400128_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 40-0128 Certificate Of Coverage Number: AWS400128
2. Facility Name: Collvn Beaman Farm
3. Landowner's Name (same as on the Waste Management Plan): Collvn Beaman
4. Landowner's Mailing Address: 502 Sturbridge
City: Snow Hill State: NC Zip: 28580
Telephone Number: 252-747-7708 Ext. E-mail: collvnbeaman a vahoo.com
5. Facility's Physical Address: Dunwoodv Rd
City: Farmville State: NC Zip: 27828
6. County where Facility is located: Greene
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"): Murphy -Brown LLC
10. Operator Name (OIC): Carson E. Beaman Jr. Phone No.: 252-747-7708 OIC #: 16497
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit:
Operation Types:
Operations Type Allowable Count
Swine - Wean to Feeder 4,160
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
I CB
3/23/1995
19.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), signed by the owner and a certified technical specialist containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to S25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than S10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name:
Signature:
Name:
.1�
Signature:
Name:
Signature:
Title:
Date:
Title:
Date:
Title:
Date:
U
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER
Governor
MICHAEL S. REGAN
Secretary
LINDA CULPEPPER
ofrecror
NORTH CAROLINA
Environmental Quality
February 27, 2019
Collyn Beaman
Collyn Beaman Farm
502 Sturbridge
Snow Hill, NC 28580
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https://deq.nc.gov/about/divisions/water-resources/water-quality-regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non -Discharge General Permits, von must submit an application for
permit coverage to the Division. Enclosed you will find a "Request for Certificate of Coverage Facility Currently Covered by an
Expiring State Non -Discharge General Permit." The application form must be completed, signed and returned by April 3. 2019.
Please note that you must include one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with the
completed and signed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Pennits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Washington Regional Office, Water Quality Regional Operations Section
Greene County Soil and Water Conservation District
AFOG Section Central Files - AWS400128
Murphy -Brown LLC
North .,aronaDepartment ofEnvrcr.monte:+Qua:ty 1 Dv_-:sanofl",'aterResources
512 N. Sa Sbury It. 1 1E36 Mail SarVea venter I Ra,!eign, North Cocoa 27699-163
519.7•07.S0u0

Nutrient Management Plan For Animal Waste Utilization
04-19-2005
This plan has been prepared for:
C. Beaman
Collyn Beaman
502 Sturbridge Dr.
Snow Hill, NC 28580
252-747-7708
This plan has been developed by:
Carl Dunn
•DSWC WaRO
943 Washington Sq Mall
Washington, NC 27889
252-9.46-6481
Developer Signature
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal
waste utilization plan for the farm named above. I have read and understand the
Required Specifications concerning animal waste management that are included with
this plan.
Signature (owner) Date
Signature (manager or producer) Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
adopted by the Soil and Water Conservation Commission.
Plan Approved By: t_ . t' ti,,.._
296088
ti.-16l-0
Technical Specialist Signature Date
r Database Version 3.1
Date Printed: 04-19-2005 Cover Page 1

Nutrients applied in accordance with this plan will be supplied from the
following source(s):
Commercial Fertilizer is not included in this plan.
S5
Swine Nursery Lagoon Liquid waste generated 794,560 gals/year by a 4,160 animal
Swine Nursery Lagoon Liquid operation. This production facility has waste storage
capacities of approximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
1830
Incorporated
3143
Injected
3461
Irrigated
1989
Max. Avail.
PAN (lbs) *
Actual PAN
Applied (Ibs)
PAN Surplus/
Deficit (lbs)
Actual Volume
Applied (Gallons)
Volume Surplus/
Deficit (Gallons)
Year 1
1,989
4747
-2,758
2,341,668
-1,547,108
Year 2
1,989
5145
-3,156
2,054,321
-1,259,761
Note: In source ID, S means standard source, U means user defined source.
* Max. Available PAN is calculated on the basis of the actual application method(s) identified in the plan for this soi
296088 Database Version 3.1 Date Printed: 04-19-2005 Source Page 1 of 1

The table shown below provides a summary of the crops or rotations included in this plan for each field. Realistic
Yield estimates are also provided for each crop in the plan. In addition, the Leaching Index for each field is shown,
where avai !able.
Planned Crops Summary
Tract
Field
Total
Acres
Useable
Acres
Leaching
Index (L1)
Soil Series
Crop Sequence
RYE
1249
2
2.85
2.85
N/A
Norfolk
Cotton
8751bs.
1249
3
2.89
2.89
N/A
Norfolk
Cotton
875 lbs.
1249
4
2.93
2.93
N/A
Norfolk
Cotton
8751bs.
1249
5
3.20
3.20
N/A
Norfolk
Cotton
8751bs.
1259
10
3.03
3.03
N/A
Norfolk
Corn, Grain,
115 bu.
Wheat, Grain
60 bu.
Soybeans, Manured, Double Crop
35 bu.
1259
6
2.70
2.70
N/A
Norfolk
Corn, Grain
115 bu.
Wheat, Grain
60 bu.
Soybeans, Manured, Double Crop
35 bu.
1259
7
3.19
3.19
N/A
Norfolk
Corn, Grain
115 bu.
Wheat, Grain
60 bu.
Soybeans, Manured, Double Crop
35 bu.
1259
8
3.19
3.19
N/A
Norfolk
Corn, Grain
115 bu.
Wheat, Grain
60 bu.
Soybeans, Manured, Double Crop
35 bu.
1259
9
3.19
3.19
N/A
Norfolk
Corn, Grain
115 bu.
Wheat, Grain
60 bit.
Soybeans, Manured, Double Crop
35 bu.
128
Zone 1
0.76
0.76
N/A
Norfolk
Small Grain Overseed
1.0 Tons
Hybrid 1ermudagrass Hay
6.5 Tons
128
Zone 2
0.76
0.76
N/A
Norfolk
Small Grain Overseed
1.0 Tons
Hybrid Bermudagrass Hay
6.5 Tons
128
Zone 3
0.75
0.76
N/A
Norfolk
Small Grain Overseed
1.0 Tons
Hybrid Bermudagrass Hay
6.5 Tons
k. 128
Zone 4
0.75
0.75
N/A
Norfolk
Small Grain Overseed
1.0 Tons
Hybrid Bermudagrass 1-lay
6.5 Tons
296088 Database Version 3.1 Date Printed 4/19/2005
NOTE: Symbol * means user entered data.
PCS Page 1 of 2

