients including phosphorous, copper and zinc can also be limiting. Since nutrient levels are generally very high,
application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be used for
sludge application. If this is not possible, care should be taken not to load effluent application fields with high amounts of
copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water moving to streams and lakes,
phosphorous is a concern. Soils containing very high phosphorous levels may also be a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
lb/ac
Maximum Sludge
Application Rate
1000 gal/ac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Feeder -Finish Lagoon Sludge - Standard
Corn 120 bu
150
13.16
30.69
61.38
92.07
Hay 6 ton R.Y.E.
300
26.32
15.34
30.69
46.03
Soybean 40 bu
160
14.04
28.77
57.54
86.31
633520 Database Version 3.1 Date Printed: 11-16-2005 Sludge Page Page 1 of

The Available Waste Storage Capacity table provides an estimate of the number of days of storage capacity available
at the end of each month of the plan. Available storage capacity is calculated as the design storage capacity in days
minus the number of days of net storage volume accumulated. The start date is a value entered by the user and is
defined as the date prior to applying nutrients to the first crop in the plan at which storage volume in the lagoon or
holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design storage
capacity of the facility. If the available storage capacity is greater than the design storage capacity, this indicates that
the plan calls for the application of nutrients that have not yet accumulated. If available storage capacity is negative,
the estimated volume of accumulated waste exceeds the design storage volume of the structure. Either of these
situations indicates that the planned application interval in the waste utilization plan is inconsistent with the
structure's temporary storage capacity.
Available Waste Storage Canaci
Source Name
Swine Feeder -Finish Lagoon Liquid
Design Storage Capacity (Days)
Start Date
9/01
180
Plan Year
Month
Available Storage Capacity (Days)
1
1
33
1
2
18
1
3
50
1
4
76
1
5
101
1
6
127
1
7
152
1
8
180
1
9
169
1
10
157
1
11
143
1
12
127
* Available Storage Capacity is calculated as of the end of each month.
633520 Database Version 3.1 Date Printed: 11-16-2005 Capacity Page Page 1 of 1

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during operation
or land application. Any discharge of waste that reaches surface water is
prohibited.
2. There must be documentation in the design folder that the producer either owns
or has an agreement for use of adequate land on which to properly apply the
waste. If the producer does not own adequate land to properly dispose of the
waste, he/she shall provide evidence of an agreement with a landowner, who is
within a reasonable proximity, allowing him/her the use of the Iand for waste
application. It is the responsibility of the owner of the waste production facility to
secure an update of the Nutrient Management Plan when there is a change in the
operation, increase in the number of animals, method of application, receiving
crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for
realistic crop yields based upon soil type, available moisture, historical data,
climatic conditions, and level of management, unless there are regulations that
restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year.
Waste may be applied to land eroding at more than 5 tons per acre per year but
less than 10 tons per acre per year provided grass filter strips are installed where
runoff leaves the field (see USDA, NRCS Field Office Technical Guide Standard
393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste application.
Waste should not be applied when there is clanger of drift from the land
application field.
6. When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to
conservation tilled crops or grassland, the waste may be broadcast provided the
application does not occur during a season prone to flooding (see "Weather and
Climate in North Carolina" for guidance).
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such
that runoff does not occur offsite or to surface waters and in a method which does
not cause drift from the site during application. No ponding should occur in order
to control odor and flies.
633520 Database Version 3.1 Date Printed: 11/16/2005 Specification Page 1

8. Animal waste shall not be applied to saturated soils, during rainfall events, or
when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that
the crop is not covered with waste to a depth that would inhibit growth. The
potential for salt damage from animal waste should also be considered.
10. Nutrients from waste shall not be applied in fall or winter for spring planted
crops on soils with a high potential for leaching. Waste/nutrient loading rates on
these soils should be held to a minimum and a suitable winter cover crop planted
to take up released nutrients. Waste shall not be applied more than 30 days prior
to planting of the crop or forages breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the
following: The outer perimeter of the land area onto which waste is applied from
a lagoon that is a component of a swine farm shall be at least 50 feet from any
residential property boundary and canal. Animal waste, other than swine waste
from facilities sited on or after October 1, 1995, shall not be applied closer that 25
feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than
those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public
right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or
wetlands by a discharge or by over -spraying. Animal waste may be applied to
prior converted cropland provided the fields have been approved as a land
application site by a "technical specialist". Animal waste shall not be applied on
grassed waterways that discharge directly into water courses, and on other
grassed waterways, waste shall be applied at agronomic rates in a manner that
causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks,
etc., shall not be discharged into the animal waste management system.
633520 Database Version 3.1 Date Printed: 11/16/2005 Specification Page 2

