310321_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Facility Currently Request for Certification of covered by an Expiring Sate Non-Discharge General Permit Qusl}ly
On September 30, 2019, the North Carolina State Non-Discharge General r�®�t>9ljpt18
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these St
Non-Discharge General ate
Permits must apply for renewal at least 180 da s Permits for Animal Waste Management Systems will
must be received by the Division of Water Resources by no later than April 3,2019.prior to their expiration date. Therefore, all applications
Please do not leave any question unanswered Please verify all information and make any necessary corrections bel
Application must be signed and dated by the Permitter
oiv.
I. Farm Number: 31-0321
Certificate Of Coverage Number:
2. Facility Name: James E_Kin�Farm AW 310321
3. Landowner's Name(same as on the Waste Management Plan): James E Kin
4. Landowner's Mailing Address: 1150 Stockinr�Head Rd �6
City: Roses
State: NC
Telephone Number: 910-289-3624 Ext. E-mail: Zip: 28-458-8565
5. Facility's Physical Address:
1076 Stockinehead Rd
City: Rose Hill
State: NC
6. County where Facility is located: Dup lin Zip: 28458
7. Farm Manager's Name(if different from Landowner):
8. Farm Manager's telephone number(include area code):
9. Integrator's Name(if there is not an Integrator,write"None"): Presta a Farm Inc
10. Operator Name(OIC): J rigs E Kin
Phone No.: 210-289-3624 OIC#: 16375
11. Lessee's Name(if there is not a Lessee,write"None"): /)pfl(;
12. Indicate animal operation type and number:
Current Permit:
Operations Type Allowable Count
Swine-Feeder to Finish
Operate_•oo-eC, 2,480
Swine Cattle
Wean to Finish Dairy Calf kr Poultry
Wean to Feeder Non Laying Chickens Other Tvues
Farrow to Finish Dairy Heifer Laying Chickens Horses-Horses
Feeder to Finish Milk Cow Pullets Horses-Other
Farrow to Wean Dry Cow Turkeys Sheep-Sheep
Farrow to Feeder
Beef Stocker Calf Turkey Pullet Sheep-Other
Beef Feeder
Boar/Stud Beef Broad Cow
Gilts Other R'et Pouet"
Other Non Laying pullet
Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Estimated Liner Type Estimated Design Freeboard
Structure Estimated
(Clay,Synthetic, Capacity Surface Area "Redline"
Name Built Unknown)
r(1Cubic Feetu) (Square Feet) (Inc
1-2 pp�� hes)
•mil QQQ 19.50
3-4
19.50
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d)to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan(WUP),signed b► the owner and a certified technical specialist. containing:
a. The method by which waste is applied to the disposal fields(e.g,irrigation injection,etc.)
b. A map of every field used for land application(for example:irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation(RYE)for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted-Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal
(e.g.composting,digesters,waste transfers,etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]
10Quialfty
�019

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included,this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation,signature should be by a principal executive officer of the corporation):
c Name: E Title: C-0 146!,r
/ s Signature: te: l
If
Name: Ql .Darr C � Title: � 0
` Date: Z-
Signature:'� `
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699-1636
Telephone number:[phone]
E-mail:[e-mail]
FORM: RENEWAL-STATE GENERAL 02/2019

_ 4
ROy COOPER
MICHAEL S.REGAN
Semm" NORTH CAROLINA
LINDA CULPEPPER Environmental Quality
Director 27,2019
February
James E King
James E.King Farm
1150 Stocking Head Rd
Rose Hill,NC 28458-8565
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee: Permits,
ation
Your facility is currently approved for operation under one mal Wa Animal operation eSta eerNon DSschargetate oGeneral Permit are available
which expire on September 30, 2019. Copies of the new if -r ei n -o erations/ fo or by writing or calling:
at h f :ll a .n . v a u 'vi io te
/w a-reso
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699-1636
Telephone number:[phone]
d r th tate Non-Dish en ral Pe it . r
s bmi li do r
In or er t ur c ntin ed co r e wil m „R es fo C fi a of C v r e Faci it urre tl� o eyed b�
v ra i the D'visi n. En to e o
u b c m l to - i n d and return b� Anril_
Ex iri Sta Non- is h Gene al Perini " T e a 1'c i n fo
e fo nd o e 2 of th rene al
e note thaw must incl d one 1 co of the cludeddinAthe 1 A as a Mana eme Pl n CAWMP ith
Tle� A lit of 'ems
coin eted a d sir ed a lication form.
oplicatip p result in a civil penalty
Failure to request renewal of your co .
verage under a general permit within the time period s ecified may
of our facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
Operation y
result in assessments of civil penalties of up to$25,000 per day. related matter please feel
If you have any questions about the State Non-Discharge General Permits, the enclosed application, or any
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Sincerely,
Jon Risgaard,Section Chief
Animal Feeding Operations and Groundwater Section
Enclosures Regional Operations Section
cc(w/o enclosures): Wil inc on Regional Office,Water Quality Reg P
DRDlin County Soil and Water Conservation District
AFOG Section Central Files-AWS3110321
PrestW a FaMs Ino
North Caroins Departnoentof Enva�enmeMtai Qoalary I Diw"ion of Water Resources
�� °34�H. aeh3b«ry St. 1636 Mai!Servme Center I R&WO,Woxtia Carol a 27599 1G3Fi
�... 919.707 WO

Mortality Management Methods Version—November 26,2018
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
QBurial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table.Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A
13B .0200. NCA C
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
aA composting system approved and permitted by the NC Department of Agriculture&Con-
sumer Services Veterinary Division(attach copy of permit). If compost is distributed off-farm,
additional requirements must be met and a permit is required from NC DEQ.
aIn the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture&Consumer Services(G.S. 106-549.70).
aAny method which, in the.professional opinion,&of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm-specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
POrts a variety of emergency mortality disposal options; contact the Division for;,widence.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be,.done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions(refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency,the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Signature of Farm Owne onager
Date
Signature of Technical Specialist
Date

Field 1
n
h
Field 4 Field 6
Field
Fo
geld:
Field 5
oogle
02019 Goog(e-Imagery 02019 USDA Farm Service Agency,DigitalGlobe,Map data o2o
200 ft

1346 ✓ _
/• ' i Snit.
1300 \ 1516 \' 1517 CM1.ael
_ 11301
1.9 i� .8 SCh. 16 1731
P.B. 1379 ' . � 17oi Y-1400 7.
Raiford i378 '3 \ �
Alrparf . 1'6 \ ' 170
10043
I. 1301 \ 1700 ._\ .�__.�\�•
2.`
J a� f � 17 I
1378\ ® \ S
I I1NE A 1377
F •\ i c 1728
1700
729
9i
ro �aai 7 \ } 1906 4\ KENANSVILLE 1�o 37
POP.a73
l '1927 I r r 1959 24 W
1701 �73
�p Mea 1702
- 2013, I _
1908 �. 1959
1
}I t 3 926 __ '\ 1727
.1908 2014 l 's 1924 1726
C - •} 1701
— 1702 1739 J
\ 1923 \0.b DO
1114 1991 \ J
6 r' 1702 19
CI
\ •�, I _./
1922
Mat
I 1-' 1 ^'�', \ •� 1� � .\:e 1 \�\ �\ �4�^r.. 1961 � i{:7800 t7za,
1912 ,& J• 1961
'm 1-11}. 1920 1912} —, 1964
11t - m 2 0 1737 11411957
19
PPOPGNMW 161 \, 2016 r \�, 1 1957 ` 4
1915 1911\ 1921 '•'iZ„ \ 1953
q • 1919 � i955 \
1177
1964
195G 7141 / •'\
.-
1003 1103 1911 � 0 1
`1917 •^ 1 _\ �'� \
0
N 1918 \• / 19531
- 2017
I%4
9d5 1915T 1141 %-
I123 1103 1967 �-
1.4
1911 .2 1141 S�9».r r� I96
� i l '�l R ` -. 1984
1122 ROSE f11[L •p 1 I 19M \ 1964 b
POP.IA21 O
t 125 _ II 1 GRERNEVM /
POP-631 0
1103
02 1 \ charily
^ 1142 -- --_-
I40} 1139 } 0 I
1970'
Muo* '
1947
1143 I._ 1148 177 1935 --�•� l -I '} 41
1733 /•• 20�8 _•.
1=01 \7 173f3 1146 1162 1936 f 19W ^1907 19zs 1 '•\1� Two•;q. it6o N 1945 FE1135
AR
Ma
•\ 1
1137 11 1 11 } _ ® 190.9 1945' 19W 1979
r P I'9 Jones O`epal i" \ _ G 1987 1977 1� ,
-?b* 1136 j 1170 TFACHy 1 1 r _-
1 POP.243 '8 61 \. J •'
1976
201
Sao. 197�.
-
/J/`_ /•.1 V ANaaLA BAY
. �• � ( 41 ' -•/'• \� GAVE IANO
t
m \ �.�i�J•.1 � ' - 1 1941
940 _ — —•—•—•— —._._ ------------
of WALLACEAL 3
n F R

