310451_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non-Discharge General Permit
On September 30, 2019, the North Carolina State Non-Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non-Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3,2019.
Please do not leave any question unanswered Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 31-0451 Certificate Of Coverage Number: AWS310451
2. Facility Name: Otis Brown Farm
3. Landowners Name(same as on the Waste Management Plan): Otis G Brown
4. Landowner's Mailing Address: 976 Brown Town Rd
City: Magnolia State: NC Zip: 28453-8628
Telephone Number: 910-290-1337 Ext. E-mail:
5. Facility's Physical Address: /976 Brown Town Rd
City: -G,,ie �A j{V V /l A State: NC Zip: 28435
6. County where Facility is located: Duplin
7. Farm Manager's Name(if different from Landowner):
g, Farm Manager's telephone number(include area code):
9. Integrator's Name(if there is not an Integrator,write"None"): Murphy-Brown LLC
10. Operator Name(OIC): Otis G.Brown Phone No.: 910-290-1337 OIC#: 18021
11. Lessee's Name(if there is not a Lessee,write"None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Swine-Feeder to Finish 1,470
Operation Types;
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses-Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses-Other
Farrow to Finish Milk Cow Pullets Sheep-Sheep
Feeder to Finish Dry Cow Turkeys Sheep-Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Estimated Liner Type Estimated Design Freeboard
Structure Date (Clay,Synthetic, Capacity Surface Area "Redline"
Name Built Unknown) (Cubic Feet) (Square Feet) (Inches)
#I /999 �'Li47 Zd7 QdcYd 19.50
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.1OC(d)to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan(WUP),§igned by the owner and a certified technical specialist containing:
a. The method by which waste is applied to the disposal fields(e.g.irrigation,injection,etc.)
b. A map of every field used for land application(for example:irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation(RYE)for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted-Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g.composting,digesters,waste transfers,etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included,this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.613, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation,signature should be by a principal executive officer of the corporation):
Name: /' Title:
Signature: cz Date: J ~ 7
Name: Title:
Signature: _ Date:
Name: Title:
Signature: _ Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699-1636
Telephone number:[phone]
E-mail:[e-mail]
FORM: RENEWAL-STATE GENERAL 02/2019

ROY COOPER
Governor
MICHAEL S.REGAN Secretary •_,'~ Qh 0 4019
' «°`^
LINDA CULPEPPER NORTH CAROLINA
Dirncror Envlranmental Quality
Rf9gl0lk �,rr.:e+wrw..�
February 27,2019
Otis G Brown
Otis Brown Farm
976 Brown Town Rd
Magnolia,NC 28453-8628
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non-Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non-Discharge General Permits are available
at httpsildeq.nc.goylabout/divisions/water-resources/water-t)uali[r-revional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699-1636
Telephone number:[phone]
In order to assure your continued cover a under the State Non-Discharge Permits- you must submit an Application for
permit coverage to the Division. Enclosed you will find a "Request for Certificate of Coverage Facility Currently Covered by an
Eypirinp State Non-Discharge General Permit." The application form must be completed. sig;iied and returned b4 April 3. 2019.
Please note that you must include one 111 copv of the Certified Animal Waste Management Plan fCAWMPI with the
completed and signed application form. A list of items included in the CAWMP can be found on pie 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to$25,000 per day.
If you have any questions about the State Non-Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Sincerely,
Jon Risgaard,Section Chief
Animal Feeding Operations and Groundwater Section
Enclosures
cc(w/o enclosures): Wilmington Regional Office,Water Quality Regional Operations Section
Duplin County Soil and Water Conservation District
AFOG Section Central Files-AWS310451
Murvhv-Brown LLC
North Carolina Department of r: A mental Quality I DbAsion of Water Resources
t $52 M,Sa +,ry St. f63K Ns :t,,rw)o Center l Rade,o,North Carolina 27699-i63B

Nutrient IVanagement Plan For A .
n1mal Waste Utilization
04-25-2002
This plan has been Pz•epa red for:
This plan has been developed by;
Otis Br011-77
Otis Grey Brotwl, Bill TI;0177as
)76Broti n Tott,rr Rcl Duplin Soil& I 'ccter
Rose Hill, hrC 28435 PO Box 277
910-289 4734 Kei76177sville, NC 28349
[phone]
Developer SignatureType of Plan: Nitrogen. Only with Manure Only
0Ivner/A,'Ianaaer/Producer Agreem V
I (we) understand and agree to the specifications
Procedures established in this nutrient Management«taste utilization plan for the farm named ` t the operation and maintenanc
Required Specifications co e fal-1n g ment plan «Thich includes an above. I have read and understand the al
w th this plan, g animal waste management that are included
Signature(owner) "7" 6
Date
Signature(manager or producer)
This plan meets the miniznurn standards and spec Date
Agriculture - Natural Resources Conservation s cnficatTons of the U.S. Department
adopted by the Soil and Water CConseO'sIrvati ti Coien,-lce or the standard of ract ces of
nmtssion. p ices
Plan approved By:
Teclmicai Spe ialist Signature
Date
861029
Database Version 2.0 ---- - --
Date Printed: 01-2 5-2002 CON,er Page ]

Nutrients applied in accordance with this plan will be supplied from the
following source(s):
Commercial Fertilizer is not included in this plan.
S7 Swine Feeder-Finish Lagoon Liquid waste generated 1,362,690 gals/year by
a 1,470 animal Swine Finishing Lagoon Liquid operation. This production
fac-ility has waste storagre capacities of approximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast 3140
Incorporated 5 393
Injected 5940
Irrigated 3414
Actual PAN Actual Volume.applied Volume Surplus/Deficit
Applied (Pounds) (Gallons) (Gallons)
Year 1 4,918 1,963,296 -600,606
Year 2 6,311 2,519,302 -1,156,612
Note: In source ID. S means standard source, U means user defined source.
961029 Database Version 2.0 Date Printed: 04-25-2002 Source Page 1 of 1

The Waste Utilization table shown beloNv summarizes the Waste utilization plan for this operation. This plan provides an estimate of the
number of acres of cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to
be grown,their nutrient requirements, and proper timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being gro«'il and an estimate of the nitrogen amount being
supplied by manure or other by-products, commercial fertilizer and residual from previous crops. An esti.tnate of the quantity of solid and
liquid vvaste that will be applied on each field in order to supply the indicated quantity of nitrogen from each source is also included. A
balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides for the
utilization of the manure generated by the operation.
Depending on the requirements of the crop and the nutrient content of the waste, some nutrients will likely be over or under applied if animal
waste is being utilized. Waste should be analyzed before each application cycle and annual soil tests are required if animal waste is being
applied. Soil tests should be used to balance the nutrient application amounts with the realistic yields of the crop to be grown. Nutrient
management plans may require that the application of animal waste be limited so as to prevent over application of phosphorous when
excessive levels of this nutrient Lire detected in a field.
W I Ttifizition Table yva .
Nitrogen Comm Res. Manure I Liquid Solid Liquid Solid
PA Fert. (lbs/A) PA I Manure Manure Manure Manure
Nutrient Nutrient Nutrient Applied Applied Applied Applied
Req'd Applied Applied (acre) (acre) (Field) (Field)
Source 'total Use. RYE Applic. Applic. 1000
Tract I Field LD, Soil Set ics Acre Acres Cron RYE Unit Period N N N Method Ibs/A eal/A tons 1000 Vals tons
4289 PI S7 Rains 4.9 4.9 Corn,Grain *127.0 Bushels 2/15-6/30 *137 0 *I5 Irrig. 122 49.70 0 241.08 0,00
4289 PI S7 Rains 49 4.9 Wheat,Grain *56.9 Bushels 9/1-4/30 *44 0 0 Irrig. 44 17.56 0 86.95 0.00
4289 P2 S7 Rains 3.6 3.6 Corn,Grain *127.0 Bushels 2/15-6/30 *137 0 *15 Irrig. 122 48.70 0 176.79
4289 1'2 S7 Rains 3.6 3.6 Wheat,Grain *56.9 Bushels 9/1-4/30 *44 11 0 Irrig- 44 17.56 0 63,76 0.00
4289 P3 S7 Rains 3.4 3.4 Corn.Grain *127A Bushels 2/15-6/30 *137 0 *I5 Irrig. 122 48.70 0 164.62 0-00
4289 P3 S7 Rains 3 4 3.4 Wheat,Grain *56.9 Bushels 9/1-4/30 *44 0 0 Irrig. 44 17.56 0 59.37 0.00
4289 P4 S7 Rains l,1 1.1 Corn;Grain *127.0 Bushels 2/I5-6/30 *137 0 *I5 Irrig. 122 48.70 0 55.03 0.00
4289 P4 S7 Rains I.l 1.1 Wheat,Grain *56.9 Bushels 9/1-4/30 *44 0 0 Inie. 44 17 56 0 19.85 0.00
4289 P5 S7 Noboeo 2S 2.5 Corn,Grain *120.0 Bushels 2/I S-6130 *I:>7 0 *I5 Irrig. M 48.70 0 1 19.32 0-00
861029 Database Version 2.0 Date Printed: 4/25/02 WUT Page 1