LI
Potential Leaching3
Technical Guidance
< 2
Low potential to contribute to soluble
nutrient leaching below the root zone.
None
>= 2 &
<= 10
Moderate potential to contribute to
soluble nutrient leaching below the root
zone.
Nutrient Management (590) should be planned.
> 10
I-ligh potential to contribute to soluble
nutrient leaching below the root zone.
Nutrient Management (590) should be planned. Other conservation practices that
improve the soils available water holding capacity and improve nutrient use efficiency
should be considered. Examples are Cover Crops (340) to scavenge nutrients, Sod -Based
Rotations (328), Long -Term No -Till (778), and edge -of -field practices such as Filter
Strips (393) and Riparian Forest Buffers (391).
296088 Database Version 3.1 Date Printed 4/19/2005
NOTE: Symbol * means user entered data.
PCS Page 2 of 2

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements,
and proper timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure or
other by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field in
order to supply the indicated quantity of nitrogen from each source is also included. A balance of the total manure produced and the total manure applied is
included in the table to ensure that the plan adequately provides for the utilization of the manure generated by the operation.
Waste Utilization Table
e
Tract
Field
Source
ID
Soil Series
Total
Acres
Use.
Acres
Crop
RYE
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
(Ibs/A)
Comm.
Fert.
Nutrient
Applied
(lbs/A)
Res.
(lbs/A)
Applic.
Method
Iviattt#re,
i
Ntsent
,Applied
(lbs/A)
Liquid
ManureA
pplied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
N
N ""
1003
gal/A
Tons
1000 gals
tons
1249
2
S5
Norfolk
2.85
2.85
Cotton
875 lbs.
*3/15-8/31
*88
0
0
hrig.
88
35.15
0.00
100.18
0.00
1249
3
S5
Norfolk
2.89
2.89
Cotton
875 lbs.
*3/15-8/31
*88
0
0
Inrig.
88
35.13
0.00
101.53
0.00
1249
4
S5
Norfolk
2.93
2.93
Cotton
875 lbs.
*3/15-8/31
*88
0
0
Irrig.
88
35.13
0.00
102.93
0.00
I1249
5
S5
Norfolk
3.20
320
Cotton
875 lbs.
*3/15-8/31
*88
0
0
In-ig.
88
.. ...........
35.13
0.00
112.42
0.00
1259
10
S5
Norfolk
3.03
3.03
Com, Grain
115 bu.
2/15-6/30
131
0
20
hTig.
111
44.31
0.00
134.26
0.00
1259
10
S5
Norfolk
3.03
3.03
Wheat, Grain
60 bu.
9/1-3/31
63
0
0
In-ig.
63
24.95
0.00
75.60
0.00
1259
6
S5
Norfolk
2.70
2.70
Com, Grain
115 bu.
2/15-6/30
131
0
20
hrig.
:' 111
44.31
0.00
119.64
0.00
1259
6
S5
Norfolk
2.70
2.70
Wheat, Grain
60 bu.
9/1-3/31
63
0
0
Inrig.
63
24.95
0.00
67.37
0.001
0.001
0.00
1259
7
S5
Norfolk
3.19
3.19
Corn, Grain
115 bu.
2/15-6/30
131
0
20
hrig.
111
44.31
0.00
141.35
1259
7
S5
Norfolk
3.19
3.19
Wheat, Gram
60 bu.
9/1-3/31
63
0
0
In-ig.
63
24.95
0.00
79.59
1259
8
S5
Norfolk
3.19
3.19
Corn, Gram
115 bu.
2/15-6/30
131
0
20
brig.
11 1
44.31
0.00
141.35
0.00
1259
8
S5
Norfolk
3.19
3.19
Wheat, Grain
60 bu.
9/1-3/31
63
0
0
hrig.
63
24.95
0.00
79.59
0.00
1259
9
S5
Norfolk
3.19
3.19
Com, Gram
115 bu.
2/15-6/30
131
0
20
hrig.
111
44.31
0.00
141.35
0.00
1259
9
S5
Norfolk
3.19
3.19
Wheat, Gram
60 bu.
9/1-3/31
63
0
0
brig.
6
24.95
0.00
79 a9
0.00
128
Zone 1
S5
Norfolk
0.76
0.76
Small Grain Overseed
1.0 Tons
10/1-3/31
50
0
0
Irrig.
50
19.97
0.00
15.18
0.00
128
Zone 1
S5
Norfolk
0.76
0.76
Hybrid Bcrmudagrass Hay
6.5 Tons
3/1-9/30
296
0
0
hrig.
296
118.24
0.00
89.86
0.001
296088 Database Version 3.1
Date Printed: 4/19/2005
W1JT Page 1 of 4