17. A protective cover of appropriate vegetation will be established on all disturbed
areas (lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as
necessary, to protect the vegetation. Vegetation such as trees, shrubs, and other
woody species, etc., are limited to areas where considered appropriate. Lagoon
areas should be kept mowed and accessible. Berms and structures should be
inspected regularly for evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate
the possibility of an illegal discharge, pollution, and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a
regular basis to prevent breakdowns, leaks, and spills. A regular maintenance
checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops
for direct human consumption. However, if animal waste is used on crops for
direct human consumption, it should only be applied pre -plant with no further
applications of animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom elevations of
the temporary storage (pumping volume) of all waste treatment lagoons.
Pumping shall be managed to maintain the liquid level between the markers. A
marker will be required to mark the maximum storage volume for waste storage
ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the
rate -determining nutrient, unless other restrictions require waste to be applied
based on other nutrients, resulting in a lower application rate than a nitrogen
based rate. Zinc and copper levels in the soils shall be monitored and alternative
crop sites shall be used when these metals approach excessive levels. pH shall be
adjusted and maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of five years. Poultry dry waste application
records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for five (5)
years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
633520 Database Version 3.1 Date Printed: 11/16/2005 Specification Page 3

Crop Notes
The following crop note applies to field(s). 1, 2, 3
Small Grain: CP, Mineral Soil, medium leachable
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from
October 15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for
each week seeding is delayed beyond the optimum time. See the seeding rates table for applicable
seeding rate modifications in the current NCSU "Small Grain Production Guide". AIso, increase the
initial seeding rate by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and
rye at 1-1 1/2 bushels/acre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is
essential. Review the NCSU Official Variety "green book" and information from private companies to
select a high yielding variety with the characteristics needed for your area and conditions. Apply no more
than 30 lbs/acre N at planting. Phosphorus and potash recommended by a soil test can also be applied at
this time. The remaining N should be applied during the months of February -March.
The following crop note applies to field(s): 1, 2, 3
Bermudagrass: CP, Mineral Soil, Moderately Well Drained.
Adaptation: Well -adapted.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs 1" to 3"
deep (1.5" optimaI). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization
of Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance.
633520 Database Version 3.1 Date Printed: 11-16-2005 Crop Note Page Page 1 of 1

CS- E N C- 538
Rev. 5-70
U... S. OEPARTMEN1 OF AGRIL;ULI L11-4t
SOiL CONSERVATION SERVICE
5
C /07
SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSE
- —
FARMER'S NAME \71' ! cl � T' DISTRIC
DATE ` F. ` 1G COUNTY
S. C. S. PHOTO SHEET NO. WORK UNIT
WATERSHED AREA MEASUREMENTS
CROPLAND ACRES PASTURE ACRES
WOODLAND - ACRES TOTAL ACRES
POND CLASS
WORK UNIT CONSERVATIONIST
SKETCH OE PROPOSED POND SHOWING WHERE BORINGS WERE MADE (Approx. scale 1"= feet)
• Locate reference palm! -in center line of dam and identity an sketch.
I
t
1j it
L
(
(3)i'-r
tab
-
/
i'
6-- 0
r
r
07,-5
°
//
f
SHOW
DFP'CH
SCALE
J
%r/ BQ7f{ING
uke urr fi 1,-st darn -site and spillway bonnpd Arsl
n tir'ii_d un buck where necessary) Spiro, wa ter.
-.1
NIIMJIER
lflen
-able
AND PROFILE
ached area and borrow pit burinps • separate with vertical red line.
waliuns on darn -site bprinps,
1
2
3
4
5
6
7
y/
12
13
I 14
15
1.6
17
18
19
20
21
22
I
23
51Y)
;)rr
o
5iri
52
5R
a-
'; c
:>c
,
5d
5
-.4
Sc
"C
5C
s7
�•
1.
L_k�L
-7
_
—�
��
L•
`ir r
sl
SP\
�D
i� t
C
`c-/
l
BORINGS MADE BY 22ain'PP 4 ( /4I SIGNATURE & TITLE C71)
L `i
Z„ rf

•
• .
- • . • ...76 r" •
•
(
•".

