310213_Permit Renewal Application 2019_20190410

EECalgOlICZENDWE
State of North Carolina
Department of Environmental Quality APR O5 2019
Division of Water Resources
Wate O
Animal Waste Management Systems R6007301Opci5ufi10SBettr+i1
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 31-0213 Certificate Of Coverage Number: AWS310213
2. Facility Name: 2 deo t h 6_, rkwr,' (.1 1 U m.s
3. Landowner's Name (same as on the Waste ManagementPlan): pew&Smith Ca c)
4. Landowner's Mailing Address: 42Q-Box-68--- 1 /P j3 UX , 1.
City: - t ey-- G f i lei -f v State: NC Zip: 211513.4008 2. 3.2, 7
Telephone Number: 919-533-3184 Ext. E-mail:
ta 4'-99a7i1 7
5. Facility's Physical Address: 256 Glacces Manning Ln
City: Warsaw State: NC Zip: 28398
6. County where Facility is located: Duplin
7. Farm Manager's Name (if different from Landowner): ®Ski` •••—° -- L..OPw _5
8. Farm Manager's telephone number (include area code): - - CO 0 G C1 0 - Z U-7 -7
9. Integrator's Name (if there is not an Integrator, write "None"): Pr.-S . 1-;-1 °1"-S
10. Operator Name (OIC): i r• ,_To S L 0.- Phone No.: OIC #: 1i84949-'
C00"16s 5"'4"60-7P77 111'9Al)
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit:
Operations Type Allowable Count
Swine - Wean to Feeder 6,400
Operation Types:
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
J
#1
#2
Estimated
Date
Built
2/1/1993
r� 4/ ?
Liner Type
(Clay, Synthetic,
Unknown)
c Lit
Capacity
(Cubic Feet)
/.:(700
/f'x. 7)
ti
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
J"-6a
19.50
—2
y
y (s'7j
19.50
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), sinned bl the owner and a certified technical specialist. containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
S. Operation and Maintenance Plan
completed and signed application
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a prince al executive officer of the corporation):
Title: (%G✓ftA.
Name:
Signature:
�.s. � Date: —/�r-79
--
Name: Title:
Signature: Date:
Name: _ Title:
Signature: _ _ Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER
Cavalier
MICHAEL S. REGAN
&we ary
LINDA CULPEPPER
Director
Perry E Smith
Long Haul Farms Site #1 & 2
PO Box 68
Turkey, NC 28393-0068
NORTH CAROLINA
Environmental Quality
Subject: — Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
February 27, 2019
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https://deq.nc.gov/about/divisions/water-resources/water-quality -regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non -Discharge General Permits. you must submit an application for
permit coverage to the Division. Enclosed you will fmd a "Request for Certificate of Coverage Facility Currently Covered by an
Expiring State Non -Discharge General Permit." The application form must be completed. signed and returned by April 3, 2019.
Please note that ■ou must include one (1) copv of the Certified Animal Waste Manaeement Plan CAWMPI with the
completed and signed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Wilmington Regional Office, Water Quality Regional Operations Section
Duplin County Soil and Water Conservation District
AFOG Section Central Files - AWS310213
Maxwell Foods Inc
North Carolina Department aF En vironment& Quality I (*Az': - : ` s:=_ E _:.:f :
512N.Salisbury St.J 1636Mail ServsneCenter I Raieigt'.`.:.: _e": eZ'c,3•:.334
919.707 9000

Li
Operation Description:
Type of Swine No. of Animals
• Wean to Feeder 6404)
❑ Wean to Finish
❑ Feeder to Finish
❑ Farrow to Wean
❑ Farrow to Feeder
❑ Farrow to Finish
Notification of Change of Ownership
Animal Waste Management Facility
(Please type or print all information that does not require a signature)
In accordance with the requirements of 15A NCAC 2T .1304(c) and 15A NCAC 2T .1305(d) this form is o ffcation
Ewa`
to the Division of Water Resources (DWR) of the transfer of ownership of an Animal Waste Marageme i i his
form must be submitted to DWR no later than 60 days following the transfer of ownership.
General Information:
Previous Name of Farm: x J+o /%19cc./44r1
Previous Owner(s) Name: x onr cov, %iF Phone No: X «O'$ 3 7
New Owner(s) Name: JosH JA COOw,.B5 Phone No: 9IO-9so- 7077
New Farm Name (if applicable): 0041 L.►
Mailing Address: P O LC (012 C L i w To,l
AA
NC
Facility No:x3 1 - /3
Farm Location: Latitude and Longitude: 34' 58 ' Z9"/ 78
(o Z 7 County: b V Pt.i 4
Please attach a copy of a county road map with location identified, and provide the location address and driving directions
be ow (Be specific: road names, directions, milepost, etc.):
Or 1 r J P" S S
Type of Swine
❑ Gilts
❑ Boars
No. of Animals
Other Type of Livestock: Number of Animals:
Acreage Available for Application: AC:7 y Required Acreage: 7 9 L7`
a.k•
.A. / /ATV
r
Type of Cattle No. of Animals
❑ Dairy
❑ Beef
Type of Poultry No. of Animals
❑ Layer
❑ Pullets
Number of Lagoons / Storage Ponds:_ Total Capacity: 3/ 4/9 Cubic Feet (ft3)
**************************************************************(*********************
Owner / Manager Agreement
I (we) verify that all the above information is correct and will be updated upon changing. I (we) understand the operation and
maintenance procedures established in the Certified Animal Waste Management Plan (CAWMP) for the farm named above
and will implement these procedures. I (we) know that any modification or expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a permit modification before the new
animals are stocked. I (we) understand that there must be no discharge of animal waste from the storage or application
system to surface waters of the state either directly through a man-made conveyance or from a storm event less severe than
the 25-year, 24-hour storm and there must not be run-off from the application of animal waste. I (we) understand that this
facility may be covered by a State Non -Discharge Permit or a NPDES Permit and completion of this form authorizes the
Division of Water Resources to issue the required permit to the new land owner.
Name of Previous Land Owner: PRiNY Zkiii,rx ,f y,< Xe
Signature:
Name of New Land Owner: x
Signature:_ x
Name of Manager (if different from owner):
Signature:
Please sign and return this form to:
Date: A ,J - / 9- /
Date: A 3/121 ?
Date:
Animal Feeding Operations
N. C. Division of Water Resources
Water Quality Regional Operations Section
1636 Mail Service Center
Raleigh, NC 27699-1636
June 12, 2015

Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
❑o
El El
An
El El
El El
El El
Version —November 26, 2018
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opiniorof the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must bedone in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
2
Signature of Farm Owner/Manager
nr ure of Technical Specialist
31/C`i/q
Date
5 42� /r
to

