710014_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Pennit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Pernrittee.
1. Farm Number: 71-0014 Certificate Of Coverage Number: AWS710014
2. Facility Name: Locklin Farm
3. Landowner's Name (same as on the Waste Management Plan): Locklin Farms LLC
4. Landowner's Mailing Address: PO Box 665
City: Wallace C 1 a . "?..c71� � I-V ((� State: NC Zip: 28466
Telephone Number: 910 205-3079-Ext. E-mail:
5. Facility's Physical Address: 2205 Cypress Creek Rd
City: Maple Hill
6. County where Facility is located: Pender
7. Farm Manager's Name (if different from Landowner):
g. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"):
10. Operator Name (OIC): Floyd Matthew Cavenaugh
11. Lessee's Name (if there is not a Lessee, write "None"):
12. indicate animal operation type and number:
Current Permit: Operations Type
State: NC Zip: 28454
Murphy -Brown LLC
Phone No.: 910-284-2391 OIC N: 990000
Allowable Count
Swine - Feeder to Finish 3,672
Operation Types:
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Fccdcr Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
'Redline"
(inches)
71-04-1
.. l0- I.s..-\
1 D(cSO 11
131�a.5 0
? I . In
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with thi completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
I. The most recent Waste Utilization Plan (WUP), signed by the owner and a certified technical specialist containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

1 attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting infonnation and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name: (----cc &\•n,— .r try 5 Title: 0
Signature: /I /r��l(A/ '%-(� L- Date: \O— 2R— IQ
Name: Title:
Signature: Date:
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

Nutrient Management Plan For Animal Waste Utilization
12-19-2012
This plan has been prepared for:
Locklin Farms
Glen Cavenaugh
PO Box 665
Wallace, NC 28466
910-285-3077
This plan has been developed by:
JASON TURNER
PENDER SWCD
PO BOX 248
801 S. WALKER ST.
BURGAW, NC 28425
9-259-9123 Ext. #3
j4
D eloper Signature
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance procedures
established in this nutrient management plan which includes an animal waste utilization plan for
the farm named above. I have read and understand the Required Specifications concerning animal
waste management that are included with this plan.
Signature (manager or producer)
Date
Date
This plan meets the minimum standards and specifications of the U.S. Department of Agriculture -
Natural Resources Conservation Service or the standard of practices adopted by the Soil and Water
Conservation Commission.
Plan Approved By:
nical Specialist Signature Date
839184 Database Version 3.1 Date Printed: 12-19-2012 Cover Page 1

Nutrients applied in accordance with this plan will be supplied from the following
source(s):
Commercial Fertilizer is not included in this plan.
S7
Swine Feeder -Finish Lagoon Liquid waste generated 3,403,944 gals/year by a 3,672
animal Swine Finishing Lagoon Liquid operation. This production facility has waste
storage capacities of approximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
7840
Incorporated
13464
Injected
14828
Irrigated
8522
Max. Avail.
PAN (lbs) *
Actual PAN
Applied (lbs)
PAN Surplus/
Deficit (lbs)
Actual Volume
Applied (Gallons)
Volume Surplus/
Deficit (Gallons)
Year 1
8,522
9043
-521
3,612,092
-208,148
Note: In source ID, S means standard source, U means user defined source.
* Max. Available PAN is calculated on the basis of the actual application method(s) identified in the plan for this source.
839184 Database Version 3.1 Date Printed: 12-19-2012 Source Page Page 1 of 1

Narrative
This will be a com and small grain cover rotation each year. Bermuda will be grazed and overseeded
small grain. PLAT results showed that field with the Center pivot and H-A 5&6 showed a high
phosphorus ranking. NCSU nutrient management guide shows the trigger number at 200. NCANAT
program flagged at 186 for a deep sample. Recommended that a deep sample be taken in January 2013
and the result will be reentered in the PLAT results for this field.
839184 Database Version 3.1 Date Printed: 12-19-2012 Narrative Page Page 1 of 1

The table shown below provides a summary of the crops or rotations included in this plan for each field. Realistic Yield estimates
are also provided for each crop in the plan. In addition, the Leaching Index for each field is shown, where available.
Planned Crops Summary
Tract
Field
Total
Acres
Useable
Acres
Leaching
Index (LI)
Soil Series
Crop Sequence
RYE
7046
A-1
4.07
4.07
2.0
Grifton
Corn, Grain
110 bu.
Small. Grain Cover
N/A
7046
A-5&6
5.71
5.71
2.0
Grifton
Hybrid Bermudagrass Pasture
4.0 Tons
Small Grain Overseed
1.0 Tons
7046
A -Center P
12.18
12.18
2.0
Grifton _
Hybrid Bermudagrass Pasture
4.0 Tons
Small Grain Overseed -
1.0 Tons
7046
B 1-4
15.73
15.73
2.0
Grifton
Com, Grain
110 bu.
Small Grain Cover
N/A
7046
C 1-4
18.34
18.34
2.0
Grifton
Com, Grain
110 bu.
Small Grain Cover
N/A
7046
D 1-4
10.79
10.79
2.0
Grifton
Com, Grain
110 bu.
Small Grain Cover
N/A
PLAN TOTALS: 66.82 66.82
LI.
Potential Leaching -
Technical Guidance
< 2
Low potential to contribute to soluble
nutrient leaching below the root zone.
None
�— 2 &
<= 10
Moderate potential to contribute to soluble
nutrient leaching below the root zone.
Nutrient Management (590) should be planned.
10
High potential to contribute to soluble
nutrient leaching below the root zone.
Nutrient Management (590) should be planned. Other conservation practices that improve the soils
available water holding capacity and improve nutrient use efficiency should be considered.
Examples are Cover Crops (340) to scavenge nutrients, Sod -Based Rotations (328), Long -Term
No -Till (778), and edge -of -field practices such as Filter Strips (393) and Riparian Forest Buffers.
(391).
839184 Database Version 3.1 Date Printed 12/19/2012
NOTE: Symbol * means user entered data.
PCS Page Page 1 of 1

