670001_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 67-0001 Certificate Of Coverage Number: AWS670001
2. Facility Name: Onslow Farm
3. Landowner's Name (same as on the Waste Management Plan): M and A Phillips. LLC
4. Landowner's Mailing Address: 903 Wards Bridge Rd
City: Warsaw State: NC Zip: 28398
Telephone Number: 910-290-0111 Ext. E-mail: mhp 123C earthlink.net
5. Facility's Physical Address: 402 Costin Rd.
City: Richlands State: NC Zip: 28574
6.
7.
8. Farm Manager's telephone numbi (include area code
County where Facility is locatddt: ?rw4 [itt-sliS- Y�,..
Farm Manager's Name (if different from Landowner r-a_. -; -.- .-= . �._ -
x-- w-�
9. Integrator's Name (if there is not an,lnlegrutor, writrss."None" ): -. Carolina I Toward
10. Operator Name (OIC): Marshall 1-1. Phillips
11. Lessee's Name (if there is not a Lessee, write 'None" ):
12. Indicate animal operation type and number:
Current Permit:
Operation Types:
Phone No.: 914-290-01 1 1 OIC #: 28714
Operations Type - Allowable Count
Swine - Wean to Finish
Swine Cattle
Wean to Finish Dairy Calf
Wean to Feeder Daily Heifer
Farrow to Finish Milk Cow
Feeder to Finish Dry Cow
Farrow to Wean Beef Stocker Calf
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other - Layers •
..-
11,295
Dry 'Poultry
Non Laying Chickens
Laying Chickens
Pullets
Turkeys
Turkey Pullet
Other Types
Horses - Horses
Horses - Other
Sheep - Sheep
Sheep - Other

13. Waste Treatment and Storage Lagoons (Verify the following iryYormation is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline'
(Inches)
#11
f 'd -/�f0`
CIA r IP
/ CP/ 2-31
/q!y 32-7
.. 2-0,
ii2
/ 0 0 •- Ill e
et`.,t iI-
?/ 1 >Y
'20.00
#3
M0 NV? O
CC/1 c .
f 7P1/3
AN), 640
35.00
as
, D - ifqq d'
CLAy
£-/ d Ofert —
33 ?. / J
-15 ,2 p /I
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components;
1. The most recent Waste Utilization Plan (WUP), signed by the owner and ;Certified technical specialist containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every tied used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shaft in the WUP
I• he max rani m PAN to be a .lied to every Iand application Field
g. '1 he:avaste appli " r
h. ..I fie.reytuted.
A site map/schematid
Emergency Action Plan --
' insect Contr tI..G}teckli t viili eh�senr#tr St inail:'
r<
.. Odor 1. onirol Cheat isi with cltg i ri best inanag _
Mortality Control Checklist witlk elei;ted ntethod noted = Ust t e. enclosed updated Mortality Control Cli«klls' ;Y __—
I,agoonlsIcrage pond capatiity: documentation (design, calculations; etc.) . Phase bc surc. the al=uve iable is accurate and
4F - s.. complete. Also provide• any',: -site ea ions, wetland • determinations, • or hazwrd..classifications that 'May be applicable to
i rrr, your facility. •
Operation and Maintenance Plan • .
Ir your CA . MP l; includs any .omiinineents nut howl .'n tlris list, plcast. inrlttdr the additional coinpoiiicri[s`with your sulnniti l
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and entail one signed copy of the
application and all lite CAW NIP items above to: 2O19PcrtnitRenewaiuncdcnr.gov -
D

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name:
` r Title: /"�`" 6cZ'
Signature: Date:
247 /
Name: Title:
Signature: Date:
Name: Title:
Signature: Date:
-1
-
TI4E COMPLETED APPI.1CATl{3N Si IOCL[) 13I= SENT TO 1 Fil.:.FOLL
- -- tiCl)1;(/-I)\► R
Animal Feeding Operations Program
1636Mail lien ice Center __ - •-
Raleigh. North Carolina27699-1636 �"- ' 'f;
Telephone nu m he, : 1919) 707-9100
E-mail: 2019Permi tRenewalg acdenr.gov
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER.
Governor
MICHAEL S. REGAN
Serrerary
LINDA CLrLPEPPER
Oinactor
NORTH CAROLINA
Environmental Quality
February 27, 2019
M and A Phillips, LLC
Onslow Farm
903 Wards Bridge Rd
Warsaw, NC 28398
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee: .
VW4C13el*
\1'3
vlaSls*
itetat0906g66"4"4
Your facility is currently approved for operation under one of the' Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation' State Non -Discharge General Permits are available
at httns t'deo nc.eov/about/divisions/water-resources/water-quality-regional-nperatinns(afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636__
:4ephone•number (41-9)7Q7 9
k it
_ ... r, � --.a,;...2— . ..— �' , ,..k .. �' >. mac+
I &der' to assure•our continued co"veragenunder the7Sta es Non=Discharr General � Permits -.i'ou-'must- submit an "application for
permit.co, vers a to;xhe` Division Enclosed_jou.vvill fmdra Request for CCertifrcate of.Coverage Facility :Currently: -Covered by an
Exptrtn TState Non=Discharge" General Permit The; .:application form must .be • comrIeted 6 signed and a re`tu`rned b"v APrrl 3; 2019.
P1eaae no`te'� that= youl'mtist- rnciude one { 11 "Pco v of :the Certified Animal Waste Manaeei. n Plan -'(CA�WMP)• with the
= i <li .l +ram a i* a l.. i= r. .:.._ . �• . _i . -
comnleted.`=and slQned=annlicahon form. : A list of -'items Included in the CAWMP can be found' n'pag' 2 of the renewal
4 applrcationform ` _ µ - k _>
s
: s °WAS✓' +t a. ''"fe.047I _L'-,tea" 4 -# ,.-;-.J... ' -e 'F _. .. :".75 € -' - ,. . y',r ' .
{ - Y•_"�. _-4fY•-v- '�'S(. - _ Wes_
Failure to request . renewal of your coverage' under `a general : permit within the time period specified may result in a civil penalty.
-Operation of your „`facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to.$25,000 per day:
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related (natter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
14 rInoriaton Regional Oftiie.,Waccr C.usliry Rceinnal Operations Section -
i 1n..1A County Soil :end Water Conser‘.ariorr l ien i�r c
ction C unn,r[ 1 i1 :; -tit Cirroinia watt . • . .
D E
araisreDer� aiSYait�iasauraEa
cs�N..S34stiuiyrEt_ I1= =r ;_-•`_-_=rIni.g,r:.rtCanx.ea.27699-1e36
1

North Carolina
e•ar ni-gpt.of Environment and
8f.') and -Wa onseniailo
!' n
G oye
�r11i[Ilalrl' doss Jr. Secreiaiy
David � . o el; Director
Date
Subject:
arch--10,' 2004=
PerrnitRe.quest
euhoff Farm`;
Facilify N'urnb:er 67-1
atu ral Resources
on D scha`r e Perm t`Unit ;
-NORTH CAROLINA DEPARTMENT OF
;-'ENVIRONMENT-AND NATURAL-RESOURCES��"
RECEIVED
WATER wow SECTION
MAR 1 5 2004
NON -DISCHARGE PERMITTING
The Neuhoff Farm (AG) according to the owner and the records that ! have
searched has never "received_a foripa! Nora -Discharge permit by the Division of Water
Quality, However;=itthas been in the permitting process for gi_'ite some time now. It is
-my unaerstanding_'t't-'at"the firm is-close"tc,be ing.:permitted at this=tiro. The final hurdle.::-«-.
_seems to be the removal of sludge. from the farm. This has been accomplished.,
i. t=?.a-eri inspected by both the Division of Water QuLlity and the Division of Soii- Y
vanion since the inception of tit -_ ifIsoect�n5 ram.-Trhefarm was
Certified Raiph Sam Jarvis in December of 1997 in accordance with the appropriate
procedures.
This farm was originally built in the 1960 era. Thus, the farm has been and
should be treated as an existing facility. There are four lagoons on this farm that were
created over a period of time prior to 1990. The lagoons on this farm are not sufficient
to accommodate180.days of storage however three of the lagoons are capable of
accommodating a 90 day storage period. This is accomplished by having two lagoons
-act as the treatment cells, while the third lagoon is used to store all of the temporary
storage requirements. The elevation and depth of the fourth lagoon on this farm
renders it useless to be used for treatment or storage. Thus, three of the lagoons will
be used as treatment and storage while the fourth lagoon will be isolated from receiving
additional waste, however the excess rainfall and storm storage volumes for this lagoon
has been calculated as parts of the overall waste management plan to ensure that this
lagoon will not cause a discharge.
I have recertified the storage capacities of the lagoons as well as created a new
waste management plan for the facility based on actual irrigated acreage. The facility
required the use of a honey wagon to meet the required PAN balances. However, I
have provided an irrigation plan for this farm which includes an additional six acres that
will be put under a solid set irrigation system. The additional acreage will now allow the
943 Washington Square Mall, Washington, North Carolina 27889 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer

farm to operate without the use of a, honey wagon. The new solid set irrigation has not
.been installed at this time however it will be"installed within thirty the. date of
this letter I required sludge :to be removed from the* facility priorto cer i~f~ying: the
rage_capacities in the lagoons • ,g
-
'f have enclosed the new certification Corms=anti=tkie new waste r a: agertaent,pleg
;;well as a copy of the sludge removal plan for your review 'The sludghs already
een=removed from the facility.: If you could expedite the permit reviewfor this arrm hat_ -
-
p o the c vn rs hey are -concei ned abou t
eir;s
a
Thank you very much for your help in this matter. Please include this letter as
part of the permit review package as it is helpful in explaining to the reviewer_how_this _ _
farm will function. If you have further questions or comments I may be reached at 252-
946-6481. "
RECEIVEOW -WR
• APR 1 0 2019
Water Quality
Regional Operations Section
943 Washington Square Mall, Washington, North Carolina 27889 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer

Murphy -Brown, LLC
Grovgr(s):
Farm Name:
Coun :
ty
Farm Capacity
9/28/2018
PAN
hatl
Onslow Fa
Onslow Co
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Wean to Finish
Feeder to Finish
11295
Storage Structure:
Storage Period:
Application Method:..
• Anaerobic Lagoon.
>180 days
Irrigation
P.O. Box 856
Warsaw, NC 28398
y - ;.' ": •_�.r-_-,c' r._"e- ems`-". r;.xb' ,._"
t The waste from =your an. imall facility must be land applied at: a specified rate to prevent pollution
`
of surface, water-and/or_groundwater;The plant nutrients in the animal waste should be used
to reduce the amount of commercial feitiher:;requ zired for the crops in the fields where the waste`
is to be applied •:X
u
his waste utilization plan uses nitroge as tha
efore-each application_:cycle Annual 1
utrients.Mean be balanced fora i tic;' y e dsff
.-Several factors are importa+rl r�frngo
,.the fertilizer value- of the:waste art ,to;ensure;thaTt iris app
Waste should be analyzed
u[agedsodhat-
�� � E 2
led m afi environnientallyFsafe`manne
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen. than the cropcan utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

nS'iis•-;
This planis based on the waste application method shown above 1y,u jiro,e hange01
methods in the future, you need to revise thispIaq '3uti• n leer' e1 i r d f erf ,# xor ra iti,r .
methods�are of k
•.. r - ate,_
The estimated acres needed to apply the animal waste is based on typical n �Ii ,F r l r,ntenl
for this type of facility. In some cases you maywant to have plant analysis nyade, whichh
allow additional waste to be applied Provisions shall be made for the area receiving tee
be flexible so as to accommodate changing' wasteanalysis content and croptype: Lime.rriust-
be applied to maintain pH in the optimum range for specific crop production. -
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental ManagernentComrnission _
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
Waste Produced per Animal w Total
Capacity
11295
Type
Farrow to Wean
Farrow to Feeder
y Farrow to,Finish-..,
Wean'to Feeder
Wean to Finish
Feeder to Finish
3203 gal/yr_
3861 gal/yr
10478 gallyr
i 91 gaWyr-
776 gal/yr
927 gal/yr .•
gal/yr
r_ gallyr
al/yr
lgal%yT
8,764,920 gallyr.
:gal/yr
. Total 8,764,920 gallyr
A-- AUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Nitrogen Produced per Animal.1
11295
Farrow to Wean
Farrow to Feeder`. •
--• Farrow to Finish
• Wean to Feeder
Wean to Finish
Feeder to Finish
3,84_ Ibslyr.
6.95'Ibslyr
_040
_. _ _ _ 0.34 Ibslyr_.—=
1.40 Ibslyr
1.67 Ibslyr
15,777' Ibslyr
Ibslyr
Total 15,777 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the .amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage:
Total N Required 1st Year:
Total N Required 2nd Year:
Average Annual Nitrogen Requirement of Crops:
Total Nitrogen Produced by Farm:
Nitrogen Balance for Crops:
82.97
25731.01
0
25,731.01
15,776.86
(9,954.15)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

•
-
. -
' •""--\==
. .
•
-
7Lifivrf:7-rrimtiV,Triffpfigalareeplq,
• v=4 4
- 4-Efz
--Apmra5

190
Reception Area Specifications
, ,•
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs T;g0i, Pas N 2nd Crop 4..,;;Time to,- •2nd Crop 2nd Crop Lbs N/Ac
' •
1l1Acreagyele A Yield lbs N/Unit Residual OPP/Ati10411.ilkiod Code Wi.VAtibi02..itYield lbs N/Unit Residual
; •
3197 P1
3197
3197
3197
3197
3197
3197
3197
3197 P8
3197 P9
3197 P10
3197 AW3
3197 P11
3197 AW4
3197 P14
3197 AVV5
3197 P15
3197 AW6
3197 AW7
2001 AW8
P2
P3
P4
P5
AW1
P6
AW2
3197 AW9
Lbs N Total lbs N • .1411
/Ac Utilized; Lbs Niko
Total lbs IsT
Utifized
3.15 Forestall C March -Sept 6.0 46 , ,,, , 76 869,4 LIMIIIMA•2„Pt — -.i. 50 50 ,i,,
1 11°6236.89247,
4,,,• ,.,,/6,.,,,,
3.57 Foreston C March -Set 6.0 46 276 . 985 32 L Se•t-• irit •),;j!1 : D•• 50 50
17.9 • 0.- .,,
3.32 Foreston C March -Se t 6.0 46 276 , . 916 32 Se ,t-Ai'ril lie,. 1 .,4 . ,, ,,„ 50 50 166 1982 •32
3.28 Foreston C March -Sept 6 0 46 . 2•Fa . 905 26 L Se .1-klin1=1.=,. 1 .,' st,:,.50 . t, 50 .164 g•I 2: , ;7211," ., : 1 069.28 •.
2.94 Foreston C March -Se t ,6.0, 46 MUM 18411551 4564 ,. En .swlmo=iimior ietf44:50 m.,,.:.10=;, :t:, r . 197539i. 4.04:
MEEEMOMMIll:4“41 ,, X'1,1 .,3 111111111MailL •, ..:- ' .L,-7 • N : ! .1167.08'
IESTIMMInnelld,14, 4itii 50 50 i1 616.14
s.e.i.••41111=IMIlWit,-- 7- -„•:' - 1.1020 38
".111 .4" *I' '3IK?WMIUMMIIMISrii ii4E-1 111115MilliiM5M50 5° 71i:01405' _iv;._•,,•:;,..Li :1,..1 7 1' :1686:393445:57C1.4002-9-e3.079:548.
50
MBIIIMA. 1370 655
50 .- 128 ri, j . 'LW: 817.924
50
50 a 22 4.,KAM - 140 58
684 6
Foreston
Foreston
Foreston
Foreston
March -Sept
March -Sept
C March -Se
March -Se,
6.0 46
.6.0 46
6.0 46
6.0 46
12.2 Foreston March -Sept 6.0 46
14.58
Totals: 82.97
Leon
March -Sept 4.5 42
- •
275
=NM
2755.- 62 ,L
MEMikk •
,,.',44tV,L,ti-ktii.21-582.51,1, •„
3(a) of B
Se
Se
iSe
.4.50 50
50,+4,4
50 •
Sept,.APrit xtlfig• 1
se .t-A
t-Aoril', 1,
4.14f...so
1.4 50
50 50 , •
50
50
10 5 la
610. -
L 6a,
729 ' ,23414„
-
3977 2
34134 62,
4148.5 25731.01
F

14.1.
r12
Reception Area Specifications
Tract Field Irrigated Soil. lst Crop
Acreage Type Code
rdV
ii
•
'10"It 7 ,i• , -
Time to 1st Crop lst Crop Lbs N/AtAltillOs N Tots] ins N 2nd Crop,. Tn,d Crop 2nd Crop Lbs N/Ac
i
Apply Yield lbs N/Unit ResiduallIVIAC • Utilized Code .• 'Abe N/Unit Residual
Totals:
'i/40;10-,•1;••
•
Lbs N Total lia tai Total !Os N
/Ac UtIJI Ac Utilized
•••
•
Utb) bf 0
I .a..1
.*A.

C
r •
•
•-•
•-• - -
77.2•NnalgOT
.•.
• • • . • .
• • •
•
. • •-.
• _ •
• • '
.7 .

