400029_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 40-0029 Certificate Of Coverage Number: AWS400029
2. Facility Name: Clay Ridge Farm
3. Landowner's Name (same as on the Waste Management Plan): Michael W Hardy
4. Landowner's Mailing Address: 2364 Glenfield Rd
City: Snow Hill State: NC Zip: 28580
Telephone Number: 252-559-0197 Ext. E-mail: [e-mail]
5. Facility's Physical Address: 1167 Morris Bbq Rd
City: Hookerton State: NC Zip: 28538
6. County where Facility is located: Greene
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"): Maxwell Foods LLC
10. Operator Name (OIC): Michael W. Hardy Phone No.: 252-559-0197 OIC #: 16413
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit:
Operation Types:
Operations Type Allowable Count
Swine - Feeder to Finish 4,000
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
8/15/1994
C1CU./
60 102 Z,
121,968.00
19.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), signed by the owner and a certified technical specialist containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be. subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name: EC.-.{Vc '2.rV
Signature:
R1
Title:
Date: -J -- I S _ (
Name: Title:
Signature: Date:
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

peratorlIMIRE HARDY County: GREE_NE Date: 06/23/94
i stance to neatest residence (other than owner): 1500.0 feet
AVERAGE LIVE WEIGHT (ALW)
O sows (farrow to finish) x 1417 lbs.
O sows (farrow to feeder) 522 lbs.
400I0 head (finishing on).y) x 135 lbs.,.
O sows (farrow to wean) x -433 lbs.
O head (wean to feeder) x 30 lbs.
Describe other .
Total Average Live Weight =
MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
O l b s
O lbs
540000 i. b s
O lbs
O lbs
540000 1 b s
Volume = 540000 lbs. ALW x Treatment VoJ.urne (CF) /1.b. ALW
Treatment Volume(CF)/1b. ALW = 1 CF/.ib. ALW
Volume = 540000 cubic feet
STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
TOTAL DESIGNED VOLUME
PieSLA;:fit: De51GN WrOwNE-U5 (ZetStAG.S7,
IAALL Pm.r✓1(7 45 NEEDED
Inside top length (feet)-- ------------
Inside top width (feet)— ___..__._.._._-•-
Top of dike elevation (feet) -
Bottom of lagoon elevation (feet) ------------
Freeboard (feet)
Side slopes (inside lagoon' --._._...-_._—_...
Total design volume using piri.smoidal. formula
410.0
270.0
55.0
45. 0
1.0
3.0 1 1
SS/END1 S S/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 404.0 264.0 9.0
AREA OF. TOE
LENGTH * WIDTH =
404.0 F:64. 0
AREA OF BOTTOM
LENGTH * WIDTH
350.0 210.0
AREA OF MIDSECTION
LENGTH * WIDTH * 4
377.0 237.0
i.Q)6656 (AREA OF TOP)
73500 (AREA OF BOTTOM)
357396 ( AREA OF MIDSECTION * 4)
CU. FT. = CAREi=t TOP 4- (4 AREA MIDSECTION) -t- AREA BOTTOM] x DEPTH/6
106656.0 357396.0 73500.0
Total Designed Volume Available = 806328 CU. FT.
TEMPORARY STORAGE REQUIRED

DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
410.0 270.0 110700.0 square feet
Buildings (roof and lot water)
0.0 square feet
TOTAL DA 110700.0 square feet
Design temporary storage period to be 180 days.
1. Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
Describe this area.
Volume = 540000 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 986400 gals. or 131871.7 cubic feet
3. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that
?circulate
the lagoon water are accounted for in 5A.
Volume =
0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
1. Volume of rainfall in excess of evaporation
oount.
::
Use period of time when rainfall exceeds evaporation by largest
180 days excess rainfall
= 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 64575.0 cubic feet
). Volume of 25 year — 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume = 64575.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 131872 cubic feet
5B. 0 cubic feet
5C. 64575 cubic feet
5D. 64575 cubic feet
TOTAL 261022 cubic feet
SUMMARY