U
79,
led O' a
T
.0 „CO
U ea O
p ▪ 5 N
ro ro
o. ro
U T a
5 a a
Q
T ° id
a d 'a
v 4)
00 C
a U
En•O 0
.5w
.O U
❑
O 00 'g
N Q 'd
O CO
ap5
� • .3'S
o
g
a)
✓ .
pgp .b s
01a b '
W O g
no 14
.5 O
0
• 4` o
O y O
Y a
U
• C faBj)
p W F .d
a)29
O
a'.
N
O� Q O
U
W O *5 P. o p O
G 7
O' 6 D
t2
v Q
ro
v • v
ro a
5 . .4
N M U
"g
✓ ti 4-1
•• • •N 0
O Eo
.�
• '8 ❑
• N .r
00 0 o o
tt O 0
N
.0
F
0
N
3
9 7 9 v
N N aL1V
tons
0
O
O
0.00
0
O
°I
0.00
0.
O
O
0
O
O
0.00
0
O
O
0
O
O
0
O
O
0
O
O
O
O
O
_
'> >$ '�
i Q v
O
0
vNl
�..
0
d
n
T
N
O
.d.
..+
632.481
ND
N
d
N
590.62
CO
0
h
688.621
et
co
V
O
y
n
O
.-
m
q ,g'i
p G �v
a
4,
0
O
O
0
O
O
0
O
O
0
O
O
0
O
O
0
O
O
0
O
O
0
O
O
0
0
O
0
O
O
0
O
O
o
O
O
o u p
o A
a
„
N
n
CIl1
O.
0:
CI
—
0
N
CA
a
NI
CI
CT
o:
N
vt
enn
ON
ON
d
0
V)
N
CI
CT
0.:
WI
in
N
.n
0,a
0,
0'
o s
oa'1u ..
Z
0
N
O
en
O
Ln
O
en
CDon
Lel
N
P
N
P
Ln
N
74.f.
A..g..g
i
..
g
)0 � p
z
N
O
O
O
O
O
N
0
N
O
N
O
u
E. g' .
O.Z
U d Z Q C
o
0
0
0
0
0
0
0
0
0
0
0
9 a E �''ir
L ° c
z Z
Q
N
0
vOi
O
N
P
if,N.
a
N
N
d 'S
a 6
0
n
`5
..
N
-
en
n
^
T
0
en
m
n
..
'-"
'^
.-
0
`n
m
n
...
-'
'
r
0
O
`--
`?
..
m
n
r
[i`
0
'n
.-.
N
„
n
n
G'
0
--
'4
..
..
M
n
_S
T
«
JD
2
—
a
z
co
6
F
o
0
d
F
0
_
2
..
a.0
z
2
..
a
Z
a
2
..
a
z
e'
0
Com, Grain
Small Grain Cover
Hybrid Bermudagrass Pasture
Small Grain Overseed
Hybrid Bermudagrass Pasture
t
Id
Opp
V
Tei
Com, Grain
Small Grain Cover
Corn, Grain
1Small Grain Cover
Com, Grain
Small Grain Cover
6
o
<
O
d
N
vl
N
vi
-
(V
00
ei
N
H
r
hd9
m
M
ro
N
O
T
O
o o
N
o
d
tO
d
vi
vi
h
vi
00
N
ao
N
nn
.
n
1-
y
d
n
m
d
n
o0
T
n
o
T
r
d
E
•/)
O
cac
7
O
O
a
O
U
!
O
x
CC
O
a
CCV
O
a
O
s
U
a
O
ar
UU
O
a
U
K Q
v)
t-
v)
!
v)
n
an
)
N
v)
N
N
c-
co,
N
v)
t-
v)
n
V)
n
N
N
V)
.
a
<
<
a
aY
Li a
CO
0
0
o
n
m
E;
0
d
o
N
0
et
00
N
0
et
0
d
0
b
et
0
0
et
0
0
et
0
0
et
0
0
et
0
b
et
0
0
d
0
0
et
0
.-1
0
ON
N
Z
A
Database Version 3.1

d
v e
o g da
o F, aw
'.:,0-71
tons I
0
0
o
0
0
0
0
0
0
q
q= V p
'cIrC
R m
rn
o
N
3,403.94
r
0.
eth'IL
Q
O
o
b
n
0
N
uj �i QP' v
F
g
ITotal Applied, 1000 gallons
Total Produced, 1000 gallons
O�
O
a'3i
w
i
5.
QQ
Total Produced, tons
G
o552m
a
o
$
az'aG
z
.
a'
Ea
c
z
• v^
E t'6 as
o z'ac
z
gabs
z�C-tt
z
z
sb
:-.0
as
r
a
6
VPi
L p
3 Q
O
F Q
iti
00
O
h
d
0
h
v
iit
1.5
WUT Page Page 2 of 2
Date Printed: 12/19/2012
tri
Database Ver
rn
Cr)

