660041_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 66-0041 Certificate Of Coverage Number: AWS660041
2. Facility Name: Blue Rose 4
3. Landowner's Name (same as on the Waste Management Plan): Blue Rose Inc
4. Landowner's Mailing Address: 426 E Main St
City: Conway State: NC Zip: 27820
Telephone Number: 434-594-6144 Ext. E-mail: mattmiles64cjgmail.com
5. Facility's Physical Address: Old Place Ln
City: Conway State: NC Zip: 27820
6. County where Facility is located: Northampton
7. Farm Manager's Name (if different from Landowner): Matthew G Miles �i �q/�
8. Farm Manager's telephone number (include area code): 434 661 7049-Ext. 4'. ". / / 4" L1Y9
9. Integrator's Name (if there is not an Integrator, write "None"): Murnhs -Brown LLC
10. Operator Name (OIC): Matthew G. Miles Phone No.: 434-594-6144 OIC #: 988420
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Swine - Feeder to Finish 600
Operation Types:
Swine Cattle lire Pouitrr Utter i vpes
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultr
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
MAIN
/ `.
:. .4. h014t1
Pr I,;, S
�2, Po -
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), signed In the owner and a certified technical specialist containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, �siignaturee ss ould be by a principal executive officer of the corporation):
Name: I I7a4I4 ``� ri11L Title: 1 7(e5eZ i
Signature: '7/ 114- 4 ) J / �` Date: 3'24'0/2
Name: Title:
•Signature: Date:
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER.
Governor
MICHAEL S. PECAN
Serrpmry
LINDA CULPEPPER
rtfreetor•
NORTH CAROLINA
Environmental Quality
February 27, 2019
Blue Rose Inc
Blue Rose 4
426 E Main St
Conway, NC 27820
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
ryryi`-; Yam'' tn
MAR 29Mi9
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https://deq.nciov/about/divisions/water-resources/water-uualitt -regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure ■ our continued coverage under the State Non -Discharge General Permits. t ou must submit an application for
permit coverage to the Division. Enclosed t ou will find a "Request for Certificate of Coverage Facility Currenth Covered bt an
Expiring State Non -Discharge General Permit." The application form must be completed. signed and returned bs, April 3, 2019.
Please note that 1'ou must include one 11) cool of the Certified Animal Waste Management Plan iCAWNIPI with the
completed and signe_d application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Raleigh Regional Office, Water Quality Regional Operations Section
Northampton County Soil and Water Conservation District
AFOG Section Central Files - AWS660041
Murphy -Brown LLC
tWnt s.r� �a3epa-ttre•tori.Er rar^rerts Q:.a'tp 1 3ys),ofWater Rese�-roes
5i2'N_ Sa att.1 St. l 163€ h's Sr'e3e e-ter 1 Ra _ , tvrt7 t."a*,'•a 276S9-SS36
�, ,.- 919.737w23.^,

Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
O ❑
O O
O O
O ❑
[ErO
El El
El El
Version —November 26, 2018
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the, professional opiniorof the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
�l(
Signature of Farm Owner/Manager Date
Signature of Technical Specialist Date

Steven W. Troxier
Commissioner
Mr. Matthew Miles
The DM] Group LLC
426 East Main Street
Conway, NC 27820
North Carolina Department of Agriculture
and Consumer Services
Veterinary Division
Swine Farm 911 Address:
Blue Rose 3 Farrn
1174 Jenkins Mill Road
Conway, NC 27820
Northhampton County
State ID: 555314224
National ID: OODQTXS
Dear Mr. Miles:
April 12, 2013
Swine Farm 911 Address:
DMJ l (Composter Location)
388 Zion Church Road
Conway, NC 27820
Northampton County
State ID: 555314223
National ID: OODQVFJ
Swine Farm 911 Address:
Blue Rose 4 Farm
237 Old Place Lane
Conway, NC 27820
Northampton County
State ID: 555314229
National ID: OODS5N
1;ill
CVi�►.�De r/ —' marl
/'l 47ew /i1i/U
David T. Marshall, DVM
State Veterinarian
Swine Farm 911 Address:
DMJ 2 Farm
190 Deer Trail
Rich Square, NC 27869
Northampton County
State ID: 555313072
National ID: OODSZLE
Swine Farm 911 Address:
Blue Rose 7 — Jenkins Farm
1651 Bridgers Road
Woodland, NC 27897
Northampton County
State ID: 555313883
National ID: OODS6D2
Pursuant to NCAC 52C.0102, your request to compost swine mortality on your premises at 388 Zion
Church Road, Conway, NC and from your four other premises listed above is approved. The approval is
granted under the following conditions and stipulations:
1. All North Carolina solid waste, air, water quality, and other applicable regulations must be met in
siting and operation of the system
2. Only poultry or swine are to be processed in this facility; NO bovine, caprine, ovine or cervid
species shall be processed
3. Mortality to be processed shall originate only from the identified premises and the finished
product is used solely on agricultural operations owned, operated, or leased, by the permitee
4. The final product of the process must be stored, treated and utilized in accordance with all federal,
state, and local laws, regulations, and permit requirements; the final product shall not be sold
5. Temperatures shall be within NRCS guidelines to reach a minimum of 131 degrees F within 5
days of filling the unit and remain at least at 131 degrees F for a minimum of 5 consecutive days
to maintain the composting process and reduce pathogen load
6. Dead animals are not to be removed from composting until all flesh, internal organs, and other soft
tissue are fully decomposed
7. The proposed facility shall have the following minimum setback requirements*:
1030 Mail Service Center, Raleigh. North Carolina 27699-1030 e [phone]
An Equal opportunity Affirmative Acllon Employer