Waste Utilization Table
Year
Tract
Field
Source
ID
Soil Series
Total
Acres
Use.
Acres
Crop
RYE
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
(lbs/A)
Comm.
Fert.
Nutrient
Applied
(lbs/A)
Res.
(Ibs/A)
Applic.
Method
Manure
Nutsi Ytt
Applied
(lbs/A)
Liquid
ManureA
pplied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
N
N`
1003
gal/A
Tons
1000 gals
tons
128
Zone 2
S5
Norfolk
0.76
0.76
Small Grain Overseed
1.0 Tons
10/1-3/31
50
0
0
Irrig.
50
19.97
0.00
15.18
0.00
128
Zone 2
S5
Norfolk
0.76
0.76
Hybrid Bermudagrass Hay
6.5 Tons
3/1-9/30
296
0
0
brig.
296
118.24
0.00
89.86
0.001
0.00
128
Zone 3
S5
Norfolk
0.76
0.76
Small Grain Overseed
1.0 Tons
10/1-3/31
50
0
0
Inig.
S0
19.97
0.00
15.18
128
Zone 3
S5
Norfolk
0.76
0.76
Hybrid Bermudagrass Hay
6.5 Tons
3/1-9/30
296
0
0
Irrig.
296
118.24
0.00
89.86
0.00
128
Zone 4
S5
Norfolk
0.75
0.75
Small Grain Overseed
1.0 Tons
10/1-3/31
50
0
0
Irrig.
50
19.97
0.00
14.98
0.00
128
Zone 4
S5
Norfolk
0.75
0.75
Hybrid Bermudagrass Hay
6.5 Tons
3/1-9/30
296
0
0
Irrig.
296
118.24
0.00
88.68
0.00
'` v" Total Applied, 1000 gallons
1,895.52
Total Produced. 1000 gallons
794.56
Balance, 1000 gallons
-1,100.96
Total Applied, tons
0.00
Total Produced, tons
" "
0.00
Balance. tons
0.00'
Notes: 1. In the tract column, - symbol means leased, otherwise, owned.
2. Symbol * means user entered data.
296088 Database Version 3.1 Date Printed: 4/19/2005 WUT Page 2 of 4

Waste Utilization Table
yu+ Al
Tract
Field
Source
ID
Soil Series
Total
Acres
Use.
Acres
Crop
RYE
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
(lbs/A)
Comm.
Fert.
Nutrient
Applied
(Ibs/A)
Res.
(Ibs/A)
Applic.
Method
Manure
PA
Nutrient
Applied
(Ibs/A)
Liquid
ManureA
pplied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
N
N
1000
gal/A
Tons
1000 gals
tons
Total Applied,
1000
gallons
2,054.32
.;
Total Produced 1000 gallons
794.56
Balance, 1000 gallons
-1,259.76
Total Applied, tons
0.00
Total Produced, tons
. -
0.00
0.00'
Balance, tons
ores: 1. In the tract colunm, — symbol means leased, otherwise, owned.
2. Symbol * means user entered data.
296088 Database Version 3.1 Date Printed: 4/19/2005
\\'UT Page 4 of 4