The Irrigation Application Factors for each field in this plan are shown in the following table. Infiltration rate varies with soils. If
applying waste nutrients through an irrigation system, you must apply at a rate that will not result in runoff. This table provides the
maximum application rate per hour that may be applied to each field selected to receive wastewater. It also lists the maximum
application amount that each field may receive in any one application event.
Irrigation Application Factors
Tract
Field
Soil Series
Application Rate
(inches/hour)
Application Amount
(inches)
7046
A-1
Grifton
0.40
1.0
7046
A-5&6
Grifton
0.40
1.0
7046
A -Center P
Grifton
0.40
1.0
7046
B 1-4
Grifton
0.40
1.0
7046
C 1-4
Grifton
0.40
1.0
7046
D 1-4
Grifton
0.40
1.0
839184 Database Version 3.1 Date Printed 12/19/2012 IAF Page Page 1 of 1
NOTE: Symbol * means user entered data.

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for sludge
utilization for the indicated accumulation period. These estimates are based on average nitrogen concentrations for each source,
the number of animals in the facility and the plant available nitrogen application rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At clean out, this
material must be utilized for crop production and applied at agronomic rates. In most cases, the priority nutrient is nitrogen but
other nutrients including phosphorous, copper and zinc can also be limiting. Since nutrient levels are generally very high,
application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be used for
sludge application. If this is not possible, care should be taken not to load effluent application fields with high amounts of
copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water moving to streams and lakes,
phosphorous is a concem. Soils containing very high phosphorous levels may also be a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
lb/ac
Maximum Sludge
Application Rate
1000 gal/ac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Feeder -Finish Lagoon Sludge - Standard
Com 120 bu
150
13.16
46.03
- 92.07
138.10
Hay 6 ton R.Y.E.
300
26.32
23.02
46.03
69.05
Soybean 40 bu
160
14.04
43.16
86.31
129.47
839184 Database Version 3.1 Date Printed: 12-19-2012 Sludge Page Page 1 of

,
The Available Waste Storage Capacity table provides an estimate of the number of days of storage capacity available
at the end of each month of the plan. Available storage capacity is calculated as the design storage capacity in days
minus the number of days of net storage volume accumulated. The start date is a value entered by the user and is
defined as the date prior to applying nutrients to the first crop in the plan at which storage volume in the lagoon or
holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design storage
capacity of the facility. If the available storage capacity is greater than the design storage capacity, this indicates that
the plan calls for the application of nutrients that have not yet accumulated. If available storage capacity is negative,
the estimated volume of accumulated waste exceeds the design storage volume of the structure. Either of these
situations indicates that the planned application interval in the waste utilization plan is inconsistent with the
structures temporary storage capacity.
Available Waste Stora¢e Canaci
Source Name
Swine Feeder -Finish Lagoon Liquid
Design Storage Capacity (Days)
Start Date
9/1
180
Plan Year
Month
Available Storage Capacity (Days) *
1
1
46
1
2
38
1
3
52
1
4
76
1
5
124
1
6
180
1
7
174
1
8
153
1
9
131
1
10
110
1
11
98
1
12
79
* Available Storage Capacity is calculated as of the end of each month.
839184 Database Version 3.1 Date Printed: 12-19-2012 Capacity Page Page 1 of 1

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during operation
or land application. Any discharge of waste that reaches surface water is
prohibited.
2. There must be documentation hi the design folder that the producer either owns
or has an agreement for use of adequate land on which to properly apply the
waste. If the producer does not own adequate land to properly dispose of the
waste, he/she shall provide evidence of an agreement with a landowner, who is
within a reasonable proximity, allowing him/her the use of the land for waste
application. It is the responsibility of the owner of the waste production facility to
secure an update of the Nutrient Management Plan when there is a change in the
operation, increase in the number of animals, method of application, receiving
crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for
realistic crop yields based upon soil type, available moisture, historical data,
climatic conditions, and level of management, unless there are regulations that
restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year.
Waste may be applied to land eroding at more than 5 tons per acre per year but
less than 10 tons per acre per year provided grass filter strips are installed where
runoff leaves the field (see USDA, NRCS Field Office Technical Guide Standard
393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste application.
Waste should not be applied when there is danger of drift from the land
application field.
6. When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to
conservation tilled crops or grassland, the waste may be broadcast provided the
application does not occur during a season prone to flooding (see "Weather and
Climate in North Carolina" for guidance).
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such
that runoff does not occur offsite or to surface waters and in a method which does
not cause drift from the site during application. No ponding should occur in order
to control odor and flies.
839184 Database Version 3.1 Date Printed: 12/19/2012 Specification Page 1

17. A protective cover of appropriate vegetation will be established on all disturbed
areas (lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as
necessary, to protect the vegetation. Vegetation such as trees, shrubs, and other
woody species, etc., are limited to areas where considered appropriate. Lagoon
areas should be kept mowed and accessible. Berms and structures should be
inspected regularly for evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate
the possibility of an illegal discharge, pollution, and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a
regular basis to prevent breakdowns, leaks, and spills. A regular maintenance
checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops
for direct human consumption. However, if animal waste is used on crops for
direct human consumption, it should only be applied pre -plant with no further
applications of animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom elevations of
the temporary storage (pumping volume) of all waste treatment lagoons.
Pumping shall be managed to maintain the liquid level between the markers. A
marker will be required to mark the maximum storage volume for waste storage
ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the
rate -determining nutrient, unless other restrictions require waste to be applied
based on other nutrients, resulting in a lower application rate than a nitrogen
based rate. Zinc and copper levels in the soils shall be monitored and alternative
crop sites shall be used when these metals approach excessive levels. pH shall be
adjusted and maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of five years. Poultry dry waste application
records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for five (5)
years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
839184 Database Version 3.1 Date Printed: 12/19/2012 Specification Page 3

