430001_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than Apri13, 2019.
Please do not leave any question unanswered Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 43-0001 Certificate Of Coverage Number: AWS430001
2. Facility Name: K & J Farm
3. Landowner's Name (same as on the Waste Management Plan): James Russell Man ar
4. Landowner's Mailing Address: 1600 Peach Farm Rd
City: Lillington State: NC Zip: 27546-6518
Telephone Number: 910-893-4693 Ext. E-mail:
5. Facility's Physical Address: 1620 Peach Fann Rd
City: Lillington State: NC Zip: 27546
6. County where Facility is located: Harnett
7. Fann Manager's Name (if different from Landowner): James Russell Magyar
8. Farm Manager's telephone number (include area code): 910-893-4693 Ext
9. Integrator's Name (if there is not an Integrator, write "None"): Prestage Farms Inc
10. Operator Name (OIC): James Russell Magyar Phone No.: 910-709-2956 OIC #: 25593
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit:
Operation Tvnes:
Operations Type Allowable Count
Swine - Wean to Feeder 1,536
Swine - Feeder to Finish 2,940
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
1
6..-- - IL!
CJc.
Lf • 09r:
72 275
19.00
43-01
s
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
The most recent Waste Utilization Plan (WUP), si::ned b) the owner and a certified technical specialist, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
✓ 3. Emergency Action Plan
,/ 4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
01 6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
✓7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application maybe subject • to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be byy�a principal executive officer of the corporation):
Name: eS e I vy{ Title: el er' tt'-
Signature: �e t - Date: "`/ J� /
Name: Title:
Signature: _ Date:
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER
Governor
MICHAEL S. REGAN
secretary
LINDA CULPI PPER
DFrnctor
NORTH CAROLINA
Environmental Quality
February 27, 2019
James Russell Magyar
K&JFarm
1600 Peach Farm Rd '
Lillington, NC 27546-6518
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
MAR 2 6 2019
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at hops://deq.nc,gov/about/divisions/water-resources/water-uualior -regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure %our continued coverage under the State Non -Discharge General Permits you must submit an application for
permit coverage to the Division. Enclosed you will find a "Realest for Certificate of Coverage Facility Currently Covered by an
Expiring State Non -Discharge General Permit." The application form must be completed, signed and returned bV' April 3, 2019.
Please note that you must include one {1} copy of the Certified Animal Waste Manaeement Plan ICAWMPI with the
completed and signed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form,
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
r.%2-
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Fayetteville Regional Office, Water Quality Regional Operations Section
Harnett County Soil and Water Conservation District
AFOG Section Central Files AWS430001
Prestaee Farms Inc
North Ceara- a :Department of Environmental Quality I Division of Water Resources
512 N. Salisbury St 11636 Mail Service Center I Raleigh, North Carolina 27699-1636
919.707 9D00

;4,
Swine Farm Waste Management Odor Control Checklist
Source Cause
.?nnnstcad
• • Svvino production.
Animal body surfaces • Dirty manure -covered animals 451 Dry floori
Floor surfaces • Wet manure -covered floors
Manure collection pits • Urine; 46 Frequent manure removal by flush„ pit recharge,
• Partial microbial decomposition Of scrape;
O Underfloor ventilation
•.BMPs to Minimize Odor
• Vegetaiive or wooded buffers;
Af Recommended best management practices;
O Good judgment and common sense
Site Specific Practitre-s- d'•
.17,111!ft:e.
O Slotted floors;
, •
O Waterers located over slotted floors;
O Feeders at high end of solid floors;
O Scrape manure buildup from floors;
O Underfloor ventilation for drying
Ventilation exhaust fans • Volatile gases;
Dust
Indoor surfaces • Dust
O Fan tnairuenance;
dr Efficient air movement
Flush tanks • Agitation of recycled lagoon
liquid while tanks are filling
Flush alleys
• Agitation during wastewater
conveyance
Pit recharge points
Lift stations
• Agitation of recycled lagoon
liquid while pits are filling
• Agitation during sump tank
filling and drawdown
Outside drain collection
or junction boxes
Washdown between groups of animals;
O Feed additives;
O Feeder covers;
O Feed delivery downspout extenders to feeder
covers ,
O Flush tank covers;
O Extend fill lines to near bottom of tanks with
anti -siphon vents
O Underfloor flush with underfloor ventilation
O Extend recharge lines to near bottom of pits
with anti -siphon vents
4,
O Sump tank covers
• Agitation during wastewater
conveyance
p Box covers
AMOC - November 11,
1996, Page 3