• 100-foot buffer between all property lines and compost areas
• 100-foot buffer between all wells and compost areas, except for monitoring wells
• 50-foot buffer between perennial streams/rivers and compost areas
8. A copy of the permit, plans, and operational reports shall be maintained on site and be available
upon request by NCDA&CS, Veterinary Division personnel
9. The facility and operational records shall be available for annual inspection be Veterinary Division
personnel and shall be sent to the Veterinary Division upon request
10. Operational reports shall include temperature monitoring during initial facility start-up and follow-
up records that contain either 10 days/month or annual laboratory results of pathogen load testing
11. An application for a permit modification shall be required for changes in facility ownership, an
increase in facility capacity, or any other changes from the stipulations of this permit
12. In the event that movement of carcasses from the premises of origin to the compost facility on
another premises is specifically permitted by NCDA&CS, the owner must comply with conditions
in GS I06-168.8 (5) and (6) followed by licensed renderers: The carcasses must be transported
within 24 hours of death in a leak -proof vessel or vehicle with a cover, to prevent spread of
disease by flies or other agents during the transportation. Prior to movement from the premises of
origin, the vessel or leak -proof container or vehicle containing the carcasses must be disinfected
following loading of carcasses, to prevent the spread of disease. Following unloading at the
composter, the vehicle or vessel must be cleaned and disinfected prior to leaving the composter
premises. The person loading and transporting the carcasses must wear rubber boots and suitable
protective clothing. The boots must be disinfected prior to entering the premises with carcasses to
be moved, as well as after unloading carcasses at the compost facility, prior to leaving that
premises or entering a public area. Contaminated protective clothing must be discarded or
removed and safely disposed of to prevent carrying disease organisms away from the farm of
origin or the compost facility.
13. The Veterinary Division must be immediately notified of any complicating issues involving
animal disease or environmental concerns
14. The State Veterinarian reserves the right to cancel this permit if a specific concern for controlling
animal disease arises, or if any of the aforementioned conditions are not met.
This document shall in no circumstances be interpreted as an endorsement of any specific manufacturer or
type of mortality management system by the State Veterinarian and the Office of the State Veterinarian
does not approve or disapprove the technical or performance standards for specific makes or designs of
equipment.
*Additional requirements and regulations will apply from DENR, Division of Solid Waste Management if
application for off -farm disposition of composted material is requested (see G.S. 130A-309.29 and 15A
NCAC I3B, Section .1400
Sincerely,
Dr. Tom Ray, DV11+)<, MPH
Director of Animal Health Programs/Livestock
cc: Dr. David Marshall, State Veterinarian
Dr. Sarah Mason, Director, AHP-Poultry
Dr. Jim Kittrell, Veterinary Medical Officer
Mr. Paul Boone, NRCS

Murphy -Brown, LLC 6/2/2016
NUTRIENT UTILIZATION PLAN
2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
Grower(s): Blue Rose, Inc.
Farm Name: Blue Rose 4; AWS660041
County Northampton
Permit Ca • ac
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Wean to Finish
Feeder to Finish 600
Gilts
Boars
Storage Structure: Anaerobic Lagoon
Storage Period: >180 days
Application Method: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWR regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 11