Waste Utilization Ta e
Nitrogen Comm. Res. Manure Liquid Solid Liquid Solid
PA Fert. (Ibs/A) PA Manure Manure Manure Manure
NLI[fiCnl Nutrient Nutrient Apjilicd Applied Applied Applied
Req'd Applied Applied (acre) (acre) (Field) (Field)
Source Total Use. RYE Applic. Applic. 1000
'rract Field I.D. Soil Series Acre Acres Crol RYF Unit Period N N N Method Ibs/A aal/A tons 1000 gals tons
4289 P5 S7 Noboco 2 5 2.5 Wheat,Grain 60.0 Bushels 9/1-4/30 50 0 0 Irri_. 50 1996, 0 48.90 0 UO
4289 116 S7 Noboco 6-2 62 Corn,Grain *1200 Bushels 2!15-0/30 *137 0 *15 Irrig. 122 48.70 0 301A7 0.00
4289 P6 S7 Noboco 62 6.2 Wheat,Grain 60.0 Bushels 9/1-4/30 50 U 0 Irrig. 50 19.96 0 123,J5 r?^�
42891 117 S7 Noboco L6 16 Corn,Grain *120.D Bushels 2/15-6/30 *137 0 *15 Irrig. 122 48 70 0 76.95
4289 P7 S7 I Noboco 1.6 L6 Wheat,Gram 60.0 Bushels 9/1-4/30 50 0 0 Irrig. 50 19.96 0 31.54 0.00
4289 P8 S7 Noboco 5 7 5.7 Corn,Grain *120-0 Bushels 2/15-6/30 *137 0 *15 Irri— 122 48.70 0 279.55 0.00
4289 P8 S7 Noboco 5.7 5.7 Wheat,Grain 60.0 Bushels 9/1-4/30 50 0 0 Irrig. 50 1996 0 114.57 OM
3io
T. tili�l,- A
0.00
Balance.Ions 0001
Notes: I In the tract column.symhol-means leased,otherwise,owned. 2.Symbol*means user entered data.
X
m
o•
w O
Q bpi,
Cn o it
v
861029 Database Version 2.0 Date Printed: 4/25/02 WILT Page 2

Waste Utilization Ta>>e I •.
Nitrogen Conlin. Res. Manure Liquid Solid Liquid Solid
PA I-cit. (Ibs/A) PA M•,Irlure Manure Manure Manure
Nutrient Nutrient Nutrient Applied Applied Applied Applied
Req'd Applied Applied (acre) (acre) ([Meld) (Field)
Source .total Use. RYE Applic. Applic. 1000
Tract Field 11). Soil Series Acre Acres Crob RYE• Unit Period N N N I Method Ibs/A gal/A ions 1000-,als tons
4289 P] S7 Rains 49 4.9 Wheat,Grain *56.9 Bushels 911-4/30 *66 0 0 Iriig. 66 26.35 0 13042 0,00
4280 Pl S7 Rains 49 4.9'Soybeans,Manured, 37.0 Bushels 4,/1-9/15 143 0 0 Irrig. 143 57.09 (1 28258 0.00
Double Crop
4289 112 S7 Rains 3 b 3.6 Wheat,Grain *56.9 Bushels 911-4130 *66 U U Irrig. 66 26.35 0 95 64
4289 P2 S7 Rains 3 6 3.6 Soybeans,Manured, 37.0 Bushels 4/1-9115 143 0 0 IrriE. 143 57.09 0 20722 0.00
Double Crop y
4289 P'3 S7 Rains 3 4 3.4 Wheat,Grain *56 9 Bushels 9/1-4130 *66 0 0 Irrig. 1 66 2635 0 89.05 0.00
4289 P3 S7 Rains 3.4 34 Soybeans,Manured, 37 0 Bushels 4/1-9/1? 143 0 0 Irrig, 143 57 09 0 192,95 0,00
Double Crop V
4289 P4 S7 Rains 1.1 1.1 Wheat,Grain *56 9 Bushels L 911-4/30 *66 0 U Irrig. 66 26.35 0 29.77 000
4289 P4 S7 Rains 1.1 1.1 soybeans,Manured, 37.0 Bushels 4/1-9/15 143 0 0 Irrie. 143 57.09 0 64.51 0.00
Double Crop
4289 P5 S7 Noboco 2.i 2-5 Wheat.Grain 60.0 Bushels 9/1-4/30 75 0 U irri2 75 29.94 U 7335 000
4289 PS S7 Noboco 2.5 2.5 Soybeans,Manured, 38.0 Bushels 4/1-9/IS 149 0 U Irrig. 149 i948 0 145.73 0.00
Double Crop
4289 P6 S7 Noboco 6.2 6.2 Wheat,Grain 60.0 Bushels 9/1-4/30 75 1 0 0 Irrig. 1 75 29.94 0 185.33 0.00
4289 116 S7 Noboco 6.2 62 Soybeans,Manured, 38.0 Bushels 411-9/15 149 0 0 Irrig 149 59.48 0 363,19 U00
Double Crop -
4289 117 S7 Noboco 1.6 1.6 Wheat.Grain 600 Bushels 9/1-4/30 75 0 0 1rrig. 75 2994 0 47.31 C
4289 P7 S7 NobUCO 1.6 1.6 Soybeans,Manured, 3&0 Bushels 4/1-9/15 149 0 0 Irrie. 149 59.48 0 93.98 0.00
Double Crop
4289 119 S7 Noboco 5.7 5.7 Wheat,Grain 60.0 Bushels 9/1-4/30 75 0 0 Irrig. 75 29.94 0 171.86 0.00
4289 is S7 Noboco 5,7 5.7 Soybeans,Manured, 380 Bushels 4/1-9/15 149 0 0 Inig. 149 59.48 0 341,42 (100
Double Crop
861029 Database Version 2.0 Date Printed: 4/25/02 WUT Page 3

Waste Mill l atlon Tabi Vvo 2
Nitrogen Comm. Res ,Manure Liquid Solid Liquid Solid
PA Fert. (Ibs/A) PA_ Manure Manure Manure Manure
Nuttiest Nutnent Nutrient Applied Applied Applied Applied
Req'd Applied Applied (acre) (acre) (Field) (field)
Source Total Use. RYE Applic- Applic, 1000
Tract Field I D, soil Series Acre Acres Crop RYE Unit Period N N N Method Ibs/A aal/A tons 1000 eats tons
a I .-LID1,7 2 519 30
nt dp o 'r'9
1� n
Balance tuns 7..
Nnics: I.In the tract column,symbol—means leased,othenvlse,owled. 2.Symbol `means user entered data.
861029 Database Version 2.0 Date Printed: 4/25i02 WUT Pane 4

The Irrigation Application Factors for each field in this plan are shown in the following
table. Infiltration rate varies tyith soils. If applying waste nutrients through an irrigation
system, you must apply at a rate that will not result in runoff. This table provides the
maximum application rate per hour that may be applied to each field selected to receive
Nvaste-vvater. It also lists the maximum application amount that each field may receive in
any one application event.
Irrigation Ap lication Factors
Application Rate Application Amount
Tract Field Soil Series (inches/hour) (inches)
4299 PI Rains 0.40 0.96
4289 P2 Rains 0.40 0.96
4299 P3 Rains 0.40 0.96
4289 P4 Rains 0.40 0.96
4289 P5 Noboco 0.50 0.96
4289 P6 Noboco 0.50 0.96
4289 P7 Noboco 0.50 0.96
4289 P8 Noboco 0.50 0.96
861029 Database Version 2.0 Date Printed: 01-25-2002 IAF Page I of 1

The fotlow in17 Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of
acres needed for sludge utilization for the indicated accumulation period. These estimates are
based on a\Tera e nitrogen concentrations for each source; the number of animals in the facility and
the plant available Iutrogen application rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of
the effluent. At clean out, this material must be utilized for crop production and applied at
agronomic rates. In most cases, the priority nutrient is r>_itrogen but other nutrients including
phosphorous, copper and zinc can also be limiting. Since nutrient levels are generally very high,
application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray
fields should not be used for sludge application. If this is not possible, care should be taken not to
load effluent application fields with high amounts of copper and zinc so that additional effluent
cannot be applied. On sites vulnerable to surface water moving to streams and lakes, phosphorous
is a concern. Soils contairling very higli phosphorous levels may also be a concern.
Lagoon Sludge Nitrogen Utilization Table
Ma\lnmill NlaUmnln Sludge
Crop PA-N Rate Application Rate Rlinimuin Acres Mininnun Acres Minimum Acres
lb/ac 1000 cal/ac 5 Years Accumulation 10 Fears Accumulation 15 Years Accunlulatioll
Swine Feeder-Fiirisb Lagoon Sludge - Standard
Com 120 bu 150 13.16 18.43 36.86 55.29
I ,iy 6 ton R.Y.E. 300 26.32 9.21 18.43 27.64
Soybean 40 bu 160 14.04 17.28 34.55 51.83
961029 Database Version 2.0 Date Printed: 04-25-2002 Sludge Page 1 of 1