Waste Utilization Table
Tract
Field
Source
ID
Soil Series
Total
Acres
Use.
Acres
Crop
RYE
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
(lbs/A)
Comm.
Fert.
Nutrient
Applied
(lbs/A)
Res.
(Ibs/A)
Manure
PA
Nutrient
Applied
(Ibs/A)
Liquid
ManureA
pplied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
N
APPIic.
Method
N
I0W
gal/A
Tons
1000 gals
tons
1249
2
S5
Norfolk
2.85
2.85
Cotton
875 lbs.
*3/15-8/31
*88
0
0
Irris.
88
35.15
0.00
100.18
0.00
1249
3
S5
Norfolk
2.89
2.89
Cotton
875 lbs.
*3/15-8/31
*88
0
0
Irrig.
88
35.13
0.00
101.53
0.00
1249
4
S5
Norfolk
2.93
2.93
Cotton
875 Ibs.
*3/15-8/31
*88
0
0
hrig.
88
35.13
0.00
102.93
0.00
1249
5
S5
Norfolk
3.20
3.20
Cotton
875 lbs.
*3/15-8/31
*88
0
0
Irrig.
88
35.13
0.00
112.42
0.00
1259
10
S5
Norfolk
3.03
3.03
Wheat, Grain
60 bu.
9/1-3/31
63
0
0
Irrig.
63
24.95
0.00
75.60
0.00
1259
10
S5
Norfolk
3.03
3.03
Soybeans, Manured, Double Crop
35 bu.
4/1-9/15
137
0
0
In-ig.
137
54.69
0.00
165.71
0.00
1259
6
S5
Norfolk
2.70
2.70
Wheat, Grain
60 bu.
9/1-3/31
63
0
0
Irrig.
63
24.95
0.00
67.37
0.00
1259
6
S5
Norfolk
2.70
2.70
Soybeans, Manured, Double Crop
35 bu.
4/1-9/15
137
0
0
Irrig.
137
54.69
0.00
147.67
0.00
1259
7
SS
Norfolk
3.19
3.19
Whoat, Grain
60 bu.
9/1-3/31
63
0
0
In-ig.
63
24.95
0.00
79.59
0.00
1259
7
S5
Norfolk
3.19
3.19
Soybeans, Manured, Double Crop
35 bu.
4/1-9/15
137
0
0
In-ig.
137
54.69
0.00
174.46
0.00
1259
S
S5
Norfolk
3.19
3.19
Wheat, Grain
60 bu.
9/1-3/31
63
0
0
In-ig.
63
24.95
0.00
79.59
0.00
1259
8
S5
Norfolk
3.19
3.19
Soybeans, Manured, Double Crop
35 be.
4/1-9/15
137
0
0
Irrig.
137
54.69
0.00
174.46
0.00
1259
9
S5
Norfolk
3.19
3.19
Wheat, Grain
60 bu.
9/1-3/31
63
0
0
Irrig.
63
24.95
0.00
79.59
0.00
1259
9
S5
Norfolk
3.19
3.19
Soybeans, Manured, Double Crop
35 bu.
4/1-9/15
137
0
0
brig.
137
54.69
0.00
174.46
0.00
128
Zone 1
S5
Norfolk
0.76
0.76
Small Grain Overseed
1.0 Tons
10/1-3/31
50
0
0
hrig.
50
19.97
0.00
15.18
0.00
128
Zone I
S5
Norfolk
0.76
0.76
Hybrid Bermudagrass Hay
6.5 Tons
3/1-9/30
296
0
0
In-ig.
296
118.24
0.00
89.86
0.00
128
Zone 2
S5
Norfolk
0.76
0.76
Small Grain Overseed
1.0 Tons
10/1-3/31
50
0
0
Irrig.
50
19.97
0.00
15.18
0.00
128
Zone 2
S5
Norfolk
0.76
0.76
Hybrid Bermudagrass Hay
6.5 Tons
3/1-9/30
296
0
0
brig.
296
118.24
0.00
89.86
0.00
128
Zone 3
S5
Norfolk
0.76
0.76
Small Grain Overseed
1.0 Tons
10/1-3/31
50
0
0
Irrig.
50
19.97
0.00
15.18
0.00
128
Zone 3
S5
Norfolk
0.76
0.76
Hybrid Bermudagrass Hay
6.5 Tons
3/1-9/30
296
0
0
Irrig.
296
118.24
0.00
89.86
0.00
128
Zone 4
S5
Norfolk
0.75
0.75
Small Grain Overseed
1.0 Tons
10/1-3/31
50
0
0
In-ig.
50
19.97
0.00
14.98
0.00
128
Zone 4
S5
Norfolk
0.75
0.75
Hybrid Bermudagrass Hay
6.5 Tons
3/1-9/30
296
0
0
brig.
296
118.24
0.00
88.68
0.00
296088 Database Version 3.1
Date Printed: 4/19/2005
WUT Page 3 of 4

The Irrigation Application Factors for each field in this plan are shown in the following table. Infiltration rate varies
with soils. If applying waste nutrients through an irrigation system, you must apply at a rate that will not result in
runoff. This table provides the maximum application rate per hour that may be applied to each field selected to
receive wastewater. It also lists the maximum application amount that each field may receive in any one application
event.
Irrigation Application Factors
Tract
Field
Soil Series
Application Rate
(inches/hour)
Application Amount
(inches)
1249
2
Norfolk
0.50
1.0
1249
3
Norfolk
0.50
1.0
1249
4
Norfolk
0.50
1.0
1249
5
Norfolk
0.50
1.0
1259
10
Norfolk
0.50
1.0
1259
6
Norfolk
0.50
1.0
1259
7
Norfolk
0.50
1.0
1259
8
Norfolk
0.50
1.0
1259
9
Norfolk
0.50
1.0
128
Zone 1
Norfolk
0.50
1.0
128
Zone 2
Norfolk
0.50
1.0
128
Zone 3
Norfolk
0.50
1.0
128
Zone 4
Norfolk
0.50
1.0
296088 Database Version 3.1 Date Printed 4/19/2005 IAF Page 1 of 1
1JTllmt . O.* ........ ............«..«..,7 .7..«..