3/20/2019 256 Glacces Manning Lane Warsaw NC - Google Maps
Go gle Maps 256 Glacces Manning Lane Warsaw NC
Google
Imagery ©2019 Google, Map data ©2019 Google 1000 ft
r
9 Villan Foo
I -1
Ca ill.,F.re:h Meats
Toya Things
https://www.google.com/maps/search/256+Glacces+Manning+Lane+Warsaw+NC/@34.9789832,-78.104673,2250m/data=!3m 1 ! 1 e3 1 /1

WASTE UTILIZATION PLAN
Goldsboro Hog Farms, Inc.
. Monday, March 29,1999
if- -2`c 9
Producer :
Farm Name :
Telephone # :
Type of Operation :
Number of Animals :
Application Method:
Perry E. Smith, Jr.
Long Haul Farms
P.O. Box 68
Turkey,NC 28393
[phone]
Wean to Feeder Swine
6400 pigs design capacity
Irrigation
'
6, e9 e..-ks L1J -
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the fields where
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
contents of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and avaialable water holding capacities. Normally waste shall not be applied to
land eroding at greater than 5 tons per acre per year. With special pre -cautions, waste may
be applied to land eroding at up to 10 tons per acre per year. Do not apply waste on
saturated soils, when it is raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To
maximize the value of the nutrients for crop production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied to bare ground not more
than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems. This plan is based on waste application through irrigation for this is
the manner in which you have chosen to apply your waste. If you choose to inject the waste
in the future, you need to revise this plan. Nutrient levels for injecting waste and irrigating
waste are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananlysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1

AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
6400 pigs X 0.4 tons waste/pigs/year = 2560 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
6400 pigs X 0.48 Ibs PAN/pigs/year = 3072 PAN/year
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type and suface application.
TABLE 1 : ACRES OWNED BY PRODUCER
TRACT FIELD SOIL TYPE &CLASS- CROP YIELD 135'7A'COMM ACRES, LBS AW APPLIC.
DETERMINING PHASE CODE 1 N/ACR_ NACRE USED TIME
1 1645
1
*
10A
AUTRYVILLE ALL
SB
25
I 0� 1
110
APR-SEP 15
1645
*
10A
AUTRYVILLE ALL
W
35
_134)
01 1.1
92.4
PPR-SEP?5
1645
*
*
10A
AUTRYVILLE ALL
C
75
93 75
01 1.1
103.125
MAR-JUN
1645
10B
AUTRYVILLE ALL
SB
25
,100i
01
0 61
0.81
61
APR-SEP 15
1645
*
*
10B
AUTRYVILLE ALL
W
35
64
0'
51.24
APR-SEP15
1645
10B
AUTRYVILLE ALL
C
75
93,75�
01
0.61
s 1.1
;1 1
57.1875
MAR-JUN
1645 *
11
AUTRYVILLE ALL
SB
25
-too
841
0
110
APR-SEP 15
APR-SEP15
MAR-JUN
1645 *
11
AUTRYVILLE ALL
W
35
_ 0
0'
92.4
1645
i*
11
AUTRYVILLE ALL
C
751
93.75
" 1.1
0 92
103.125
1645
*
12
AUTRYVILLE ALL
SB
25
't00i
01
92
APR-SEP 15
1645 1*
12
AUTRYVILLE ALL
W
35
' 1'84
0
a92
77.28
APR-SEP15
1645 *
12
AUTRYVILLE ALL
C
75
9375
0
0.92
86.25
MAR-JUN
1645 *
13
AUTRYVILLE ALL
SB
25
100' 01
0.83
'0.83
83
APR-SEP 15
1645
*
13
AUTRYVILLE ALL
W
35
. ;844 01
69.72
APR-SEP15_
MAR-JUN
1645
*
13
AUTRYVILLE ALL
C
75
93,51 0 0.83
77.8125
1644
2A
AUTRYVILLE ALL
BH
5.5
' y275
0 0.92
253
MAR-SEP
1644
-
2A
AUTRYVILLE ALL
SG
1
50
0 0,92
46
SEP-MAR
1644
2B
AUTRYVILLE ALL
BH
5.5
275
0 • „1i.1
302.5
MAR-SEP
1644
-
2B
AUTRYVILLE ALL
SG
1
5,01
2751
0
0
1.1
55
SEP-MAR
1644
3A
AUTRYVILLE ALL
BH
5.51
1
1.01
277.75
MAR-SEP
1644
-
3A
AUTRYVILLE ALL
SG
BH
501
275I
0
101
50.5
SEP-MAR
1644
3B
AUTRYVILLE ALL
5.5
0
1.01
277.75
MAR-SEP
1644
-
3B
AUTRYVILLE ALL
SG 1 .5p
01
Y 1.01
50.5
SEP-MAR
1644
4A
AUTRYVILLE ALL
BH
5.5 2751
0
0
z1.1
1.1
302.5
MAR-SEP
1644
-
4A
AUTRYVILLE ALL
SG
1' •50
55
SEP-MAR
1644
4B
AUTRYVILLE ALL
BH
5.51 275
0
; 092
253
MAR-SEP
1644
-
4B
AUTRYVILLE ALL
SG
11 50
0
0.92
. 0.73
46
SEP-MAR
1644
5
AUTRYVILLE ALL
BH
5.5
275
0
20075
MAR-SEP
1644
..
5
AUTRYVILLE ALL
SG
1
:5Q
0
0.73
36.5
SEP-MAR
1644
6
AUTRYVILLE ALL
BH
5.5
2, 5
0
0.37
101.75
MAR-SEP
1644
-
6
AUTRYVILLE ALL
SG
1
50
0•
..0.37
18.5''
SEP-MAR
1644
7 1AUTRYVILLE
7
ALL
BH
5.5
275
0
1 1
302.5
MAR-SEP
1644
-
AUTRYVILLE ALL
SG
1
50
0
1.1
55
SEP-MAR
1645
*
*
8A jAUTRYVILLE
8A
ALL
SB
25
100
0
1.1
�110
APR-SEP 15
1645
AUTRYVILLE ALL
W
35
84
0' 1.1
92.4
APR-SEP15
1645 *
8A
AUTRYVILLE ALL
C
75
93.75
0 1:11
103.125
MAR-JUN
1645
*
8B
8B [AUTRYVILLE
8B
AUTRYVILLE ALL
SB
25
100
0 0.37
37
APR-SEP 15
1645
ALL
W
35
j84
0
037
0.37
31.08
APR-SEP15
1645
UTRYVILLE ALL
AUTRYVILLE
C
75
93.75
0'
34.6875
MAR-JUN
1645 I *
9A ALL
SB
25
100
0 1.1
110
APRSEP 15
1645 I*
9A 1AUTRYVILLE ALL
W 35
084
0 1.1
92.4
APR-SEP15
Page 2