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
Capacity Type Waste Produced per Animal Total
600
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Wean to Finish
Feeder to Finish
Gifts
Boars
3203 gal/yr
3861 gal/yr
10478 gal/yr
191 gal/yr
776 gal/yr
927 gal/yr
1015 gal/yr
2959 gaUyr
gal/yr
gal/yr
gal/yr
gal/yr
gal/yr
556,200 gal/yr
gal/yr
gal/yr
Total 556,200 gaUyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Nitrogen Produced per Animal Total
600
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Wean to Finish
Feeder to Finish
Gilts
Boars
3.84 Ibstyr
6.95 Ibstyr
18.86 Ibstyr
0.34 lbs/yr
1.4 Ibstyr
1.67 Ibstyr
1.83 Ibstyr
5.33 Ibstyr
Ibstyr
Ibstyr
Ibs/yr
Ibstyr
Ibstyr
1,002 Ibstyr
Ibs/yr
Ibstyr
1,002 Ibstyr
_
Total
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage:
Total N Required 1st Year:
Total N Required 2nd Year:
Average Annual Nitrogen Requirement of Crops:
Total Nitrogen Produced by Farm:
Nitrogen Balance for Crops:
6.6
2303.40
0.00
2,303.40
1,002.00
(1,301.40)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 11

Reception Area Specifications
Tract Field Irrigated Soli 1st Crop Time to 1st Crop 1st Crop Lbs N/Ac Lbs N Total Iba N
Acreage Type Code Apply Yield Ibs NIUnit Residual /Ac Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs N/Ac Lbs N Total Ibe N
a Code Apply Yield Ibs PI/Unit Residual IAc Utilized
Total
Lbs NIAc
Total
1 UtIII
T239
1
1.41
Goldsboro
C
Mar -Sept
6.50
46.00
299.00
421.59
L
Sept -Apr
1.00
50.00
50.00
70.50
349.00
492
T239
2
2.34
Goldsboro
C
Mar-Seps
8.50
46.00
299.00
699.66
L
Sept -Apr
1.00
50.00
50.00
117.00
349.00
81E
T239
3
2.85
Norfolk
C
Mar -Sept
6.50
48.00
299.00
852.15
L
Sept -Apr
1.00
50.00
50.00
142.60
349.00
994
OPTIONAL
Land
T2877
4
3.41
Norfolk
D
Feb15-June
138.00
0.95
131.10
447.05
0.00
0.00
131.10
447
T2877
5
3.22
Norfolk
D
Feb/5-June
138.00
0.95
131.10
422.14
•
0.00
0.00
131.10
422
T2877 J
6
3.23
Norfolk
D
Feb15-June
138.00
0.95
131.10
423.45
•
0.00
0.00
131.10
423
T2877
7
3.27
Norfolk
D
Fnb15-June
138.00
0.95
131.10
428.70
0.00
0.00
131.10
428
T2877
8
2.29
Norfolk
0
Feb15-June
138.00
0.95
131.10
300.22
*
0.00
0.00
131.10
300
T2877
9
0.88
Norfolk
D
Feb15-June
138.00
0.95
131.10
116.37
*
0.00
0.00
131.10
115
T2877
10
1.38
Norfolk
D
Feb15-June
138.00
0.95
131.10
180.92
•
0.00
0.00
131.10
180
T2877
11
1.13
Norfolk
D
Feb15-June
138.00
0.95
131.10
148.14
•
0.00
0.00
131.10
148
T2877
12
0.72
Norfolk
D
Feb15-June
138.00
0.95
131.10
94.39
0.00
0.00
131.10
94.
T2877
13
2.88
Norfolk
D
Feb/5-June
138.00
0.96
131.10
377.57
•
0.00
0.00
131.10
377
T2877
14
3.27
Norfolk
D
Feb15-June
138.00
0.95
131.10
428.70
•
0.00
0.00
131.10
428
T2877
15
1.33
Norfolk
D
Feb15-June
138.00
0.95
131.10
174.38
•
0,00
0.00
131.10
174
OPTIONAL
Crops
T2877
Any
Norfolk
F
Mar15-July
875.00
0.09
77.88
0.00
T2877
Any
Norfolk
CC
Sept -Apr
1.00
30.00
30.0D
0.00
Note: Amount applied
to cover crop must be deducted From following
crops starting
PAN rate
Totals: 6.60 1973.40 330.00 2317
3(a) of 11

Reception Area Specifications
Tract Field Irrigated Soli 1st Crop Time to 1st Crop let Crop Lbs N/Ac Lbe N Total Ibs N
Acreage Type Code Apply Yield Ibs N1Unit Residual /Ac Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbe N/Ac Lbs N Total Ibe N
Code AAplr Yield Ibs NIUnit Residual /Ac Utilized
Total
Lbs NIAc
Total Ibi
Utilize
totals: 0 0 0
3(b) of 11