Temporary storage period
Rainfall in exr_-es of evaporation====:===== _:
25 year - 24 hour
Freebord-=-- =-__=_____._-_ _
Sicie slopes _---_------- - }
.I n s i d e top l e r i g i,; i-,:-..--.---- •--------.-..._.-_- ____ -_ _>
Inside top width===-=__-- -- ---- }
Top of dike elevation===-==_-_-=_----__.___:,__>
B+ottom of lagoon elevation-- ------>
Total required volume-==-=.________-.___--
Act ua i design volume------ ------------------>
Seasonal high water table elevation (SHWT)====>
Stop pumping elev. =__- ___-___-__
Must be > or == to the SHWT e l ev.:_:___ __= _:==>
Must be > or = to min. req. treatment e l . _>
180
7.0
7.0
1.0
3.0
410.0
270.0
55.0
45. 0
801022
806328
47.4
47.4
51.0
days
inches
inches
feet
feet
feet
feet
feet
cu. f t .
c u . ft. #.
feet
feet s/.
feet
feet
Required minimum treatment volume_______..-___> 540000 cu. ft.
Volume at stop pumping elevation---_._____- _> 532730 cu. ft.
Start pumping e l ev.------.----_ _-:.- = _ __ -_=_-_-_> feet r.. 6•
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr. - 24 hr. rainfall===> 741753 cu.
Volume at start pumping elevation __} 732647 cu.
Required volume to be pumped------ _.-.-.=> 196447 cu.
Actual volume planned to be pumpeci
Min. thick less of soil liner when r~equired:== {t- -• t
DESIGNED BY:
Dj-3'1 i:_
APPROVED BY:
DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
Vic/ cr
QK�
pt< B
ft
ft.
ft. i 9-6,,527<r Pt<
COMMENiTs: " Arp av I T_� Stt D C !d o"1 c.1 e'tiS
7i--aitsat-e w( le -her- Le uJr-e bet rc. it ( an 8/0. tee

OPERATION & MAINTENANCE PLAN
Proper lagoon management should be a year-round priority. It is especially important to manage
levels so that you do not have problems during extended rainy and wet periods.
Maximum storage capacity should be available in the lagoon for periods when the receiving crop is
dormant (such as wintertime for bermudagrass) or when there are extended rainy spells such as a
thunderstorm season in the summertime. This means that at the first sign of plant growth in the
later winter / early spring, irrigation according to a farm waste management plan should be done
whenever the land in dry enough to receive lagoon liquid. This will make storage space available
in the lagoon for future wet periods. In the late summer / early fall the lagoon should be pumped
down to the low marker (see Figure 2-1) to allow for winter storage. Every effort should be made
to maintain the lagoon close to the minimum liquid level as long as the weather and waste
utilization plan will allow it.
Waiting until the lagoon has reached its maximum storage capacity before starting to irrigated does
not leave room for storing excess water during extended wet periods. Overflow from the lagoon for
any reason except a 25-year, 24-hour storm is a violation of state law and subject to penalty
action.
The routine maintenance of a lagoon involves the following:
• Maintenance of a vegetative cover for the dam. Fescue or common bermudagrass
are the most common vegetative covers. The vegetation should be fertilized each
year, if needed, to maintain a vigorous stand. The amount of fertilized applied
should be based on a soils test, but in the event that it is not practical to obtain a
soils test each year, the lagoon embankment and surrounding areas should be
fertilized with 800 pounds per acre of 10-10-10, or equivalent.
• Brush and trees on the embankment must be controlled. This may be done by
mowing, spraying, grazing, chopping, or a combination of these practices. This
should be done at least once a year and possibly twice in years that weather
conditions are favorable for heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the herbicide must not be allowed to enter the
lagoon water. Such chemicals could harm the bacteria in the lagoon that are treating the waste.
Maintenance inspections of the entire lagoon should be made during the initial filling of the lagoon
and at least monthly and after major rainfall and storm events. Items to be checked should
include, as a minimum, the following:
Waste Inlet Pipes, Recycling Pipes, and Overflow Pipes -- look for:
1. separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes
2

Lagoon surface -- look for:
1. undesirable vegetative growth
2. floating or lodged debris
Embankment -- look for:
1. settlement, cracking, or "jug" holes
2. side slope stability -- slumps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack or vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalis, thereby weakening the lagoon
dam. A good stand of vegetation will reduce the potential damage caused by wave
action. If wave action causes serious damage to a lagoon sidewall, baffles in the lagoon
may be used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dam. If your lagoon
has any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a
threat of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps -- check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, or a large amount of vibration, may indicate that the pump is in need of repair or
replacement.
NOTE: Pumping systems should be inspected and operated frequently enough so that
you are not completely "surprised" by equipment failure. You should perform your
pumping system maintenance at a time when your lagoon is at its low level. This will
allow some safety time should major repairs be required. Having a nearly full lagoon is
not the time to think about switching, repairing, or borrowing pumps. Probably, if your
lagoon is full, your neighbor's lagoon is full also. You should consider maintaining an
inventory of spare parts or pumps.
• Surface water diversion features are designed to carry all surface drainage
waters (such as rainfall runoff, roof drainage, gutter outlets, and parking lot
runoff) away from your lagoon and other waste treatment or storage
structures. The only water that should be coming from your lagoon is that
which comes from your flushing (washing) system pipes and the rainfall that
hits the lagoon directly. You should inspect your diversion system for the
following:
1. adequate vegetation
2. diversion capacity
3. ridge berm height
3

Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an overflow problem from a surface water diversion or there may be seepage into
the lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before waste
loading begins, taking care not to erode lining or bank slopes.
3. Drainpipes into the lagoon should have a flexible pipe extender on the end of the
pipe to discharge near the bottom of the lagoon during initial filling or another
means of slowing the incoming water to avoid erosion of the lining.
4. When possible, begin loading new lagoons in the spring to maximize bacterial
establishment (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon liquid
volume. This seeding should occur at least two weeks prior to the addition of
wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below 7.0, add
agricultural lime at the rate of 1 pound per 1000 cubic feet of lagoon liquid volume
until the pH rises above 7.0. Optimum lagoon liquid pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate biological
activity. Consultation with a technical specialist is recommended if these
conditions occur for prolonged periods, especially during the warm season.
Loading:
The more frequently and regularly that wastewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily
are optimum for treatment. Pit recharge systems, in which one or more buildings are
drained and recharged each day, also work well.
4

• Practice water conservation --- minimize building water
leaking waterers, broken pipes and washdown through
water conservation.
• Minimize feed wastage and spillage by keeping feeders a
the amount of solids entering the lagoon.
Management:
usage and spillage from
proper maintenance and
djusted. This will reduce
• Maintain lagoon liquid level between the permanent storage level and the full
temporary storage level.
• Place visible markers or stakes on the lagoon bank to show the minimum liquid level
and the maximum liquid level. (Figure 2-1).
• Start irrigating at the earliest possible date in the spring based on nutrient
requirements and soil moisture so that temporary storage will be maximized for the
summer thunderstorm season. Similarly, irrigate in the late summer / early fall to
provide maximum lagoon storage for the winter.
• The lagoon liquid level should never be closer than 1 foot to the lowest point of the
dam or embankment.
• Don not pump the lagoon liquid level lower than the permanent storage level unless
you are removing sludge.
• Locate float pump intakes approximately 18 inches underneath the liquid surface and
as far away from the drainpipe inlets as possible.
• Prevent additions of bedding materials, long-stemmed forage or vegetation, molded
feed, plastic syringes, or other foreign materials into the lagoon.
• Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed.
• Maintain strict vegetation, rodent, and varmint control near lagoon edges.
• Do not allow trees or large bushes to grow on lagoon dam or embankment.
• Remove sludge from the lagoon either when the sludge storage capacity is full or
before it fills 50 percent of the permanent storage volume.
• If animal production is to be terminated, the owner is responsible for obtaining and
implementing a closure plan to eliminate the possibility of a pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:
5

• proper lagoon sizing,
• mechanical solids separation of flushed waste,
• gravity settling of flushed waste solids in an appropriately designed basin, or
• minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long term will:
• have more nutrients,
• have more odor, and
• require more land to properly use the nutrients.
Removal techniques:
• Hire a custom applicator.
• Mix the sludge and lagoon liquid with a chopper - agitator impeller pump through large
- bore sprinkler irrigation system onto nearby cropland; and soil incorporate.
• Dewater the upper part of lagoon by irrigation onto nearby cropland or forageland; mix
remaining sludge; pump into liquid sludge applicator; haul and spread onto cropland or
forageland; and soil incorporate.
• Dewater the upper part of lagoon by irrigation onto nearby cropland or forageland;
dredge sludge from lagoon with dragline or sludge barge; berm an area beside lagoon
to receive the sludge so that liquids can drain back into lagoon; allow sludge to
dewater; haul and spread with manure spreader onto cropland or forageland; and soil
incorporate.
Regardless of the method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that field and
crop requirement. Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage.
Close attention by the pumper or drag -line operator will ensure that the lagoon liner
remains intact. If you see soil material or the synthetic liner material being disturbed, you
should stop the activity immediately and not resume until you are sure that the sludge
can be removed without liner injury. If the liner is damaged it must be repaired as soon
as possible.
Sludge removed from the lagoon has a much higher phosphorus and heavy metal
content than liquid. Because of this it should probably be applied to land with low
phosphorus and metal levels, as indicated by a soil test, and incorporated to reduce the
chance of erosion. Note that if the sludge is applied to fields with very high soil -test
phosphors, it should be applied only at rates equal to the crop removal of phosphorus.
As with other wastes, always have your lagoon sludge analyzed for its nutrient value.
6