Animal Waste Manageinent Plan Certification
(Please
.' ; or print all information that does not require a' lure
a�S1Ila:
New ar Expanded : ... (Please.cireie
General Information:
Name of Farm.. - - - - - - - -- - -- ----'
L01 r.1
Owner(s) Name: A
Mailing Address: h
_ Facility No:�__ _
Phone No: 1 D-;'f9_ �6�4
Farm Location: ° i
Fourteen Digit Hydrologic Unit: OY D ~
Latitude and Longitude: a t, o od - -- -- --- -
Please attach a copy of a count road ma `—� — County:
y P with location identified and describe below (Be specific:
road names, directions, milepost, etc.): S
O eration Descri tion: ----~-~- - -
Type of Swine No of Animals
17 Wean to Feeder Type of Poultry
0Feeder to Finish 0 Layer No ofAnintals Type of cattle 0 Farrow to Wean ��Pullets Q Dairy No ofAnintals
EJ Farrow to Feeder — D Beef
Q Farrow to Finish
Other Type of Livestock:
.........—........................... :
............................ Nun
....................... -� t s:
Number of Animal
pQlZll'In ( .:`El`Qh017: IZi'.^ . _ ......................_........_...._.................
............_..._.......
Prerflzrs L1e;�tgrz Capazt
. ddrtrnal T:esz$n Capactt
Tr�trxl:�esrz Capacr.t { -
zsirz :`�.
g and F.x Qdrn eraianti.
_... .
... ... :................
.,....._...::..........:_...._:.:........:::..............:..........:..:.......::::.
_...._.........
.. .................
egzsratrn;!Jae
Acreage Available for Application. �� V.
II
trzt~ arm a
PPlreJ.Q>~ egztcrta�r):......
Number of Lagoons/Storage Ponds: - ReQulred Acreage: ab, .........:......................... ..............:. ...:.......:...:
Are subsurface drains present on the farm: Total Capaci
*******esen on the farm: �j *��*� O � Cubic Feet (ff3)
or (please circle one)
Owner/Manager Agreement
I(we)verify that all the above information is correct and will be updated upon changing.
procedures established in the approved animal waste management plan for the farm named g g. I(we)understand the operation and maintenance
'snow that any expansion to the existing design capacity
:tew certification to be submitted to the Division of Environmental Management before�e above and will ruction of these procedures. I(we
P ty of the waste treatment and storage system or construction of new facilities will require a
must be no discharge of animal waste from the Storage or a new
wartL;OlI ey I(w or from a storm event less severe than the 25-year,24-hour storm and there must n animals are stocked. I
g application system to surface waters of the state either directly through aman-made
(we)understand that there
tt�aste. r(we)understand that run-off of pollutants from lounging and heavy use areas must be Minimized
the Natural.Resources Conservation Service. The approved plan will be fried at the farm and at
be run-off from the application of anima!
Conservation District.I(we)know that modification must be approved by a technical specialist a using technical standards developed by
L.; the office of the local Soil and Water
District prior to implementation. A change in land ownership requires written notification to DEM o
an submitted to the Soil and Water Conservation
changed)within 60 days of a title transfer.
Name of r a new certification(if the approved plan is
Land Owner:
Signature:_
NGtme of Manager (if different from owner): � -- -- --
Inature --- Date:; r.�c
"VC--April 24, 1996 - -- - --- -
1 Date:

Tec —aical Specialist Certifica Jn
L As a technical specialist designated by the North Carolina Soil and Water Conservation Commission
pursuant to 15A NCAC 6F .0005, I certify that the animal waste management system for the farm
named above has an animal waste management plan that meets or exceeds standards and specifications
of the Division of Environmental Management (DEM) as specified in 15A NCAC 2H.0217 and the
USDA-Natural Resources Conservation Service (MRCS) and/or the North Carolina Soil and Water
Conservation Commission pursuant to 15A NCAC 2H.0217 and 15A NCAC 6F .0001-.0005. The
following elements are included in the plan as applicable. While each category designates a technical
specialist who may sign each certification (SD, SI, WUP, RC, I), the technical specialist should only
certify parts for which they are technically competent.
II. Certification of Design
A) Collection, Storage Treatment SvstPm
Check S1:e appropriate box
Existing facility without retrofit (SD or WUP)
Storage volume is adequate for operation capacity; storage capability consistent with
waste utilization requirements.
❑ New. ex landed or retrofitted facility (SD)
Animal waste storage and treatment structures, such as but not linuted to collection systems,
lagoons and ponds, have been designed to meet or exceed the minimum standards and
specifications.
Name of Technical.Specialist (Please Print):_
Affiliation: - BILLY W HOUSTON -
- — DUPLIN S & I! CONSER DISTPICT _
Address(Agency): PO BOX 277
Signature: KENANSVILLE NC 28349 —
6'2 TFI .FPHONF 91 D-2
B) Land Apnlli! a n Site (WUP)
The plan provides for minimum separations (buffers); adequate amount of land for waste
utilization; chosen crop is suitable for waste manage7P t- hvrlrniylir. nnrl nntriPnt loading rates.
Name of Technical Specialist (Please Print):_ BILLY W HOUSTON
Affiliation: ; DUPLIN S & W CONSER DISTRICT
PO' BOX 277
Address(Agency): KENANSVILLE NC 28349
Signature- 6- /_ TELEPHONE [phone]
C) Runoff Controls from Exterior Loth
Check the appropriate box
❑ Facilit without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
❑ Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been
designed in accordance with technical standards developed by MRCS.
Name of Technical Specialist (Please Print):— _
Affiliation: —
Address(Agency): —Phone No..
Signature: — -
-
AWC -- April 24, 1996 2

D) Application and Handlin jtlipm nt
Check the appropriate box
CT" Existing facility with existing waste application etlui ment (WUP or I)
Animal waste application equipment specified in the plan has been either field calibrated or
evaluated in accordance with existing design charts and tables and is able to apply waste as
necessary to accommodate the.waste management plan: (existing application equipment can
cover the area required by the plan at rates not to exceed either the specified hydraulic or
nutrient loading rates, a schedule for timing of applications has been established; required
buffers can be maintained and calibration and adjustment guidance are contained as part of the
plan).
❑ New or expanded facilit • or existing facility without existing waste application_ ui merit (I)
Animal waste application equipment specified in the plan has been designed to apply waste as
necessary to accommodate the waste management plan; (proposed application equipment can
cover the area required by the plan at rates not to exceed either the specified hydraulic or
nutrient loading rates; a schedule for timing of applications has been established; required
buffers can be maintained; calibration and adjustment guidance are contained as part of the
plan).
Name of Technical Specialist (Please Print):_ ILLY w HOUSTON —
Affiliation: DUPLIN S & W CONSER DISTRICT _
PO BOX 277
Address(Agency): KENANSVILLE NC 28349
�v - 6-z1- 9t TELEPHONE [phone]
Signature: _ ---- -
III. Certification of Installation
A) Collection Storne Treatment Installation
New, expanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds,
have been installed in accordance with the approved plan to meet or exceed the minimum
standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print):--
Affiliation:-
Address(Agency): Phone No.: _
Signature:_ _Date:
AWC -- April 24, 1996 3

B) Land Annlication Site (WS . )
Check the appropriate box
9"' The cropping system is in place on all land as specified in the animal waste management plan.
Conditional Approval: all required land as specified in the plan is cleared for planting; the
cropping system as specified in the waste utilization plan has not been.established and the
owner has committed to establish the vegetation as specified in the plan by
(month/day/year); the proposed cover crop is appropriate for compliance with the waste
utilization plan.
O Also check this box if appropriate
if the cropping system as specified in the plan can not be established on_newly cleared
land within 30 days of this certification, the owner has committed to establish an interim
crop for erosion control;
Name of Technical Specialist (Please Print)-___. BILLY W HOUSTON -
Affiliation:_ - DUPLIN S & W CONSER DISTRICT -
PO BOX 277
Address(Agency): _ KENANSUILLE NC 28349 -
Signature:�� TELEPHONE [phone]
This following signature block is only to be used when the box for conditional approval in III. B
above has been checked.
I (we) certify that I (we) have committed to establish the cropping system as specified in my (our) waste
utilization plan, and if appropriate to establish the interim crop for erosion control, and will submit to
DEM a verification of completion from a Technical Specialist within 15 calendar days following the date
specified in the conditional certification. I (we)realize that failure to submit this verification is a
violation of the waste management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner :--
Signature: Date:
Name of Manager(if different from owner):-
Signature:. _ __.. Date:.
C) Runoff Controls from Exterior Lots (RC)
Facilitv with exterior Iots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been
installed as specified in the plan.
For facilities without exterior lots, no certification is necessary:
Name of Technical Specialist (Please Print): -
Affiliation: -
Address(Agency): Phone No.:-
Signature: Date:
AWC -- April 24, 1996 4

.D) a nnlieafion and Handlin- uinment Installation (WUP or 1)
Check the appropriate block
2""'Animal waste application 'and handling equipment specified in the plan is on site and ready
for use; calibration and adjustment materials have been provided to the owners and are
contained as part of the plan.
❑ Animal waste application and handling equipment specified in the plan has not been
installed but the owner has proposed leasing or third party application and has provided a
signed contract; equipment specified in the contract agrees with the requirements of the
plan; required buffers can be maintained; calibration and adjustment guidance have been
provided to the owners and are contained as part of the plan.
❑ Conditional approval: Animal waste application and handling equipment specified in the
plan has been purchased and will be on site and installed by
(month/day/year); there is adequate storage to hold the waste until the equipment is installed
and until the waste can be land applied in accordance with the cropping system contained
in the plan; and calibration and adjustment guidance have been provided to the owners and
are contained as part of the plan.
Name of Technical Specialist (Please Print):_ BILLY t4 HOUSTON —
Affiliation: DUPLIN S & W CONSER DISTRICT —
— PO BOX 277
,Address(Agency): KENANSVILLE NC 28349 —
Signature: f�' �''� 6-�,i-�� 910-296-2120
The following signature block is only to be used when the box for conditional approval in III D
above has been checked.
I (we) certify that I (we) have committed to purchase the animal waste application and handling
equipment as specified in my (our) waste management plan and will submit to DEM a verification of
delivery and installation from a Technical Specialist within 15 calendar days following the date specified
in the conditional certification. I (we) realize that failure to submit this verification is a violation of the
waste management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner :
Signature: Date:-
Name of Manager(if different from owner):--
Signature: Date:- ..-
Please return the completed form to the Division of Environmental Management at the
following address:
Department of Environment, Health, and Natural Resources
Division Of Environmental Management
Water Quality Section, Compliance,Group
P.O. Box 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy in
your files with.your Animal Waste Management Plan.
AWC -- Apri124, 1996 5