7)3 (
EMERGENCY ACTION PLAN
PHONE NUMBERS
DWQ
EMERGENCY MANAGEMENT SYSTEM L110- - t>
SWCD-.v9-
NRCS ice g M6,
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or leave
your property to consider that you have a problem. You should make every effort to ensure that
this does not happen. This plan should be posted in an accessible location for all employees at the
facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions include:
a Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pimp.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
1 December 18, 1996

D: Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b_ Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing
leaks- possible action:
a. Dig a small sump or ditch away from the embankment to catch all seepage, put in a
submersible pump, and pump back to lagoon.
b. If boles are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon bottom as soon
as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f Could a future rain event cause the spill to reach surface waters?
g_ Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality) regional office;
Phone - - . After hours, emergency number: 919-733-3942. Your phone call
should include: your name, facility, telephone number, the details of the incident from. item
2 above, the exact location of the facility, the location or direction of movement of the
spill, weather and wind conditions. The corrective measures that have been under taken,
and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number - -
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number - - , local SWCD office phone number - - , and
local NRCS office for advice/technical assistance phone number - - .
2 December 18, 1996

4: If none of the above works call 911 or the Sheriffs Department and explain your problem to
them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site damage.
a. Contractors Name:
b. Contractors Address:
c. Contractors Phone:
6: Contact the technical specialist who certified the lagoon (MRCS, Consulting Engineer, etc.)
a. Name:
b. Phone: 9.
7: Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.
3 December 18, 1996

insect Control Checklist for Animal Operations
Source Cause BMPs to Control insects Site Specific Practices
Liquid Systems
Flush Gutters
• Accumulation of solids
Flush system is designed and operated
sufficiently to remove accumulated solids from
utters as designed.
Remove bridging of accumulated solids at
discharge
Lagoons and Pits • Crusted Solids
Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8_inches over more than 30% of surface.
Excessive Vegetative
Growth
• Decaying vegetation �3' Maintain vegetative control along banks of
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
Dry Systems
Feeders
• Feed Spillage Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
cumulation of decaying wastage.
❑/Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
uring winter).
Feed Storage • Accumulations of feed residues
Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
Inoisture grain products).
spect for and remove or break up accumulated
solids in filter strips around Feed storage as
needed.
.0 - November 11, 1996, Page 1

Swine Farm Waste Management Odor Control Checklist
Source Cause
BMPs to Minimize Odor Site Specific Practices
Farmstead • Swine production /J Vegetative or ooded buffers;
ommended st management practices;
/Good judgment and common sense
Animal body surfaces • Dirty manure -covered animals
ry floors
Floor surfaces • Wet manure -covered floors
otted floors;
"terers located over slotted floors;
eders at high end of solid floors;
Scrape manure buildup from floors;
0,4lnderfloor ventilation for drying
Manure collection pits • Urine; Frequent manure removal b ush,*1)it recharge,
• Partial microbial decomposition or scrape;
❑ / Underfloor ventilation
Ventilation exhaust fans
Volatile gases;
Dust
Indoor surfaces • Dust
Flush tanks • Agitation of recycled lagoon
liquid while tanks are filling
an maintenance;
Efficient air movement
ashdown between groups of animals;
Feed additives;
7 Feeder covers;
❑ Feed delivery downspout extenders to feeder
,overs
ush tank covers;
Extend fill lines to near bottom of tanks with
anti -siphon vents
Flush alleys
• Agitation during wastewater
conveyance
❑ Underfloor flush with underfloor ventilation
Pit recharge points
• Agitation of recycled lagoon ❑ Extend recharge lines to near bottom of pits
liquid while pits are filling with anti -siphon vents
on hi'
Lift stations
• Agitation during sump tank ❑ Sump tank covers
filling and drawdown
cri!4
Outside drain collection • Agitation during wastewater ❑ Box covers
or junction boxes conveyance
November 11, 1996, Page 3