The application of sludge will increase the amount of odor at the waste application site.
Extra precaution should be used to observe the wind direction and other conditions
which could increase the concern of neighbors.
Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned discharge of wastewater from the structure.
Types of failures include leakage through the bottom or sides, overtopping, and breach
of the dam. Assuming proper design and construction, the owner has the responsibility
for ensuring structure safety. Items which may lead to lagoon failures include:
• Modification of the lagoon structure -- an example is the placement of a pipe in the
dam without proper design and construction. (Consult an expert in lagoon design
before placing any pipes in dams.)
• Lagoon liquid levels -- high levels are a safety risk.
• Failure to inspect and maintain the dam.
• Excess surface water flowing into the lagoon.
• Liner integrity -- protect from inlet pipe scouring, damage during sludge removal, or
rupture from lowering lagoon liquid level below groundwater table.
NOTE: If lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the dam. Once this damage starts, it can quickly cause a large
discharge of wastewater and possible dam failure.

ROY COOPER
Governor
MICHAEL S. REGAN
Secrerory
LINDA CULPEPPER
Director
NORTH CAROLINA
Environmental Quality
February 27, 2019
Michael W Hardy
Clay Ridge Farm
2364 Glenfield Rd
Snow Hill, NC 28580
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https://deq.nc gov/about/divisions/water-resources/water-quality-regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non -Discharge General Permits, you must submit an application for
permit coverage to the Division. Enclosed you will find a "Request for Certificate of Coverage Facility Currently Covered by an
Expiring State Non -Discharge General Permit." The application form must be completed, signed and returned by April 3, 2019.
Please note that you must include one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with the
completed and signed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Washington Regional Office, Water Quality Regional Operations Section
Greene County Soil and Water Conservation District
AFOG Section Central Files - AWS400029
Maxwell Foods LLC
Csr©lna Department of EaVson x ents, €qua ty 1 tThis,ar: of Water Res ones
512 N. Salsbury St. 1 1636 IV aq Serves Center 1 riaieVr, North C.asc;':e 2769E-1636
919.707 .fit}

Version —November 26, 2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
71
P1n
P1
P1n
P1 II
P1
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
ner/Mana ge Date
f TechI Specialist
Date

Emergency Action Plan
This plan will be implemented in the event that wastes from your operations are leaking, overflowing, or
running off the site. You should NOT wait until wastes reach surface waters or leave your property to
consider that you have a problem. You should make every effort to ensure that this does not happen. This
plan should be available to all employees at the facility, as accidents, leaks, and breaks can happen at any
time.
1) Stop the release of wastes. Depending on the situation, this may or may not be possible. Suggested
responses to problems are listed below:
a) Lagoon overflow:
• add soil to the berm to increase the elevation of the dam
• pump wastes to fields at an acceptable rate
• stop all additional flow to the lagoon (waterers)
• call a pumping contractor
• make sure no surface water is entering the lagoon
Note: These activities should be started when your lagoon level has exceeded the temporary storage level.
b) Runoff from waste application field:
• immediately stop waste application
• create a temporary diversion or berm to contain the waste on the field
• incorporate waste to reduce further runoff
c) Leaking from the waste distribution system:
• pipes and sprinklers:
O stop recycle (flushing system) pump
© stop irrigation pump
© close valves to eliminate further discharge
© separate pipes to create an air gap and stop flow
• flush system, houses, solids separators:
© stop recycle (flushing system) pump
© stop irrigation pump
© make sure no siphon effect has been created
© separate pipes to create an air gap and stop flow
d) Leakage from base or sidewall of the lagoon. Often these are seepage as opposed to flowing
leaks:
• dig a small well or ditch to catch all seepage, put in a submersible pump, and pump back
into the lagoon

• if holes are caused by burrowing animals, trap or remove animals
and fill holes and compact with a clay type soil.
• other holes may be likewise temporarily plugged with clay soil.
Note: For permanent repair measures, lagoon problems require the
consultation of an individual experienced in their design and installation.
2) Assess the extent of the spill and note any obvious damages.
a) Did the waste reach any surface waters?
b) Approximately how much was released and for what duration?
c) Any damage noted, such as employee injury, fish kills, or property damage?
3) Contact appropriate agencies.
a) During normal business hours, call your DWQ regional office: [phone] ; after
hours, emergency number: 1-800-858-0368. Your phone call should include: your
name, facility, telephone number, the details of the incident, the exact location of the
facility, and the location or direction of movement of the spill, weather and wind
conditions, what corrective measures have been taken, and the seriousness of the situation.
b) If the spill leaves the property or enters surface waters, call the local EMS:
747-2544.
c) Instruct EMS to contact the local Health Department: 747-8181.
d) Contact CES: 747-5831
local NRCS office: 747-3705
and your integrator:
4) Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.
5) Contact contract pumping and/or irrigation equipment companies:
a)
b)
c)
Rr� nn i 4UkJ l q 1 q--7 3s- 35821