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for
sludge utilization for the indicated accumulation period. These estimates are based on average nitrogen
concentrations for each source, the number of animals in the facility and the plant available nitrogen appl ication
rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At
clean out, this material must be utilized for crop production and appl ied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of sludge must be carefully applied.
Sites ►nust first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, care should be taken not to load effluent application fields with
high amounts of copper and zinc so that additional effluent cannot be appl ied. On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also
be a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
Ib/ac
Maximum Sludge
Application Rate
1000 gal/ac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Nursery Lagoon Sludge - Standard
Corn 120 bu
150
13.16
10.59
21.18
31.77
Hay 6 ton R.Y.F.
300
26.32
5.29
10.59
15.88
Soybean 40 bu
160
14.04
9.93
19.85
29.78
296088 Database Version 3.1 Date Printed: 04-19-2005 Sludge Page 1 of 1

The Available Waste Storage Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the plan. Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crop in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater than the design storage
capacity, this indicates that the plan calls for the application of nutrients that have not yet accumulated.
If available storage capacity is negative, the estimated volume of accumulated waste exceeds the design
storage volume of the structure. Either of these situations indicates that the planned application interval
in the waste utilization plan is inconsistent with the structure's temporary storage capacity.
Available Was
Source Name
Swine Nursery Lagoon Liquid
Design Storage Capacity (Days)
Start Date
10/31
180
Plan Year
Month
Available Storage Capacity (Days) *
1
1
102
1
2
88
1
3
135
1
4
180
1
5
180
1
6
180
1
7
159
1
8
179
1
9
149
1
10
180
1
11
180
1
12
149
2
1
118
2
2
180
2
3
180
2
4
180
2
5
180
2
6
180
2
7
180
2
8
180
2
9
180
2
10
149
2
11
133
r
2
12
102
* Available Storage Capacity is calculated as of the end of each month.
296088 Database Version 3.1 Date Printed: 04-19-2005 Capacity Page 1 of 1

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches surface
water is prohibited.
2. There must be documentation in the design folder that the producer
either owns or has an agreement for use of adequate land on which to
properly apply the waste. If the producer does not own adequate land to
properly dispose of the waste, he/she shall provide evidence of an
agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the
responsibility of the owner of the waste production facility to secure an
update of the Nutrient Management Plan when there is a change in the
operation, increase in the number of animals, method of application,
receiving crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture, historical
data, climatic conditions, and level of management, unless there are
regulations that restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre
per year. Waste may be applied to land eroding at more than 5 tons per
acre per year but less than 10 tons per acre per year provided grass filter
strips are installed where runoff leaves the field (see USDA, NRCS Field
Office Technical Guide Standard 393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drift
from the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste
will be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone
to flooding (see "Weather and Climate in North Carolina" for guidance).
296088 Database Version 3.1 Date Printed: 4/19/2005 Specification Page 1

7. Liquid waste shall be applied at rates not to exceed the soil infiltration
rate such that runoff does not occur offsite or to surface waters and in a
method which does not cause drift from the site during application. No
ponding should occur in order to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall
events, or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner
that the crop is not covered with waste to a depth that would inhibit
growth. The potential for salt damage from animal waste should also be
considered.
10. Nutrients from waste shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Waste/nutrient
loading rates on these soils should be held to a minimum and a suitable
winter cover crop planted to take up released nutrients. Waste shall not
be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11. Any new swine facility sited on or after- October 1, 1995 shall comply with
the following: The outer perimeter of the land area onto which waste is
applied from a Iagoon that is a component of a swine farm shall be at least
50 feet from any residential property boundary and canal. Animal waste,
other than swine waste from facilities sited on or after October 1, 1995,
shall not be applied closer that 25 feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and
public right-of-ways.
296088 Database Version 3.1 Date Printed: 4/19/2005 Specification Page 2

15. Animal waste shall not be discharged into surface waters, drainageways,
or wetlands by a discharge or by over -spraying. Animal waste may be
applied to prior converted cropland provided the fields have been
approved as a land application site by a "technical specialist". Animal
waste shall not be applied on grassed waterways that discharge directly
into water courses, and on other grassed waterways, waste shall be
applied at agronomic rates in a manner that causes no runoff or drift
from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
system.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas
shall be fenced, as necessary, to protect the vegetation. Vegetation such as
trees, shrubs, and other woody species, etc., are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and
accessible. Berms and structures should be inspected regularly for
evidence of erosion, leakage, or discharge.
18. if animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution, and
erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected
on a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used on
crops for direct human consumption, it should only be applied pre -plant
with no further applications of animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid level
between the markers. A marker will be required to mark the maximum
storage volume for waste storage ponds.
296088 Database Version 3.1 Date Printed: 4/19/2005 Specification Page 3

22. Waste shall be tested within 60 days of utilization and soil shall be tested
at least annually at crop sites where waste products are applied. Nitrogen
shall be the rate -determining nutrient, unless other restrictions require
waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the
soils shall be monitored and alternative crop sites shall be used when
these metals approach excessive levels. pH shall be adjusted and
maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of five years. Poultry dry waste
application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for five
(5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
296088 Database Version 3.1 Date Printed: 4/19/2005 Specification Page 4

Putt _.
Put i
P'ut(
4
'i Ott
Pull 5
=
pacing = 200 r
A1"e0. L
C. (it)
500
535
3.50 5:5
J 32,.E
r-,(-tiCYIG.!.
Areo. Length
(o.c) C� 4)
Pall 5 3.50 530
Put! 7 3.84 650
650
Putt 9 3.96 650
Putt 10 2.60 345
Q Pieta Edge
— 'flitch
Irrigation
l r a c -t 1211