Irv. tr
13 4 41 TO COMFOO
Me 2-6 At b
Lm Im
75 to
im
Cabin 1714-
17IQ Ins
P 17
24 JZ27
1.9 im 111 1711
dell
227- At
Lm-5
1724
195F W rtl. rl PAP
f721
4 ]may -5 A1702 lz)l�1.0
_172-
F_ 24
LULJ 147
> 1.61 :4 H.dl-y j,5
A
61 LLV 1.02 1.35 1-06 1715 1
1737 6 1724.
H.11mll. .
.3 too 6 1
1W I
V, Igo.
1600
1-0111 1
n - 1.1 — .7
/ ; J,
is-
eat .8 S Store leo Quinrlsb
1.0 1933 q
1957 2.3
1609
lelo
d C.d.,Fork
-P :Q IBM
I-
!? m3
19" Fork I.6141,
:_V 1.12 c
low — wldh 17-15
1954 1715
Both.[[
... 1967
1821 gmjo�n
1968 1401 % 1814 F.Wf A 1715*-,
IJ .1.2
1964 IIT 34,
.3 1. 2 s
161710
1, ffI
-6
(WEENEY v05 p
lei?
lot? 1014
-:7 477 41 18 • 141. m 11101 1417 1.9
IV70 -0
1919 2.1
SL .1.2 50 1715 171,11 i c
1971
017
I
1837 1616
2.1
1- 1917 1S ft
1970
9"
'-Z n jjU.9 142$ 1.26
IS47
1,90 19 1828
19"
1987
F JAL'
B3
A-
3'AS'A
1976 J4 cyp�
Pin
UZI 1027
L2 P
Im
INV
1976
A N G 0 L A A Y KEY TO C:GUWY
AM"A01
GAME LAND
so
y
c 0 u T Y

Nutrient Management Plan For Animal Waste (Utilization
03-12-2009
This plan has been prepared for: This plan has been developed by:
James Edward King31321 Billy W Houston
James Edward King Duplin Soil& Water Conservation
1150 Stockinghead Rd. PO Box 219
Rose Hill, NC 28458 Kenansville,NC 28349
910-289-3624 910-296-2120
Develop)'er Signature
Type of Plan® Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I(we)understand and agree to the specifications and the operation and maintenance procedures
established in this nutrient management plan which includes an animal waste utilizattion plan for
the farm named above.I have read and understand the Required Specifications concerning animal
waste management that are included with this plan.
O
Signature{owner) Date
Signature(manager or producer) Date
,This plan meets the minimum standards and specifications of the U.S.(Department of Agriculture-
Natua°al It€sources Conservation Service or the standard of practices adopted by the Soil and Water
Conservation Commission.
Plan-Approved B
Technic4YSpecialist Signature Date
--------------------------------------------------------------- - --- --------
858492 Ua&base Version 3.1 Date Printed: 03-12-2009 Cover Page I

Nutrients applied in accordance with this plan will be supplied from the following
source(s)-
Commercial Fertilizer is not included in this plan.
S7 Swine Feeder-Finish Lagoon Liquid waste generated 2,298,960 gals/year by a 2,480
animal Swine Finishing Lagoon Liquid operation.This production facility has waste
storage capacities of approximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast 5295
Incorporated 9094
Injected 10014
Irrigated 5755
Avail. Actual PAN PAN Surplus/ Actual Volume Volume Surplus/
(Ibs) Applied(lbs) Deficit(lbs) Applied(Gallons) Deficit(GallonsYqM�a�x.
5,755 5981 -226 2,389,037 -90,077
----- - :_.:.,---- --------------------------- ---- -----------------
Note: 1n source iD,S mesas standard source,U means user defined source.
*Max.Available PAN is.calcalated on the basis of the actaaLapplication method(s)identified in the plan for this source....
858492 Database Version 3.1 Date Printed: 03-12-2009 Source Page Page 1 of 1

The Waste.Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of cropland needed to use -
the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown,their nutrient requirements,and proper timing of applications to
maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure or other by-products,
commercial fertilizer and residual,from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field in order to supply the indicated quantity
of nitrogen from each source is also i cluded. A balance of the total manure,produced and the total manure applied is included in the table to ensure that the plan adequately provides
for the utilization of the mangre-genefated by the operation.
Waste Utilization Table Year l
-- - Nit ogen Comm. Res. Manure Liquid Solid Liquid Solid
PA Fed. (lbs/A) PA ManureA Manure Manure Manure
Nutrient Nutrient Nutrien+A pplied Applied Applied Applied
Req'd Applied pplied (acre) (acre) (Field) (Field)
(lbs/A) (lbs/A) (lbs/A)
Source Total Use. Aeriod MethApplic. 1000
Tract Field ID Soil Series Acres Acres Crop R1'L Period N N N Method N gal)A Tons 1000 gals tons
1 4282 1 S7 Norfolk 6.91 6.91 Small Grain Overseed 1.0 Tons 10/1-3/31 90 D O brig. 50 19.97 0;00 138.01 0.00
4282 1 S7 orfolk 6.91 6.91 Hybrid Bermudagrass;Hay 6.5 Tons 311-9/30 *325 0 0 1 Irrig. 325 129.82 0.00 897.05 0.00
4282 4 S7 orfolk 1.12 1.12 Small Grain Overseed 1.0 Tons 10/I-3/31 50 0 0 brig. 5 19.97 0.00 22.37 0.00
4282 4 S7 INorfolk 1.12 1.12 Hybrid Bermudagrass Hay 6.5 Tons 3/1-913.0 *325 0 0 brig. 325 129.82 0.00 145.40 0.00
4282 5 S7 Norfolk 3.82 3.82 Small Grain Overseed 1.0.Tons 10/1-3/31 50 0 0 brig. 50 19.97 0.00 76.29 0.00
4282 5 S7 Norfolk 3.82 3.82 Hybrid Bermudagrass Hay 6.5 Tons 311-9130 *325 0 0 brig. 325 129.82 0.00 495.91 0.00,
4282 6 S7 Norfolk 3.00 3.00 Fescue Pasture 3.5 Tons 8/1-7/31 *130 0 0 Irrig. 130 51.93 0.00 155.78 0.00
i 4282 6A S7 Norfolk 2,49 .2.49 Small Grain Overseed 1.0 Tons 10/1-3/31 50 0 0 Irrig. 50 19.97 0.00 49 J31 0.00
4282 6A S7 Norfolk 2.49 2.49 Hybrid Bermudagrass Pasture 6.5 Tons 3/1-9/30 *240 0 0 Irrig. 240 95.87 0.00 238.71 O.OI
4282 7 S7 Norfolk 3.27 3.27 Fescue Pasture 3.5 Tons 8/1-7l31 *130 0 0 Irrig. 130 51.93 0.00 169.80 009
Total Applied,.1000 gallons 2,389 04
1 Total Produced,1000 gallons 2,298.96
Balance 1000 gallons -90;08
Total Applied,tons 0.00
Total Produced,tons -0.00
Balance,tons 0.00
Notes: 1. In the tract column,-symbol means leased,otherwise,owned. 2. Symbol*means user entered data.
858492 Database Version 3.1 bate Printed.3/12/2009 WUT Page Page 1 of 1

i
The table shown below provides a summary of the crops or rotations included in this plan for each'.field... Reali Yield
are also provided for each crop in the plan. In addition, Leaching Index for each field is shown,where'available. estimates
stic
the L
Planned Crops Summary
Total Useable Leaching
II Tract Field Acres Acres Index(LI)
Soil Series Crop Sequence
4282 1 RYE
— 6.91 6.91 N/A Norfolk -- - -
Small Grain Overseed
1.0 Tons
4282 Hybrid Benn }
4 1.12 1.12 N/A Norfolk udagrass� 6.5 Tons
Small Grain Overseed
_--- —`— 1:0 Tons
4282 Hybrid Bermudagrass Hay =—
5 3. 3•S N/A Norfolk -•— -- 6:5 Tons
Small Grain Overseed
1.0 Tons
4282 6 � 3.00 3.00 NIA Norfolk Hybrid Bcrmudagrass Hay —--— 6.5 Tons
Fescue Pasture
4282 6A _ 2.49 2.49 N/A Norfolk 3.5 Tons
Small Grain Overseed `
,1.0 Tons
Hybrid Bermud
4282 7 s Pasture 6.5 Tons
3.27 3.27 N/A Norfolk
PLAN TOTALS; 20.61 20.61 Fescue Pasture
3.5-Tons
LI Potential Leaching
<2
Low potential to contribute to soluble None Technfcal Guidance
nutrient leaching below the root zone.
x 2& Moderate potential to contribute to soluble Nutrient Management(590)should be planned
<_10 nutrient leaching below the root zone.
High potential to contribute to soluble Nutrient Management(590)should be planned Other
nutrient leaching below the root zone. available water holding conservation practices that improve the soils
>10 g capacity and improve nutrient use efficiency should be considered
Examples are Cover Crops(340)bo scavenge nutrients,Sod-Based Rotations(328),Long-Term
No-Till(778),and edge-of-field practices such as Filter Strips(393)and Riparian Forest Buffers
858492 :•Database Version`3.1 Date Printed 3/I2/2009
NOTE: Symbol*means user entered data. PCS Page page 1 of 1

The Irrigation Application Factors for each field in this plan are shown in the following table,.-Infltratioif iate varies with soils. If
applying waste nutrients through an irrigation system,you must apply at a rate that will not result-,.n runoff-This table provides the
maximum application rate per hour that may be applied to each field selected to receive wastewater: It:ilso lists the maximum
application amount that each field may receive in any one application event.
Irrigation Application Factors
Application Rate Appli cation Amount�
Tract Field Soil Series (inches/hour) (inches)
j 4282 1 Norfolk 0.50 1.0
4282 4 Norfolk 0.50 1.0
4282 5 Norfolk 050 1.0
4282 6 Norfolk 0.50 1.0
4282 6A N'orfolk 0.50 1.0
4282 7 Norfolk 0.50 1.0
858492 Database Version 3.1 Date Printed 3/12/2009 IAF Page Page 1 of 1
NOTE:.Symbol.'means,user_entered data_