Source
End of drainpipes at
lagoon
Cause
• Agitation during wastewater
conveyance
Lagoon surfaces
BMPs to Minimize Odor
O Extend discharge point of pipes underneath
lagoon liquid level
Site Specific Practices
Irrigation sprinkler
nozzles
• Volatile gas emissions;
• Biological mixing;
• Agitation
O Proper lagoon liquid capacity;
O Correct lagoon startup procedures;
O Minimum surface area -to -volume ratio;
O Minimum agitation when,pumping;
O Mechanical aeration;
O Proven biological additives
• High pressure agitation;
• Wind driR
Storage tank or basin
surface
• Partial microbial decomposition;
• Mixing while filling;
• Agitation when emptying
O Irrigate on dry days with little or no wind;
C! Minimum recommended operating pressure;.
O Pump intake near lagoon liquid surface;
O Pump from second -stage lagoon
O Bottom or midlevel loading;
O Tank covers;
O Basin surface mats of solids;
O Proven biological additives or oxidants
Settling basin surface • Partial microbial decomposition; 0 Extend drainpipe outlets underneath liquid
Manure, slurry or sludge
spreader outlets
Uncovered manure,
slurry or sludge on field
surfaces
• Mixing while tilling;
• Agitation when emptying
level;
O Remove settled solids regularly
I,;WA: ,3C..
• Agitation when spreading;
• Volatile gas emissions
• Volatile gas emissions while
drying
Dead animals • Carcass decomposition
Dead animal disposal • Carcass decomposition
pits
O Soil injection of slurry/sludges;
O Wash residual manure from spreader after use;
O Proven biological additives or oxidants
O Soil injection of slurry/sludges
O Soil incorporation within 48 hrs.;
O Spread in thin uniform layers for rapid drying;
O Proven biological additives or oxidants
❑ !'roper disposition of carcasses
Incinerators • Incomplete combustion
AMOC - November 11, 1996, Page 4
❑ Complete covcriug of carcasses in burial pits;
O Proper location/construction of disposal pits
0 Secondary stack burners
p

Source
Standing water around
facilities
Manure tracked onto
public roads from farm
access .
Cause
• Improper drainage;
• Microbial decomposition of
organic matter
IIMPs to Minimize. Odor
Grade and landscape such that water drains
away from facilities
•
Site Specific Practices
Additional Information :
• Poorly maintained access roads
Farm access road maintenance
Swine Manure Management; 0200 Rule/BMP Packet
Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment ; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment ; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage ; EBAE 103-83
Calibration of Manure and Wastewater Application Equipment ; EBAE Fact Sheet
Controlling Odors from Swine Buildings ; PIH-33
Environmental Assurance Program ; NPPC Manual
Options for Managing Odor; a report from rite Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies ; PRO107, 11`995 Conference Proceedings
Available From.:
NCSU, County Extension Center__ _
NCSU-'BAE •
_..W.
NCSU -BAE
NCSU - BAE
NCSU - BAE
NCSU - BAE
NCSU - Swine Extension
NC Pork. Producers Assoc
NCSU Agri Communications
Florida Cooperative lsxtcnsion
AMOC - November 11, 1996, Page 5

Version —November 26, 2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
El El Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Q Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
© Rendering at a rendering plant licensed under G.S. 106-168.7.
71 1 Complete incineration according to 02 NCAC 52C .0102.
CI El A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
El El In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
El El Any method which, in the professional opiniorrof the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
of Farm ner Mana er
/77,144
C-27.evito C.Y iIF
3-19-19
Signature of Technical Specialist Date
Signature a / g . Date