Operator:COLLYN 8EAMAN County: GREENE ,� Date: 3'6-95
Distance to nearest residence (other than owner): 1600 feet
1. AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish) x 1417 |bs. = 0 |bs
0 sows (farrow to feeder) x 522 |bs. = 0 lbs
0 head (finishing only) x 135 |bs. = 0 |bs
0 sows (farrow to wean) x 433 lbs. = 0 /hs
4160 head (wean to feeder) x 30 lbs. = 124800 /bs
Describe other :
____________________________________� 0 |bs
-------------------------------------
Total Average Live Weight = 124800 |hs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 124800 |bs. ALW x Treatment Vo|ume(CF)/|b. ALW
Treatment Volume(CF)/|b. ALW = 1 CF/}b. ALW
Volume = 124800 cubic feet
3.
STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 62400 cubic feet
4. TOTAL DESIGNED VOLUME
Inside top length (feet) ---------------------
Inside top width (feet) ----------------------
Top of dike elevation (feet) -----------------
Bottom of lagoon elevation (feet) ------------
Freeboard (feet) -------------I---------------
Side slopes (inside lagoon) ------------------
350.0
140.0
50.5
40.5
1.0
3.0 : 1
Total design volume using prismoida} formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 344.0 134.0 9.0
AREA OF TOP
LENGTH * WIDTH =
344.0 134.0
AREA OF BOTTOM
LENGTH * WIDTH =
290.0 80.0
AREA OF MIDSECTION
LENGTH * WIDTH * 4
317.0 107.0
46096 (AREA OF TOP)
23200 (AREA OF BOTTOM)
135676 (AREA OF MIDSECTION * 4)
/
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA 8OTTOM3 * DEPTH/6
46096.0 135676.0 23200.0 1.5
Total Designed Volume Available = 307458 CU. FT.

5. TEMPORARY STORAGE F ,UIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
350.0 140.0 49000.0 square feet
Buildings (roof and lot water)
0.0 square feet
TOTAL DA 49000.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Feces & urine production in gal./day per 135 |b. ALW
VoIume =
Vo|ume =
Describe this area.
124800 |bs. ALW/135 |bs ALW * 1.37 gal/day
227968 gals. or 30477.0 cubic feet
58. Volume of wash water
1.37
/
180 d,ays
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system or excess water. Flush systems
that recirculate the lagoon water are accounted for in 5A.
Vo|ume =
Volume = 20021.4 cubic feet
832.0 gallons/day * 180 days stora8e/7.48 gallons
per CF
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall
= 7.0 inches
Volume = 7.0 inches * DA / 12 inches per foot
.Volume = 28583.3 cubic feet
5D. Volume of 25 year - 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume = 28583.3 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 30477 cubic feet
5B. 20021 cubic feet
5C. 28583 cubic feet
5D. 28583 cubic feet
TOTAL 107665 cubic feet

6. SUMMARY
Temporary storage period====================> 180 days
Rainfall in excess of evaporation===========> 7.0 inches
25 year - 24 hour rainfa|/==================> 7.0 inches
Freeboard===================================> 1.0 feet
Side s/opes=================================> 3.0 : 1
Inside top |en8th===========================> 350.0 feet
Inside top width============================> 140.0 feet
Top of dike e|evat{on=======================> 50.5 feet
Bottom of lagoon e|evation==================> 40.5 feet
Total required vo}ume=======================> 294865 cu. ft.
Actual design voiume========================> 307458 cu. ft.
Seasonal high watertab|e elevation (SHWT)===> 43.5 feet (qw^,l?
Stop pumping e|ev.==========================> 46.7 feet/ '
Must be > or = to the GHWT e{ev.=======G==> 43.5 feet
Must be > or = to min. req. treatment el.=> 46.5 feet
Required minimum treatment vo|ume===========> 187200 cu. ft.
Volume at stop pumping eievation============> 189368 cu. ft.
Start pumping e|ev.=========================> 48.8 feet �
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr - 24 hr rainfa|/===> 278875 cu. ft.
Volume at start pumping e|evation====------ => 275889 cu. ft.
Required volume to be pumped================> 79082 cu. ft.
Actual volume to be pumped==================> 86521 cu. ft.
T. DESIGNED 8Y
Q0-k(
DATE: Lj/2-3���.
� /.'
APPROVED BY:
DATE: 3~X~�~��'
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS:__________________________________________________________
_

OPERATION AND MAINTENANCE PLAN
SHEET 1 OF 2
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations and the amount
of fresh water added to the system. '
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
^
fairly constant throughout the year and from year to year, but excess
rainfall wi | | vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage/
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
bui|d(n3(s). If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
I. It is strongly recommended that the treatment lagoon be pre --
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharSing is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed.This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 48.8 as marked by permanent marker. Stop pump-
`
out when the fluid level reaches elevation 46.7 . This ^emporary
storage, less 25 yr- 24 hr storm, contains 79081.7 cubic feet or
591531.3 gallons.