6) Contact dirt moving and/or heavy equipment companies:
a) t'cY\ 1 it ( 252. 52.(0 841/03
b)
c)

' WASTE UTILIZATION PLAN
Brian Tingen Company
Saturday, March 09, 2013
Producer :
Farm Name :
Telephone # :
Type of Operation :
Number of Animals:
Application Method:
MIKE HARDY
CLAY RIDGE
2364 GLENFIELD RD
SNOW HILL,NC 28580
[phone]
Feeder to Finish Swine
4000 hogs design capacity
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the fields where
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
contents of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and avaialable water holding capacities. Normally waste shall not be applied to
land eroding at greater than 5 tons per acre per year. With special pre -cautions, waste may
be applied to land eroding at up to 10 tons per acre per year. Do not apply waste on
saturated soils, when it is raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To
maximize the value of the nutrients for crop production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied to bare ground not more
than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems. This plan is based on waste application through irrigation for this is
the manner in which you have chosen to apply your waste. If you choose to inject the waste
in the future, you need to revise this plan. Nutrient levels for injecting waste and irrigating
waste are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananlysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1

AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
4000 hogs X 1.9 tons waste/hogs/year = 7600 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
4000 hogs X 2.3 lbs PAN/hogs/year = 9200 PAN/year
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type and suface application.
TABLE 1 : ACRES OWNED BY PRODUCER
TRACT FIELD
619
619 1
619 - 1
561 * 10
561 * 10
561 * 10
561 * 11
561 * 11
561 * 11
619 - 2
619 2
619 - 3
619 3
619 4
619 4
619 - 4
619 5
619 5
619 - 5
619 - 6
619 6
619 - 7
619 7
619 8
619 8
619 * 9
619 * 9
619 * 9
SOIL TYPE &CLASS -
DETERMINING PHASE
COWARTS 1-5%
NORFOLK 2-6%
NORFOLK 2-6%
KALMIA 0-2%
KALMIA 0-2%
KALMIA 0-2%
KALMIA 0-2%
KALMIA 0-2%
KALMIA 0-2%
COWARTS 1-5%
COWARTS 1-5%
COWARTS 1-5%
COWARTS 1-5%
COWARTS 1-5%
NORFOLK 2-6%
NORFOLK 2-6%
COWARTS 1-5%
NORFOLK 2-6%
NORFOLK 2-6%
KALMIA 0-2%
KALMIA 0-2%
NORFOLK 0-2%
NORFOLK 0-2%
COWARTS 1-5%
KALMIA 0-2%
KALMIA 0-2%
KALMIA 0-2%
KALMIA 0-2%
CROP YIELD
CODE
BP 4.7 235 0
BP 5.2 260 0
SG 1 50 0
W 60 120 0
C 110 117.5 20
SB 38 152 0
W 60 120 0
C 110 117.5 20
SB 38 152 0
SG 1 50 0
BP 4.7 235 0
SG 1 50 0
BP 4.7 235 0
BP 4.7 235 0
BP 5.2 260 0
SG 1 50 0
BP 4.7 235 0
BP 5.2 260
SG 1
SG 1 50
BP 5.4 270
SG 1 50
BP 5.2 260
BP 4.7 235
BP 5.4 270
C 110 117.5
W 60 120
SB 38 152
LBS AW COMM ACRES LBS AW APPLIC.
N/ACRE NACRE USED TIME
2.91 683.85
2.91 756.6
5.82 291
5.42 650.4
5.42 636.85
5.42 823.84
6.24 748.8
6.24 733.2
6.24 948.48
3.48 174
3.48 817.8
2.37 118.5
2.37 556.95
1.45 340.75
1.45 377
2.9 145
2.06 484.1
2.06 535.6
4.12
3.18 159
0 3.18 858.6
0 3.3 165
0 3.3 858
0 3.4 799
0 3.4 918
20 5.42 636.85
0 5.42 650.4
0 5.42 823.84
TOTALS: 12365.1
APR-SEP
APR-SEP
SEP-MAY
SEP-APR
MAR-JUN
APR-SEP 15
SEP-APR
MAR-JUN
APR-SEP 15
SEP-MAY
APR-SEP
SEP-MAY
APR-SEP
APR-SEP
APR-SEP
SEP-MAY
APR-SEP
APR-SEP
SEP-MAY
SEP-MAY
APR-SEP
SEP-MAY
APR-SEP
APR-SEP
APR-SEP
MAR-JUN
SEP-APR
APR-SEP 15
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirments. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of NC to have a nutrient management plan that addresses all
nutrients. This plan only addresses Nitrogen.
Page 2