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres heeded for sludge
utilization for the indicated accumulation period. These estimates are based on average nitrogen concentrations for each source,
the number of animals in the facility and the plant available nitrogen application rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At clean out,this
material must be utilized for crop production and applied at agronomic rates. In most cases,the priority nutrient is nitrogen but
other nutrients including phosphorous,copper and zinc can also be limiting.. Since nutrient levels are generally very high,
application of sludge must be carefully applied. .
Sites must first be evaluated for their suitability for sludge application. Ideally,effluent spray fields should not be used for
sludge application. If this is not possible,care should be taken not to load effluent application fields with high amounts of
copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water moving to streams and lakes,
phosphorous is a concern. Soils containing very high phosphorous levels may also be a concern.
Lagoon Sludge Nitrogen Utilization Table .
-- Maximum Maximum Sludge - - -� - - -- - -- �- --- - i
Crop PAN Rate Application Rate Minimum Acres Minimum Acres Minimum Acres
lb/ac _ 1000 gal/ac 5 Years Accumulation 10 Years Accumulation j15 Years Accumulation J
Swine)seeder Finish Lagoon Sludge-Standard 1
Corn 120 bu 150 13.16 3,1.09 62.18 _ 93.27
Hay 6 ton R.Y.E. 300 26.32 15.55 31.09 46.64
Soybean 40 bu 160 14.04 29.15 58.29 87.44
Q�Ecefv
'� �ellhr
ke�ztdll�6'���ons S�Q1e
858492 Database Version 3.1 Date Printed: 03-12-2009 Sludge Page Page 1 of

The Available Waste Storage Capacity table provides an estimate of the number of days of storage capacity available
at the end of each month of the plan. Available storage capacity is calculated as the design storage capacity in days
minus the number of days of net storage volume accumulated. The start date is a value entered by the user and is
defined as the date prior to applying nutrients to the first crop in the plan at which storage volume in the lagoon or
holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design storage
capacity of the facility. If the available storage capacity is greater than the design storage capacity,this indicates that
the plan calls for the application of nutrients that have not yet accumulated. If available storage capacity is negative,
the estimated volume of accumulated waste exceeds the design storage volume of the structure. Either of these
situations indicates that the planned application interval in the waste utilization plan is inconsistent with the
structure's temporary storage capacity.
Available Waste Storage Ca aci
Source Name Swine Feeder-Finish L oon Liquid Design Storage Capacity(Days)
Start Date 9/1 180
Plan,Year Month Available Storage Capacity(Days)
755
1 2 58
1 3 78
1 4 92
1 5 105
1 6 129-
1 7 142
1 8 155
1 9 165
1 10 146-
1 11 127
1 12 108
*Available Storage Capacity is calculated as of the end of each month.
858492 Dafahase Version 3.1 Date Printed: 03-12-2009 Capacity Page Page'1 of 1

til
Required Specifications For Animal Waste l0�a ge` n
1. Animal waste shall not reach surface waters of the state by runoff,drift,
manmade conveyances,direct application, or direct discharge during operation
or land application.Any discharge of waste that reaches surface water is
prohibited.
2. .There must be documentation in the design folder that the producer either owns
or has an agreement for use of adequate land on which to properly apply the
waste.If the producer does not own adequate land to properly dispose of the
waste,he/she shall provide evidence of an agreement with a landowner,who is
within a reasonable proximity,allowing him/her the use of the land for waste
application.It is the responsibility of the owner of the waste production facility to
secure an update of the Nutrient Management Plan when there is a change in the
operation,increase in the number of animals,method of application, receiving
crop type,or available land.
3. Animal waste shall be applied to meet,but not exceed,the nitrogen needs for
realistic crop yields based upon soil type,available moisture,historical data,
climatic conditions,and level of management,unless there are regulations that
restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year.
Waste may be applied to land eroding at more than 5 tons per acre per year but
less than 10 tons per acre per year provided grass falter strips are installed where
runoff leaves.the field(see USDA,MRCS Field.Office Technical Guide Standard
393 m Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste application.
Waste should not be applied when there is danger of drift from the land
application field.
6. When_animal waste is to be applied on acres subject to flooding,waste will be soil
incorporated on conventionally tilled cropland.When waste is applied to
conservation tilled crops or grassland,the waste may be broadcast provided the
application does not occur during a season prone to flooding(see "Weather and
Climate in North Carolina" for guidance).
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such
that runoff.does not occur offsite or to surface waters and in a method which does
not cause4rift from the site during application.No ponding should occur in order
to.eontrot-odor°and flies.
.......................------------------_;_--------------------------....._.----------------..........................................................................
858492 Database Version 3.1 Date Printed:3/12/2009 specification.Page 1

g. Animal waste shall not be applied to saturated soils,during rainfall`events,or
when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such.a manner that
the crop is not covered with waste to a depth that would inhibit growth.The
potential for salt damage from animal waste should also be considered.
10. Nutrients from waste shall not be applied in fall or winter for spring planted
crops on soils with a high potential for leaching.Waste/nutrient loading rates on
these soils should be held to a minimum and a suitable winter cover crop-planted
to tale up released nutrients.Waste shall not be applied more than 30 days prior
to planting of the crop or forages breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the
following: The outer perimeter of the land area onto which waste is applied from
a lagoon that is a component of a swine farm shall be at least 50 feet from any
residential property boundary and canal..Animal waste,other than swine waste
from facilities sited on or after October 1, 1995,shall not be applied closer that 25
feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than
those owned by the landowner.
14. Waste shall be applied is a manner not to reach other property and public
right-of-ways.
15. Animal waste shall not be discharged into surface waters,drainageways,or
wetlands by a discharge or by over-spraying. Animal waste may be applied to
prior converted cropland provided the fields have been approved as a land
application site by a "technical specialist". Animal waste shall not be applied on
grassed waterways that discharge directly into water courses,and on other
grassed waterways,waste shall be applied at agronomic gates in a manner that
causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities,showers,toilets,sinks;
etc.,shall not be discharged into the animal waste management system.
: . --------- -
i-------------
ecification_
85$49.2 Database Version 3.1 Date Printed:3/12/2009
Specification Page 2

_ I -
114
I _
�,
I
4
I !
..-
—
-T,
1: I
n �
4-1
Tl
Fl
�I
pp
- 1
:
f
_
I
-
r� I 1 �

�Y
- I
774
Kv
�'i J -
17
wi-
a � _
Ci
_i
T y
i
I 1 �
,

.7-777
lev �K5�.
TIPU
I !. S777
w �
. . t
o
r77 -
- -
-- - 77, N
I
-La
r , —
` _.f.�, +III
_.
i
y _
_L
-
� —
�.
n`-
_ l

t _
I
I
I
-
- °��IP
w - '-S -
I
1
I `
LE LIL
1It - 1---
! f_
f J'T�-
-- r
Ej
I-
LL ......
++yf/T PaG i" yam'
r r Qr►
1
r
II'�tLl! -
_
f
-
r.� ' � --t r� I i I _+• +r f..� -- I I_.1 I I it F •��: �j ..
NTI �1
�=T I -- -
f I
FI I�_,r�_
IIf .i ��Y �i t '� Y� i r �
1 i [
r I
r
I !i 11 �i�f--:-++�'.-.L� llf i ':. � � 1 rl� 1�:.
tI �! 1

i
, I .
r
TM
I w.
I I I
I
'ag !
471
Lu
�l '
J _
-•—'f-"�".L fr �=ice_�`,� - ... �� - JS� -•- _
4.
_ n -
I�
_ - -,� r-
I _ _
7,1
,
T
L
r 1
-
f�
t
C r
ll
H -:4
I i

r
,
49)
!
I I
I :
o lie,
r
I
f
y
, ti
_-
I� ,II
I � 1�O G 9 A Q �• ! � -
, x � ,�
7 iJr /U . r� r -77
J L
Fj
1 - ! EF- +714D9. - -V r 1- r-17
J - 1 --
-t-
Ln
tj
rr t
gl��•i Irx I _ i I ;1'
=— - - —
I Ir J_ ..y'�L� r 'F'jI�-�_ {--17 - L I j , .',; t� — _ F ✓~'
IJ�L�.,
III"' 1 --t l
r I II tI Ti FJu hT J .I
ttt + II + if
l '-I !+I 1�Jf t! iII r7Gf� 1 r� IGi I � I�I!_ Ij
L
r- !r - itJrrlIr I 1j J 1I I j r -I }j
I I !T I!' r -�_
II

1 17 +
14
+
�[ ��1 .r r ? a l+f-� 1 'I J t� t-_.F Jy.- - •-a-�1 --. � 1 r
1
:
..}_- �: — 1 _
•_ - _ F 1 Tf�- -� '..-? I- �1. i' 1�T 1y: *,[� _T ,rIT
1 _
I
F J-
F tip':
x
43
CL
7 1-�•'I f��<. +w_. r, .-'* ^-�..� a� .t I r}:_ - , 7:- -J .1 /�_t=� 1
m ! f .F �� I 'T {1 `T_
r --� r L -ly , d t�i, i _ I + •4 rj u F ��. •-L
_ - i 1 I + -
71
N I _ a J.
oq ram+
t s+� '77 77 `
f t
40
-I ;
_ 7:Tr1
I I I_ ! -1
............—
Ito ,.
77
h i-
-
_
- -...
..w
_ .. .
II •�� _.... .:' .�J _.. .-._I.__.__ ____1. I I . :. ' '. . '. '.. is . .`. •I
I
30;..
'I
I