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definitely interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
A
B
C
B/C
D
E
F
G
H
J
K
L
M
N
0
P
S
CC
Barley
Grazed Hybrid Bermudagrass
Hybrid Bermudagrass Hay
Comb. Hybrid Bermudagrass
Com - Grain
Com - Silage
Cotton
Grazed Fescue
Fescue Hay
Oats
Rye
Grazed Overseed
Overseed Hay
Grain Sorghum
Wheat
Soybean
Pine Trees
Small Grain
Cover Crop
Description -Harvested As
Grain Crop
Pasture/Grazed
Hay
Graze/Hay Combination
Grain Crop
Silage
Cotton Lint
Pasture/Grazed
Hay
Grain Crop
Grain Crop
Pasture/Grazed (Seeded in Bermudagrass)
Hay (Seeded in Bermudagrass)
Grain Crop
Grain Crop
Grain Crop
Pine Trees
Grain Crop/ Hay (After Grain Crop)
Not Harvested; Bumed/Disked In
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 11

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Wean to Finish
600 Feeder to Finish
Gilts
Boars
PAN/yr/animal
0.8
0.96
3.9
0.07
0.27
0.34
0.39
0.55
Farm TotaIvr
204
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 204 pounds of plant available nitrogen per year and will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
ff you remove the sludge every 5 years, you will have approximately 1020 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 3 acreas of land. If you apply the sludge
to com at a rate of 125 pounds per acre, you will need 8.16 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 11

The following is provided as a guide for establishing application rates and amounts.
Soil Application Rate Application Amount
Tract Hydrant Type Crop in/hr * inches
T239 1 Goldsboro C 0.4 1
T239 2 Goldsboro C 0.4 1
T239 3 Norfolk C 0.5 1
OPTIONAL LE
T2877 4 Norfolk D 0.5 1
T2877 5 Norfolk D 0.5 1
T2877 6 Norfolk D 0.5 1
T2877 7 Norfolk D 0.5 1
T2877 8 Norfolk D 0.5 1
T2877 9 Norfolk D 0.5 1
T2877 10 Norfolk D 0.5 1
T2877 11 Norfolk D 0.5 1
T2877 12 Norfolk D 0.5 1
T2877 13 Norfolk D 0.5 1
T2877 14 Norfolk D 0.5 1
T2877 15 Norfolk D 0.5 1
OPTIONAL Cr
T2877 Any Norfolk F 0.5 1
T2877 Any Norfolk CC 0.5 1
?r crop must be deduct(
6of11 MAR 292019
-;v1tc ualty

Additional Comments:
This plan revised to reflect wetted acreage for the facility and the additon of
optional land and crops. The production and application rates have been
updated to reflect current rates as listed on the NCSU Nutrient Management
website.
7 of 11

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Blue Rose 4; AWS660041
Owner: Blue Rose, Inc.
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWR before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWR upon request.
Name of Facility Owner: Blue Rose, Inc.
Signature:
66.1- g5-• .1.;“ 1)1 7netod- Pa 4ria..20/4
Date
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist:
Affiliation:
Address:
t99AA- Pik
rasvG2 n9v6
M. Kevin Weston
7f0,2°i/
Date
Smithfield Hog Production Division
2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
Signature: ,4, (4/2 /(
Date
8 of 11

1
2
3
NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation,. increase in the number of animals, method of
application, recieving crop type, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based upon soil type, available moisture, historical data, climatic conditions,
and level of management, unless there are regulations that restrict the rate of applications
for other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field
(See USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See 'Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and
flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is not
covered with waste to a depth that would inhibit growth. The potential for salt damage from
animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste/nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of the crop or forages breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following: The
outer perimeter of the land area onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential property boundary and canal. Animal
waste, other than swine waste from facilities sited on or after October 1, 1995, shall not be
applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by
the landowner
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by discharge
or by over -spraying. Animal waste may be applied to prior converted cropland provided the fields
have been approved as a land application site by a "technical specialist". Animal waste shall not
be applied on grassed waterways that discharge directly into water courses, and on other grassed
waterways, waste shall be applied at agronomic rates in a manner that causes no runoff or drift
from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be
discharged into the animal waste management system.
10 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
17 A protective cover of appropriate vegetation- will be established on all disturbed areas (lagoon
embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to protect the
vegetation. Vegetation such as trees, shrubs, and other woody species, etc., are limited to areas
where considered appropriate. Lagoon areas should be kept mowed and accessible. Berms and
structures should be inspected regularly for evidence of erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is responsible for
obtaining and implementing a "closure plan" which will eliminate the possibility of an illegal
discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to
prevent breakdowns, leaks and spills. A regular maintenance checklist should be kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct human
consumption. However, if animal waste is used on crops for direct human consumption, it should
only be applied pre -plant with no further applications of animal waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the temporary
storage (pumping volume) of all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will be required to mark the maximum
storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually at crop
sites where waste products are applied. Nitrogen shall be the rate -determining nutrient, unless
other restrictions require waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the soil shall be monitored
and alternative crop sites shall be used when these metals approach excessive levels. pH shall be
adjusted and maintained for optimum crop production. Soil and waste analysis records shall be
kept for a minimum of five years. Poultry dry waste application records shall be maintained for a
minimum of three years. Waste application records for all other waste shall be maintained for a
minimum of five years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
11 of 11