TABLE 2 : ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land. See required specifications 2.)
There are no Acres Leased
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
* Acreage figures may exceed total acreage in field due to overseeding.
**Lbs AW N (animal waste nitrogen) equals total required nitrogen less any commercial
nitrogen (COMM N) supplied.
The following legend explains the crop codes used in TABLES 1 and 2 above:
CROP CODE
BP
SG
SB
CROP
CORN
HYBRID BERMUDAGRASS-PASTURE
SMALL GRAIN OVERSEEDED
SOYBEANS
WHEAT
UNITS
BUSHELS
TONS
AC
BUSHELS
BUSHELS
LBS N/UNIT
1.25
50
50
4
2.4
Page 3

TOTALS FROM TABLES 1 AND 2
ACRES LBS AW
N USED
TABLE 1 52.261 12,365
TOTALS: 52.26 12,365
AMOUNT OF N PRODUCED: 9,200
BALANCE -3,165
*** This number must be less than or equal to 0 in order to fully utilize the animal waste N
produced.
Acres show in each of the preceeding tables are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter
areas not receiving full application rates due to equipment limitations. Actual total acres in the
fields listed may, and most likely will be, more than the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of
sludge at agronomic rates. The sludge will be nurturient rich and will require precautionary
measures to prevent over application of nutrients or other elements. Your production facility
will produce approximately 1480 pounds of plant available nitrogen (PAN) per year in the
sludge that will need to be removed on a periodic basis. This figure is PAN when
broadcasting the sludge. Please be aware that additional acres of land, as well special
equipment, may be needed when you remove this sludge.
See the attached map showing the fields to be used for the utilization of waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of
irrigation such that runoff or ponding occurs. This rate is limited by initial soil moisture
content, soil structure, soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of the
crop.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 5.92 months. In no instance should the volume of
waste being stored in your structure be within 1.7 feet of the top of the dike.
If surface irrigation is the method of land application for this plan, it is the responsiblity of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application rates and amounts.
APPLICATION APPLICATION
TRACT FIELD SOIL TYPE CROP RATE (in/hr) AMT (inches)
561 *lo, *1 i KALMIA 0-2% W 0.50 *1
561 *Jo, *1 1 KALMIA 0-2% SB 0.50 *1
561 *lo, *1 1 KALMIA 0-2% C 0.50 *1
619 -1, -4, -5 NORFOLK 2-6% SG 0.50 *1
619 1, 4, 5 NORFOLK 2-6% BP 0.50 *1
619 -7 NORFOLK 0-2% SG 0.50 *1
619 7 NORFOLK 0-2% BP 0.50 *1
619 *9 KALMIA O-2% W 0.50 *1
619 -6 KALMIA 0-2% SG 0.50 *1
619 *9 KALMIA 0-2% SB 0.50 *1
619 *9 KALMIA 0-2% C 0.50 *1
619 6, 8 KALMIA 0-2% BP 0.50 *1
619
-2, -3
COWARTS 1-5%
SG
0.00
*1
619
1, 2, 3, 4, 5, 8 COWARTS 1-5%
BP
0.00
*1
Page 4

* This is the maximum application amount allowed for the soil assuming the amount of
nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Page 5

NARRATIVE OF OPERATION
Page 6

PLANS & SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division of Water Quality for every
day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land to properly dispose of waste. If the producer
does not own adequate land to properly dispose of waste, he shall provide NRCS with a copy
of a written agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climate conditions, and level of
management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS) or
an Alternative Conservation System (ACS). If an ACS is used the soil loss shall be no greater
than 10 tons per acre per year and appropriate filter strips will be used where runoff leaves
the field. These filter strips will be in addition to "Buffers" required by DEM. (See FOTG
Stantard 393 - Filter Strips and Standard 390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland, the
waste may be broadcast provided the application does not occur during a season prone to
flooding. (See "Weather and Climate in North Carolina" in the NRCS Technical Reference -
Environment file for guidance.)
*7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order to control conditions conducive
to odor or flies and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of a crop on bare soil.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
the outer perimeter of the land area onto which waste is applied from a lagoon that is a
Page 7