This plan does. not include commerciahtertclizer I hefarm should pros uie adequate plant.T ---
available nitrogen to tisfy the-Fquirernents of
The applicators cautioned that P avid `I' ,'Tt3y i]c' vim:2pnIieri-wliile"rpeefinggth N rec uirerny,ts
the future regulations may require armers in .,o'me pelts‘ -of North Carolina to have a nutrie'n
managementplan that addresses all nutrients$'kTl is-planbrrrly! addresses nitrogen s." y
In interplanted fields ( i.e. small grain,'etc, interseeded in Lie muda),'forage must be removed ,
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass,,, This loss
of stand will result in reduced yields and less nitrogen
bein_ g i tilized.' Rather g small than cuttingrain for hay or silage just before heading as is t-
the normal situation, -you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time s mall.grain is planted in the.faaIi T �
icy #�-5:�+2"s
The ideal time to interplant small grain etc is late September or early October';.Drilling is,
recommendedeover bradcasting-Uermiidagra s slouldbe razed or cutto a -height of.
about two inches before drilling for best results�a`
gz.
rt'�3:tii -
OP_COQELEG ND
E
F
G
H
J
K
L
M
N
0
P
bushel
:'.
ice. s50Ibton
FTyben mu ar-ass a_Hay 50 Ibs N /ton
_.. -Corn -Grain - > 1.25 Ibs N / bushel
Corn - Silage 12 Ibs N / ton
Cotton 0.12 Ibs N / Ibs lint
Fescue - Grazed 50 Ibs N / ton
Fescue- Hay - 50 Ibs N / ton
Oats 1.3 Ibs N / bushel
Rye 2.4 Ibs N / bushel
Small Grain - Grazed 50 Ibs N / acre
Small Grain - Hay 50 Ibs N / acre
Grain Sorghum 2.5 Ibs N / cwt
Wheat 2.4 Ibs N / bushel
Soybean 4.0 Ibs N / bushel
Pine Trees 40 Ibs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

tu
S LU DGE,/{PPLICATION
--wing_table des bes the #rito-a-jIlitrogen accumulation rate per animal
--... 'e.., ' -' - -' ti ,--.
Wean to Finish 0.306
':Feederto Finish 0.36
-
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates.- The sludge will be nutrient rich and will require precautionary measures to
prevent over application Of nutrients or other elements. Your production facility will produce
approxim tely 0 pounds of plantavailable nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation fisted above
� o ' 3` .,
'you remove theme: sludge every 5`years you will have approximately 0 pounds of plant '
vailable-mtrogen to ufihze Assuming you apply this PAN to hybrid bermuda grass'hayland atthef
'rate of 300 you s of nitrrroogen pe acre you will need 0 acreas-of land. If you apply the sludge
to corn at a rete^of125 pounds£per acre you will need 0:acres-of land. Please note that these
are oinlyest at s of the -PAN Produced`and the landErequiredato utilize that PAN. Actual valuesf .,
'may only bbe determined.by sampling the fudgee for plant available nitrogen content prior to application
ctual utllati ate's w rywith so jtype crop and,realistic yield expectattonss for the spec• ific
, appli07.0 i l esigrote r sludgeapphcation trne bf removal g - t�:
PCICAT GI F 1N.07rE BY IR,1119 LION
irrigatret p 1 rQ rate hzaUtd f excee � "I.srateYo the -soil -at the„time of irrigation _
i ,so'citthatrunoinitial soil moisture content soil
structure, soil texture, water droplet size, and organic solids. The application amount should not -
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts' of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
CaII your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

ry
Application Rate Guide
- •"
'at e. 6'nd '5i-fiburif.
proyidedi9s a -guide
• • Oii
Hydrant Type
forestablishing applicatio
•-=
MAC:;.1110.9aR0
• - ,
(cAkiicip
- P1 - Forestonr"' , :"--1'-`140 5 -"' •
-••-•(-3197 • -.1-°-r=-i-P2 .."' --, -Foreston f ''..; ''`jr C ' .::7 %tb.5 - -,
3197.- -17-=.3P3 —.-- .,.Foreston -.0 " ' : 0.5
3197 ' . P4 ' Foreston , b j 0.5
3197 P5 Foreston —C 0.5
3197 AVV1 . Foreston C 0.5
3197-,--- - - -, P6 = ...,..:„ Forestoh C ..i. _
3197 AW2 Foreston C . 0.5
P8 Foreston C 0.5
'''',*",:•.--3311997,4.4..•:, P9iz74F9reston.....-,...ii 0.5
'-'316 /7-1,--"-' P10 FoForeston- C
0.5
0.5
; 0.5
. • ._
0.6
- ,
:4, 0.6 :tr.f: = • ,z
'Se • 1,
AY.A
: • .-- , :1
•—
":4=1,T.:Appat.
6 of 8

7.7
• _ • "
- • ,
. _ _ . . •
NUTRIEN
'
v.•.! Nat!)
§ _ • -
Own
-,•••••4 ".7
UTILIZATIOO PLAN CERTIFICATION
f7MapOer.
OwneilManager Agreeirient.t,,
11-11:wto;
ar06,
1/we understand and will follow and implement the specifications and the operation and
,..-maintenance procedures established,in.the approved animal waste nutrient management
.. .4... .
plan for the farm named aboVe. 1/we know that any expansion to the existing design capacity
of the waste treatment and/Or storage System, or construction of new facilities, will require a
.
. . : ,..
new nutrient management plan and .a 'Dew certification to be submitted to DWQ before the new
animals are stocked.- .= P:_=--*--4-,.- "--;$' vg.' .a.•=4,i • - ° = '''' -' .1 = '''.. , ...i: . - „
_ — -
irrigation
e
must own or have acess to fL-Rrtrn„..-,a _
y -
•*-4-7-a-geMOni plan- "?
I've :51 waSter,.-le„.„s,LEL(3indischargewioccurs
17i7tci.Carr.'/**
Trio y
7-ply,the-anTm'
in the event of a 25 year 24houLstor.rT
appropriate
1, so,. _
4141-144'hltyat-no
t the waste
rates which p
d
according to this plan atthe appropriate times 1a
je,w--cbf-fice
e-suc z
and at:
rod ull cb: appliedatheer"
no runoff-
9fthe local
--natioti-4J-..--esIticltLatld.V4 :#74-01.ab
`--=`
Name
of aci1( Owner - -
ord.
Name of Manager (if different from owner):
Signature:
=au
Date
Name of Technical Specialist.
Affiliation:
Address:
Signature:
Toni W. King
Murphy -Brown, LLC.
2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
Date
Date
8 of 8

, AdditEnnal _Comments:
ncludes subfield acres to use an aerway machine wan np
Vi
crop ch 196s.'- r,iall_grain is optional.
Grower wilt resprig bermuda in the spring 2016.
6/27/2017 New field added and will be applied on using an AerWaii machine.
7 of 8

•
2
Animal waste shall not reach 'surface waters=of '3 s -te
conveyances, -direct application, or,direct discharge during open
Any discharge of;waste which reaches surface water is prohibits
There must be documentation in the design folder that the producer either owns or has •
an agreement for use of adequate land on which "to properly apply the waste. If the
producer does not own adequate land to properly dispose of, the .waste he%she, shall __
provide evidence of an agreement with a landowner, who is' within a reasonable.
proximity, allowing _ him/her the use of the land for waste application. It is the -
responsibilityyof the,owner of the iwaste production. facility jp secure . an update of the .
utrrlent Utilization Plan when there is a change i the operation, :increase in the number
f animals; method�of applicatio �rec evmg rop type or available land t °
L3- Animal waste shall be applied to meet butI:not exceed„_the nitrogen needs for realistic'
- crap yields based upo•onn:_so l type available moisture ;historical dataclimatic.conditions;
and level fof management, unless there are}regulations that restrict the rate of appl�tions
for other nutrients_'':'
:_�-'.°,'r�s`"°'_",: _':.z2'....i3�'��.+'-.'YxT.h`�'..7ataaa_Cc c'`-`i re.+-, .r3r+'rf?',3t'-_`ram-csSxa�u•,a-�.---' �..r
rnmal waste shall be appliedao land=ero ng less -than 5 tons per: acre:.
ay -be aptilied ti land ernCdi acrever eaffh less t
foi s per acre"per y ar.°provided- grass. filterwstrips7are- inttalled.where-runoff_-leavesot
field (See USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation
-tilled crops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not cause
drift from the site during application. No ponding should occur in order to control odor and
flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
1 of 3

rr
NUTRIENT UTILIZATION PLAN
I: ' 1- F EDSP IFICATi�3
,.. •,r f;A; �`' ;(contii1uedf'';...
`nimal waste shall•be applied on: ctively growing crops s insuch a•manner that the crop is
not covered,with waste to a depth "thaf.would inhibit growth,-The'potential for salt damage
from animal waste should also be considered;-
10 Nutrients from waste shall not be applied in fall or Winter for spring planted crops on soils
with a high potential_ for leaching Wastelnutrient loading rates on these soils should be
'held to a. minimum and a suitable winter cover crop planted to, take up released nutrients.
Waste'shall, notbe applied more than- 30 days prior to`planting of the crop or forages
breaking dormancy TAM
� s 1 1.995 shaII com I with the following
��Any new�swyne facility{sited�on �or�af�er Octobe ;� s p Y =
The o tee erimeter of,tfe� land area onto which waste is applied from a lagoon that is a
component of a farm shal eat east 0' feet from any residential°property
r z-
boundary and canal Animal wastste, other an w ne waste Jrom facilities sited on or after
October 1 µ1995 shall not be ap hed cl. se an a to erennial waters
�*�-�`��€�F�1:.�'��'� ae.r me�r`: -".,,,we�� . .iS� _.. 3:.;'�F'�e`"z��r"4_aw''�Irc 'xT •'�' .;'.•^��"ct.,�' � ..: f ..,r i....... �. �_ . �.,;�.at'�» �. MY'.� :�
13
14
Waste shall be applied in a mannernot to reach other property and public right-of-ways.
Animal waste shall not be discharged into surface waters, drainageways, or wetlands by.
:discharge or by over -spraying. Animal waste may be applied to prior converted cropland
15 provided the fields have been approved as. a land application site by a "technical
specialist". Animal waste shall not. be applied on grassed waterways that discharge
directlyinto water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
16
2 of 3