iue / Rose 4
M6130041
tale 1'=3001`
Pull # Acres
1 1.41
2 2.34
3 2.85
4 3.41
5 3.22
6 3.23
7 3.27
8 2.29
9 0.88
10 1.38
11 1.13
12 0.72
13 2.88
14 3.27
15 1.33
Total 33.61
Field boundaries drawn based on Goole mo s s
Specifications: Pulls
Ocmis R2 Reel
225 GPM; 280' WD
180' Lane Spacing (TYP)
6 1 2016

WASTE UTILIZA iaN PLAN
ANIMAL WASTE UTILIZATION AGREEMENT
(Needed only if additional land has to be leased, etc.)
11 4Vorw\ �,. , hereby give /at ie05 e :-/'/C- UK
permission tQ apply animal waste from his Waste Utilization System on ?Mt acres
of my land for the duration of time shown below.
understand that this waste contains nitrogen, phosphorous, potassium, and other
trace elements and when properly applied should not harm my land or crops. I also
understand that the use of waste will reduce my needed for commercial fertilizer.
Adjacent Landowner:
Date:
Waste Producer: eke C • Date:
Technical Representative: Date:
SWCD Representative: / Date:
Term of Agreement:L
"7/ / .} 419 to L/ r 20
(Minimum of Ten Years on Cost Shared Items)
(See Required Specification No. 2)
3-.26 201
Page 9

ANIMAL WASTE UTILIZATION AGREEMENT
"(needed only if additional land has to be leased etc.)
I Ass --ew hereby give bi /12 ?eps1 -' a permission
to appl imal waste from his Waste Utilization System on 7, O / acres of
my land for the duration of the time shown below.
I understand that this waste contains nitrogen, phosphorous and other trace elements and
when properly applied will not hurt my land or crops. I also understand that the use of
waste will reduce my need for commercial fertilizer.
Adjacent Landownirr '�`� Date
Waste Producer l c IrtC Date
Tech Representative Date
SWCD Representative Date
Terms of Agreement l '' / 20/4 to
(Minimum of 10 years on cost share items)
L/ -a0f,
/-/-2o/t
20 /1

EMERGENCY ACTION PLAN
PHOL NUMBERS
DWQ / -- 5 . 4 "' . 1 ^ fit,
EMERGENCY MANAGEMENT SYSTEM ii 9- v V 6 9 l%
SWCD _a5 53 y- d NRCS ..r a a..• .) 7 !
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Cali a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e..: Evaluate the application rates for the fields :where runoff occurred.
----- C:—Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D: Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle -pump:
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
1 December 18, 1996

e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks- possible action:
a. Dig a small sump or ditch away from the embankment to catch all seepage,
put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what .duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality)
regional office; Phone - - . After hours, emergency number: 919-733-3942.
Your phone call should include: your name, facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility, the location or
direction of movement of the spill, weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number -
-
c. Instruct EMS to contact. local Health Department.
d. Contact CES, phone number°..'-: _'- . , local SWCD office phone number - - •
and local NRCS office for advice/technical assistance phone number 4 - -
ain
4: If none of the above works and ask that person to 911 or toontact the proe Sheriffs Department agencies and
you. your
problem to them
5: Contact the contractor of your choice to begin repair of problem to minimize off -site
damage.
a. Contractors Name:
b. Contractors Address: P IC. " kxa
c. Contractors Phone: -
-�s� 53 -/aV5

6: Contact the technical specialist who certified the lagoon (NRCS, Consulting
Engineer, etc.)
a. Name: To 6 A b
b. Phone: q;9, 551-,2,5''t
7: Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
..:1',:ii077_1111,ZP1'4117067,71711
MAR 292019
3 December 18, 1996