SHEET 2 OF 2
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
out |ets.
8. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.
/

Swine Farm Waste Management Odor Control Checklist
Source
Farmstead
Cause
• Swine production
Animal body surfaces
HMI's to Minimize Odor
Ea Vegetative or wooded butlers;
Gi Recommended best management practices;
t Good judgment and common sense
Site Specific Practices
• Dirty manure -covered animals 0 Dry floors
Floor surfaces
• Wet manure -covered (lours
• Slotted floors;
C Waterers located over slotted floors;
O feeders at high cod of solid floors;
13 Scrape manure buildup from floors;
O Underfloor ventilation for drying
Manure collection pits • Lit ine;
• Partial microbial decomposition
pf Frequent manure removal by flush, pit recharge,
or set ape;
O Underfloor ventilation
Ventilation exhaust fans
Volatile gases;
Dust
Indoor surfaces • Dust
Fan maintenance;
3 Efficient air movement
1: Washdown between groups of animals;
• 0 feed additives;
O feeder covers;
Feed delivery downspout extenders to feeder
covers
Flush tanks
Flush alleys
• Agitation of recycled lagoon
liquid while tanks are filling
• Agitation during wastewater
conveyance
fit recharge points
O flush tack covers;
O Extend fill lines to near bottom of tanks with
anti -siphon vents
0 Underfloor flush with underfloor ventilation
• Agitation of recycled lagoon
liquid while pits are filling with anti -siphon vents
O Extend recharge lines to near bottom of pits
Lift stations
• Agitation during sump tank 0 Sump tank covers
filling and drawdown
Outside drain collection
or junction boxes
Agitation during wastewater
conveyance
AMOC - November 11, 1996, page 3
O tiox covers

Source
End of drainpipes at
lagoon
Lagoon surfaces
Cause
• Agitation during wastewater
conveyance
• Volatile gas emissions;
• Biological mixing;
• Agitation
Mrs to Minimize Odor Site Specific Practices
O Extend discharge point of pipes underneath
lagoon liquid level
b. Proper lagoon liquid capacity;
El Correct lagoon startup procedures;
0 Minimum surface area -to -volume radio;
Minimum agitation when pumping;
O Mechanical aeration;
O Proven biological additives
Irrigation sprinkler
nozzles
• I Iigh pressure agitation;
• Wind drill
Irrigate on dry days with little or no wield;
0 Minimum recommended operating pressure;
O Pump intake near lagoon liquid surface;
0 Pump from second -stage lagoon
Storage tank or basin
surface
• Partial microbial decomposition;
• Mixing while filling;
• Agitation when emptying
O Bottom or midlevel loading;
O Tank covers;
O Basin surface mats of solids;
O Proven biological additives ter oxidants
Settling basin surface
• Partial microbial decomposition;
• Mixing while filling;
tvtanure, slurry or sludge •
spreader outlets •
• Agitation when emptying
Agitation when spreading;
Volatile gas emissions
O Extend drainpipe outlets underneath liquid
level;
Cl Remove settled solids regularly
O Soil injection of slurry/sludges;
O Wash residual manure from spreader after use;
O Proven biological additives or oxidants
Uncovered manure,
slurry or sludge on field
surfaces
• Volatile gas emissions while
drying
O Soil injection of slurry/sludges
O Soil incorporation within 48 hrs.;
O Spread in thin uniform layers for rapid drying;
O Proven biological additives or oxidants
Dead animals • Carcass decomposition
p9- Proper disposition of carcasses
Dead animal disposal • Carcass decomposition
pits
O Complete covering of carcasses in burial pits;
O Proper location/construction of disposal pits
htcinerators • Incomplete combustion
O Secondary stack burners
AMOC - November 11, 1996, Page 4

Source
Standing water around
facilities
Manure tracked onto
public roads from farm
access
Cause
• Improper drainage;
• Microbial decomposition of
organic matter
• l'oorly maintained :access roads
HMI's ttr-aliuin►izc Odor
Grade and landscape such that water drains
away from facilities
Farm access road maintenance
Additional Information :
Swine Manure Management ; 0200 Ituie/13M1' Packet 1 13A1: Fact Sheet
Swine Production Farm Potential Odor Sources and Remedies ;
8
Swine Production Facility Manure Management:
Undc �(toorFlushb Lagoon Treatn►eLt�AE[3AE 129-88
Swine Production Facility Manure Management:
Lagoon Design and Managemenivsnure Equipment Treatment
and : FactSheet
103-83
Calibration of Manure and Wastewater
Controlling Odors from Swine Buildings ;
PI11-33
Environmental Assurance Program ; NPPC Manual
Options for Managing Odor ; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies ; PRO107, 1995 Conference Proceedings
AMOC - November 1 I, 1996, Page 5
Site Specific Practices
Available From :
NCSU, County Extension Center
NCSU - f3AE
NCSU - BAE
NCSU - [3AE
NCSU - f3AE
NCSU -13AC
NCSU - Swine Extension
NC Pork Producers Assoc
NCSU Agri Comnrtinications
Florida Cooperative Extension

Insect Control Checklist for Animal Operations
Sourcc Cause
Flush Gutters • Accumulation of solids
11N91's to Control lusects
Site Specific Practices
Liquid Systems
CI Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed.
0 Remove bridging of accumulated solids at
Lagoons and Pits • Crusted Solids
discl►argc
0 Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
Excessive Vegetative
• Decaying vegetation
Growth
AP
Maintain vegetative control along banks of
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
Dry Systems
Feed Spillage 0 Design, operate and maintain feed systems (e.g.,
Feeders • bunkers and troughs) to minimize the
accumulation of decaying wastage.
0 Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
Feed Storage • Accumulations of feed residues
during winter).
Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
moisture grain products).
Inspect for and rcinovc or break up accumulated
solids in filter strips around feed storage as
needed.
AMIC - November 11, 1996, I'agc 1