A`protective cover of appropriate vegetation will be established. on all disturbed areas
�,...b- rm�rP•p ri
(lagoon embankments`"berms, i e runs,'etc.). Areas shall be fenced, as necessa to
protect the vegetation. Vegetation such as trees, shrubs, and other woody'species, etc.,
are=limited. tot areas where considered appropriate. Lagoon areas should be kept mowed
.
�:: and --accessible Berms 'and- structures --should be -inspected., regularly,for, evidence of
erosion, leakage,,or discharge.
If an mal production at' the facility is to be
18 .Y responsible for • obtaining rand, implementing
•possiwitty of an illegal discharge poliuition and
suspended or terminated, the owner' is -7
a "closure plan" which will eliminate the'
erosion.
.r�
d ter.
Wa"st�
bia"n dlmg structureslkpiping pumps, reels, etc , should be„inspec a on o regu.
s to prevent brew cd w s,ea}ks amend spillsA regular maintenance checksh�ould I
inept onse-
h ". x, a.d Yev"v-. _Li FF .yiS.RJ"�i 3's.5i1L ..II"wbIatG'
x in._a rotation that- includesvegetables and othercrops for trec
nimal _v�aste=is _used on crops for drr ctthumaf
resplant;wit no furthrappatio�o?afL
Highly visible markers -shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
21 managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
-Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
22 nutrient, unless other restrictions require waste tobe applied based . on other nutrients,
resulting in a lower applicationrate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
3 of 3

•
•
CS
��'••-�. ° �+�� `"-: TRIENTU L,,IZ,R" -T«.�.�Ta��- 7s�1 � +�
_PLAN4'
I Rfir ': 111: 7..."i IONS
minimal waste shall not :reach surface&waters" of the sty by runoffdrift nmpue
conveyances, direct application, or direct discharge,duting peration or land application:
Any'discharge of waste which .reache5`surface water is prohibited
2 There must be documentation in the desigri`folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not;own adequate _landto properlydispose 'of,, -the waste, he/she shall provide
_ _ evidence of an agreement;withia ;landowner who` is within a reasonable proximity,
allowing.him/her the use .of the 'land for waste application. It is .the responsibility of the
OW of tt a waste production f kty to secOte a- ..-tesof the Nutnent.Utihzationi ft?h
when''there`�is a'change in the operation, increase in the number of amm IIs, methooddTof
:_ ,..Ni...... .
application;°recievmg crop type, :or available land
i._..._ -3�.• ..�J..:�. ?%-.�i?.? _ xggyi'c`r•+'h..:'h'"rrY
3 grnmal waste shall be applied,to meet but not exceed the nitrogen needs forirealrs#ic�'�
crop�yrelds based upon soil type, available moisture h�stoncal data,climaticon�tions
rr%arragement7-unl��ess the`er egulations that reStnctthe rate of apghcatrtis;
or -other nutnense
w r
al waste#shalb plied ess#hann5 onspeacre pery
e apliedto;land erodingva _ osperake pe"aDeh tb
peace-peryearprvidegPSsfiite%7stnps#areirstalled'whererrunoffaeaves he fielrd
(See USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
Odors can be reduced by injecting -the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.._
When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See 'Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and
flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9 of 11

•••..-Iiik•."*_ • -'
31,i••• - --••••• • --
Y. te+27-
• 17.471.
REnIJIRC:..) •,-.3! ECIRCATIONS_ -•
,i,d,,,
.._:' .4...,•••-
AV; prdtettive: ,,,,,y_w„:,a, p•L'r.!-2poitei ,.-‘ie:;_el_lapon•rkLill' b.4..eefstablished on. all disturbed areas(lagodn
ernbAkIttrits f,beritis,815.-iPe4;ri-Unse-ft).TAreaST-s1-611,..p•92.,fenced, as necessary, ,to *tea the
vegetaiion. VegetatiOn sus irees, shrubs, and other' woody species, etc., are limited tare
7'':''1.7whereconsiderPPP
ed a ro riate Lagoon areas Should be kept mowed and accessible. Berms and
strb ctures bei
i}'-*-- shouldnspected regularly for evidence of erosion, leakage, or discharge.
i., -- --':-I,I... ,- „J. ._•_-.,.._ --•:, .------,,-,44‘, • - ,
, ..‘„-,r• - ,,e-,1.0.,„„ it,- ' ' , ,
^ --,:,,,, A 1 A.17 '',..,..*, .,- t• ' ''':' ' T , . ‘... ,7" ... 4 . a'
,.
fjhinialproduCtion.at,tbefacilityLis tobe_suspended or terminated, the owner is responsible for
, _ .,-,,, ,..•-.- -
e- ''''• -11.-4 .r. -,_.- .--.:_ .-•.,.,„..•.-. ----....3-
s
; -baYnTrit irAWdririi.157igir,rin intLea-kild'41.1reidr3l4n"?Which will elirriinatethe posibilily ofan il1„5galz,,,,,_. „.„.:4„:,
',‘,14.-4"1,44.' -`vf-lifl-/ Pi-4/*:-'414-414-'e'''' ',.',‘r•--Ze--.....-.444,1-0,i- ' -.,,eyar.V.'' '''_ 71',._tk '-:- -:;:t !,,'" - - - , '.. _ -..'1.- ,...'-- ,,` , -'- - -. •'-'.i:* _7,-,.S.7- '4.,2:';',t1:7;',f .--‘
iscnarge7pollution'ano-terpsio.-- „,,,,,,,,„.., ,..,,,,,:,_ ,•,.., . _..:_•• , „-,,, :, , ._ ,• _ , ...,_ , _,
- . - -- - - . ,:-..„-, - i.-,,---, z • „,... •, . 1 . -2- :_., -, 4.,,,-,.., • .: . - •
, -- . -.‘, ----....,--;,.-,..-A • 1,--4."t&:•.. --4--,
•----,
hoe- jkinl'ispie-hete_dy
•-• reels etc, s ou
,
-t-br-ak-diliwnsMea ar maintenance c ec is s ould be kept on:site,'„,,-.
_ •- -
- ,
- '
n
.viefa
, 3-r5 rason„,
- iJua . imat wa• , .
• _num AN -
Vibeapplied„p_
tfrk
- ire
te during t
--:-nctiurtherapp
7114.
43-X-iaL
21 Highly visible markers shall be installed to mark the top and bottom elevations of the teinpotary -
storage (pumping volume) of all waste treatment lagoons. Pumping shall be managed to
'maintain the liquid level between the markers. A marker will be required to mark the maximum
storage volume for waste storage ponds..
22 Waste shall be tested within 60 days of utilizationand soil shall be tested at least annually at crop
- .
sites where u‘iate Products are applied. Nitrogen shall be the rate -determining nutrient, unless
• other restrictions require waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the soil shall be monitored
and alternative crop sites shall be used when these metals approach excessive levels. pH shall be
adjusted and maintained for optimum crop production. Soil and waste analysis records shall be
kept for a minimum of five years. Poultry dry waste application records shall be maintained fora
minimum of three years. Waste application records for all other waste shall be maintained for a
minimum of five years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
kiLLEChan DWR
APR 1 0 2019
Water Quality
RegionalOperations Section
11 of 11
. •

441I1171:;8117,5":
1.!
NOTES
ew Irrigationiones.' ":• ;14 ,,V+4
e located or: ,ili;xi*quare `••;:;.,4-• r?.•
; or on cs. sli.:19,Iepaterat.W 'Oat;
.. a catcutations _14 E 097
spaing, SeetIrri9aton.44i1.4,!!1..Vt4
• or zones 1781for..- 'more
. Atom • The neyfkrriga7tIon4 6'
.e used In pldeelpfL:41,0A.,-t'
tanes, The,OzOeS,
Irrtgatlorr.: 01)14v.' .
•
; (1-15) are :.e*I.SkIngg •
varies bekweet1f1 1.
covErage.V'HYdrar.A;
o rake cal OF
Liago9ni,
qert
Sp' zle,D
4cres
iS
357
Ac'r QS
3.2$
2.54
Spactng
Peres
113
2.59
ast
2.77
,
t) Ac,es
5.c:9
2.56
Zone Acres App'. Rate Total,';‘,TINe'
;Y* , In'/Hr - Minutes 24
47' ••
- The 1
L°999"
.4
I ;
Hose Length 6t
• 'Na*ite"n %sure el fi uur - t.ar: cin4 ieng erg
Sp
1 ;:i4ge, V=4:
Atcgt,t,;".1
E OF NORTIPCAROLINg
ta OF ENVIRONMENT 14 NATURAL RESOURCES
g OF SOIL & WATER CONSERVATION
iflINGTON REGIONAL OFFICE
•YTON Sq NAU.. PHONE: [phone]..
*6#4,14.,,a;ootroio.
41d04,V9,0',
'04t4ker'slA
GuDIOiet
Ar.0•A'Sejetin
kiun Spacln
Flow Rate.
. „
Cadrqdryt 3000;
g
NelEor00:
A07,5
.108 y3,00 '
Ringr
pslUI
290
480 C,1804•deor ee.:s.'ff0
"f(' !e t
•-•
•
ii•cih•s;:`•••Ror • Zcines.• •, ;.,
;t1,•,•1,4441,,-;44;:45i• ••
`.4.: • • lot O.- •4401.1
E.nr[rt9er,,4054).4.jhu
(746.§144.0'd*?4
-feel
Oegre,-.,s
2g"gpn . •
AGgr a r m
Irrigationz.,CalculatipTs
FACILITY 67-1, ONSLOW COUN'I'Y : ION E1(91 0) 32,ez•1804.;•r'
11' "ft.
Ji
Scale, I!' 600'
• • 409,), 400'
i'll°1E6,r1WP/X.,9 Snie111,1' 209.
DRAWN wt CDUNi, DATE: 3-10-64
CHECKED T' DATE:
FILE ag12.ciwe
•
•,Ar'