1645 9A AUTRYVILLE ALL
75] 93.75
1645 1 * 9B
1645 '* 98
�1645 `• 9B
AUTRYVILLE ALL
AUTRYVILLE ALL
AUTRYVILLE ALL
I SB
W
C
251 100
35' 84
75 93.75
1.1
0I 0.55
0 0.55
0 0.55
103.125 MAR-JUN
55 APR-SEP 15
46.2 APR-SEP15
51.5625 MAR-JUN
TOTALS: 3751.06
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
Indicates a Crop Rotation
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirments. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of NC to have a nutrient management plan that addresses all
nutrients. This plan only addresses Nitrogen.
Page 3

TABLE 2 : ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land. See required specifications 2.)
TRACT FIELD
1643
I 1643
1643
1643
1643
1643
1643
1643
1A
1A
1B
1B
SOIL TYPE &CLASS- CROP YIELD LBS AW COMM ACRES LBS AW APPLIC.
DETERMINING PHASE CODE N/ACRE N/ACRE USED TIME
AUTRYVILLE ALL
,AUTRYVILLE ALL
AUTRYVILLE ALL
AUTRYVILLE ALL
SA
1
SG
SA
SG
1
1
1101 0 1.1
100
110
100
121 APR-JUL
0
1C
1C
AUTRYVILLE ALL
AUTRYVILLE ALL
SA
SG
1D
AUTRYVILLE ALL
1
110
100
1 110
1 D EAUTRYVILLE ALL SG 1 100
0�0
1.1
1.1
1.1
1.1
110
121
110
121
SEP-MAR
APR-JUL
SEP-MAR
APR-JUL
1.1
0 1.1
110 SEP-MAR
0 1.1
121 APR-JUL
110 SEP-MAR
TOTALS: 924
Indicates that this field is being overseeded (Le. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
* Acreage figures may exceed total acreage in field due to overseeding.
**Lbs AW N (animal waste nitrogen) equals total required nitrogen Tess any commercial
nitrogen (COMM N) supplied.
The following legend explains the crop codes used in TABLES 1 and 2 above:
CROP CODE CROP UNITS
C CORN BUSHELS
LBS N/UNIT
1.25
BH , HYBRID BERMUDAGRASS-HAY TONS 50
SG SMALL GRAIN OVERSEEDED
SB SOYBEANS
SA
SUMMER ANNUALS
lW f WHEAT
AC
50
BUSHELS
4
AC 110
_77;;` a p^7 FrTwr,^
APR 0 5 Z019
Water ag8'v'"J
Regional C3psrraucnsSection
Page 4

TRACT
1643
1643
1644
11644
TOTALS FROM TABLES 1 AND 2
ACRES LBS AW
N USED
(TABLE 1
TABLE 2
TOTALS:
15.94
4.4
20.34
3,751
924
4,675
AMOUNT OF N PRODUCED: 3,072
*** BALANCE -1,603
*** This number must be less than or equal to 0 in order to fully utilize the animal waste N
produced.
Acres show in each of the preceeding tables are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter
areas not receiving full application rates due to equipment limitations. Actual total acres in the
fields listed may, and most likely will be, more than the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of
sludge at agronomic rates. The sludge will be nurturient rich and will require precautionary
measures to prevent over application of nutrients or other elements. Your production facility
will produce approximately 486.4 pounds of plant available nitrogen (PAN) per year in the
sludge that will need to be removed on a periodic basis. This figure is PAN when
broadcasting the sludge. Please be aware that additional acres of land, as well special
equipment, may be needed when you remove this sludge.
See the attached map showing the fields to be used for the utilization of waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of
irrigation such that runoff or ponding occurs. This rate is limited by initial soil moisture
content, soil structure, soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of the
crop.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 5.92 months. In no instance should the volume of
waste being stored in your structure be within 1.63 feet of the top of the dike.
If surface irrigation is the method of [and application for this plan, it is the responsiblity of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application rates and amounts.
APPLICATION APPLICATION
CROP RATE (in/hr) ANIT (inches)
FIELD SOIL TYPE
-1A, -1B, --IC, -1D AUTRYVILLE ALL
-1A, -1B, -IC, -1D AUTRYVILLE ALL
SG 0.60 [ *1
SA 060
1B, -3A, -3B, -4A, -4B, -5, AUTRYVILLE ALL
1,6„,
2B, 3A, 3B, 4A, 4B, 5, 6, ' AUTRYVILLE ALL
SG
BH
0.60 ''11-1
0.60 *1
11645
OB, •11, *12, *13, •8A, *833, AUTRYVILLE ALL
W
1645
_1645
OB, *11, *12, *13, *SA, *8B, 4AUTRYVILLE ALL
08, *11, *12, *13, *8A, *8B, AUTRYVILLE ALL
SB
c
0.60
0.60
0.60
'1
*1�
'1
* This is the maximum application amount allowed for the soil assuming the amount of
nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Page 5

NARRATIVE OF OPERATION
This WUP has been written to reflect wettable acres with actual field measurements and the
pulls labeled to correspond with the map and WUP.
The 100 Ib option for overseeded small grain has been utilized with the following conditions:
(1) no animal waste may be applied to the bermuda grass after August 31, (2) the application
of PAN must be split and may be applied between September 15 and October 30 and in
February - March, and (3) the small grain must be harvested prior to April 7. If the
aforementioned conditions are not met, then the PAN rate for the small grain will be 50
lbs/acre with the application windows listed in Tables 1 &2.
This WUP was amended April 15, 2002 to reflect a C/W/SB rotation for Perry Smith who
purchased Long Haul Farm from Steve Draughon. Whatever crop follows the SB crop will
need to have 20 lbs of PAN deducted from the PAN rate for residual N from the soybean crop.
WUP amended 11-02-09 to reflect 50 Ib overseed. If grower elects to use 100 Ib overseed he
wiii have to folow application rule listed above with no pumping in November, December, and
January. Farm will have a Balance of -2016.06
Page 6