Animal Holding Areas • Accumulations of animal ‘vastcs
and feed wastage
I )1j' tlantil e I landling
SvslClnS
So11rre Cause 13l\11's to Control Insects Site Specific Practices
O Eliminate low areas that trap moistu►e along
fences and other locations where waste
accumulates and disturbance by animals is
minimal.
0 tvlaintain fence rows and filter strips around
animal holding areas to minimize
accumulations of wastes (i.e., inspect for and
remove or break up accumulated solids as
needed).
• Accumulations of animal wastes O Remove spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
during winter) where manure is loaded for land
application or disposal.
O Provide for adequate drainage around manure
stockpiles.
O Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and
manure handling areas as needed.
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University,
Raleigh, NC, 27695-7613.
A("IIC - November I I, 1996, Page 2

Version —November 26, 2018
Mortality anagement Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Signature of Farm Owner/Manager
hnical Specialist
3- /--/
Date
Date

Emergency Action Plan
This plan will be implemented in the event that wastes from your operations are leaking, overflowing, or
running off the site. You should NOT wait until wastes reach surface waters or leave your property to
consider that you have a problem. You should make every effort to ensure that this does not happen. This
plan should be available to all employees at the facility, as accidents, leaks, and breaks can happen at any
time.
1) Stop the release of wastes. Depending on the situation, this may or may not be possible. Suggested
responses to problems are listed below:
a) Lagoon overflow:
• add soil to the berm to increase the elevation of the dam
• pump wastes to fields at an acceptable rate
• stop all additional flow to the lagoon (waterers)
• call a pumping contractor
• make sure no surface water is entering the lagoon
Note: These activities should be started when your lagoon level has exceeded the temporary storage level.
b) Runoff from waste application field:
• immediately stop waste application
• create a temporary diversion or berm to contain the waste on the field
• incorporate waste to reduce further runoff
c) Leaking from the waste distribution system:
• pipes and sprinklers:
O stop recycle (flushing system) pump
O stop irrigation pump
© close valves to eliminate further discharge
® separate pipes to create an air gap and stop flow
• flush system, houses, solids separators:
O stop recycle (flushing system) pump
O stop irrigation pump
© make sure no siphon effect has been created
® separate pipes to create an air gap and stop flow
d) Leakage from base or sidewall of the lagoon. Often these are seepage as opposed to flowing
leaks:
• dig a small well or ditch to catch all seepage, put in a submersible pump, and pump back
into the lagoon

• if holes are caused by burrowing animals, trap or remove animals
and fill holes and compact with a clay type soil.
• other holes may be likewise temporarily plugged with clay soil.
Note: For permanent repair measures, lagoon problems require the
consultation of an individual experienced in their design and installation.
2) Assess the extent of the spill and note any obvious damages.
a) Did the waste reach any surface waters?
b) Approximately how much was released and for what duration?
c) Any damage noted, such as employee injury, fish kills, or property damage?
3) Contact appropriate agencies.
a) During normal business hours, call your DWQ regional office: [phone] ; after
hours, emergency number: [phone]. Your phone call should include: your name,
facility, telephone number, the details of the incident, the exact location of the facility,
and the location or direction of movement of the spill, weather and wind conditions, what
corrective measures have been taken, and the seriousness of the situation.
b) If the spill leaves the property or enters surface waters, call the local EMS:
747-2544 .
c) Instruct EMS to contact the local Health Department: 747-8181
d) Contact CES: 747-5831
local NRCS office: 747-3705
and your integrator:
4) Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.
5) Contact contract pumping and/or irrigation equipment companies:
a) &bcis 25-1,-23S'-yg/
b)
c)

6) Contact dirt moving and/or heavy equipment companies:
a)
b)
c)
Ca-- Y1.3

USDA United States
Department of
MUM Agriculture
Greene County, North Carolina
Farm 4654
Tract 3840
2019 Program Year
CLU
Acres
HEL
Crop
37.88
NHEL
2
10.62
NHEL
3
12.76
NHEL
4
18.67
NHEL
5
20.1
NHEL
12
92.71
UHEL
Noncropland
Page Cropland Total: 100.03 acres
Map Created October 19, 2018
Base Image Layer flown in 2016
Common Land Unit
Cropland
Non -Cropland
Tract Boundary
Wetland Determination Identifiers
• Restricted Use
V Limited Restrictions
Exempt from Conservation
Compliance Provisions
USDA FSA maps are for FSA Program administration only. This map does not represent a legal survey or reflect actual ownership; rather it depicts the information provided directly from the producer and/or the NAIP imagery. The producer
accepts the data 'as is' and assumes all risks associated with its use. The USDA Farm Service Agency assumes no responsibility for actual or consequential damage incurred as a result of any users reliance on this data outside FSA Programs.
Wetland identifiers do not represent the size, shape, or specific determination of the area. Refer to your original determination (CPA-026 and attached maps) for exact boundaries and determinations or contact NRCS.