^ '
-
`
�
^
�
combination of This
"shou|d'bedone at least once o year and possibly twice in years that weather
conditions are favorable for heavy vegetative growth.
OTE:�lf-iie�-6tati'o'-'n'lis,.'c�6htr6lied.,by!s raying, 1he herbicide must not beallowed toenter the lagoon
waste.
° ^ ~Mainte duhngthe ind�|�0n0ofthe �goon
and at least monnance thly
� and after nn�or nai [� U and storm events.
Items to be checked should include,
aaa minimum, the following: .
Waste Inlet Pipes, Recycling Pipes, and Overfl»vxFipes—look for:
1. `meponaUon of joints
2. cracks orbreaks
3. accumulation ofsalts orminerals
4. overall condition of pipes
`r
�~
2

Ardmiviwt: - Amor .-4sgawarAem: 411411P11.1M 411111. -
Lagoon surface — look for:
1. undesirable ve
2.floating or lOdg
Embankment -- look for:
701P-i• 1. settlement, cracking, or "jug" holes
2 side slope stability -- slumps or bulges
3.wet or damp areas on the back slope
4. erosion due to lack or vegetation or as a result of wave action
,„„ „ .
damage
Larger lagoons may be subject-to,liner damage due to wave:_action:Caused by strong .
dS-.these ayes tan-erOCethe lagoon sidewalls,.thereby weakening the lagoon dam
b Ction'llIf
-
winW se
A goaciStand.of vegetation will reduce the potentialdamage cau y vvave a
wavet.action:oauses_ serious damagetp:alagoon sidewall, baffles in the lagoon
Tr= „?.
'-used-toleduce,.-the-waveimpaots,,v._
- .4,- • ,-:•••
'7%•
.4,..=,1----,---
.
:,.7 -:.0,i,--,•-1...
.,-,',","?;•-'*'-',.,"-',-,-n--,.i-r...-',,----ai,'"-,i.t',
4
orY6
tfittes$6afyr9i,6ii41ta0jP1,1P510)A8rcrne--' 0m4--.j4-.'.K-.'-7-e.--.:_. -n- l''
). 9,,
..-., i-of
4-;,-,t--,7.-,-t6
idam...._,-
slt,i.YQ,,7,7
-_70, .,:4-":-',1lagoon-
u:
hi5n features
conb4rk,o-tcf.vaste,agqQngYoumayt09d4to'provide,a-tempbi;441511!6e;ldZ: thrrai7116„dis?lrge4ow ;e11ir:ent'solOti617sKII:11re4770'L:k)
ll;.digi0917I6bi,FW,withr:f17‘941Pccie:.vd,$R041ialls:;u:::-1iit4h'6-,8::e s
recdmmended
by an 5pioiia1expert
,:
TransferPumps40 tiipeatik1;
recyclingpyrp-,a- ._,- -1 ---
.' irrigation pumps '
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, or a large amount of vibration, may indicate that the pump is in need of repair or
replacement.
, NOTE : ' Pumping systems should be inspected and operated frequently enough so tht
you are not completely "surprised" by equipment failure. You should perform your
pumping system maintenance at a time when your lagoon is at its low level. This will
allow some safety time should major repairs be required. Having a nearly full lagoon is
not the time to think about switching, repairing, or borrowing pumps. Probably, if your
lagoon is full, your neighbor's lagoon is full also. You should consider maintaining an
inventory of spare parts or pumps.
• Surface water diversion features are designed to carry all surface drainage
waters (such as rainfall runoff, roof drainage, gutter outlets, and parking lot
runoff) away from your lagoon and other waste treatment or storage
structures. The only water that should be coming from your lagoon is that
which comes from your flushing (washing) system pipes and the rainfall that
hits the lagoon directly. You should inspect your diversion system for the
following:
1. adequate vegetation
2. diversion capacity
3. ridge berm height
3

lentified prcble s��shouldrr� be cected promptly --It is advisable to'inspect your system ,.
dur g - Qr, •rr,rn@ aalery, fallowiric CI'- 1 �:av, 'rain Of:technical assistance is needed .to
etenizne, o'.- :rilutwn Gq sult,wirr:,.Jpiro, ripe' xperts
4.You sl�oul� reeiy r� the Iq el of the oon just pro L<) when rain is predicted, and then
record the leve L On 4:t hours after the F�a_r a�� .+mes there is no.:pumping) This will,,,:;_
ivetyou an .fie of hoW. uch your lagoon veh-will rise with a certain ra nfall _amount
ou :must also be • record ragyour rarnfall ford this into woirk); Knowing`. this' should help in ua_
planning irrigation appli ,ations:and storage.,: If your lagoon rises excessively, you may
have. an overflow problem from a surface water diversion or there may be seepage into
the lagoon from the sur ounding-land2
`• am
mmediately after,' c_strr}aidn establas j:
.It is _recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon liquid
volume This seeding should occur at least two weeks prior to the addition of
wastewater.
6.-:Maintain_a -periodic check on -the .lagoon liquid pH. If the pH falls below 7.0, add
ff agricultural limeat the rate of1:pound per 1000 cubic feet of lagoon liquid volume
:until the pH rises above.? 0 ,Optimum lagoon liquid pH is between 7.5 and 8.0.
:7. A dark color, lack°of bubbling, and excessive odor signals inadequate biological
activity. Consultation with a technical specialist is recommended if these
conditions occur for prolonged periods, especially during the warm season.
Loading:
The more frequently and regularly that wastewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily
are optimum for treatment. Pit recharge systems, in which one or more buildings are
drained and recharged each day, also work well.
4

"gyp - 1111M
•e` -water conservation r minimize buildin,
waterers; broken pipes and washdon thrro
co se'vation ~^� wp
1� 4 �^ "' ->�
i, ui a feeeed wastage and spillage by keeping feeders adtuste
��• a ount'of solids.etntering the lagoonr Y-; _£�
anagement :
amtam lagoon liquid /eve
n temporary;storage}level _:
between `the permanent `storage.`.level and the full -
Place visible markers or stakes on the lagoon•bank to show the minimum liquid leve
and the maximum liquid level =(Figure.2-1).
tars �ggtng t Fie ear'fiesposSilaetlain#„thespnngb ednn rent
equirements and soil moisture:so that temporary storage wilt be maximized for the
summer thunderstorm season. - Similarly, irrigate in the late summer / early fall to .
_provide maximum lagoon storage for the wnter. -
t lagoon liquid level should nel/er.be closer than 1 foot to the lowest point -of the
am=or-=embankinerit. -
.-Don not pump the lagoon liquid level_ lower than the permanent storage level unless
u.are rernoq ,sludge.--- - .
•—Locate float pump intakes approximately 18 inches underneath the liqui'i surface and
as far away from the drainpipe inlets as possible.
• ^ Prevent additions of bedding materials, Tong -stemmed forage or vegetation, molded
feed, plastic syringes, or other foreign materials into the lagoon.
Frequently remove solids from catch basins at end of confinement houses or,
wherever they are installed.
• Maintain strictvegetation, rodent, and varmint control near lagoon edges.
• Do not allow trees or large bushes to grow on lagoon dam or embankment.
• Remove sludge from the lagoon either when the sludge storage capacity is full or
before it fills 50 percent of the permanent storage volume.
• If animal production is to be terminated, the owner is responsible for obtaining and
implementing a closure plan to eliminate the possibility of a pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by.
5