WASTE UTILIZATION PLAN
Produc er.----- :James RusyE_ell&Nri ti.na Magyar
Name of r arm- n K & J Farm
L .L l l i n J t,.. on NC S 27546
P 1i34 e----_ --._ a k910}8..e., 469.3
Type taper ton ...,..._w M......_ :Wsets Fiii 'Y
Number- of Animal - __---. 4476
Storage Structure ----------:Anaerobic Lagoon
Method of application ---- --:Irrigation
Amount of waste produced per year . 6235 tons/year
Amount of plant available N (PAN) Produced/year-: 7499 lbws./year
The waste from your animal facility must be Iarid applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be use
to reduce the amount.. _of core mereial.. fertx 1 . er recut rasa _ for -.i: h --
crops: in the fields where the waste .is to be applied.
This waate utilization plan uaes nitrogen as the limiting
nutrient.. Waste should to analyzed before each application cycle.
Annual soil tests are strongly encouraged so that all plant
be balanced for realistic yields of the crop to be
your
waste
fertilizer value of t h e
4n environmentally aafe
of' the crop to be grown
Do not
apply more
a. to land eroding at more
per year. Waste may be applied to land
toms per acre annually, but less than
year providing that adequate filter
strips• are established.
-4. Do r'sot--appl-y--was;te•. onsat.uxatecl...=sos.I.sF when_.it_.Is_r:.aznz-rfgF---o••
when the surface is frozen. Either of these conditions may
in runoff to the surface watery which is not allowed under DWO
regulations.
�. Wind conditions should also be
downwind odor problems.
6. To maximize the value of the nutrients for crop production
to reduce the potential for pollutions the waste should be
applied to a growing crop or applied not More than 30 days
prior to planting a crap or forages breaking dormancy.
Injecting the waate or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown
you choose to change methods in the future, you need
this plan. Nutrient levels for different application
not the same.
The eatirnaat.ed acrea needed to apply the animal waste is based
typical nutrient content for this type of facility. Acreage
requirements should be based on the waate analysis report from
your waste management facility. In some cases you may want to have
nutrients can
grown.
Several factors are important in implementing
utilization plain in order to maximize the
waste and to enure that it ia applied in
1. Always apply waste based on the needs,
and the nutrient content of the waste.
nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
Normally haste shall not be applied
than 5 tong per acre
eroding at 5 or more
10 tone per acre per
considered to
avoi l d drift arid
and •
above . If
to revise
methods are
on
County :Harnett
RECEIVED / DENR / DWQ
AQUiFFR•PP.l7TF(;TioN SECTION

�+ x .7 term
Page 2
plant analysi.s made, which could allow additional waste to be
applied. Provisions shall be made for the area receiving waste to
be flexible •4.cx aa to accommodate ah r giriy" waste ena1yai ac content
and the crop type. Lime muat be applied to maintein• pH in the
optimum range for specific crop production.
This waste utilization plar€r if carried out, meets the
requirements for compliance with 15A NCAC 2H .0217 adopted by the
Environmental Management Commission.
YOUR WASTE UTIL12ATION PLAN IS BASED ON THE FOLLOWING:
tract.
5w'fir
5236
5286
5236
5286
5408
5408
5408
5408
Field
No.
Soil
Type
FaB
riB
F a E3
FaB
N r B
NoB
FaD
FeB
.N r B
Nok
Crop Yield Lbs. N Acres Lbs. N Month to
Code /Acre /Unit Used Apply
E 1 4.7 50.00
E 4.7 50.00
1,1 N J A 90.00
B 5.2 50.00
K NIA 90.00
4.7 50.00
�. NIA 90.00
6.1 50.00
L N: A 120.00
15.E
15.0
4.1
4.1
1.4
1.4
5.1
5.1
2.7
2.7
3525 APR-SEP 235
964 Apes -SSE =' 2.3S"
369 APR --SEP •q ej
364 SEP-MAR 2.6©
126 Apia-:SEP '
1199 APR-SEP 2.35
459 SEP-MAR 90
824 APR-SEP 305
324 APR--SEP/4O
Total 9503
Available Nitrogen (includes commercial) 7499
Surplus Or Deficit -2003
Crop codes: Crop -unit
A-Barley--bu. •
B=ued: mudagr'at.i•s (tjraz ) -tong.;
€ :=Bermudagrass(hay) --tons
D=Corn(gra rti-bu..
F='='Cts tb -- :(: b
t?=Fel cue(ci reeze) tons
H=Fesc ue(hay) -ton
I=fats-`tau.
J=Rye-bu.
K=Small grain(graze)-acre
L=Smell grain(hay)-acre
M=Sor•ghtint(Agrain) -cwt.
--- =10heat ICJ : - .,._......_ , _:.
Y=Fescue (pasture) -tons.•
, Z =SBDC Soybeans DC-bu .
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.