PLANS & SPECIFICATIONS
1 Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division of Water Quality for every
day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land to properly dispose of waste. If the producer
does not own adequate land to properly dispose of waste, he shall provide NRCS with a copy
of a written agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climate conditions, and level of
management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS) or
an Alternative Conservation System (ACS). if an ACS is used the soil Toss shall be no greater
than 10 tons per acre per year and appropriate filter strips will be used where runoff leaves
the field. These filter strips will be in addition to "Buffers" required by DEM. (See FOTG
Stantard 393 - Filter Strips and Standard 390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland, the
waste may be broadcast provided the application does not occur during a season prone to
flooding. (See "Weather and Climate in North Carolina" in the NRCS Technical Reference -
Environment file for guidance.)
*7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control conditions
conducive to odor or flies and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during_ rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of a crop on bare soil.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following_
the outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
Page 7

and from any perennial stream or river (other that an irrigation ditch or canal. Animal waste
other than swine waste from facilities sited on or after October 1, 1995), shall not be applied
closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal Waste shall not be applied closer than 200 feet of dwellings other than those
owned by the Iandownwer.
14. Waste shall be applied in a manner not to reach other property and public right - of ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted croplands
provided they have been approved as a land application site by a "technical specialist".
Animal waste should not be applied on grassed waterways that discharge directly into water
courses, except when applied at agronomic rates and the application causes no runoff or drift
from the site.
*16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
*17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon berms
and structures should be inspected regularly for evidence of erosion, leakage or discharge.
*18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the possibility
of an illegal discharge, pollution and erosion.
*19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied as a preemergence with no other applications of
animal waste during the crop season.
*21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume fpr waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soils shall be monitored and alternative crop sites
shall be used when these metals approach excessive levels. pH shall be adjusted for
optimum crop production amd maintained. Soil and waste analysis records shall be kept for
five (5) years. Poultry dry waste application records shall be maintained for three (3) years.
Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina Department of
Page 8

Agriculture regulations.
* Liquid Systems
Page 9

NAME OF FARM: Long Haul Farms
OWNER / MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications and the operation and
maintenance precedures estalished in the approved animal waste utilization plan for the farm
named above. I (we) know that any expansion to the existing design capacity of the waste
treatment and/or storage system or construction of new facilities will require a new utilization
plan and a new certification to be submitted to DEM before the new animals are stocked.
1 (we) understand that I must own or have acces to equipment, primarily irrigation equipment,
to land apply the animal waste described in this waste utilization plan. This equipment must
be available at the appropriate pumping time such that no discharge occurs from the lagoon
in a 25-year 1-day storm event. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY OWNER: Perry E. Smith, Jr.
SIGNATURE:
DATE:
NAME OF MANAGER (if different from owner):
please print
SIGNATURE: DATE:
NAME OF TECHNICAL SPECIALIST: Robert B. Mitchell Jr.
AFFILIATION: Private Technical Specialist
ADDRESS (AGENCY): 104 Adler Lane
Goldsboro, NC 27530
[phone]
SIGNATURE: A.i` 73, b'
DATE: 1 I - 2 -0 ci
Page 10

"egg /ANL 1*41
ifiencr /6 t3
1Fx.i-kh 1

Source
Farmstead
Swine Farm Waste Management Odor Control Checklist
Cause
• Swine production
BMPs to Minimize Odor
D Vegetative or wooded buffers;
D Recommended best management practices;
ErGood judgment and common sense
Site Specific Practices
Animal body; surfaces
• Dirty manure -covered animals
O Dry floors
Floor surfaces
• Wet manure -covered floors
-9—Slotted floors;
aerers located over slotted floors;
O Feeders at high end of solid floors;
D — crape manure buildup from floors;
O Underfloor ventilation for drying
Manure collection pits
• Urine;
• Partial microbial de©omposition
el -'"Frequent manure removal by flush, pit recharge,
or scrape;
.11--Underfloor ventilation
Ventilation exhaust fans • Volatile gases;
Dust
Er —Fan maintenance;
CV -Efficient air movement
Indoor surfaces
• Dust
laiWashdown between groups of animals;
0 Feed additives;
O Feeder covers;
o -1 eed delivery downspout extenders to feeder
covers
Flush tanks
Flush alleys
••' • Agitation of recycled lagoon
liquid while tanks are filling
• Agitation during wastewater
conveyance
D Flush tank covers;
D Extend fill lines to near bottom of tanks with
•anti -siphon vents
0 Underfloor flush with underfloor ventilation
Pit recharge points
• Agitation' of recycled lagoon
liquid while pits are filling
D Extend recharge lines to near bottom of pits
with anti -siphon vents
Lift stations
• Agitation during sump tank
filling and drawdown
D Sump tank covers
Outside drain collection
or junction boxes
• Agitation during wastewater
conveyance
D Box covers
AMOC - November 11, 1996, Page 3

Source Cause BMPs to Minimize Odor Site Specific Practices
End of drainpipes at
lagoon
• Agitation during wastewater
O Extend discharge point of pipes undemeath
conveyance lagoon liquid level
Lagoon surfaces
• Volatile gas emissions;
• Biological mixing;
• Agitation
'iroper lagoon liquid capacity;
Er -Correct lagoon startup procedures;
I i iinimum surface area -to -volume ratio;
O Minimum agitation when,pumping;
O Mechanical aeration;
O Proven biological additives
Irrigation sprinkler • High pressure agitation;
nozzles
• Wind drift
-0� Irrigate on dry days with little or no wind;
t3 Minimum recommended operating pressure;
OPump intake near lagoon liquid surface;
O Pump from second -stage lagoon
Storage tank or basin
surface
• Partial microbial decomposition; 0 Bottom or midlevel loading;
• Mixing while filling; 0 Tank covers;
• Agitation when emptying O Basin surface mats of solids;
1 0 Proven biological additives or oxidants
Settling basin surface • Partial microbial decomposition; O Extend drainpipe outlets underneath liquid
• Mixing while filling; level;
• Agitation when emptying 0 Remove settled solids regularly
Manure, slurry or sludge • Agitation when spreading;
spreader outlets : • Volatile gas emissions
1
O Soil injection of slurry/sludges;
O Wash residual manure from spreader after use;
O Proven biological additives or oxidants
Uncovered manure, ' • Volatile gas emissions while
slurry or sludge on field drying
surfaces
O Soil injection of slurry/sludges
O ' Soil incorporation within 48 hrs.;
O Spread in thin uniform layers for rapid drying;
O Proven biological additives or oxidants
Dead animals
• Carcass decomposition doper disposition of carcasses
Dead animal disposal • Carcass decomposition
pits _t
O Complete covering of carcasses in burial pits;
O Proper location/construction of disposal pits
Incinerators • Incomplete combustion
•
O Secondary stack burners
Mon( November 11, 1996, Page 4