• " ,tit _+ •
mechanical solids separationof flusiihd ste:
gravity settling 'of flushed Ova to colt s �n an -apj
minimizing feeedwastage and spillage.
Removal „technique
•
•
Custom -appl[catcr:��—�
�.__+tea nz... . ' ;^-- _ r.i�^,i._ - . `-,�-.r`"' saw-*^�•'...e. t-retzi ar,^x..., ter.
F.
Mix the sludge and Lagoon liquid with a chopper - agitator impeller pump through large "y. --
bore sprinkler irrigation system onto nearby cropland; and soil incorporate -_° ' "°'� :=
Dewater the upper part of lagoon by irrigation onto: nearby cropland jar.forageland;-Mix -.
remaining sludge; pump .i.nto:liquid sludgeapplicafor;.haul and spread onto cropland or
forageland; _and soil incorporate.
Dewater the upper part of lagoon by _irrigation onto nearby cropland or forageland;
dredge sludge "fro 'f ooi vit lragiine'ar":sludge•barge; berm an area beside lagoon*,
to receivethe slddgel.scAiiait- cjuids can drain back into lagoon; allow sludge- to. I.
dewater; haul and spread with manure spreader onto cropland or forageland; and soil
incorporate.
Regardless of the method, you _must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited_by these nutrients as wellas any previous waste applications to that field and crop
requirement. Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage.
Close attention by the pumper or drag -line operator will ensure that the lagoon liner
remains intact. If you see soil material or the synthetic liner material being disturbed, you
should stop the activity immediately and not resume -until you are sure that the sludge can
be removed without liner injury. If the liner is damaged it must be repaired as soon as
possible.
Sludge removed from the lagoon has a much higher phosphorus and heavy metal content
than liquid. Because of this it should probably be applied to land with low phosphorus and
metal levels, as indicated by a soil test, and incorporated to reduce the chance of erosion.
Note that if the sludge is applied to fields with very high soil -test phosphors, it should be
applied only at rates equal to the crop removalof phosphorus. As with other wastes,
always have your lagoon sludge analyzed for its nutrient value.
6

.:� M1
J_ Ju1 e' will increase` the amount of odor ati. the waste application site: F
.observe the wind direction and other conditions w
Possii_' Causes o
• Lagoon failures result in the unplanned discharge of wastewater from the structure:
Types of failuresncludeleakage through the bottom or sides, overtopping, and breach of
.the dam Assuming proper design and construction:the owner -has the -responsibility ford
ensuring structure safety ,Items which may lead to lagoon failures include:
'-.. - £3� .Y- ,% r - _
��-a'v. 'z.$.? f[' L�'a 3id"a , �.n - i
Modification of the lagoon, structure ' an example is'the placement of a'pipe in the dam_
without proper design ,and construction ' (Consult an expert in lagoon design before
lacingvany pipes;n dams)' `..., _ .. 4.'
ti_nspecfi i ihtain fhe darn
'.E)ces;s hvarr late ilov ing ha"lag n
4 y r` . - i.. x .t-tt'.d. .-y `s7",.m,i
Line,r inregrty = protect from -inlet pipe s+ ournng- damage,dunng sludgeremov al;
rupture front-lower€rig lagoon Jiquld Ievei below groundwater table`
NOTE If lagoon water is allowedlto overtop the -dam, the mov-ing'waterwill soonnvause
- gullies to furrn `in .the .dam Once -this damage--starts,#rt :can qurctCly cause a larger
7770ischarge ofwastewater an srble dam farrure .. �� ' -
7

4-
F
,4744.
DIVIS ON OFMATER QUALITY DWQ)g�
EMERGENCY MANAGEMENT SERVICES (EMS)
fi SOIL AND WATER CONSERVATION DISTRICT (SWCD)
ATURACRESOURCES_CONSERVATION'SERVICE (NRCS)'
OPERATIVEEXTENSION SERVICE (CES)
nsuresthat
�r ah employ
4.x
-LIS `s- LQi (�`1
S
cw)-' 55 �.5;%1?3
Il be imptementedkinthe e ent thatt wastes from your operation are leaking
t nn ng f site Y u should riot wait null:wastes reach surface w ters
�operty to con der tha%yo i have s prrobI m You should make :every effort to
hi�s�planAshould be'posted In an'accessible location:
ees a e aciIity' Lhe o_ owirrg�are some action items you sh ld t _e
�� * efgpah re eleasebilvaefes. Depending h-th situation this mayor may not be
=vim - s esponse a so ri nssib Nrrablems rel.'sted-be"tow
D.
A_dd oil to berm to increase eIcv tion ofdam;
w stes: to fields ,ai'an ac_e fable rate,,
zalt lou to iargooiliiiinedi itOy
pg contractor
alce sure noltaattra et is entering agoon
Runoff from waste application field -actions include:
a) Immediately stop waste application.
b)' Create a temporary diversion to contain waste.
c) Incorporate waste to reduce runoff.
_d) Evaluate and eliminate the reason(s) that cause the runoff.
- Evaluate the application rates for the fields where runoff occurred.
Leakage from the waste pipes and sprinklers - action include:
•.._ a) -_ Stop recycle pump.
b) Stop irrigation pump.
c) _ Close valves to eliminate further discharge.
w„ d) Repair all Teaks prior to restarting pumps.
•
Leakage from flush systems, houses, solid separators - action include:
a) - Stop recycle pump. _
b) Stop irrigation pump.
c) Make sure siphon occurs.
d) Stop all flow in the house, flush systems, or solid separators.
ossible: Sri e&te
ry
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing leaks
possible action:
a) Dig a small sump or ditch from the embankment to catch all seepage, put in a submersible
pump, and pump back to lagoon.
b) If holes are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
c) Have a professional evaluate the condition of the side walls and the lagoon bottom as soon
as possible.
8

r
nyRdamaget notes;s h a damage
"Did the spell Ieade the opera'• •
',
Does the -spill have !potentiai reach surface wet
Could a future rani event cause spill to reach stitr�waters?
Are. potable wa
.art-.ter s.rn anger ei
='R.r-�-^. property)?
welld(ther on or, off the
How much reached surface waters?
Contact a p p.rop nate agencies. ? .- `"
uring _ r rural business hours call your; DWQ, regional office, y Phone'#, After hours,
:emergency numberp(919)733 3942 Your phone call should. include your, name,: facility_
numbef, 4telephone _number,athe� detailsYof the' incident from item 2 `above, ..the exact
location of the facilitythe`location'or direction of the ;movement of the spill,,. weather and
wmdcondrtrons The correctyemeasures that have been under ,taken, and the
nssol t•ae situation�x
- If the_sp[ll leases_property:-o�eriter .,siAtf te's,3-calliocal EMS phone number '
c. Instruct EMS to contact local Health. Department.
Contact.CE's phone number, local SWCD office phone number'and the local MRCS •
office for advice I technical assistance -phone. number.
If none of the above works call 91.1.or theSherif `s'�.e0ttment_and explain your prohlerrr to
•there and ask the person'to o0ntact'the proper agencies foryou...--;-
5 Contact the -contractor of your -_choice to begin repair or problem to minimize offsite damage.
-
44:
-
b. Contractors Address: P.O. Box 856, Warsaw, NC 28398
c . Contractors Phone: [phone]
6. Contact the technical specialist who certified the lagoon (NRCS,-Consulting Engineer, etc.)
a. Name: Kraig Westerbeek
b. Phone: [phone]
•
7. Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage,'repair the system, andreassess the waste management plan to keep problems
with release of wastes from happening again.
9

• ' "l_tr&-"_•
•
• , I
--•••A •-•••
rtqr,
• ' •.1";'• '.:..."4- ..,-,1?- •-"---,--.- , ,. . Z.v.• ""'—•-t. ''''• s --n"-:::: -r-r'''' --W?..-rr'"?' •-• - _'",-;'.."'',"-r-r•,-" !.!'" t'•=r,,,,,
. -.11. iiN s4- 6-''.768n1-ii61:;1-1E'L'9. CHECKLIST FOR ANIMAL OPERATIONS ','_,.. ,:: .ii • • - ! -
-
' - -
# .47-,-- ,rot -, • . -4',. - ._ ,,,,
• ,•.,..'"-ylt-4... ''''
..4.-.:-.-Z-til. . ' " _=.4"-•\,
.: ..!:V..-P..4 • tit Mr-111 • .. ' " • 1..
--;,-,,, , ,t•
1. 1-Pilglir _.}...i".
71-A•IglIVII5rEliZiliilar.. ' .",•''''',' 't* — - -
. i. 2-• •:,. r4-i.j-fri.F:-z7. -- -,'
"'"p:Till"."-431re. '. , .43-''''''/J`" - ''.-'''" . MP''to Minimize Odor 1---- 4,4 r Site
..
;,t-i; r ,I. • r •vi -•,.., .' .;., , ,, .:'-,... ,..ff ' r•-'n: _
-...:-'v4 4 -:b44 . • ' r ....:':1:- ''I""' :- -. '' . ' ' . .
.: e r4:•'
10'',GulterififAcCuMii1ation `of sdlidSi-m--ttt(!) Flush system is designed and operated
• ,---4. ,,,--t-,•;- t•=ti:--.---7,f 4.-"s•-,-*'.. , 1,
..• ' 4."tr. :' 6.. :"'"`"---rt-, '=",, , ' , :, ." - .- sufficiently to remove accumulated
f', • ,..:7 t..4 '-.... z.:'_ .
.... - • 1,.,-,:. -i solids from gutters as designed. ,
'Remove bridging of accumulated solids at
"'" ,-:AisChaige ' -'--- ' - - 7 . -, .-77-'4'4.-77 .. .
'-'4,,..'-i:..,' Lagoifins'and'Pittia,CrUsted„Sblids .,-,;.. • ' - -
-----' - --- ----:-,:7. s=7.---. 44 •.,':7 .-...oz - 4.--., ,,,,,,ig 4,..;.'-',-'44'.", (7!,.) Maintain lagoons, settling basins and
:-..,pits,viinere pest breeding is apparent to ., .- --, ._ '-'--".
minimize the crusting of solids to a depth 4 4,,,_.,4,4-Le_4,4,-,
---1,
of no more than 678 inches over more than
bf iurface
. • .7...- . - ' - -.'..'r -
-
,--
.....,-4,,. ,:.
vegetative control along banks bf7.:t4,
, .
egbOns,ant`pttlet impoundment s ti:2--gleventy-ip, „
accurnylari Rf decaying ,vegetative rnattersq,4-*7.,
c0Ke'.94rnztUndrIe.yri. ts:;pri......„.,..teria.:,-"
,-- - -....,-- --•-,7,4,7-:42-i44,!:f-av * ...t.,:.-4...t7.47t---:--- ..
. .
- -•:,--..y...1.00f0, _.... 4!., ,r..-1 '.u.k.4 ',---?il,...A.. e-,4"4,-,4"...m-A4:::.?:"4"
:-...kit...4-N— idiftitild'maintain feed sjiStemsle7g ,---g;4-'''''''-Wrk4.6•wAisr-UF--X-r40-
--si.=
t*T-,144-111_,5)1tOrrililirtliZ,...,..p.theaaufrijilatiqn----,4,, • -", - .
3001,xaita-g-el'- --4 - - .. • - ' --
. leAtY;CIF:setlfabe'dit a routine basis (e g 7 10 day,,--- • -
riiTabdtirina,tsiiromer0 5,30 interval 7'
..1.-X-1.- - ,7-i-;,..-rf,,4.. 15, 1 .1444a,4i.-z." v",--:44.44. " - .10;-.4--tt4-4 • •-•-• -
6igaWeiiili utaticir*ithiii aficretlandriktiftW,l'
1
P0106:Rer:10P19119t fS-cs1§0T9e,.,M,PS,DY4-..0,-
, "7-•:r• --' E.:,""; ins ti rind drainage aWay frorn site and/orproviding -4- 74--,, -
,:!.,.......,-
"4.:.
'.. adequate containment (e.g., covered bin for
- .7:.-4
..-_,_, :i..,1':...--.
7 brewer's grain and similar high moisture grain -$ a
productS).
() Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed.
1.Feed S
. 14=. .
"s,"4:
- = Animal Holding Accumulation of animal () Eliminate low area that trap moisture along fences
Areas wastesand feed wastage '-4,* ' -and other locationswhere waste accumulates and
i7=47 4 •••''v disturbance by animals is minimal. . •
4( ) Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e. inspect for and remove or break up accumulated
solids as needed).
•.".."••.4
MIC - November 11, 1996
£
•
•
10