7S S 1 S
44
s m,'ddl� 4Lo
.5
S J
/3,s 7= S
3�r,o /sA
38,3 yb, 112 11,z i==yrD
'All o�T },8 C ID,�
Om
3yA
41,3
�9 Ail' f ,o,s C= 11,3
i
Itn,�d( IG,S� fp 0,'
n 3 ;3 15,K ,h —JA
i
-.
r_31 g,q4
G I,q
F-'LI,7
I �3�� Fo•3 '
4',3
E
I
po 0
7-9
T,8 m
�fSF� tL
�, •, �. G
i J/�rq
(i t_f�°41.E

I •
f_.
� t
a
I
�i
�-
1-44
X �_ � i - - �:. -� _ -.._ — — — ", is •—r y—r �� —---�— ——- � •—. —
r — — —-- — —-•— —— — — — — ..—
I �.
.r.
le
rl—
J.. LJ�,J I�t___' � —- it .. •� _ _ — "--,_.... �. _ _ ____ _ —
r �r
,
r
i r i� r �� •�-e-il, ,
,
i
I
+
,f ,fir:;,, �I �,`� +, __ '1 '� • �� .,- � �=_ �" -f

t
Elm
_ -
r
t. !
T - 1
Ij
Ll
77-1
— rLi
M1 W -
f•
_
4 l I
n �rrr
-f-•7y.� r f r I t
tj
}-
�•'t)I ;y�{ _ I- +I `{' ---�t ,T`' ..rt�Tj-{ �.[.(��� t-, I- I,L� - _ .�- i 7• +-: ,
Tr�11 -_ F r r- r fI .�F fr L{{-(�{t.
r iT
r
J r
1 I
t._ rrll
,.j
� r

r
i,.
4.11
_ a
t_-' L.' .
r
rI
414
-777
ji
i
I- I
i
I. t'
U
+
rr
_ r 1IlI r` 211-1,�
-7T-r
1 r
-L I f' .-F.: _ ._ ,'�r r - 'i�-� r� r .._ice _±• i.TT_! .� r
r
�_1=.� r! F - I
��_ -
-�,_± 'i,+i1 r!+t-�: I I -i�.1 !r! .. r r 1 F �r� !� ,!:r t - L�`,�+•I:.;- L{' ! 1 --- _ -- --
j_
-=
mow_

-'-
, .. -: _, x,ram. +". _ L:}- .I •..
1
-
r
-
�f-ab i �_ ' � � � I _ j ��� - !- I I I �'' LI] -r-� �• --l� it
_ -
t J- p + 7
i'- f ' {- 'may i1 + .L
J-1
Q Y,V jz j_t I _ `?—�--L•� —U —" P —.—��, --'l�.1,r. I
ir i :-'7:
n 2 " ;. ,F1 �i
,-L-.-
a .1 _• ' J — �1 ' "—'•—'-�—L _—irri,— III •:•� ...L� f..
Y� r `-'�-r'--r�' 7 :. I , - .. , -� r r_� r if_ ttr� T �: �Y_ �t��. � �•_
!
-
r
i
r
F r " t
� �--�y-�{ '''- '~ {L r-� -•-I {�, r i +-L _J i =.tom � �i�. Y
I ;� r�rl i �r �IT'+� ' I -4�i � f f -dy I j � -r- -�' -� '' { ,•f� '
f
f i
1 r7'' 'I _i '.�`'i f 1 f ,11 �r �-+ rT�' ' -• I. - +_ ' f >_
I ' Id-
f
l j j. i i I' r' f ' 1I!l,�r� lr- ,f 4 1J l
I Yf
1. I-

i
17a
i
_ , . ..
f
- I
6, .75
r ! .
- f
+r 1
iLF
`
bi
Tj
1
i 1
f p 11 tM1) ` f "�
r4+ I�`, 'L�` I L � ' �_• -�—ter , r.L
[K 2 n � --• i _ r -
Jy�y I
177
Ir
•_ 77
T kk
i
-------
_J -'
-77
V
I
1 }
r
I �—•-I' !"'*' µr nl �;'--�.I ... ' ----�'-r- _ :.2
77-
61)1
t �! it �I' J rid• i. lri "-"1 1'ir F� _ ;' .
r
�I - J ! r
_ I

:
,
air S� �F t
• ::4
77
a —
t� _ }+ E ,_ 4 I_.�
j 1
L I - 7
�I { IL
ry�: Ttl
f�
' I i
1 1 7{f
11 R /� x"�-Y fr'�.�_r ._ r.; L `;-` TL -r I'� a- lt.. f'- r r ,..I 1 -�7=I•T
JI
I I _ ij LL
{
I
I
7 —
/ I -' II - r l'T LL i1tlr T_
'
rt
�a r.7
r
f f
--?��7tll {�1i1 .:i f :±�: 11jf ~ I � �;`'I I, �: - — _ �1• t� -- — '�
I:T -: .,., r -..:�I �
�'-1

u� ar
Ed
s t
p _�
bb
"d �? ;
Jr i
i _ I
II! l ! I (t
1 it
jr-
�
-I j
f 1 1 '1
z
r--
1'=1 �_L I [ r
r_J
fL I L�
r 1 r
l® � I J
r r*� RI _1_'` r TIC ' r..( 1 �- r I , T-
L J l_-! (`ll
f. J.
+----1
1-1-, r 1 I+ 1
Ej r i` -I
T,
L -
-
r
'---. .: +[ �i.._.;..
_� 1
+-
Ili r � _l r 'ram
t F4--I
F
.,--7._l
'�l
II I
i

Ed King.ESS: PAGE 2
AND SIZE 1240 Topping operation
OPERATION
CLASS 111
DESIGNED BY Johnny Lanier
DATE
2-3-89
APPROVED BY
DATE
PERMAMENT STORAGE �
1240 Hogs x 135 / bs per hog 1 Ft per / b . 167400 Cu Ft
TEMPORARY STORAGE
167400 / bs »fanimal x 1 .35 cu, ft . of waste per day 40678 Cut
p 1
�, 000 / os of animal wt . x 180 days u
RAINFALL LESS EVAPORATION
7" X 46664 sq. ft . surface area per 12"per ft 27221 Cu Ft
RAINFALL - 25 YR. 1 DAY STORM
7.5" X 46664 sq. ft . of surface area per 12" per ft . 29165 Cu Ft
TOTAL STORAGE NEEDED 264464 Cu Ft
9795 Cu Yds
TOTAL STORAGE AVAILABLE 271500 Cu Ft
10056 Cu Yds
AMOUNT OF FILL DIKE 90480 Cu Ft
PAD 100360 Cu Ft
---------
TOTAL 190840 Cu Ft
SETTLEMENT 10% 19084 Cu Ft
---------
TOTAL AMOUNT OF FILL 209924 Cu Ft
CUT TO FILL RATIO T775 Cu Yds
1 ,2: 1 TOTAL EXCAVATION 260000 Cu Ft
9630 Cu Yds

JAME
his OPERA PA GE
N onn
on tvo IS "ON AOn
T i- (S' S
eq-u i
d Lj e
-to SO i
P Ian, fi.and -10 d m n i muly
d i 1 ,et pol water a d e
hod at -
to
0 •
the
% GO
raw , sy,,
Loste ,
water
=POO. I Ion, ,
zrr
and
I prom, satj, .,
fr - 00 Q u Onn i
UM th - a ed
P r End -
IS 1.- 19 he field event gf? ,
Soon. n. - frient
_'r er P ivot- acceptab lo
Shou*ld t Method t P 5 In?
crops o U I S
and to dlYmph S g
Po ' "Wins item v ent
Now alpSIND9
P the Pump_ Carried
Of
7 Wh
,up Pump. - pre n f I U d I
Sep , . out be,.. dete 'two I
at a Wned
ter, C the SISV -
avorable bacpp 1 _- atj,, 'livert..
Sterm ' ned d, 580on pepth .
Th e I... pth. z 5
Od Yhis
"Snds , ts ' an 6 f 9
maximum rec, U amoun.j. /eve, ", th
InVended '. t 0 the loss
it KV
0 WIN
IN vecomw cltiOn Irri sat ,
Cana — a. i o 1-1
`Y totr Ong
-1 f t I- - latpreve - breat,,,, inch - nch,
I jnitiaj 'P Opel nt .. I Per h
Wa t o n F..'. C'S VC U on u
11 e Ochs, 0 do r S hOuld be C,Q, nS th, " ing ul.- is
Pdlic
C-S t or,
keep vemation IV th W.'agoo, jt .1�j
d step a t h P C C C,1-1 ri<7
build . c e 1,tr on of
ail tir,'educil
Re pa InSs mowed' on the embankment and a es .
Th any e"Oded areas and a.r C, t
ut
Ulean o I-,
r a I I rl to Act (�-Ip 11h in
W&Wr�s 0 1 7
a9 t SeCLQS of t h e, Ij proli i
t i 00 arid C,,,,,, ted the
Y has t ate, sch-
h e Y e w S T h
-A C'S P0 r� opmen t. D_1
surface ty
uat fop ast
e and t- Owatet..
Stab / Q be diverted pro. WS this
e outlet.
the /aSoOn to a]i