Source
Standing water around
facilities
Manure tracked onto
public roads from farm
access
Cause
• Improper drainage;
• Microbial decomposition of
organic matter
• Poorly maintained access roads
/BMPs to Minimize Odor
Grade and landscape such that water drains
away from facilities
Site Specific Practices
Farm access road maintenance
Additional Information :
Swine Manure Management ; 0200 Rule/BMP Packet
Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment ; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment ; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage ; EBAE 103-83
Calibration of Manure and Wastewater Application Equipment ; EBAE Fact Sheet
Controlling Odors from Swine Buildings ; PIH-33
Environmental Assurance Program ; NPPC Manual
Options for Managing Odor ; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies ; PRO107, 1995 Conference Proceedings
DATE
l`��✓S'B
TECHNICAL SPECIALISTS DATE
' - November II, 1996, Page 5
Available From :
NCSU, County Extension Center
NCSU - BAE
NCSU - BAE
NCSU - BAE
NCSU -BAE
NCSU - BAE
NCSU - Swine Extension
NC Pork Producers Assoc
NCSU Agri Communications
Florida Cooperative. Extension

Version ---November 26, 2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
❑ 71
El Pi
❑
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Sig
e of Farm Owner/Manager Date
nature of Technical Specialist Date

/
� �perator:�. J. Rivenbark County: Pender Date:
Distance to nearest residence (other thao owne�): 1000.0 feet
1. STEADY STAT� LIVE WEI8HT
/
\
�
~^
0 sows x = 0 |bs
boars x |bs. = 0 |bs
�itters : piSs/fitt�r x |bs./p|3 = 0 |bs
0 sows (farroo to finisb> x 141T |bs. = 0 ibs
sows (farrow to feeder> x 572 }by. = 0 >bs
2500 head (fini�hing on|y) x 135 |bs. = 33750�
TOTAL STE�DY ST�T� LIVE WEI8HT (SSLW) = 337500 |bs
M1NlMUM REQUIRED TREATMENT VOLUME OF LA8OON
Vo|ume = 3375O0 |b�. 5SLW x Treatment Vo|ume(CF}/}b. SSL�
Treatment Vo|ume(CF)/|b. SBLW= 0.00 CF/|b. SSLW
Vo>ume = O.0 cub�c fee�
DESI8N TRE�TMEN� VOLUME
Maintaiu treatment I'm. �iquid |eve( at e|evation feet
8ottom of |agoon e|evation 36.0 feet
La800n size (fur treatment ia800u |iquid vo|ume) usin3 pr|smoda| fnrmu|a
LEN8TH WIDTH SS/END1 SS/END2 SS/SIDEt S�/SIDE2
245.0 165.0 2.5 2.5
ARE4 UF TOP
�IoT� =
245.0 165.0 40�25.O (AREA fD!F TOP}
AREA OF DOTTOM
Lb * Wb ~
190.0 110.0 2090O.O (AREA OF 8QTTOM)
DEP��
11.O
AREA OF MIDS�CTION
(Lm * Wm) *4 =
217.5 13T.5 119625.0 (ARE� OF MIQSECTIGN * 4)
CU' FT. = [AREA TOP + (4«AREA MIDSECTION) + AREA BOTTOM]
4O425.0 119625.0 20900.0 1.83
VOLUME OT TREATMENT LIQUID LEVEL = 331741.T CU. FT.
4. TOp OF LA8UGN ELEVATION (INCLUDES TEMPORARY STOR/�8E��ND FREE8OARD>
P|ace sPoi| as a continuous dike to e|evation 48.0 feet.