7
11
Source Cause BMPs to Minimize. Odor Site Specific Practices
Standing water around • Improper drainage;
facilities
• Microbial decomposition of
organic matter
t d --Grade and landscape such that water drains
away from facilities
Manure tracked onto • Poorly maintained access roads Er Farm access road maintenance
public roads from farm
access
:1;
Additional information :
Swine Manure Management ; 0200 Rule/BMP Packet , ,
Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment ; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment ; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage ; EBAE 103-83
Calibration of Manure and Wastewater Application Equipment ; EBAE Fact Sheet
Controlling Odors from Swine Buildings ; PIH-33
Environmental Assurance Program ; NPPC Manual
Options for Managing Odor ; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies ; PRO107, 1995 Conference Proceedings
Available From :
NCSU, County Extension Center
NCSU-BAE
NCSU - BAE
NCSU - BAE
NCSU-BAE
NCSU'- BAE
NCSU - Swine Extension
NC Pork Producers Assoc
NCSU Agri Communications
Florida Cooperative Extension
AMOC - November 11, 1996, Page 5
l

Insect Control Checklist for Animal Operations
Source
Cause BMPs to Control Insects Site Specific Practices
Liquid Systems
Flush Gutters • Accumulation of solids 0 Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed.
0 Remove'bridging of accumulated solids at
discharge_
Lagoons and Pits • Crusted Solids , -21--1 aintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
Excessive Vegetative • Decaying vegetation aintain vegetative control along banks or
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
. along water's edge on impoundment's perimeter.
Dry Systems
Feeders • Feed Spillage 0 Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
accumulation of decaying wastage.
O Clean up spillage on a routine basis (e.g., 7. 10
day interval during summer; 15-30 day interval
Feed Storage • Accumulations of feed residues
during winter).
O Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
moisture grain products).
O Inspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AP'"^ 'ivember 11, 1996, Page l

r-
Source
Cause BMPs to Control Insects.
Animal Holding Areas • Accumulations of animal wastes D Eliminate low areas that trap moisture along
and feed wastage fences and other locations where waste
accumulates and disturbance by animals is
minimal.
0 Maintain fence rows and filter strips around
animal holding areas to minimize
accumulations of wastes (i.e., inspect for and
remove or break up accumulated solids as
needed).
Dry Manure Handling
Systems
• Accumulations of animal wastes
0 Remove spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
during winter) where manure is loaded for land
application or disposal.
O Provide for adequate drainage around manure
stockpiles.
O Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and
manure handling areas as needed.
Site Specific Practices
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State, University,
Raleigh, NC, 27695-7613.
AMIC - November 11, 1996, Page 2

Emergency Action Plan
This plan will be implemented in the event that wastes from you operations are leaking, overflowing,
or running off the site. You should NOT wait until wastes reach surface waters or leave your
property to consider that you have a problem. You should make very effort to ensure that this does
not happen. This plan should be available to all employees at the facility, as accidents, leaks, and
breaks can happen at any time.
1) Stop the release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to problems are listed below -
a) Lagoon overflow:
• add soil to the berm to increase the elevation of the dam
• pump wastes to fields at an acceptable rate
• stop all additional flow to the lagoon (waterers)
• call a pumping contractor
▪ make sure no surface water is entering the lagoon
Note: These activities should be started when your lagoon level has- exceeded the temporary
storage level.
b) Runoff from waste application field:
• immediately stop waste application
• create a temporary diversion or berm to contain the waste on the field
• incorporate waste to reduce further runoff
c) Leaking from the waste distribution system:
• pipes and sprinklers:
© stop recycle (flushing system) pump
• stop irrigation pump
© close valves to eliminate further discharge
® separate pipes to create an air gap and stop flow
Page 1

• flush system, houses, solids separators:
® stop recycle (flushing system) pump
® stop irrigation pump
© make sure no siphon effect has been created
® separate pipes to create an air gap and stop flow
d) Leakage from base or sidewall of the lagoon. Often these are seepage as opposed
to flowing leaks:
• dig a small well or ditch to catch all seepage, put in a submersible pump, and
pump back into the lagoon
• if holes are caused by burrowing animals, trap or remove animals and fill holes
and compact with a clay type soil.
• other holes may be likewise temporarily plugged with clay soil.
Note: For permanent repair measures, lagoon problems require the consultation of an individual
experienced in their design and installation.
2) Assess the extent of the spill and note any obvious damages.
a) Did the waste reach any surface waters?
b) Approximately how much was released and for what duration?
c) Any damage noted, such as employee injury, fish kills, or property damage?
3) Contact appropriate agencies.
a) During normal business hours, call your DWQ regional office: 910-395-3900; after hours,
emergency number: 800-858-0368 or 919-733-3942. Your phone call should include:
your name, facility, telephone number, the details of the incident, the exact location of the
facility, and the location or direction of movement of the spill, weather and wind
conditions, what corrective measures have been taken, and the seriousness of the
situation.
b) Your integrator: Goldsboro Hog Farms Division, Maxwell Foods, Inc.
919-778-3130 extension 1430
c) If the spill leaves the property or enters surface waters, call the local EMS:
910-296-2160
Page 2

d) Instruct EMS to contact the local Health Department: 910-296-2126.
e) (For technical assistance)
Contact CES: 910-296-2143
Local NRCS office: 910-296-2121
4) Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.
5) Contact contract pumping and/or irrigation equipment companies:
a)
b)
c)
6) Contact dirt moving and/or heavy equipment companies:
a) _
b)
c)
duplin
Page 3

�P-4730iY & IVL-kLVZ' 'NNCE PLAN
PZvpe:' lagoon liquid maaagemrnt should be a - - .� imnor^�t to a levels so � }'�---r.�und p�_ar_ty. It is y
wept _ you do not have problems during extend
rainy and.
Maximum =Tap
o ty should
b.e available in the lagoon }:oor vio whene
as vy- ttrtime for c--- n - PZtL7diw^� �� sty=Ic such as the tLti.i3 _ C3e:'nuC,a�:�s.S) or when ���
atthat �'•• �LiL s��TLS of plant Q--�tlll'Z on in the mummer -dine- 'j"�
a i � go in the lire,- ;�.� nt SLs u , -'l oin
eme t P should be donefD
x�^-�ve lagoon liouid. % � :�.� �h�eve: the �d is � mama to
{pericxiS. In the o __'wily l the moo available d w to helow et
PL 2-1) to allow for wing' storage_ vezy a own fire low
r the lagoon close to the �mn itauijievel as-longe should. be and ra
�II D� Win allow it the ►,rand "'
Waiting tmra the lagoon has e3 I s
'ten' does not leave roomrs maximum store arZ before s--
for st r g excess during
a.=d wet periods_
stale law e s the tomto r any
reason except 2-vea.;c%-o -storm oi� of
The routine - ► trance of a ice tot: rrvolv..4 L ±bflo ririn
zt
ai eailce of a {e:m:ve forthe
...,o of Co covertiL=�
covers. The ir�`?� bermada�~ �e the trio coiJYnQ e
eze o� should be _3 ry? each n ve "Y..
a v goro stand The amount t of ie^ `i-- i e si should
bases on a 'ltest but in -the event that it is -s cam_ _e I StfCTtll4�* be
a soils test each ve the lagoon ernb.' e� r_T+� ounc in oat
should be ;�.,*d-TY w � c�ia..+i� and s'+zi-:i3tInczlareas
2n4eni< "� QO potinc*s pe^ arm of I()-10-i0, or
3rLsh and trees on the ernbani4-tent must
done ay rnas��� s: =Yir� be C:o�?�ti�i This may be ► in, graz g caging, or a combjna; iOn of
tht. iris should be done at 1 once a yr and
h veg ,twimve that weather CoIItiI2FOIIS are .favorable
ui for
NOM If vt-r-.i
on is controlled by spraying- thensic?de
the unI�est nor be allow to— Such chemi~is could r-m t� e
loon
�m ZL'-R� sQnS of the eat r Q
the-lagoonnren and s I monthly and is oon should be made cu.--zg the initial iJ�g of
chi should include, and af.._ Major �rai and s^� L events I- r� to be -
as a minimum, the follows::
Wasre Inlet Pines, Recycling Pipes, and five=-=
separ on of ioints -2OW Pity look for.
c ac.1 or bre::-t
3- a=tunuladon of salts or i
A.
A2' S
ov iT condjLon of wives fa^.hl�4V�
APR 0-5 2019
Water ovetky