The following crop note applies to field(s): A-5&6, A -Center P
Bermudagrass CP, Mineral Soil, Poorly Drained to Somewhat Poorly Drained.
Adaptation: Effective artificial drainage MUST be in place to achieve Realistic Yield Expectations
provided for these soils.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs 1" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and notallowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization
of Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance.
The following crop note applies to field(s): A-1, B 1-4, C 1-4, D 1-4
Small Grain Cover Crop
839184 Database Version 3.1 Date Printed: 12-19-2012 Crop Note Page Page 2 of 2

r uno3aapuo.
0

ZTOZ/6I/ZI xdse lnpwud/saaeidulas,;uudaiis/sBmau/na'au,S;unoa.mpuad•st2//:dpti
O611 EZd TOO :s3007 XVl
VII :3NOZ
USN :NOISIAIOens
00.OS :301VA a3LH3d3O
00'965'SST3 :311VA 1V101
00'OS :an -nut ONIalII18
00.965'S8TS :3/11VA ONV1
68'001 :53113V
A110H :3530 HSNJ
OTT :dIHSNM01
000000'TET/06 :1140033V
Z£OOTV00 :111ld
00'000'080 :37I1Id 31VS
600Z/ET/C :31VO
A3AU05 311 d8C B S3WVC OdVHDIII
Z£/T6 9d Z dL :NO1dIu7S3o Al113dOHd
ON N33d3 55311dA7 :SS3HOOV Ald3d011d
9998Z:dIZ
7N :31VsS
33V11VM :AlI7
599 XO9 Od :NOW/
III SWBVd NI1N301 :315VN
0000-6E5Z-50-66E£ :NId
000T:T :ale3S
13o i o5ed
dew

Z I OZ/6 I/Z I xdse•Inp;uud/somiduuaDuud/alIs/ST2mau/nog out<i;unoa.Iapuad•st8//:duq
71,11-11109
000T:T :eleas
IJoIaged
dew

h- >. G-15-2005 09:28 FROM:PENDER SWCD OFFICE 9102591505 TO:919102933138 P.1
RECALCULATED VOLUMES WISED ON 1.0 FEET OF FREEBOARD
Operator: JBP LLC. County: Pender Date: 08/15/05
Distance to nearest residence (other than owner): 1500.0 feet
1. AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish) x 1417 lbs. = 0 Ibs
0 sows (farrow to feeder) x 522 lbs. = 0 Ibs
3600 head (finishing only) x 135 lbs. 4116000 lbs
0 sows (farrow to wean) x 433 lbs. = 0 Ibs
0 head (wean to feeder) x 30 Ibs. = 0 Ibs
Describe other : 0
Total Average Live Weight = 486000 Ibs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 486000 Ibs. ALW x Treatment Volume(CF)/Ib. ALW
Treatment Volume(CF)/Ib. ALW = 1 CF/Ib. ALW
Volume = 488000 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
As
�M/
n to
SLUDGE ACCUMULATION NOT COMPUTED
Volume = 0.0 cubic feet AT OWNERS REQUEST. REMOVE SLUDGE
AS NEEDED.
4. TOTAL DESIGNED VOLUME
Inside top length (feet)
Inside top width (feet) —
Top of dike elevation (feet) --------
Bottom of lagoon elevation (feet)---------
• Freeboard jfeet)------------------
Side slopes (inside lagoon) ---------
Total design volume using prismoidal formula
375.0
350.0
49.8
39.2
to it
2.5 : 1
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
2,5 2.5 2.5 2.5 370.0 345.0 9.6
AREA OF TOP
LENGTH *WIDTH 2.-
370.0 345,0
AREA OF BOTTOM
LENGTH ° WIDTH =
322.0 297.0
AREA OF MIDSECTION
LENGTH *WIDTH ° 4
346.0 321.0
127650 (AREA OF TOP)
95634 (AREA OF BOTTOM)
444264 (AREA OF MIDSECTION *4)

°RUG-15-2005 09:29 FRM1:PENDER SNCD OFFICE 9102591505
TO:919102917138 P.2
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTHI6
127650.0 444264.0 95634.0
1.6
Total Designed Volume Available = 1068077 CU. FT.

RUG-15-2005 09:29 FROM:PENDER SWCD OFFICE 9102591505
TO:919102933138 P.3
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length • Width =
375.0 350.0 131250.0 square feet
Buildings (roof and lot water)
0.0 square feet
TOTAL DA 131250.0 square feet
Design temporary storage period to riod to b e
5A. Volume of waste produced
Feces & urine production in gal./day per 135 Ib. ALW
Describe this area.
180 days.
1.37
Volume = 486000 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume a 887760 gals. or 118684.5 cubic feet
5B. Volume of wash water
this is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume =
Volume = 0.0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall 7.0 inches
Volume L. 7.0 in DA / 12 inches per foot
Volume = 76562.5 cubic feet
0.0 gallons/day • 180 days storage/7.48 gallons
per CF