Swine Farm Waste Management Odor Control Checklist
Source Cause BMPs to Minimize Odor
Farmstead • Swine production 7-Vegetative or wooded buffers
Recommended best management practices
Er600d judgment and common sense
Animal body • Dirty manure -covered .a -`Dry floors
surfaces animals
Floor surfaces
Manure collection
pits
• Wet manure -covered floors 1lotted floors
'Waterers located over slotted floors
a -feeders at high end of solid floors
-Scrape manure buildup from floors
Ii 0 Underfloor ventilation for drying
Site Specific Practices
• Urine
• Partial microbial
decomposition
Frequent manure removal by flush, pit recharge,
r scrape
Underfloor ventilation
Ventilation exhaust
fans
• Volatile gases
• Dust
Indoor surfaces • Dust
Fan maintenance
f fficient air movement
Washdown between groups of animals
C i Feed additives
pal 0 Feeder covers
171 Feed delivery downspout extenders to feeder
covers
Flush tanks • Agitation of recycled lagoo !l Flush tank covers
liquid while tanks are filling Extend fill lines to near bottom of tanks with
anti -siphon vents
Flush alleys • Agitation during wastewater Ei/Underfloor flush with underfloor ventilation
conveyance
AMOC - November 11. 1996_ page 1

Source
Pit recharge points
Swine Farm Waste. Management Odor Control Checklist
Cause BMPs to Minimize Odor Site Specific Practices
• Agitation of recycled lagoon 0/Extend recharge lines to near bottom of pits with
liquid while pits are filling anti -siphon vents
Lift stations
• Agitation during sump tank 0 Sump tank covers
filling and drawdown (�
Outside drain
collection or junction
boxes
• Agitation during wastewater 0 Box covers
End of drainpipes
at lagoon
Lagoon surfaces
conveyance
• Agitation during wastewater rtExtend discharge point of pipes underneath
conveyance Lagoon liquid level
• Volatile gas emissions
• Biological mixing
• Agitation
7T Proper lagoon liquid capacity
Correct lagoon startup procedures
Minimum surface area -to -volume ratio
Minimum agitation when pumping
Mechanical aeration
proven biological additives
Irrigation sprinkler
nozzles
• High pressure agitation
• Wind drift
Storage tank or
basin surface
irrigate on dry days with little or no wind
/Minimum recommended operating pressure
iump intake near lagoon liquid surface
L1 ' Pump from second -stage lagoon
• Partial microbial
decomposition
• Mixing while filling
• Agitation when emptying
O Bottom or midlevel loading
Tank covers
O Basin surface mats of solids
0 Proven biological additives or oxidants
AMOC - November 11. 1996. naae 2

Swine Farm Waste Management Odor Control Checklist
Source
Settling basin surface
Cause
• Partial microbial
decomposition
• Mixing while filling
• Agitation when emptying
BMPs to Minimize Odor
4i\A D Extend drainpipe outlets underneath liquid level
D Remove settled solids regularly
Site Specific Practices
Manure, slurry, or
sludge spreader
outlets
• Agitation when spreading
• Volatile gas emissions
D Soil injection of slurry/sludges
D Wash residual manure from spreader after use
D Proven biological additives or oxidants
Uncovered manure,
slurry, or sludge on
field surfaces
• Volatile gas emissions while D Soil injection of slurry/sludges
drying D Soil incorporation within 48 hours
D Spread in thin uniform layers for rapid drying
D Proven biological additives or oxidants
Dead animals
• Carcass decomposition fIT Proper disposition of carcasses
Dead animal disposal • Carcass decomposition
pits
MKComplete covering of carcasses in burial pits
" Proper location/construction of disposal pits
Incinerators
• Incomplete combustion (vk D Secondary stack burners
Standing water
around facilities
• Improper drainage
• Microbial decomposition of
organic matter
Grade and landscape such that water drains away
from facilities
Manure tracked onto
public roads from
farm access
• Poorly maintained access
roads
Farm access road maintenance
AMOC - November 11. 1996. nage 3

Additional Information:
Swine Manure Management; .0200 Rule/BMP Packet
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge— Lagoon Treatment; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush— Lagoon Treatment; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
Controlling Odors from Swine Buildings; PIH-33
Environmental Assurance Program; NPPC Manual
Options for Managing Odor; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedings
Available From:
NCSU, County Extension Center
NCSU— BAE
NCSU— BAE
NCSU— BAE
NCSU— BAE
NCSU— BAE
NCSU— Swine Extension
N.C. Pork Producers Assoc.
NCSU Agricultural Communicati(
Florida Cooperative Extension
AMfC - Nnvemher 11. 1996_ page 4