Lagoon sunIm--h oo for:
1. underaabie. ve„ Ye ,groar
floating or iodgj de its
.F.mbanknieIt look for
1- s: cement, ac a g, or "jug" holes
-- side slope s b iityshnuns or bulges
3. wet or thing atoms on the har+ slope
erosion due to lack of vemrion oral a result of wave action
PalenEdartaIe
Tzr-gerlaRoans may be sui,i to tiger -
damage caue to wave -action caused by Thy waves can crud.-- the moon sidewafls, there�a
A good c-:=; d of vegetation �� titer •
wave _ � will � thea,1€ia�a�4e Famed. by wa�asxio� If
sed a rubes ort causes sous damage to alagoon sidewU, hafec is theJag may be
waveimams_
Any of these features could %d to erosion and wig of th
any Or `�'��5.� t � dam If y(�ur'I��OGat has
aT f , you should mil an nuro na"te exxn f i iiEa r with and ..on of w� lagoons_ You may needto of a was:�e sc:�-�, However;pine a =``� �x if �� is a treat
a pal.- TTent solution should be reviewed by the
:iazic �_ Any ding � a aaoon rirrr
IIndei-,.�� ����� =io�� with heavy ars�mr is � s�iaus
_conse ueiit c and should not be ondg ,u j
._ endeby an ataro1ra 7 ex r_
` z n •r Pur ens-1c; i for riroo otaion of:
= r yciinC pumps
i sraion pis
C wl: for + , loose € ?
noiseii035r or a g anti ov rpump o on. An L menally loud of g
, ,-ram` amount of vibizzi , may lattice thrt the pump is in need or � or
NO'i : _ z g �s shots be in ect and �_= e ::
are not { :i '""` =� � P.Fioi�it S{? �cs you_
r i y si ne by �mmt fai You should
system -Rr=-� � yob
safety time should at a time when yotw lagoon is at its: low Level. 'Ibis
to about major � be Iea caving a_nearly full lagoon is not a cc IIe
o tb n ourz�, � , or borrowing �• Probably, ifyour1a ooa js snII,
s_ lagoon is tall also. You silo:•ie rs ae li 11 an
mventnry part= or of spare
Sur ace water di -,ion fmtarm are ficKivied to gamy :
4L-.4riage warm (stit as rainfall runoff, roof dr-an/age, gutter oaks,
and parking lot runoff) away from your lagoon and other waste
tzmunent in -sun -age The only water dr= shoulcLbe
coming f om yotm goon is t -Ar which comes yourfT hfr g
���g) system pipes and the rainfall t h* his the lagoon-Pv.
should ins= your diversion sys-=1 for the following:
1. aC -motion
diversion sty,
3. rd_e berm height

Practice wares conservation—minimizebuildingwater usage and
spillage from leafing warerers, broken pines and wasbdown through
proper maintenance and water conser anon_
Minimize feed warage and sainPcre by k=riing feeders adjusted. This
will reduce the amount of solids entering the lagoon
Manascwttprrr-
Maintain lagoon liquid level between the penman- storage level and
the full temporary storage level_
Place visible mans or stakes on the lagoon bank to show the
minimum liquid level and the maxi num liquid lever (Figure 2-1).
Start ini acing at die earliest possible bate in the spring based on
nutrient requirements and soil moisture so thrr temporary storage
will be maxir-,izw for die summer thunde worm s ason. Simi?�riy,
ith_ate in the lare summer/early fall to provide =a2timuni lagoon
storage for the wince,
The
lazoon iiauid level sizould never be closer
point of the danii of embankt-nenL 1 foot to the lflwew
!Do not Damp the lagoon liquid eel . level lower �:ar tie pm-manett st4icze
level unless you are removing sludge_ _
Locare float dui'n? inzates approately 18 inches underneath the linuid
sui:raie and 25 far away aom the drainpipe in e S as possible.
Prevent additions of bedding _fnPr- als, long-stemmed fo �e 0
:molded i2ed, pizsjc svrinsAother rz' �'__.,..,rsrt�
,..s, or iOI::,�,`.,1T TCt^.-re-:,1s jljt0 the ham_
• = requentiy remove solids from catch basins az end of conanement houses cs wherever they are nszlled_
- Maintain stud veaeradon, rodent, and varmint control near lagoon wits
Do not allow try or large bushes to grow on lagoon dam or embPrirm r-
Re;nove sludge from the lagoon either when the sludge storage catty is
full or before it :ills 50 _Decent of the p nanent storage volume.
If animal production is to be to to j. the owneris responsible for
Q°taining and immlerteadng a closure plan to eliminate the pos.sibiiLty of a pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup crrt bereduces by:

Proper lagoon sizing
• merfianical Solids s=ararion of flushed waste,
• gravity settling of flushed waste solids in an ampropriately der,;.gge basin, or
mini„-"ng age and spillage.
Lagoon sludge that is removed
annually rather than ssorev long te`rrt
have more nuaients, •
• have more odor, and
re uire more land to properly use the nutrients.
Removal tec hniaues:
Fire a =stain alit: tor.
• Mix the sludge and lagoon liquid with a chot r tatoi im e.
Dump through large -bore sprinkler
er irrigation system onto nearby c opim d;
and soil into/po_4e.
Dewater the upPer Dtr of boon by .i zigadon Onto nearby cropiantr tr
:or2gaiand; .'12:; nalaino- sludge: pump into Liquid sludge ran aac- haul
and spread onto cropland or forcge rr.d; and soil In^coroorare.
-Dewater the upper of lagoon pa. : lagoon by L' at--- or: onto s? crbY ioia..i2IIC: dredge SitiuQ�. ., �lpl= d or
ro rc..beside � ge e from lagoon with Li e oras D
`-'aoo,� ro recejve the sludge so ng " nei-.., k
into Door,;. allow Sludge to deviate-7 hail' �` liquids �A dry h
onto cropland or _or�ge:'aud-; I and � with m �;- _„�
, and soil .IIC'w3?pUia•:?_
Regardless of the method, you .n ss '
constzii:e�� ins: as you ; ave the siud�e �.�ateri� araivz� for ��
would your ulagoon wat:r. The sludge
nuthent zad metal values m ; to liquid. will sludcontage
to fields 1-4
flat ie byaz thesemauuh from
as well The avt,i cation of the si€t(fge fields rviii be
- as any Devious waste aDDliC -
iectrire.m=t_. Waste 3DDli OA will be ..cLtbIIs io that tZe.`£! and L'^JD
ISMS GLISCZossu, ith de '3 j lu Chaaix r 3.
When removing shidge, you
r o in purnDor drag -line o pay attention to the line to prevent Ci2M _g" Close
� o�..-aror will ensure thar the lagoon liner rep s
ink_ If you soh material or the synthetic Fine: mate lr being disturbed, you should
stQn the acthrity
j�.. y and not resume until you are stire the sludge en be
removed without liner injury_ Lithe lincris dart gci IL mus be repaired as soon as
possible.
Sludge removed from the lagoon has a much
than �Q�a-- Because of this it should higher �hOSpfiOiiS and_ heavy iile:2! content
and liaui levels, as in probably be applied to land with Iow phospti
Qica ej by a soil and in �+ t)f
erosion._ Note that if thesludge •Qe is ^ ��_' cOi �OF.'ai..�: to r�Iltw the C�'%il{:a of
aunijed to fields with very- high soil -test phosph©re, it:
should be ailed only at rams equal to the crop removal or Dhos-ohortts.As with other -
wastes, always have your lagoon sludge eyz. �� an�Ad far 0r its nuzrie;.t value_
The aapllc_,14on of sludge will increase the amount ofappiication
EXIIa r--odor at the �;.�-a;, 4
Ext 1 e..-udon should be used to observe the wind direczjon and other conditions which
could Iii.�."-': se the concern of neighbors.

Identified problems should be camera d promptly. It is advisable to inst t your syst:.�
during or immediately following a. heavy rain_ If te`ihnicxl assistance is needed to
cff..17.^nine'Draper solutions, consult with approoii De-css_
You should record the level of the lagoon just poor to when rain is predicrM, and then
record. the level. again 4 to 6 hours after the rain (assumes then is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall_ for this to work). Knowing this should heir III
plarming it ization appiicauons and stor-age. If your lagoon rs-s excessively, you may
have an inflow problem from a surface wad diversion or therze. may be s=age inm the
lagoon from the surrounding 12nd
Lagoon- Operation.
sue:
1_ immediately after constucdon establish a complete sod cover on bare soil
sues to avoid erosion_
Fill new lagoon d sigh tt eatrnent volume at ieasr half full of water before
waste loading bps, taking care not to erode lining or bank sloe
Dr =-mines into the i_soon should have a flexible pipe exurader on the
end of the pipe to discharge near the bottom of the lagoon dttriLT=nip+
Fain fin_ or another melns of slowing the incoming w'arr to avoid erosion of
the lining.
When possible, begin loading new lagoons Ln the spring „a:zbacterialto maxi
bacterial esrabikirrent (due to warmer w weather).
a
A :
5_ It is recommended that a new lagoon be see with sludge from a hd=i-by
woting swine lagoon. in the amount of 0.25 De: -Cent of the full lagoon
.icund voluii e. This suing should os our at _ea. t two weeks pnoi to the
addition of wastewat
6. Maintain a periodic chi on the lagoon licuid pz. If the pH tali
i . 0, add S below
culturzj Jime at the IBre of i pound per 1000 cubic fee of
loon liquid volume until the p$ rises above 7.0. Optimum lagoon Iiauid_
DE: is between 7.5 and 8.0_
A dark color; lack. of bubbling, and excessive odor signals -a
aioiagical activity. Consultation with a �111 .' ! e,,_" st is recommended
if these conditions occ it for prolonged periods. esoeiaiiy during the wai
season_
Loading:
The more ft eau; atly and regularly that wastewat is adder to a lagoon, the bet the
lagoon will funcdon_ Flush systems that wash worst into the is oon several times daily are
optimum for treatment. Pit re._uarge systems, itt which one or more buildings
and reuazge_d �;i day, are drained
� also work well

3/20/2019
256 Glacces Manning Lane Warsaw NC - Goggle Maps
Go gle Maps 256 Glacces Manning Lane Warsaw NC
Imagery ©2019 Google, Map data ©2019 Google
1000 ft
hitpsJ/www.gswg!e.com/maps/sPa ch/256+GIacces+Manning+Lane+Warsaw+NC/@34.9789832,-78.1.04673,225f m/data=!3m1!1e3 111

)perator:Steve Draughon
County: Duplin
U+stance=
L.
IIE are
66.,e
Date:
11/14/95
residenceff` (other than owner) 800. 0 feet - �
AVERAGE LIVE WEIGHT (ALW)
O sows (farrow to finish) x 1417 lbs. =
O sows (farrow to feeder) x 522 lbs. _
O head (finishing only) x 135 lbs. =
O sows (farrow to wean) x 433 lbs. =
3200 head (wean to feeder) x 30 lbs. _
Describe other e
Total Average Live Weight =
MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 96000 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb. ALW
Volume = 96000 cubic feet
O lbs
O lbs
O lbs
0 lbs
96000 lbs
0
96000 lbs
STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0. 0 cubic feet if OWNER REquE'r5 NO 5[. U6 5regAbE,
SwvG W+`(. 8E 'REMOVED AS N W p "
-j!OTAL DESIGNED VOLUME
Inside top length (feet
Inside top width (feet)
Top of dike elevation (feet)
Bottom of lagoon elevation (feet)
Freeboard (feet)
Side slopes (inside lagoon)
Total design_volume using prismoidal
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2
3.0 3.0 3.0 3.0
AREA OF TOP
LENGTH * WIDTH =
164.0 144.0
AREA OF BOTTOM
LENGTH * WIDTH =
104.0 84.0
AREA OF MIDSECTION
LENGTH * WIDTH * 4
134.0 114.0
CU. FT. = [AREA TOP +
23616.0
formula
170.0
150.0
48.2
37.2
1.0
3.0 : 1
LENGTH WIDTH DEPTH
164.0 144.0 10.0
23616 (AREA OF TOP)
8736 (AREA OF BOTTOM)
61104 (AREA OF MIDSECTION * 4)
* DEPTH/6
1.7
Total Designed Volume Available = 155760 CU. FT.
(4*AREA MIDSECTION) + AREA BOTTOM]
61104.0 8736.0