RUG-15-2005 09:29 FRON:PENDER SWCD OFFICE 9102591505
TO:919102933138 P.4
5D. Volume of 25 year - 24 hour storm
Volume = 8.0 inches/ 12 inches per foot * DA
Volume = 87500.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 118684 cubic feet
5B. 0 cubic feet
5C. 76563 cubic feet
5D. 87500 cubic feet
TOTAL 282747 cubic feet
6. SUMMARY
Temporary storage period=====_______=====___> 180 days
Rainfall in excess of evaporation > 7.0 inches
25 year - 24 hour rainfall > 8.0 inches x-
Freeboard======_ _---_ _ > 1.0 feet
Side slopes = __________> 2.5 : 1
Inside top length=====__= 375.0 feet
Inside top width== =___== > 350.0 feet
Top of dike elevation==-= > 49.8 feet
Bottom of lagoon elevation =___==___> 39.2 feet
Total required volume- = _______> 766747 cu. ft.
Actual design volume=== > 1068077 cu. ft.
Seasonal high watertable elevation (SHWT)===> 45.2 feet
Stop pumping elev.=== == =___=> 45.2 feet
Must be > or = to the SHWT elev. > 45.2 feet
Must be > or = to min. req. treatment el.=> 45.2 feet
Required minimum treatment volume==========> 488000 cu. ft.
Volume at stop pumping elevation =____> 631314 cu. ft.
Start pumping elev.=--------__ > 48.0 feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall==> 980577 cu. ft.
Volume at start pumping elevation > 967097 cu. ft.
Required volume to be pumped > 195247 cu. ft.
Actual volume planned to be pumped -----___-> 335783 cu. ft.
7. RECALCULATED BY: - b..s n... _
DATE:
l5-65
e
•
•

11- It-r
System Calibration
Information presented in manufacturer's charts are based on average operation
conditions with relatively new equipment. Discharge rates and application rates change
over time as equipment gets older and components wear. In particular, pump wear tends
to reduce operating pressure and flow. With continued use, nozzle wear results in an
increase in the nozzle opening which will increase the discharge rate while decreasing the
wetted diameter.
You should be aware that operating the system differently than assumed in the design will
alter the application rate, diameter of coverage, and subsequently the application
uniformity. For example, operating the system with excessive pressure results in smaller
droplets, greater potential for drift, and accelerates wear of the sprinkler nozzle. Clogging
of nozzles can result in pressure increase. Plugged intakes or crystallization of mainlines
will reduce operating pressure. Operating below design pressure greatly reduces the
coverage diameter and application uniformity.
For the above reason, you should calibrate your equipment on a regular basis to ensure
proper application rates and uniformity. Calibration at least once every three years is
recommended. Calibration involves collecting and measuring flow at several locations in
the application area. Any number of containers can be used to collect flow and
determine the application rate. Rain gauges work best because they already have a
graduated scale from which to read the application amount without having to perform
additional calculations. However, pans, plastic buckets, jars, or anything with a uniform
opening and cross-section can be used provided the liquid collected can be easily
transferred to a scaled container for measuring.
For stationary sprinklers, collection containers should be located randomly throughout the
application area at several distances from sprinklers. For traveling guns, sprinklers
should be located along a transect perpendicular to the direction of pull. Set out
collection containers 25 feet apart along the transect on both sides of the gun cart. You
should compute the average application rate for all nonuniformity of the application. On a
windless day, variation between containers of more than 30 percent is cause for concern.
You should contact your irrigation dealer or technical specialist for assistance.
`Reprinted for Certification Training for Operations of Animal Waste Management Systems Manual
1

OPERATION & MAINTENANCE PLAN
Proper lagoon management should be a year-round priority. It is especially important to manage
levels so that you do not have problems during extended rainy and wet periods.
Maximum storage capacity should be available in the lagoon for periods when the receiving crop is
dormant (such as wintertime for bermudagrass) or when there are extended rainy spells such as a
thunderstorm season in the summertime. This means that at the first sign of plant growth in the
later winter / early spring, irrigation according to a farm waste management plan should be done
whenever the land in dry enough to receive lagoon liquid. This will make storage space available in
the lagoon for future wet periods. In the late summer / early fall the lagoon should be pumped down
to the low marker (see Figure 2-1) to allow for winter storage. Every effort should be made to
maintain the lagoon close to the minimum liquid level as long as the weather and waste utilization
plan will allow it.
Waiting until the lagoon has reached its maximum storage capacity before starting to irrigated does
not leave room for storing excess water during extended wet periods. Overflow from the lagoon for
any reason except a 25-year, 24-hour storm is a violation of state law and subject to penalty action.
The routine maintenance of a lagoon involves the following:
• Maintenance of a vegetative cover for the dam. Fescue or common bermudagrass
are the most common vegetative covers. The vegetation should be fertilized each
year, if needed, to maintain a vigorous stand. The amount of fertilized applied
should be based on a soils test, but in the event that it is not practical to obtain a
soils test each year, the lagoon embankment and surrounding areas should be
fertilized with 800 pounds per acre of 10-10-10, or equivalent.
Brush and trees on the embankment must be controlled. This may be done by
mowing, spraying, grazing, chopping, or a combination of these practices. This
should be done at least once a year and possibly twice in years that weather
conditions are favorable for heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the herbicide must not be allowed to enter the lagoon
water. Such chemicals could harm the bacteria in the lagoon that are treating the waste.
Maintenance inspections of the entire lagoon should be made during the initial filling of the lagoon
and at least monthly and after major rainfall and storm events. Items to be checked should include,
as a minimum, the following:
Waste Inlet Pipes, Recycling Pipes, and Overflow Pipes -- look for:
1. separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes
2