& j k='arm
Page 3
The applicator is cautioned that P and K may be over applied while
meeting the N requirements. In the future, regulations may require
farmers in aome parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only
addresaes nitrogen.
In interplanted fields (i.e. amall grain, eta, interseeded in
bermudagrasa), forage must be removed through grazing, hay and/or
silage. Where grazing, plants should be grazed when they reach a
height of aix to nine inches. Cattle should be removed when plants
are grazed to a height of lour inches. In fielda where small grain
etc is to be removed for hay or silage, care should be exercised
not to to let small grain to reach maturity, especially late in
the,season (i.e. April or May). Shading may result if small grain
gets too high and this will definitely interfere with stand of
bermudagrasa. This loss of atand will result in reduced yields and
less nitrogen being utilized. Rather than cutting small grain for
hay or silage juat before heading aa is the normal situation, you
are encouraged to cut the small grain earlier. You may want to
consider_harvesting hay or -
season, depending on time small grain is planted in the fall.
The ideal time to interplant email grain, etc, is late September
or early October. Drilling is recommended over broadcasting.
Bermudagrass should be grazed or mowed to e height of about two
inches before drilling for best results.
Caution muat be exercised in grazing or haying summer annuals
under atresaed conditions. Nitrate poisoning may occur in
livestock. Sampling forage or hay for nitrate levels ig
reCommended.
Acres shown in the tables are considered to be the usable acres
excluding required buffers , filter strips along ditches, odd
areas unable to be drrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the field listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization
of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provision for periodic
land -application of sludge at agronomic rates. The sludge will be
nutrient rich and will require precautionary measures to prevent
over application of nutrients or other elementa. Your production
facility will produce approximately 1169 lbs. of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years, you will have approximately
5643 lbs. of PAN to utilize. asauming you apply thin PAN to
hybrid bermudagraea hayland at the rate of 300-lba. ofnitrogen
per acre, you will need 19 acres of land. if you apply the
sludge to corn at the rate of 125 lbs. of nitrogen per acre, you
will need 4 acres of land. Please be aware that theae are
only eatimatGa of the PAN and land needed. Actuai requirements
could vary by 25% depending on your sludge waste analysis, soil
typea, realistic yielda, and application methods.

K. & J Harm page 4
APPLICATION- OP WASTE 1 V r'r:R i sATION
The irrigation application rata should not exceed the intaRe rate
of the soil at the time of irrigation auch that runoff or ponding
occurs. This, rate is limited by initial soil moisture content,
moil structure, soil texture., water droplet size, and organic
solids. The application amount should not exceed the available
water holding capacity of the soil at the time of irrigation nor
should the plant available nitrogen applied exceed the•nitrogeri
needs of. the crop.
If surface irrigation is the method of land application for this
plan, it i.r the responsibility of the producer and irrigation
deaiyner to ensure that an irrigation system is installed to
properly irrigate the .cram shown in tables. Failure to apply the
recommended rates and amounta of nitrogen shown in the table may
make thia plan invalid.
The following table i8 provided as a guide for establishing
application rates. and amounts.
Tract Field Soil Crcp
No. No. Type
5236
5236
5236
5236
5236
5408
5408
5408
5 408
2 FaB
2 Fare
5 FaB
FaB
6 NoB
6 NoB
3 FaB
3 FaB
1 NoB
:1 NoB
Applic
Rate
(inihr)
i3 0.4
Ii 0.4
A.4
i 0.4
L'r 0.9
Ii 0.5
0.4
X A.4
t ^ 0.5
L 0.5
This is the maximum application
assuming the amount of nitrogen
applied. In many ait.uationa the
applied because of the nitrogen
application amount shown can be
conditions.
Applic
Amount
(in(s))
1
1
1
1
1
1
1
1
1
1
IRIS-2
PAN
LBS/A(.
235
90
2 5
90
260
90
235
90
'305
120
amount allowed for the soil
allowed for the crop is not over
application amount shown cannot be
limitation. The maximum
applied under Optimum soil

K J Farm
Page 5
Your facility is designed for 180 daya of temporary storage and'
the temporary storage must be removed on the average of once every
6 months. In no instances should the volume •of the waste be stored
in your structure be within the 25 year 24 hour storm storage or
one foot of freeboard except in the event of the 25 year 24 hour
storm.
It :Le the responsibility of the producer and waste applicator to
en8ure that the spreader equipment is operated properly to apply.
the correct rates to the acres shown in the tables. Failure to
apply the recommended rates and amounts of nitrogen shown in the
tables may make this plan invalid.
Call your technical specialist after you receive the waste
analysis report for assistance in determining the amount of waste
per acre and the proper application rate prior to applying the
waste.
NARRATIVE OF OPERATION
The ratea in this plan aro taken from a previous plan written
3/15/96 by Parks. V. Blake USDA-NRCS.