/
\
5A.
/
\
/
l
oEMPORARY STORA8E REQUIRED
DRAINA6E A�EA:
La800n (top of dike)
Length
250.0 170.0 61100.0 square
feet
8ui|d1nSs (roof aod |ot water)
Len8th * Width =
0.0 0.0 0.0 sqaare feet
TOTAL DA '61100.0 square feet
Pumpin8 cyc|e to be 180.0 days.
Vo|ume of waste produced
Approximate dai|y prodaction of t tanure in CF/LB SSLW
0.0013�
Vo�ume = 33T500.O Lbs. SSLW * CF of Waste/Lb./Day * 180'0 �ays
Vo|ume = 82012.� cubic feet
Vo1ume of wash water
This is the amouat of fresh water used for washinS LIP, e
of fresh water used for a �|usb system. F�ush systems that recircu|ate
the |aS000 water are accounted for in 5A.
Vo|ume =
Vy|ume =
0.0 8a)|ons/day *
per cu. ft.
0.0 cubic feet
Vo|ume of rainfa|| in excess of evaporation
180 days in cyc|e / 7.48 ga|!or
Use period of timm �h�n ra)nfa|| exceeds evaporation by |ar3est amount.
Rainfa||
Evapor.
Excess ra�nfal| (difference)
=
=
Vo|ume = T.5 in � DA / 1Z inches per foot
Vo|ume = 3818T.5 cubic feet
40.5
71.
I
/ncnes
inches
�nches

/
/
\
/
`
6.
Vo|ume of 25 year - 24 hour storm
Vo|ume = T.5 incbes / 12 inches per foot * �A
�o|ume = 3818T.5 cubic feet
TOTAL REqUIRED TEMpORARY STO�A6E
5A.
58.
82012.5 cubic feet
0.0 cubic feet
3818?.5 cubic foet
38187.5 cubic feet
TOTAL 158387.5 cub|c feet
DEPT� 0F STURA8E REQUIRED (ABOVE LAGOON TREAT�ENT �OLU�E ELEVATlON)
Depth required = Vo\ume of tem;orary storage div|ded by the
avera8e area of the temporary stora8e
Depth requ�red = 158387.5 cub�c feet/ 40425.0 square feet
Depth required = 3'9
Top of dike eYevation =
La800n treat�ent |iquid e}evation =
Depth batween top of dik� and treatment jiquid |eve! =
Deph requ|red =
Freebo8.rd =
Tota1 depth required =
3.9 feet
1.0 feet
4.9 feet
48.0 feet
0.0 feet
48.0 feet
NOTE: IHE DEPTH �ETWEETOF O� LExEP T
TO OR GREATER THAN Tl HE TOTAL DEPTH R�QUIRED, T� N ADEQUATE STORAGE
HAS BEEN PRO�IDEB.
7. LAND APPLIC�TION OF EFFLUENT FOR NITROGEN DISPOSAL
TYPE GF OPERATION :
TYPE OF VE8£TATION :
A�IM�L UNITS :
ACRES / ANIMAL UNIT :
TOTAL ACRES :
�.0o00
0.0
*SEC8NbARY EFFLUENT DI�POSAL AREA*
TYPE 8F OPERATION :
TYPE OF VEGFTATION ;
ANIM�L UNITS :
ANIMAL UNIT :
TOTAL ACRES �
w.o
DESI6NED BYv
Wi|=vn Spencer APPROY�� �Y:
DATE: 1 TE:

f
_7 /
i
U.(9 (i) e
/ 1u /V ti
S--
46/ 23 +C)1g6)0
1/ 9z 2
UUiarye reN
Ads
r /
peri
-7--tfry) 38S
ri,fisba- F-52
--5 -3 -ptq
3 v/ 7 f

} II J
'1:
a f ii111" T.}a�
}I Fin
rI_C�
Tr (y'yt 1 ' : r -'
rrYi'1'�'rrt'i 1
fitr, r
Ft '11 4'}l_
I
T r fI -r
Ii t �.4 .
1 17 j
.,.___ 3Tf --1
1F� I '--111 ra QI - e `I;
jL t I i_--Yrf 1 i1L_i�7'
1 . -
1-- } i i
T 1. 1- _ 1. h- a r _ I i
TI 1 ..r , I _E - - r -Ii_
{
t � rr E-1 'F1.- ! i f II'�
i E..r , I 1 r
d I
l'il4 l I I ,
i
,
Iq'� G!P.1 I I j I
pi , .. 1 r 1 I
1 ! ` �I TAG �� � f
I I
1 1 l LIf
Gs /I
c(1.1.5.reNce,-j,o.