impoppanwpiplomk
Y; ;
r •"�.
`: �iasnrr
.,. - - - _ .• '«r,.�.-_�.'-•---`'h •fir
Dry Manure Handling
Systems
... .. fr.:In-
ie.:
or disp
{ } Provide �E
( ) Inspect ' _ -nd (em0
in filter strips around s
areas as needed.
age around manure
break up accumula
piles andrnanure,h
The is-Suess checketl pertain to this. operation The landowner / integrator, agrees to use
t)
.-..v<+: ` r •. ..�.-s- >.'. '-+bs?fir`=.+r - ter : ...,.� -�{.� --_� �., .:.= 7tib�,.:. x� �• N
"sound judgment in applying` insect control measures as practical:
1 certify the, aforrementioonned insect control Best Management Prractices�have beee
reviewed with me_.�A �� . `.
mar .fi F _
•
For more information contact the Cooperative Extension Service, Department of Entomology, Box
7613, North Carolina State University, Raleigh, NC 27695-7613.
AMIC -- November 11, 1996
•
11

-
r
ettlmg bsrn 'n' r#ial rrii ' ial°dF coin
surface a osition d wh le filling
y Agitation w :ernptVing
Manure, slurryor;'- Agitation when spreading
sludge spreadert-04Volatile gas emissions
outlets -e`
Dead animals Carcass decomposition
t. Dead animal
disposal pits
Incinerators..
atcass decomposition.`
Eli m aTriftirri anon
z SWIRE
5wir'e I?
•SwE
►{.iI: iid le vel loading
;care ;
krfaoa01.140 of solids
iojt,lr yt�: additives or oxidants
:1. ■ :-r _
crt�np p=.'Toutlets underneath lrqu
Re >> '_settled -sol ds regular!
E )Soil injection of slurryisludges
'')Wash residual manure from spreader after use
`)Provenbiological additives or oxidants
)Proper disposition of carcasses
)Complete covering of carcasses in burial pits
)Properaocattion 1 construction of disposal pits
')Secondary stack burners
Farris access road maintenance";
awa rosn-facElifies
4y` AZailable Frorr
BMP
?lint inn ` �Pote6 i b '�urec s and Prfie ies BAb act Sheet } NI;SU BAE s
yr. a� bli .!`ems`_ „ get L 7reatm_'I
uctiorl acita _ panllr larlagE<rnenr�,t Fecharg a Lagob� T[eatmenf EBAE128 8$IVCSU BAE
rht Van.
a age
:.C�alibra ion o Manure an as
Controlling Odors from Swine Buildings PIH-33 _ _ NCSU-Swine Extension
Environmental Assurance Program:.NPP.0 Manual NC Pork Producers
Assoc': ' _ - nr., :..
options for Managing Odor a report from the Swine_ Odor Task Force
Nuisance -Concerns in Animal Manure Management:, Odors'and Flies;,PRO101,
1995 Conference Proceedings
NCSU County Ex4ertsron Centte
g rtt- 1 Z 88NQSU BAE
a - ea , ent and .torage _ EBAE103 83NCSU BAEr
ewa er p ica iota q i me E"FaeEst" NCSU BAE'
�;
The -issues checked O prtainto this operation ;The landowner! integrator agrees to
'use sound judgment In applying_odor'cdntroT measures as practical.
NCSU Agri Communication
Florida Cooperative Extension
1 certify the aforementioned odor control Best Management P actices have been reviewed
with ne.
(Land. ,'r Signature)
13

-7 OC -alit ana
. lndreate �t;iiic 1i, ff�.
When'selectrnr t{n'e`7+7c1 s ► r1
.4.44600 atijj.1 I of
i
Secondac ` r
Y Routine Mortality -
Burial three feet beneathtl�e surface of the grourl
l'=1 death ;The°burial must beat least.300 feet fromnyEflowing st eam or:publEc body of water _
(G S 106-403) 4Thebottom' of the _burial pit should' be at:least one foot above the seasonal
high water table Attach burial location map and planes P' 4 r ! �= 5 `'dp 1 � y-4 �'��+e• ' 2 �fr,"-�r- - �, . �;� •xs a".t � � xie�i"j`� �'` ��'$;�3s E �- � �•35�. � ,u�,tl,.y� �..''�.�- �� ,.
�,
Landfill at municipal `solid waste facility permitted by NC DEQ under GS' 15A NCAC M=
Version—NDvember 26, 2(115
�G m eh et h ods_
�i:iIlii3r}f b'tISL15S ..i. 'r ili r. tIfi:
p ) (.,ev carrp� V7.
s
endermg at a rendering plant licensed under;
! , '
within;24 hours ar,kriu Medge. of animal'
mplete finer er tibrocco cl� g
-oompostmgsystern approved and permitted by.the IvF 6.1enlro
Utner Services. Veterinary Division (,attach cagy of permit 73 o'
rddif`onal requirements must be,met and a permit is required
p,
:Lsethro tOn line FV zlnana au d i ah r slhi
thesalva�e _o „�sr3A 9 iitta`‘t ngehr9141Mataitn al a t
�(Wrrtterm' p o l b' 'the�`5 w i t rtrtdrlarir iist l t ached
Klass Mortality Plan z
.-; Mass mortality plans are r•equired for farms covered by an NPDES permit These plans are
'also recommended for all animal operations This plan outlines farm -specific mortality man ,-
agement methods to be used for mass mortality! ;The NCDA&CS VeterinaryDivision sup„
ports a variety of emergency mortality disposal -options,, con act Division:for guidance:
REiAEW1I A catastrophic mortality disposal plan is tart of thefacility's CAWMP and is activated E...
R On
I when numbers of dead animals exceed normal mortality rates as specified by the State . -.
Veterinarian. e" '
®' Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary r
N
,�T�' - Division regulations and guidance. --- - ` - ' -
ReeSi �►OPat ® -Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
z
nature of Farm Owner/Manager Date .
Niat-Lc1--
echnical Specialist Date