Page 6
WASTE UTILIZATION PLAN AGREEMENT
Name 7i Farm: K &• J Farm
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
.end the operation and maintenance Procedures established in the
approved animal waat.e utilization plan for the faro named above_. I
(we) know that any expansion to the existing design capacity of
the waste treatment and storage system or construction of new
facilities will require a new certification to be .submitted to the
North Carolina, Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
dis,charae of animal waste from this system to the s;tLar4., we.ters
o± the state from a storm event less severe than the 25-year: , 24...
hour• storm. The approved plan will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation
District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Tames Russell&iCriatina Magyar
(Please print)
Signature:
Name of Manager(If different from owner) :
Date: /a/c3/a.2-__
Signature
Date:
Were c,f Person Preparing Plan: Gm Glenn Clifton
(Please print:)
A.: f i, l i i't.xO !-- Pr'eaAt.L- ge. Fs:i2'i t r c a 7 }r_
Address: P 0 B,ot? 438 Ext. 249
Clinton NC 28329
Signature:
Date: b)/3102_-

Prest age Farms Swine Locations a.pp
https://pfi.maps.arcgiis.isomJapps/webappviewerlindex.html?id=bcd31 c72d7.d04bceac9388b...
1
Prestage Farms Swine
Find address or place Q
—41
-78.874 35.395 Degrees
600ft
1 of 1
'1/19/N119 11 19 AM

�'HARNETT
DIVISION OF EMERGENCY COUNTY
EMERGENCY WATER QUALITY ENCY ACTION r
SOIL MANAGEMENT {DWG7( FLAN
b1�?TER corvsERUAGEo ICES 33 330
NATURAL RESOURCES{EMS)
COOPERATIVE CONSERVATION (SWCD) )
910-
EXTE ATION SERVICE 9/0-
Thi SERVICE f {�yRCS) 91�+_893-8b,��
ICE
s plan will CES) 893-756y
910-89
operation are be implemented '3"7584
NOT wait until wastes
overflowing,
the event 91-863-753r
consider that Washavereae wings or running
wastes from
ens that you a surface watersg off the your
accessible location
does not roblem. You should leave site. You s
are cat i o Ppen, your pro should
some action items
all employees plan shQkldevery effort erty to
1. Stop the you should take. « facility. be posted in an
t the
or mayrelease of wastes.he following
listed belownot e possible. S'-9gestDeeddin9 on the sit
responses to situation, this may
A. Lagoon overflow -possible
Problems are
law -Possible
a. Add 1 tsolutions are:
soi
o berm
b. qualified alteration iafth�e elevation of
Pump wastes to field
specialist.
should be dam, any
permanec, Stoll all ield at approved by a
house additional flaw t e.
d. Call if possi anoaheptable rate.
e. Make aspumping contractor.
lagoon -hold waste in the no e
he
B. Runoff from water is entering lagoon.
m waste
application
Immediately ion field -action inch
a. y stop Mast include:
Great temporary e a
waste e a tem y diversion
bc. Incorporate
or berm to contain the
Evaluate
waste to
runoff. a and reduce further
d.e. Evaluate eliminate the re runoff
state the anon (s) that
runoff apPlicat' caused the
occurred ion rates
:�+ Leakage from the wastefor
the fields where
='' pipes an
;� a. SPQR recycle (flushing d sprinklers -action include:
as
. e' Repair all eleaksePrionate fort diGiS scharge.
har
Leakage isc ge.
a include:
from r to restarting pumps.
tde, flush systems houses: solids separators actions
b. recycle
c. Make surop e
nlPumpng system? pump.
siphon
d. Stop all flows effect
e. St op separatall l in the house, �afl shnsy created. systems,
leaks
prior to restarting Pum mss or solid
Ps.