4AAE.,;
NY
fEAFt'.1' "" A TROGEN AND PHOSPHORUS TOAT WILL BE PRODUCED PER PAGE
41TROGEN (N) 5771 0-S 8 L,
AHOSPNORUs (p, 1683Z-34LES TONS WASTE
:T 21 01QRED
MA TE-D THAT APPDr-
PLE FOR TKAIMATELY 25
USE AS FERr LIZEi:-, OF THE NITR OGEN WILL.
AE FOLLOWING AMOUNT CAN BE APPLIED ON THE LAND
14427- 72 LES,,
F APPL rE-
- =D At T THE RA TE OF
72, 14 ACRES 1 200 LES PER ACRE n-
F APPIIE W LL BE NEEDED rp
AT THE TO TAKE Q.:71
7 ACRES W LL QUO 1 Em, E EFFLUAT""
RATr op
0
BE NEEDED -jo
0 ry
EFORE ANY TAKE CANE
PIE
14 PjALE." - I E:- t L. ..... LMENT.,
ZIU4 is ; -n, ! J THE-
01 NUITP-1p.
::j
ONTAC KING SA 7-tN-r- .1 T
BHO-ULD
IST 0 1 -r . -
N--
Apns -
AGRnMj,I A L."MITE ',--VA /_1 t. tj
n C RERV. - D - BASIS, r
BLUE "ES D I
VTO
910- RIDGE* R-
GH -I R
PHONE'" 9jq.7,j:-`?*i,----,1. 1
HEN APPL VING 265C.;
OVER CROP THE EFALENT T0--
SEEDED OR A .-
ROW C 'UPLAND IT
R ; PLANTED SHOULD nE
OME OF THE EPF
ROWING SEASON..
DRING THE g LUENT COULD BE USED FOR To PREVENT
A C 1 GA TI ON PURPOSE...,
OF LAND AVAILABLE
15AC OF CORN WILL. MCI- FOR APPLICATION OF EPPLUENT
AC OF FES ZE
-50AC CU&­ WILL. LJ'VrLl'--E
OF 8ERMODA WILL U'
T I L 1 0 L B S OF NITI--i-OGEN
PUMPrNG THE EFP 12 j' OF NI-l-ROGE
PLU.J.-D " COLUENT 000 L8S. N
NOT LEVEL REA IES WHEN Bottom of outlet Orz' NY TROG0%i
LOPIE'R Elev. Of 39. pipe
THAN THE FLUID ANY 0
r=r
--PLUENT 2 ft below 7u-----
Elev. Otlet Pipe SHOUL D E'E--:- of 36.
ONTO SUROO - APF
APPPL QED AT A RATE THAT
"I'lENDED UNDING AR AS OR LEACJjYjqCj WILL NOT
mus RE, ICATT N RATE I N CA L-SE ANY
MMENDED ASU Gl-'�'OUI'11D
"LICATj INCHES PER
ON AMOUNT HOUR AND THE
IS INCH PF-R

YAME: Ed k.in8
KEDIN8 SPECIFICATIONS PAGE 5
AREA TO BE SEEDED
3 AC.
APPLY THE FOLLOWING
3000 LBS, 8-8-8 FERTILIZER
6 TONS DOLOMITIC LIMESTONE
/SE THE SEED MIXTURE
300 BALES SMALL GRAIN STRAW
'
NDICATED
'
150 LBS. FESCUE GRASS
'
r ' 105 L8S. OATS
�
( � )
150 LBS, 8AHIA GRASS
( �� ), 12 LDS, WEEPING LOVE GRASS
� )
, 36 L8S. HULLED 8ERMUDA GRASS
( > ^
60 LB8, UNHULLED DERMUDA GRASS
IVERT ALL WATER TO A STABLE OUTLET
HE NEAREST RESIDENCE IS
1500 FT.
'8.M. 50.00 ELEVATION
ESCRIPTION Northeast corner of feed bin
VERY
_IMPORTANT
_-_PLEASE READ CAREFULLY
/E LAGOON AND THE AREA 'R---------------------
ITHER A TEMPORARY OR pE* uUNDTHEHO6 HOUSES MUST BE SEEDED WITH
'`M" FROM"qxT GRASS, DEPENDING ON THE TIME OF THE
�*R' WITHIN THIRTY (30)
-�TED AND READY FOR USE DAYS uMTHE TIME THE BUILDINGS ARE COM
-upES' DRAINS AND ETC, ^ `�ccuMD THAHAT THE LAGOON AREA SID�
-
�EDED WITHIN FIFTEEN ( ^� )A�D�ySELL RE *S MTHE SIDE SLOPES OF THE p �"D BE
�/UDRY OUT AS MUCH IF -~`D " WI A�INTE� CONSTRUCTION. THE SOIL WILL
��� LT IN A MUCH BETTER
-EEAED OF /HRASTHIS TIME FRAME WHICH WILL

NAME: Ad King
PA8E 6
DEPTH [AREA OF TOP + AREA OF BOTTOM + 4 X AREA OF MIDSECTION]
VOLUME = --------- ....................................................
60, 27
DEPTH [ L X W + L X W + 4 X L X W ]
IOLUME = --------- ------~_ ----------__________
27
9.0 [ 140 X 295 + 86 X 241 + 4 X 113 X 268]
/OLUME = --------- ....................................................
6,
, 27
y.0 [ 1831621
/OLUME = --------- --------
6.0 27
274743.0 CU. FT.
'OLUME = ---------
27.0
/OLUME = 10175. 7 CU.YDS.
46664.0 sq . ft ^ ^
266245.0 cu. ft . needed
IDE SLOPES 3: 1

7_J•1
so
• 7 411
r r I
1`rT T ii it t4-
fT
''!! �. ti_ +-'._� «r �r��I'-`r - F f( I�. •ICI-I�: IfI :� I-1 t"�j - _i _• -+'•
�z; itIL
ul
Lil
,-j37
eL
f
I
F'
�A
i
• : - - -
L ,.
•
i
:_.........._._I I
-31
r
LL -- _... -- - -...._. _...... _
Spa P�+-sb 3ta� L S�`a« 0 tsoCa fib
So;
►^n
0- 1 Sm Grh-Sc,
)-a S c 2`3 Ism S L
Olt
5-Co b. c_
6-7 c. 14
G L
I a S rr1 /r_ S C-
f s �, 0U5 , ��.

T'FrCA rIOIV ®r r
' n �� Q UZPI4EIT,
followine (Producer)
b Ilgation
T pE�u'Pment: ' certify that I (own, have ac
ATIp�r AND SIZE
IRRI� cess to) the
/
A t 41 LABLE FRO S
I further cer , .
ti f
will be abl } �ha, throuo (""nCr��r u,
e to il�j to bh the arrana "� Pmcnt)
as necessary arraccangements 1 have m
Signature ding to mY Waste drnanaaeconceme o irrigation u.
nt plan e9 "Pment, I
Producer)
` Date
� Q�
p '°� TCER CE 'TIP
ICA T101V °'p
as outlined . (Pro,du,C
date n e to mY waste m , certif h®vim ��,f�Al
's I excess Of ana�nonths Y that 1
cover o1 small grain6 f neededf r ment plan the date e j the next availables
�[ the Pecifted grasses
Sio for Irrigation. stocl;animals, hn�ding date. 1f t
bnature1, 1 will Provide a ter seeding
mPorary
(P C,!r)
Date

for the�sprp e=ator should tak r
lo�q i A res
been adjusted
with less th noJ60Of the different run F'e4,i
so that�no oveE an deg arcs . These �• times
api3icativn of the effluentnOccurs.times
r� A IRum r,.
too
Wy
,-
360
i •ZZ �= .�-,a 1 •off
in ZZ lr ,80
,f 8= 150 toq
3i9 + J. 320
3.0
y 2r ► 1,- a, o J. o i
•.11`4q
13- 3v0
s aa9 1{= a 40 4 2
Q-ra 1 d V
3b0 j 3
��� � `�-`�-1 19: 3coc � • 3 8
ya\ f 2 L 10= 950 •,P Cl
�, ` / 2— t tc -c,9

- 1 . �� _ ',•:mac `
1 a ✓ s � aQ a
P
TABLE 3 - Solid Set irrigation Cup Settings V LP 9 i �e o
ao b Umrrn-3
;'lrtnke, Mode! a�cl Type Of EgoiPtnent; ~_
T' l L-r
l;'Icld Not Q-7� u n �
Weekd
aria Nwaher or Nydrsnl SPealn . I OPERATING P W)
l.Ie�e nod ale rter' i{ ApPllrailon METAIL,
ii rants /ecl �'$!° between Rate Nowt operatin
C - L ► 1 I a PI s!!►tss INt,r Diameter >?reosure �°e►�ttrta
�hes Time
C-l 5 1 4 c 1 ,4 O , ; Gun r! H drsnt
C-l '4 So I, t3 �Oliltlpth4s
r C L,-4 ? wee Clear j' :
rur% 4srncS
C t-5 + 5n
^C', - �rr
I �
f B ,
l cl 1
L 1
live
}f
LU 1
i
i See allsdied map.
23howscp*n4eentries- - for earn Pipeline .
with hY�ats in eado Teld.
�e �iq Sri n tS
� � _" ;,n.; ' . . �P r �fYY'C'•�t r ,C3 �`�( Gi�y O �Ory ,
NRCS„ NL'

io
Client. Ed King Farts
Farm; King Farm
Field: Field C North Car,olula
1--'yrr-: Field Boundary
1 3.7 0 Acres
n �
Main Line End t or
0 +
tAr
N
We
[]C Q C r` ARC Aa`riL r - — `—
. ..� :� � f �,b - ._....�.9 _.. At4E � A.R�A►VC.�d, E f3i�n� ��nnE
L4 ISO
qyR 36Q
�• � 9
iv as l 1 ) 1 a�u t .oy
4.9 as a. � P`f
13 as I3�
a.aq
1'nklix`ed 49 Top Soii jk iaiau de c C7 y u
�b� •��� i � uo f .9 a
9 � '�• � I f�v !
ton
I a�f

5O.A.J
I recision
Ed Knig Varn,
Farin: King Farm NorLh Carolina
Field: Field D
Layer- Field Boundary
1 .49 Acres
Field
13
1.49
Aerns
Woods
NOTE: Field B
field A. sprayed an Using the same means as on
1 . 49 ac X . 75 = 1 . 12 Total Eff, Acres
PrWueod by Top ,;nil I IvoH rnt
Ag