component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other that an irrigation ditch or canal. Animal waste
other than swine waste from facilities sited on or after October 1, 1995), shall not be applied
closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal Waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landownwer.
14. Waste shall be applied in a manner not to reach other property and public right - of ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted croplands
provided they have been approved as a land application site by a "technical specialist".
Animal waste should not be applied on grassed waterways that discharge directly into water
courses, except when applied at agronomic rates and the application causes no runoff or drift
from the site.
*16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
*17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon berms
and structures should be inspected regularly for evidence of erosion, leakage or discharge.
*18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the possibility
of an illegal discharge, pollution and erosion.
*19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied as a preemergence with no other applications of
animal waste during the crop season.
*21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume fpr waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soils shall be monitored and alternative crop sites
shall be used when these metals approach excessive levels. pH shall be adjusted for
optimum crop production amd maintained. Soil and waste analysis records shall be kept for
five (5) years. Poultry dry waste application records shall be maintained for three (3) years.
Page 8

Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina Department of
Agriculture regulations.
* Liquid Systems
Page 9

NAME OF FARM: CLAY RIDGE
OWNER / MANAGER AGREEMENT
1 (we) understand and will follow and implement the specifications and the operation and
maintenance precedures estalished in the approved animal waste utilization plan for the farm
named above. I (we) know that any expansion to the existing design capacity of the waste
treatment and/or storage system or construction of new facilities will require a new utilization
plan and a new certification to be submitted to DEM before the new animals are stocked.
I (we) understand that I must own or have acces to equipment, primarily irrigation equipment,
to land apply the animal waste described in this waste utilization plan. This equipment must
be available at the appropriate pumping time such that no discharge occurs from the lagoon
in a 25-year 1-day storm event. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY 0 MIKE _HARDY
SIGNATURE.
DATE:
NAME OF MANAGER (if different from owner):
please print
SIGNATURE: DATE:
NAME OF TECHNICAL SPECIALIST: BRIAN TINGEN
AFFILIATION: PRIVATE TECHNICAL SPECIALIST
ADDRESS (AGENCY): 404 PEAKBRANCH RD
SNOW HILL, NC 28580
(25 05
SIGNATURE:
DATE:
Page 10

f
• 4
_44
•
a
"

WETTABLE ACRES DETERMINATION
MIKE HARDY
CLAY RIDGE
FIELD WIDTH LENGTH START END ACRES .
1. 270 842 .61 5.82
2. 240 483 .825 3.48
3. 270 250 .825 2.37
4. 240 380 .825 2.9
5. 240 598 .825 4.12
6. 180 625 .6 3.18
7. 270 434 .61 3.3
8. 270 1000 .61 6.8
9, 0220 woo ,37
10 . (20o loco
loco so cv.,N
?SO
2-14-2001

iF
(
•sg.:04.§
1
34,
4
;%'..•A•

Swine Farm Waste Management Odor Control Checklist
Source Cause
HMI's to Minimize Odor Site Specific Practices
Storage tank or • Partial microbial
basin surface decomposition
• Mixing while filling
• Agitation when emptying
O Bottom or midlevel loading
O Tank covers
.0 basin surface mats of solids
C1 Proven biological additives or oxidants
Settling basin • Partial microbial
surface decomposition
• Mixing while filling
• Agitation when emptying
O lxtend drainpipe outlets underneath liquid level
O Remove settled solids regularly
Manure, slurry, or
sludge spreader
outlets
• Agitation when spreading
• Volatile gas emissions
fJ Soil injection of slurry/sludges
O Wash residual manure from spreader after use
ID Proven biological additives or oxidants
Uncovered manure, • Volatile gas emissions while CI Soil injection of slurry/sludges
slurry, or sludge on drying O Soil incorporation within 4X hours
field surfaces
O Spread in thin unifonu layers for rapid drying
O Proven biological additives or oxidants
Dead animals • Carcass decomposition CI Proper disposi(ion ol'carcasses
Dead animal
disposal pits
• Carcass decomposition
O Complete covering of carcasses in burial pits
CI Proper location/construction of disposal pits
Incinerators
• Incomplete combustion O Secondary stack burners
Standing water
around facilities
• Improper drainage
• Microbial decomposition of
organic matter
f-1 Grade and landscape such that water drains away
from facilities