2.
E. Leakage from base or sidewall of lagoon. Often this is seepage
as opposed to flowing leaks -possible action:
a. Dig a small sump or ditch to catch all seepage, put in a
submersible pump, and pump back into lagoon.
b. If holes are caused by burrowing animals, trap or remove
animals and fill holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side
walls and the lagoon bottom as soon as possible.
Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b.
c.
d.
e.
f.
g•
h.
Approximately how
duration?
Any damage noted,
property damage?
Did the spill leave
Does the spill have
waters?
Could a future rain
surface waters?
Are potable water wells in danger (either on or off of
the property) ?
How much reached surface waters?
much was released and for what
such
as employee injury, fish kills,
the property?
the potential to reach surface
event cause the spill to reach
3. Contact appropriate agencies.
or
a. During normal business hours, call your DWQ (Division of
Water Quality) regional office, at 910-486-1541, after
hours, emergency number:919-733-3942. Your phone call
should include: YOUR NAME, FACILITY, TELEPHONE NUMBER,
THE DETAILS OF THE INCIDENT FROM ITEM #E ABOVE, THE
EXACT LOCATION OF THE FACILITY, AND THE LOCATION OR
DIRECTION OF MOVEMENT OF THE SPILL, WEATHER AND WIND
CONDITIONS. THE CORRECTIVE MEASURES THAT HAVE BEEN UNDER
TAKEN, AND THE SERIOUSNESS OF THE SITUATION.
b. If spill leaves property or enters surface waters, call
local (EMS) Emergency Management Services at
910-893-8659.
c. Instruct EMS to contact local Health Department.
d. Contact local Soil and Water Conservation District
(SWCD), Natural Resources Conservation Service
(MRCS) office at 910-893-7584 and Cooperative Extension
Service (CES) at 910-893-7530 for advice/technical
assistance.
4. If none of the above works call 911 or the sheriffs Department
and explain your problem to them and ask that person to contact
the proper agencies for you.

5. Contact the contractor of your choice to begin repair off the
problem to minimize off —site dam
a. Contractors Name:
b. Contractors Address:
c. Contractors Phone:
6. Contact the technical specialist who certified the lagoon (NRCS,
Consulting Enginee -tc.)
a. Name: / &Z"` "!�
b. Phone:
7. Implement procedures as advised by DWG! and technical assistance
agencies to rectify the damage, repair the system, and reassess
the waste management plan to keep problems with release of wastes
from happening again.
8. If your are a contract swine grower associated with a swine
company integrator, contact the company representative at
1-910-592-5771

Insect Control Checklist for Animal Operations
Sotirce
Flush gutters
Lagoons and pits
Cause
BMPg-to Control Iiiseets:'
Liqiiid Systems
• Accumulation of solids
• Crusted solids
Excessive vegetative • Decaying vegetation
growth
`1,4 Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed
0 Remove bridging of accumulated solids at
discharge
Maintain lagoons, settling basins and pits where
(•pest breeding is apparent to minimize the crusting
of solids to a depth of no more than 6 to 8 inches
over more than 30 percent of surface
px, Maintain vegetative control along banks of
lagoons and other impoundments• io prevent
accumulation of decaying vegetative matter ;Along
watees edge on impoundment's perimeter.
' Site'.Scificlit
ffl
%
Dry Systems:
Feeders
• Feed spillage
ADesign, operate, and maintaiii'feed systems
(e.g., bunkers and troughs) to Minimize the
.accumulation of decaying wastage
'47k Clean up -Spillage on a routine basis (e.g., 7- to 10-
day interval ittiring,:,SutrpCr;'15-:10 30-day interval
during winter)

Cause
Insect Control Checklist for Animal Operations
Feed storage • Accumulation.sof feed
residues ..._ .
Animal holding • Accumulations of animal
C1s wastes and Feed wastage
I)ry manure Accumulations of animal
handling systems wastes
efil
P
'.13MI's Iti Control lntsects
Reduce moisture -accumulation within and arciiitid
immediate perimeter of feed storage areas by
ensuring drainage.is away From site and/or
providing adequate containment (e g.; covered .bin
for brewer's grain and siniilar high moisture grain
products)
Inspect for and remove or' brcak`up arccuntulated
solids in filter strips around • feed storage as needed
Eliminate love areas that trap moisture.along-fences
and other locations where waste accuniitlates'and
disturbancc`by animals is minimal
iVlainlaii fence rows and filter strips around animal
holding areas to minimize aCOMMilations of wastes
(i.e:, inspect for and remove -Or. break•ttp
accumulated solids ais-needed)
Remove spillageon (e.g.,
7- to 10-day interval during sutniner, 15- to 30-day
interval during winter) where manure is loaded for
land application or disposal
.1 Provide Ibr adequate drainage around manure
stockpiles
ifa Inspect for and remove orb -eak up.accunrulatcd
wastes in filter strips around stockpiles and manure
handling areas as needed
Site Specific Practices
For more information contact:
Cooperative Extension Service, Department of Entomology, 13ox 7613, North Carolina State University, Raleigh, NC 27695-7613.