E'•cs sox eo
A"wmerr B$pI&M al'R%W,
Ittr BORCL N012m G7kOr_MA S7Bbe

r
o
Ag
Ch"L: Ed K.irig Fax t r,
Fa.rrrz Kitt; Farl1'1
Field: Field A North Carolin,,
Layer, Field Bou rides-y
.G y Acme;
i
i
I-
f
i
,l T°field A
I �
5-0 9
Acros
1
_ I
NOTE: Fied A will be sub_cnnt.racted out by the grower, to be
comercially sprayed, ( sub-contractor must be held to same
standards as laid out in WUP) Approx. 75% of the total acres
in field A can be accounted for.
5. 09 ac X . 75 w 3 . 82 Total Eff_ Acres
Prudllocd by top tinii Precielnrr, AC

Source SW11VE FARIVj WASTE
Farmstead Ca Use MA
�w'nepr°d � BGE�E�I T CONTROL NTROL
MP'S to M. 'Mize odor CHRCKC/$T
( j9etetiv r
Animal body surfaces ( ecomrnOnde W°pded buffers; Site Specific Pr
Floor surface, Dirty r"antire P ctices� d best rnanag0rr)ent
We -covered animals -�Ood judgment
1 manure cOvared floors - (�l!DrY floors and eornmOn sense
(trotted floor';
r"waterers
Manure collection pits ((! Feeders atlh Be over slotted floors;
Urine �1 gape manur end of solid floor
( darfl a buildup fro ors:
Ve 1, oOr ventilation m floors.
ntilatio aritaf rnicorbial O" equent for drying
n exhaust fans decomposition
Indoor �Usatile Bases; _ �� (lea�9e,or sc apre M-an'llre e emoval by flush,plt
surfaces t oOr ventilation
( r
Dust an r aintenanc e;
a!r
( movernenr
wn
nY
Flush tanks ((JIFe ed add-ves?tWean groups of animal
eder covers; s
(i Feed deliver
Agitation C) rec
liquid While kcfed lag°On feeder covers downspout
e
xtenders to
Flush alleys s tanks are f%.,ling (1 Flush tank
(!Extend covers
Pit rechargeonvetlOn dUrin9 Wastev, tanks IV, h 1lnes to near botto `-�
Aolnts Yanance ateranti-siphon vents m of -
Lift lA9ltation of recycled nderfloor flush With u l�
stations quid While lagoon ventilation nderf!°Or
Pits are filling
Agitation during () Extend rechard G
Dutsid and draWdOWn B surhp to Pits With t a
nk filling anti-s•lines one r bottom Of
orlunc i drain collection
(J Su tPhon vents tron boxes Agitation d rnP tank End c
tinn9 Waste °refs of drainpi)as
a cOnveYance Water
P s at lagOOn Agitation during (J Box covers
�agOpn surf Wastelvater
aces
4 Volatile (1 Extend discharge
Bio 9!O gas emissions underneath point of pip
Pes
al mixing ( lagoon liquid!ev Agitation ro el
( er leg
OOn liquid
( %tract lagoon'tart,capaCitY -
u'lVJp.Proced ~~
mun�surface are tires
n9ation sprinkler ( mimu a-to-
noz2les High pressure a i -� ((1( Chan a!a'eaatanWhen PumA^gratin
Wind draft agitation ( [oven biological addltives
�ri9ca O
y�lyy n dry
:D...lVovember 11, 799g �� ,_/'mrmum r�0pmrnendda olltife Or no Wina-��-
(�1 Fu P intake peration
() P near la Pressure
amp frorn
s age la so!hsurface

Storage tank or basin Partial microbial decomposition () Bottom or midlevel loading
surface Mixing while filling () Tank covers
Agitation when emptying { ) Basin surface mats of solids
(} Proven biological additives or oxidants
Settling basin surface Partial micobial decomposition () Extend drainpipe outlets underneath liquid
Mixing while filling level
Agitation when emptying () Remove settled solids regularly
Manure, slurry or sludge Agitation when spreading Soi injection of slurry/sludges -
spreader outlets Volatile gas emissions ( ash residual manure from spreader after use
( ) Proven biological additives or oxidants
Uncovered manure, slurry Volatile gas emissions while drying ( S�nfection of slurry/sludges
or sludge on field surfaces (}�S it incorporation within 48 hours
( . pread in thin uniform layers for rapid drying
() Prov n biological additive�ro dants
Dead animals Carcass decomposition
_ ( roper disposition of carcasses -
Dead animal disposal Carcass decomposition ( ) Complete covering of carcasses in burial pits
pits
() Proper location/constr4ction of disposal pits
Incinerators Incomplete combustion, () Secondary stack burners - — - -
Standing water around Improper drainage — — — —
( rade and landscape such that water drains
facilities Microbial decomposition of
p away from facilities
organic matter'.
Manure tracked onto public Poorly maintained access roads — — —
( Farm access road maintenance
roads from farm access
Additional Information:
Available From;
Swine Manure Management;0200 Rule/BMP Packet —
Swine Production Farm Potential Odor Sources and Remedies, EBAE Fact Sheet NCSU-County Extension Center
Swine Production Facility Manure Management: Pit Recharge--Lagoon Treatment; EBAE 128-88 NCSU-BAE
Swine Production Facility Manure Management: Underfloor Fluse--Lagoon Treatment; EBAE 129-88 NCSU-BAE
Lagoon Desig and Managemert for.Livestock Manure Treatment and Storage; EBAE 103-83 NCSU-BAE
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet NCSU-BAE
Controlling Odors from Swine Buildings;PIH-33 NCSU BAE
Environmental Assuranc Program: NPPC Manual NCSU-Swine Extension
Options for Managing Odor;a report from the Swine Odor Task Force NC Pork Produces Assoc
NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedin s
9 Florida Cooperative Extension
The issues checked ( pertain
p to this operation. The landowner/integrator agrees to use sound judgment in applying
odor control measures as practical.
I certify the aforementioned odor control Best Managment Practices have been reviewed with me.
(Landowner 5ignatur )
AMOC--November 11, 1996

INSECT CON7--R� CHEC
Source L
Cause KLIST FpR ANIMA
C OPERA
T/ONS
Flush Gutters BMP� -
s to Mrnurnt2e Odor~�---- -
Accumulation Of solids (Liquid S - ---
ystems) Site S
("Flush s Pecific Pract
"stem is __ _
sufficie designed and ntly to remove acc operated
La soiid from gutters ted
Crested Solids Umul
s and Pits
s as designed,
discharge
emove bridging of accumulated solids at
goon
( aintain la
Pits where goons' settling-----
Pits
Pest bre 9 basins and-------
min;mi ading is apparent
Excessive Vegetative ze the
Growth to
Decaying vegetation
egeta ' of no
more than 6crust�8g•of solids to a depth
tion 30 of surface. inches over more than
f nllaintain Vegetative
t lagoons and°jh control along banks
°f accumulati er impoundments
on of �
Feeders along water's decay;ng vegetati to Prevent
d
Feed Spillry Systems) ge °n impoundment s pa
Pillage (Dejmeter.
() Design, °Aerate
bunkers and troughs)
maintain feed systems
u
Feed Storage Accu (1 Clean UP spilaast 8e)to minimize the ac umulae.9ion �~
e on a
mutations of feed residues mterva!during eUmme routine basis (e.g. �_
15-30 10 day
() Reduce mots day interval t- acc during winter).
immediate part Umulatio
meter of n wtthtn and arou
insuring drat feed storage nd
adequate ge away from site ge areas by
ode na
brewer
re Wer,s containment(e g., and/or providing
grain and simil covered bin for
Animal Holding products), ar high inois g Areas f 1!ns ture grain
Ps it for and rernoVe or break
Accumulatio solid
and feed wastage ar"met wastes () Eli s to filter strips around feed up accumulated
mina that Stor d.
Ye low area age as needed.
and t trap rrtolstur
Other locations Where
a along fences
and disturbance b Waste
() Maintain y ant accumulates and
� fence rO mats is minimal.
(heldin Aectg areas to Minimize a'�su strips around animal
- solios as needed)for nd rnulations of wastes
move or break up accumulated
---1Jovember 1 j 1996

Dry Manure Handling Accumulations of animal wastes ( I Remove spillage on a routine basis (e.g. 7-10 day
Systems interval during summer; 1 5-30 days interval during
winter) where manure is loaded for land applicatipn
or disposal.
( ) Provide for adequate drainage around manure stockpiles.
( ) Inspect for and remove or break up accumulated wastes
in filter stripes around stockpiles and manure handling
areas as needed.
The issues checked ( ertain to this operation. The landowner/integrator agrees to use sound judgment in applying
insect control measures as practical.
I certify the aforementioned insect control Best Management Practices have been reviewed with me.
(Landowner S gn ture)
1
(Farm ame)
— �J
(Facility Number)
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University, Raleigh, NC
27695-7613.
AMIC--November 11, 1996