Lagoon surface -- look for:
1. undesirable vegetative growth
2. floating or lodged debris
Embankment -- look for:
1. settlement, cracking, or "jug" holes
2. side slope stability -- slumps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack or vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the lagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dam. If your lagoon
has any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a
threat of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps -- check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, or a large amount of vibration, may indicate that the pump is in need of repair or
replacement.
NOTE: Pumping systems should be inspected and operated frequently enough so that
you are not completely "surprised" by equipment failure. You should perform your
pumping system maintenance at a time when your lagoon is at its low level. This will
allow some safety time should major repairs be required. Having a nearly full lagoon is
not the time to think about switching, repairing, or borrowing pumps. Probably, if your
lagoon is full, your neighbor's lagoon is full also. You should consider maintaining an
inventory of spare parts or pumps.
• Surface water diversion features are designed to carry all surface drainage
waters (such as rainfall runoff, roof drainage, gutter outlets, and parking lot
runoff) away from your lagoon and other waste treatment or storage
structures. The only water that should be coming from your lagoon is that
which comes from your flushing (washing) system pipes and the rainfall that
hits the lagoon directly. You should inspect your diversion system for the
following:
1. adequate vegetation
2. diversion capacity
3. ridge berm height
3

Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an overflow problem from a surface water diversion or there may be seepage into
the lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before waste
loading begins, taking care not to erode lining or bank slopes.
3. Drainpipes into the lagoon should have a flexible pipe extender on the end of the
pipe to discharge near the bottom of the lagoon during initial filling or another
means of slowing the incoming water to avoid erosion of the lining.
4. When possible, begin loading new lagoons in the spring to maximize bacterial
establishment (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon liquid
volume. This seeding should occur at least two weeks prior to the addition of
wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below 7.0, add
agricultural lime at the rate of 1 pound per 1000 cubic feet of lagoon liquid volume
until the pH rises above 7.0. Optimum lagoon liquid pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate biological
activity. Consultation with a technical specialist is recommended if these
conditions occur for prolonged periods, especially during the warm season.
Loading:
The more frequently and regularly that wastewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily
are optimum for treatment. Pit recharge systems, in which one or more buildings are
drained and recharged each day, also work well.
4

• Practice water conservation --- minimize building water usage and spillage from
leaking waterers, broken pipes and washdown through proper maintenance and water
conservation.
• Minimize feed wastage and spillage by keeping feeders adjusted. This will reduce the
amount of solids entering the lagoon.
Management:
• Maintain lagoon liquid level between the permanent storage level and the full
temporary storage level.
• Place visible markers or stakes on the lagoon bank to show the minimum liquid level
and the maximum liquid level. (Figure 2-1).
• Start irrigating at the earliest possible date in the spring based on nutrient
requirements and soil moisture so that temporary storage will be maximized for the
summer thunderstorm season. Similarly, irrigate in the late summer / early fall to
provide maximum lagoon storage for the winter.
• The lagoon liquid level should never be closer than 1 foot to the lowest point of the
dam or embankment.
• Don not pump the lagoon liquid level lower than the permanent storage level unless
you are removing sludge.
• Locate float pump intakes approximately 18 inches underneath the liquid surface and
as far away from the drainpipe inlets as possible.
• Prevent additions of bedding materials, long-stemmed forage or vegetation, molded
feed, plastic syringes, or other foreign materials into the lagoon.
• Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed.
• Maintain strict vegetation, rodent, and varmint control near lagoon edges.
• Do not allow trees or large bushes to grow on lagoon dam or embankment.
• Remove sludge from the lagoon either when the sludge storage capacity is full or
before it fills 50 percent of the permanent storage volume.
• If animal production is to be terminated, the owner is responsible for obtaining and
implementing a closure plan to eliminate the possibility of a pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:
5

• proper lagoon sizing,
• mechanical solids separation of flushed waste,
• gravity settling of flushed waste solids in an appropriately designed basin, or
• minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long term will:
• have more nutrients,
• have more odor, and
• require more land to properly use the nutrients.
Removal techniques:
• Hire a custom applicator.
• Mix the sludge and lagoon liquid with a chopper - agitator impeller pump through large -
bore sprinkler irrigation system onto nearby cropland; and soil incorporate.
• Dewater the upper part of lagoon by irrigation onto nearby cropland or forageland; mix
remaining sludge; pump into liquid sludge applicator; haul and spread onto cropland or
forageland; and soil incorporate.
• Dewater the upper part of lagoon by irrigation onto nearby cropland or forageland;
dredge sludge from lagoon with dragline or sludge barge; berm an area beside lagoon
to receive the sludge so that liquids can drain back into lagoon; allow sludge to
dewater; haul and spread with manure spreader onto cropland or forageland; and soil
incorporate.
Regardless of the method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that field and crop
requirement. Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage.
Close attention by the pumper or drag -line operator will ensure that the lagoon liner
remains intact. If you see soil material or the synthetic liner material being disturbed, you
should stop the activity immediately and not resume until you are sure that the sludge can
be removed without liner injury. If the liner is damaged it must be repaired as soon as
possible.
Sludge removed from the lagoon has a much higher phosphorus and heavy metal content
than liquid. Because of this it should probably be applied to land with low phosphorus and
metal levels, as indicated by a soil test, and incorporated to reduce the chance of erosion.
Note that if the sludge is applied to fields with very high soil -test phosphors, it should be
applied only at rates equal to the crop removal of phosphorus. As with other wastes,
always have your lagoon sludge analyzed for its nutrient value.
6