The Available Waste Storage Capacity table provides an estimate of the number of days of
storage capacity available at the end of each month of the plan. Available storage
capacity is calculated as the design storage capacity in days minus the number of days of
net storage volume accumulated. The start date is a value entered by the user amid is
defined as the date prior to applying nutrients to the first crop in the plan at�,vhich storage
volume in the lag>oon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to
the design storage capacity of the facility. If the available storage capacity is Q;r eater than
the design storage capacity, this indicates that the plan calls for the application of
nutrients that have not yet ace-Lunulated, If available storage capacity is negative, the
estimated volume of accumulated waste exceeds the design storage volume of the
structure. Either of these situations indicates that the planned application interval in the
waste utilization plan is inconsistent with the stricture's temporary storage capacity.
Available Waste. S t ratje Ca oacit ,
Source Name Swine Feeder-Finish LaLmon Lit uid Design Storage Capacity f Day O
Start Mite 109/11 180
Plait'Year 1-�401101 Available Storage Capacity(Days)
1 1 38
1 2 86
1 3 131
1 4 177
1 5 150
1 6 180
1 7 149
1 8 118
t 9 125
1 10 131
1 11 138
1 12 t44
2 1 150
2 2 159
2 3 180
2 4 180
2 5 180
2 G 180
7 180
2 8 180
2 9 180
2 l0 149
11 119
861029 Database Version 2.0 Date Printed: 04-25-2002 Capacity Page 1 of 2

Available 14'as e Storage Ca acit ,
Source Name Swine Feeder-Finisli Lagoon Liquid Desi"n Stol"We Capacity (Dais)
Start Date o)/11 180
Plan Year Month Available Storage Capacity(Days)
12 8S
* Available Storage Capacit-, is calculated as of the end of each month.
861029 Database Version 2.0 Date Printed: 04-25-2002 Capacity Page 2 of 2

Required Specifications For Animal Waste Nianagement
1. Animal waste shall not reach surface waters of the state by runoff,
drift, manmade conve`rances, direct application. or direct discharge
during operation or land application. Any discharge of waste that
reaches surface water is prohibited.
Z. There must be documentation in the design folder that the producer
either owns or has an agreement for use of adequate land on which to
properly apply the waste. If the producer does not own adequate land
to properly dispose of the waste, lie/she shall provide evidence of an
agreement with a landowner, who is within a reasonable proximity,
allowing hini/lier the use of the land for waste application. It is the
responsibility of the owner of the waste production facility to secure
an update of the Nutrient Management Plan when there is a change
in the operation, increase in the number of animals, method of
application, receiving crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen
needs for realistic crop yields based upon soil type, available
moisture, historical data, climatic conditions, and level of
management, unless there are regulations that restrict the rate of
applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per
acre per year. Waste may be applied to land eroding at more than 5
tons per acre per year but less than 10 tons per acre per year provided
grass filter strips are installed where runoff leaves the Meld (see
USDA, MRCS Field Office Technical Guide Standard 393 - Filter
Strips).
s. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drif
from the land application field.
861029 Database Version 2.0 Date Printed: 04-25-2002 Specification Page 1 of 4

6. When animal waste is to be applied on acres subject to flooding,
waste will be soil incorporated on conventionally tilled cropland.
When waste is applied to conservation tilled crops or grassland, the
waste may be broadcast provided the application does not occur
during a season prone to flooding (see "Weather and Climate in
North Carolina" for guidance).
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offshe or to surface
`raters and in a method which does not cause drift front the site
during application. No ponding should occur in order to control odor
and flies.
s. Animal waste shall not be applied to saturated soils, during rainfall
events, or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a
manner that the crop is not covered with waste to a depth that would
inhibit growth. The potential for salt damage from animal waste
should also be considered.
10. Nutrients from waste shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching.
Waste/nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to
planting of the crop or forages breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area onto
which waste is applied from a lagoon that is a component of a swine
farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited
on or after October 1, 1995, shall not be applied closer that 25 feet to
perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal �N,aste shall not be applied closer than 200 feet of dwellings
other than those owned by the landowner.
961029 Database Version 2.0 Date Printed: 04-23-2002 Specification Page 2 of 4

14. Waste shall be applied in a manner not to reach other property and
public right-of-ways.
15. Animal waste shall not be discharged into surface waters.
drainageways, or wetlands by a discharge or by oN-er-spraying.
Animal waste may be applied to prior converted cropland provided
the fields have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on grassed
waterways that discharge directly into water courses, and on other
grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers,
toilets, sinks, etc., shall not be discharged into the animal waste
management system.
17. A protective cover of appropriate vegetation will be established on
all disturbed areas (lagoon embankments, berms, pipe runs, etc.).
Areas shall be fenced_ as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc., are
limited to areas where considered appropriate. Lagoon areas should
be kept mowed and accessible. Berms and structures should be
inspected regularly for evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated,
the owner is responsible for obtaining and implementing a "closure
plan" which will eliminate the possibility of an illegal discharge,
pollution, and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be
inspected on a regular basis to prevent breakdowns, leaks, and spills.
A regular maintenance checklist should be kept on site.
2o. Animal waste can be used in a rotation that includes vegetables and
other crops for direct human consumption. However, if animal
waste is used on crops for direct human consumption, it should only
be applied pre-plant with no further applications of animal waste
during the crop season.
861029 Database Version 2.0 Date Printed: 0 4-2-5-2002 Specification Page 3 of 4

21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid
level between the markers. A. marker will be required to mark the
maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be
tested at least annually at crop sites where waste products are
applied. Nitrogen shall be the rate-determining nutrient, unless other
restrictions require waste to be applied based on other nutrients;
resulting in a lower application rate than a nitrogen based rate. Zinc
and copper levels in the soils shall be monitored and alternative crop
sites shall be used when these metals approach excessive levels. pH
shall be adjusted and maintained for optimum crop production. Soil
and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a
minimum of three years. Waste application records for all other
waste shall be maintained for a minimum of five gears.
23. Dead animals wilI be disposed of in a manner that meets North
Carolina regulations.
861029 Database Version 2A Date Printed. 04-25-2002 speciFicaion Page 4 of 4

Crop Notes
The following crop note applies to field(s): P 1, P2, P1 P4
Corsi 1 CP, Mineral Soil; low-leachable
l.n the Coastal Plain, corn is normally planted when soil temperatures reach 52 to » degrees fahrerilleit.
Review the Official Variety "green book" and information from private companies to select a high yielding
variety with the characteristics needed for your area and conditions. Plant 1-2" deep. Plant populations
should be determined by the hybrid being planted. Increase the seeding rate by 10°4,when planting no-till.
Phosphorus and potassium recommended by a soil test can be broadcast or banded at planting. Wien
planting early in cool, wet soil, banded phosphorus will be more available to the young plants. Ail accepted
practice is to apple 20-30 lbs/acre N and 20-30 lbsi'acre phosphorus banded as a starter and one-half die
rcmaining N behind the planter. The rest of the N should be applied about 30-40 days after emergence. The
total amount of N is dependent on soil type. Nt11en including a starter in the fertilizer program, the
reconunended potassium and any additional phosphorus is normally broadcast at planting. Plant samples
can be anah zed during the groNving season to monitor the overall nutrient status of the corn. Timely
management of weeds and insects are essential for corn production.
The following crop note applies to field(s): P5, Ph, P7, P8
Coral: CP_ 1\-l1ineral Soil, medium leaching
In the Coastal Plain. corn is normally planted when soil temperatures reach 52 to » degrees fahrerlleit.
Review the Official Variety "green book" and information from private companies to select a high yielding
variety with the characteristics needed for your area and conditions. Plant 1-2" deep. Plant populations
should be determined by the hybrid being planted. Increase the seeding rate by 10"() when planting no-till.
Phosphors and potassium recommended by a soil test can be broadcast or banded at planting. When
planting early in cool, wet soil, banded phosphors will be more available to the young plants. An accepted
practice is to apply 20-30 lbs/acre N and 20-30 lbs/acre phosphors banded as a starter and one-half the
remaining N behind the planter. The rest of the N should be applied about 30-40 days after emergence. The
total amount of N is dependent on soil type, NVhen including a starter in the fertilizer program, the
reconllnellded potassium and any additional phosphorts is normally broadcast at planting. Plarit samples
can be analyzed during the growing season to monitor the overall nutrient status of the corn. Timely
mauiagement of weeds and insects are essential for corn production.
861029 Database Version 2.0 Date Printed: 04-25-2002 Crop Note Page 1 of 3