GHrr ■ ; Na b. ,wwiu .arar.. uausmEm11YE. Ewa.a.lM" i1r r�aWWY'}AnlYlnlwoom a Y13 RPINI XEqIl���}1}MEM�a riAGA.
NEMtl 11111WSNEf MEEK INEENMWIWME.IWAMERSIMIE1lrSINI EEEE.NWIW �A111.1rnf1111.1 rri11.11 MEMEMMEENIIMa Eia .....H W111111. drlrra a.a
MM
1om
iEi
plrr i r■ErRYErrglrrNEElrrraErrar#ERnlEEl1EEEHENEaE�,IEEaEIErpY■Yrw alpwYEEgrraErgrmaRrr EaEHnErra
lMIME
.l1NEEHHM.IR. .ENlYa. NEraEINgrEr0Err■}pIYF�ENnEE\pIE�VEBq}IEEEEHNSEElIEwEEEEEE! wEEEtirEEi!}E
■i7g■r■gE'EE EE /lEa NNaEC`�t!yyrrEEEE.ga =ra ErJEEEiwEEwIYS`■E.Ea►r►MEEMEEEE 7 7. 7. 1WW1EiEElg111. riElME �(OHH�EEEr}E
1M1HIIH1F r�ll1MEE71.►lMMiR�Prnspo ,, 'i ' � 'iglRN1Y1N
r li}I/.f47gG}E/E71E►1ElF11•2 grILIWIM IrYENEr�r}Ea ' EEEEE EE INIMEnIYFEEiw EEEwEa GF�r1 Ah^G +�,�r�NErrrEEagE
lElwMEwnEMEMl.l7,'fJ'A•�RyIIJR►;rM1EIpl/NY. ENQEEEEiaE=EEEEH.wRrE}Er ww r7EEE►7EwEnEE WW11{rwEEErmormiEwga mown
rHEaNHMMMMMlifiLMZMMMMMa:EHYfrEiEE1EEE ErairrEsrmmas►� Ep. WWII. EYwr►EyErI1WW1.0 7�Ss 71111 �JKJ'JFrrEf53�K9f�t'y }GEq
■a}r1grNAMAMNrg11r11YrRgEqaIMAIME a/.%Y'lENrwEYNIIIMMEE\'r'�Srrl MME 'CH � E iElrgrq/EEEEaEEEIElEEE.1111.W.11 1
yii13j.Ii9T7;i1r- E/©f=/217,,A,•:1E►dL/.PWAIEC111111 iri/gWA11 RwREgHRYYE 111...11 ..wE•lb7E}EEEHw.7ilsl7lL�aM'17wrErE111W.. ...
f/ ...*A ... ...E renr/Y regamus rans mi w...m...m. lEa4r►.,MMAIII HEEafYlici�GrM`IrYr� jyfrrgYElllAEwa ZMISS p IEE IN=
1/IEYEEEi1E1E .�.Ew\:Oaa...aar.a.EEEE� wYElaaaalM.ri. gErEwYENjE
yH AGEMMIlYrwl�rrs�l�yr]r11FF �rli E.. IIMEMO-AE�illErr 11f ISLE. J11NJLlA.G
- — l.MINEM Y0WWW rrr� w Ji CSYIIEI� N1��YrErEr"��JE ilrli
EE.M.ME.....MM1p1�lrM1 Yni19�j11lEEgEEEYWfaarEE � 7la - aE
1El...n. N�snR.4
Y......qENrraNNlwr{rmigH#EwEEEIEwEwYaErE�.Z!1rWErYY l �r , EminifWYY rEEE
WMOWNElIEw YEaaM.E.M EM..M.na..aH a..■EE/r7lr.I.w�lgrrow. EEEENUMM.aE01/..E,�E!!E•�l1El...--- wEEIw..WWEEEEn:
■EM�EY 9EEE mmalaEp.�EPrrmrrYREwEi1Nl'. H q }wA�y �� E NifIbMiltill.
EYrrEpIE
11111
• lwYEErEBaEgaMMIIIM EEHEEaaa1YYHMEEEgrgwrirqsAi� ■N Mil E7MEL'a\wrENC\YEMNRRRRRR�EP�M1 IF i_MMIAIET:1• 'r'.•'J�JM1HEnCy r+JE11`7,
■wMEaEwrrEagRgNr m MlrlyrNEEEwENEMEENEEwmEWINEEYEwrrgr■Y maansima- ammium wsi qr umwra ammii EmmaimaEflr
moms
W■r�E 111.1 111.11.E :�EYIYHE IEE1:Hglrrrgr Yr'rY�EYr-- Rwp1Hi��jtlEE" Ec¢at�aNE: E11.11. �:Y:MaE:'EHEaEEaEREEEE ■H o r
'•..I..M.EE.NWIEB.M.M.E NEa.........M.......InE IIMONAr1. REAM'..N\'E IENIUM rrrErsmIwwY��t . _w� iria�E.o E�rrrrR ��.
EawaaUE..a1!!l1MaEMwEYE.lEwBM1..E �� +.r�iriMElEw.a.rq
'�YNHppM�AOEgINraNr�q�aaEHr N manaw=mmmos ENeimmir .Ylr MEER..Ma� EEEEM aaw.-s_ 9wM nN,