Source
Flush alleys
Swine Farm Waste Management Odor Control Checklist
Cause
IBMPs to Minimize Odor
• Agitation during wastewater El Underfloor flush with underfloor ventilation
conveyance
Pit recharge points • Agitation of recycled lagoon O Extend recharge lines to near bottom of pits with
liquid while pits are tilling anti -siphon vents
Lift stations
• Agitation during sump tank O Sump tank covers
filling and drawdown
Outside drain • Agitation during wastewater El I3ox covers
collection or conveyance
junction boxes
L?nd of drainpipes • Agitation during wastewater
at lagoon
Lagoon surfaces
conveyance
• Volatile gas emissions
• Biological mixing
• Agitation
Site Specific Practices
Irrigation sprinkler • I ligh pressure agitation
nozzles
• Wind drift
O Extend discharge point of pipes underneath
lagoon liquid level
gProper lagoon liquid capacity
C1 Correct lagoon startup procedures
C7 Minimuur surface area -to -volume ratio
O Minimum agitation when pumping
CI Mechanical aeration
D Proven biological additives
Irrigate on dry days wiili little or no wind
f� Minimum recommended operating pressure
El Pump intake near lagoon liquid surface
El Pump from second -stage lagoon

Swine Farm Waste Management Odor Control Checklist
Source Cause
13MI's to Minimize Odor Site Specific Practices
Farmstead • Swine production GI Vegetative or wooded buffers
Q Recommended best management practices
f Good judgment and common sense
Animal body
surfaces
• Dirty manure -covered O Dry floors
animals
Floor surfaces
• Wet manure -covered floors Slotted floors
f7 Waterers located over slotted floors
El Feeders at high end of solid floors
O Scrape manure buildup from floors
El Underfloor ventilation for drying
Manure collection • Urine
pits • Partial microbial
decomposition
Ci Frequent manure removal by flush, pit recharge,
or scrape
O Underfloor ventilation
Ventilation exhaust
fans
• Volatile gases
• Dust
O Fan maintenance
Fflicient air movement
Indoor surfaces • Dust
Washdown between groups of animals
O Feed additives
O Feeder covers
O Feed delivery downspout extenders to feeder
covers
Flush tanks
• Agitation of recycled lagoon CI Flush tank covers
liquid while tanks are filling Q Extend fill lines to near bottom of tanks with
anti -siphon vents

Swine Farm Waste Management Odor Control Checklist
Source Cause BMPs to Minimize Odor
Manure tracked onto • Poorly maintained access Farm access road maintenance
public roads from roads
farm access
Site Specific Practices
Additional Information:
Swine Manure Management; .0200 Rule/UMP Packet
Swine Production Farm Potential Odor Sources and Remedies; E13AE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge Lagoon Treatment; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush—Lagoon,Treatment; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
Controlling Odors from Swine Buildings; PI11-33
Environmental Assurance Program; NPPC Manual
Options for Managing Odor; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedings
Available From:
NCSU, County Extension Center
NCSU BAE
NCSU BAE
NCSU BAE
NCSU—BAE
NCSU—BAE
NCSU—Swine Extension
N.C. Pork Producers Assoc.
NCSU Agricultural Communications
Florida Cooperative Extension

Insect Control Checklist for Animal Operations
Source
Cause
HMI's to Control Insects
Liquid Systems
Site Specific Practices
Flush gutters
• Accumulation of solids
(`J Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed
CI Remove bridging of accumulated solids at
discharge
Lagoons and pits
• Crusted solids
Excessive vegetative • Decaying vegetation
growth
Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the crusting
of solids to a depth ant) more than 6 to 8 inches
over more than 30 percent of surface
Maintain vegetative control along banks of
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter along
water's edge on impoundment's perimeter.
Feeders
Dry Systems
• Feed spillage
O Design, operate, and maintain feed systems
(c.g., hunkers and troughs) to minimize the
accumulation of decaying wastage
O {.'lean up spillage on a routine basis (e.g., 7- to 10-
day interval during summer; 15- to 30-day interval
during winter)

Insect Control Checklist for Animal Operations
Source Cause 111'IPs to Control Insects Site Specific Practices
Feed storage • Accumulations of feed
residues
0 Reduce moisture accumulation within and around
immediate perimeter of feed storage areas by
ensuring drainage is away liom site and/or
providing adequate containment (e.g., covered bin
for brewer's grain and similar high moisture grain
products)
Cl Inspect for and remove or break up accumulated
solids in filter strips around Teed storage as needed
Animal holding • Accumulations of animal O Eliminate low areas that trap moisture along fences
areas wastes and feed wastage and other locations where waste accumulates and
disturbance by an►mals ►s minimal
D lvlaintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e., inspect for and remove or break up
accumulated solids as needed)
Dry manure
handling systems
• Accumulations of animal
wastes
Remove spillage on a routine basis (e.g.,
7- to 10-day interval during summer; 15- to 30-day
interval during winter) where manure is loaded for
land application or disposal
El Provide for adequate drainage around manure
stockp►les
El Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and manure
handling areas as needed
For more information contact:
Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University, Raleigh, NC 27695-7613.