The following crop note applies to field(s): P1, P2, P3, P4
`A,Beat: Coastal Plain, Mineral Soil; low-leachable
Ln the Coastal Plain, wheat should be planted from October 20-November 25. Plant 22 seed/drill row foot
at 1-1 11/2" deep and increase the seeding rate by ?°;for each week seeding is delayed beyond the optimtum
time. See the seeding rates table for applicable seeding rate modifications in the current NCSU "Small
Grain Production Guide". Also, increase:the initial seedinv rate-' by at least 10"n when planting no-till.
.adequate depth control when planting the wheat is essential. Review the NCSU Official Variety ",nen
book" and information from private companies to select a high yielding variety N,�ith the characteristics
needed for your area and conditions. apply no more than 30 lbs/acre NT at planting. Phosphonis and potash
recommended by a soil test can also be applied at this time. The remaining N should be applied during the
months of Febnian-Marcb. The total N is dependent on the soil type. Plant samples can be analyzed
during the growing season to monitor the nutrient status of the wheat. Tiimely management of diseasesr
insects and weeds are essential for profitable wheat.production.
The following crop note applies to field(s): P5, P6. P7, PS
1k'heat: Coastal Plain; Mineral Soil. medium leachable
In the Coastal Plain.; wheat should be planted from October 20-November 25. Plant 22 seedidrill ropy foot
at 1-1 1/2" deep and increase Cie seeding rate by 5% for each week seeding is delayed beyond the optimum
time. See the seeding rates table for applicable seeding rate modifications in the current NCSU "Small
Grain Production Guide". Also, increase the initial seeding rate by at least 10") when planting no-till.
Adequate depth control when planting the wheat is essential. Review the NCSU Official Variety "green
book" and information from private companies to select a high yielding Variety iyith the characteristics
needed for your area and conditions. apply no more than 30 lbs/acre:N at planting. Phosphorus and potash
recommended by a soil test report can also be applied at this time. The remaining N should be applied
during the months of Febn.inn-March. The total N is dependent on the soil type. Plant samples can be
analyzed during the growing season to monitor the nutrient status of tht wheat. Timely management of
diseases, insects and .weeds are essential for profitable\yheat production.
The folloNving crop note applies to field(s): P 1, P2, P37 P4
Double-Crop Soybeans, Coastal Plain: Mineral Soil, low-leachable
Double-crop soybeans should be planted as early in June as possible with planting completed by July 4th.
When no-tilling soybeans in small grain straw, it is essential to manage the straw to achieve adequate plant
Populations. Review the NCSU Official Variety "green book" and information from private companies to
select a high yielding variety with the characteristics needed For your area and conditions. Plant 2-4
seed,/row foot for 7-8" drills: 4-6 seed./row foot for 15" rows; 6-8 seecProw foot for 30" rows and 5-10
seed/row toot for 36'' roNvs. Increase the seeding rate by at least I M40 for no-till planting. Seeding depth
Should be 1-1 1 2" and adequate depth control is essential. Phosphonis and potash reconunended for the
soybeans can be applied to the wheat in the Fall. Soybeans produce their own nitrogen and are normally
Uro�vn without additions of nitrogen. Ho«ever, applications of 20-30 Ibs/acre N are sometimes made at
planting to promote early grovah and vigor. Tissue samples can be analyzed during the grow'
ing season to
monitor the overall nutrient status of the soybeans. Timely management of vtcds and insects is essential
for profitable double crop soybean production.
861029 Database Version 2.0 Date Printed: 04-25-2002) Crop Note Page 2 of 3

The Collowing crop note applies to field(s). P-5, Ph, 1?7, P8
Double-Crop Soybeans. Coastal Plain: Mineral soil. llied111111 leachable
Double-crop soybeans should be planted as early n1 June as possible with planting Completed by July 4th.
\-Vlien no-tilling soybeans in sinall gratll straw, it is essential to manage the straw to achieve adequate plant
populations. Review the NCSU Official Variety"green book" and information from private companies to
select a high yielding varlety with the characteristics needed for your area and conditions. Plant 2-4
seed/row foot for 7-8" drills, =4-6 seed/row foot for 15" rows, 6-8 seed!row foot for 30" rows and 8-10
seed/roor foot for 36" rows, Increase the seeding rate by at least 10%for no-till planting. Seeding depth
should be 1-1 1/2" and adequate depth control is essential. Phosphorus and potash reconmiended for the
soybeans can be applied to the wheat in the Fall. Soybeans produce their own nitrogen and are normally
groiwn without additions of nitrogen. However, applications of 20-30 lbs/acre N are sometimes made at
planting to promote early growth and igor. Tissue samples can he analyzed during the growing season to
monitor the overall nutrient status of the soybeans. Timely nlanaLenictit of weeds and insects is essential
for profitable double Crop Soybean production.
861029 Database Version 2.0 Date Printed 04-25-2002 Crop Note Page 3 of 3

tis Brown
T-4289
,Faclity# 3 ' 4- 5t
Brown Town RD � _ •.
WFT 5.47ac
129FT
04
A
r

NUTRIENT UTILIZATION PLAN AMENDMENT
Grower(s): Otis Brown
Farm Name: Otis Brown Farm Facility 31-451
County: Duplin
Farm Ca acity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 1,470
Storage Structure: Anaerobic Lagoon
Storage Period: >180 days
Application Method: Irrigation
Grower may plant an unharvested cover crop on any of the land in the following table and apply up to 30 Ibs N/acre.
Any PAN applied to the small grain cover crop must be deduted from the following crop.
- Owner/Manager Date
a©lam
Technical Spe6iAt Date

Reception Area Specifications
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs N/Ac Lbs N Total Ibs N 2nd Crop Time to 2nd Crop 2nd Crop Lbs N/Ac Lbs N Total We N Total Total Ibs N
Acreage Type Code Apply Yield Ibs N1Unit Residual /Ac Utilized Code Apply Yield Ibs N/Unit Residual /Ac Utilized Lbs N/Ac Utilized
T4289 p1 4.9 Rains CC Se:t-A.iril 1.0 30 30 147 0 0 30 147
T4290 P2 3.6 Rains CC Sept-April 1.0 30 30 1D6 0 0 30 108
T4291 P3 3.4 Rains CC Se-t-A it 1.0 30 30 102 0 0 30 102
T4292 P4 1.1 Rains CC Se t-April 1.6 30 30 33 0 0 30 33
T4293 P5 2.5 Noboco CC Sept-April 1.0 30 30 75 0 0 30 75
T4294 P6 6.2 Noboco CC Sept-April 1.0 30 30 186 0 0 30 186
T4295 P7 1.6 Noboco CC 5e rt-A ril 1.0 30 30 48 0 0 30 48
T4296 P8 5.7 Noboco CC Se t-A ril 1.0 30 30 771 0 0 30 48
J
71
0 0
0 0
0 0
0 0
0 0
fi
0 0
* 0 0
0 0
* 0 0
* D 0
0 0
* 0 0
* 0 0
` 0 0
* 0 0
* 0 D
* 0 0
* D 0
D 0
0 0
* 0 0
* D 0
0 0
* 0 0
* 0 0
* D 0
D 0
0 0
0 0
* 0 0
* 0 0
0 0
* 0 0
* D 0
* o D
* 0 0
* o 0
* o 1 0
Totals: 29 870 0 870

Operator:Otis Brown County: Duplin Date: 03/28/94
Distance to nearest residence (other than owner) : 1500. 0 feet
1. AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish) x 1417 lbs. = 0 lbs
0 sows (farrow to feeder) x 522 lbs. = 0 lbs
1470 head (finishing only) x 135 lbs. = 198450 lbs
0 sows (farrow to wean) x 433 lbs. = 0 lbs
0 head (wean to feeder) x 30 lbs. = 0 lbs
Describe other 0
Total Average Live Weight = 198450 lbs
2 . MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 198450 lbs. ALW x Treatment Volume(CF) /lb. ALW
Treatment Volume(CF) /lb. ALW = 1 CF/lb. ALW
Volume = 198450 cubic feet
3 . STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0. 0 cubic feet 'Valpal/�/�2 -Z�
4. TOTAL DESIGNED VOLUME
Inside top length (feet) --------------------- 250. 0
Inside top width (feet) ----------------------
200. 0
Top of dike elevation (feet) ----------------- 50. 0
Bottom of lagoon elevation (feet) ------------ 40. 0
Freeboard (feet) ----------------------------- 1. 0
Side slopes (inside lagoon) ------------------ 3 . 0 1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3 . 0 3 .0 3 . 0 3 .0 244 . 0 194 . 0 9. 0
AREA OF TOP
LENGTH * WIDTH =
244. 0 194 . 0 47336 (AREA OF TOP)
AREA OF BOTTOM
LENGTH * WIDTH =
190. 0 140. 0 26600 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
217 . 0 167. 0 - 144956 (AREA OF MIDSECTION * 4)
CU. FT. _ [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/,
47336. 0 144956. 0 26600. 0 1

Total Designed Volume Ava—able = 328338 CU. F'
5. TEMPORARy STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
250. 0 200. 0 50000. 0 square feet
Buildings (roof and lot water)
0. 0 square feet Describe this area.
TOTAL DA 50000. 0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Feces & urine production in gal. /day per 135 lb. ALW 1.37
Volume= 198450 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 362502 gals. or 48462 .8 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculai
the lagoon water are accounted for in 5A.
Volume = 0. 0 gallons/day * 180 days storage/7.48 gallon:
Volume = 0. 0 cubic feet per CF
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount
180 days excess rainfall = 7. 0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 29166. 7 cubic feet