�rrlragrgq.H i mi..�E r@llwrrr
°EwB1NMM.aiurwwar.. .wrr1 nE .Yla'
alawrirM� wMaEY�M..E1.wM"E ulmu i mi nmi/.ia rem .�a.iH.ir .H:a: wig
gum
EH.HHEYRMMHEE�EO.IEN�E.a]aET�E�ME�Eagrq�:num
�IM�1 �'
r1•rr. M.M.sm.wmaEEEE EE.a!/M.r/a Y�E awY E. �rw. �HE..E �E�E.a...aE.i-
fEE7.iYYwiNaME..a MVP Y •_ EE.{s .EM�•Ur Aral ME
MIEN ., �IN,
#RE�Rra.E...E. 11 1. ..Ea H.Y.iM1MNwrBa 11111 1 aNW .Eis� is - 1w
�.i.ManaEw - E.M. ENE E.LrlaE- iE8F=a.ra�71�a:.wT ..11•7a1
��.1.. WI.wY .rgr,Mq
:•1.1111..Nna �MEE�.E.r�.al.agwwHM EE MYw. mMONala..aliE.ME.aawE.ME..a y�.M.E
iIEa.dgWErw.rrrEEErr YYNHMa.aw MlIE N }.�1gw�e.•.iaa1MarY\7ifYLilE .�.wEN`M�r'
7a.E.Ma� nawaan YYEE4a EE..E� �aaw .wEEanY.wEY1rr1}E.Ea aYYE.aw MM.Mw
:.Hraw.wri.agY.wwwWWEN= E..I grEYrr__ .lEEE.1wE.a�R r:�
• .iR.. 11.wEr.1EaE..r..1.EEEw..YYaYr-- - __ -. nn E...E._
M.ammiu err E■EEEH=E11wEEE\ r1 1q•EwYMHaaa..w.MYaaE O• W� .•
Mr.. ..aYHwEEYaYY aaarrYrrrgrrt YE �E 'w
MII.W rw.RE.rgp.wHwga}waanl...
ErdE
■Eii.IMERABUIgYYwMM MYlgrrNr - m
.NM
ME ..wwwMlY
Mr 1.11
�Y
r'r • AI�1wfwlr— y '
¢' ar.1L7mArEATIMM
s n o �• - .
riarrIMAANO
.alA
ril 4-•0 .n - ..irn�.ar. . - �,
1'
3= w•
w.m
•
1_1
ENr
.1 1
Sv f�
rQr
1-J I?,,,,.1L.%-'
DEPARTMENT OF AGRICULTURE
DU CONSERVATION SERVICE
/ 55

SHEET1 4F 2
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation, Also
included is storage for the 25 yr - 24 hr storm for the location and a
heavy rain factor. The volume of waste generated from a given number
of animals will be fairly constant throughout the year and from year to
year, but excess rainfall will vary from year to year. The heavy rain
factor and 25 yr rainfall will not be a factor to consider in an annual
pumping cycle, but this storage volume must always be available.
The waste produced by the animals shall be utilized in accordance with
an approved waste utilization plan. Highly visible markers shall be
installed to mark the upper and lower elevations of the temporary
storage (pumping volume). Pumping shall be done as necessary to
maintain the liquid level between these markers.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. Before wastes are introduced, the waste treatment lagoon shall be
charged to 1/2 its treatment volume to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solide should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 46.30 as marked by permanent marker. Stop pump --
out when the fluid level reaches elevation 44.30 . This temporary
storage less 25 yr and heavy rain contains 51,663 cubic feet or
386,437 gallons.