la
ApoProper
to m liquid man ®p047'I®V`g 41
Periods. manage leyejs�o had should be a A�T��C�pLA
h'laxi You do not haveUndprio N
mum storage
extnded rC OA s o macity should e PrOblerns du�Y• It is especial
that at to nt spells Sant such as e available . g extended rally and
a farm waste signs of Lichas the th wintertime rn the 1a
perreciods
lagon anagemeP ant grotivth 1 derstorr for bermuda°n for periods
ods quid plan n the easort in grass) or when th
m In the This Should be later wrote the sum when there e
maa?'ker(see P. late Summer/ ill make ste done w r/e l ntertlme are
ntQlthe gore 2_ earl rages henever they'Piing, i This
utilization PI lagoon clos to allowY fall the land i �gation Means
Phan will e to the for teragopace u1 ailab �th� dr u accord'ng to
W allow mini win stor n shO d Eve e le in la Y enO gh to
Overte d nt tithe lagoon hot leave it mum liquid eve as to effolP�o own°o the 1 tore ow we
ld be
state a and m he goo orn fo reached its maxim long as the weather na e to
The routine m SubJe�t to P nal t or Y actlo°n excel Water dulin capacity e f and waste
arntenan n. A a 25_ g extend ore starti
Maien ce Of a lagoon
involy year, 24_hou S e peo'rm is a od g to
Cove
eue nance of a v es the follow. violation of
covers• Th Ammon ertative cover following:
maintain a v vegetatiom'dagrass for the da
hoUld
hsOjbaselds t sta ff soils test Stand Thy a rtil z each v
test be fe ch Year, rn the event°unt of fe Year, if Vegetative
el uivalent. rtilized with 8 goou eMank it is not ia W i0d Id
donesband tree,on th ndsPeracre oMent f l01 p°endingobtain
mo g, s e e ank I0, or areas
se Prat
these win m6
Possibly tices. Th ice i - Ying shl , grazient must be
lVCl'E• If heavy egtrve rears hat wbe done at Ipprngootrolled' s m
the ve growth. eathe Est comb na aY be
the waste water�a such controlled b h r condr�on°are f Vear matron of
and
the , chemicals c old h�mg, the erbi orable for
check Sho nd at leaStnS °f the enb the bacteria nth la not be allowed e lag InsPectio
old include, as nthly and aftleagnng
°a should be goon that are t e$0 enter
Iwaste Inlet pi mum' the follow nfall Made So wring the initial
2 SeParatio soReeYclin g. m events. Ite llinbg o f
4' Craaccurns la eaksnts g pipes, and flo ms to
br, ®ver
overall clond tiof salts or w Pipes_'`look for:
of pipes Minerals
AIAR Z o 2819
`V
bons S�'o �
q

• Lagoon surface---look for:
1• undesirable vegetative growth
2. floating or lodged debris
Embankment---look for:
1. settlement, cracking, or "jug" holes
2. side slope stability---slumps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the lagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the darn. If your lagoon has
any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a threat
of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy
undertaking with potentially serious consequences and should notlbe conductedr unless
recommended by an appropriate technical expert.
• Transfer Pumps---check for proper operation of.
1• recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise., or a large amount of vibration, may indicate that the pump.is in need or repair
replacement. . p or
NOTE: Pumping systems should be inspected and operated frequently
are not.completely "surprised" b ure. y enough so that you
system maintenance at a time when equipment
r lagoon is at its ow le el.YOU should his w your pumping
safety time should major repairs be required. Having a nearly full lagoon is not the time
to think about switching, repairingll allow some
Your neighbor's lagoon is full als or
uohould consider maintainins. Probably,g
if your lagoon is full,
Parts or pumps. taming an inventory of spare
• Surface water diversion features are designed to carry all surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parking lot runoff) away from your lagoon and other waste
treatment or storage structures. The only water that should be
coming from your lagoon is that which conies from your flushing
(washing) system pipes and the rainfall that hits the lagoon directly.
You should inspect your diversion system for the following:
1• adequate vegetation
2. diversion capacity
3• ridge berm height

Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should helpin
planning irrigation applications and storage. If your lagoon rises excessively, you ma
have an inflow problem from a surface water diversion or there may be seepage into the
lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before
waste loading begins, taking care not to erode lining or bank slopes.
3. Drainpipes into the lagoon should have a flexible pipe extender on the
end of the pipe to discharge near the bottom of the lagoon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining.
4• When possible, begin loading new lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon
liquid volume.. This seeding should occour at least two weeks prior to the
addition of wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below
7.0, add agricultural lime at the rate of 1 pound per 1000 cubic feet of
lagoon liquid volume until the pH rises above 7.0. Optimum lagoon liquid
PH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate
biological activity. Consultation with a technical specialist is recommended
if these conditions occur for prolonged periods, especially during the warm
season.
Loading:
The more frequently and regularly that wastewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily are
Optimum for treatment. Pit recharge systems, in which one or more buildings are drained
and recharged each day, also work well.

Practice water conservation---minimize building water usage and
spillage from leaking waterers, broken pipes and washdown through
proper maintenance and water conservation.
Minimize feed wastage and spillage by keeping feeders adjusted. This
will reduce the amount of solids entering the lagoon
Management:
Maintain lagoon liquid level between the permanent storage level and
the full temporary storage level.
Place visible markers or stakes on the lagoon bank to show the
minimum liquid level and the maximum liquid lever (Figure 2-1).
• Start irrigating at the eaciiest possible date in the spring based on
nutrient requirements and soil moisture so that temporary storage
will be maximized for the summer thunderstorm season. Similarly,
irrigate in the late summer/early fall to provide maximum lagoon
storage for the winter,
The lagoon liquid level should never be closer than 1 foot to the lowest
point of the dam or embankment.
Do not pump the lagoon liquid level lower that the permanent storage
level unless you are removing sludge.
Locate float pump intakes approximately 18 inches underneath the liquid
surface and as far away from the drainpipe inlets as possible.
Prevent additions of bedding materials, long-stemmed forage or vegetation,
molded feed,.plastic syringes, or other foreign materials into the lagoon.
Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed.
Maintain strict vegetation, rodent, and varmint control near lagoon edges.
Do not allow trees or large bushes to grow on lagoon dam or embankment.
Remove sludge from the lagoon either when the sludge storage capacity is
full or before it fills 50 percent of the permanent storage volume.
If animal production is to be terminated, the owner is responsible for
obtaining and implementing a closure plan to eliminate the possibility of a
pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:

proper lagoon sizing,
mechanical solids separation of flushed waste,
gravity settling of flushed waste solids in an appropriately designed basin, or
minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long term will.
have more nutrients,
have more odor, and
require more land to properly use the nutrients.
Removal techniques:
Hire a custom applicator.
Mix the sludge and lagoon liquid with a chopper-agitator impeller
pump through large-bore sprinkler irrigation system onto nearby cropland;
and soil incorporate.
` Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; mix remaining sludge; pump into liquid sludge applicator; haul
and spread onto cropland or forageland; and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; dredge sludge from lagoon with dragline or sludge barge; berm
an area beside lagoon to receive the sludge so that liquids can drain back
into lagoon; allow sludge to dewater; haul and spread with manure spreader
onto cropland or forageland; and soil incorporate.
Regardless of the method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that field and crop
requirement. Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage. Close
attention by the pumper or drag-line operator will ensure.that the lagoon liner remains
intact. If you see soil material or the synthetic liner material being disturbed, you should
stop the activity-immediately and not resume until you are sure that the sludge can be
removed without liner injury. If the liner is damaged it must be repaired as soon as
possible.
Sludge removed from the lagoon has a much higher phosphorus and heavy metal content
than liquid. Because of this it should probably be applied to land with low phosphorus
and metal levels, as indicated by a soil test, and incorporated to reduce the chance of
erosion. Note that if the sludge is applied to fields with very high soil-test phosphores, it
should be applied only at rates equal to the crop removal of phosphorus. As with other
wastes, always have your lagoon sludge analyzed for its nutrient value.
The application of sludge will increase the amount of odor of the waste application site.
Extra precaution should be used to observe the wind direction and other conditions which
could increase the concern of neighbors.

Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned discharge of wastewater from the structure. Types
of failures include leakage through the bottom or sides, overtopping, and breach of the
dam. Assuming proper design and construction, the owner has the responsibility for
ensuring structure safety. Items which may lead to lagoon failures include:
Modification of the lagoon structure---an example is the placement of a pipe
in the dam without proper design and construction. (Consult an expert in
lagoon design before placing any pipes in dams.)
Lagoon liquid levels---high levels are a safety risk.
Failure to inspect and maintain the dam.
Excess surface water flowing into the lagoon.
Liner integrity---protect from inlet pipe scouring, damage during sludge
removal, or rupture from lowering lagoon liquid level below groundwater
table.
NOTE: If lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the dam. Once this damage starts, it can quickly cause a large discharge
of wastewater and possible dam failure.

EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ) [phone]
EMERGENCY MANAGEMNET SERVICES (EMS) [phone]
SOIL AND WATER CONSERVATION DISTRICT (SWCD) [phone]
NATURAL RESOURCES CONSERVATION SERVICE (MRCS) [phone]
COOPERATIVE EXTERSION SERVICE (CES) [phone]
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters
or leave you property to consider that you have a problem. You should make every
effort to ensure that this does not happen. This plan should be posted in an accessible
location for all employees at the facility. The following are some action items you should
take.
1 . Stop the release of wastes. Depending on the situation, this may ore may not be
possible. Suggested responses to some possible problems are listed belwo
A. Lagoon overflow-possible solutions are:
a. Add soil to berm to increase elevation of dam. <
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field-actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that cause the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers-action include:
a. Stop recycle pump.
b. Stop irrigation pump.
G. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators-action include.
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed
to flowing leaks-possible action:
a. Dig a small sump or ditch from the embankment to catch all
seepage, put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone - -. After
hours, emergency number: 919-733-3942. Your phone call should include: your
name, facility number, telephone number, the details of the incident from item 2
above, the exact location of the facility, the location or direction of movement of
the spill, weather and wind conditions. The corrective measures that have been
under taken, and the seriousness of the sitution.
b. If spill leaves property or enters surface waters, call local EMS phone number.
c. Instruct EMS to contact local Helath Department.
d. Contact CEs, phone number - , local SWCD office phone number - -, and local
NRCS office for advice/technical assistance phone number - -.
4 If none of the above works call 911 or the Sheriff's Department and explain you
problem to them and ask the person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair or problem to minimize off-
site damage.
a. Contractors Name: Pre- e 5
b. Contractors Address: ; n
c. Contractors Phone:
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting
Engineer, etc.)
a. Name: �-
b. Phone: Qi�,
7. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste managment plan to
keep problems with release of wastes from happening again.
2