The application of sludge will increase the amount of odor at the waste application site.
Extra precaution should be used to observe the wind direction and other conditions which
could increase the concern of neighbors.
Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned discharge of wastewater from the structure.
Types of failures include leakage through the bottom or sides, overtopping, and breach of
the dam. Assuming proper design and construction, the owner has the responsibility for
ensuring structure safety. Items which may lead to lagoon failures include:
• Modification of the lagoon structure -- an example is the placement of a pipe in the dam
without proper design and construction. (Consult an expert in lagoon design before
placing any pipes in dams.)
• Lagoon liquid levels -- high levels are a safety risk.
• Failure to inspect and maintain the dam.
• Excess surface water flowing into the lagoon.
• Liner integrity -- protect from inlet pipe scouring, damage during sludge removal, or
rupture from lowering lagoon liquid level below groundwater table.
NOTE: If lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the dam. Once this damage starts, it can quickly cause a large
discharge of wastewater and possible dam failure.
7

EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ)
EMERGENCY MANAGEMENT SERVICES (EMS)
SOIL AND WATER CONSERVATION DISTRICT (SWCD)
NATURAL RESOURCES CONSERVATION SERVICE (NRCS)
COOPERATIVE EXTENSION SERVICE (CES)
Gto - as°- tato
qlo-a99-9tz3
ono �sq �tz3
cto - a5q - t)-35
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location
for all employees at the facility. The following are some action items you should take.
B.
Stop the release of wastes. Depending on the situation, this may or may not be possible. Suggested
responses to some possible problems are listed below.
Lagoon overflow - possible solutions are:
a) Add soil to berm to increase elevation of dam.
b) Pump wastes to fields at an acceptable rate.
c) Stop all flow to the lagoon immediately.
d) Call a pumping contractor.
e) Make sure no surface water is entering lagoon.
Runoff from waste application field -actions include:
a) Immediately stop waste application.
b) Create a temporary diversion to contain waste.
c)
d)
e)
Incorporate waste to reduce runoff.
Evaluate and eliminate the reason(s) that cause the runoff.
Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers - action include:
a) Stop recycle pump.
b) Stop irrigation pump.
c) Close valves to eliminate further discharge.
d) Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators - action include:
a) Stop recycle pump.
b) Stop irrigation pump.
c) Make sure siphon occurs.
d) Stop all flow in the house, flush systems, or solid separators.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing leaks -
possible action:
a) Dig a small sump or ditch from the embankment to catch all seepage, put in a submersible
pump, and pump back to lagoon.
b) If holes are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
c) Have a professional evaluate the condition of the side walls and the lagoon bottom as soon
as possible.
8

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone #, After hours,
emergency number: [phone]. Your phone call should include: your name, facility
number, telephone number, the details of the incident from item 2 above, the exact
location of the facility, the location or direction of the movement of the spill, weather and
wind conditions. The corrective measures that have been under taken, and the
seriousness of the situation.
b. If the spill leaves property or enters surface waters, call local EMS phone number.
c. Instruct EMS to contact local Health Department.
d. Contact CE's phone number, local SWCD office phone number and the local NRCS
office for advice / technical assistance phone number.
If none of the above works call 911 or the Sheriff's Department and explain your problem to
them and ask the person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair or problem to minimize offsite damage.
a. Contractors Name: Murphy Brown, LLC
b. Contractors Address: P.O. Box 856, Warsaw, NC 28398
c . Contractors Phone: [phone]
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting Engineer, etc.)
a. Name: Kraig Westerbeek
b. Phone: (910) 293 - 5330
Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems
with release of wastes from happening again.
9

INSECT CONTROL CHECKLIST FOR ANIMAL OPERATIONS
Source Cause BMP's to Minimize Odor Site Specific Practices
(Liquid Systems)
Flush Gutters Accumulation of solids
(✓) Flush system is designed and operated
sufficiently to remove accumulated
solids from gutters as designed.
( ) Remove bridging of accumulated solids at
discharge
Lagoons and Pits Crusted Solids
(✓) Maintain lagoons, settling basins and
pits where pest breeding is apparent to
minimize the crusting of solids to a depth
of no more than 6-8 inches over more than
30% of surface.
Excessive Decaying vegetation (V)Maintain vegetative control along banks of
Vegetative Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along waters edge on impoundment's perimeter.
(Dry Systems)
Feeders Feed Spillage () Design, operate and maintain feed systems (e.g..
bunkers and troughs) to minimize the accumulation
of decaying wastage.
() Clean up spillage on a routine basis (e.g. 7-10 day
interval during summer; 15-30 day interval during winter).
Feed Storage Accumulation of feed
residues
() Reduce moisture accumulation within and around
immediate perimeter of feed storage areas by
insuring drainage away from site and/or providing
adequate containment (e.g., covered bin for
brewers grain and similar high moisture grain
products).
() Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed.
Animal Holding Accumulation of animal () Eliminate low area that trap moisture along fences
Areas wastes and feed wastage and other locations where waste accumulates and
disturbance by animals is minimal.
() Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(Le. inspect for and remove or break up accumulated
solids as needed).
MIC — November 11, 1996
10

Dry Manure Handling Accumulations of animal () Remove spillage on a routine basis (e.g. 7-10 day
Systems wastes interval during summer; 15-30 days interval during
winter) where manure is loaded for land application
or disposal.
() Provide for adequate drainage around manure stockpiles
() Inspect for and remove or break up accumulated wastes
in filter strips around stockpiles and manure handling
areas as needed.
The issues checked () pertain to this operation. The landowner / integrator agrees to use
sound judgment in applying insect control measures as practical.
I certify the aforementioned insect control Best Management Practices have been
reviewed with me.
(Landowner Signature)
For more information contact the Cooperative Extension Service, Department of Entomology, Box
7613, North Carolina State University, Raleigh, NC 27695-7613.
AMIC -- November 11, 1996
11