5D. Volume of 25 year - 24 hour storm
Volume = 7. 5 inches / 12 inches per foot * DA
Volume = 31250. 0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 48463 cubic feet
5B. 0 cubic feet
5C. 29167 cubic feet
5D. 31250 cubic feet
TOTAL 108880 cubic feet
6 . SUMMARY
Temporary storage period____________________> 180 days
Rainfall in excess of evaporation=====______> 7. 0 inches
25 year - 24 hour rainfall__________________> 7 . 5 inches
Freeboard___________________________________> 1. 0 feet
Side slopes=________________________________> 3 . 0 • 1
Inside top length___________________________> 250. 0 feet
Inside top width____________________________> 200. 0 feet
Top of dike elevation_______________--------> 50. 0 feet
Bottom of lagoon elevation__________________> 40. 0 feet
Total required volume=====__________________> 307330 cu. ft.
Actual design volume________________________> 328338 cu. ft.
Seasonal high watertable elevation (SHWT)===> 46. 0 feet
Stop pumping elev.__________________________> 46. 1 feet
Must be > or = to the SHWT elev.====______> 46. 0 feet
Must be > or = to min. req. treatment el.=> 46. 0 feet
Required minimum treatment volume=====______> 198450 cu. ft.
Volume at stop pumping elevation=====_______> 201822 cu. ft.
Start pumping elev._________________________> 48. 3 feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall==> 297088 cu. ft.
Volume at start pumping elevation=====______> 295843 cu. ft.
Required volume to be pumped________________> 7763o cu. ft.
Actual volume planned to be pumped=====_____> 94021 cu. ft.

Min. thickness of .1 liner when required==> 1. 5 feet
7. DESIGNED BY: APPROVED tEAgje
V� elL� ! nyOb '
DATE: DATE: a��0� L ;,•e•-° •.j4ya `go
• it r�a
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN -
COMMENTS: °
i• J base. �\ �c / /

SHEET 1 OF 2
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
-------------------------------------------------
FOUNDATION PREPARATION:
-----------------------
The foundation area of the lagoon embankment and building pad shall be
cleared of trees, logs, stumps, roots, brush, boulders, sod and rubbish.
Satisfactory disposition will be made of all debris. The topsoil from
the lagoon and pad area should be stripped and stockpiled for use on
the dike and pad areas. After stripping, the foundation area of the
lagoon embankment and building pad shall be thoroughly loosened prior
to placing the first lift of fill material to get a good bond.
EXCAVATION AND EARTHFILL PLACEMENT:
------------------ -----------------
The completed excavation and earthfill shall conform to the lines,
grades, and elevations shown on the plans. Earthfill material shall
be free of material such as sod, roots, frozen soil, stones over
6 inches in diameter, and other objectionable material. To the extent
they are suitable, excavated materials can be used as fill. The fill
shall be brought up in approximately horizontal layers not to exceed 9
inches in thickness when loose and prior to compaction. Each layer
will be compacted by complete coverage with the hauling and spreading
equipment or standard tamping roller or other equivalent method.
Compaction will be considered adequate when fill material is observed
to consolidate to the point that settlement is not readily detectible.
NOTE THE SPECIAL REQUIREMENTS FOR PLACEMENT OF LINERS IN THE LINER
SECTION OF THIS SPECIFICATION. The embankment of the lagoon shall be
installed using the more impervious materials from the required
excavations. Construction of fill heights shall include 5 percent for
settlement. Dikes over 15 feet in height and with an impoundment
capacity of 10 acre-feet or more fall under the jurisdiction of the NC
Dam Safety Law. The height is defined as the difference in elevation
from the constructed height to the downstream toe of the dike.
Precautions shall be taken during construction to prevent excessive
erosion and sedimentation.
LINER: THE MINIMUM REQUIRED THICKNESS SHALL BE 1.5 ft.
-------------------------------------------------
NOTE: LINERS (PARTIAL OR FULL) ARE REQUIRED WHEN THE ATTACHED SOILS
INVESTIGATION REPORT SO INDICATES OR WHEN UNSUITABLE MATERIAL IS

ENCOUNTERED DURING CON: :UCTION. A TYPICAL CROSS 5. .TION OF THE LINER
IS INCLUDED IN THE DESIGN WHEN LINERS ARE REQUIRED BY THE SOILS REPORT.
When areas of unsuitable material are encountered, they will be over-
excavated below finish grade to the specified depth as measured
perpendicular to the finish grade. The foundation shall be backfilled
as specified to grade with a SCS approved material (ie - Ct,SC,CH) .
REFER TO THE SOILS INVESTIGATION INFORMATION IN THE PLANS FOR SPECIAL
CONSIDERATIONS.
SHEET 2 OF 2
Soil liner material shall come from an approved borrow area. The
minimum water content of the liner material shall be optimum moisture
content which relates to that moisture content when the soil is kneaded
in the hand it will form a ball which does not readily separate. Water
shall be added to borrow as necessary to insure proper moisture content
during placement of the liner. The moisture content of the liner
material shall not be less than optimum water content during placement.
The maximum water content relates to the soil material being too wet
for efficient use of hauling equipment and proper compaction. Proper
compaction of the liner includes placement in 9 inch lifts and .
compacted to at least 90 percent of the maximum ASTM D698 Dry Unit
Weight of the liner material. When smooth or hard, the previous lift
shall be scarified and moistened as needed before placement of the next
lift.
The single most important factor affecting the overall compacted perme-
ability of a clay liner, other than the type of clay used for the
liner, is the efficient construction processing of the compacted liner.
The sequence of equipment use and the routing of equipment in an estab-
lished pattern helps assure uniformity in the whole placement and
compaction process. For most clay soils, a tamping or sheepsfoot
roller is the preferable type of compaction equipment.
The soil liner shall be protected from the discharge of waste outlet
pipes. This can be done by using some type of energy dissipator(rocks)
or using flexible outlets on waste pipes.
Alternatives to soil liners are synthetic liners and bentonite sealant.
When these are specified, additional construction specifications are
included with this Construction Specification.
CUTOFF TRENCH:
--------------
A cutoff trench shall be constructed under the embankment area when
shown on a typical cross section in the plans. The final depth of the
cutoff trench shall be determined by observation of the foundation
materials.

VEGETATION:
All exposed embankment and other bare constructed areas shall be seeded
to the planned type of vegetation as soon as possible after construc-
tion according to the seeding specifications. Topsoil should be placed
on areas of the dike and pad to be seeded. Temporary seeding or mulch
shall be used if the recommended permanent vegetation is out of season
dates for seeding. Permanent vegetation should be established as soon
as possible during the next period of approved seeding dates.
REMOVAL OF EXISTING TILE DRAINS
-------------------------------
When tile drains are encountered, the tile will be removed to a minimum
of 10 feet beyond the outside toe of slope of the dike. The tile
trench shall be backfilled and compacted with good material such as
SC, CL, or CH.

OPERATION AND MAINTENANCE PLAN SHEET 1 OF 2
------------------------------
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. ' Also
included is storage for the 25 year. - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s) . If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre-
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre-charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2 . The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3 . Begin temporary storage pump-out of the lagoon when fluid level
reaches the elevation 48 . 3 as marked by permanent marker. Stop pump-
out when the fluid level reaches elevation 46. 1 . This temporary
storage, less 25 yr- 24 hr storm, contains 77630 cubic feet or
580669 gallons.

SHEET 2 OF 2
4 . The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0. 3
inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
Pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

SEEDING SPECIFICATIONS
----------------------
AREA TO BE SEEDED: 2 .0 ACRES
USE THE SEED MIXTURE INDICATED AS FOLLOWS:
120. 0 LBS. FESCUE GRASS AT 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 1 TO NOVEMBER 30
FEBRUARY 1 TO MARCH 30
60. 0 LBS. RYE GRAIN AT 30 LBS. /ACRE (NURSERY FOR FESCUE)
0. 0 LBS. 'PENSACOLA' BAHIA GRASS AT 60 LBS. /ACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES: MARCH 15 TO JUNE 15
16. 0 LBS. HULLED COMMON BERMUDA GRASS AT 8 LBS. /ACRE
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
0. 0 LBS. UNHULLED COMMON BERMUDA GRASS AT 10 LBS. /ACRE
SEEDING DATES: JANUARY 1 TO MARCH 30
0. 0 LBS. RYE GRASS AT 40 LBS. /ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THE FOLLOWING:
2000. 0 LBS. OF 10-10-10 FERTILIZER (1000 LBS. /ACRE)
4 . 0 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
200. 0 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING 'IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS. /ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAHIAGRASS IS ESTABLISHED.
.3,L ,.1'IUty!a,7, yytd,
APR 042 19

MENEM
------------momm-
M No 0 M No NONE No 0 0 0 IMIMMEME M
OWN Now
low 0 110111
Im MENNEN M
I molill 11111 1111,111
MEN 0 M MONO
SMEN
0
MEN MEN
...
inn Emu
so
No Poo
IN I M
moml M
IMMENow NINE on
0 M
on M
Ism MR ilips� 0 will
1 11 111111111
ON no MEN MEN
MENEM M EMEME 0
ONE
0 MENEM A
No sm
Ir-d I
on MMMEM M n x 0 MEN MEN
M 111 11 IN