Insect Control Checklist for Animal Operations
Source Cause BMPs to Control Insects Site Specific Practices
Liquid Systems
utters Accumulation of solids 1:i" Flush system is designed and operated sufficiently
to remove accumulated solids from gutters as
signed
Remove bridging of accumulated solids at
ciischa r
is and pits • Crusted solids
ive vegetative • Decaying vegetation
4 Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the crusting
of solids to a depth of no more than 6 to 8 inches
over more than 30 percent of surface
!T)' Maintain vegetative control along banks of
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter along
water 's edge on impoundment 's perimeter.
Dry Systems
• Feed spillage Cy6Fesign, operate, and maintain feed systems
(e.g., bunkers and troughs) to minimize the
_ ccumulation of decaying wastage
Clean up spillage on a routine basis (e.g., 7- to 10-
day interval during summer; 15- to 30-day interval
during winter)
- November 11, 1996, page 1

Source
storage
Insect Control Checklist for Animal Operations
Cause
• Accumulations of feed /Reduce moisture accumulation within and around
residues immediate perimeter of feed storage areas by
ensuring drainage is away from site and/or providing
adequate containment (e.g., covered bin for
brewer 's grain and similar high moisture grain
products)
❑ Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed
al holding areas • Accumulations of animal ❑ Eliminate low areas that trap moisture along fences
wastes and feed wastage and other locations where waste accumulates and
disturbance by animals is minimal
❑ Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e., inspect for and remove or break up
accumulated solids as needed )
ianure handling Accumulations of animal ❑ Remove spillage on a routine basis (e.g.,
ns wastes 7- to 10-day interval during slimmer; 15- to 30-day
interval during winter) where manure is loaded for
,4 J land application or disposal
Y� ❑ Provide for adequate drainage around manure
stockpiles
❑ Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and manure
handling areas as needed
BMPs to Control Insects Site Specific Practices
ore information contact:
rative Extension Service, Department of Entomology, Box 7613, North Carolina State University, Raleigh, NC 27695-7613..
IC - November 11, 1996, page 2

i
THIS DESIGN IS FOR A SINGLE STAGE LAGOON
/usr/all/eng/lagoons/owners/designs
Riel.eido Lanier Farm'
IENTS NAME ____--_ = = =_=> ,
J�.mmy Bridgers
TODAYS DATE =======---G
COUNTY =========_=_=___-'___= Northampton
>
DISTANCE TO NEAREST NONFARM RESIDENCE-=>
NUMBER OF PIGS WEANLING TO FEEDER =====>
NUMBER OF PIGS FEEDER TO FINISH
NUMBER OF SOWS FARROW TO WEANLING =>
NUMBER OF SOWS FARROW TO FEEDER =======>
NUMBER OF SOWS FARROW TO FINISH
DEGREE OF ODOR CONTROL
(minimum 1.0 cu. ft. per lb SSLW)
(maximum 3.0 cu. ft. per lb SSLW)
NUMBER OF -YEARS OF SLUDGE ACCUMULATION >
TOP LENGTH AT NORMAL WATER LEVEL >
TOP WIDTH AT NORMAL WATER -LEVEL =======>
NORMAL WATER LEVEL ELEVATION .= ___>
SEASONAL HIGH WATER TABLE ELEVATION
LAGOON BOTTOM ELEVATION =__
Depth Of Permanent Water
===>
===>
(minimum depth without sludge = 6 feet)7'5
(minimum depth with sludge .= 8 feet)
SIDE SLOPES ===___=======_=============> 2.5:1
Ponmanent Volume Required 81000.0 cubic feet
L.4anent Volume Provided 147285.0 cubic feet
10/11/96
2000+ FEET
0
600
0
0
0
1.0
0.0 YEARS
ADDITIONAL DRAINAGE AREA IN SQUARE FEET>
(i.e. pumpout pond & other outside area)
LENGTH OF PUMPING CYCLE ==_==___
GALLONS OF FRESH WATER ADDED DAILY ====>
EXCESS RAINFALL ABOVE EVAPORATION ====_>
25YR/24HR STORM RAINFALL =========>
FREEBOARD =======__________ ____
ESTIMATED TOP OF DAM ELEVATION
Temporary Storage Volume
==__====>
61853.8
cop of Dam Elevation = fill
Inside Dimensions of Lagoon at Top
;ength = 279.0 feet Width =
Begin Pumping Elevation =
Stop Pumping Elevation =
Volume To Be Pumped =
g• 1
e / l
262.0 FEET
99.0 FEET
97.0 FEET
96.0 FEET
89.5 FEET
feet
oIqJ
0 SQUARE FEET
AFITOTITAMT
0 GALLONS
8..9 INCHES
6.7 INCHES
1.0 FEET
cubic feet
in spillway
SIOMMOMNIM
of Dam
116.0 feet
98.7 feet
97.0 feet
43784.0 cubic
%,d