Operator :Ray Stanley County: Harnett Date: 06/01/94
Distance to nearest residence (other than owner): 1000.0 feet
AVERAGE LIVE ViEIG=T (ALW)
0 - y � ,4 7 lbs. - l t.
novas (-:3r�ow to f_r�:sh' 10 as
0.sows (farrow to feeder) _: 522 lbs. = 0 lbs
`940 had (finishing only) x 135 lbs. = 396900 lbs
0 sows (farrow to wean) x '433 lbs. = 0 lbs
0 head (wean to feeder) x 30 lbs. = 0 lbs
Describe other : 0
Total Average Live Weight =
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
3960^n 71-s
Volume = 396900 lbs. ALW Tre txae?r VoI Ira F) Ilb. ALW
y7
Treatment Volume CFti /lb.r. r+ i i = 1 ALW
Volume = 396900 cubic
STORAGE VOLUME ^:i1_ SLUDGE ASC7MULATTONSludge Accumulation CC..._'; a
At
nw er
Volume = _ cubic -e-- As �_ 1
-)TAL ✓ES_GNED r-7 7ME
(feet-- Inside a. l; j: length �eF` . -_ -_ __ __ .. ._ _ _...
- l5_l2C top width ( _ .. .. - _ .-._._. - -75
Top of dike elevation ' r_ t - - .. 72.5
Bottom of lagoon e_f: a.r---- 7 ^L= 21.E
Freeboarr'l (-_mot) -.----.. .. . _,r_•,
_Dice blue .t` 7 _tl..-•lub . agoo ) '.0 :
Total design volume using .L-a:i:__da1_. formula
SS/ENDi
AREA OF TOP
OF EC.77=
r-r/..TDri Sr.'7_IE^
L ENCT
71 . PTom }
- J.
1
r,mT.

r,
TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (Lop of dike)
Length * Width =
245.0 295.0 72275.0 square feet
Buildings (roof and lot..water
0.0 square feet
TOTAL DA 74847.5 square feet
Design temporary storage period to be 190
_.. Volume of waste produced
Feces & .--du• -_orl in = ,y p'-- --.
Describe this area.
ALW 1.37al:PO dyy=
Volume = 396900 i�75. HL�L,-. =- _r.. lbs.? .'d.a" - g r - -
Volume - 7..5.04 •a• _s. _:. 7 . ub'-- t...
Volume of wash water
This is the mcu,_ u==d f3= wAsh_lg floo.rz.of fresh water used for a flush system. Flush systems the_
the lagoon water ?_ accc'jnted for in 5A.
Volume = - . i i ons .t `i. - y
4 o, mF. - 0.0 _ U1 _ . f e`_ _
EC. Volume a'- _ -. .1f i _ _.. ::: -L s s of v a ifL at - D._
Use period of tiro:_ wh.en e . =:t.:or C
T7
days: -- 2 gal one
C T
p _ _ 1
-r

Volume of 25 year - 24 hour stern
Volume = , ... inches / 12 :riches per foot ' DA
'volume = 43661.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
5B.
6G.
- T
96926 cubic feet
0 cubic feet
43661 cubic feet
43661 cubic feet
TOTAL 124248 cubic feet
6. SUMMARY
Teinpora_ storage period
_r_ e_:cess of eiapora_
.._ year - 24 hour - ainfa I _ --. _.._
Side s'opes---- -:..._ .- -
da- -
-.0 incl-lea
!' reel:
7.n .
Inside top with ,
Top of 11._ c_e__ ___---_.._-__---__--__-_-__ . f____
Li- .t..OM of _ J ___ elevation-- _.--- _. ^ . . _.
..:
Tonal =eq i.i ed volume .--' -'- --- - 17 - - - -'-'
Actual design volume-- - _ . 594039 ft. *
Stop pumping r- _ _ , _....._ _... ... _ _ _ _
M' - th.. SET T e t'. ---.---------` n . 0 Le-
1 U _- .. be ` _ _ t ,-) min. L _ treatment .- _ '" 27.5 _ - -
t.
Requ__er. _.i ri_l.. rc, treatment v ul ulie ----------- -'- ._-Eti
- _ iu:at :_ _ y• pumping e _ e __ i .. ._ _ A ^ n C- -- - : _
bzart pumping e_E_.--'-'------ _.._._ n_ "? `c. s
Actual is .- _ ui : _ it.12a 25 y - . _. 24 h . rain - =' - - -. - ' _ ` - - - -
Volume at s .. _.. _ t.. -....1'' i `-g - , a. . ' - -
c.