Erg
Sell
IN
ON

Animal Waste Management Plan Certification
(Plc.: 'type or print all information that does not requir "'ignature)
General Information:
Name of Farm: Facility NO: .3J --L15-L
Owner(s) Name: Phone No:-Q 31- '-Ir?
Mailing o, Address: q,76
— -
Farm Location: County Farm .is located in:
Fourteen Digit Hydrologic Unit:
Latitude and Longitude: Integrator: Eat�61 -Tic-
Please attach a copy of a county road map with location identified and describe below (Be specific:
road names, directions, milepost, etc.):
0-,?eration DescriT)tion:
Type of Swine No of Animals Type of Poultry No of Animals Type of Cattle No of Animals
W to Feeder ()Layer ()Dairy
e:,r to Finish iq 10 OPuUets ()Beef
0 Farrow to Wean
0 Farrow to Feeder
()Farrow to Finish Other Type of Livestock:— Number of Animals:-
0 Guts
0 Boars
................... ......
.0-9....MW ;?!.P4Z a.A. Y
revrous Design............ ..... . .... ............. ...
........................... ................................. ..... ....... ........................................... .............. .......................... ..................
A'14P.fy
Tk.
V4
............. ........ ...........
............ ..........
Acreage Available for Application: Required Acreage: c9'7- 9,
Number �toraa C,e Ponds: tat Capacity: 3;t,?33,2 Cubic Feet(0)
4 —=u
Are subsurface drains present on the farm: YES oCN0) (please circle one)
L 01
If YES: are subsurface drains present in the area of the ON or SPRAY FIELD (please circle one)
Owner/Manager Agreement
1(we)verify that all the above information is correct and will be updated upon changing. I(we)understand the operation and maintenance
procedures established in the approved animal waste management plan for the farm named above and will implement these procedures. I(we)
know that any expansion to the existing design capacity of the waste treatment and storage system or construction of new facilities will require a
new certification to be submitted to the Division of Environmental Management before the new animals are stocked. I(we)understand that ther
must be no discharge of animal waste from the storage or application system to surface waters of the state either directly through a man-made
conveyance or from a storm event less severe than the 25-year,24-hour storm and there must not be run-off from the application of animal
waste. I(we) understand that run-off of pollutants from lounging and heavy use areas must be minimized using technical standards developed b
the Natural Resources Conservation Service. The approved plan will be filed at the farm and at the office of the local Soil and Water
Conservation District. I(we)know that modification must be approved by a technical specialist and submitted to the Soil and Water Conservatio
District prior to implementation. A change in land ownership requires written notification to DEM or a new certification(if the approved plans
changed)within 60 days of a title transfer.
J
Name of Land 0 TroLin
Signature: a-�- Date:
Name of Mahager (if different from owner):___
Signature: Date:­
AWC --August 1, 1997 1
BOMUW05

Technical Specialist Certification
I. As a technical specialist c.. ignated by the North Carolina Soil and WaL . Conservation Commission pursuant to 1
NCAC 6F .0005, I certify that the animal waste management system for the farm named above has an animal wa
management plan that meets or exceeds standards and specifications of the Division of Environmental Management(DEM)
specified in 15A NCAC 2H.0217 and the USDA-Natural Resources Conservation Service (MRCS) and/or the North Carol
Soil and Water Conservation Commission pursuant to 15A NCAC 2H.0217 and 15A NCAC 6F .0001-.0005. The follow.
elements are included in the plan as applicable. While each category designates a technical specialist who may sign u
certification (SD, SI,WUP, RC,I) the technical specialist should only certify parts for which they are technically competent.
II. Certification of Design
A) Collection, Storage. Treatment System
Ch!5kihe appropriate box
( Existing facility without retrofit(SD or WUP)
Storage volume is adequate for operation capadity; storage capability consistent with waste utilization requirements.
( ) New. exoanded or retrofitted facilir, (SD)
Animal waste storage and treatment structures, such as but not limited to collection systems, lagoons and ponds, hav
been designed to meet or exceed the minimum standards and specifications.
Name of Technical Specialist (Please Print)
Affiliation:` l wn�� C � U � L ate ydork Completed.
Address(Agency)-?0 &JC Phone No: _ , L,
f
Sign re: N Dater e7
B) Land A,34ilion Site)
The plan provides for minimum separation(buffers); adequate amount-of land for waste utilization; chosen crop is
suitable for waste management; hydraulic and nutrient loading rates.
Name of Technical Specialist (Please Print):
Affiliation: 6ate Work Completed:
Addr i gency): Phone No:
Signatu 4 Date:
C) Runoff rols from xterior Lots
Check he appropriate box
( FaciIity without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
() Facility with exterior lots(RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been designed in accordance
with technical standards developed by NRCS.
Name of Technical Specialist (Please Print): 7ZJ►!�< tom.. �� S U
Affiliation: Da e Work Completed:
fSi
dress (Acr cy): Phone No.:
nat e: . i Date: —Y—
r r r Z
AWC— Augus/l 1997
B00101281106

D) Application and Handling Equipment
Check the Appropriate box
Existing or ex andina facility with existine waste application eqyipment(WUP or I)
Animal waste application equipment specified in the plan has been either field calibrated or evaluated in accordance
with existing design charts and tables and is able to apply waste as necessary to accommodate the waste managemen
plan: (existing application equipment can cover the area required by the plan at rates not to exceed either the
specified hydraulic or nutrient loading rates, a schedule for timing of application has been established; required buf
can be maintained and calibration and adjustment guidance are contained as part of the plan).
() New. exaanded or existing facility without existin• waste al2plication Nuipmen for s rave irrigation(I)
Animal waste application equipment specified in the plan has been designed to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the plan
rates not to exceed either the specified hydraulic or nutrient loading rates: a schedule for timing of applications,has
been established; required buffers can be maintained; calibration and adjustment guidance are contained as part of th
plan).
() New.ex anded.or existing facility without existing waste application -equil2ment for land svreadine not usino, stray
irri�. (WUP or I)
Animal waste application equipment specified in the plan has been selected to apply waste as necessary to
accommodate the waste management plan; (proposed gpplication equipment can cover the area required by the plan,
rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of applicaions has
been established: required buffers can be maintained; calibration and adjustment guidance are contained as part of th,
Ian).
Name of Technical Specialist (Please Print): J
Affiliation: '
Date Work Completed:
Addre ncy): Phone No:
Sign Date:
E) Odor Co Insec C ntrol Mortality Man cement and Emenzenev Action Plan SD.$I WUP RC.or D
Th aste manag meat plan for this facility includes a Waste Management Odor Control Checklist, an Insect Contro.
Checklist, a Mortaility Management Checklist and an Emergency Action Plan. Sources of both odors and insects hai
been evaluated with respect to this site and Best Management Practices to Minimize Odors and Best Management
Practices to Control Insects have been selected and included in the waste management plan. Both the Mortality
Manangement Plan and the Emergency Action Plan are complete and can be implemented by this facility.
Name of Technical Specialist (Please Print):
-?Utz S o
Affiliation: Date'Work Completed:
Address cy): Phone No.:
Signat ��� Date:
F) Written N tice f New o� x anding Swine Farm a
The fo ing signature block is only to be used for new or expanding swine farms that begin construction after June
21, 1996. If the facility was built before June21, 1996, when was it constructed or last expanded . I(we)
certify that l(we) have attempted to contact by certified mail all adjoining property owners and all property owners
who own property located across a public road, street or highway from this new or expanding swine farm. The notict
was in compliance with the requirements of NCGS 106-805. A copy of the notice and a list of the property owners
notified is attached.
Name of Land Owner:
Signature: Date:
Name of Manager (if different from owner):
Signature: Date: ~
AWC— August 1, 1997 3
B00101281107

III. Certification of Installation
A) Collection. Storage,,.Treatrr ' Installation
New, ex^anded or retrofitted facility (SI)
Animal waste storage and treatment structures such as but not limited to lagoons and ponds, have been installed in
accordance with the approved plan to meet or exceed the minimum standards and specifications.
Fo fisting facilit ithout retrofits, no certification is necessary.
Name of Technical-Specialist (Please Print):
Affiliation: Date Work Completed:
Address(Agency): Phone No.: `
Signature: Date:
B) Land Application Site (WUP)
Check the appropriate box
(.� The cropping system is in place on all land as specified in the animal waste management plan.
() Conditional Approval: all required land as specified in the plan is cleared for planting; the cropping system as
specified in the waste utilization plan has not been established and the owner has committed to established the
vegetation as specified in the plan by _(month/day/year); the proposed cover crop is appropriate fox
compliance with the waste utilization plan.
() Also check this box if appropriate
if the cropping system as specified in the plan can not be established on newly cleared land within 30 days o
this certification, the owner has committed to establish an interim crop for erosion control;
Name of Technical Specialist(Please Print):
Affiliation: �Y Da e Work Completed:
Address(Agency): Phone No.:
Signati re: 1 Date: / �
This folio gnature block is only to be used when the box for conditional approval in M.B above has been checked
I(we) certify that I (we) have committed to establish the cropping system as specified in my (our)waste utilization plan' and i
appropriate to establish the interim crop for erosion control, and will submit to DEM a verification of completion from a
Technical Specialist within 15 calendar days following the date specifed in the conditional certification. I (we) realize that
failure to submit this verification is a violation of the waste management plan and will subject me(us) to an enforcement actioi
from DEM.
Name of band Owner: — - --
Signature: Date:
Name of Manger (if different from owner):
Signature: Date:
AWC --August 1, 1997 4 B00101281108