J•
TEMPORARY STORAGE REQUIRED
Drainage Area:
Lagoon (top of dike)
Length X Width =
170 145 24650 Square Feet
Buildings (roof and lot water)
Length X Width =
0 0 0 Square Feet
TOTAL DA 24650 Square Feet
===> Design temporary storage to be 180 days.
A. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume =
Volume =
96000 Lbs. SSLW X CF of waste/lb/day X
23501 Cubic feet
B. Volume of wash water
180
This is the amount of fresh water used for washing floors or
volume of fresh water used for a flush system. Flush systems
that recirculate the lagoon water are accounted for in 5A.
_Volume = 0 Gallonslday X 180 days storage/7.48
gallons per CF
Volume = 0 Cubic feet
C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by
largest amount.
180 days excess rainfall
Volume = 7.0 Inches X DA / 12 inches per foot
Volume = 14379.167 Cubic feet
D. Volume of 25 year — 24 hour storm
Volume = 7.5 inches / 12 inches per foot X DA
Volume = 15406 Cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 23501 Cubic feet
5B. 0 Cubic feet
5C. 14379 Cubic feet
5D. 15406 Cubic feet
7.0 inches
TOTAL 53286 Cubic feet

6. SUMMARY
Total required volume = 145E:86 Cubic feet
Total design volume avail.= 156739 Cubic feet
Min. regrd. trtmnt. vol. plus sludge accum.= 96000 Cu. Ft.
At elev.
41.00 Ft; Vol= 96208 Cubic feet (end pumping)
Total design volume less 25yr-24hr storm = 141333 Cu. Ft.
At elev. 43.30 Ft; Vol= 141223 Cubic feet (start pumping)
Seasonal high water table elevation is 39.00 Feet,.which must
be lower than the elevation of top of treatment volume 41.00
DESIGNED' BY:
84/1s,X, ()sc. r
DATE: / 1 i - 95
.APP'ROVED BY:
ivl �S� �
DATE: 2'1 L )
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
ADDITIONAL NOTES:

Operator:Steve Draughon County: Poplin
iLlazx
Date: 01/19/93
— Distance to nearest 'residence (other than owner) : lij00 feet
1. STEADY STATE LIVE WEIGHT
O Sows (farrow to finish) X 1417 lbs. = _0
O Sows (farrow to. feeder) X 522 lbs. = 0
O Head (finishing only) X 135 lbs. = 0
0 Sows (farrow to wean) X 433 lbs. = 0
3200 Head (wean to feeder) X 30 lbs. = 96000
TOTAL STEADY STATE LIVE WEIGHT (SSLW) = 96000
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 96000 lbs. SSLW X Treatment Volume CF/lb. SSLW
Treatment Volume CF/lb. SSLW= 1.0 CF/lb. SSLW
Volume = 96000 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0 cubic feet
4. TOTAL DESIGN VOLUME
(NOT COMPUTED AT)
(LANDOWNER REQUEST)
(Sludge Removed As Needed)
,d .-----
Inside top: length 170 feet ; width 145 feet
Top of dike at elevation ,/ 45.00 feet
Freeboard 1.0 feetV .Side slopes 3.0:1 (inside)
Total design lagoon liquidilevel at elevation 44.00 feet
Bottom of lagoon at elevation 33.00 feet
Seasonal high water table elevation 39.00 feet
Total design volume using prismoidal formula:
SS/END1 SS/END2 SS/SIDE1 SS/END2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 164.0 139.0 11.00
AREA OF TOP
LENGTH X WIDTH
164 139 22796 (Area of Top)
AREA OF BOTTOM
LENGTH X WIDTH =
98 73 7154 (Area of Bottom)
AREA OF MIDSECTION
LENGTH X WIDTH X 4
131 106
55544 (Area of Midsection X 4)
CU. FT. = [Area top+(4XArea Midsection)+Area Bottom] X Depth/6
22796 55544 7154
VOL. OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 156739 CU. FT.

Da
Volume of 25 year - 24 hour storm
Volume = 7.5 inches / 12 inches per foot
Volume = 15937.5 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 23444 cubic feet
5B. O cubic feet
5C. 14875 cubic feet
5D. 15938 cubic feet
TOTAL 54256 cubic feet
SUMMARY
Temporary storage period >
Rainfall in excess of evaporation
25 year - 24 hour rainfall >
Freeboard
Side slopes >
Inside top length >-
Inside top width
Top of dike elevation >
Bottom of lagoon elevation
Total required volume
Actual design volume >
Seasonal high watertable elevation (SHWT)===>
Stop pumping elev. >
Must be > or = to the SHWT elev. >
Must be > 9r = to min. req. treatment el.=>
Required minimum treatment volume _ >
Volume at stop pumping elevation >
Start pumping elev. >
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall==> 139823
Volume at start pumping elevation > 137452
Required volume to be pumped > 38319
-Actual volume planned -to -be -pumped > 40836
Min._thickness of soil liner when required- i 1.6
* DA
BY:
GE©' +ETiU�i i GNF, t i •
DATE : i �{
180
7.0
7.5
1.0
3.0
170.0
150.0
48.2
37.2
150256
155760
42.8
44.4
42.8
43.2
96000
96616
46.4
days
inches
inches
feet ✓
1
feet
feet
feet
feet
cu. ft.
cu. ft. *
feet
feet
feet
feet
cu. ft.
cu. ft.
feet *
cu. ft.
cu. ft.
cu. ft.
cu ft.
feet--
Gn../i 4T,^j 40 `a'7r0/N
DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
IzJfz.Jr5
COMMENTS:

TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
170.0 150.0 25500.0 square feet
Buildings (roof and lot water)
0.0 square feet
TOTAL DA 25500.0 square feet
Design temporary storage period to be
Volume of waste produced
Feces & urine production in gal./day per
Volume = 96000 lbs. ALW/135 lbs. ALW *
Volume = 175360 gals. or 23443.9 cubic
3•. Volume of wash water
Describe this area.
180 days.
135 lb. ALW 1.37
1.37 gal/day 180 days
feet
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume =
0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall
Volume = 7.0 in * DA / 12 inches per foot
Volume = 14875.0 cubic feet
7.0 inches