• ,
• •
- P. • • • 1..
•

Grower: Marshall Phillips
Address: 903 Wards Bridge Rd
Warsaw, NC 28398
County: Onslow
- gtih ' •
• G)ishin
ferrbw -to weariling.
= •
Earrow.to-feeder.
-=-13oar8:7,
St6eag-e 'Period: •
25 Yr./ 24.Hr..St&rri'lient •
- -
"Heavy -Rai" Factor
Rginfa(1-in Excess of,Evapotptioh
AdditionaThWater
- .
Additional:13raing6
- ikWiTaria
Side 816pet:
Inside Top l_erigth: „ -
Inside Top Width
Top of Dike Elevation
Finished Bottom Elevation
Start Pump Elevation
Stop Pirri3
•
TOTAL VOLUME NOT ADEQUATE"
LAGOON VOLUME REQUIRED VOL.
Storm Stor =
Temporary =
Permanent =
Total Volume2=
• 96218 (Cu.Ft.)
79380 (Cu.Ft.)
1082495 (Cu.Ft.)
1,258,093 (Cu.Ft.)
Designed By: 1MW
Checked By: DSE
Date:
Sheet 1 of 7
Depth
8.80 Ft.
20.4 In.
- 24 In.
DESIGN VOLUMES
99,449 (Cu.Ft.)
42,156 (Cu.Ft.)
915,628 (Cu.Ft.)
1,057,233 (Cu.Ft.)
1/2 Treatment Volume =
1/2 Treatment Volume Elevation =
90 Temporary Storage Volume Elevation =
541,248 (Cu.Ft.)
43.89 Ft.
45.41 Ft.
Min. Required Liner Thickness
Lagoon Surface Area: (Inside TOD)
707.0 Ft.
204.1 Ft.
48.60 Ft.
39.80 Ft.
46.90 Ft.
46.60 Ft.
% REQ'D.
103.36%
53.11%
84.59%
84.03%
56.48 In.
38.28 In.
1.5 Ft.
144,327 S.F.
••
12,121f5Wciagr
Murphy -Brown, LLC Engineering
P.O. Box 856 ,Warsaw, NC 28398
[phone]

Grower: Marshall hillips
Address: 903 Wards Bridge :Rd.
Warsaw, NC 28398:,�af
County: Onslow'
STRT PMP EL.= 46.90 s': 1 .41:
END PMP EL. = 46.60
Murphy: -Brown, LLC Engineering
FINISHED BOTTOM ELEV= 39:8

4.7
of Lagoon: 4,
Start'Pump: 44.2E"
us r�Side Slopes: 3 :1
Lagoon Area (Acres): 0.80
Bottom to Water Level: • 6.80
~- - Maximum Liquid; Levei to the
Present Liquid Level: ? �Q
Freeboard:�� r

i =rower:
Actress:::
Marshall Philips
903 Wards Bridge Rd
Warsaw, NC 28398
. pnslow
NALRO3IC WASTE
Ri ATIM • - "
, Nursery:
Finishing:
:Farrow to weanling:
1� Farrow to, feeder:
Farrow to finish , '
r z z Boars: -
Stora-$Period
25Yr'/24.Hr ttorm Event
"Heavy`Rarn" Factor
Rarifali h Excess.`of!Evaporation
Ad`dicral Wier Uae
i ona ray eArea
�.brain;Ta1�
S &5f]C3�i ig
Designed By. KBW
Checked By: DSE
Date: 02/26/16
Sheet 3of12 — -
'Erne ciy Spfllway Flow Depth Not pl bt4gen howny
Side Slopes
Inside Top Length
Inside Top Width:
Top of DikeElevation:
Finished Bottom Elevation:
Start PumpElevation
Stop :Pump: -Elevation
•
Depth
10.40 Ft.
34.8 In.
87.96 In.
LAGOON VOLUME REQUIRED VOL. DESIGN VOLUMES
Storm Stor
Temporary =
Permanent =
Total Volume =
185463 (Cu.Ft.)
415583 (Cu.Ft.)
0 (Cu.Ft.)
601,046 (Cu.Ft.)
90 Temporary Storage Volume Elevation =
Min. Required Liner Thickness
Lagoon Surface Area: (Inside TOD)
186,576- (Cu.Ft.)
417,109 (Cu.Ft.)
275,131 (Cu.Ft.)
878,815 (Cu.Ft.)
37.73 Ft.
374.9 Ft.:/
268.5 Fl(
43.90 (t.
33.50 Ft.
41.00`Ft.
36:57 Ft:
REQ'D.
-1
100.60%
100.37%
146.21%
74.07 In.
1.5 Ft.
100,660 S.F
Murphy -Brown, LLC Engineering
P.O. Box 856 ,Warsaw, NC 28398
[phone]

Grower:
Address:
County:
Marshall Phillips •
903 Wards Bridge,I3d
- Warsaw, NC 28398 '
Onslow
Top of Dike= Elevation.
Emergency Spillway CrestElevation
Top of 25Yr. / 24Hr ,Storm Storage
Top of Heavy#Rain'.;;Storage7
Start Pump Elevation °
End Pump Elevation
Top,of Sludge Storage .�
Seasonal High.Watertable Elev
Finished Bottom Elevation
Insi e Top Len
Inside-,..
Side Slopes
Lagpon Surface:Area °
Min`Linei th rckness,(if=required) -
Freel4 rCtDe'-
Zone Depths:
= -sJOTA-CD
a�-
Treatment / Sludge Storage Zone Depth
Temporary Storage Zone Depth =
Freeboard/ Storm Storage Zone Depth _
Designed By: KBW
Checked By: DSE
Dater- .::" 02126./16
Sheet 9 of 12
Not Applicable -
42 90 `FT
ot;Appliceble
41.00, FT
36.57 FT'
$Not Applicable
000
33 50 AFT
74'aFT
81
1.0:1 H:V
"iG4; 60"SF.''""_-
1:00=.-
-- `';-' 49
-417 815(CUFTi�+F_ .__- ,
�t�
3.1 FT.
.4fT
2.9 FT.�
Total Lagoon Depth
Murphy -Brown, LLC Engineering
P.O. Box 856, Warsaw NC 28398
(910) 293-34:

Grower:
Address:
County:
Marshall Phillips
903 Wards Bridge Rd
Warsaw, NC 28398
Onslow
STRT PMP EL.= 46.96
END PMP EL. = 0.00
Murphy -Brown, LLC Engineering
1
1
1
1
1
:.;.ZONEELEVATIONS lsi:STAGE
it. t
:4;1?":-. •
OFDIKE'ELEV2t 48.60
it
•
1"PF.,•'STORM ELEV=.47.60
„...,
-111 It
,17!
;7,019,._ •
ji`irOtir MRZTORAGEELEV = 46.96
;TREAT;ELENtii=',0.00
,•, •, ,•„t
P.O. BO'.856;Wairsaw'1\1C:283961q.
Designe KBW
Checker DSE
Date: 02/26/16
Sheet 10 of 12
/
/
Si-1\11[7 -17

- �• -s'S16[C :'JrmL6+s.�� +r: evF'�' • aeP�ll: .
- rower: �larsl rail Phillips
Address: 903 Wards Bridge Rd
Warsaw, NC 28398
County: Onslow
ANAEROBIC
FARM INFORMATION
Nursery:
Wean to Finish:
Finishing:
Farrow to weanling:
Farrow to feeder:
Farrow to finish:
Boars:
Storage Period:
25 Yr. / 24 Hr Storm Event
"Heavy Rain" Factor
Rainfall in Excess of Evaporation
Additional Water Usage
Additional Drairiage Area:"
LAGOON INFORMATIO
Is Lagoon oesigned.as awn Irregular Shape
an
Does Operator Wt Emergency Spillway
Was Thispesign Built Pnorjto Sept19�"'
Is Drain Tile Req'd to Lower'SHWT'
Seasonal High Water. Table.Elev.
Freeboard >
Emergency Spillway Flow Depth:
Side Slopes:
Inside Top Length:
Inside Top Width:
Top of Dike Elevation:
Finished Bottom Elevation:
Start Pump Elevation:
Stop Pump Elevation:
esigned by:
Checked By: DS
Date:
Sheet,-1 of 7
'WASTE' • ((;a- '3i Irk
Not Applicable
LAGOON VOLUME
Storm Stor =
Temporary =
Permanent =
Total Volume =
•
Not Applicable:' '.
02/26/16
it
0
0
0
0
0
8.0 In.
6.6 In.
1 :1 (H:V)
150.5 Ft.
220.7 Ft.
Depth 45.50 Ft.
8.30 Ft. 37.20 Ft.
20.76 In. 43.77 Ft.
24 In. 43.50 Ft.
TOTAL VOLUME NOT ADEQUATE111!
REQUIRED VOL. DESIGN VOLUMES
22141 (Cu.Ft.)
18266 (Cu.Ft.)
216430 (Cu.Ft.)
256,837 (Cu.Ft.)
23,538 (Cu.Ft.)
8,571 (Cu.Ft.)
185,990 (Cu.Ft.)
218,098 (Cu.Ft.)
1/2 Treatment Volume =
112 Treatment Volume Elevation =
90 Temporary Storage Volume Elevation =
Min. Required Liner Thickness
Lagoon Surface Area: (Inside TOD)
108,215 (Cu.Ft.)
40.98 Ft.
42.39 Ft.
% REQ'D.
106.31%
46.92%
85.94%
84.92%
54.23 In.
37.29 In.
1.5 Ft.
33,211 S.F.
Murphy -Brown, LLC Engineering
P.O. Box 856 ,Warsaw, NC 28398
[phone]

Grower
Address:
County:
Marshall Phillips
903 Wards Bridge Rd
Warsaw, NC 28398
Onslow
Murphy -Brown, LLC Engineering
P. c)::, Box 856; •vVareaw".NC 2839p.'
•`' ''••," •
Designe KBW
Checker DSE
Date: 09/23/15
Sheof,6,ot 7
, .
[phone]