C) Runoff Controls from Exterior Lots (RC)
Facility with exterior lc
Methods to minimize 6 .an off of pollutants from lounging and heavy �e areas have been installed as spec{fie the plan.
_ For facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print): ~�
Affiliation: Date Work Completed: ^~
[Addres=s(Agency) Phone No.:
Signature: Date:
D) MPH ati n and Handling E ui ment Installation (WUp or n
Check the appropriate block
(Animal waste application and handling equipment specified in the plan is on site and ready for use; calibration and
adjustment materials have been provided to the owners and are contained as part of the plan.
() Animal waste application and handling equipment specified in the plan has not been installed but the owner has
proposed leasing or third party application and has provided a signed contract; equipment specified in the contract
agrees with the requirements of the plan; required buffers can be maintained, calibration and adjustment guidance h:
been provided to the owners and are contained as part of the plan.
() Conditional approval: Animal waste application and handling equipment specified in the plan has been purchased
and will be on site and installed by (mon'
hold the waste until the equipment is installed and until the waste can be land a plied in accordancewith croppinstorg
system contained in the plan; and calibration and adjustment pp pp g
contained as part of the plan. J guidance have been provided to the owners and are
Fffiliation:
of Technical Specialist (Please Print):
`n-rn Iri ,$Pam.
Date 'ork Completed:
ss(Agency): Phone No.:
Signal'bb Date:
The followingAig ture blo is only to be used when the box for conditional approval in III D above has been h ked
I (we) certify tba (we)have committed to purchase the animal waste application and handling equipment as specified in my
(our) waste management plan and will submit to DEM a verification of delivery and installation from a Technical Specialist
within 15 calendar days following the date specified in the conditional certification. I(we) realize that failure to submit this
verification is a violation of the waste management Ian and will subject me(us) to an enforcement action from DEM.
Name of Land Owner:
Signature: Date:
Name of Manager(if different from owner):
Signature: Date:
E) Odor Control Insect Control and Mortality Management SD.SI WUP RC orI'
Methods to control odors and insects as specified in the Plan have been installed and are operational. The mortality
management system asspecified in the Plan has also been installed and is o erational.
Name of Technical Specialist (Please Print):
Affiliation: C Date 'ork Completed:
Address (Agency) Phone No.: B0010128110
Signatur "Date: —
AWC -- Augy st 1997 5 �
0
y� y

Please return the completed form to the Division of Water Quality at the
following address:
Department of Environment, Health,and Natural Resources
Division of Water Quality
Water Quality Section, Compliance Group
P.O. BOX 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste Management Plan to the
local Soil and Water Conservation District Office and to keep a copy in your files with your Animal Waste Managem
PIan.
AWC — August 1, 1997 6 60010128WO

EMMRGEiTCY ACTION PLAN
PHONE NUMBERS
DWQ giG-3y,�_3goa
EMERGENCY MANAGENMN'T SYSTEM 91 I
SWCD
NTRCS 9/o -
'?his plan will be implemented in the event that wastes from your operation are lealan
overflowing, or ruruung offsite. You should not wait until wastes reach su rf
thus does not happen. 1 ace waters or leave
your property to consider that you have a problem. You should make every effort to ensure that
t e lelca ' n
faQ!Z Tne following are some action items you should take.
I. Stop the release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to some possible problems are listed below.
A- Lagoon overflow--possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump waste to fields at an acceptable rate.
c. Stop all flows to the Iagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering Iagoon.
B. Runoffrom waste application field-actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
C. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reasons) that caused the runoff
e. Evaluate the application rates for the fields where runofFoccurred.
C. Leakage from the waste pipes and sprinklers-action include:
a. Stop recycle pump.
b. Stop irrigation pump.
C. Close valves to eliminate further discharge.
d. Repair all Ieaks prior to restarting pumps.

D. Leakage from flush systems, houses, solid separators-action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewaH of lagoon. Often this is seepage as opposed to flowing
leaks-possible action:
a. Dig a small well or ditch to catch all seepage, put in a submersible pump, and pump
back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon bottom as soon
as possible.
2. Assess the:extent of the spill and note any obvious damages.
a_ Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger(either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ (Division of Water Quality)
!�"s5�=.3scv tQ ty) regional office;
Phone
After hours, emergency number: 9/9-9,33 37,l your phone call
should include: your name, facility, telephone number, the details of the incident from item
2 above, the exact location of the facility, the location or direction of movement of the spill,
weather and wind conditions. The corrective measures that have been under taken, and the
seriousness of the situation.
.b. If spill leaves property or enters surface waters, call local EMS Phone number 911.
C. Instruct EMS to contact local Health Department.
d. Contact CES, phone number ���-� 5/•�l�S
local SWCD office phone number
(1'�!3/ and local MRCS office for advice/technical assistance phone number
4. If none of the above works, call 911 or the Sheriffs Department and explain your problem to
them and ask that person to contact the proper agencies for you.

5. Contact the contractor ofyour choice to begin
1 repair of problem to minimize off-site damage.`rowr '11
a. ContractorseName:
b. Contractors Address:
c. Contractors Phone:
6. Contact the technical specialist who certified the lagoon (MRCS, Consulting Engineer,
a. Name: ` n etc-)
b. Phone: \ r nsavi ! r Sw2bun
10-
7. Implement procedures as advised by DWQ and technical assistance agencies to rectify
damage, fair the�e� and reassess the waste management plan to keep problems with
release of wastes from happening age

Version—November 26,2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
pBurial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be.at least one foot above the seasonal
high water table.Attach burial location map and plan.
Landfill at municipal solid waste facility
13B .0200, permitted by NC DE under GS 15A NCAC
Rendering at a rendering plant licensed under G.S. 106-168.7.
aComplete incineration according to 02 NCAC 52C .0102,
aA composting system approved and permitted by•the NC Department of Agriculture&Con-
sumer Services Veterinary. Division(attach copy of permit). If compost is distributed off-farm,
additional requirements must be met and a permit is required from NC DEQ.
0 a In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture&Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinionjof the State Veterinarian,would.make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm-specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A.catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be-done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions(refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency,the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Signature of Farm Owner/Manager
j Date
Signature of Technical Specialist
Date

,gip 1 ••
ly I1•�'anascmcn[ illethods '•
• .
(check tvhich methods) are being! implemented) .
~ Durial three feet beneath lIlc surface of tltc ground
krto�vledge of tltc death. '1'l�e burial must be le least nd fithinrom lours after
strcanl or public body o f"•ater. dn! flo►ving .
Rendering
at a re:rderiltty Jllant licensed under G.S. 106-163.7
Complete incineration
0 In (Ile case of dead poultry only )lacing
approved by the Dc artmcnt of A- i Ina disposal pit of a size and'dcsign
p nculture
G Anv method %%,Itirll ill the Professional opinion of the St
atestake possible Ill(! salt'ane or-pa� or -, dead animal's Vallee %Veterinarian would • '
human or animal health. (Written approval of the State Vclelr narlan nest
attached)
n must be
Insect C011[r01 Checl(list for Animal O pera
tionstiu�n cc
IIH11's lu Cuulrul I,uccls
_ l,iquld 5yslcnrs Sire tilurifi,t I'rnrrlres
Accuuml;tfi+nr of solids ~0 Flush syslent is design
~------
ell
�-ll-
SlIfficleally Io rentuvenct:uuntL•+Ied lsolids From
Millers as designed.
Q ltentove bridallg ofaccnnnd;rled solids ill
la,gn�++s 1uu) NIS dischnr�u
Crnste+l St,li,ls
MoinU+iu lul;nnns,se111 tic basins will bits where
pest hremnoi; is npparenl to ntinlrttize the
crtls"11C of solids to a depth of no more flan 6-
7sres�i►, Ve�clative U inches over more than ail%of snt'fnct.
(ituttllt I),enYin, vcucl;rliun t fvlainloin venelalivu control wlon; banks
I;;goons tutrl other impotnteimcnts to prevent
acctllllll ;Ilon ofdeeny1119 vecelalivc m;mer
wtung walcr's e+lce on impoundntctrI's perinrcler.