SWINE FARM WASTE MANAGEMENT ODOR CONTROL CHECKLIST
Source
Cause
BMP's to Minimize Odor Site Specific Practices
Farmstead
Swine production
(V)Vegetative or wooded buffers:
(1)Recommended best management
practices;
(V)Good judgment and common sense
Animal body
surfaces
Dirty manure
covered animals
( )Dry floors
Floor surfaces Wet manure -covered
floors
(1)Slotted floors;
(1)Waterers located over slotted floors;
(V)Feeders at high end of solid floors;
(v)Scrape manure buildup from floors;
( )Underfloor ventilation for drying
Manure collection Urine
pits
Partial microbial
decomposition
(V)Frequent manure removal by flush, pit
recharge or scrape
( )Underfloor ventilation
Ventilation
exhaust fans
Volatile gases
Dust
(v)Fan maintenance;
(V)Efficient air movement
Indoor surfaces Dust
(✓)Washdown between groups of animals
( )Feed additives;
( )Feeder covers;
( )Feed delivery downspout extenders to
feeder covers
Flush Tanks
Agitation of recycled
lagoon liquid while tanks
are filling
( )Flush tank covers
( )Extend fill lines to near bottom of tanks
with anti -siphon vents
Flush alleys
Agitation during waste ( )Underfloor flush with underfloor
water conveyance ventilation
Pit recharge
points
Agitation of recycled
lagoon liquid while pits
are filling
( )Extend recharge lines to near bottom of
pits with anti -siphon vents
Lift stations
Agitation during sump ( )Sump tank covers
tank filling and drawdown
Outside drain
collection or
junction boxes
Agitation during waste
water conveyance
( )Box Covers
End of drain Agitation during waste
pipes at lagoon water
( )Extend discharge point of pipes
underneath lagoon liquid level
Lagoon surfaces
Volatile gas emissions
Biological mixing
Agitation
(V)Proper lagoon liquid capacity
(V)Correct lagoon startup procedures
( )Minimum surface area -to -volume ratio
(1)Minimum agitation when pumping
( )Mechanical aeration
( )Proven biological additives
Irrigation sprinkler High pressure agitation
nozzles Wind draft
(V)Irrigate on dry days with little or no wind
(1)Minimum recommended operation pressure
(V)Pump intake near lagoon liquid surface
( )Pump from second -stage lagoon
AMOC — November 11, 1996
12

Storage tank or
basin surface
Partial microbial ( )Bottom or midlevel loading
decomposition Mixing while ( )Tank covers
filling Agitation when emptying( )Basin surface mats of solids
( )Proven biological additives or oxidants
Settling basin
surface
Partial microbial decom- ( )Extend drainpipe outlets underneath liquid
position Mixing while filling level
Agitation when emptying ( )Remove settled solids regularly
Manure, slurry or
sludge spreader
outlets
Agitation when spreading
Volatile gas emissions
( )Soil injection of slurry/sludges
( )Wash residual manure from spreader after use
( )Proven biological additives or oxidants
Dead animals
Carcass decomposition ( )Proper disposition of carcasses
Dead animal
disposal pits
Carcass decomposition ( )Complete covering of carcasses in burial pits
( )Proper location / construction of disposal pits
Incinerators
Incomplete combustion ( )Secondary stack burners
Standing water
around facilities
improper drainage (V)Farm access road maintenance
Microbial decomposition of away from facilities
organic matter
Manure tracked Poorly maintained access (1)Farm access road maintenance
onto public roads roads
from farm access
Additional Information:
Available From:
Swine Manure Management 0200 Rule / BMP Packet NCSU-County Extension Center
Swine Production Farm Potential Odor Sources and Remedies, EBAE Fact Sheet NCSU-BAE
Swine Production Facility Manure Management:Pit Recharge --Lagoon Treatment:EBAE128-88NCSU-BAE
Swine Production Facility Manure Management:Underfloor Fluse-Lagoon Treatment 129-88NCSU-BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE103-83NCSU-BAE
Calibration of Manure and Wastewater Application Equipment EBAE Fact Sheet NCSU-BAE
Controlling Odors from Swine Buildings; PIH-33 NCSU-Swine Extension
Environmental Assurance Program: NPPC Manual NC Pork Producers
Assoc
Options for Managing Odor; a report from the Swine Odor Task Force NCSU Agri Communication
Nuisance Concerns in Animal Manure Management: Odors and Flies; PR0101, Florida Cooperative Extension
1995 Conference Proceedings
The issues checked ( ) pertain to this operation. The landowner / integrator agrees to
use sound judgment in applying odor control measures as practical.
I certify the aforementioned odor control Best Management Practi es ave bee. - iewed
with me.
andown: Signature)
13

Version —November 26, 2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
❑ El Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
(111 Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
UUUU 13B .0200.
ElEl Rendering at a rendering plant licensed under G.S. 106-168.7.
ElEl Complete incineration according to 02 NCAC 52C .0102.
El ❑ A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
El ❑ In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
El 171 Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional tem • - - procedures or measures for disposal according to G.S. 106-399.4.
ignature of Farm Owner/Manager Date
la-2q-IR
Signature of Technical Specialist Date