STEADY STATE LIVE WEIGHT
0 head weanling to feeder x 30 lbs.
600 head feeder to finishing x 135 lbs. 0 lbs
0 sows farrow to weanling x 433 lbs. - 81000 lbs
0 sows farrow to feeder x 522 lbs. - 0 lbs
0 sows farrow to finish x 1417 lbs. 0 lbs
0 lbs
TOTAL STEADY STATE LIVE WEIGHT (SSLW) _
81000 lbs
SLUDGE ACCUMULATION
Sludge accumulates at the rate of 0.080 cu. ft. per year
per pound of STEADY STATE LIVE WEIGHT in swine.
Years of sludge accumulation in design? 0.0
Sludge Volume = 0.0 cubic feet
REQUIRED LIQUID VOLUME OF LAGOON
Design for 1.0 cu. ft. per pound SSLW
Total Volume =
(SSLW * Design factor) + Sludge Volume
Total Volume = 81000.0 cubic feet
NORMAL LAGOON LIQUID LEVEL
Maintain normal lagoon liquid level at elevation 97.0 feet
Construct lagoon bottom elevation 89.5 feet
Lagoon size for normal lagoon liquid volume using prismodial formula
SS/END1 SS/END2 SS/SIDEI SS/SIDE2 DEPTH
2.5 2.5 2.5 2.5 7.5
AREA OF TOP
LENGTH *WIDTH =
262.0
99.0 25938.0 (AREA OF TOP)
AREA OF BOTTOM
Lb * Wb
224.5 61.5
AREA OF MIDSECTION
(Lm * Wm)
243.2 80.2
13806.8 (AREA OF BOTTOM)
19520.8 (AREA OF MIDSECTION)
CU. YD. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/6
25938.0 78083.2 13806.8 1.250
VOLUME OF LAGOON AT NORMAL LAGOON LIQUID LEVEL =47285.0 CU. FT.

VOLUME NEEDED
81000.0 CU. FT.
THE SURFACE DIMENSIONS OF THE LAGOON AT NORMAL LIQUID LEVEL
ARE 262.0 FEET LONG BY 99.0 FEET WIDE
S. DIKE
Place spoil as a continuous dike to elevation 100.4 feet.
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width
279.0 116.0 32364 square feet
Additional Drainage Area
TOTAL DA
Pumping cycle to be
6A. Volume of waste produced
Volume =
0 square feet
32364 square feet
180 days.
81000 SSLW * 0.0101481 gallon/lb. SSLW/day *
in the pumping cycle / 7.48 gallons per cu. ft.
Volume = 19780.6 cubic feet
6B. Volume of wash water
This is the amount of fresh water used for washing floors or
volume fresh water used for a flush system. Flush systems that
recycle the lagoon water are accounted for in 6A.
Volume = 0 gallons/day * 180 days in the pumpin
cycle divided by 7.48 gallons per cu. ft. g
Volume = 0.0 cubic feet
6C. Volume of rainfall in excess of evaporation
TJse period of time when rainfall exceeds evaporation by largest
amount.
Excess rainfall (difference)
8.9 inches
Volume = 8.9 inches * DA / 12 inches per foot
Volume = 24003.3 cubic feet

6D. * Volume of 25 year - 24 hour storm
Volume =
Volume
6.7 inches * DA /
18069.9 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
6A.
6B.
6C.
6D.
TOTAL TEMPORARY STORAGE
19780.6
0.0
24003.3
18069.9
12 inches per foot
cubic feet
cubic feet
cubic feet
cubic feet
61853.8 cubic feet
7. DEPTH OF STORAGE REQUIRED (ABOVE NORMAL LIQUID ELEVATION
Depth re OF LAGOON)
quired = Volume of temporary storage divided by surface
area of lagoon.
Depth required
Depth required =
Normal lagoon liquid
Depth required
Freeboard
Top of Dam
61854 cu.ft. / 25938 sq.ft.
2.4 feet
elevation =
97.0 feet
2.4 feet
= 1.0 feet
100.4 feet
THE DIMENSIONS OF THE INSIDE EDGE OF THE DAM AT ELEVATION
ARE 279.0 FEET BY 100.4
116.0 FEET
SET BEGIN PUMPING ELEVATION
PUMPED STORAGE VOLUME
6A.
68.
6C.
TOTAL PUMPED VOLUME _
19780.6 cubic feet
0.0 cubic feet
24003.3 cubic feet
43784.0 cubic feet
Depth required = Volume of
area of lagoon at mad storrgl divided by surface
normal water level.
Depth required =
Depth required = 43784.0 cu.ft. /
DESIGNED BY:
Tony Short
DATE:
1.7 feet
APPROVED BY:
DATE:
25938.0 sq. ft.