• r
Swine Farm Waste 1111<
---- ►»Jcment Odol• Con(rol C17eciclist
Fit,
• Swiue protlucliott Ilq•11's lalu�jttlnlu,lc(jtlur
Ve(;elallYe or Wooded bllflets; Stlt ;;l,cel(Ic 1'rt,clll'cI
/ Itecolnmcntictl'best ul;tn:tgenlenl pruckes;
Auint:d I►wly swfitrc�t I)itly ntanure-covcrt d anintuls Qaod judgillcnl and cununuu scnso
I�luu� r Stu j;icta I)1'y Ilonrs
• Wcl ut:nutre-cuvcrcd Iluurs Skilled Iluors;
Waterers Inc.acd over slnlled fours;
Cl Feeders III high cull orsolill floors;
Cl Scrape manure bllilllup rr'out floors;
til:uutre t ullcctinll 1111s Ilrine - Under(fonr willilalino for drying
frcglrcrrl nrunn'c renlovW by lush 1 ' c
• fill liill IIIICrtlhiill decoolltnsilinu or SCfrllll`;
Vt ntrl�tuun e�hiurll l�nu - ---�— Undcrlloor venlilillinn
Vlllittllt:Li1SL's;'~� � ,
Dust fnn nntintcualice;
b„luur swfi,�es lil'licienl uirmnvcnlen(• I)usl
Wushdn►vn behvecn groups of aniulals;
f7 I'Cl'll rl(IIIIIIYL's; '
!7 Feeder cuvery;
CI Feed th:livcry duwnsltnul cxleutlers It, realer
flush Uutk' Agil:nioa orrecycicd lagoon covers
li,lufd whUe lucks are lilling CI flush Inuk covers;
Cl 'ihlentl rill li►les lu nt:ilr bnumi,uriatll:s Ivilh
fhuh alleys ALilnlinu Ihniug tvnsletwner Mill-si,hnll veins
• conveptilca
Cl Undern(Iljr!lush ►vilh nnderlhntr vt nlilnlinn
Pi,r�chin'(;c puinls -
A�iluliun urrCCycletl lilguutl — —_
1-1 lixtend rechurgc lilies lu ucur bulhnu ul'pils
_ liynid►vhiltl Ails urt:filling
with anti-siplum Lilt A
veils
sluliwu `�
. gitullnn rhuing sump hulk GI Suulp Iunk covers
lilling untl drillvlluwn
flntsitl�drlliu cullt:cllurl
urfuncllatt huxcs ALil�tliuu during wuslt:wul�r CI 'lox covers
canveyanca
AtvlfJl;-hlnvvndlcr 11, 19'Jb, I'u�u

taut of rlr;,inlril,cs n1 ----- -luul- -- �-'u,s��" •--- ---...�..4.....,...,�
IuLnorl Al;ila Iln„ng %VilllClY�,lcr IIAgI's (n 1111nlrrlize 01111
Cl Iixlcnd discltn' rj~ ; Point of pipes unrlcrncnlh e 'r��• r
ro,Ivc}'n ice MIL'�,IIL'l'IIIC I'1,I1'IICLS
LuLuu,I sn,F,ccs Ingaon liquid level
• VoL•,lilo Ells emissions•
• alugicul nlixiug; P
Ili roper Ingonn liquid cnpuclly;
• hgit,ulon Correct IaLnon sla,lop procedures;
Minlnllnn surf,ca urea-Ia-valnn,e rnlio;
• Mb,lnnun ngilnrion tvl,cn•punq,ing; .
Cl hlechanlcnl ncrallun;
Irrignlinn sprinl.lcr f=1 I'rnVe,l I ligl, binlol;icul uddillves
puzzles pressure„gilaliuu;
• Wind ill-in l Irr(g:,lu of,rlry dnys lvilh_lilllu or un win,l;
Mlnin►urn rcColllrltc4dcd operalllrg liresslrre;
Pump inlnkc ncr,r 1„gnon liquid surface;
ur L;rsin • 1',ulinl uticruLial dccnrupnsiliun n I'untp from sccand-sin
�ur(hr o Lc lagonu
• Mlx6,g tvitile 1i111ng; CI Ilotlon,or nlldluvcl luarliug;
• ASIlallorl%Vile,,rll►I,lyll,, C, �I•nlll;covers;
`11sill surf,lce rltnis nfsalitis;
S�Illing I,:uin sw G,co ,. Cl 1'rovun bialo
Pill n,icn,l►i:Il dccnnrpr,siliu,,; Lrc„)uddilives or oxidants
• Mixing lvl,ile filing; CJ lix1coll druinpipu oulluls un,lcrncall, lirplid level;
A•Innnrc, slurry Ill*slurlgc . n Liurllon wllcn cntplyiog n ltcrnova scrrlr:d solids re .
�preurl�r owlets gilullnu when slu'endirrg; Lul„rly
. Cl Soil injection ofsln,ry/sludges;
Volatile gas e„tissia,Is .
Cl Wusll•residu;,l nr,utltrc rrorl,sprcadcr tiller use;
Ih,_CI vcrc,I nurnnre,�;�_�— n Proven biulnl;icul,uldillvt nrnxld;mis
slrllry or sludge oilli►:I,I drying Ens cu,lssiuns whilu
CI soil injection ufslmry/sltrdguS
stnl�recs
CI Soil incorparalloll%vill,in l8
Cl Spreatl ill 1411,nnifiu'lu Inyers fur rapid drying;
I}call nnim;Iis Cl Proven l,iolugicnl ndditivcs fir oxi,Luus
• CO MISS tictuutposiliuuji:d
I)ca,l uuin111
rrl Ilk lus„I Ct,rcass ticcou,pusili„u Proper dispnsilirul ureurcassuat
Ails Cl Cun,plelu covurin
(,of curcnsscs in LurL•rl Ails;
Inciurru ls Cl Prop
,I er lucnlinn/cm,slnlelian nrdispnsnl Ails
• Incuny,lcic cumin,stiun
CI Sccnnllary slnd Inn'ucrs
AMOC Nuven►I►cr I1, 19tJ6, Ih,pu,I

er cc
Sl;ur{hrlg►v;1lcr;uoullrl Cuu
rse
l�rrilitics Inrliruper drainaLc t-11-'s -- nlin-once(I Inr
Grade and l:uulscu ►c sue
• Microbial dccnm Ios' Slic 5 ►rriflc '
i tttoll of I h Ihal walr r dr:lins I I ucllces
urgallic Illaltcr aivHY frn111 r:►cililics
hl;uuuC iracl;cd unlu 1'ou11y n1)IIII iucd acress t—o—s
pn111i�roods limn filrnr
urress iI ucccss road nruinlcnancu .
Arlilitional Infonnnilnn; � •• �'
Slvl I,c A. 1,! nuru M:Iual;culCnl; nznrl Iculr�uM1'1'uckcl • .
tilvinc!'rul4lcllurt hurrn Pulcnllal OdorSuurccs and Ilculedle
Swb1c I'rullucrion I�uclilly Mnnpre Mal Iles I'h IlcclllrI �e_ Aynllp111t;hrnnt ; ,
Swtnc 1'rnducllnn huciliry Ivlarlara MluruLctuclll: 'll 11t to s f 11gool rncl Shccl NCSII,G111n1y lixlcnsiun Cellfer .
LuCnun Ihsi�r L Ln�null'Iir;llnlcnl; I;llAI; 129_83 NCSIJ-IIAII
h I nud hlanngcnlenl Ii1r Llvcslnck Mannrc'i'ruthnenl allrl Slnrn �c ' 1ICslJ-IlA(;
or Flush-Lagllon'I'rcafnlenl; NMI;
Calibration of ,Munurc uud Wnsleivalcr Appllcaliun Lgnipnlcul; [i1JA : IZ9-U8
C0111folilog Orlurs from Swine Ilulldin s• L , PIMP 111]-U] NCSII- IIAIi
I:uvlrounrcnrul Assurance I'ro gram • C I I11-JJ I ncl Slice'
llcr NCSIJ- IIAI's
npllulls frlr hlauu�In • NI'11C Manual NCSIJ-IlA1i
L b Odor n report rront the Swlnc Odor Tusk hnrce NCSII-Swhtc Cxlcnslun
Phllrurec C'nnccnIs lu/►ulnwl Munurc Munlll;entcnl:Odors unll k F • 'Flies. I ROM, 1975 Currfcreltcc I'rncccllilt g NC I'1►rk 1'rllIIllCCr!Assuc
NCSIJ Agrl Cu111111unlcallnns
C I:Iurh1;1 Cuoperulivu I:xlcnslhm
• • ', , . .. . •' 'try: !• •
..4:>;' AA1t I(; 1411vcIn111 r I i I 1 Jri 1'I ,

OPERATION AND MAINTENANCE PLAN SHEET 1 OF 2
------------------------------
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s) . If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre-
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre-charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids. should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2 . The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3 . Begin temporary storage pump-out of the lagoon when fluid level
reaches the elevation 48. 3 as marked by permanent marker. Stop pump-
out when the fluid level reaches elevation 46. 1 . This temporary
storage, less 25 yr- 24 hr storm, contains 77630 cubic feet or
580669 gallons.

SHEET 2 OF 2
4 . The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0. 3
inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8 . Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
Pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.