.OPE w.TT• T AND T N 10E T
����lv MAI�:_EIYy'�:•..� PLAN
SHEET 1 OF 2
SHEET
This lagoon is ..--_gin' for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consirts of 180 days storage for:
1. waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and From year to year, but excess
rai ifall will vary from: year __ year. The 25 year rainfall will not
be a factor to consider in an annual_ pumping cycle, hut this storage
volume 11.'^always a- y _ be available.
A maximum e _ _ _ _ ddetermin d in Par.h de-; n t
puMpirLg and t--i_ is usually the :,ut'et invert of pips-; f_cm
iuildirzgf - If t'__ outlet j pe i_ not instal l _ 7 at tte s eva '� - -
- - t s 1 - e -« e-� - this elegy; _t_-'o beg_ rJ'tl i!!i'__:g, - t`P il!Lall �'p; r_a l-✓?Y �e�_. .._ ;_ _r:�_�i_ _. _- to indicate when pumping_--- Ta bec'n. An -_ -at__n. e tali' _skier
to 5 t .�.. ,•-. + , 7..: - - '- � - - _'_ -` - - - - __ - - r �. _• r-
1' i:' =i
^limn r! l • - _ _ 1- ' �" _. - _ - ` - - t - p: p e t _ ?Ti : T. -. a i . ._ _ ? o
e1e7at----- ppe a-i ---' -- - - a.E-. -i €: • end:.,_ permit, such a.
runoff or _e-+...i_ g
Land appli:2atioll is :a:,,Dgni.:_ed
_Tet.n__. d._-1r'ca_. Method_=. of apy•l _ _atn set,
taken When applying .=,ate _ - t.:, L' seven: damage tc --:pL .
tilt Iollow_ng to L_
1 h - t - t 1:.. -
- i__�:•lia:ieri• ca. t.ia� __.... ih.G .. .. _-� __-' -- r'-'-
- 1 _ + to .r - _ - f _ L.-.. _
-- -_ - reduces t' _... ~ - -- : _ni t
e ri t i n _ h e i ; ✓ o n `
covered with at a__ _n+:::_-••-_--- i- A:,a - 7 -
flush zhoullfi
h_ --=- -'--- -- - initial ----telly
•

SHEET 2 OF 2
recommended ma:imum amount Zo al:ply per irrigation is_
ane (1) inch and the recommended aa::mum application rate is 0.3
utilization plan for further details.
_==3 ;:_et Rose. Refer to the waste =_ �izat
�. 26E vegetation on the embankment a_:' area 2djacent to the
lagoon mowed annually. Vegetation Should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by r3dent: and
eetabiish in vcgat tion.
7. All surface runoff is to be di=ertee £:= goon to stable
outlets.
`E c ` ` eeoetated buffer
3. Eee2 a minimum of �. £eel � :.: ,=a�_ ��� around
waato e__ -___ : ..� J = .___ _\^perenria! streama. Waste will
be \\//i- \ , di es. 20 not hin 2S? Ee t ^£ a
notz ::2 � 25mg = x-- .tee c
c; ir`10e feet of a well. Waste aha.1 t£ a2p1ied i.
!. _-- _
322 2= £eaCt otbe� 2l=ge::2 ass 2=\Ii2 =limb e ©«!�.
3. The Clean Water Act of 1977 :ro!hit£ the 'iEcharge of
'=e - ----e -- -
l_o.____ _._z=te_: _£ tienitE2 2ta_==. =e2=�« --
7� 2&._ 2_m.z , Kealt' and §a2==.. __ Environ
2=.L01 .anageze=t, 2:_ :3�.,__._ :.:�
.�,